2002 Ford F-150

Defect. FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.

Risk. AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.

Remedy. FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21

Defect. DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Defect. SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Defect. K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Risk. WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy. K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.

Defect. CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

Risk. IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.

Remedy. ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.

Defect. CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.

Defect. CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy. AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.

Defect. CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.

Risk. FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Remedy. UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.

Defect. CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.

Defect. ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

Risk. A FIRE AT THE SWITCH COULD OCCUR.

Remedy. BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)

One or both of the steel straps holding up the fuel tank and attaching it to the truck frame can corrode and fail (break or separate).If one strap fails, the tank may tilt and drop and possibly contact the road surface.If both straps break, the entire tank may drop to the road.If either failure occurs while the vehicle is being driven, contact with the road can abrade the tank and create a hole from which gasoline can spill.When the tank drops, it remains attached to the vehicle only by the fuel filler hose and/or supply lines, or in rare instances, by the skid plate, if present.In some cases …

On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 FORD vehicles with triton v-8 and v-10 engines.odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.as of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in …

Ea05-005 is closed with FORD?s actions in recalls 05v-017, 05v-388, and 06v-286, recalling approximately 6.7 million vehicles equipped with texas instruments speed control deactivation switches (scds).the brake systems in these recalled vehicles generate a vacuum that can potentially cause the scds to fail and, in certain switch installation orientations, catch fire.FORD is also including the entire population of 1998 explorers.FORD has informed odi that testing to determine the cause of failures in the 1998 explorers will continue after this investigation is closed.odi believes that the …

This SKU is an Oil Dipstick. The customer communication requested return of unsold inventory to inspect the dipstick tube. The dipstick tube inner diameter may be small enough that it prevents installation of the OE dipstick.

1999-2008 7.3L/6.0L/6.4L/4.5L DIESEL F-SUPER DUTY - CLEAN THE CHARGE AIR COOLER (CAC) SYSTEM AFTER CERTAIN TURBO OR ENGINE FAILURES - SERVICE TIP. *NJ

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE

MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P1131 AND/OR P1151 - 4.2L ENGINE. *TT

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT

USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE. *TT

I had the recall number 05s28 repaired at high desert ford on July sixth as a part of a California safety inspection to register my vehicle. Per ford they are done however they refuse to update the system which holds my vehicle unable to be registered even after the services were rendered and complete. Multiple attempts to trendy have failed any results thus ford is holding my vehicle hostage from legal use in the state

Cruise control kicked on and won't go off. Gas fumes come from the AC unit. When driving the truck started speeding up. Now the truck is parked.

Front seatbelts on 2002 Ford F-150 become unlatched unexpectedly while driving. This has been noticed over the last two or three years occasionally, but has been getting worse. Seat belt has become unlatched about 5-6 times during a 600 mile road trip. Seat belt was confirmed by two passengers that it was indeed latched correctly and nothing pushing the release button. Seatbelt was confirmed to be latched by firmly tugging on seat belt to witness that it was latched. Both passengers confirmed that the seatbelt become unlatched randomly while driving. Passenger and driver safety is at risk. If driver seatbelt comes unlatched while driving or during accident, the driver could loose control of truck and put other drivers at risk. The unlatching does not show any warning signs as to when it will become unlatched. Seatbelt just becomes unlatched and starts to recoil without warning. Ford service just says that the truck is out of warranty and that they dont cover seat belt replacements as there is no open recalls for such. Seatbelt is still currently installed on vehicle but can be available for inspection on vehicle or removed for inspection.

Just learned of recall.

DRIVING DOWN [XXX] THE STRAPS ON MY GAS TANK BROKE BECAUSE THEY RUSTED THRU CAUSING GAS TANK TO DROP AND SPILL FUEL ALL OVER [XXX] IN IOWA CAUSING SO MUCH FUEL SPILLED OUT THEY HAD TO CLOSE ONE LANE OF TRAFFIC....THE FIRE DEPT CHIEF OF WHITING, IOWA, STEVEN SNYDER, Can verify what happened....THERE IS A POLICE REPORT BUT I DIDN'T HAVE IT FILING OUT THIS REPORT INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2002 Ford F-150. The contact stated while driving at an undisclosed speed, the vehicle made a loud sound. No warning light was illuminated. The vehicle was towed to an independent mechanic, who diagnosed and determined that cylinder #3 spark plug had blown out, but no repair was recommended at the time. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 108,000.

The contact owns a 2002 Ford F-150. The contact stated while at a tire shop to have the tires rotated, the mechanic was unable to remove the tires due to the lug nuts being swollen. The manufacturer was made aware of the failure and suggested to the contact to call the NHTSA Hotline to report the failure. The approximate failure mileage was 100,000.

The contact owns a 2002 Ford F-150. The contact stated that the rear driver's side and rear passenger's side doors failed to open from inside or outside the vehicle. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact stated that the vehicle was previously serviced due to the failure. The failure mileage was 70,000.

Systems failed. Recalls incomplete

The contact owns a 2002 Ford F-150. The contact stated that while driving approximately 45 MPH and attempting to pass a slower vehicle, the vehicle experienced unintended acceleration. The contact stated that while depressing the accelerator pedal, the pedal suddenly extended to the floorboard causing the vehicle to immediately accelerate faster than intended. During the failure the speed increased to over 75 MPH before the contact shifted the transmission into neutral and the vehicle decelerated. The contact stated that the vehicle had experienced the failure on two other occasions and the cruise control feature was never activated during the failure. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted. The failure mileage was 94,000.

The contact owns a 2002 Ford F-150. The contact stated that she observed smoke emanating from under the vehicle near the engine compartment. The contact stated that she opened the hood and flames erupted from the engine compartment near the battery. The contact threw dirt on the engine to extinguish the fire. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 200,000.

The contact owned a 2002 Ford F-150. The contact stated that while his wife was driving at 50 MPH, she crashed into a tree. The air bags failed to deploy upon impact. The contact's wife was taken to the hospital where she was treated for a concussion, multiple hematomas to her right thigh, right abdomen, and head; as well as three fractures on her vertebrae. A police report was filed. The vehicle was towed from the scene to an independent tow yard where it remained in their possession. The dealer nor the manufacturer had been notified of the failure. The contact was informed by his insurance that the vehicle was a total loss. The failure mileage was approximately 280,000.

Speed control deactivation switch

The contact owns a 2002 Ford F-150. The contact stated while opening the driver’s side rear door, the door failed to unlatch. The contact also attempted to open the passenger’s side rear door; however, the door would not unlatch. The vehicle was taken to an independent mechanic and the contact was informed that the wiring harness in the doors needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 80,000.

Unknown cause of incident. Vehicle is available for inspection. Vehicle spontaneously burst into flames. No reproduction due to incident happening on 09/02/2022. Vehicle inspected by Fire Department and California Highway Patrol. No warnings or symptoms leading up to incident. On 09/02/2022 I attempted to help my wife that was stranded out State Route Highway 36 in her 2009 BMW 750 LI at the Van Duzen Grange. I had been hooked up to her car for approximately 10 to 15 minutes with my truck idling when she screamed, " Your truck's on FIRE!" I barely got myself out of the cab when a ball of flames shot through the dashboard. 3/4ths of the truck was consumed in fire in less than 5 minutes. Fire Department arrived approximately 10 minutes later and doused the fire. Everything in my truck was destroyed. My wife's BMW suffered severe damage to the front end.

I have a 2002 Ford F-150 and The problem is with the transmission my vechile acts like it's going in reverse and when it goes to backup it seems as something is locked I been over the brakes and rear end and yet nothing has came up I even replaced the transmission filter to see if that would help but nothing so I been having to drive my truck with no reverse and today the overdrive light on the shifter started blinking what is the problem with these transmission please Ford do a recall to fix the transmission

1. Coils on top of spark plug get moisture in them when there is just the right kind of rain storm. This makes the coil or coils fail until the dry out. This seems to make the coil eventually go bad. Yes, it is available for inspection. 2. Not sure if its a combination of heat and moisture but sometime right away and sometimes a few minutes into driving the coil or coils fail and the engine loses power. Then if seems to be a random, unpredictable occurrence until it dries out, Very Unsafe. If one coil fails it loses just a little power, but if more than one fails it loses a lot of power and stalls at times. This is why I am writing it up. A few time now, I have gone to pull into traffic and then I lose power and either have to run off the road or just upset the car behind me if they are not too close. 3 & 4. I have advise all the Ford dealerships in my area trying to find one that has a fix yet. The only fix Ford has, is a new designed coil, which does not appear to be any better. The dealership just replaces the coil. I have had all my coils replaced, some 2 or 3 times. 5. It depends, sometime the engine light will come on and advise which coil is misfiring and sometimes if does not. Right now my engine light is on and it displays the #6 coil misfire. Then the engine light will go out after it dries out and stops failing or it will stay off if the coil had gone bad again. I am sure its not just the F 150, but the 4.6 liter engine that is in other vehicles. I started keeping

Left rear passenger door will not open. Door is jammed. This will not allow rear passengers to quickly exit vehicle if pinned in due to crash or fire.

I went to get a state inspection and a code came up Po174

This F 150 has experienced SUA. I have reported it back in June. I have tried to fix the problem but I cannot. I don't know what causes my truck to accelerate full throttle. So, I've come to the conclusion I must move on. Then I realized I really cannot sell the vehicle? Somebody would be killed no doubt. I've been lucky and savvy enough to slide the shifter into neutral. If I sell the truck and do not mention the problem? The thing is I could sell this truck in 5 minutes. It runs like a top spins. I have always taken care of any maintenance issues since purchasing new. I've educated myself on SUA. It's extremely interesting but if you've experienced it, it is awful. I read one story about a guy who wanted a Toyota dealership to take his Camry back. It was practically new. They would not. So he went to another dealership and traded it in. I can't blame the guy but I can not sell my truck and sleep at night. So what do I do with a truck that roars off like a rocket ship? How many people have had this problem? And what do they do with the car/truck once they realize it really cannot be driven anymore?

SUA sudden unwanted acceleration, at least 4 times. No floor mats. 1st time truck surged back and forth a little then accelerated full throttle. I went to neutral. I kicked gas pedal although gas peddle was not depressed. It stopped. I was shook up but in control. I decided to remove throttle body and clean extensively. Replaced TB Sensor w/ genuine Ford part and replaced throttle valve on top. Hoped for the best. Still have the problem. 2002 F 150 XL 4.2 purchased new. I still have truck because its been such a great truck, I never felt like it was time to move on. It runs like new and I've taken care of it. I am writing this info for safety and only safety. I've been researching this issue. trying to solve problem. I took truck to qualified shop where mechanic is known to me and he was a little stumped. No codes, no check engine light. Can't solve the puzzle? So, I'm on top of the possibility of it happening. I really don't go anywhere w/ truck, to the store and back pretty much. So when its happens, I'm fast to go to neutral. I also feel like if I wanted to show somebody what I'm talking about, all they have to do is get in. I'm almost positive if I punch the gas peddle just a little, say to pass a slow driver, it'll go like hell. I have started thinking about my next truck. But no way I'm trading or selling this truck and passing the problem to someone else. So, I'm dealing with it and really hope my experience helps. I've read the story's on line. Because I've lived it,

When it rains the rain is somehow getting into the fuse box under the steering column and causing it to drain the battery, short out some of the instrument cluster, make noise, blow fuses, and rust up. It is a fire hazard and it puts all inside the truck in danger. I have not yet had a fire but if I keep the truck as is it will eventually.

I WAS DRIVING ON FREEWAY WHEN A CAR THAT WAS TRAVELING IN AN EXCESS OF 80+ MILES AND REAR-ENDED MY 2002 FORD F 150. MY TRUCK WAS TOTALED AND MY DRIVERS SEAT BACK FRAME BROKE FROM RIGHT SIDE AND NONE OF MY AIRBAGS DEPLOYED. I ENDED UP IN THE HOSPITAL FOR 3 DAYS. I HAD A CONCUSSION, NECK INJURY, KNEES AND RE-INJURED MY BACK. I WAS LUCKY TO BE ALIVE.

I AM TRYING TO FIND OUT IF THIS TRUCK HAS A RECALL THAT WAS NOT TAKEN CARE OF WITH PREVIOUS OWNER BASED ON REVIEWS.. - THERE APPEARS TO BE IDLE ISSUES.. ENGINE LIGHT INDICATES SENSOR ISSUE. *TR

SPARK PLUG SHOOTS OUT OF MOTOR WHILE DRIVING. HAS BEEN REPORTED ON LOTS OF VEHICLES FOR YEARS.

TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT WHILE STOPPED, THE CONTACT WAS UNABLE TO SHIFT THE VEHICLE OUT OF PARK. THE CONTACT STATED THAT THE VEHICLE WAS DIAGNOSED BY HIS STEP-SON. THE CONTACT WAS INFORMED THAT THE CYLINDER VALVE NEEDED TO BE REPLACED. THE CONTACT CALLED SKYLINE FORD LOCATED AT 2510 COMMERCIAL ST SE, SALEM, OR 97302, (503) 581-2411, AND THE DEALER WAS INFORMED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 150,000.

WHEN MY TRUCK IS IN IDOL POSITION, THE TRUCK JUMPS AS THOUGH IT IS EITHER TRYING TO SHUT OFF OR TAKE OFF. I ACTUALLY HIT ANOTHER VEHICLE IN A DRIVE THROUGH WHILE SITTING IN IDOL POSITION.

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.

I WAS DRIVING AND THE SPEED WOULD GO UP TO 90 MPH, THE TRUCK WAS NOT GOING THE SPEED IN REALITY. THEN THE RPM'S WOULD GO UP REALLY HIGH, I STOPPED THE TRUCK PUT IT IN PARK AND BACK IN DRIVE TRIED TO DRIVE OFF. THE TRUCK THEN WOULD NOT GO OVER 30 MPH AND THE GAS PEDDLE WAS ALL THE WAY DOWN TRYING TO GO, THE ENGINE STARTED SMOKING AND WHEN I PULLED OVER OPENED THE HOOD IT WAS SMOKING FROM THE DRIVER SIDE UPPER CORNER OF THE TRUCK. AFTER HAVING A MECHANIC LOOK AT IT, HE SAID THE BREAK PRESSURE SWITCH NEEDED TO BE REPLACED BECAUSE IT'S A HOT WIRE AND IT'S LEAKING. AFTER CHECKING THE FORD VIN CHECK IT DIDN'T SAY MY TRUCK WAS APART OF THE RECALL BUT THEY YEAR AND MAKE AND MODEL IS. I'M CONFUSED AND AT THIS POINT DON'T WANT TO PUT MY CHILDREN IN A FIRE BALL LIKE THAT IF IT CATCHES ON FIRE...

THIS IS FOLLOW UP ASSESSMENT TO MY 9/22/2019 CLAIM [XXX]- WHERE I FOUND MYSELF IN A VERY DANGEROUS VEHICLE RUN AWAY SITUATION THAT RESULTED IN A REAR END ACCIDENT WITH ANOTHER VEHICLE. MY MECHANIC'S FIRST OBSERVATION WHEN TURN IGNITION KEY, THE ENGINE RACED AT FULL THROTTLE OUT OF CONTROL. AFTER QUICKLY SHUTTING DOWN ENGINE THE SYMPTOMS LEAD MY MECHANIC TO TEST THE IDLE AIR CONTROL VALVE. HAVING NEVER SEEN THIS DANGEROUS SYMPTOM FROM A BAD IACV, HE CONTINUED TO DO FURTHER TEST ON THE IACV ONLY TO DETERMINE THE PART WAS INDEED DEFECTIVE. AFTER DIAGNOSING THE PROBLEM, THE DEFECTIVE IACV PART WAS QUICKLY REPLACED. THE ENGINE IS NOW RUNNING GOOD AGAIN. IF YOU NEED TO CONTACT MY MECHANIC: DUGAN AUTO SERVICE, NARVON PA - DOUG MILLER 464-798-8097 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT

CAR WAS ON THE HIGHWAY DOING 65 MPH. WHEN I TOOK MY FOOT OFF THE ACCELERATOR, THE CAR CONTINUED TO ACCELERATE ON ITS OWN. WHEN I APPLIED THE BRAKES I WAS ABLE TO SLOW IT DOWN AND CONTROL THE CAR. WHEN I GOT OFF THE EXIT RAMP AND TRIED TO BRING THE CAR TO A STOP, THE ENGINE WAS RUNNING AT HIGH RPMS AND I COULDN'T COMPLETELY STOP CAR UNTIL I REAR ENDED ANOTHER VEHICLE. I'VE TRIED TO START THE CAR AFTER THAT, BUT THE ENGINE IMMEDIATELY STARTS RACING AS IF I HAVE MY FOOT PRESSED ON ALL THE WAY DOWN ON THE GAS.

TL* THE CONTACT OWNS A 2002 FORD F-150. WHILE DRIVING 55 MPH, THE CRUISE CONTROL FAILED TO OPERATE AND THE CROSS CONTROL WENT INTO A LOCKED POSITION. THE CONTACT ATTEMPTED TO BRAKE, BUT THE VEHICLE WOULD NOT STOP. THE CONTACT PLACED THE VEHICLE IN NEUTRAL AND WAS ABLE TO SLOW DOWN THE VEHICLE. WHEN THE VEHICLE FINALLY STOPPED, THE CONTACT DISCONNECTED THE CRUISE CONTROL CABLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 222,112.

TL* THE CONTACT OWNS A 2002 FORD F-150 EQUIPPED WITH FOUR TOYO NITTO TERRA GRAPPER TIRES, SIZE: 285/55/20 (NA). WHILE DRIVING 60-65 MPH, THE VEHICLE SHOOK VIOLENTLY. THE CONTACT EXITED THE VEHICLE AND NOTICED BUBBLES IN THE TREAD ON BOTH FRONT TIRES. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE VIN AND DOT NUMBER WERE UNKNOWN. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 40,000 AND THE TIRE FAILURE MILEAGE WAS 25,000.

THE TRUCK SIMPLY SHUT DOWN WHILE I WAS DRIVING. THE ENGINE STOPPED RUNNING. FOR A PERIOD OF ABOUT A MONTH PRIOR TO THIS ACTION, THE TRUCK WOULD SOMETIMES, RANDOMLY, NOT START. AFTER WAITING A PERIOD OF TIME THE TRUCK WOULD START.

TL* THE CONTACT OWNS A 2002 FORD F-150. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT HEARD A LOUD ABNORMAL NOISE UNDERNEATH THE HOOD AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED BY A DEALER. THE CONTACT KNEW THAT THE FAILURE WAS CAUSED BY A SPARK PLUG. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 190,000. *BF *JB

TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT AN EXPLOSION OCCURRED UNDER THE HOOD AND THE VEHICLE CAUGHT FIRE WHILE PARKED IN THE DRIVEWAY. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. THE VEHICLE ONLY HAD LIABILITY COVERAGE; THEREFORE, THE FAILURE WAS NOT COVERED BY THE INSURANCE COMPANY. THE VEHICLE WAS TAKEN TO METRO FORD INC (2860 S NOLAND RD, INDEPENDENCE, MO 64055, (816) 254-9800), BUT THEY COULD NOT ASSIST. THE DEALER SUGGESTED HAVING AN INDEPENDENT MECHANIC DIAGNOSE THE VEHICLE. THE MANUFACTURER WAS NOT CONTACTED. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL), WHICH COULD HAVE CAUSED THE FIRE. THE FAILURE MILEAGE WAS 204,000. *BF *TR

TL* THE CONTACT OWNED A 2002 FORD F-150. AFTER THE CONTACT TURNED OFF AND EXITED THE VEHICLE, HE WAS ALERTED BY A PASSERBY THAT THERE WERE FLAMES UNDER THE HOOD. THE FLAMES WERE NEAR THE DRIVER'S SIDE OF THE ENGINE COMPARTMENT NEAR THE BRAKE SYSTEM. A FIRE INSPECTOR EXTINGUISHED THE FLAMES. THE VEHICLE WAS DESTROYED BY THE FIRE. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS UNCERTAIN IF THE FAILURE WAS RELATED TO NHTSA ACTION NUMBERS: EA05005 (ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL) AND DP05005 (ENGINE AND ENGINE COOLING) AND NHTSA CAMPAIGN NUMBERS: 06E056000 (FUEL SYSTEM, GASOLINE) AND 05V388000 (VEHICLE SPEED CONTROL). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE REMAINED AT THE SCENE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 175,000.

TL* THE CONTACT OWNS A 2002 FORD F-150 EQUIPPED WITH GOODYEAR WRANGLER SR-A TIRES, SIZE: P255/70R16 (NA). UPON INSPECTING THE TIRES, THE CONTACT NOTICED THAT THE TREAD WAS CRACKED ON ALL FOUR TIRES. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED. THE VIN AND TIRE FAILURE MILEAGE WERE NOT AVAILABLE. THE VEHICLE FAILURE MILEAGE WAS 1,200.

TL* THE CONTACT OWNED A 2002 FORD F-150. WHILE THE VEHICLE WAS PARKED IN FRONT OF THE CONTACT'S HOUSE, IT CAUGHT FIRE WITHOUT WARNING. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT WAS NOT FILED. THERE WERE NO INJURIES. THE FIRE WAS NOT HEAT RELATED. THE VEHICLE WAS TOTALED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT THE DRIVER'S SEAT BELT WAS NOT PROPERLY SECURING INTO THE BUCKLE TO CLICK, LOCK, AND SECURE THE DRIVER. THE VEHICLE WAS TAKEN TO MULLINAX FORD OF MOBILE (7311 AIRPORT BLVD, MOBILE, AL 36608, 1-(888) 241-4640) AND AUTONATION FORD MOBILE (901 EAST INTERSTATE 65 SERVICE RD S, MOBILE, AL 36606, (251) 202-2016). BOTH DEALERS INDICATED THAT A SEAT BELT KIT NEEDED TO BE PURCHASED AS A UNIT, WHICH INCLUDED ALL OF THE SEAT BELTS IN THE VEHICLE. THE DRIVER'S SEAT BELT WAS NOT REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE TO DETERMINE IF THEY COULD APPROVE JUST THE DRIVER'S SEAT BELT BEING REPLACED. THE MANUFACTURER HAD NOT ISSUED ANY SEAT BELT RECALLS FOR THE YEAR, MAKE, AND MODEL VEHICLE; HOWEVER, THEY ISSUED TWO TSBS FOR THE SEAT BELTS. THE APPROXIMATE FAILURE MILEAGE WAS 174,000. *TT *JB

STATIONARY CAUGHT FIRE IN STORAGE GARAGE, DAMAGING, EQUIPMENT LAWN MOWERS,MOTORHOME,STRUCTURE.

PARKING BRAKE DOES NOT WORK AT ALL. CABLES AND ACTUATOR ARE WORKING PROPERLY AND ALSO THE PARKING BRAKE SHOES ARE STILL IN GOOD CONDITION. STILL DOES NOT HOLD TRUCK

TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT THE FUEL TANK STRAPS FRACTURED AND THE FUEL TANK DROPPED. THE VEHICLE WAS UNABLE TO BE DRIVEN DUE TO THE FAILURES. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE) ACCORDING TO THE MANUFACTURER. THE VEHICLE WAS NOT DIAGNOSED BY A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER ADVISED THE CONTACT TO TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING AND REPAIR. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.

WHILE DRIVING (IN MOTION), THE DRIVER'S SIDE SEAT BELT RANDOMLY DISCONNECTS. THERE IS NO WARNING OR SPECIFIC CONDITION THAT CAUSES THIS TO HAPPEN. OBVIOUSLY THIS CREATES A VERY DANGEROUS CONDITION.

TL* THE CONTACT'S FATHER OWNED A 2002 FORD F-150. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED UNINTENDED ACCELERATION WITHOUT WARNING. WHILE IN A PARKING LOT, THE VEHICLE ACCELERATED AND SPUN OUT OF CONTROL. THE DRIVER STRUCK A CURB TO AVOID CRASHING INTO OTHER VEHICLES IN THE PARKING LOT. AS A RESULT, THE VEHICLE WENT AIRBORNE AND STRUCK A TELEPHONE POLE, BUT CONTINUED TO ACCELERATE AT A HIGH RATE OF SPEED UPON TOUCHING THE GROUND. THE VEHICLE THEN DROVE OVER ANOTHER CURB AND CRASHED INTO SOME BUSHES. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS NOT FILED. THE DRIVER SUSTAINED INJURIES THAT REQUIRED MEDICAL TREATMENT. THE VEHICLE WAS TOWED AND PLACED IN STORAGE. THE CONTACT'S FATHER NO LONGER OWNS THE VEHICLE BECAUSE HE IS DECEASED DUE TO UNRELATED CIRCUMSTANCES. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED LATER OF THE CRASH. THE FAILURE MILEAGE WAS NOT AVAILABLE. *TT UPDATED 9/19/18*JB

DRIVERS SIDE SEAT BELT DOES NOT LOCK AT ANY TIME

2002 F-150. CONSUMER WRITES IN REGARDS TO ISSUES WITH FRONT TIRES. *LD THE CONSUMER STATED THEIR DAD HAD AN ACCIDENT TO DUE POSSIBLE DEFECTIVE TIRES. *TR

WOKE UP AT 1AM ONE 4-1-2018 TO MY FORD F 150 ON FIRE DRIVERS SIDE FRONT UNDER THE HOOD. UNKNOW TO US OUR LOCAL SHERIFF HAD SPOTTED THE FIRE AND ALREADY CALLED THE FIRE DEPARTMENT. TOTAL LOSS. BOUGHT THE TRUCK A FEW MONTHS BACK WITHOUT ANY KNOWLEDGE OF A RECALL ON THE SPEED CONTROL SWITCH. THE VEHICLE WAS SITTING IN OUR DRIVE NEXT TO OUR OTHER CARS FOR 3 HOUR WITH KEYS OUT OF THE IGNITION.

THE RECALL IE AN INLINE FUSE ON SPEED CONTROL DEACTIVATION SWITCH DID NOT WORK IT JUST CAUGHT ON FIRE AND RUINED MY MASTER CYLINDER AND BRAKE SYSTEM.IT WONT HOLD BRAKE FLUID NOW BECAUSE THE SWITCH MELTED INTO IT.FORD SAYS OH WELL RECALLS BEEN DONE

TL* THE CONTACT OWNS A 2002 FORD F-150. WHILE DRIVING 50 MPH, THE CONTACT NOTICED THAT THE DRIVER'S SEAT BELT UNBUCKLED RANDOMLY. THE FAILURE ALSO OCCURRED ON THE FRONT PASSENGER SIDE. THE DEALER (SIMI VALLEY FORD, 2440 1ST ST, SIMI VALLEY, CA 93065) STATED THAT THERE WERE NO RECALLS ATTACHED TO THE VIN AND, WITH THE VEHICLE BEING A DIFFERENT YEAR THAN WHAT WAS IN THE RECALL, THE FAILURE WOULD HAVE TO BE PAID OUT OF POCKET AT A COST OF $700. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE THROUGH EMAIL. THE CONTACT WAS AWAITING A RESPONSE FROM THE MANUFACTURER. THE FAILURE MILEAGE WAS 180,000.