1996 Ford F-150

Defect. DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Defect. SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Defect. CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy. CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

Defect. CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy. PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Defect. ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

Risk. A FIRE AT THE SWITCH COULD OCCUR.

Remedy. BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)

Defect. THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Risk. INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .

Remedy. OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.

Defect. THE SEAT RECLINER TO SEAT FRAME ATTACHING BOLTS ON THESE VEHICLES COULD LOOSEN, FATIGUE AND FRACTURE, ALLOWING THE SEAT BACK TO SUDDENLY RECLINE.

Risk. IF THIS WERE TO OCCUR TO THE DRIVER'S SEAT, THIS COULD RESULT IN A SUDDEN LOSS OF VEHICLE CONTROL INCREASING THE RISK OF A VEHICLE ACCIDENT.

Remedy. DEALERS WILL REMOVE ALL FOAM AND/OR FABRIC SANDWICHED BETWEEN THE RECLINER ASSEMBLY AND THE SEAT FRAME, INSTALL WASHERS BETWEEN THE SEAT RECLINER AND THE SEAT FRAME AT EACH ATTACHMENT POINT, AND INSTALL NEW ATTACHING BOLTS TORQUED TO A HIGHER SPECIFICATION. THESE CORRECTIONS WILL BE MADE TO BOTH THE DRIVER'S AND PASSENGER'S SEATS.

Ea05-005 is closed with FORD?s actions in recalls 05v-017, 05v-388, and 06v-286, recalling approximately 6.7 million vehicles equipped with texas instruments speed control deactivation switches (scds).the brake systems in these recalled vehicles generate a vacuum that can potentially cause the scds to fail and, in certain switch installation orientations, catch fire.FORD is also including the entire population of 1998 explorers.FORD has informed odi that testing to determine the cause of failures in the 1998 explorers will continue after this investigation is closed.odi believes that the …

There is no summary currently available

AFTERMARKET WIRING ALTERATIONS - SERVICE TIP. *TT

A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. *TT

SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT

FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC

SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS

WIRING- AFTERMARKET WIRING ALTERATIONS- SERVICE TIP. *JD

The contact owned a 1996 Ford F-150. The contact received notification of NHTSA Campaign Number: 05V017000 (Vehicle Speed Control). The contact stated that while parked in the driveway, she observed fire between the finder and the hood. The heat from the fire rippled the front of the garage causing property damage. The vehicle was not diagnosed and the origin of the fire was not determined. The fire was extinguished by the fire department. The vehicle was towed to an unknown impound lot. It was unknown if a police report or fire department report was filed. The manufacturer was notified of the failure. The failure mileage was approximately 75,000.

The contact owns a 1996 Ford F-150. The contact stated that while driving at unknown speeds, the speedometer became inoperable. The driver was unable to accurately determine the speed. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 218,000.

I am unsure of what happened. This truck was sitting in my driveway and caught fire. While on fire it kept trying to start even though no one was in it and the keys were no where near it. The fire truck was called out due to the trucks proximity to the home and the fire was put out. There has not been any insoection done on the vehicle since it is burnt to a crisp.

The contact owns a 1996 Ford F-150. The contact stated while driving 45 MPH, the vehicle started to shutoff and restart independently. The check engine warning light was illuminated. The vehicle was diagnosed by an independent mechanic. The mechanic informed the contact that the rear tank’s fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that there was no open recall associated with the VIN for the failure. The failure mileage was approximately 130,000. The contact stated there is an issue with the front fuel tank feeding fuel into the rear tank when the rear tank pump is not operational and having to switch the fuel supply over to the front tank. When the rear tank is full from the front tank feed, it spills over out of the rear tank fill spout, and runs out on the ground.

The front fuel tank is overflowing when I run the vehicle with the rear tank. The return fuel is always to the front tank causing it to overflow its a hazardous situation.

The brake fluid pressure sensor is leaking on to the electrical main computer wires its also leaking from the electrical harness coming from the brake fluid pressure sensor causing the brake tail lights to fail intermittently during vehicle operation

TL* THE CONTACT OWNS A 1996 FORD F-150. THE CONTACT STATED THAT THE DRIVER'S SIDE SEAT BEAT ANCHOR RUSTED AND DETACHED RESULTING IN THE SEAT BELT DRAGGING ON THE GROUND. THE VEHICLE WAS NOT TAKEN TO THE LOCAL DEALER. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 151,000.

FUEL FROM REAR TANK FILLS FRONT TANK.IT CAN OVERFLOW CAUSING A FIRE.

ABOUT 10 YEARS AGO, KELLY FORD IN EMMAUS, PA REMOVED MY DRIVERS AIRBAG AND TOLD ME IT WOULD BE REPLACED. IT WAS NEVER REPLACED. KELLY SOLD THE DEALERSHIP AND I NEVER HEARD ANOTHER THING ABOUT IT.

A SMALL CHIP IN THE WINDSHIELD RESULTED IN A BIG CRACK AFTER THE WEATHERS TEMPERATURE DROPPED TO FREEZING.

I HAD TROUBLE TURNING THE IGNITION SWITCH WITH THE ORIGINAL KEY,WHEN THE POWER STEERING STOPPED WORKING AFTER MAYBE 2 YEARS SOMETHING BROKE IN THE STEERING COLUMN THAT CAUSED THE STEERING WHEEL TO FLOP AROUND AND A FEW YEARS AFTER THAT THE STEERING WHEEL BROKE OFF OF THE STEERING COLUMN.

TL* THE CONTACT OWNS A 1996 FORD F-150. THE CONTACT WAS NOTIFIED BY HIS MOTHER THAT THE VEHICLE WAS ON FIRE WHILE PARKED IN THE DRIVEWAY. THE CONTACT NOTICED FLAMES UNDER THE HOOD ON THE DRIVER'S SIDE NEAR THE WINDSHIELD. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. WHEN THE CONTACT OPENED THE HOOD, HE NOTICED THAT THE WIRING HARNESS, FUSE BOX, AND RELAY BOX WERE BURNED, AND THE MASTER BRAKE CYLINDER WAS COMPLETELY MELTED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). THE FIRE DEPARTMENT WAS NOT NOTIFIED. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

FUEL FLOWS OUT THE FRONT TANK WHEN USING THE REAR TANK AND THE FRONT ON IS FULL !! FOUND THIS WHEN PARKED IN MY GARAGE .

FUEL FROM THE FRONT TANK IS OVERFLOWING FUEL INTO THE REAR FUEL TANK AND VICE VERSA. THIS HAS BEEN HAPPENING FOR YEARS BUT NO ONE SEEMS TO KNOW HOW TO REPAIR OR WHAT IS CAUSING THE ISSUE.

TL* THE CONTACT OWNED A 1996 FORD F-150. THE CONTACT STATED THAT WHILE PARKED, THERE WAS AN ABNORMAL NOISE AND THE VEHICLE CAUGHT FIRE. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

FUEL KEEPS LEAKING FROM SECOND TANK SOMEWHERE TOWARDS THE OPENING.BEEN LIKE THIS SINCE THE DATE I HAVE REPORTED TILL NOW BUT NEVER THOUGHT MUCH ABOUT IT UNTIL REVIEWING CASE NHTSA ID NUMBER: [XXX] AND NHTSA REF # 10587059 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 1996 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS EQUIPPED WITH A DUAL FUEL TANK AND WHILE DRIVING VARIOUS SPEEDS, A STRONG ODOR OF GASOLINE EMITTED INSIDE AND OUTSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO STATED THAT THE FUEL RETURN CHECK VALVE WOULD NEED TO BE REPLACED BECAUSE THE FUEL FROM THE REAR FUEL TANK OVERFLOWED INTO THE SECOND FUEL TANK. IN ADDITION, FUEL HAD SEEPED OUT OF THE FUEL TANK CAP. THE VEHICLE WAS NOT REPAIRED. THERE WAS A RECALL ISSUED FOR 1990-1993 F-SERIES MODEL VEHICLES UNDER NHTSA CAMPAIGN ID NUMBER: 01I008000 (FUEL SYSTEM, GASOLINE) BUT NOT FOR THE 1996 MODEL YEARS. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. UPDATED 06/30/14 MA UPDATED 07/2/2014 *JS

TL* THE CONTACT OWNS A 1996 FORD F150. THE CONTACT STATED WAS DRIVING APPROXIMATELY 35 MPH AND LOST CONTROL OF THE STEERING, CRASHING INTO A TREE. THE AIR BAGS DID DEPLOY. HOWEVER, THE CONSUMER SUFFERED SEVERE INJURIES. THE CONTACT SUSTAINED A FRACTURED CERVICAL SPINE, INJURIES TO THE SHOULDERS, A CONCUSSION AND THE LOSS OF HER RIGHT EYE. THE VEHICLE WAS DESTROYED DURING THE CRASH. THE CONTACT INDICATED THAT AN INVESTIGATOR WITH THE DEPARTMENT OF TRANSPORTATION INSPECTED THE VEHICLE AND CONFIRMED THAT THE AIR BAG HAD VIOLENTLY DEPLOYED DURING THE CRASH AND CAUSED INJURIES TO THE CONTACT. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 110,000. UPDATED 06/04/14

ABOUT THREE MINUTES AFTER I PARKED AND SHUT OFF THE TRUCK IN THE DRIVEWAY, I HEARD A LOUD EXPLOSION, STEPPED OUTSIDE AND SAW FLAMES SHOOTING OUT FROM UNDER THE HOOD ACCOMPANIED BY BILLOWING SMOKE. THE FIRE LASTED 15-20 MINUTES, WENT THROUGH THE FIREWALL, ENTERED AND MELTED DOWN THE CAB. DURING THIS PERIOD OF TIME, I WAS ATTEMPTING TO PUT OUT THE FIRE IN ORDER TO PREVENT IT FROM SPREADING TO THE GARAGE AND THE PROPANE TANK. AS A RESULT, I HAD TO BE TREATED FOR MODERATE SMOKE INHALATION BY THE FIRST RESPONDERS ON THE SCENE. THE TRUCK WAS PART OF THE 2005 RECALL CONCERNING THE LEAKING BRAKE FLUID AND ITS CORROSION OF THE ELECTRICAL SYSTEMS. I BROUGHT THIS TRUCK TO COPPER COUNTRY FORD IN ORDER FOR THEM TO PERFORM THE NECESSARY REPAIRS TO COMPLY WITH THE RECALL NOTICE, WHICH, TO THE BEST OF MY KNOWLEDGE, WAS PERFORMED. *TR

TL* THE CONTACT OWNS A 1996 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, HE LOST CONTROL OF THE VEHICLE AND CRASHED INTO A TREE. THE AIR BAGS DEPLOYED VIOLENTLY, FRACTURING THE DRIVER'S NECK AND CAUSING PARTICLES FROM THE BAG TO BECOME LODGED IN HIS EYE. AS A RESULT, THE CONTACT WAS PERMANENTLY BLIND. THE AIR BAG ALSO SHATTERED THE DRIVER'S SHOULDER AND CAUSED VARIOUS OTHER INJURIES. THE VEHICLE WAS DESTROYED. THE MANUFACTURER SENT AN INSPECTOR TO DIAGNOSIS THE FAILURE BUT NO REPORT WAS PROVIDED TO THE CONTACT. THE FAILURE AND CURRENT MILEAGE WAS 100,000. UPDATED 1/29/13 *CN UPDATED 2/8/2013 *JS UPDATED 04/14/14*LJ UPDATED 04/18/2014 *JS

TL* THE CONTACT OWNS A 1996 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 58 MPH, THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING. THE CONTACT WAS ABLE TO KEEP THE VEHICLE UNDER CONTROL AND COASTED ONTO THE ROAD SHOULDER. THE CONTACT INSPECTED THE VEHICLE AND DETERMINED THAT THE THROTTLE FAILED. THE CONTACT CLEANED THE THROTTLE AREA AND DISCONNECTED THE CRUISE CABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 195,000.

TL* THE CONTACT OWNS A 1996 FORD F-150. THE CONTACT NOTICED FUEL LEAKING FROM THE FILLER CAP. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE FUEL FROM THE REAR FUEL TANK WAS SPILLING INTO THE FRONT FUEL TANK, CAUSING IT TO OVERFLOW AND LEAK. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.

TL* THE CONTACT OWNS A 1996 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 20 MPH THE FUEL TANK DETACHED FROM THE VEHICLE. APPROXIMATELY 3 GALLONS OF FUEL SPILLED OUT OF THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO ADVISED HIM THAT BOTH STRAPS WERE SEVERELY COVERED WITH RUST AND NEEDED TO BE REPLACED ALONG WITH THE FUEL TANK. BOTH STRAPS AND THE FUEL TANK WERE REPAIRED. THE MANUFACTURER WAS CONTACTED REGARDING THE FAILURE AND STATED HIS VIN WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE MILEAGE WAS APPROXIMATELY 122,700.

PRIMARY FUEL TANK STRAPS BROKEN, TANK RESTING ON SKID PLATE. SECONDARY FUEL TANK STRAPS CORRODING. *TR

TL* THE CONTACT OWNS A 1998 FORD F-150. WHILE THE VEHICLE WAS PARKED THE CONTACT NOTICED FUEL LEAKING FROM THE FUEL TANK. THERE WAS A NHTSA RECALL CAMPAIGN ID NUMBER: 98V161000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY) THAT MAY BE RELATED TO THE FAILURE. THE DEALER WAS MADE AWARE OF THE FAILURE AND STATED THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 1996 FORD F150. THE CONTACT STATED THAT THE FRONT FUEL TANK STRAP WAS CORRODED AND CAUSED A LEAK IN THE FUEL TANK. HE TOOK THE VEHICLE TO A LOCAL MECHANIC WHO REPAIRED THE STRAP BUT DID NOT REMEDY THE ISSUE WITH THE FUEL LEAK. THE CONTACT THEN SWITCHED TO USING THE REAR FUEL TANK, IN WHICH HE SOON DISCOVERED THAT THE THERE WAS ALSO A LEAK COMING FROM THE REAR TANK. THE MANUFACTURER WAS CONTACT WHO STATED THAT THERE WERE NO RECALLS FOR THE FAILURE AND OFFERED NO FURTHER ASSISTANCE. THE CONTACT PROCEEDED TO FILE A CLAIM WITH THE MANUFACTURER. THE FAILURE MILEAGE WAS 92,000.

TL*THE CONTACT OWNS A 1996 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH HE HEARD A FLAPPING NOISE FROM AN UNKNOWN LOCATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THE REAR PASSENGER SIDE WHEEL WAS CRACKED AND CORRODED. A BRAND NEW WHEEL WAS INSTALLED ON THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 238,357.

TL* THE CONTACT OWNS A 1996 FORD F-150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 05V388000 (VEHICLE SPEED CONTROL) AND THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS. FOUR YEARS LATER, THE NEW PARTS THAT WERE PLACED ON THE VEHICLE UNDER THE RECALL BEGAN TO OVERHEAT AND SMOKE WHENEVER THE VEHICLE WAS PARKED. THE VEHICLE HAD NOT BEEN INSPECTED BY A DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 167,000. UPDATED 06/01/11*LJ UPDATED 1/18/2012 *LN THE CONSUMER STATED THE CONTROL VALVE WAS REPLACED ON 4/26/11

TL*THE CONTACT OWNS A 1996 FORD F150. THE CONTACT STATED THAT FUEL WAS FLOWING FROM THE REAR FUEL PUMP AND INTO THE FRONT FUEL PUMP, CAUSING AN OVERFLOW AND ABNORMAL LEAKAGE. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THE CONTACT THAT SOMEONE WOULD RETURN HIS CALL BUT TO NO AVAIL. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AT THE FRONT FUEL PUMP CHECK VALVE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 83,553.

TL*THE CONTACT OWNS 1996 FORD F150. THE CONTACT ATTEMPTED TO START THE VEHICLE AND IT WOULD NOT START; HOWEVER, AFTER SWITCHING TO THE REAR FUEL TANK THE VEHICLE STARTED. THE FRONT FUEL TANK HAD APPROXIMATELY A HALF TANK OF FUEL IN IT AT THE TIME. THE CONTACT NOTICED THAT THE FUEL WAS LEAKING IN THE FRONT FUEL TANK. THE FUEL WAS OVERFLOWING FROM THE BACK TO THE FRONT FUEL TANK CAUSING A LEAK AND A FUEL ODOR. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR TO BE REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 1996 FORD F150. THE CONTACT WAS SITTING IN THE DRIVERS SEAT WITH THE VEHICLE PARKED WHEN THE AIR BAG EXPLODED WITHOUT WARNING. THE CONTACT SUSTAINED INJURIES TO THE EAR AND CHEST. THE VEHICLE WAS TAKEN TO THE DEALER WHO INSPECTED AND FOUND NO TANGIBLE REASON FOR THE AIR BAG EXPLOSION BUT THEY ADVISED THAT THEY WERE UNABLE TO REPLACE IT. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THERE WAS NO EVIDENCE OF THE EXPLOSION AND THEY WERE UNABLE TO PROVIDE ANY ASSISTANCE. THE FAILURE MILEAGE WAS 150,000.

I OWN A 1996 FORD F150 WITH DUAL TANKS. I HAVE A PROBLEM WITH THE BACK FUEL TANK TRANSFERRING GAS TO THE FRONT TANK. IF UNNOTICED THIS WILL CAUSE GAS TO OVERFLOW ONTO THE GROUND CAUSING A REAL SAFETY AND POLLUTION HAZARD. I CALLED FORD AND THEY SAID THAT THERE WASN'T ANY RECALL FOR THIS PROBLEM ON MY VIN. WELL EVEN IF THERE ISN'T A RECALL FOR THIS PROBLEM OR NOT IT IS STILL A PROBLEM AND THERE WAS A RECALL FOR THIS PROBLEM ON THE 1990 TP 1993 F150 SO I'M FIGURING THAT THEY STILL HAVE THE PROBLEM ON MY VEHICLE ALSO. *TR

TL*THE CONTACT OWNS A 1996 FORD F150. THE VEHICLE WAS EQUIPPED WITH MICHELIN TIRES, AND THE TIRE SIZE WAS P235/75/15(NA). WHILE THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH THE REAR PASSENGER TIRE EXPLODED. THE VEHICLE WAS DRIVEN TO THE SIDE OF THE ROAD WITH CAUTION. THE TIRE WAS REPLACED WITH THE SPARE TIRE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE SPARE WAS REPLACED WITH A NEW TIRE. THE FAILURE MILEAGE WAS 160,000. THE DOT NUMBER AND VIN WERE UNAVAILABLE.

1996 FORD F-150 TRUCK BURST INTO FLAMES WHILE IT WAS TURNED OFF AND WAS SITTING FOR 5 DAYS. FIRE INSPECTOR DETERMINED THE ORIGIN OF FIRE WAS AT THE MASTER SOLENOID OF THE BRAKE SYSTEM. THE CRUISE CONTROL, WHICH HAD STOPPED WORKING ONE WEEK PRIOR TO THE EVENT, RESTS ON THE MASTER BRAKE SOLENOID.. THE CRUISE CONTROL HAS BEEN RECALLED ON THIS VEHICLE. THE OWNER HAD NOT RECEIVED A RECALL FROM THE FORD COMPANY. THE TRUCK IS A TOTAL LOSS WITH BOTH ENGINE AND CAB COMPLETELY ENGULFED IN FLAMES. THE HOUSE THAT WAS APPROX. FIVE FEET AWAY WAS DAMAGED. *TR

WAS ON MY WAY HOME FROM THE STORE AND THE SPARK PLUG IN MY 1996 FORD 150 BLEW OUT, DAMAGED THE COIL AND SRTIPED OUT SPARK PLUG THREADS ON THE HEAD. FORD SAYS NO RECALL IN PROCESS OF TRYNG TO GET IT FIXED I UNDERSATAND THERE HAVE BEEN NUMEROUS COMPLAINTS ABOUT THIS AND NO ACTION HAS BEEN TAKEN..

BOUGHT A SET OF TIRES. AT 17,160 MILES HAD A BLOW. TOOK BACK TO DEALER HAD TO BUY A NEW TIRE. AT 19,000 MILES HAD ANOTHER TIRE SEPARATED. HAD TO BUY ANEW TIRE. AT 20,000 MILES HAD TIRE BLOW OUT. HAD TO BUY A NEW TIRE. AT 26,000 HAD ANOTHER BLOW OUT AT 65MPH. DID NOT WRECK. BUT WENT TO DITCH . DEALER REFUSES TO DO ANY THING ABOUT THIS. WHAT CAN I DO. *TR

EARLY ONE EVENING ABOUT 8:00PM A DRIVER IN AN NON-KNOWLEDGEABLE AREA IS TRYING TO FIND HIS WAY BY LOOKING AT STREET SIGNS AND ADDRESSES. CAN'T SEE SAFELY ENOUGH TO SAFELY MANEUVER HIS VEHICLE THROUGH OUT THE CITY. THE POPULATION IS AT RISK, HIS SIGHT IS IMPAIRED BY THE VIEW THROUGH HIS DULL, FUZZY LIGHTS. THIS HAS BEEN A SITUATION DUE TO NEGLECT, THE LAW DOESN'T CONFRONT THE SITUATION AND HAVE IT CORRECTED, WHY? *TR

TL* THE CONTACT OWNS A 1996 FORD F-150. SHE NOTICED THAT THERE WERE FIRE BALLS UNDER THE VEHICLE, NEAR THE FRONT DRIVER SIDE WHEEL AND FLOOR BOARD. THE FIRE DEPARTMENT WAS NOT NOTIFIED. THERE WERE NO INJURIES. PRIOR TO THE FAILURE, THE ABS LIGHT FUSE WAS REPLACED CONTINUOSLY. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 140000.

TL*THE CONTACT OWNS A 1996 FORD F-150. WHENEVER THE CONTACT WOULD ATTEMPT TO STOP THE VEHICLE, IT WOULD TURN OFF AND FAIL TO RESTART. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE FUEL PRESSURE REGULATOR NEEDED TO BE REPLACED. THE CONTACT ALSO NOTICED THAT THE SECOND FUEL TANK WAS TRANSFERRING FUEL TO THE FIRST FUEL TANK. THERE WERE NO WARNINGS PRIOR TO THE FAILURES. THE CURRENT AND FAILURE MILEAGES WERE 104,000.

TL*THE CONTACT OWNS A 1996 FORD F-150. THE CONTACT STATED THAT THE VEHICLE BEGAN ROLLING AFTER BEING PARKED FOR APPROXIMATELY FOUR MINUTES. THE VEHICLE CRASHED INTO A DITCH, WHICH CAUSED MODERATE VEHICLE DAMAGE. THERE WERE NO INJURIES. THE MANUFACTURER STATED THAT THEY WOULD NOT ASSUME ANY RESPONSIBILITY FOR THE FAILURE BECAUSE THERE WAS NO RECALL. THE VEHICLE IS IN THE PROCESS OF BEING REPAIRED. THE CONTACT HAS A COPY OF THE POLICE REPORT. THE FAILURE AND CURRENT MILEAGES WERE 187,000. UPDATED 04/21/09. *LJ THE CONSUMER STATED THE VEHICLE JUMPED OUT OF GEAR. THE VEHICLE WAS IN IDLE AND RUNNING. UPDATED 04/21/09.*JB

TL*THE CONTACT OWNS A 1996 FORD F150. SPORADICALLY, THE HEADLIGHTS WOULD FLICKER ON AND OFF ACCOMPANIED BY A BURNING ODOR. THE CONTACT INSTALLED A HEAD LAMP SWITCH, BUT THE FAILURE RECURRED TWO YEARS LATER. HE CALLED THE MANUFACTURER IN REFERENCE TO NHTSA CAMPAIGN ID NUMBER 99V024000 (EXTERIOR LIGHTING:HEADLIGHTS:SWITCH). THE REPRESENTATIVE FROM THE MANUFACTURER STATED THAT BECAUSE HIS MODEL'S BODY STYLE WAS NOT INCLUDED IN THE RECALL, THEY WOULD NOT ASSUME RESPONSIBILITY FOR ANY REPAIRS. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 90,000 AND CURRENT MILEAGE WAS 98,000.

A FIRE OCCURRED UNDER THE HOOD OF OUR 1996 FORD F-150, DESTROYING THE WHOLE FRONT END AND INTO THE CAB. TRUCK IS A TOTAL LOSS. NO ONE WAS HURT, AND IT WAS PARKED ON MY JOB PARKING LOT, AWAY FROM ANY CLOSE VEHICLES. I HAD JUST DRIVEN TO WORK. I ARRIVED TO WORK AS A SECURITY OFFICER AT 11:20P.M. AND AT 12:50A.M. THE TRUCK WAS IN FLAMES. WE BOUGHT IT USED IN MARCH 2008 AND HAD NEVER HEARD OF ANY RECALLS OR ANY DEFECTS. IT WAS A VERY CLEAN, WELL KEPT TRUCK. WE RECEIVED ONE RECALL NOTICE IN LATE NOVEMBER EARLY DECEMBER 2008(DURING HOLIDAYS) ABOUT A SPEED CONTROL SWITCH. THE LETTER STATED THAT THE VEHICLE COULD IGNITE AT ANY TIME. IT GAVE NO WARNING SIGNS TO LOOK FOR AND STATED IF WE COULD NOT GET IT IN RIGHT AWAY TO PARK IT AWAY FROM ANY DWELLINGS. MY HUSBAND IS DISABLED, HE COULDN'T JUST RUN DOWN THERE, AND IT WAS THE HOLIDAYS AS WELL. I LOOKED UP THE RECALL ONLINE AFTER THE FIRE, AND IT STATED THE POTENTIAL FOR A FIRE WAS SMALL, AND IT GAVE WARNING SIGNS TO LOOK FOR ON THE VEHICLE. WHY WEREN'T THOSE WARNINGS EXPLAINED IN THE RECALL NOTICE?? TO OUR KNOWLEDGE, THE TRUCK WAS 12 YEARS OLD AND RAN LIKE A NEW ONE. HOW COULD IT HAVE BEEN OVER-LOOKED ALL THOSE YEARS? THIS WAS DEVASTATING TO US, IT COULD HAVE BEEN MUCH WORSE AND KILLED SOMEONE. THE TRUCK WAS 3/4 FULL OF FUEL. *TR

TL*THE CONTACT OWNS A 1996 FORD F-150. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 05V388000 (VEHICLE SPEED CONTROL). HE TOOK THE VEHICLE TO THE DEALER, BUT THEY DID NOT HAVE THE PART TO PERFORM THE RECALL REPAIR. THEY DID NOT KNOW WHEN THE PART WOULD BE AVAILABLE AND COULD NOT PROVIDE MUCH INFORMATION. A FEW DAYS LATER, THE VEHICLE CAUGHT FIRE. THE FIRE AND POLICE DEPARTMENTS WERE CALLED TO THE SCENE. THE VEHICLE WAS DESTROYED. THE VEHICLE WAS TOWED TO A YARD. THE FAILURE AND CURRENT MILEAGES WERE 170,000.

TL*THE CONTACT OWNS A 1996 FORD F150. THE CONTACT STATED THAT THE CLUTCH WOULD NOT RELEASE WHEN THE SLAVE CYLINDER DEVELOPED A LEAK. HE PULLED UP TO AN INTERSECTION AND DEPRESSED THE CLUTCH PEDAL, BUT THE VEHICLE CONTINUED TO MOVE. HE KEPT DEPRESSING THE PEDAL, BUT IT WOULD NOT RELEASE; THEREFORE, HE APPLIED THE BRAKES AND TURNED OFF THE ENGINE SIMULTANEOUSLY TO PREVENT A CRASH. THE SAME FAILURE RECURRED THE FOLLOWING DAY SO THE CONTACT STOPPED DRIVING THE VEHICLE. THROUGH ONLINE RESEARCH, HE NOTICED THAT MANY OTHER CONSUMERS EXPERIENCED THE SAME ISSUE. THE MANUFACTURER AND DEALER HAVE NOT BEEN NOTIFIED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 140,000. UPDATE 12/16/08 *CN UPDATED 12/18/08. *JB

THE CRUISE WAS NOT WORKING IN OUR 1996 FORD PICKUP. WE HAD DROVE IT THAT NIGHT AND HAD GOTTEN HOME ABOUT 10:00 P.M. AND ABOUT 3:00A.M. WE HEARD A LOUD BANG. THE GARAGE WAS ON FIRE. WE REPORTED IT TO FORD MOTOR CO. WITH NO RESPONSE FROM THEM, EXCEPT WE THEN RECEIVED A RECALL NOTICE. *TR

1996 FORD F150 4 X 4-BOTH REAR BRACKETS CONNECTING THE LEAF SPRINGS (REAR OF VEHICLE) TO THE FRAME WERE TERRIBLE CORRODED AND CRACKED. MECHANIC WAS FEARFUL OF FAILURE WITHIN A MONTH OR TWO. REPLACEMENT PARTS ARE ONLY AVAILABLE FROM A FORD DEALERSHIP. CALLED LOCAL DEALERSHIP AND WAS ASSURED PARTS AVAILABLE. UPON ARRIVAL AT THE DEALERSHIP, NOT ALL PARTS AVAILABLE AS DEMAND HAD BEEN SO GREAT THEY KEPT RUNNING OUT OF THE PARTS. I HAD TO GO TO A DIFFERENT DEALERSHIP TO OBTAIN THE REST OF THE PARTS. THE REPLACEMENT PARTS WERE OF SIGNIFICANTLY HEAVIER BUILD THAN ORIGINAL PARTS. HAVE SINCE BEEN INFORMED BY MY MECHANIC AND OTHERS THAT MID 90S FORD 150S AND EXPLORERS ARE LOSING THE BRACKETS EN MASSE. I CONSIDER THIS A SIGNIFICANT SAFETY ISSUE AS AN IMPORTANT CHASIS COMPONENT IS MORE THAN LIKELY TO FAIL. THESE OLDER TRUCKS ARE NOW BEING HANDED DOWN TO HIGH SCHOOL KIDS. A FAILURE AT HIGHWAY SPEEDS WILL SURELY LEAD TO INEXPERIENCED DRIVERS PANICKING AND OVER CORRECTING AT THE TIME OF FAILURE. THERE WAS NO ACCIDENT, BUT BASED ON THE DEMAND AT A SINGLE DEALERSHIP (I WAS TOLD AT THE PARTS DEPARTMENT THAT THEY HAD RECEIVED 12 REQUEST FOR THE VERY SAME PART IN ONE DAY. ALL REQUESTS WERE FOR EITHER 1996 F150S OR 1996 EXPLORERS). I CONSIDER THAT STATISTICALLY SIGNIFICANT AND WISHED TO BRING IT TO YOUR ATTENTION. THANK YOU. *TR

MY FORD F-150 PICKUP TRUCK CAUGHT FIRE AFTER IT HAD BEEN PARKED FOR APPROXIMATELY TWO HOURS. THE FIRE APPEARS TO HAVE ORIGINATED IN THE ENGINE COMPARTMENT NEAR THE MASTER CYLINDER. THE DAMAGE WAS SEVERE AND IF NOT FOR A VIGILANT NEIGHBOR, WOULD HAVE SPREAD TO MY HOUSE. *TR

1996 FORD F150 PICKUP. BURNED UP SETTING IN DRIVEWAY. *TR

TL*THE CONTACT OWNS A 1996 FORD F150. THE CONTACT STATED THAT SHE HAS BEEN WAITING TWO YEARS FOR FORD TO REPAIR THE CRUISE CONTROL ON HER VEHICLE. NHTSA CAMPAIGN ID NUMBER 05V388000 (VEHICLE SPEED CONTROL) WAS ISSUED IN 2005 AND THE CONTACT HAD THE CRUISE CONTROL DEACTIVATED IN MAY OF 2006. SHE CALLED FORD SEVERAL TIMES TO FIND OUT WHEN THE PARTS WOULD BE AVAILABLE FOR THE RECALL REPAIR. THE DEALER KEEPS PROVIDING DIFFERENT DATES AND THE PARTS ARE STILL UNAVAILABLE. WHEN THE CONTACT WAS RECENTLY INFORMED THAT HER LOCAL DEALER DID NOT HAVE THE PARTS, FORD PROMPTED HER TO CONSULT OTHER DEALERS; HOWEVER, NONE WERE IN CLOSE PROXIMITY. THERE HAD BEEN NO FAILURE TO DATE. THE PURCHASE DATE AND POWERTRAIN WERE UNKNOWN. THE CURRENT MILEAGE WAS 140,000.

TL*THE CONTACT OWNS A 1996 FORD F150. WHILE DRIVING 2 MPH, THE STEERING WHEEL LOCKED AND WOULD NOT TURN. THE CONTACT HAD TO USE EXCESSIVE FORCE IN ORDER FOR THE STEERING WHEEL TO TURN. THE DEALER STATED THAT THE STEERING COLUMN FAILED AND THEY REBUILT THE STEERING COLUMN. APPROXIMATELY THREE YEARS LATER, THE FAILURE RECURRED. AS OF NOVEMBER 30, 2007, THE DEALER HAD NOT INSPECTED THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 179,000. UPDATED 12/18/07 *TR