2023 Ford F-150

Defect. Ford Motor Company (Ford) is recalling certain 2023-2027 F-150 vehicles. The fuel tank may be improperly secured and leak fuel, or detach from the vehicle while driving.

Risk. A detached tank can create a road hazard, increasing the risk of a crash. In addition, a fuel leak can cause an engine stall or increase the risk of a fire.

Remedy. Dealers will inspect and replace the fuel tank straps, as necessary, free of charge. Owner notification letters were mailed September 21, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S69. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 14, 2026.

Defect. Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Risk. An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

Remedy. The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed October 9, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.

Defect. Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

Risk. Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.

Remedy. The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.

Defect. Ford Motor Company (Ford) is recalling certain 2021-2022 Expedition, Lincoln Navigator, 2021-2023 F-150, 2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The moonroof wind deflector clips may be inadequately attached to the moonroof frame, which can result in the wind deflector detaching from the vehicle.

Risk. A detached wind deflector can become a road hazard and increase the risk of a crash.

Remedy. Dealers will inspect and repair the moonroof wind deflector as necessary, free of charge. Owner notification letters were mailed November 10, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB7. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 30, 2025.

Defect. Ford Motor Company (Ford) is recalling certain 2023-2025 F-150 vehicles equipped with the Trailer Tow Max Duty package and a 9.75-inch heavy duty axle with a 3/4 float axle design. The rear axle hub bolt may fatigue and break, which can result in damage to the axle hub splines.

Risk. Damaged axle hub splines can result in a vehicle rollaway when in park without the parking brake applied or cause a loss of drive power. Either of these conditions can increase the risk of a crash.

Remedy. Dealers will replace the left and right rear axle shaft assemblies, free of charge. This is a phased recall. Ford owners will receive letters in multiple phases, beginning August 2025 through Winter 2025. Phase 1 will include 2023 F-150 model year vehicles. Phase 2 will include 2025 F-150 model year vehicles and Phase 3 will include 2024 F-150 model year vehicles. Interim owner notification letters informing owners of the safety risk were mailed August 22, 2025. Owner notification letters were mailed August 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S82. This recall expands previous NHTSA recall number 23V896.

Defect. Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.

Risk. A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy. The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.

Defect. Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk. Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

Remedy. Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

Defect. Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 vehicles equipped with the Trailer Tow Max Duty package and a 9.75-inch heavy duty axle with a 3/4 float axle design. The rear axle hub bolt may fatigue and break, which can result in damage to the axle hub splines.

Risk. Damaged axle hub splines can result in a vehicle rollaway when the vehicle is in park without the parking brake applied or cause a loss of drive power. Both of these conditions can increase the risk of a crash.

Remedy. Dealers will replace the left and right rear axle shaft assemblies, free of charge. Owner notification letters were mailed on May 9, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S65.

Defect. Ford Motor Company (Ford) is recalling certain 2023 F-150 and Ford SD F250, F350, F450, F550, and F600 vehicles. The steering wheel clock spring may have an insufficient weld, causing a loss of electrical connection to the driver's frontal air bag.

Risk. A deactivated air bag will not deploy during a crash, increasing the risk of injury.

Remedy. Dealers will inspect and replace the clock spring as necessary, free of charge. Owner notification letters were mailed on May 3, 2024. Owners may contact Ford customer service at 1-866-436-7332.

Defect. Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 vehicles equipped with a single exhaust system. Contact with the rear axle housing may damage the wiring harness, causing the electric parking brake to activate unexpectedly.

Risk. Unexpected activation of the electric parking brake while driving increases the risk of a crash.

Remedy. Dealers will install a protective tie strap, tape wrap, and replace the harness as necessary, free of charge. Owner notification letters were mailed February 12, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S35.

Defect. Ford Motor Company (Ford) is recalling certain 2023 F-150, Expedition, and Lincoln Navigator vehicles. The front axle pinion may not have been heat-treated, which can cause it to fracture.

Risk. A fractured pinion can result in a loss of 4-wheel drive and may cause the front wheels to lock up, increasng the risk of a crash.

Remedy. Dealers will replace the front axle pinion gear set. If there is a broken front axle pinion, the entire axle assembly will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed April 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S07.

Defect. Ford Motor Company (Ford) is recalling certain 2023 F-150 vehicles. The instrument panel top cover on the passenger-side may prevent the air bag from deploying as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk. An air bag that does not deploy as intended increases the risk of injury in a crash.

Remedy. Dealers will replace the passenger instrument panel top cover, free of charge. Owner notification letters were mailed March 16, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C01.

Defect. Ford Motor Company (Ford) is recalling certain 2022-2023 F-150, Mustang, Explorer, Bronco, and 2023 Lincoln Aviator vehicles equipped with automatic transmissions. The transmission may contain a loose bolt which could prevent the transmission from engaging the park gear, although the gear shifter position may indicate that the vehicle has been shifted to "PARK."

Risk. The inability to secure the vehicle in the park position can result in a rollaway, increasing the risk of a crash or injury.

Remedy. Dealers will inspect and, if necessary, replace the transmissions, free of charge. Owner notification letters were mailed April 25, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S06.

Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: * Harsh 3-4, 4-5 upshifts * Harsh 5-3, 4-3 downshifts * Harsh reverse engagements These symptoms may be worse when cold. This may be due to the F clutch friction plates brinelling into the clutch and planetary container cylinder (7B177).

Customer Satisfaction Program 24N04 – Supplement #1 Certain 2021-2023 Model Year F-150 HEV and 2022-2023 Model Year Maverick HEV Vehicles Replacement of Exhaust Gas Heat Recovery System If Failed

Customer Satisfaction Program 23B24 Certain 2022 Super Duty and 2023 F-Series Models with Tailgate Step - Inspection of Tailgate Step Handle and Replacement

This bulletin supersedes 26-2309. Reason For Update: update the Model section to remove Aviator 10R80, update the Parts list to add 3.3L to W520514-S440, and add L1MZ-7Z490-G valve body separator plate for Aviator. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: * Harsh 3-4, 4-5 upshifts * Harsh …

This bulletin supersedes 26-2066. Reason for update: To remove "(2024 only)" from the Issue statement to include 2021-2025 vehicles that may exhibit a clicking sound coming from the gear shift lever. Some of the vehicles listed in the Model statement above equipped with a console GSM may exhibit at least one of the following conditions: * Clicking sound …

This bulletin supersedes 26-2241. Reason For Update: update the parts list to correct the claim quantity of the part number JB3Z-4B496-B from 3 to 6. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: * Harsh 3-4, 4-5 upshifts * Harsh 5-3, 4-3 downshifts * Harsh reverse engagements These symptoms …

This bulletin supersedes 25-2383. Reason for update: to add 2023-2026 F-150 2.7L vehicles. Some of the vehicles listed in the Model Statement may exhibit a vibration/shudder felt during light throttle tip in at highway speeds (8,9,10 gear) with no diagnostic trouble codes (DTC) present. This may be due to various software parameters in the powertrain …

This article supersedes 25-2302. Reason for update: update the labor time allowance for F-150 vehicles, update the Parts list to replace the part number W716979-S439 with W721084-S439, and add a note for LV fluids XT-10-QLVC and CXT-10-LV6 "Transfer Case Fluid". Some of the vehicles listed in the Model statement above may exhibit at least one of the …

This bulletin supersedes 25-2587. Reason For Update: update the Parts list to add the F-clutch friction plates HL3Z-7B164-D and the F-clutch steel plates PR3Z-7B164-A for the proper vehicle lines, replace the transfer case mounting bolt part number from W714288-S438 to W714288-S437, update the part number W720688-S439 quantity from 2 to 1, update the part …

BACKUP CAMERA IS BLURRY AND HARD TO MAKE OUT WHAT IS BEHIND VEHICLE

While using adaptive cruise control in stop-and-go traffic on the Brooklyn Bridge, my 2023 Ford F-150 repeatedly loses track of the vehicle directly ahead and accelerates toward its set speed despite stopped traffic in front of me, requiring me to brake manually to avoid a collision. This happens every time I cross the bridge in traffic, most recently on October 26, 2026, at about 7:33 PM, at 37,293 miles.

Spring of 2025 shortly after buying this truck I took it to Ford dealer to have theinspection for the axle bolts. They reported they were ok and closed the recall. On 10/5/2026 I took my truck to an independant mechanic for a leaking right rear axle seal. When he pulled the wheel off the axle bolt head fell to the ground. When he called me to let me know what was going on I told him about the recall and to wait untilI contacted Ford. When I called ford dealer who did the inspection they told me it was closed and no further action due by them. That I would be responsible for the repairs. They said they could not sell me new axles because they were kept for vehicles fixed under the recall. So, ai has my mechanic replace the sea, hub and bolt. A week later the seal failed again. I do not know if the bolt broke again or not I haven't had it to the garage yet. I have contacted customer service at Ford they refused to let me talk to someone higher up and hung up on me. I am currently driving the truck it is my main transportation. I contacted the social media group at Ford also they just gave me the run around and same answer - "the recall is closed and no further action required". My opinion Ford knows it is a costly design problem in that the bolt is insufficient for the load and they do not want to pay for the repairs.

Trace water accumulation routing from clogged/faulty drain plug to corroded DCN wiring connector during rainfall. Due to manufacturing design of '23 Ford F150 model windshield drain cowls, minor debris allowed for water to backflow into the Data Communication Network (DCN) wiring harness and Body Control Module (BCM) connectors, interior electrical components, and interior of the cab wetting the upholstery and flooring within the front passenger side of truck. Driver experienced electrical black outs within the dash and center screens, lighting failures, and multiple system alert misfires while driving the vehicle. Alerts consistently glitching on the dash screen included: Service Vehicle Soon, Pre-Collision Assist Not Available, Service Advance Trac, Rear Belt Monitor Fault Service Required. The issues were reported to Ford, whose representatives noted the history behind water damages associated with cowl/drain designs, but confirmed the issue has not been formalized for recall. This known issue presents buyers with financial and physical safety risks, known by Ford, and places full responsibility for poor engineering on new owners. The vehicle is currently at the dealership for repairs and parts replacement. All at the owners expense.

Ford recall #25SB7 notice from dealer. Took it in since my moonroof has the exact problem mentioned in the recall notice. For some reason, my truck has no recall notice.

Picking up the carseat out of the car, the handle became detached on one side which caused the seat to drop to the ground with child inside.

Due to cracking in the body seam towards the roof on the A-pillar on the drivers side. During moderate to heavy rain water enters the cab of the truck and soaks the floorboard and thus soaks electrical components underneath said floor board. Ford motor company refuses to fix it under warranty and I fear it could cause issues with my windshield or electric components in the pillar or floorboard and cause a wreck or in jeopardize my safety in other manners. If you look online it has been documented multiple times and yet ford still refuses to fix it under warranty. I discovered the issue after a rain storm last week when I opened my door to approximately a 3 inch puddle in my floor board, and the vehicle is just outside of fords “factory warranty” which when I talked to ford customer service they said I would be out of pocket on it still as they wouldn’t cover it.

The vehicle is experiencing an immediate, uncorrected mechanical steering safety defect where the internal steering geometry physically slips out of specification while driving at highway speeds. During a comprehensive diagnostic tear-down by an authorized manufacturer technician at Porter Ford on September 24–30, 2026 (RO #56117630), a structural component hardware failure was verified and documented in writing. The master technician explicitly noted that the 'steer head alignment was slipping out of spec' and that the root cause was a defective 'worm gear stake causing steer head slip.' Despite three consecutive dealership service alignment attempts, the internal steering mechanism continues to slip while the vehicle is in motion. This causes the vehicle to tracking-drift unpredictably on the highway and alters the steering wheel center position, creating an immediate loss-of-control crash hazard. The manufacturer has been unable to correct this structural failure

2023 F150 28K miles. No warnings. Continious issues with Severe transmission shifting, loud clunk and jerking/whiplash and failure to engage when first put into gear. Shudder at times around 55 mph, reared backlash issue identified but within tolerance per dealership. transmission was rebuilt resulting in more sever shifting at high speeds 10-9-8 and 3-2-1 down shifting.

Rear axle half shaft and hub replacement assembly (Manufacturer Recall Number 25S82 NHTSA Recall Number25V512). Neither Ford nor the local dealership seem to care about repairing this issue in a timely manner. The truck was inspected soon after the recall was received. The dealer confirmed that my truck fell under the recall. They supposedly placed an order for parts at that time (October 2025). A year later the repair has not been completed. I have contacted Ford Customer Service twice about the parts availability issue. Ford states the parts are available. The dealership states the parts are not available. According to the NTSB, recall repairs should happen in a timely manner. If they don't, NTSB suggests filing a complaint. I believe more than a year of waiting, with noting done, has given both Ford and the dealership ample time for repairs to be completed. This is an official complaint regarding the lack of expediency by both Ford and the local dealership.

THE REAR BRAKE LIGHT LED FAILED AND FORD REFUSED TO COVER UNDER THEIR 4/48000 BUMPER TO BUMPER WARRANTY, THERE IS NO DAMAGE TO THE LIGHT ASSEMBLY AND THE FAILURE IS GOING TO COST $1700 TO CORRECT. FOR A LIGHT BULB(LED SO NO BULB) ISSUE, THIS IS FRAUD FROM FORD NOT HONORING COVERAGES AND FOR NOT SELLING A VEHICLE WITH NON SERVICABLE PARTS FOR COMMON FAILURE POINTS

I am reporting a safety-related transmission problem I experienced with my 2023 Ford F-150 equipped with the 10R80 automatic transmission. While driving normally, the transmission suddenly shifts violently, lurches from P to D, delayed shifting. This occurred while while driving under normal conditions creating a potentially dangerous situation because the truck did not respond as expected when I needed predictable acceleration or propulsion. I believe this incident may be related to the known 10R80 CDF clutch-cylinder/sleeve problem. Ford technical information identifies axial movement of the CDF sleeve that can cause hydraulic-circuit leaks and harsh or delayed engagement and shifting. This condition can result in slipping, RPM flares, delayed engagement, unexpected gear changes, harsh downshifts, lurching, or loss of propulsion. This is a safety concern, not merely a transmission quality or reliability issue. Unexpected loss of propulsion or unpredictable shifting while merging, accelerating into traffic, crossing an intersection, turning, or traveling at highway speed can create a collision hazard. Because I personally experienced this unexpected transmission event, I request that NHTSA investigate the 10R80 CDF clutch-cylinder/sleeve condition in Ford F-150s. Please review Ford warranty claims, dealer repair records, transmission replacements, consumer complaints, and field-failure data to determine whether this is a safety defect requiring a recall. I believe owners sho

This is related to obtaining a timely repair for the following recall: Manufacturer Recall Number25S82 NHTSA Recall Number25V512 Ford lacks the parts to address the recall. My recall was confirmed by the dealer, photos taken and an order placed with Ford over one year ago, after trying to have the recall addressed at another dealer. The recall was issued on May 24, 2024 and all parts are still on backorder. This is a safety concern. I get notified weekly that my vehicle needs the repairs yet none of the dealers around me have parts.

I am reporting a safety-related transmission problem I experienced with my 2023 Ford F-150 equipped with the 10R80 automatic transmission. While driving normally, the transmission suddenly lost the selected gear and rims spiked and then it violently slammed into gear. It feels like it thru my truck into a limp mode. It lost 5th would not catch it going up and down thru the gears. It happened randomly. This occurred while while accelerating to merge on the highway. It also kept going it in stop and go traffic on the interstate, creating a potentially dangerous situation because the truck did not respond as expected when I needed predictable acceleration or propulsion. I believe this incident may be related to the known 10R80 CDF clutch-cylinder/sleeve problem. Ford technical information identifies axial movement of the CDF sleeve that can cause hydraulic-circuit leaks and loss of gears causing no propulsion and possibly causing a tragedy

The contact owns a 2023 Ford F-150. The contact stated that while driving in a rainstorm, rainwater leaked into the vehicle from the front driver’s side windshield seal onto the dashboard. The contact was concerned that the water might eventually cause electrical failures inside the dashboard. The cause of the failure was not yet determined. The local dealer was notified of the failure, and an appointment was scheduled. The failure mileage was 31,000.

The contact owns a 2023 Ford F-150. The contact stated that while driving at an undisclosed speed and activating the passenger’s side turn signal, the turn signal lever started to stick. The contact researched online and located similar failures. The contact stated that the dealer was four hours away and was not notified of the failure. The failure mileage was approximately 55,000.

While driving the button to engage shift gear came off causing me to not be able to switch gears to put vehicle in park. It fell off while driving

Pirelli Tires on F150 prematurely cracking & failing w/only 16,700 miles on the tire. Tread barely has any wear. On Saturday evening XXX Left rear tire wall blew out & PSI on tire went from 35 to 0 in less than 1 second. Upon closer inspection, all tires have premature cracks in the walls & the concern is that they could also fail and explode at any moment. We were not traveling at a high speed when the rear tire wall failed, but things could have been very different if we had been a highway - without doubt a major accident would have occurred. Brought the truck immediately to Coggins Deland Ford on [XXX] on Monday morning XXX where I purchased F150 brand new about 30 months ago, there is only about 16,700 miles on the truck. I am well within the tire warranty that Ford offers for the tires & well within bumper to bumper. All 4 tires should be replaced per the Ford tire warranty as they show signs of defect. The dealer has only approved the replacement of the tire that blew out so far & instructed me to contact the tire manufacture about the other tires that are cracking at 16K miles - I contacted Pirelli and was told since the dealer is giving me a hard time, Pirelli provided me with a case number and told me to tell the dealership to file a claim which they already know to do. Ford should provide the tire warranty on the tires per their own policy that is clearly stated on [XXX]. The dealer at first tired to tell me the tire only has warranty for 12,000 but it is not true,

The contact owns a 2023 Ford F-150. The contact stated that while attempting to park the vehicle, the gear shifter was sticking. The contact stated that the failure reoccurred. The contact stated that while the vehicle was parked, the gear shifter was shifted into park; however, the shifter gear independently shifted into reverse. The vehicle crashed into the garage at the residence. The contact stated that the failure had occurred after the vehicle was reversed to attach the trailer to the vehicle. The contact was almost struck by the vehicle. The dealer was not made aware of the failure. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 20,000.

As I was stopping at an intersection for a redlight, the brakes locked up and the collision assist warning and another message came up on the screen. There were no cars in front of me at the intersection. This is the first time that this has ever happened and the truck has 32,665 miles. No servicing has been performed on this truck beyond oil changes and tire rotations.

While driving at speed, my vehicle experienced a severe safety hazard: the transmission jerked violently and the engine completely stalled on the road, causing an immediate loss of power. The dealership diagnosed the truck and stated that tree debris had plugged the cowl drains at the base of the windshield. Because the drains plugged, rainwater backed up and overflowed directly into the passenger cabin, soaking the Body Control Module (BCM) and crashing the central computer network. A vehicle's central computer network should not be engineered in a way that normal outdoor tree debris can completely flood an interior cabin module and cause a dangerous drivetrain shutdown while driving.

Passenger side vertical LED drivers running light bar is out on 2023 Ford F-150 XLT Supercrew. Have heard and seen many Ford F150 trucks that have had this issue. Faulty LED diod heats and burns the light tube from which the light is generated. THIS IS A VERY COMMON ISSUE, IS A MANUFACTURERS DEFECTIVE PART THAT MUST BE RECALLED AND REPLACED.

The contact owns a 2023 Ford F-150. The contact stated that while reversing, the brake pedal was depressed; however, the vehicle failed to stop as intended. The contact stated that the brake pedal was depressed to the floorboard and the brake system malfunction message displayed. The contact stated that the vehicle drove onto a hilly grass embankment before coming to a complete stop. The contact stated that the failure had occurred while loading the vehicle with motorcycles for an event. The vehicle was towed to the dealer, but a diagnostic test was not performed. The manufacturer was not made aware of the failure. The failure mileage was approximately 46,500.

I am reporting a safety-related transmission problem I experienced with my 2023 Ford F-150 equipped with the 10R80 automatic transmission. While driving normally, the transmission suddenly lost power and was totally unresponsive. It slammed into gear and went back to normal operation. The transmission has been reset by the dealership several times and I'm told it's normal operation for it to slam into gear on the upshift and downshift. There are no lights or warnings. This occurred while I was crossing rail road tracks creating a potentially dangerous situation because the truck did not respond as expected when I needed predictable acceleration or propulsion. I believe this incident may be related to the known 10R80 CDF clutch-cylinder/sleeve problem. Ford technical information identifies axial movement of the CDF sleeve that can cause hydraulic-circuit leaks and harsh or delayed engagement and shifting. This condition can result in slipping, RPM flares, delayed engagement, unexpected gear changes, harsh downshifts, lurching, or loss of propulsion. This is a safety concern, not merely a transmission quality or reliability issue. Unexpected loss of propulsion or unpredictable shifting while merging, accelerating into traffic, crossing an intersection, turning, or traveling at highway speed can create a collision hazard. Because I personally experienced this unexpected transmission event, I request that NHTSA investigate the 10R80 CDF clutch-cylinder/sleeve condition in Ford F-

While towing a 6000 pound travel trailer 6/21/26, the brakes on the trailer failed. A trailer wiring fault message came up on the dash each time I braked. It is available for inspection. How was our safety put at risk??? Stopping distance was increased substantually. When you need to stop, you need to stop! The truck has been brought to the dealer 4 times prior to this for the same problem. One of those times was for the recall on the trailer brake, May of 2026. The first time the truck was taken to the dealer for the warning message was April of 2025. The trailer was taken to the RV dealer after the incident (on my Oct 2025 visit, the dealer told me the problem was with the trailer. I wanted to rule that out). The RV dealer found no problem with the trailer brakes, and determined the problem is with the truck. The truck was then taken to the dealer July 23 with "Trailer Brake Module Fault" message every time it is started. It remains at the dealer now. They believe it is the trailer brake control module. The module is on backorder with no estimated time for repair.

275/50 R22 I was driving on a major interstate approximately 65 mph when a strong vibration was felt. As I started to move to the shoulder and slow down, the tread detached from the tire. The tire remained on the vehicle but the tread delaminated and was in the middle of the highway. This caused significant (>$11k) damages to the truck. I sent the tire to Continental and they declined taking liability for the tire failure. However, this happened to another owner a week or two after my issue and they had the same tire with only 30k miles. Additionally, there is already a recall on the same type of tire (different size) from last year due to tire delamination. This is a serious safety issue that could result in fatalities.

Delayed/unexpected transmission gear changes. The transmission delays downshifts at slow speeds causing the vehicle to not accelerate when acceleration is needed. This causes a huge safety issue when maneuvering in traffic (for example). Please help me with a solution to this.

I am reporting a safety-related transmission problem I experienced with my 2023 Ford F-150 equipped with the 10R80 automatic transmission. While driving normally, the transmission has suddenly lost propulsion, jerked, and hard down shifted impacting braking. This occurred while trying to merge onto freeways and making turns into lanes containing traffic, creating a potentially dangerous situation because the truck did not respond as expected when I needed predictable acceleration or propulsion. I believe this incident may be related to the known 10R80 CDF clutch-cylinder/sleeve problem. Ford technical information identifies axial movement of the CDF sleeve that can cause hydraulic-circuits. I've also experienced similar issues with this transmission after warranty repairs had been completed.

I am reporting a safety-related transmission problem I experienced with my 2023 Ford F-150 equipped with the 10R80 automatic transmission. While driving normally, the transmission suddenly shifts down violently from 10th to 8th gear, and rapidly jumping from 10th to 8th to 10th, causing harsh shifts. This occurred while driving on a highway or above 60mph. Just cruising and traveling. creating a potentially dangerous situation because the truck did not respond as expected when I needed predictable acceleration or propulsion. I believe this incident may be related to the known 10R80 CDF clutch-cylinder/sleeve problem. Ford technical information identifies axial movement of the CDF sleeve that can cause hydraulic-circuit leaks and harsh or delayed engagement and shifting. This condition can result in slipping, RPM flares, delayed engagement, unexpected gear changes, harsh downshifts, lurching, or loss of propulsion. This is a safety concern, not merely a transmission quality or reliability issue. Unexpected loss of propulsion or unpredictable shifting while merging, accelerating into traffic, crossing an intersection, turning, or traveling at highway speed can create a collision hazard. Because I personally experienced this unexpected transmission event, I request that NHTSA investigate the 10R80 CDF clutch-cylinder/sleeve condition in Ford F-150s. Please review Ford warranty claims, dealer repair records, transmission replacements, consumer complaints, and field-failure data t

I was practicing backing up while turning my new approximately 3,000 lb equipment trailer for safety & maneuvering skill purposes. There was no payload in my trailer that I was towing. While slowly maneuvering & turning my equipment trailer in reverse at 1–3 mph, our 2023 Ford F-150 XLT suffered a commanded, abrupt, unexpected sudden acceleration while in reverse, which was not via the gas pedal or my input. The trailer violently jackknifed, made a loud noise on impact to the truck resulting in damage to the truck bed’s right quarter panel at the rear, and a broken right tail light. It happened so fast I had to slam on the break hard, since the truck felt like it would keep backing into the jackknife position with powertrain seeming to struggle to overcome the break for a short instant. I believed at that instant that a mechanical or software or both malfunction caused this since this happened so fast and abruptly. Also to note, the parking break has often turned on or off automatically both during this incident and prior to, both while the vehicle was moving motionless. After looking at the damage, it first appeared to me to be less than a $1,000.00 repair bill, since only a small portion of the right rear corner of the fender was dented and the tail light broke. On Monday and Tuesday however I was surprised to learn after getting estimates that the damage is around $4,000 or more, since the entire quarter panel needs to be replaced - aluminum Quarter panels cannot be welded

The driver's side headlamp has a significant amount of shadows within the beam. This is in both the low beam and high beam modes. The shadows are highly visible on the road, and create a significant distraction while driving. This distraction is made significantly worse by the vehicles adaptive headlight system, as the shadows move on the road then you turn the steering wheel. The causes the driver's eyes to focus on the moving shadows, rather than on the road ahead. Additionally, the shadows in the headlamp significantly reduce visibility on the driver's side of the car, making it far more difficult to see animals or debris in the road. The vehicle was purchased new and the issue has been prevalent since the very beginning. Ford customer service will not help. Ford dealers tell me that the see the issues, and it should be that way, but are unwilling to replace the headlamp assembly because the cannot determine the root case (code), and are fearful that Ford will just charge them back for the warrant repair.

The torque converter inside my transmission on my 2023 f-150 “started coming apart” and has spread metal throughout my entire transmission and transmission cooler. There was no warning signs or lights that were shown to me other than when I noticed the problem which prompted me to immediately set up an appointment with my local ford dealer for a diagnosis and check up. It is a safety hazard because it can cause Sudden Gear Slippage & Power Loss: The torque converter may lose its ability to transfer power to the transmission, causing sudden drops in acceleration or unintended revving where the engine speeds up but the vehicle does not. This is extremely dangerous when trying to merge onto highways.Violent Shuddering: A faulty lockup clutch causes a harsh bucking sensation—often described as driving over a heavy rumble strip—usually between 35 and 70 mph. This can cause a sudden loss of vehicle control.Severe Overheating: Slippage and failing parts generate massive amounts of excess friction and heat. This boiled transmission fluid can melt internal seals, leading to fluid leaks, permanent clutch damage, and a potential engine bay fire if the fluid hits hot engine components. It can also cause Unintended Stalling and the vehicle shut off at stop lights or when driving. The truck is only 3 years old with 70,000 miles which is just outside of the powertrain 65,000 mile warranty. It was investigated and diagnosed by Trilakes ford in Branson. It has since been brought up to ford fo

Since shortly after buying my F-150 truck, I have had an ongoing issue with the Brake problem notification light coming on. I have spoken to the local Ford Dealership about this issue several times and had no resolution. They told me they could do an inspection, but it would cost me over $500, and only if they found a warranty issue that they were responsible for would they reimburse me the cost of the inspection. They also said that if the notification light was not on when they did the inspection, they would be unlikely to find an issue even if one existed. The warning light can go days or weeks without appearing and can stay on anywhere from a few minutes to an hour or so. I have tried to get the truck to the dealership several times, but it always goes off before I can get there (the dealership is about 40 minutes drive from my house). I am concerned because the warning light comes on more often these days but I still can not get the truck to the dealership with the light on. As the issue appears to be increasing in frequency, I am getting more concerned. The first time this appeared was approximately August 2024.

The contact owns a 2023 Ford F-150. The contact stated that while driving at an undisclosed speed, the front passenger's tire was flat. The vehicle was driven to a nearby church parking lot. The vehicle was repaired. The contact stated that while driving at an abnormal speed, there was an abnormally loud sound coming from the vehicle. The contact stated that the failure had occurred while making a right turn. The vehicle was driven to the residence and inspected. The contact stated that the front passenger’s side tire had been rubbing against the brake line bracket. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 49,270.

I was driving down the highway and the right, rear window shattered and blew glass all over the inside of my truck (the cab). There was no incident, no stress cracks, etc. The window simply “exploded”. I drove to the nearest Ford Dealership, assuming it would be covered under my bumper to bumper warranty. After the dealership had my vehicle a full week, they informed me Ford would not pay. I told them to order the window and replace it as I needed my vehicle back. I ended up being without my truck for two weeks. I paid $591.60 and called Ford today, to ask for reimbursement. I was told they cannot do so as the warranty only covers “windshields” for 12 months. I reminded the agent that this is a rear passenger window to no avail. After a little research, I’ve found that hundreds of F-150 owners have had this occur. *My granddaughter could have been in that seat as it was the rear passenger seat! This is a dangerous issue. I am still cleaning up glass, I continue to find all over the cab.

Driving approximately 20 miles an hour, gently applying the brake as I was approaching a stoplight when the brake suddenly engaged forcefully causing the car to jerk to a stop unexpectedly. There was a warning across the dash that said " forward collision is not available" and that disappeared. A local dealership said this was an ABS issue and reprogrammed it.

The contact owns a 2023 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V512000 (POWER TRAIN); however, the part to do the recall repair was not yet available. The dealer was contacted and informed the contact that parts were on backorder. The contact was concerned that the failure might occur while driving in an area where there was no phone service as the residence was in the countryside. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that parts were on backorder. The contact had not experienced a failure.

Hello, My range should be 320 mph on my F150 lightning. It is 226 fully charged was lower the last charge. This effects safety, time and money wheh traveling. I took it to the dealer and they said that there is nothing they can do. That I should run the range down to zero miles and that should reset the range. That didnt work. I have had several propulsion proplems. So many that I won a Lemon law suit. According to the NHTSA the range loss is tied to the systematic battery or drivetrain defect and ford refuses to honor my warranty and my extended warranty or address a potiential safety hazzard.

Today 6/18/2026 I was stopped at a stoplight and the engine cut off as if often does and when the light changed and I stepped on the gas instead of restarting the car went into park and remained off until I restarted the truck. This is similar to the safety issue built into the truck if stopped and the front door is opened the truck automatically goes into park. This is the second time it has happened in the past year- the truck being stopped at a light and the engine stops running and when I step on the gas instead of restarting it has gone into park.

There is a manufacturing defect that is causing water to to enter the vehicle when driving in the rain. Where this becomes a significant safety issue is that the water enters somewhere near the bottom of the windshield (source still not determined) and runs down the pillar over the fuse box and BCM (neither is protected from the water). This could lead to an electrical short on any of the major modules of the vehicle unpredictably. the leak is confirmed but source is still to be determined by the dealership after 2 visits. In searching the web, this seems to be a fairly common issue on this generation of F150 trucks. I'll attach the pictures I could get but can never get one with the water actually coming in live

Turn signal stalk binds up intermittently, requiring excessive force to deactivate signaling. Most commonly occurs after signaling to toward the right. This has been occurring intermittently shortly after vehicle purchase, but has become more common over the past year. Safety is affected due to the amount of force being required having the potential to cause the driver to inadvertently jerk the steering wheel left while attempting to deactivate the signal. No inspections have been performed and this vehicle has not yet been assessed by a dealer or independent service center. No warnings or other associated indicators of this issue have been noted.

The turn signal stalk on my 2023 Ford F-150 Lightning intermittently requires excessive force to manually cancel after turns and lane changes. The stalk self-cancels normally roughly 50% of the time, but when the steering wheel does not rotate far enough to trigger automatic cancellation the driver must manually return the stalk to center. The condition is most reliably reproduced when the cabin has been elevated in temperature for an extended period and subsides once cooled. The issue predominantly affects right-hand turns and lane changes. The affected component is the turn signal stalk switch pack (multifunction switch), available for inspection. Diagnostic scanning confirmed DTC B124C stored in the SCCM. Based on my research this code indicates a Turn Indicator Stalk Switch Pack fault. The safety risk is threefold: first, a stalk that does not self-cancel sends false signals to other drivers. Second, manually forcing the stalk back to center diverts driver attention from vehicle control. Third, when the stalk releases under applied force it does so suddenly and without warning, and if the driver's hand is on the steering wheel this can cause an involuntary steering input, risking unintended lane departure at highway speeds. I am the second owner, having purchased from a dealership at approximately 60,000 miles. The defect was present at purchase and has worsened progressively to approximately 76,000 miles. The vehicle has not been inspected by a dealer as it is outside wa

As I was driving in to my driveway slowly, and applying the brake my 2023 Ford F-150 accerated and lunged forward.

The contact owns a 2023 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000(POWER TRAIN); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not available. The contact stated that while driving at low speeds, a bearing noise was heard. The vehicle was taken to the local dealer, who confirmed that the rear axle bolt had fractured. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was 35,991.

Odometer Fraud. The contact purchased a _____. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale/dealer sale. At the time of purchase, the vehicle mileage was ___ and at the time of registration, it was discovered that the mileage was ___.

The contact owns a 2023 Ford F-150. The contact stated that the rear end broke. There were no warning lights illuminated. The contact received the recall notification letter for NHTSA Campaign Number: 23V896000 (Power Train). The contact called the local dealer, who confirmed the part was backordered. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 92,000.

SHIFT SYS FAULT SERVICE REQUIRED

Tried to turn on vehicle one morning and it would not start due a parking brake error message & a warning light on the dashboard. The message on the screen behind the steering wheel stated “park brake fault service now” and there was a clicking noise heard coming from underneath the truck. I tried to reset the parking brake by pressing and holding the button as indicated online but it didn’t work. The brake also physically revolted at me pressing down on it and would stutter/thump and not let me press it down fully without heavy resistance. The clicking noise continued randomly even when I was not in the vehicle. Then the door locks stopped working with my car keys, I could only open the drive door manually. I had no means to jumpstart my battery. I called Ford local dealership to come check the issue incase it was a recall issue that had not been reported for my vehicle yet. They are scheduled to come Monday 6/1/26.

The EPB system has a fault and service now code. This puts a risk on safety of me, passengers and others on the road. this make and model is a single exhaust unit and i believe it has to do with an open recall. July 21, 2023 NHTSA CAMPAIGN NUMBER: 23V509000 Unexpected Activation of Electric Parking Brake Unexpected activation of the electric parking brake while driving increases the risk of a crash. NHTSA ID Number: 23V509000 Manufacturer Ford Motor Company Components PARKING BRAKE Potential Number of Units Affected: 870701 Summary Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 vehicles equipped with a single exhaust system. Contact with the rear axle housing may damage the wiring harness, causing the electric parking brake to activate unexpectedly.

The contact owns a 2023 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V512000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was taken to the dealer, who inspected the vehicle and informed the contact that the rear axle hub bolt was broken; however, parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.