2016 Ford Edge

Defect. Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.

Risk. A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

Remedy. Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.

Defect. Ford Motor Company (Ford) is recalling certain 2016-2018 Lincoln MKX and 2015-2018 Edge vehicles. The rear brake jounce hose may rupture and leak brake fluid.

Risk. A brake fluid leak can extend the distance required to stop the vehicle, increasing the risk of a crash.

Remedy. Dealers will inspect and replace the brake jounce hoses and adjust brake jounce hoses with no damage present, free of charge. Interim owner letters notifying owners of the safety risk were mailed September 8, 2025. Additional letters will be sent once the remedy is available, anticipated August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S87.

Defect. Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.

Risk. A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.

Remedy. Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.

Defect. Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.

Risk. A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.

Remedy. Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.

Defect. Ford Motor Company (Ford) is recalling certain 2013-2016 Ford Fusion and Lincoln MKZ, 2015-2016 Ford Edge, and 2016 Lincoln MKX vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin. Road salt or other contaminants may corrode the electric power steering gear motor attachment bolts.

Risk. If the bolts corrode, the steering gear motor may detach from the gear housing resulting in a loss of power steering assist, requiring a greater steering effort, especially at lower speeds, and increasing the risk of a crash.

Remedy. Ford will notify owners, and dealers will replace the steering gear motor bolts and apply a wax sealer. If any of the steering gear motor attachment bolts are broken or missing, a new steering gear will be installed in the vehicle. These repairs will be performed free of charge. The recall began October 18, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S26.

Defect. Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Edge and Lincoln MKX vehicles and 2017 Lincoln Continental vehicles. In the event of a crash, the driver's frontal air bag may not fully inflate or the air bag cushion may detach from the air bag module. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Risk. During deployment, if the air bag does not fully inflate or the cushion detaches, there is an increased risk of injury in the event of a crash.

Remedy. Ford will notify owners, and dealers will replace the driver frontal air bag module, free of charge. The recall began June 16, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C02.

Defect. Ford Motor Company (Ford) is recalling certain model year 2015-2016 Ford Edge vehicles manufactured February 9, 2015, to August 12, 2016. During dealer servicing, the affected vehicles may be have been updated with incorrect Antilock Brake System (ABS) and Electronic Stability Control (ESC) software. This software can cause the ESC system to lose engine torque control, and not provide any warning lamps to warn the driver if there was an ABS or ESC system malfunction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems" and number 135, "Light Vehicle Brake Systems."

Risk. If the operator is not warned of an ABS or ESC malfunction and the ESC loses engine torque control, there would be an increased risk of a crash.

Remedy. Ford will notify owners, and dealers will replace the ABS module, and update the service software, free of charge. The recall begin November 22, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16C14.

Slow coolant loss and cylinder 2 misfire. Causing car to rough idle after a cold start when sitting over.

This vehicle has under 100,000 miles on it and the engine light came on, the code at Autozone and O'Reilly's both read P0301 for bad misfire in coil 1. I replaced all 4 sparks plugs and ignition coils and the code never cleared, i started noticing while smoke when start up and suspected coolant issues. I had a diagnostician help me investigate and forums suggested coolant intrusion from poor engine block design can happen in cylinders 2 & 3, but after scoping the block, we found coolant leakage in cylinder 1. I called ALM Ford Marietta and my rep said they'd confirm my suspicions free of charge and confirmed the results. The only repair was to do a whole engine swap with a refurbished or new longblock costing $5k for parts and $6k for labor. I have an allowance of $3500 for vehicle repairs so i am devastated that i cannot even sell this vehicle with a bad engine. The ford 2.0 ecoboost engine forums suggest coolant intrusion is common and Ford should have fixed this problem between 2015-2019 bud did not and thousands of vehicles have this problem (fusion, focus, edge, escape) but is Ford taking responsibility that the spiral coolant application is a bad design and costing people thousands upon thousands of dollars of repairs that shouldn't have happened in the first place. I mean, i have less than 100k on my edge, why should i need a whole new engine, what is next, a new transmission for 7k next year? What happened to quality? we are a single vehicle family so we are relying o

Component-Engine / Propulsion System Symptoms-Progressive coolant loss without external leaks, rough starting, engine shaking, white exhaust smoke, and illuminated Check Engine Light with cylinder misfire codes. Description of Incident- My 2016 Ford Edge equipped with the 2.0L EcoBoost engine is experiencing internal engine coolant intrusion into the combustion cylinders, perfectly matching the design defect identified in Ford Technical Service Bulletin (TSB) 19-2346. The vehicle exhibits persistent coolant loss alongside severe engine misfires. This defect poses an immediate safety hazard, as the fluid intrusion causes rough idling, stalling, and a sudden, hazardous loss of motor power while operating at driving speeds. This complaint is being filed in direct relation to the active NHTSA Defect Petition DP26008 investigating 2015–2018 Ford Edge vehicles for engine failures caused by this specific coolant intrusion flaw.

Recently purchased the vehicle, the following morning after purchased, the check engine light came on and I had it hooked to a computer scanner for it showed a cylinder 3 misfire. We also visually notice that the coolant level in the reservoir was somewhat low after sitting for several hours, so we filled the coolant reservoir to the appropriate line shown on the tank, but just between the afternoon when it was purchased , and that next morning there was no coolant that had leaked underneath the vehicle . The dealer that I purchased it from had the spark plugs, the spark plug wires and the ignition coils replaced. When I picked up the vehicle after those were replaced, I drove it for about a total of 40 miles before the check engine light came back on and upon starting, the vehicle started kind of rough like it wasn't igniting completely. Over the next day and a half upon each start whether it be a cold start or not, the vehicle started in the same way where it felt as though it was not getting a good ignition or fire but it would still start up. I took the vehicle to a Ford dealership where the technicians connected their diagnostic scanner and also did a pressure test where it reported to have coolant intrusion and would require a new motor . As I could not afford to replace it, since I just purchased the vehicle, I took it home and did not try to drive it but by the next morning, less than 24 hours, upon trying to start it, the vehicle would not start at all. The warranty

While on vacation in September of 2021the check engine light came on. it was for a number three cylinder misfire. I replaced the spark plug thinking that was the problem. In October of 2021 I was driving the car and the dashboard lit up with numerous warning lights. I pulled the car off the road and checked under the hood. There was no coolant in the reservoir. I could not restart the vehicle. Had it towed to a shop and was told that one of the cylinders had coolant in it. Had it towed from the original shop to a Ford dealer in hopes Ford would be able to help with the repairs. I was told that there was a possible class action suit against Ford for this engine problem and Ford would not help with the repair. After much back and forth with the dealer I decided to have them do the repairs at my expense. They replaced the engine block with a Ford remanufactured part. The total cost of the repair was $5004.12. I did not file this at the time because I was waiting to see if the class action suit was going to be filed for Virginia.

There was coolant leaking into the cylinders creating a white smoke from the tail pipe exhaust. our safety was put at risk as the car was stalling out and would shake when started. We took it to a ford dealership and had it check out with them performing a scope test on the cylinders and they said we needed a long block replacement.

The contact owns a 2016 Ford Edge. The contact stated that coolant was entering the engine combustion chamber. The check engine light was illuminated, and the vehicle displayed DTC: P0301. The contact also referenced a scanner displaying code 4301. The contact stated that there was a sweet smell while starting the vehicle, which was consistent with coolant intrusion into the engine. The condition progressively worsened. The contact consulted with an independent mechanic. The contact was concerned that the vehicle might stall or that the engine could suffer catastrophic damage while driving on the highway. The failure mileage was approximately 83,000.

The contact owns a 2016 Ford Edge. The contact received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer and the manufacturer were made aware of the issue and confirmed that parts were not yet available.

Dealer has told me that there is a leak that could impact engine performance/life. They said it could happen in 2,000 or 20,000 miles. What I have experienced is that several times a month when I turn the engine on it has a rough idle. Sometimes it happens when I have stopped at a traffic light. So far the engine has not stopped or slowed down, as others have reported. I am concerned that the engine will slow or stop, risking my safety and the safety of those around me. I have not had any warning lights, to date. This has been going on for about the last year.

RE: Safety Recall MFG No. 25S87, NHTSA No. 25V544, 08/25/2025 Rear Brake Lines - Potential Failure. It has been OVER ONE YEAR and my car has not been repaired due to lack of parts. This is unacceptable - This Safety Recall is NOT being addressed in a timely manner.

Coolant intrusion. 2.0 engine blows white exhaust.

Transmission jumps from 2nd to 4th without warning and causes the vehicle to jerk into oncoming traffic

Total engine failure at 81,000 miles due to coolant intrusion. This is due to a known defect by FORD as outlined in the Technical Service Bulletin #19-2346. Engine light and codes PO316 and PO304 promoted spark plug replacement, which did not clear the codes. 1 day later, the coolant intruded into the cylinder and the engine block failed. FORD stated they would extend warranty if this happens within 7 year/85,000 miles. Since my car is a 2016 with only 81,000 miles, was perfectly maintained, and was under mileage, I hoped FORD could cover a full block replacement (as stated in the TSB). The representative denied my request since the car is 9 years old, but assigned a case number and said she’d send the report to the ‘Safety’ department for the option to further investigate if they chose.

My 2016 Ford Edge equipped with the 2.0L EcoBoost engine experienced an internal engine coolant intrusion failure that resulted in significant engine damage and ultimately required replacement of the complete engine assembly. The coolant intrusion occurred internally within the engine, allowing coolant to enter the combustion chambers and causing the engine to malfunction. The failed engine assembly and related components are available for inspection upon request. The failure created a significant safety risk because the engine experienced a loss of power and reliability while the vehicle was being operated. Coolant intrusion resulted in engine misfires, rough running, reduced engine performance, and sudden loss of power or engine failure while driving. This presented a risk to me and other motorists, particularly if the failure occurred while traveling at highway speeds or in traffic. The problem was diagnosed and confirmed by a qualified automotive service facility, which determined that the engine had suffered from coolant intrusion and that the appropriate repair required replacement of the complete engine assembly. The vehicle was inspected by the servicing facility as part of the diagnostic and repair process. If requested, documentation of the diagnosis and engine replacement can be provided. Prior to the complete engine failure, the vehicle exhibited symptoms consistent with coolant intrusion, including engine misfires, rough engine operation, and loss of performance.

My 2016 Ford has EcoBoost coolant intrusion defect, The system failed to hold pressure, dropping significantly below operational thresholds. A subsequent borescope inspection confirmed that coolant is actively leaking past the block sealing surface and directly flooding the engine cylinders. The service facility has confirmed that because the structural engine block itself is defective, a simple head gasket replacement is mathematically unviable. The only permanent, safe solution is a complete engine long block replacement.. I contacted Ford and was told they are aware of this but cannot fix the issue or assist in fixing the problem.

See attached document for complaint.

2.0 Ecoboost coolant intrusion. Vehicle is now undrivable and was told the current engine cannot be repaired and a whole new engine is needed.

Engine started having a rough idle on start up and within a few days the check engine light came on. Took to Lonnie Cobb Ford in Henderson, TN. DTC P0300 and P0302 diagnosed. Coolant leaking on to piston head. Issue involved in lawsuit Miller vs. FordMotor Ecoboost lawsuit. Safety issue due to possible engine lock up or fire. Out of warranty. Quote for $6500 on an $8000 vehicle for an engine defect Ford has been aware of for years.

My 2016 Ford Edge with the 2.0L EcoBoost engine began having rough starts, misfiring, and an intermittent check-engine light. The warning light repeatedly turns on and off, but the problem continues. On 96000, the Ford dealership diagnosed internal coolant intrusion into the engine/cylinder area and advised that the vehicle requires major engine repair or replacement estimated at approximately $10,000. This defect can cause continued misfires, reduced engine performance, overheating, stalling, or sudden loss of power while driving. I am concerned that the engine could fail or lose power in traffic without adequate warning. This appears to be a premature internal engine failure rather than normal maintenance. Ford declined my request for financial or goodwill assistance even though coolant intrusion is a documented problem affecting similar Ford EcoBoost engines. I am requesting that NHTSA investigate this defect and determine whether a safety recall is necessary.

The contact owns a 2016 Ford Edge. The contact stated that the brake warning light illuminated while driving at an undisclosed speed. The contact was notified of NHTSA Campaign Number 25V544000 (Service Brakes, Hydraulic); however, the part to do the recall repair was on back order. The vehicle was taken to an independent mechanic, who replaced the brake pads and brake lines. The vehicle was then taken to a local dealer, where an unknown diagnosis and repair were performed. The brake pads and brake lines had been replaced three times, but the failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 160,000.