2005 Ford F-150

Defect. FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.

Risk. THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.

Remedy. FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

Defect. DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Defect. SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Defect. FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.

Risk. ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.

Remedy. DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Defect. CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.

Remedy. SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.

Defect. CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.

Remedy. SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.

Defect. CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.

Defect. CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

Risk. IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.

Remedy. ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.

Defect. CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy. TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.

Defect. CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Risk. LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH

Remedy. AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.

Defect. CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.

Risk. FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Remedy. UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.

Defect. CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy. ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.

Defect. CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.

Risk. THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.

Remedy. DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Defect. CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.

Risk. AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.

Remedy. CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.

ODI opened this investigation based on reports of inadvertent airbag deployment.Data provided by Ford indicated that the airbag clockspring jumper wire, which is situated inside the steering wheel assembly, was installed in a manner that would allow it to rub (abrade) against a sharp metal edge on the nearby horn plate.Because the horn plate is electrically grounded the abrasion of an airbag wire on the sharp edge could cause a short circuit condition.As a result the airbag light may illuminate and/or the airbag may inadvertently deploy.Inadvertent deployments are most likely to occur during …

Ford reports that the inadvertent airbag deployments are most likely caused by the airbag horn mounting plate's sharp metal edge that eventually can chafe/cut the airbag clockspring jumper wire leading to a short-to-ground condition.one hundred eighty two (182) of the 230 reports were for airbag deployments resulting in 56 injuries with remaining 48 reports for an airbag light illumination condition.injuries include abrasion, contusion and cuts to the arm/hand/face and/or upper body regions.one owner reported a broken tooth and two owners reported being knocked unconscious as a result of the …

By letter dated may 5, 2008, FORD motor company (FORD) notified the agency that it will conduct a safety recall (NHTSA recall number 08v-208) to address a manufacturing defect in approximately 605,684 model year (my) 2005 and 2006 FORD f-150 and lincoln mark lt vehicles originally equipped with the 5.4l displacement, 3-valve per cylinder, v-8 engine.the recalled vehicles were built from july 18, 2004 through may 31, 2006 at the dearborn truck plant; from may 4, 2004 through may 31, 2006 at the kansas city assembly plant; and from april 19, 2004 through may 31, 2006 at the norfolk truck …

FORD LINCOLN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CUSTOMER SATISFACTION PROGRAM 07M08: CERTAIN 2005 MODEL YEAR F-150, F-SUPER DUTY, EXPEDITION, AND NAVIGATOR VEHICLES WITH 5.4L 3V ENGINES-EXTENDED WARRANTY COVERAGE ON FUEL INJECTORS. CSC WAS RECEIVED. *NJ UPDATED 5/20/09. *PE

AN ALUMINUM-BACKED BUTYL PAD MAY HAVE BEEN ADDED TO THE INSIDE SURFACE OF THE RIGHT HAND SIDE BOX OUTER PANEL IN FRONT OF THE TAIL LAMP. CUSTOMER SATISFACTION PROGRAM 04B23. BUTYL PAD REMOVAL. *TT SUPPLEMENT #1. *TT SUPPLEMENT #2. *TT

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT

POWERFOLD MIRRORS APPEAR LOOSE OR WILL NOT LOCK IN PLACE - SERVICE TIP. OASIS NOV 2004. *TT

My sister's 2008 Hyundai Elantra burned completely nothing left my truck was parked next to it it also burned the entire driver's side It was ruled an accident by fire department but progressive has turned down any claim from me the said since there was no one at fault even though her car burned my truck it's my problem

The contact owns a 2005 Ford F-150. The contact stated that while driving at 55 MPH, while the brake pedal was depressed, the brakes failed to engage; the contact pulled the vehicle into a Home Depot parking lot, exited the vehicle, and discovered that the engine compartment was on fire. The Home Depot employees came out to the vehicle and extinguished the fire with a fire extinguisher. The Fire Department and Police Department were contacted; however, the contact was unsure if a report was filed for either department. The orgin of the fire was not confirmed however, the fire department informed that timing was critical because any longer the fire would have caused an explosion. No warning lights were illuminated. The vehicle was towed back to the residence, and the vehicle was not diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 360,000.

Customer states that the frame of the vehicle has been compromised by corrosion. the vehicle only has 163,844 miles on it and it has major holes in the frame. The chassis could break in half prohibiting the use of this vehicle on the roadway due to the safety of occupants. I advised the customer of this of which they bought a frame repair kit (Pre-cut over frame c-channel steel) to weld onto the frame to support a longer lifespan. The truck is now safe for the roadway.

Spark plug blew out no check enginge lite until after coil an plugs replaced now motor has a knocking sound 5/23 not 1969 like date happended onlys puts down even if i select present day

While changing the spark plugs 7 of the eight broke off in the engine block, the threaded section came out but the ceramic bottom portion is what broke. I find that this is somewhat common because Auto Zone rents a spark plug extractor specifically for this. My safety isn’t at risk. Problem not reported to a dealership yet. No inspection yet. The check engine light was on

The contact owns a 2005 Ford F-150. The contact stated that while parking the vehicle, the vehicle rolled backwards. The contact shifted the gear shifter into park and turned off the vehicle; however, the vehicle rolled backwards again. The contact stated that while attempting to start the vehicle, the vehicle failed to start. No warning lights were illuminated. The contact stated that upon inspecting under the hood, the contact became aware that the shifter cable had melted. The contact purchased a new shifter cable and replaced the shifter cable. The vehicle was started and driven to the residence. In addition, the contact stated that the failure had occurred at night, which was dangerous for being on the side of the road. The contact stated that the shifter cable had melted again within 12 hours. The contact stated that the failure was the result of a design flaw. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 260,000.

My airbag light is on and the dealership says I have no active recalls but when I ask about recall number 11V-107 no one can confirm the when and where for this recall. I would like it repaired at no cost and the criteria of this recall number.

This is an extended cab - 4 door - the rear doors are half doors with a a handle allowing entry and exit to and from the rear passenger seats. (It is not a crew cab 4 door). The doors LOCKED and the handles failed with a child in the rear seat. THe doors cannot be opened. The child and his mother had to climb over the center console to exit the vehicle. THe vehicle is at a mechanic who states no part are available to repair this faulty and unsafe door mechanism. Both rear doors are LOCKED. QUalified mechanic estimates the cost to rig a fix, in absence of any left door mechanism parts will be near or over $500.00. THe mechanic reports that the control cables from the handles to the door latch stretched and failed. If there had been a collision or engine fire, rear seated passengers would be trapped inside the vehicle. THIS NEEDS TO BE ADDRESSED and REPAIRED BY FORD.

Odometer Fraud. The contact purchased a 2005 Ford F-150. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 122,180 and at the time of registration, it was discovered that the mileage was 216,350.

I don't even have 150,000 miles on this thing. I get it serviced regularly. I've used the 4x4 when needed, as I live in the Sierra Nv Mountains area. I don't overdo it, I don't abuse it. One day with "ZERO" Clues or indications my truck popped out of drive into neutral ON ITS OWN I put it back into drive. Then as I tried to accelerate NOTHING, I got a code/msg saying faulty transmission, my O/D kept turning off and on. I pushed it to the side if the road. I eventually got reverse back, 1st gear, but that's it. And NOBODY KNOWS WHAT IS WRONG WITH IT. Its Automatically you need a transmission. [XXX]!! You go online and this is happening to TONS of people. Are you saying WE ALL NEED NEW TRANSMISSIONS?? Kinda odd same trucks, same issues on the same part. What's the common denominator here ford??? Your [XXX] transmissions. Figure it out!!! My truck is paid off and I can't even drive the [XXX]. I'm walking because of a [XXX] transmission, on top of paying over 20,000 you want me to dish out another 3grand for your [XXX]?? Nah... Figure it the [XXX] out. Take care of your customers as you should!!! Integrity is doing the right thing when no one is looking. Come on Ford. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My electrical fixtures have failed or blinks off and on, on its own.

The contact owns a 2005 Ford F-150. The contact stated while starting the vehicle, there was an abnormally loud knocking sound coming from the engine. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the cam phasers had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 190,000.

Issues with transmission/ over drive snap ring vehicle only has 145,000 miles. This truck has many complaints and many failures and flaws that need fixed.

The DMV has a extended warranty coverage on the fuel injectors .. coming up a recall at DMV. What do I do.

Nothing has happened yet but frame of truck is rusting apart and suspension is going to fall off. This is not just this truck it’s lots of 04-06 f150

Frame started rusting through frame the inside out, first discovered in 2021. I had to have the frame repaired with no help from Ford in October of 2022

Frame on passenger and drive side by transmission, fuel tank, and rear leaf springs are rusted and have no integrity left. No structure integrity if in an accident. If fractures completely, will loose control of vehicle as the bed will contact cab, driveshaft will jamb into transmission, lock up brakes from pinched brake lines, loss of brakes from severed brake lines, lose control and go into on coming traffic or into roadside structures including pedestrians. NOTE: Your system will not let me upload pictures.

No incident FAR SOME REASON MY AIR BAG LIGT STAY ON

The contact owns a 2005 Ford F-150. The contact stated that when he had the vehicle serviced that the independent mechanic informed him that the front and rear frame of the vehicle was rusted and he should not be driving the vehicle. The manufacturer was made aware of the failure but provided no assistance but did inform the contact to contact NHTSA. The failure mileage was approximately 170,000.

The contact owns a 2005 Ford F-150. The contact stated while driving at an undisclosed speed, he smelled an abnormal fuel odor. Additionally, the contact stated that while the accelerator pedal was depressed, the vehicle failed to accelerate as needed. The check engine warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 200,000.

The whole frame is rusting out and the bed dipped and looks like it will fold in half.

Pulled out of driveway and made it 50 feet and whole truck shut down right on the road. Could not make the vehical restart no click or anything dead right where it stopped. Could of caused an accident. Had to have truck taken to a shop they took a week to find out that the electrical fuel system harness had a dead short in it. So no fuel going to the feul injectors or to the key to start the vehical. Still have head lights and breaks and radio. Just no way to restart the vehical. They checked thw wires and after unplugging many wires to the fuel system and retesting it started. Left with the truck a day later the same thing happen but this time i had to jump a curb to avoid an accident and coasted into a parking lot. I got out and wiggled a few of the wires and the truck started back up. I made it back to where i was staying only 2 blocks up the road and it died in the parking lot in a stall. That has been over 3 weeks and cant find the parts to fix it even by talking to ford shops. There not able to get this harness due to they have been discontinued...truck has low miles on it and now i dont know what to DO. This is my daily driver for WORK. This shouldnt of happened with the wires being wrapped even the mechanic who has his own shop but also works for Ford as a mechanic he has seen this before and now having problems getting parts. I hope you can help with this matter. Due to its very disturbing to myself when its in good shape and was taken care of and NOW cant get parts.

The contact owns a 2005 Ford F-150. The contact stated that the bed of the truck was lower than usual. The contact looked underneath the vehicle and became aware of rust underneath the vehicle. The vehicle was taken to an independent mechanic and the mechanic stated that the vehicle was rusted and that the sub frame was cracking and referred the contact to the dealer for assistance. The dealer was contacted, and the dealer stated that the vehicle needed to be inspected. The manufacturer was contacted, and the manufacturer stated that the vehicle was not under recall and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 75,000.

The contact owns a 2005 Ford F-150. The contact stated that the vehicle was taken to an independent mechanic, who informed the contact that the subframe was severely rusted. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 114,000.

The undercarriage and frame is rusted .Ford said it was not under warranty and the truck was unsafe to drive. Most of the rust is mainly at the rear of truck and if the truck was hit in the rear it would be very unsafe to drive.

The contact owns a 2005 Ford F-150. The contact stated that while driving and making a turn at various speeds, there was an abnormal popping noise detected. There were no warning lights illuminated. The contact stated that the spark plugs, cam shaft sensor, and coils were replaced. The vehicle was taken to the local dealer where it was diagnosed that the CV axle boots were torn. The vehicle was repaired but the failure persisted. The manufacturer was contacted and the contact was referred to the NHTSA hotline. The approximate failure mileage 91,082.

The contact owns a 2005 Ford F-150. The contact stated while driving at an undisclosed speed and approaching a stop sign, he had to pump the brake pedal to fully stop the vehicle. The contact stated no warning light was illuminated. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had been informed of the failure. The failure mileage was unknown.

This vehicle is part of the now famous Frame Rust Issue on 2004 - 2008 f-150 Extended Cab pickup trucks. This is a one owner well maintained, very clean vehicle in perfect running order. During regular service, I found rust spots on the frame. The rust appeared to be from the inside out. After further investigation the frame had been destroyed by internal rust. I condemned the vehicle and took it off the road. Further investigation showed this was a very widely known problem and contested Issue. I have undercoated this truck many times over the years and it was very clean. I. Have never received any notice from Ford about this well documented problem. I am in the process of repairing the frame via dorman products. Ford should be held to account any pay for this repair.

The main frame is so corroded that it is unsafe to drive. The body has no rust and the engine only has 73,000 miles on it. I went to the Ford garage for new tires and they found the damage to the frame

This is the 2nd Ford F 150 pick up with which I've had rusted frames! The 1st, a 1999, I ended up junking. This one needs $2000 of welding to make the frame safe to drive. The proprietor of [XXX] Welding says he's done over 40 F 150's for the same problem with the frames. My mechanic, [XXX], at Shaw's Automotive, says he's seen F 150's that have collapsed around a lift when they were in for a simple oil change. The internet states this is a common issue with F 150's. SAFETY, SAFETY, SAFETY! These trucks should not be on the road until Ford repairs them or buys them back, like Toyota did in the 90's!!!! INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Truck frame is rotting from the inside out, Could not tell the extent of damage from looking underneath, I have to get it repaired before it snaps in half.

My brake booster or vacuum line has went out during driving and I almost lost control with my family. I see theres recalls on my make model and year. So I wanted to check and see because it was scary I had to leave my truck and get it towed some how back still also.

The frame of the vehicle is rusted through in multiple spots. When I picked the vehicle up on the lift the weight of the vehicle crushed the bottom side of the frame upward 1/2" upon inspection below the front doors where the frame is welded together it is also rusted through. While looking up recalls I found images and videos of other same generation F-150's that have the same problem. 1 video the entire bottom side of the frame from the engine to the front leaf spring mounts was rusted through. U-haul is aware of the issue and doesn't allow certain Ford vehicles to tow their trailers due to this issue. It's only a matter of time before the frames start breaking like the Toyota pickups and accidents start to come in.

When starting the truck the airbag light is illuminated and flashes.

AIRBAG LIGHT WITH CODE 34. BOTH BELT RETENTION HAVE BEEN REPLACED BUT HAS NOT FIXED IT.

This and many other trucks of this generation have major frame rot issues due to the box frame. The rest of my truck looks excellent but the frame is so bad its most likely not repairable. I am not the only one with this major safety issue. Its only a 16 year old truck. Thankfully I have not towed or put a large load in the bed or else it could split in half. I wash my car seasonally and pressure wash off rust every spring. Yet the frame has rotted so badly they could not put it on a lift to do the alignment. I love this truck and I'm a big fan of the f150 line as a whole. Ford should take responsibility as Toyota has and fix their customers frames from this generation. I love ford but its always interesting walking through a parking lot and seeing every 04-08 f150 with major frame rot. Without fail every single one has that issue. Seems to me like they didn't properly galvanize and protect the steel. I am now needing to do a bed off frame restoration since no shop will take it on. This truck that should be going for $5k with this insane used car market. (August 3rd 2020) yet it is max $200 in scrap. Bad / cheap engineering should not be the owners responsibility. Yet that is what it has come to. It was most likely an honest unforseen mistake on their part. Overengineering the rigidity but ignoring the long term effects. Short term strength for log term pain as is commonly said with these trucks. I'm sure in a few years time these will just start breaking in half over bumps o

The contact owns a 2005 Ford F-150. The contact stated while driving approximately 30 mph and depressing the brake pedal, the brake pedal traveled to the floor. The driver immediately turned the steering to avoid hitting several kids that were crossing the street. During the failure, the brake warning light illuminated. The cause of the failure was not yet determined. The local dealer was notified of the failure. The contact was informed that the part to replace the ABS module was no longer produced by the manufacturer and was therefore unavailable for a repair. The manufacturer was not notified of the failure. The failure mileage was 174,000.

I BOUGHT USED CASH TRUCK, DROVE FINE FOR FIRST DAY, SECOND DAY WHILE TRUCK WAS IN MOTION AND PUT IN REVERSE IT DIES, TOOK A COUPLE TURNS TO STARTED UP AND IT STARTED CODING THE CAMSAFT SENSORS, GOT CODES CLEARED, AND IT DROVE OK FOR 30 MINUTES COATED AGAIN STARTED TO STALL AND STUTTER A BIT. I HEARD A LOT ABOUT FORDS IN THE CAMSHAFT SENSORS DOES THAT MEAN MY TRUCK IS DONE FOR. MY TRUCK HAS TO CAMSHAFT SENSORS. 5.4

FRAME RUSTING TERRIBLY AND FRAME CRACKING NEAR DRIVERS SIDE FORWARD LEAF SPRING MOUNT. TRUCK HAS ONLY 128,000 MILES. DO NOT HAUL OR TOW ANY WHERE NEAR THE TRUCKS CAPACITY. NORMAL DRIVING AND MINOR OFF ROAD USE.

PURCHASED VEHICLE FEB 2021 FROM PRIVATE OWNER. TOOK VEHICLE IN FOR SERVICING. SERVICE DEPARTMENT INFORMED ME THAT THE OIL CHANGE COULD NOT BE COMPLETED, BECAUSE THEY WERE AFRAID TO PLACE THE VEHICLE ON THE LIFT DUE TO THE FACT THAT IT MIGHT SPLIT DUE TO THE FRAME BEING RUSTED COMPLETELY THROUGH. FURTHER, I WAS TOLD THAT THE VEHICLE WAS UNSAFE TO DRIVE DUE TO THE EXTENSIVE CORROSION OF THE FRAME ON BOTH THE PASSENGER AND DRIVER SIDE. I WAS INFORMED THAT AT ANY TIME, IF I HIT A BUMP OR WAS HIT FROM BEHIND, THE VEHICLE WOULD FOLD IN HALF. COMPLAINT ID #: ODI 11413329

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT HE LEARNED THAT HIS VEHICLE WAS SEVERELY RUSTED ON THE PASSENGER'S AND DRIVER'S SIDE OF THE VEHICLE. THE VEHICLE WAS RUSTED FROM THE MIDDLE OF THE VEHICLE TO THE REAR OF THE VEHICLE. THE CONTACT HAD TAKEN THE VEHICLE TO A CERTIFIED MECHANIC AS WELL AS TWO BODY SHOPS WHO STATED THAT THE ENTIRE SUBFRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 76,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE SEAT BELT FAILED TO LOCK INTO IT'S BUCKLE. THE BUCKLE FAILS TO ACTIVATE THE LOCK AND RELEASE THE SEAT BELT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH WHEN A VEHICLE SLIPPED ON ICE IN FRONT OF THEIR VEHICLE, IN ORDER TO AVOID CRASHING, THE CONTACT ENDED UP STEERING INTO A NEARBY DITCH CRASHING INTO TREES. THE SEAT BELT BUCKLE FAILED TO SECURE THE SEAT BELT CAUSING IT TO SWING AND HIT THE CONTACT. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS NOT TOWED. A POLICE REPORT WAS NOT FILED. THE CONTACT STATED THAT THE SEAT BELT CAUSED HIS TEETH TO BE FRACTURED AND MEDICAL ATTENTION WAS NEEDED. THE VEHICLE WAS TAKEN TO A CERTIFIED MECHANIC WHO HAD NOT DIAGNOSED ANYTHING REGARDING THE SEAT BELT AS OF YET. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,00.

COMPLETE FRAME UNDER TRUNK IS RUSTED TO WHERE THE FRAME IS GETTING READY TO BREAK IN HALF I HAVE LOOKED AT SEVERAL OTHER OF THE SAME MAKE AND MODEL AND THEY HAVE THE SAME SIMILAR PROBLEMS SO I'M NOT AS BAD AS OTHERS BUT 90% OF THEM ARE NOT SAFE TO DRIVE I LIVE IN THE AREA THERE'S NOT A LOT OF SALT NORE SAND IF THIS WAS A PROBLEM WITH JUST MY VEHICLE I WOULD UNDERSTAND BUT SINCE IT IS A PROBLEM WITH A LOT OF THESE TRUCKS SOMETHING NEEDS TO BE DONE BUY FORD MANUFACTURES.

SPARK PLUGS AND COIL PACK CONTINUE TO EJECT THEMSELVES FROM THE CYLINDER HEAD.(F150 BLOWN OUT SPARK PLUG). THIS CONTINUES TO BE A PROBLEM AND HAS OCCURRED WHILE THE CAR IS IN MOTION ON THE HWY., TRAVELING AT A SPEED OF ABOUT 30 MPH.

THE ENGINE TIMING SYSTEM FAILED CAUSING THE ENGINE TO STOP WITHOUT WARNING. THIS FAILURE OCCURRED ON A CITY STREET. A FELLOW WHO HELPED PUSH THE TRUCK TO THECURB MENTIONED THE TRITON ENGINE IS 'KNOWN FOR THIS PROBLEM'.

WENT TO HAVE TRUCK LINED UP AND WAS TOLD IT HAD RUSTED THE FRAME ALMOST INTO IN THE REAR. IN MORE THAN ONE PLACE.

ON DECEMBER 3, 2020 AT APPROXIMATELY 11:30 PM OUR 2005 F150 BURST INTO BLAMES FROM THE ENGINE AREA. THE VEHICLE HAD BEEN PARKED SINCE APPROXIMATELY 3:30 PM EARLIER THAT DAY IN OUR PERSONALLY DRIVE WAY. WITNESS STATED THAT THEY SAW THE FIRE START NEAR THE ENGINE AREA OF THE TRUCK.

FRAME OF TRUCK IS ROTTED AROUND LEAF SPRING AREAS AND UNDER CAB OF TRUCK AS WELL AS BED RAILS.

HAD VEHICLE TOWED TO A REPAIR GARAGE TO HAVE STARTER REPLACED.ACCORDING TO REPAIR TECH.WHILE LIFTING TRUCK A LOT OF CRACKING SOUND S INSPECTION OF FRAME REVILED EXCESSIVE RUSTING AND CRACKS .THEY CALLED AND TOLD ME TRUCK WAS UN SAFE TO USE.HAVE BILLS WITH STATEMENTS MADE BY REPAIR SHOP.

JUST PURCHASED VEHICLE AIR BAG LIGHT FLASHES AND TURNS ON WHEN DRIVING LOOKED INTO ISSUE. FOUND RECALL FOR AIRBAG THAT CAUSES THIS. RECALL 11S18B. CONTACTED FORD THEY SAID RECALL HAD NOT BEEN PERFORMED AND SET UP APPOINTMENT TO HAVE IT DONE. FORD COMPLETED RECALL. PICKED UP VEHICLE DROVE 1000 FEET AIRBAG LIGHT CAME BACK ON. TURNED AROUND AND INFORMED SERVICE DEPARTMENT. THEY TOLD ME THE RECALL HAS NOTHING TO SO WITH THE AIRBAG OR LIGHT AND THAT IF I PAY 100 THEY WILL DIAGNOSE VEHICLE. I INFORMED THEM THAT IT SHOWS RIGHT ON FOR THAT THE RECALL CAUSES LIGHT TO FLASH AND POSSIBLY AIRBAG TO DEPLOY. THEY TOLD ME IT DOES NOT AND I WAS WRONG AND SENT ME ON MY WAY