2005 Ford F-150 complaints

WHILE DRIVING 75 ON A TOLL ROAD THE ENGINE WENT INTO ENGINE FAIL SAFE MODE, I LOST ALL POWER AND ALMOST WRECKED INTO ONCOMING TRAFFIC TRYING TO GET TO THE SHOULDER, I WENT TO A MECHANIC AND THEY REPLACED THE THROTTLE BODY, 3 DAYS LATER SAME THING, I WAS TOLD THIS IS A COMMON PROBLEM ON THIS MOTOR 5.4, WHY IS THERE NOT A RECALL ON THIS ??

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 65 MPH, THE SUN ROOF SHATTERED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 141,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 60 MPH, THE SUN ROOF SHATTERED. THE VEHICLE WAS TAKEN TO THE AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 141,740.

5.4 3V TRITON. WHEN THE TRUCK IS AT IDLE AT A NORMAL OPERATING TEMP, IT HAS A HORRIBLE KNOCKING NOISE ON THE PASSENGER SIDE OF THE ENGINE. FROM WHAT I AM READING THIS ENGINE HAS MAJOR PROBLEMS WITH THE CAM PHASERS AND TIMING COMPONENTS. IT SOUNDS LIKE THE TIMING CHAIN IS ABOUT TO FLY OUT OF THE ENGINE. I HOPE MY TRUCK DOESN'T GIVE OUT ON ME BECAUSE THIS IS MY ONLY TRANSPORTATION TO WORK AND CANNOT AFFORD TO HAVE IT FIXED. I BOUGHT A FORD FOR RELIABILITY, BUT UNTIL THIS IS FIXED I FEEL IT'S UNRELIABLE. I HAVE USED A FULL SYN OIL AND THE RIGHT MOTORCRAFT 820S FILTER. THIS IS A MAJOR PROBLEM AND FORD NEEDS TO PAY FOR THIS AND EVERYONE ELSE WHO HAS HAD THIS PROBLEM OVER AND OVER! RECALL THIS FORD!

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE REVERSING AT 50 MPH, THE VEHICLE ACCELERATED ON ITS OWN AND CRASHED INTO THE FRONT OF ONE VEHICLE AND THE DRIVER'S SIDE OF ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED FROM THE CRASH SCENE TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 78,000.

TRUCK BEGAN TICKING VERY LOUDLY, THEN BEGAN A KNOCKING NOISE, AND NOW THE ENGINE SHAKES THE TRUCK WHEN IDLING. CAM PHASERS BROKE APART CAUSING DAMAGE TO THE TIMING CHAIN. SUDDEN LOSS OF POWER TO THE ENGINE AS WELL AS INABILITY TO MAINTAIN SPEED WHILE ASCENDING AN INCLINE IS FREQUENT. THE LOSS OF SPEED AND POWER HAS CAUSED US SEVERAL CLOSE-CALL ACCIDENTS. TRUCK WILL SIMPLY NOT ACCELERATE WHILE PRESSING THE GAS PEDAL. ADDITIONALLY, IT ALSO FEELS LIKE THE TRUCK CANNOT CATCH GEARS WHILE IN MOTION.

!. VACUUM ADVANCE CONTROL FOR FOUR WHEEL DRIVE GETS WET, LOOSES PRESSURE AND FRONT WHEELS ENGAGE SLIGHTLY, CAUSING WHEEL HUB DAMAGE. 2. STEERING BECOMES HARD, ESPECIALLY IN COLD WEATHER. HARD TO INSPECT STEERING SHAFT UNTIL IT IS DISCONNECTED FROM STEERING RACK. COMMON PROBLEM WITH MID TO LATE 2000'S FORD CROWN VIC. POLICE VEHICLES. COME ON FORD, MAN UP AND MAKE THESE PROBLEMS A RECALL.

MY F150 FRAME IS RUSTED THROUGH WHERE IT ACTUALLY BROKE I WORK AS A WELDER AND I HAVE FIXED 3 DIFFRANT TRUCKS F150 AROUND THE SAME YEAR IT IS MOSTLY ON DRIVERS SIDE.

I WAS DRIVING THROUGH THE COUNTRY, AND SOMETHING FELT ODD. AT APPROXIMATELY 45 MPH, THE TRUCK STARTED TO SHAKE, (MORE THAN NORMAL) AND WAS THEN VANISH AFTER 55 MPH. AFTER THE NEXT FEW DAYS, THE SHAKING GOT WORSE. MY FIRST THOUGHT, "I HAVE A MISFIRE ON ONE OF MY CYLINDERS". ON MY WAY HOME FROM WORK MY TRUCK THROUGH A CHECK ENGINE LIGHT. I THEN PROCEEDED TO TAKE IT TO MY DEALER BECAUSE AT THIS POINT IT WOULD BARELY GO OVER 40 MPH. THEY CHECKED THE CODE AND TURNS OUT THAT THE TRUCK HAS A NUMBER OF PROBLEMS; THAT WHAT I HAVE SEEN ON THIS WEBSITE ARE A VERY COMMON ISSUE WITH THIS YEAR AND ENGINE TYPE (5.4L V8 TRITTON). I NEED NEW VCT SOLENOIDS, NEW CAMPHASERS, TIMING ADJUSTMENTS, AND NEW CAM SHAFT POSITION SENSORS. TO MAKE A LONG STORY SHORT, THE COMMON PROBLEM THAT HAPPENS TO THIS ENGINE, HAPPENED YET AGAIN. BAD CAM PHASERS. HAPPENED AROUND 138,4XX MILES. NOT SURE IF ANY PREVIOUS OWNER REPLACED THIS PART BEFORE OR NOT. BUT, IT SEEMS EVEN IF REPLACED, THE PROBLEM WILL STILL PERSIST IN THE FUTURE. THIS IS IN NEED OF RECALL.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE STATED WHILE DRIVING, THERE WAS AN ABNORMAL KNOCKING NOISE COMING FROM THE ENGINE. THE CONTACT STATED HE DROVE THE VEHICLE TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE CAM PHASER, THE BEARING AND THE TIMING CHAIN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT MENTIONED THAT THE VEHICLE WAS BACKFIRING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 40 MPH, THE DRIVER SIDE AIR BAG LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 190,000.

FUSE 14 CONTROLLING ABS MODULE, DTR SENSOR, REVERSE LIGHTS, PCV HEATER, AIR CONDITIONER COMPRESSOR, CRUISE CONTROL DEACTIVATOR SWITCH AND DAYTIME HEADLIGHTS WAS REPEATEDLY BLOWING. TRUCK WAS SERVICED BY DEALER ON 3-23-16, REPLACING THE A/C COMPRESSOR. REPLACING THE A/C COMPRESSOR DID NOT RESOLVE ANY ISSUES. THE TRUCK WAS RETURNED TO THE DEALER ON 4-6-16 FOR THE SAME ISSUE WITH THE SAME FUSE. THE DEALERSHIP REPLACED THE FUSE AND PERFORMED DIAGNOSTIC TESTS ON THE TRUCK, THEN INFORMING ME THAT THEY COULD NOT DIAGNOSE OR LOCATE THE SHORT. THE DEALERSHIP INFORMED ME THAT I WOULD HAVE TO DRIVE THE TRUCK UNTIL THE FUSE STARTED BLOWING MORE FREQUENTLY. THE FIRST TIME THE TRUCK WAS DRIVEN AFTER WORK WAS PERFORMED THE CRUISE CONTROL WAS NOT FUNCTIONING PROPERLY. THE TRUCK ENGINE WOULD SURGE AS THE TRUCK WENT DOWN THE ROAD WITH THE CRUISE CONTROL ON. THE ISSUE WITH THE CRUISE CONTROL HAPPENED ON 4-9-16. ON THE MORNING OF 4-10-16 THE TRUCK WAS DRIVEN APPROXIMATELY 4 MILES AND PARKED IN THE DRIVE OF MY HOME. AFTER ENTERING THE HOUSE THE ALARM WAS HEARD SOUNDING ON THE VEHICLE, AT WHICH TIME I STEPPED OUTSIDE TO FIND THE TRUCK ON FIRE. THE FIRE SEEMED TO HAVE STARTED ON THE INSIDE OF THE TRUCK.

INSIDE OF TIRE SIDEWALL SUDDENLY CRACKED OPEN LEADING TO RAPID PRESSURE LOSS. THIS SAME TIRE HAS BEEN RECALLED IN OTHER SIZES FOR THIS SAME FAILURE.

I DRIVE A 2005 5.4 TRITON AND AFTER 110000 MILES THE ENGINE HAS DIED. THE MECHANIC STATES ITS THE CAM PHASER AND I'VE SEEN SEVERAL WEBSITES COMPLAINING THE SAME ISSUE.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE SHIFTING INTO REVERSE, THE FRONT DRIVER SIDE AND REAR LOWER CONTROL ARM FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE PASSENGER SIDE LOWER CONTROL ARM AND THE SWAY BAR LINKS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 167,050.

PURCHASED MY VEHICLE USED AT THE DEALERSHIP WITH 85,000. WHICH IS TYPICALLY A GOOD BREAK-IN POINT FOR A TRUCK. WELL AFTER HAVING THE VEHICLE HOME FOR LESS THAN A MONTH I'VE NOTICED A TICKING IN THE ENGINE. A TICKING THAT I KNEW LITTLE ABOUT UNTIL FURTHER RESEARCH INTO THESE VEHICLES. SEEMS THAT ALONG WITH THOUSANDS OF OTHER PEOPLE IN THE WORLD I'VE PURCHASED A FORD LEMON. THE ENGINES RARELY MAKE IT PAST 75,000-100,000. FORD AS A WHOLE ARE AWARE OF THIS ISSUE AND DELIBERATELY FIND WAYS AROUND HAVING TO TAKE THE LIABILITY ON. THE ONLY SOLUTION TO THE TICKING IS 1,500 IN REPAIRS OF THE CAM PHASER, WHICH IN A TIMELY MANNER MELTS LIKE BUTTER OR REPLACE IT WITH A REMANUFACTURED ENGINE ONLY TO ENCOUNTER THE SAME ISSUE. WHETHER OR NOT THIS VEHICLE IS OVER 10 YEARS OLD THIS IS AN ISSUE THAT NEEDS TO BE ADDRESSED. AN ENGINE SHOULD BE ABLE TO LAST MORE THAN 100,000 MILES. I HAVE DRIVEN THIS VEHICLE LESS THAN 500 MILES AND THE PROBLEM IS EVIDENT.

STEERING GETS VERY HARD TO TURN. HAVE TO "MUSCLE" THE STEERING BACK AFTER A TURN. POWER STEERING RACK FAILED. FORD MOTOR CO. HAS A NATIONAL BACK ORDER ON REPLACEMENT PARTS. I THINK THERE'S A PROBLEM.

MY TRUCK HAS A KNOWN ISSUE WITH THE 5.4L'S CAM PHASERS. THE TRUCK MAKES A VERY LOUD NOISE AND SHAKES. TO REPAIR THIS, IT'S AROUND $3,000 AND ALSO I HAVE A KNOWN ISSUE WITH ALL 8 COILS WHICH HAD TO BE REPLACED FOR $1,200 AND A KNOWN MISFIRE. I DO NOT UNDERSTAND WHY FORD MOTOR IS AWARE OF THE ONGOING ISSUES IN THIS YEAR TRUCK AND HAS NOT DONE ANYTHING ABOUT IT. ALSO IF THE CAM PHASERS ARE NOT REPLACED THE ENGINE WILL BLOW!

ENGINE STARTED TICKING ENDED UP BEING CAM PHASERS AND NEEDED NEW MOTOR FORD KNOWS ITS A WELL KNOWN PROBLEM BUT REFUSES TO STAND BEHIND THEIR PRODUCTS.WAS TOLD IT WAS NORMAL ENGINE WEAR WHICH I FIND HARD TO BELIEVE AT 100,000MILES WITH RECOMMENDED MAINTENANCE DONE TO VEHICLE CLASS ACTION LAWSUIT WOULD BE THE BEST FOR ALL INVOLVED WHEN IT COMES TO THIS PRODUCT 7000 DOLLARS TO REPLACE MOTOR.

KNOWN ISSUE WITH FUEL INJECTORS CAUSED PREMATURE ENGINE FAILURE AT 45K MI. TOO MUCH FUEL WHEN COMPRESSED AND IGNITED BLEW THE PISTON APART. FORD REPLACED ENGINE. 80K MILES LATER SIMILAR PROBLEMS AND RECOMMENDATION IS ANOTHER ENGINE. TWO 5.4L ENGINES WITH LESS THAN 130K OVERALL MILES IS ABSOLUTELY UNACCEPTABLE. WEB SEARCHES SAY THERE IS CURRENT LITIGATION IN PROGRESS OVER THESE 5.4L ENGINES. I'M MAKING A FORMAL COMPLAINT THAT THE BASIS OF THE LAWSUIT HAS MERIT. FORD HAS ALREADY SETTLED A SUIT OVER THE SPARK PLUGS FOR THESE 5.4L BUT THE PROBLEMS WITH THESE ENGINES GOES MUCH DEEPER. I'M THANKFUL MY ENGINE FAILURES HAPPENED WITHOUT ANY ADDITIONAL INCIDENT.

F-150 BEGAN WITH A TICKING NOISE AND TURNED INTO A LOUD KNOCKING NOISE, VEHICLE LOOSES POWER OR COMPLETELY SHUTS OFF WHILE DRIVING. REPLACED COIL PACKS, AND SPARK PLUGS (ONE BROKE OFF DUE TO HORRIBLE DESIGN). BASICALLY, HAD TO TAKE APART THE ENTIRE ENGINE REPLACING SEVERAL PARTS TO STILL NOT HAVE A DRIVABLE VEHICLE. MECHANIC JUST INFORMED ME THERE IS NOTHING ELSE TO DO BUT REPLACE THE ENTIRE ENGINE. THANK YOU FORD I OWE ABOUT $8000 ON THIS POS. I HAVE ALREADY SUNK $1200 INTO THE VEHICLE AND WILL NOW BE LOOKING AT OVER $5000 TO REPLACE THE ENGINE. *TR

THE PHASERS AND TUNERS ARE SHOT INTERNAL ENGINE DAMAGE IT STARTED TO MAKE NOISE WHILE MOVING

I PURCHASED MY 2005 F150 WITH A 5.4L TRINITRON ENGINE USED IN 2010. I COMPLETED ALL REGULAR SCHEDULED MAINTENANCE USING THE RECOMMENDED PRODUCTS, MOST OF IT DONE IN FORD DEALERSHIPS. THIS 5.4L ENGINE IS A POOR DESIGN AND SHOULD BE RECALLED. IT HAS NUMEROUS PROBLEMS. I HAD A SAFETY INSPECTION DONE AT A FORD DEALERSHIP AND IT PASSED EVEN THOUGH IT HAD A TICKING SOUND IN THE ENGINE AND I HAD HESITATION AND LOSS OF POWER. REPLACE SPARK PLUGS, I HAD ALREADY REPLACED THE TRANSMISSION AT 98,000 MILES! THIS ENGINE IS A PIECE OF JUNK! FORD NEEDS TO STAND BEHIND ITS' "BUILT FORD TOUGH" TRUCKS AND MAKE THIS RIGHT. I CANT ENJOY MY TRUCK!!!

I PURCHASED MY 2005 F150 WITH A 5.4L TRINITRON ENGINE NEW IN 2005. I COMPLETED ALL REGULAR SCHEDULED MAINTENANCE USING THE RECOMMENDED PRODUCTS, MOST OF IT DONE IN FORD DEALERSHIPS. THIS 5.4L ENGINE IS A POOR DESIGN AND SHOULD BE RECALLED. IT HAS NUMEROUS PROBLEMS. I HAD A SAFETY INSPECTION DONE AT A FORD DEALERSHIP AND IT PASSED EVEN THOUGH IT HAD A TICKING SOUND IN THE ENGINE AND I HAD HESITATION AND LOSS OF POWER. AT THAT POINT, I HAD ALREADY REPLACED THE TRANSMISSION AT 62,000 MILES! NOW AT 105,000 MILES THE PLASTIC CAMPHASERS BROKE APART, THE TIMING CHAIN BROKE AND THE ENGINE IS BLOWN!! THAT IS UNACCEPTABLE FOR A FORD TRUCK TO LAST THAT LONG AND HAVE THAT MANY PROBLEMS. THIS ENGINE IS A PIECE OF JUNK! FORD NEEDS TO STAND BEHIND ITS' "BUILT FORD TOUGH" TRUCKS AND MAKE THIS RIGHT. I'LL NEVER BUY ANOTHER FORD.

HAD TO REPLACE SPARK PLUGS ON 2005 FORD F150. CAUSED MECHANICAL PROBLEMS. I GOT THEM REPLACED AT FORD DEALERSHIP IN RICE LAKE WISCONSIN.

THE HOSES FROM THE WINDOW WASHER PUMP TO THE SPRAYERS HAVE DETERIORATED

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT A STRONG FUEL ODOR WAS PRESENT IN THE VEHICLE OCCASIONALLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 124,000. .....UPDATED 04/15/16 *BF *CN

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING AND MAKING A RIGHT TURN, THE VEHICLE LOST POWER AND STALLED. THE CONTACT HEARD A BEEP SOUND PRIOR TO THE FAILURE. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DUPLICATE THE FAILURE OR RETRIEVE A FAULT CODE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

BRAKE WARNING LIGHT IS LIT ON THE DASHBOARD. THERE IS NOTHING WRONG WITH THE BRAKES. I HAVE READ THAT THERE IS A WIRING PROBLEM WHICH CAUSES THE BRAKE LIGHT TO STAY ON. FORD HAS RECALLED OTHER F150 MODEL YEARS BUT NOT 2005 F150S.

THE TRUCK HAS A TICKING SOUND INSIDE THE ENGINE. I HAVE HAD THAT NOISE SINCE I BOUGH IT. 3 YEARS AGO I HAD IT CHECKED OUT AT A FORD DEALERSHIP AND THEY SAID IT WAS NORMAL. THIS YEAR ON NOVEMBER 4, I TOOK IT AGAIN TO THE FORD DEALERSHIP AND THEY FOUND THE PROBLEM. ITS A BENT ROD. THE PROBLEM IS THAT THE EXTENDED WARRANTY THAT I HAVE WILL NOT COVER ITUNLESS THE KNOW THE CAUSE OF IT. SO FORD IS SAYING ITS A DEFECTED PART. INSURANCE WONT COVER IT AND THEY WANT ME TO PAY THOUSANDS OF DOLLARS TO REPAIR IT!! IF ITS A DEFECTED PART, DON'T YOU THINK FORD SHOULD PAY!!

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING AT APPROXIMATELY 55 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED AND THE VEHICLE LUNGED FORWARD WITHOUT WARNING. THE CONTACT STATED THAT WHEN THE VEHICLE WAS IDLE, THERE WAS A TICKING NOISE COMING FROM THE FRONT OF THE VEHICLE. THE FAILURES RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE CONSUMED EXCESSIVE OIL AT AN ACCELERATED RATE AND THE VEHICLE NEEDED AN OIL CHANGE. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 144,500.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING AT 70 MPH, THE VEHICLE SHOOK. WHILE MAKING A RIGHT TURN INTO A PARKING LOT, THE VEHICLE CRASHED INTO A MEDIAN AND A CURB. THE CONTACT SUSTAINED INJURIES TO THE SHOULDER, NECK, AND BACK, WHICH REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. NO POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 93,000.

SPARK PLUGS ARE IMPOSSIBLE TO BE REMOVED/REPLACED. WENT TO MECHANIC TO BE REMOVED/REPLACED AND WAS EXTREMELY EXPENSIVE. MUST BE SOME DEFECT ON FORD'S PART.

THE WARNING LIGHT FOR BRAKES, ON THE DASH, STAYS ON ALL OF THE TIME.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING, THERE WAS AN ABNORMAL NOISE COMING FROM THE ENGINE AREA AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT ALSO INDICATED THAT WHILE IDLE, THE VEHICLE WOULD SHAKE AND RATTLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE SOLENOID FAILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 140,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 20 MPH, THE VEHICLE SHOOK AND STALLED. THE CONTACT RESTARTED THE VEHICLE AND WAS ABLE TO DRIVE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE OIL PUMP WAS NOT SUPPLYING OIL TO THE TOP OF THE ENGINE AND THE ENGINE WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 106,200. UPDATED 1/12/16 *CN

DRIVER SIDE WINDOW REGULATOR FRAYED. WINDOW INOPERABLE.

REAR END SHAKING WHILE DRIVING DOWN ROAD ABOUT 60MPH. GETTING OFF GAS NOR PUTTING VEHICLE IN NEUTRAL WOULD NOT STOP SHAKING. HAD TO COME TO COMPLETE STOP BEFORE STARTING AGAIN TO MAKE VEHICLE DRIVE PROPERLY.

UNIT WAS RECALLED,DEALER HAD VEHICLE 3 DAYS,ADVISED THAT THEY DID NOT HAVE THE TOOLS REQUIRED TO FIX THE AIRBAG AND CONSEQUENTLY COULD NOT FIX THE PROBLEM.DEALER SAID THEY WOULD CALL ME LATER AND UPDATE PROGRESS ON COMPLETING THE RECALL.IT HAS BEEN A YEAR AND NO CALLS HAVE BEEN RECEIVED.

METAL SCRAPING SOUND FROM REAR END. MECHANIC HAS CHECKED AND SAYS PINION, BEARINGS, RING GEAR HAVE FAILED. LOOKS LIKE ITS A COMMON FAILURE. 9.75 RING GEAR, 3.55 RATIO

DRIVING VEHICLE HAVE NOTICED WHEN ENGINE IS IDLING, POWER STEERING IS SOMETIMES WEAK. FLUID IS REPLACED EVERY FALL, AS THE STEERING PUMP HAS BEEN A NOISY ONE SINCE THE TRUCK WAS NEW. DEALER SUGGESTED REPLACING FLUID WITH SYNTHETIC. IT WORKED THEN, SO I REPLACE IT EVERY YEAR. TODAY, WITH STEERING AT FULL LEFT LOCK, THE STEERING WAS STUCK AT THAT POINT. MOVED WHEEL BACK AND FORTH AND IT CAME LOOSE. HAVE NOT BEEN ABLE TO DUPLICATE SINCE. AS A NOTE AT 5 YEARS OLD AND 53,000 MILES POWER STEERING PRESSURE HOSE SPRUNG A LEAK UNDER THE CLAMP AT THE FRAME. REPLACED WITH AFTER MARKET PART, AS DEALER COULDN'T GET THE PART. BACK ORDERED!

ON HIGHWAY AT 60 MPH ENGINE STARTED TO MISS. WAS ABLE TO GET IT TO MY MECHANIC WHERE HE SAID A SPARK PLUG HAD FAILED. THE PLUG BROKE WHEN REMOVING. HE WAS ABLE TO REMOVE THE PLUG. THEN DUE TO A SQUEAL UNDER THE HOOD WHEN THE ENGINE WAS COLD, HE REMOVED THE INTAKE AND FOUND THE SEAL HAD FAILED, WHILE IT WAS APART HE NOTED 2 LEAKING FUEL INJECTORS. ALL DEFECTIVE PARTS WERE REPLACED. IN AUGUST THAT SAME YEAR I REPLACED THE OTHER 7 SPARKPLUGS, HAVING 4 MORE BRAKE OFF. THE EXTRACTOR TOOL WORKED GREAT.

I WAS STARTING THE TRUCK TO LEAVE A WAL-MART PARKING LOT AND MY LEFT FOOT WHICH WAS ON THE BRAKE WENT ALL THE WAY TO THE FLOOR OF THE TRUCK. I HAD NO BRAKES. IT WAS FORTUNATE THAT I WAS STOPPED AND NOT ON THE ROAD WITH OTHER CARS OR GOING DOWN A STEEP HILL. I HAD THE AUTO SHOP TOW THE TRUCK TO THE SHOP. THEY FIXED TWO BRAKE LINES. COMPLETE BRAKE FAILURE SHOULD NOT HAPPEN.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AND INDEPENDENT MECHANIC FOR SCHEDULED MAINTENANCE. WHILE THE VEHICLE WAS ON THE LIFT, THE MECHANIC NOTICED THAT THE ENTIRE FRAME WAS SEVERELY RUSTED AND THERE WERE FRACTURED AREAS IN FRONT OF THE WHEEL WELL ON BOTH SIDES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 67,000.

TL* THE CONTACT OWNS A 2005 FORD F-150 EQUIPPED WITH GENERAL AMERI-TRAC TIRES, SIZE: P255/70R17. THE CONTACT STATED THAT ALL THE TIRES EXHIBITED CRACKS IN BETWEEN THE TREAD PATTERN. THE TIRES WERE NOT DIAGNOSED OR REPLACED. THE TIRES WERE REPLACEMENT TIRES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS 116,000 AND THE TIRE FAILURE MILEAGE WAS 28,000.

ABOUT A YEAR AGO I WAS DRIVING MY F-150 PICKUP TRUCK DOWN STREET MAYBE 45 M.P.H WHEN OUT OF NOWHERE THE DRIVER SIDE WINDOW MADE A LOUD NOISE AND FELL DOWN INTO THE DOOR . ENDED UP THAT THE WINDOW REGULATOR HAD BROKEN . THEN YESTERDAY I WAS DRIVING ABOUT 50 M.P.H AND MY BACK WINDOW WAS OPEN ABOUT 2 INCHES I PUSHED THE BUTTON TO MAKE IT GO UP , IT MADE A LOUD GRINDING NOISE AND FELL INTO THE DOOR ALSO.

I PURCHASED MY 2005 FORD F-150 RIGHT OUT OF THE SHOW IN 2005 AND FIRST BEGAN HAVE JERKING ISSUES 6 MONTH LATER A MECHANIC THEN TOLD ME THAT IT WAS RELATED TO THE FUEL INJECTORS. SINCE THAT TIME I HAD TO REPLACE THE TRANSMISSION TWICE IN 2008, A TIMING CHAIN AND BENT RODS IN 2014 AND CURRENTLY ANOTHER TIMING BENT RODS AND DEBRI FROM THE OIL PAN. ALL CAUSED FROM THE INITIAL FAULTY FUEL INJECTOR ISSUES CONTINUING FROM LESS THAN ONE YEAR AFTER THE ORIGINAL PURCHASE IN 2005. I'VE SENT OVER $9500 IN MECHANIC COST TO DATE.

I WAS DRIVING AND HEARD A SOUND COME FROM MY ENGINE COMPARTMENT. I DIDN'T LOSE POWER, BUT PULLED OVER TO LOOK UNDER THE HOOD. NOT NOTICING ANYTHING OBVIOUS I CHECKED THE FLUID LEVELS AND NOTICED THAT MY TRANSMISSION FLUID WAS LOW. IT HAD BEEN CHECKED TWO MONTHS PRIOR DURING OIL CHANGE. I HAD NO VISIBLE SIGNS OF LEAKS. I FOUND A FORUM ON THE INTERNET THAT TALKED ABOUT TRANSMISSION FLUID GOING FROM THE TRANSMISSION TO THE TRANSFER CASE, BUT UNABLE TO RETURN. THEY HAD A $20 SEAL REPLACED UNDER WARRANTY. THE FORUM HAD STATED THAT THIS WAS A KNOWN CONDITION BUT NOTHING WAS BEING DONE BY FORD MOTOR COMPANY. A MECHANIC HAD SAID THAT IT ONLY EFFECTED 17-18% OF VEHICLES MANUFACTURED BETWEEN 2004-2008. I CALLED TWO LOCAL DEALERSHIPS AND THEY KNEW THE PROBLEM BUT SAID THAT THERE WAS NO RECALL ON IT. IT TAKES APPROXIMATELY 3 HOURS TO CHANGE, BY DROPPING THE TRANSFER CASE AND REPLACING THE SEAL. I CALLED FORD MOTOR COMPANY REPRESENTATIVE AND WAS TOLD THAT THERE WASN'T A RECALL AND THAT THEY COULDN'T HELP. I FEEL THAT THIS COULD RESULT IN A PREMATURE FAILURE OF THE TRANSMISSION AND POSSIBLY A CATASTROPHIC EVENT. I WAS TOLD BY FMC REP THAT SHOULD A RECALL OCCUR I COULD TAKE MY RECEIPT TO A DEALERSHIP AND THAT THEY WOULD POSSIBLY REIMBURSE ME. I DON'T FEEL THAT FORD SHOULD HAVE A KNOWN CONDITION BUT DO NOTHING TO CORRECT IT. PLEASE LOOK INTO THIS FOR ME AND OTHERS UNDER THE SAME SITUATION.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING AT 15 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.

A NUMBER OF WIRES LEADING FROM THE BODY INTO THE DRIVER'S SIDE DOOR HAVE BEEN CUT/WORN POSSIBLY DUE TO CONTACT WITH THE INSIDE OF THE DOOR. THE RUBBER AND PLASTIC PARTS MEANT TO PROTECT THE WIRES WERE ALSO CUT/WORN. THIS HAS LED TO COMPLETE FAILURE OF ALL ELECTRONICS IN THE DOOR INCLUDING POWER LOCK, POWER WINDOWS, AUTOMATIC SHUTOFF OF RADIO, DOOR CHIME, KEYPAD, AND MIRRORS. DISCUSSION WITH FORD DEALER INDICATED THAT THEY HAVE SEEN THIS PROBLEM IN THE PAST.