1999 Ford E-250

Defect. FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Risk. A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Remedy. FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Defect. FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Risk. AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Remedy. DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Defect. ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Risk. THIS COULD RESULT IN AN UNDERHOOD FIRE.

Remedy. DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Defect. ON CERTAIN VANS EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT.

Risk. IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO A WHEELCHAIR OCCUPANT.

Remedy. DEALERS WILL INSPECT AND REPLACE THE WHEELCHAIR SECUREMENT RETRACTORS AS NECESSARY. SURE-LOK WILL HANDLE THE REPAIRS FOR THIS CAMPAIGN. OWNERS SHOULD CONTACT SURE-LOCK AT 1-908-231-1804 OR MOBILITYWORKS AT 1-800-769-8267.

Defect. VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."

Risk. THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.

Remedy. OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Defect. VEHICLE DESCRIPTION: UTILITY VANS EQUIPPED WITH THE "60/40" HINGED SIDE CARGO DOORS. THE STRIKERS FOR THE 60/40 DOOR SINGLE LATCH SYSTEM WERE FOUND TO CONTAIN STRESS CRACKS AT THE STRIKER WIRE LOWER STAKE JOINT. STRIKERS WITH STRESS CRACKS MAY NOT MEET THE REQUIREMENTS OF FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."

Risk. IN THE EVENT OF A CRASH, THE DOOR STRIKERS MAY NOT HOLD THE DOOR, INCREASING THE RISK OF PERSONAL INJURY OR PROPERTY DAMAGE.

Remedy. DEALERS WILL REPLACE THE DOOR STRIKER.

SPARK PLUG EJECTION WITH PLUG PARTS GOING INTO MOTOR AND PUTTING HOLE IN PISTON-THIS IS A WORK VAN-NO WAY TO ECONOMICALLY FIX IT. HAPPENED WHEN DRIVING 25MPH ON CITY STREET

TL* THE CONTACT OWNS A 1999 FORD E-250. THE CONTACT STATED THAT WHILE GOING 30 MPH, THE BRAKE LINE FAILED. THE CONTACT STATED THAT HE DEPRESSED THE BRAKE PEDAL AND IT WENT ALL THE WAY TO THE FLOORBOARD. THE FRONT BRAKES STILL FUNCTIONED BUT THE REAR BRAKES FAILED. THE VEHICLE WAS NOT INSPECTED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 130,000. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE.

SUBJECT: FORD V-8 TRUCK ENGINE SPARK PLUG BLOWOUT COMMENTS: I AM A CONSTRUCTION COMPANY BUSINESS OWNER THAT USES FORD VANS FOR OUR WORK. THIS PAST WEEK WE HAD A SPARK PLUG BLOW OUT OF THE HEAD OF ONE OF OUR VEHICLES THIS IS THE THIRD TIME IT HAS OCCURRED ON THIS PARTICULAR VEHICLE EACH TIME WE HAVE TO PLACE IT IN THE SHOP IT COSTS NEARLY $300.00 TO HAVE IT REPAIRED. NOT TO MENTION THE LOSS OF USE OF THE TRUCK FOR 2 -3 DAYS. WHILE RESEARCHING THE PROBLEM ONLINE I HAVE DISCOVERED THAT THIS HAS BEEN A FAIRLY COMMON OCCURRENCE ON MANY OF THESE ENGINES FOR SEVERAL YEARS. I WONDER IF THEIR IS SOME RECOURSE THRU FORD OTHER THAN A CLASS ACTION LAW SUITE TO RECOVER THE EXPENSE? PLEASE RESPOND YOURS TRULY[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

1999 FORD E-250 1999 TRUCK ABS AND BRAKE LIGHT STAYS ON, AND BRAKES ARE ALL GOOD. DON'T LET AUTO OWNERS DISCONNECT DASH LIGHTS. *TR

TL* THE CONTACT OWNS A 1999 FORD E-250 ECONOLINE VAN. THE CONTACT STATED WHILE DRIVING AT 27 MPH DOWNHILL, THE BRAKES WERE APPLIED BUT DID NOT ENGAGE. THE CONTACT THEN SHIFTED INTO SECOND GEAR AND WAS ABLE TO COME TO A STOP. UPON FURTHER INSPECTION, THE CONTACT FOUND THAT THE REAR BRAKE LINES ON THE VEHICLE WERE CORRODED. THE VEHICLE WAS INSPECTED ONE YEAR PRIOR TO THE FAILURE AND THERE WERE NO SIGNS OF RUST OR CORROSION ON THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 158,563.

I RETURNED TO MY TRUCK AFTER WORK TO GO HOME. WHEN I STARTED IT, THERE WAS A LOUD POPPING NOISE FROM UNDER THE HOOD. AFTER INVESTIGATION, I FOUND THE #3 SPARKPLUG ON THE PASSENGER SIDE GONE. IT WAS BLOWN OUT. *TR

1999 FORD ECONOLINE WITH MULTIPLE ISSUES. CONSUMER STATES THAT THIS VEHICLE HAS MULTIPLE ISSUES WITH BREAKING DOWN. HE ALSO STATES THAT THIS VEHICLE HAS HAD SEVERAL ENGINE PROBLEMS, TIRE PROBLEMS, WINDSHIELD WIPER MOTOR PROBLEMS. *KB THE CHECK ENGINE LIGHT ILLUMINATED, THE LEFT REAR DOOR HANDLE, BATTERY, ALTERNATOR, RADIO, BALL JOINTS WERE REPLACED. THE BRAKE ROTORS AND PADS WERE REPLACED. THE AXLE SHAFT SEALS, MASS AIR FLOW SENSOR, CATALYTIC CONVERTER WERE REPLACED. THE VALVE SPRING WAS BROKEN, THE FRONT TIE ROD ENDS AND DRAG LINKS WERE REPLACED, THE TIRES, WIPER BLADES AND GASKETS WERE REPLACED. THE VAN WAS SERVICED 9 TIMES FOR THE CHECK ENGINE WARNINGS. *JB

MY NAME IS [XXX] . I AM A SMALL BUSINESS OWNER IN BARTLETT ILLINOIS. I OWN A FORD ECONOLINE 250 & A FORD EXPEDITION. BOTH VEHICLES HAVE BEEN "FORD SERVICED" SINCE NEW. I RECENTLY HAD A SPARK PLUG BLOW OUT OF THE ENGINE. I HAVE HAD MANY A CAR IN MY DAYS AND I HAVE NEVER HEARD OF THIS FAILURE. FORD INSISTED THIS WAS NOT AN ENGINE DEFECT, AND ALTHOUGH THEY WERE THE ONLY SERVICE PEOPLE THAT EVER WORKED ON THE VEHICLE, I WAS STILL RESPONSIBLE FOR THIS REPAIR. THE COST AROUND $750. MONEY IS IMPORTANT, BUT PRINCIPLE IS MORE IMPORTANT. AFTER SEARCHING THE WEB I FOUND THIS: HTTP://WWW.CONSUMERAFFAIRS.COM/AUTOMOTIVE/FORD_SPARK.HTML HUNDREDS OF COMPLAINTS WITH THE SAME FAILURE. IT IS MY HOPE THAT YOU CAN DO SOMETHING TO BRING THIS TO THE PUBLIC'S ATTENTION AND FORCE FORD INTO ADMITTING FAULT. THIS IS WHY PEOPLE DO NOT BUY AMERICAN ANY LONGER; TO BE HONEST I HAVE ALWAYS BEEN A FORD PERSON; NOT ANY MORE. I AM SELLING BOTH VEHICLES AND NEVER BUYING ANOTHER FORD AGAIN. THANKS IN ADVANCE FOR ANY HELP YOU CAN GIVE IN THIS MATTER. SINCERELY, [XXX] CES, INC. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WE PURCHASED A 99 E250 CARGO VAN IN NOVEMBER 06, WE ARE NOT SURE IF OLD OWNER HAD SAME PROBLEM, WITHIN 2 WEEKS WE HAD PROBLEMS WITH VAN STARTING. WE ONLY HAVE THE PROBLEM AFTER THE CAR IS SHUT OFF. IT DOES NOT STALL WHILE RUNNING. WE CAN TURN IT OFF AND TRY TO START IT RIGHT BACK UP, IT WILL NOT TURN ALL THE WAY OVER. WE HAVE REPLACED THE FUEL PUMP AND HAD IN THE SHOP 3 TIMES. THEY ARE UNABLE TO FIND ANYTHING WRONG. IT HAS BEEN HOOKED UP TO A COMPUTER, WHEN IT IS STARTED IT SHOWS NOTHING WRONG, WHEN IT WON'T START IT WON'T READ AT ALL. WITH NO RHYME OR REASON IT WILL START ON IT'S OWN. SOMETIMES IT WILL BE A FEW TRIES AND SOMETIMES IT IS DAYS TILL IT STARTS. OUR MECHANIC IS AT A LOSS AS TO HOW TO FIX THIS. IT HAS CAUSED MY HUSBAND TO BE STRANDED AT JOBS 4 TIMES NOW. *TR

AFTER FULL ACCELERATION, THE THROTTLE ON MY 1999 FORD E250 STUCK WIDE OPEN. THE VEHICLE DID NOT SHUT OFF AND THERE WAS NO TIME TO SHIFT INTO NEUTRAL. THE VEHICLE HAS ADAPTIVE CONTROLS MAKING SHIFTING MORE DIFFICULT THAN FOR A NON-DISABLED DRIVER. THE ADAPTIVE EQUIPMENT COULD BE THE CAUSE, BUT MOST LIKELY IT WAS THE FORD THROTTLE. *NM

SPARK PLUG BLEW OUT OF RH HEAD OF FORD E-250 VAN. *JB

VERY BAD BUMP AND CLUNKING SOUND FROM STEERING WHEN GOING OVER ROUGH SURFACES AT SLOW SPEEDS OR WHEN GOING DOWN HILL AND PUTTING ON BRAKES ESPECIALLY IN A TURN. BOUNCES OVER ROAD AND HARD TO CONTROL WHEN GOING DOWN HILL AND USING BRAKES. THE SAME PART HAS BEEN REPLACED IN THE STEERING COLUMN BY DEALER 7 TIMES AND ONLY STAYS FIXED FOR SHORT TIME. IT CONTINUALLY GETS WORSE UNTIL IT IS UNSAFE TO DRIVE. I BELIEVE BRAKES AND STEERING COLUMN ARE THE PROBLEMS. BOTH HAVE WORN OUT EXCESSIVELY. I HAVE HAD PROBLEMS SINCE BUYING THE VAN NEW. FORD GAVE ME AN EXTENDED WARRANTY BECAUSE THEY COULDN'T FIX IT. *JB

VEHICLE WAS TRAVELING AT 65 MPH WHEN ALL OF A SUDDEN THE SPARK PLUG BLEW OUT, CAUSING THE VEHICLE TO STALL. CONSUMER WILL CONTACT MANUFACTURER.*AK

MY HUSBAND AND I EXPERIENCED TWO BLOW OUTS ON FIRESTONE TIRES DURING A TRIP IN JULY-AUGUST, 2004. AFTER HAVING TO REPLACE ALL OF THE TIRES DURING THE TRIP WE CALLED FORD AND FIRESTONE. FIRESTONE OFFERED TO PAY$100.00 TO COVER SOME OF THE EXPENSES OF SPARE TIRE REPLACEMENT(AFTER THE BLOW OUTS AND BEFORE WE PURCHASED NEW TIRES BECAUSE WE FEARED FURTHER PROBLEMS) BUT WE REFUSED THIS. WE BELIEVE THESE STEELTEX RADIAL R4S TIRES ARE HAZARDOUS AND SOME WARNING SHOULD BE ISSUED. WE WERE FORTUNATE TO HAVE SURVIVED WITHOUT BODILY INJURY. I WILL CALL AND/OR SEND A COPY OF THE LETTER SENT TO THE FORD DEALER WHO SOLD THE VAN TO SPORTS MOBILE WHO CONVERTED IT INTO A CAMPING VAN. I ALSO SENT A COPY OF THIS LETTER TO FIRESTONE. *AK

BEGINING IN THE YEAR 2000, THE 98 E150 WENT THROUGH THE FACTORY MOTOR AT 90,000 MILES. COOLANT MIXING WITH OIL WITHOUT EVER OVERHEATING. FORD WAS GOING TO FIX UNTIL I TOLD THEM THAT MY MY VEHICLE WAS REPAIRED AT A PRIVATELY OWNED SHOP VERSUS THE DEALERSHIP (MY BROTHER OWNS THE SHOP AND THE LOCAL DEALER SENDS HIM ALL OF THEIR DIFFICULT REPAIRS). IT TOOK ME APPROXIMATELY 16 MONTHS COME UP WITH THE MONEY TO HAVE THE MOTOR MACHINED AND REPAIRED PROPERLY. TOTAL COST $4000. I FINALLY FELT CONFIDENT THAT THE VEHICLE WOULD SERVE ME WELL, UNTIL TWO WEEKS AGO, THE TRANSMISSION LOCKED UP . OVERDRIVE MESSED UP AND CAUSED OTHER PROBLEMS AS WELL. NOW I HAVE NO WHEELS UNTIL I COME UP WITH $1700 MORE. I'M IN THE CONSTRUCTION INDUSTRY,AND IF USE INFERIOR TECHNIQUES OR PRODUCTS I AM HELD ACCOUNTABLE. SHOULDN'T FORD LIVE BY AT LEAT THE SAME STANDARDS AS A LOWLY CARPENTER.*AK

1999 FORD E250 CARGO VAN, 24K MILES, ALL 4 BALL JOINTS FAILED. REPLACEMENT SCHEDULED, WILL RETAIN PARTS. KNOW OF TWO OTHER LOW MILEAGE, LATE MODEL FORD TRUCKS WITH SIMILAR LOW MILEAGE BALL JOINT FAILURES. FORD DOES NOT BELIEVE THEY ARE RESPONSIBLE YET THEIR OWN SERVICE PEOPLE ARE TELLING ME THEY SEE AN INORDINATE NUMBER OF THESE FAILURES AND WONDER WHY THERE HAS BEEN NO RECALL.*AK

I OWN A FORD 1999 E250 VAN THAT HAS BEEN CUSTOMIZED BY THE SPORTSMOBILE COMPANY INTO AN RV. IT CAME WITH FOUR FIRESTONE STEELTEX RADIAL R4S LT225/75R16 M/S TIRES. AS I WAS DRIVING IN THE LEFT LANE OF I-505S (JUST N OF EXIT FOR ALLENDALE RD), THE TREAD ON MY LEFT REAR TIRE SEPARATED. I WAS ABLE TO SAFELY PULL ONTO THE RIGHT SHOULDER. I DROVE (AT REDUCED SPEED ON THE DAMAGED TIRE) TO THE MIDWAY RD RV PARK AT THE NEXT EXIT. THERE I MOUNTED THE SPARE. THE TIRES HAD 22K MILES ON THEM AND HAD BEEN MAINTAINED PROPERLY.*AK

GAS LEAKED FROM THE FUEL FILLER VALVE WHEN THE VEHICLE WAS BEING REFUELED (CNG). *NLM

THE HEAD GASKET FAILED, WHICH CAUSED OIL TO LEAK. *JB

THE VEHICLE SWAYED WHEN DRIVING AT A HIGH RATE OF SPEED. THE MECHANIC NOTICED A STABILIZER BAR HAD NOT BEEN INSTALLED WHICH CAUSED THE FRONT TIRE TO WEAR ON THE INSIDE. *JB *NLM