2000 Ford F-350 SD

Defect. FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Risk. A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Remedy. FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Defect. CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.

Risk. WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.

Remedy. FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.

Defect. ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

Risk. IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

Remedy. DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

MANUAL TRANSMISSION KEEPING HANGING UP AND IS HARD SHIFTING INTO GEARS

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED THAT LOCATED UNDER THE FUEL FILTER, THE O-RING AND THE DRAIN LINE FAILED ON MORE THAN ONE OCCASION. THE VEHICLE WAS TAKEN TO THE DEALER MORE THAN TWICE AND THEY WERE NOT ABLE TO REPLICATE AND DIAGNOSE THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE DRAIN LINE AND INDICATED THAT THERE WAS TOO MUCH PRESSURE FLOWING INTO THE FUEL FILTER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000. UPDATED 05/10/16*LJ UPDATED 11/3/2017*JS

FORD F-350. CONSUMER WRITES IN REGARDS TO VEHICLE TIRE INFLATION PRESSURE PROBLEMS. *SMD THE CONSUMER STATED THE TIRE WAS INFLATED TO 55 PSI TO SOFTEN THE RIDE. LATER, WHILE HAULING TRACTOR THE TREAD ON ONE OF THE TIRES PEELED OFF. THE CONSUMER PUT THE SPARE ON THE TRUCK. THE CONSUMER WAS ADVISED TO RUN THE TIRES AT THE MAXIMUM INFLATION PRESSURE FOR THE BEST WEAR, MAXIMUM LOAD CAPACITY, BEST MILEAGE AND LONGEST LIFE. EACH OF THE TIRES EVENTUALLY FAILED ONE AT A TIME. WHEN THE CONSUMER PURCHASED NEW TIRES, THEY WERE INFLATED 60 PSI FOR THE FRONT AND 50 PSI FOR THE REAR, INSTEAD OF 80 PSI. EVERYTHING WAS FINE FOR A WHILE, UNTIL THE CONSUMER STARTED TO EXPERIENCE ROUGH RIDING AND NOISY TIRES AS A RESULT OF IMPROPER INFLATION. THE RETAILER STATED THE INFLATED THE TIRES ACCORDING TO WHAT WAS PRINTED ON THE DOOR STICKER. THE UNDER INFLATION CAUSED EXCESSIVE SIDEWALL FLEX, REDUCED MILEAGE, SHORTENED LIFE AND SEVERAL TIRE FAILURES. *JB *CN

AS WE WERE RETURNING HOME FROM A ROAD TRIP, WE HEARD A SCREECHING NOISE COMING FROM THE LEFT WHEEL WELL AREA WHEN WE MADE WIDE SWEEPING TURNS AND HIGHWAY CURVES. WE PULLED OVER AND, UPON INSPECTION, SAW OUR ORIGINAL ALLOY WHEEL ON OUR TRUCK WAS CRACKED. ONE OF THE WHEELS WAS DANGEROUSLY CLOSE TO COMING OFF THE HUB. PHOTOS DOCUMENT HOW SEVERE THE CRACKING OF THE WHEELS WAS - THREE OF FOUR WHEELS WERE FOUND TO HAVE CRACKS AND CHUCKS OF METAL MISSING,COMPROMISING THE INTEGRITY OF THE WHEELS AND THE SAFETY OF OUR VEHICLE. WE HAD TO PURCHASE NEW WHEELS AT A COST OF ALMOST $1,300.

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS THE VEHICLE STALLED ALTHOUGH THE FUEL LEVEL WAS AT CAPACITY. THE CONTACT TOOK HIS VEHICLE TO AN INDEPENDENT MECHANIC AND THE DEALER WHO BOTH STATED THAT HAVING LESS THEN 5% BIO DIESEL WOULD CAUSE THE FAILURE TO OCCUR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 130,000. THE CURRENT MILEAGE WAS 200,000.

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED THAT BRAKE FLUID WAS LEAKING FROM THE WIRES THAT WERE CONNECTED TO THE MASTER CYLINDER AND ONTO THE ELECTRICAL CONNECTOR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED CONTROL) BUT WAS ADVISED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 160,000.

DRIVING DOWN THE ROAD THE OTHER DAY IN ARE 2000 F-350 7.3 DIESEL REG CAB CHASSIS TRUCK PULLING 25,000 LB GOOSENECK TRAILER WAS DIS ENGAGING THE CLUTCH WHEN THE CLUTCH ASSEMBLY BROKE THE BUSHINGS WENT OUT AND BROKE LEAVING THE CLUTCH USELESS DRIVING IN BUSY TRAFFIC CLUTCH STAYED STICKING CAUSED A FIRE UNDER VEHICLE. *TR

I WAS TRAVELING DOWN THE HIGHWAY AT 60 MILES PER HOUR WHEN I HEARD A LARGE BANG. I STOPPED AND DIDN'T SEE ANYTHING UNTIL I STOPPED FOR GAS. GAS WAS LEAKING OUT THE FILL HOSE AND I LOOKED UNDER THE TRUCK AND THE GAS TANK STRAP HAD BROKE AND THE TANK WAS VERILY HANGING ON. I PURCHASED TWO STRAPS TO HOLD THE TANK IN PLACE UNTIL I COULD GET TO A FORD DEALERSHIP. THIS IS THE SAME PROBLEM THAT FORD RECALLED THE 150 AND 250 MODELS FOR. LUCKILY FOR ME THE TANK DID NOT RUPTURE AND CATCH FIRE. THE 350 NEEDS TO BE RECALLED TO FIX THIS PROBLEM BEFORE SOMEONE IS KILLED. *TR

THIS ISSUE WAS ON A 2000 FORD F350 AMBULANCE ON ROUTE TO EMERGENCY CALL WHEN ENGINE SHUT DOWN AND LOST ALL POWER LIKE IT WAS OUT OF FUEL 7.3 LITER DIESEL AND TANK WAS FULL. HAD UNIT TOWED TO TABS GARAGE IN KING NC AND $1700.00 LATER AFTER NEW FUEL TANK FUEL PUMP 3 INJECTORS DUE TO LINER INSIDE OF TANK CAME OFF AND CLOGGED THE FUEL SYSTEM AND ENGINE FORD MOTOR COMPANY WAS NO HELP AND SAID SINCE THE VEHICLE WAS OUT OF WARRANTY THEY WOULD NOT DO ANYTHING TO RESOLVE THE COST ISSUES. *TR

THIS ISSUE WAS ON A 2000 FORD F350 RESCUE TRUCK ON ROUTE TO EMERGENCY CALL WHEN ENGINE SHUT DOWN AND LOST ALL POWER LIKE IT WAS OUT OF FUEL 7.3 LITER DIESEL AND TANK WAS FULL. HAD UNIT TOWED TO GARAGE IN KING NC AND $900.00 LATER AFTER NEW FUEL TANK FUEL FILTER AND FUEL PUMP TO LINER INSIDE OF TANK CAME OFF AND CLOGGED THE FUEL SYSTEM AND ENGINE FORD MOTOR COMPANY WAS NO HELP AND SAID SINCE THE VEHICLE WAS OUT OF WARRANTY THEY WOULD NOT DO ANYTHING TO RESOLVE THE COST ISSUES. *TR

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 20 MPH AND MAKING A RIGHT HAND TURN, HE LOST CONTROL OF THE VEHICLE CAUSING HIM TO CRASH INTO SOMEONE'S MAILBOX. THE CONTACT STATED THAT THE POWER STEERING BECAME EXTREMELY LOOSE AND THE BRAKES ALSO FAILED. THE CONTACT DID NOT SUSTAIN ANY INJURIES. THE VEHICLE WAS UNABLE TO BE DRIVEN AND WAS LATER TOWED HOME. THE TOW TRUCK DRIVER INFORMED THE CONTACT THAT THE POWER STEERING HOSE LOOKS AS IF IT FRACTURED, WHICH MAY HAVE POSSIBLY CAUSED THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 253,000.

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT ATTEMPTED TO OPEN THE REAR DRIVER AND PASSENGER SIDE DOORS BUT NOTICED THAT THE TOP DOOR LATCH WOULD NOT RELEASE. THE BOTTOM LATCH RELEASED WITHOUT FAILURE. THE CONTACT WAS UNABLE TO OPEN THE REAR DOORS. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIAN ADVISED THAT THE DOOR ASSEMBLY WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 237,000.

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED THAT THE FRONT PASSENGER WHEEL WAS CRACKED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 224,430 AND THE CURRENT MILEAGE 224,455.

THE SPARK PLUG LOCATED AT THE REAR OF THE RIGHT CYLINDER BANK OF A 6.8 LITER GASOLINE ENGINE WAS EJECTED. THE SPARK PLUGS IN THIS ENGINE HAVE NEVER BEEN CHANGED TO MY KNOWLEDGE SO THIS IS NOT A RESULT OF IMPROPER TORQUING PROCEDURES. THE ENGINE HAD BEEN OPERATING PROPERLY AND VERY SELDOM HAS GONE OVER 70 MPH. ACCELERATION AT THE TIME OF FAILURE WAS LIGHT AND THE VEHICLE WAS NOT TOWING. NO FIRE ENSUED ALTHOUGH THERE WAS A FAINT GASOLINE ODOR UNDER THE HOOD RIGHT AFTER I SHUT THE ENGINE DOWN. THE FAILURE WAS OBVIOUS BECAUSE THE SPARK PLUG AND ATTACHED COIL PACK WAS LYING ON TOP OF THE CYLINDER HEAD. THE FORD DEALER ACKNOWLEDGED THAT THIS HAS BEEN A PROBLEM IN THESE ENGINES. *TR

TL* THE CONTACT OWNS A 2000 FORD F-350 DIESEL. THE CONTACT NOTICED THERE WAS A EXCESSIVE RUST ON THE FRAME AND THE EXTERIOR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO ADVISED HIM THAT HE NEEDED A FRAME, TRUCK BED, ETC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 118,000. UPDATED 12/05/11

2000 F350 RUST : 8 FT. BED, RAILS UNDER BED, CAB RUST, CROSS MEMBER UNDER BED FROM RIGHT FRAME TO LEFT FRAME, RUNNING BOARDS. REPLACED OIL PAN BECAUSE OF RUST YEARS EARLIER. *TR

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT HEARD A NOISE FROM THE REAR OF THE VEHICLE. THE CONTACT STOPPED THE VEHICLE TO INSPECT THE NOISE AND NOTICED THAT THE FRONT FUEL TANK STRAP WAS CORRODED AND FRACTURED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) THAT AND CONTACTED THE MANUFACTURER BUT WAS ADVISED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000. UPDATED 11/03/11*LJ UPDATED 12/02/11

TL* THE CONTACT OWNS A 2000 FORD F350 SUPER DUTY. THE CONTACT STATED THAT THE CLUTCH ARM BROKE WHILE THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH. THE VEHICLE WAS REPAIRED BY THE CONTACT. THE MANUFACTURER AND DEALER WERE CONTACTED TO REPORT THE FAILURE. THE FAILURE MILEAGE WAS 151,000 AND THE CURRENT MILEAGE WAS 154,000. UPDATED 08/31/11*LJ UPDATED 2/9/12 *CN

2000 FORD F350 CREW CAB 4X4 BRAKE LINE WAS CORRODED FROM DIFFERENT METALS USED. HAD HOLE IN LINE AND BRAKE PEDAL WENT TO THE FLOOR CAUSING ME TO HAVE NO BRAKES. EXTREMELY DANGEROUS!!! *TR

FUEL TANK STRAP HAS BROKEN AGAIN.2ND TIME FOR THE REAR STRAP,FRONT REPLACED 1 TIME. ALSO REPLACED GAS TANK IN 2006 DUE TO LEAK FROM RUSTING AT SEAM,TANK IS STARTING TO LEAK AGAIN. TANK DROPPED TO THE STREET WHEN STRAP GAVE WAY LAST TIME,LUCKILY I WAS GOING SLOW ON A SIDE STREET. SPEAKING WITH OTHER OWNERS OF THESE TRUCKS,F-350 SUPERDUTY 2000 CAB AND CHASSIS MOST ARE HAVING OR HAVE HAD THE SAME ISSUES I AM HAVING. *TR