2000 Ford F-350 SD complaints

2000 FORD F 350. CLUTCH WILL NOT DISENGAGE DRIVELINE WHEN DEPRESSED. 2 ND FAILURE OF SUCH NATURE. VEHICLE WILL KEEP ROLLING IN CURRENT GEAR AND SPEED WHEN CLUTCH IS DISENGAGED. CAN DO NOTHING BUT STALL THE ENGINE BY HARD BRAKING OR TURNING OFF THE KEY BOTH CREATE OTHER DANGERS. FIRST FAILURE HAPPENED AT 38K MILES SECOND AT 52K. PAID FOR FIRST REPAIR OUT OF POCKET- SAID TO BE THE CLUTCH MASTER CYLINDER BOOT RIPPING WHILE UNDER PRESSURE. SEEKING FORD TO FIX THIS TIME. FORD DEALERSHIPS IN NORFOLK VA AND KNOXVILLE TN DENY THAT THIS IS A SAFETY ISSUE. I DO NOT UNDERSTAND THEIR LOGIC. *AK

2000 F350 7.3 DIESEL - CAM POSITION SENSOR FAILED, SHUTTING DOWN ENGINE. LUCKILY VEHICLE HAD JUST PULLED OUR OF DRIVEWAY AND WAS ABLE TO GET TO SIDE OF ROAD. THE ENGINE RESTARTED AFTER 10 MINUTES BUT DIES AGAIN AFTER A FEW SECONDS. CAM POSITION SENSOR WAS REPLACED, SOLVING PROBLEM. EMPLOYEE AT DEALERSHIP UNOFFICALLLY SAID THIS WOULD PROBABLY HAPPEN AGAIN IN APPX. 40,000 MILES. THIS TRUCK IS USED TO PULL HORSE TRAILERS ON THE INTERSTATE. IF THIS IS GOING TO BE A REPEAT OCCURANCE, I DON'T WANT MY FAMILY OR MYSELF IN THE TRUCK IF THIS HAPPENS ON THE INTERSTATE AT 70MPH. I NO LONGER FEEL SAFE IN THIS TRUCK.*AK

I HAVE A 2000 FORD F350 PSD 4X4 THAT HAS BEEN HAVING MORE AND MORE PROBLEMS RECENTLY WITH THE DOOR AJAR FUNCTION. IN WARMER WEATHER ONE OR MORE OF THE DOOR CLOSED SWITCH SENSORS IS MALFUNCTIONING SHOW THE DOOR OPEN WHEN THEY ARE ALL CLOSED. I HAVE TRIED OPENING AND CLOSING ALL DOORS REPEATEDLY BUT NO IMPORVEMENT. LATELY IT HAS BEEN HAPPENING MORE AND WITH COOLER TEMPS AS WELL. I TALKED TO THE FORD DEALER HERE IN TOWN AND THEY SAID THEY HAD HEARD OF THIS AND TOLD ME TO TRY WD40 AS A FIX BY SPRAYING IT INTO THE DOOR CLOSER WHERE THE SWITCH IS BURIED. NO LUCK. THIS MAY NOT SOUND TO BAD OF A PROBLEM, HOWEVER THE RESULTS OF THE TRUCK THINKING THE DOOR IS OPEN IS NOT GOOD. IF THE TRUCK IS RUNNING, THE INTERIOR LIGHTS STAY ON UNTIL A SPEED OF 15MPH OR MORE IS HIT, THEREBY AUTO SHUTTING OFF THE INTERIOR LIGHTS. HOWEVER AS SPEED DECREASES AND GOES BELOW THE 15MPH THE LIGHTS TURN BACK ON. IT MAKES IT VERY DIFFICULT TO SEE AT NIGHT DRIVING FORWARD AND ALMOST IMPOSSIBLE TO BACK UP. THE OTHER CONCERN IS AFTER THE TRUCK IS SHUT OFF, THE INTERIOR LIGHTS STAY ON UNTIL THE SWITCH RELEASES OR A SELF TIMER SHUTS OFF THE LIGHTS. THIS HAS CAUSED A SLIGHT DRAIN IN BATTERY, MAKING IT SLIGHTLY DIFFICULT AT TIMES TO START A TRUCK WHICH NEEDS ALL THE JUICE IT CAN GET TO TURN OVER. I HAVE SEEN THIS DEFECT IN THE DOOR CLOSURE SWITCH HAPPEN IN AN OLD WORK TRUCK I USED TO DRIVE (99 FORD F150). I WOULD LIKE TO INSTALL A SECURITY DEVICE IN THE FUTURE, HOWEVER IF THE DOOR REMAIN AJAR, THIS COULD POSE TO BE A

WHEN YOU PRESS THE BRAKE PEDAL THE STEERING WHEEL LOCKS UP . WHEN YOU RELEASE THE BRAKE IT RELEASE THE STEERING WHEEL. 2000 FORD F350 SUPERDUTY DIESEL HAS DONE THIS SINCE OWNED TRUCK APPROX. FROM 2003 TO CURRENT. *AK

I HAVE A 2000 FORD F-350 . I BOUGHT IT USED 6 MONTHS AGO. I RECENTLY HAD THE FRONT RIGHT TIRE LOSING AIR. UPON INSPECTION BY MY MECHANIC, IT WAS DETERMINED THAT THE ALLOY RIM HAD A STRESS CRACK IN IT. UPON CONTACTING FORD, THEY SAID THERE WAS NO RECALLS AND I WOULD HAVE TO REPLACE IT AT MY EXPENSE. I HAVE THE OLD RIM AND DIGITAL PICTURES OF IT ALSO. THIS WHEEL WAS NOT DAMAGED IN ANY WAY, AND THE CRACK SEEMS TO BE FROM A DEFECTIVE DESIGN. THE RIM DID NOT FAIL, BUT HAD I NOT NOTICED THE LOW AIR PRESSURE IN THE TIRE, IT MAY HAVE SOON FAILED. THANK YOU IN ADVANCE, ROBERT POWELL. *JB

RECALL ALREADY DONE ON OCTOBER 29, 2002 FOR WIPER MOTOR. ON NOVEMBER 12, 2004 I STARTED THE TRUCK UP AND A MINUTES LATER I LOOKED AND SAW SMOKE COMING FROM THE UNDERNEATH THE HOOD AND THE WIPERS RUNNING ALL BY THEMSELVES IN THE PARKED POSITION, THE WIPER MOTOR MALFUNCTIONED AGAIN. IT WAS TOWED TO THE DEALERSHIP AFTER CALLING THEM. TOTAL REPLACEMENT COVERAGE IS UNKNOWN AND DAMAGE IS UNKNOWN AT THIS TIME. *JB

FIRESTONE, STEELTEX LOAD RANGE E, LT265/75R16 DOT# VDW81XM329. WHILE DRIVING AT APPROXIMATELY 70 MPH, THE TIRE TREAD SEPARATED, EXPOSING THE BELTS AND CAUSING DAMAGE TO VEHICLE. THE INNER WHEEL WELL WAS DESTROYED AND THE LEFT FRONT FENDER WAS SLICED THROUGH FROM THE STEEL BELTS AND THE FRONT BUMPER WAS SCRATCHED, AND THE RUNNING BOARD WAS RIPPED OFF THE TRUCK. ALSO, THE MIRROR BRACKET WAS DAMAGED. *AK *SC *JB

REAR TIRE FAILED. UPON REVIEW THE REAR LEAF SPRING BROKE AND WAS DISPLACED TO THE POINT OF RIPPING OUT THE INNER SIDE WALL OF THE TIRE. AT THE TIME I WAS RUNNING ABOUT 70 MPH IN WEEKEND HIGHWAY TRAFFIC. *AK

FIRESTONE STEELTEX AT LT265/75R16 LOAD RANGE E. DOT# VNW81XL020. THE TIRE HAD 48,854 MI OF TREAD WEAR. THE CONSUMER EXPERIENCED TREAD SEPARATION. THE TIRE DID HOLD AIR. THERE WAS ALSO DAMAGE TO THE RIGHT REAR QUARTER PANEL OF THE VEHICLE. . *JB

FORD F350 SUPER DUTY CREW CAB: WHILE DRIVING THE INNER AND OUTER AXLE BEARING SEALS BLEW OUT, ALONG WITH THE HUB BEARING ON THE FRONT DRIVERS SIDE. THE WHEEL TURNED IN AND APPEARED AS IF IT WOULD COME OFF. UPON INSPECTION, THE PASSENGER SIDE INNER AND OUTER SEALS WERE ALSO HANGING OUT. CONTACTED FORD AND THEY SAID THAT THERE WAS NO RECALL OR SERVICE BULLETIN ON THE TRUCK. THEY WILL NOT HELP OUT IN ANY WAY. THERE IS ANOTHER REPORT ON THIS WEB SITE OF THE SAME INCIDENCE. OUR FRIEND WHO OWNS THE SAME YEAR F350 CHECKED HIS TRUCK TO FIND THE EXACT PROBLEM, THE SEALS ON THE AXLE BEARINGS ARE HANGING OUT!

RIGHT FRONT CALIPER WON'T RELEASE. APPARENTLY COMMON PROBLEM WITH 4X4 PER MECHANIC. GOUGED OUT ROTOR AND ALMOST CAUSED ACCIDENT. *JB

WHILE PULLING INTO MY GARAGE I HEARD A STRANGE CLUNCK NOISE FROM THE REAR END. IT TURNED OUT TO BE MY SPARE TIRE FALLING OFF. THE FACTORY SPARE TIRE CARRIER CABLE BROKE. THE CABLE SHOWED NO SIGNS OF CORROSION, I FINALLY FOUND THE CRIMPED ON END IN THE DRIVEWAY TO CONFIRM THE CABLE BROKE AT THE POINT OF CRIMP. THANK GOODNESS THIS HAPPENED IN MY DRIVEWAY AND NOT AT 70MPH, WHO KNOWS WHAT KIND OF DAMAGE OR WHO WOULD HAVE BEEN KILLED AS A RESULT OF THIS. I CALLED MY LOCAL FORD DEALERSHIP TO INQUIRE ON A RECALL OR AT LEAST A TSB, NONE EXISTED. I INSTALLED A SAFETY CHAIN TO CATCH THE SPARE SHOULD THE CABLE BREAK AGAIN.*AK

DRIVING AT 73 MPH ON US 131 EXPRESS WAY MY TRUCK ALL OF A SUDDEN LOST ALL POWER TO THE FUEL SYSTEM. CAUSING MY ENGINE TO SHUT DOWN AND CAUSING ME TO LOOSE POWER STEERING AND POWER BRAKES. CAUSING ME TO TAKE EVASIVE MEASURES TO KEEP FROM GETTING REAR ENDED AND BRAKING WITH BOTH FEET TO GET THE TRUCK SAFELY STOPPED. IN HAVING MY TRUCK REPAIRED AT THE FORD DEALERSHIP THEY FOUND THAT THE COMPUTER MODULE PART NUMBER XC3Z-12B599-AA SHORTED OUT CAUSING THE ENGINE TO SHUT DOWN. WHEN CHECKING OVER THE MODULE MYSELF. I FOUND A METAL VENT CAP COMING OFF FROM THE OUTSIDE OF THE MODULE IN TIPPING THE UNIT OVER WATER CAME DRIPPING OUT OF THE MODULE. THIS MODULE IS LOCATED BEHIND THE WHEEL WELL ON THE FIREWALL OF THE TRUCK. I FEEL THAT THIS IS A DEFFECTIVE AND HAZARDOUS DESIGN. THAT COULD/SHOULD BE FIXED SO THAT OTHER INCIDENTS DO NOT HAPPEN.

WHILE VEHICLE WAS PARKED CONSUMER SMELLED BURNING WIRES. VEHICLE CAUGHT ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION. *AK STATE FARM INSURANCE MADE AN INVESTIGATION ON THE VEHICLE AND SAID THAT THE FIRE WAS CAUSED BY A DESIGN DEFECT IN THE DASH. *LA

THE FRONT BRAKES ON MY F350 4X4 FAILED WHILE DRIVING INTERSTATE 77.*AK

2000 F350 DEVELOPED VIBRATION IN TIRES. LR TIRE HAD SEPERATED TREAD. LT265/75R16 FIRESTONE STEELTEX AT LOAD RANGE E.

THIS IS THE SECOND TOTAL TREAD SEPARATION OF A STEELTEX R4S TIRE ON A FORD F-350 TRUCK. BOTH CASES RESULTED IN EXTENSIVE BODY DAMAGE TO THE VEHICLE AND NEAR LOSS OFF CONTROL. THE FIRST CASE ENVOLVED COMPLETE FAILURE OF THE TIRE. THE SECOND CASE (THIS ONE REPORTED) WAS ONLY A TOTAL TREAD SEPARATION.*AK

SPARK PLUG BLEW OUT OF THE CYLINDER HEAD AT 76000 MILES. MY ORIGINAL OWNERS MENUAL ATES THE PLUGS DO NOT HAVE TO BE SEVICED FOR 100,000. THIS IS CERTAINLY A DESIGN ERROR SPARK PLUGS SHOULD NOT BLOW OUT OF THE CYLINDER HEAD.*AK

2000 F350 4X4 EXTENDED CAB HAD STEERING PROBLEMS SINCE DAY ONE. TRUCK WOULD WANDER AT ALL SPEEDS. DEALER FINALLY REPLACED STEERING GEAR BOX AT MY REQUEST AND AT MY COST AND TRUCK NOW STEERS AS IT SHOULD. THIS PART SHOULD BE A WARRANTY PART. *AK

SPARK PLUG BLEW OUT OF THE CYLINDER HEAD AT 75000 MILES. FORD MANUAL DOES NOT RECOMMEND SERVICING THE SPARK PLUGS FOR 100,000 MILES. THIS IS CERTAINLY A MANUFACTURER DEFECT. *CB

WHILE DRIVING, THE CONSUMER APPLIED THE BRAKES AND THE RESERVOIR PUMP FAILED. DEALER NOTIFIED. *AK THE POWER STEERING HOSE BLEW OUT FROM THE POWER STEERING RESERVOIR TO THE HYDRO BOOSTER. *JB *NM

WHILE DRIVING 55 MPH ON STRAIGHT LEVEL ROAD VEHICLE LOST STEERING ABILITY DUE TO PASSENGER'S SIDE TIE-ROD FALLING OFF.*AK

ON SEPTEMBER 17, 2003, I HAD A FIRESTONE STEELTEX RADIAL R4S ON THE RIGHT REAR OF MY 2000 FORD F-350 SEPARATE ON INTERSTATE 10 IN SOUTH MISSISSIPPI. FIRESTONE DID NOT REPLACE OR PAY FOR REPLACEMENT OF S TIRE IN VIOLATION OF THERE PRODUCT WARRANTY. AFTER FURTHER INSPECTION, I WAS ADVISED BY A GOODYEAR TIRE DEALER THAT I SHOULD REPLACE ALL FOUR TIRES AND HAVE DONE SO. *AK

PARTIAL TREAD SEPARATION/LOSS OF APPROXIMATELY ONE-THIRD OF THE TREAD WITH NO ADVANCE INDICATION OF ANY TIRE TROUBLE. THE ENTIRE INCIDENT AT FREEWAY SPEEDS (65-70) LASTED NO MORE THAN 15 SECONDS FROM THE TIME I HEARD SOMETHING HIT MY LEFT FRONT FENDERWELL UNTIL THE CHUNK OF TREAD FLEW OFF, (DAMAGING MY LOWER REAR FENDER) AND I CAME TO A FULL STOP. THANKFULLY, THE TIRE DID NOT DEFLATE. MY DUALLY PICK-UP HAS A FULL SET OF THESE TIRES TO INCLUDE THE THE SPARE WHICH REPLACED THE DEFECTIVE TIRE. SHOULD I CONTINUE TO DRIVE ON THESE TIRES? THE ENTIRE SET HAS UNDER 26,000 MILES OF LIGHT DUTY USE. *LA

WHILE DRIVING AT 75 MPH, THE REAR PASSENGER TIRE EXPLODED AND CAUSED MAJOR DAMAGE TO THE REAR END OF THE VEHICLE. THE CAUSE OF THE FAILURE WAS UNDETERMINED. *PH *TS *SCC *JB

FRONT LEFT TIRE TREAD CAME OFF. *LA

A 2000 FORD F-350, DUALLY. ON THE INTERSTATE, THE FRONT LEFT TIRE PEALED LIKE A BANANA. WE DIDN'T KNOW WHAT HAD TAKEN PLACE UNTIL GETTING THE TRUCK UNDER CONTROL AND STOPPED. THOUGHT IT WAS OUR TIME, VERY LUCKY THE TRUCK DID NOT ROLL OVER. THE DAMAGE WAS SHOCKING! FRONT BUMPER, ALONG THE WHOLE LEFT SIDE AND UNDER CARRIAGE TO THE BACK . DAMAGED! *JB

POWER STEERING LOCKS UP WHEN AT A STOP OR MOVING SLOWLY MAKING IT VERY DIFFICULT TO MANEUVER IN PARKING LOTS. *JB

WHILE DRIVING EASTBOUND ON I80 (TWO LANES EACH DIRECTION), TWO MILES WEST OF BATTLE MOUNTAIN, NV, THE DRIVERS SIDE FRONT TIRE OF MY 2000 FORD F350 TRUCK SEPARATED. THE ENTIRE TREAD CAME OFF THE TIRE, WHILE THE REST OF THE TIRE REMAINED INTACT, INCLUDE AIR IN THE TIRE. DURING SEPARATION, WHICH HAPPENED IN THE BLINK OF AN EYE, THE TREAD SEVERLY DAMAGED THE VEHICLE, INCLUDING THE FRONT BUMPER, THE WHEEL WELL, THE DRIVERS DOOR, AND DESTROYED THE SIDE STEP. THERE WERE NO INDICATORS THAT SOMETHING WAS GOING TO HAPPEN. NO VIBRATION, OR ANYTHING ELSE. THE TRUCK VIOLENTLY SWERVED TO THE LEFT, ACROSS THE FAST LANE, AND HEADING TOWARDS THE MEDIAN. FORTUNATELY, I WAS ABLE TO GET CONTROL OF THE VEHICLE BEFORE IN HEADED DONE THE EMBANKMENT AND INTO THE GULLY DIVIDING THE EAST AND WEST BOUND LANES, AND PULLED THE VEHICLE OVER ONTO THE RIGHT SHOULDER. THIS WAS EXTREMELY DIFFICULT, DUE TO THE BUMPER BEING PUSHED INTO THE TIRE.

WHILE DRIVING MY 2000 FORD F-350 ON FREEWAY 80 WEST FROM DAVIS CA, THE RIGHT REAR FIRESTONE STEELTEX ATX SIZE 245/75X16 DEVELOPED A LARGE BUBBLE AND TREAD SEPARATION. TIRE IS FACTORY SUPPLIED ORIGINAL WITH ONLY 30,760 MILES ON IT, TREAD STILL HAS 25% OF DEPTH LEFT. TIRE WAS ALWAYS NOTED TO HAVE RUN HOTTER THAN THE OTHERS, BUT DID NOT GIVE ANY WARNING THAT FAILURE WAS EMMANENT. WHEN I QUESTIONED 2 FIRESTONE DEALERS ABOUT THE HIGH RATE OF FAILURE FOR THEIR TIRES, I WAS TOLD THAT THESE TIRES HAVE ALWAYS BEEN GOOD AND THIS HAS NOT BEEN A PROBLEM. WHEN I QUESTIONED THEM ABOUT GETTING A SETTLEMENT TOWARD BUYING ANOTHER BRAND OF TIRE, THEY GOT QUITE UPSET AND DEFENSIVE, REFUSING TO DO ANYTHING EXCEPT A PRORATED AMOUNT TOWARD A NEW FIRESTONE TIRE. I TOLD THEM I WAS NOT INTERESTED IN HAVING ANOTHER FIRESTONE TIRE, AND THEY WOULD NOT DO ANYTHING ELSE. I WAS NOT AT ALL HAPPY ABOUT THE WAY I WAS TREATED, OR ABOUT HAVING TO SHELL OUT FOR ALL NEW TIRES, SINCE I DON'T TRUST THE FIRESTONE TIRES REMAINING ON THIS TRUCK.*AK

FIRESTONE STEELEX AT TIRE 265/75R16 ORIGINAL EQUIPMENT TIRE ON 2000 FORD F350 4X4 PICKUP TRUCK AT 27,700 MILES TRAVELING AT 45 MPH RIGHT REAR GROSS FAILURE OF TIRE. OUTSIDE SIDEWALL SEPARATED 90% FROM TREAD. *AK

L22575R16, LT RSFEB1998, DA180P013L. CONSUMER STATES THAT RIGHT REAR TIRE BLEWOUT AT 65 MPH. TIRE WAS REPLACED, AND AT 400 MILES BLEWOUT AGAIN. CAUSE UNKWOWN. *AK

INCIDENCE #1-FORD F-350 CREW CAB. 69,000 MILES. FRONT WHEEL BEARING WENT OUT CAUSING WHEEL TO SUDDENLY JERK PULLING TRUCK AND HORSE TRAILER INTO ONCOMING LANE AND LOCKING UP BRAKE SYSTEM, AND ALMOST JACKNIFING TRUCK AND TRAILER. TRUCK WAS HAULING HORSES AT THE TIME. TIRE AND WHEEL WAS WOBBLING AND LOOKED READY TO FALL OFF. HORSE SUSTAINED LEG INJURY CAUSING TEMPORARY LAMENESS. INCIDENCE #2- SAME TRUCK ONE WEEK LATER. LEAKING SEALS ON THE TURBO OIL LINES CAUSED ENGINE TO BE SHUT DOWN WITH NO WARNING(LIGHTS GAUGES ETC... ALL DRIVING FUNCTIONS INCLUDING POWER STEERING, BRAKES WERE LOST TO DRIVER. TRUCK WAS AGAIN HAULING LARGE HORSE TRAILER IN HEAVY HIGHWAY TRAFFIC ON WINDY HIGHWAY. TRUCK CRASHED ONTO SIDE OF ROAD. NO OTHER VEHICLES INVOLVED INCIDENCE #3- 8 DAYS LATER. DIESEL FUEL LINES CRACKED AND LEAKING. ELECTRICAL WIRING IS FRAYED IN ENGINE COMPARTMENT. MAY HAVE BEEN CAUSED FROM DEALERSHIP WORKING ON LAST REPAIR OF LEAKING TURBO SEALS.? FORD COMPANY OR DEALERSHIP HAS BEEN OF NO HELP IN DEALING WITH FAULTY PARTS, SAFETY ISSUES OR WARRANTY.*AK

WHILE DRIVING S/B INTERSTATE 5 - 11:00 AM AT 65 MPH SOUTH OF LAS VEGAS, I HAD A TREAD SEPERATION OF THE LEFT REAR TIRE (SINGLE REAR) CAUSING DAMAGE TO LEFT REAR QUARTER PANEL AND TAIL LIGHT.*AK

MY WIFE WAS DRIVING OUR 2000 F350 FORD TRUCK. IT WAS EQUIPPED WITH FIRESTONE STEELTEX TIRES ON THE REAR. AT A SPEED OF 55-60 MPH ON I17 IN ARIZONA MY WIFE EXPERIENCED A CATASTROPHIC TIRE FAILURE ON THE LEFT REAR TIRE. THERE WAS NO WARNING, THE TIRE SIMPLY SEEMED TO COME APART. SHE MANAGED TO CONTROL THE VEHICLE AND BRING IT SAFELY TO A STOP ON THE EDGE OF THE HIGHWAY. SHE STATED THAT THERE WAS NO DEBRIS IN THE ROAD. IT WAS APPROX. 12:30 PM, THE TEMPERATURE WAS IN THE 90'S, AND THE ROAD WAS DRY. AFTER ROAD SERVICE CHANGED THE TIRE SHE CONTINUED ON TO FLAGSTAFF, AZ AND DROPPED THE RIM AND DESTROYED TIRE OFF AT A DISCOUNT TIRE FOR REPLACEMENT OF THE TIRE. THE SERVICE WRITER STATED THAT WAS THE WORSE FAILURE HE HAD SEEN ON A TIRE. THE TIRES WERE OEM. THEY HAD BEEN INSPECTED THE WEEK BEFORE BY THE LOCAL FORD DEALERSHIP AS PART OF ROUTINE SERVICE THE SAME WEEK AS THE INCIDENT. THE DISTRUCTION OF THE TIRE RESULTED BODY DAMAGE TO THE LEFT FENDER AREA OF THE VEHICLE. I REQUESTED AND HAVE THE DESTROYED TIRE. I AGREE IN OVER 20 YEARS OF MILITARY SERVICE I HAVE NEVER SEEN TIRE THAT FAILED IN THIS MANNER. *NLM

MY 2000 F-350 FORD PICKUP EXPERIENCED A VIOLENT AND CONTINUAL SHAKING WHILE PROCEEDING AT HIGHWAY SPEEDS ON I-5 ON 24 MAY,2003. INVESTIGATION REVEALED A BUBBLE AND TREAD SEPARATION ON MY LEFT REAR LT 26575R16 FIRESTONE STEEL TEX RADIAL R4S TIRE. VEHICLE WAS CONTROLLED AND TIRE CHANGED PRIOR TO ANY INCIDENT. *NLM

BLOWOUT WITH TREAD SEPARATION WHILE DRIVING 70 MPH ON LEFT FRONT R4S II LT265/75/R16 STEELTEX RADIAL M/S LOAD RANGE E CAUSING AN ACCIDENT CROSSING MEDIAN OPPOSITE DIRECTION TRAFFIC BARELY MISSING AN ONCOMING 18 WHEELER THROUGH A DITCH/6FT CULVERT THROUGH A FENCE AND INTO FIELD. EXTENSIVE ($8.000+) DAMAGE TO F-350 SCLWB 4X4 FRAME AND FRONT END. 22800 MILES ON FACTORY TIRES, FORD HAD REFUSED TO REPLACE TIRES IN 2000 WHEN ASKED "THEY WEREN'T ON THE LIST" TIRES VDW8-DECATUR PLANT. *NLM

THE "DOOR AJAR" DASH LIGHT IS ON OFTEN. NO DOORS ARE OPEN. THE INTERIOR AND EXTERIOR BED LIGHT ARE ALSO LIGHT UP. THIS PROBLEM COMES AND GOES-OFTEN. I HAVE FOUR YOUNG KIDS, IT IS A BIG SAFETY ISSUE WHEN I SEE THE LIGHTS COME ON HEADING DOWN THE FREEWAY. *NLM

THE LEFT REAR TIRE EXPERIENCED TREAD SEPARATION. *JB

THE TREAD OF THE LEFT REAR TIRE SEPARATED WHILE DRIVING AND WRAPPED COMPLETELY AROUND THE AXLE. THE TIRE REMAINED INFLATED (FIRESTONE STEELTEX, 265/75R16, LOAD RANGE E, VNW81XL2500). *NLM *NLM

BOTH REAR INSIDE TIRES WENT FLAT AT THE SAME TIME. THE RIGHT TIRE HAD APPROX. 5390 MILES ON IT SINCE IT WAS THE SPARE FROM AN EARLIER BLOWOUT. THE LEFT TIRE HAD APPROX. 22875 MILES ON IT. I HAVE NOT FILED THIS WITH THE TIRE COMPANY DUE TO THEIR TREATMENT FROM THE FIRST FAILURE. I WAS TOWING A FIFTH WHEEL RV TRAILER AT THE TIME OF THE INCIDENT.*JB

INSIDE REAR DUAL TIRE BLEW OUT WHILE DRIVING CAUSING DAMAGE TO THE FENDER, LINER AND MUD FLAP. COMPANY STATED TIRE HAD BEEN RUN FLAT. I DON'T THINK IT WOULD HAVE BLOWN IF IT WAS FLAT. I ALSO HAD TWO MORE TIRES GO OUT IN JULY OF 2002 (I WILL FILE ON IT ALSO).

CLUTCH RELEASE BEARING (THROW OUT BEARING) ACTUATOR ARM FAILURE RESULTING IN MOVEMENT OF VEHICLE WHILE CLUTCH PEDAL IS DEPRESSED THIS IS THE SECOND FAILURE OF THE SUBJECT PART IN THE LIFE OF THIS SERIAL NUMBER TRUCK. THE FIRST OCCURRED AT APX. 37,000 MILES; THE SECOND AT APX. 95,000 MILES. BOTH REPAIRS WERE COMPLETED USING OEM PARTS. I AM IN POSSESSION OF THE SECOND FAILED PART AND WILL MAKE IT AVAILABLE FOR INSPECTION UPON REQUEST. THIS FAILURE IS A MAJOR SAFETY ISSUE AS THE POWER TRAIN CAN NOT BE INTERRUPTED BY NORMAL MEANS. THAT IS, ONE NORMALLY DEPRESSES THE CLUTCH PEDAL TO INTERRUPT POWER TRANSMISSION AND APPLIES BRAKE ACTION TO STOP THE VEHICLE. WHEN THE SUBJECT ARM FAILS, ONE DEPRESSES THE CLUTCH PEDAL AND THE VEHICLE CONTINUES MOVEMENT, CAUSING AN INHERENT REACTION DELAY TO ASSES THE ABNORMALITY, SUBSEQUENTLY FOLLOWED BY APPLICATION OF BRAKE PRESSURE TO STOP THE VEHICLE, CAUSING A SIGNIFICANT BIND IN THE TRANSMISSION, RESULTING IN THE INABILITY TO MOVE THE TRANSMISSION SHIFTER OUT OF GEAR, THEN ONE MUST EITHER TURN OFF THE IGNITION OR APPLY BRAKE PRESSURE OF SUFFICIENT FORCE TO STALL THE ENGINE; ALL OF WHICH HAS CONSUMED AND EXCEEDED A REASONABLY PLANNED STOPPING DISTANCE. THE RESULTING DELAY MAY RESULT IN INJURY OR DEATH OF BY STANDERS, SHOULD THEY BE PINCHED BETWEEN THE FAILURE VEHICLE AND A STATIONARY OBJECT. THE OPERATING NATURE OF A TRUCK OF THIS DESIGN INCREASES THE RISK OF INJURY OR DEATH, FOLLOWING THE DESCRIBED FAILURE. THE MANUFACTURER MARKETS THIS TRUCK TO

COLD MORNING STARTS, ENG: 7.3DIESEL. PROBLEM STARTED AROUND DEC. 31,2001. ON FIRST START ENG. IS SLOW TO START, WHEN IT DOES START IT GOES FROM 300RPM TO 1200RPM ABOUT THREE TIMES AND THEN SETTLES DOWN ON 800RPM'S AND RUNS OK. THE VEH. HAS BEEN IN APPROX. 4 OR 5 TIMES FOR THIS PROBLEM. THE DEALER SHOWS THE VEH, HAS BEEN IN TWICE FOR THIS PROBLEM. I HAVE TALKED WITH OTHER FORD TRUCK OWNERS WITH A 7,3 DIESEL ENG. AND NO ONE HAS HAD THIS PROBLEM. THE DEALER TELLS ME THAT THIS IS NORMAL FOR THE 7.3DI IN COLD WEATHER. QUESTION: IF THIS IS NORMAL WHY DID IT TAKE ALMOST A YEAR FOR THIS TO START. OTHER PROBLEMS: 1. AARM REMAN INJ PKG #8 CYL REPLACED. 2. WARPED ROTORS (FRONT), WARPED PADS HEAT CRACKED, CALIPERS REPLACED. 3. 50 MILES ON TRUCK, TRUCK PULLED TO THE RIGHT ALL THE TIME, TOOK INTO DEALER 4 TIMES, (CARSON CITY), DEALER IN FALLON CAME TO MY HOUSE TOOK THE VEH. TO FALLON & FIXED PULLING PROBLEM. 4. POWERTRAIN CONTROL MODULE (PCM) REPLACED. 5. EGR PRESSURE FEEDBACK-PFE/EXHAUST BACK PRESSURE -EBP-REPLACED. 6. DEALER INSTALLED FUEL HEATER KIT , SOP TOP WATER FUEL HEATER. ( ALL OF THIS & THIS DIESEL STILL GOES FROM 300RPM TO 1200RPM). I TALKED TO A DIESEL SHOP IN RENO, NV. AND HE SAID THERE IS SOMETHING WRONG WITH THIS DIESEL. I HATE TO THINK WHAT THIS IS DOING TO THE INTERNAL PARTS OF THIS ENG. I WOULD THINK THAT THE BEARINGS AT 300RPM ARE GETTING VERY LITTLE OIL PRESSURE. ( HOW EVER THE DEALER SAID THIS IS NORMAL AND THAT I SHOULD PLUG IN THE ENG. HEATER. QUESTION: HOW DO YOU PL

THE FRONT WHEEL ROTORS WARPED AND HAD TO BE RE-SURFACED AT 22,000 MILES. THE DEALER TURNED THE ROTORS AND INSTALLED NEW FRONT BRAKE PADS. AT 32,000 MILES THE FRONT ROTORS WERE WARPED AGAIN. WHEEL VIBRATION COULD BE FELT IN THE BRAKE PEDAL AND FRONT END ON HARD BRAKING WHILE GOING DOWN STEEP HILLS. THE DEALER SAID THAT THE WARPING WAS CAUSED BY EXCESSIVE HEAT. AT 32,000 AND 38,000 MILES THEY SAID THAT BRAKES ARE NOT COVERED UNDER WARRANTY AND THEY WOULD NOT CORRECT THE PROBLEM. THE RECOMMENED HAVING THE ROTORS TURNED AND INSTALLING "COMPOSITE/METALLIC" BRAKE PADS. THEY STATED THAT THE FACTORY BRAKE PADS ARE TOO HARD FOR THE ROTORS. THE BRAKE PADS HAVE SHOWN LITTLE WEAR. THERE IS AN EXHAUST BRAKE ON THE VEHICLE AND THE BRAKES HAVE BEEN USED SPARINGLY. I FEEL THAT THERE IS AN ENGINEERING PROBLEM WITH THE FRONT BRAKE SYSTEM. DT

COMPLETE TREAD SEPARATION ON ENTIRE TIRE FROM STEEL BELT CARCASS. *AK

THE STEERING BOX BROKE CAUSING INSURED TO LOSE CONTROL RUNNING OFF THE ROAD AND INTO A DITCH, CLAIM 03-3137-171. *JG

CLAIM NUMBER 59-V709-810 - CONSUMER STATES THAT THE STEERING ARM SHEARED FROM THE STEERING BOX, FORD STATED THIS WAS ACCIDENT RELATED, UNABLE TO FIND CONTACT ON STEERING ARM, NO CONTACT AROUND STEERING LINKAGE OR SPRING, CONTACT WAS MADE ON LEFT FRONT OF BUMPER BAR. *TT

WHILE IN MOTION, INSURED ATTEMPTED TO CHANGE LANES WHEN THE STEERING WENT OUT, CAUSING INSURED TO STRIKE ANOTHER VEHICLE IN THE REAR, RIGHT FRONT WHEEL HAD BEEN PUSHED BACK CAUSING SECTOR SHAFT TO BREAK, CLAIM 31-3069-892. *JG

CLAIM NUMBER 11-3548-745 - WHILE IN STOP AND GO TRAFFIC IN THE FAR RIGHT LANE, VEHICLE 1 WAS TRAVELING IMMEDIATELY BEHIND VEHICLE 2, AS VEHICLE 2 STOPPED FOR TRAFFIC, VEHICLE 1 ATTEMPTED TO CHANGE LANES, WHEN SUDDENLY THE STEERING WOULD NOT RESPOND, CAUSING VEHICLE 1 TO COLLIDE WITH REAR RIGHT SIDE OF VEHICLE 2, INJURIES WERE A RESULT OF IMPACT. *TT