2001 Jeep Wrangler

Defect. CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy. PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Defect. CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.

Risk. LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.

Remedy. AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.

Defect. CERTAIN AFTERMARKET AIRTEX ELECTRIC FUEL PUMPS INSTALLED FOR USE AS REPLACEMENT EQUIPMENT FOR CERTAIN 1997-2004 JEEP WRANGLER; 1997-2001 JEEP CHEROKEE; 1997-2004 JEEP GRAND CHEROKEE; AND 2000-2003 DODGE DAKOTA VEHICLES. THE PLASTIC ELECTRICAL GROMMET CONNECTORS AT THE TOP OF THE FUEL PUMP MODULE ARE NOT COMPATIBLE WITH AUTOMOTIVE FUELS AND MAY DEGRADE CAUSING A POTENTIAL LEAK PATH FOR FUEL.

Risk. IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.

Remedy. AIRTEX WILL NOTIFY ITS CUSTOMERS AND WILL REPLACE THE AFFECTED FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 25, 2006. OWNERS MAY CONTACT AIRTEX CUSTOMER SERVICE DEPARTMENT AT 1-800-880-3056.

Defect. BESTOP AFTERMARKET REAR SHELL ROOF RACKS,MANUFACTURED BETWEEN APRIL 27 AND MAY 20, 2004, DESIGNED FOR USE WITH THE BESTOP HARDTOP MADE FOR THE 1986-1995 AND 1997-2003 JEEP WRANGLER. THE COCKPIT COVER MAY NOT STAY LATCHED TO THE ROOF RACK BECAUSE THE LATCH BRACKET MISPOSITIONS THE ROTARY LATCH TO THE COCKPIT COVER. AS A RESULT, THE COCKPIT COVER MAY NOT STAY LATCHED TO THE ROOF RACK AND COULD SEPARATE FROM THE ROOF RACK. THIS RECALL ONLY PERTAINS TO AFTERMARKET REAR SHELL ROOF RACKS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON JEEP WRANGLER VEHICLES BY DAIMLERCHRYSLER.

Risk. SHOULD THIS OCCUR, THE COCKPIT COULD CAUSE INJURY BY STRIKING PERSONS OUTSIDE THE VEHICLE OR COULD BECOME A DISTRACTION OR AN OBSTACLE TO OTHER DRIVERS, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy. BESTOP WILL NOTIFY ITS CUSTOMERS AND PROVIDE A REPAIR KIT AND INSTALLATION INSTRUCTIONS FREE OF CHARGE. OWNER NOTIFICATION BEGAN JUNE 16, 2004. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BESTOP CUSTOMER SERVICE DEPARTMENT AT (800) 845-3567.

Defect. ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.

Risk. THIS COULD RESULT IN A VEHICLE FIRE.

Remedy. DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Defect. ON CERTAIN SPORT UTILITY VEHICLES, WATER AND IMPURITIES CAN ENTER INTO THE IGNITION SWITCH, CAUSING A SHORT CIRCUIT.

Risk. THIS COULD RESULT IN A VEHICLE FIRE.

Remedy. DEALERS WILL REPLACE THE IGNITION SWITCH WITH A REDESIGNED SWITCH. OWNER NOTIFICATION BEGAN APRIL 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Defect. VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.

Risk. IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.

Remedy. OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.

The airbag clock spring has failed causing an airbag light and shut down of airbag system. The part, Airbag clock spring with speed control has been discontinued by Jeep and nobody makes the 2001-2002 clock springs aftermarket.

There is a known problem with the electrical wiring to the climate control panel including the blower motor fan switch. The wiring attached to the assembly gets too hot and melts the blower motor fan switch. When this happens, you are unable to turn on any heat/ac/air speeds. You are not able to select any speed to turn on the air which means you can’t use it to defrost the windshield. This can lead to a poor visibility situation. I am the original owner of my 2001 TJ and I’ve had to have this problem fixed multiple times. There are several videos & discussions about this problem in Jeep forums. Chrysler should’ve recalled it years ago..

MY JEEP WAS MAKING GRINDING SOUNDS WHEN I SHIFTED GEARS. AT FIRST IT WAS JUST A QUICK GRIND (METAL AGAINST METAL). THEN IT GOT PROGRESSIVELY WORSE AS THIS LAST WEEK WENT BY. IT BECAME ALMOST IMPOSSIBLE TO SHIFT INTO REVERSE AND IT WOULD POP OUT OF GEAR UNEXPECTEDLY WHILE GOING DOWN THE ROAD.LUCKILY I DIDN'T DRIVE IT MUCH. I TOOK IT TO MY MECHANIC AND HE SAID I WAS LUCKY- MY TRANSMISSION(?) WAS TILTED AND SITTING ON SOMETHING AND THAT WAS CAUSING THE NOISE (THE LUCK WAS THAT THE TRANSMISSION DIDN'T FALL ALL THE WAY DOWN). THE DESCRIPTION OF THE PROBLEM FROM PRESTIGE HI-TECH IS "CHECK FOR NOISE/ GRINDING IN DRIVETRAIN. FRAME BADLY RUSTED OUT, CROSS MEMBER UNDER TRANSFER CASE, BOLTS PULLED OUT OF RUSTED FRAME." I WAS THEN TOLD IT WAS UNSAFE TO DRIVE. VISUALLY IT IS IN GREAT CONDITION WITHOUT RUST ON THE BODY. PRESTIGE SAID BOTH SIDES OF THE FRAME ARE RUSTED THROUGH BECAUSE OF POOR DESIGN. THERE WERE NO HOLES FOR TRAPPED WATER TO ESCAPE THROUGH.

TL* THE CONTACT OWNS A 2001 JEEP WRANGLER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEED, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO JACKSONVILLE CHRYSLER DODGE JEEP RAM ARLINGTON (9600 ATLANTIC BLVD, JACKSONVILLE, FL 32225) WHERE IT WAS DIAGNOSED THAT THE PASSENGER AIR BAG NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, YEARS LATER THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 56,468.

FRAME ROTTED BY TRAIL ARMS AND CENTER BY SKID PLATE WHY DID CHRYSLER NEVER RECALL THESE FAULTY FRAMES?

FRAME BEGAN ROTTING OUT AT ROUGHLY 100,000 MILES. I DISCOVERED THIS WHILE DRIVING DOWN THE HIGHWAY ON MY COMMUTE HOME FROM WORK. WHILE ACCELERATING I FELT A SUDDEN POWER LOSS. THIS WENT ON FOR ANOTHER ROUNDTRIP THE FOLLOWING DAY. UPON RETURNING HOME THE FOLLOWING DAY I SAW SOMETHING HANGING FROM UNDERNEATH THE VEHICLE. IT WAS THE SKID PLATE, HANGING BY THE PASSENGER'S SIDE BOLTS, SUPPORTING THE ENTIRE WEIGHT OF THE DRIVETRAIN. THE DRIVESHAFT BEING AT THAT UNNATURAL ANGLE IS WHAT CAUSED THE LOSS OF POWER. TO THINK THAT I HAD DRIVEN 100 MILES THAT WAY WAS SLIGHTLY UNSETTLING. SINCE THEN I HAVE HAD THE FRAME WELDED, WHICH RAN $1,200. I HAVE SINCE HAD THE REAR RAILS (BEHIND REAR WHEELS) REPAIRED FOR AN ADDITIONAL $400. MY FRONT BODY MOUNT HAS ALSO ROTTED OUT, WHICH I FIXED MYSELF FOR $10, BUT SHOULD PROBABLY BE WELDED BY A PROFESSIONAL. BOTH MECHANIC AND WELDER SUGGESTED THAT FRAME ROT OCCURRED DUE TO LACK OF HOLES FOR WATER TO DRAIN OUT AND THAT THE SITTING WATER AND SALT JUST ATE AWAY AT EVERYTHING. THE CAR NOW HAS 215,000 MILES ON IT. I AM OTHERWISE HAPPY WITH THE CAR, BUT IT UPSETS ME THAT I COULD HAVE HAD A MAJOR ACCIDENT DUE TO THE POOR DESIGN OF THE FRAME. SEEMS STRANGE THAT THERE HAS NOT BEEN A FIX FOR THE ISSUE, NOR A RESPONSE FROM CHRYSLER TO ADDRESS THE FACT THAT PEOPLE CAN DIE AS A RESULT OF THE FRAME ROTTING OUT. MAYBE THAT'S WHAT HAS TO HAPPEN FOR A FIX?!? AT 200,000+ MILES YOU WOULD THINK I WOULD GO STRAIGHT BACK TO A WRANGLER ONCE THIS ONE BITES IT, BUT I WILL NEV

SPONTANEOUS VEHICLE FIRE WHILE PARKED FOR TWO WEEKS

TL* THE CONTACT OWNS A 2001 JEEP WRANGLER. UPON INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE FRAME OF THE VEHICLE WAS COMPLETELY RUSTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO CONFIRMED THAT THE VEHICLE'S FRAME WAS RUSTED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT THE FRAME WAS NO LONGER BEING MANUFACTURED. THE FAILURE MILEAGE WAS 107,000.

THE FRAME ROTTED OUT WHERE THE SUSPENSION CONNECT TO THE FRAME

MY JEEP FRAME RUSTED OUT, FORCING US TO PURCHASE A NEW VEHICLE IN 2015. I AM THE ORIGINAL OWNER, FEMALE, NEVER WENT OFF-ROAD WITH IT AND IT WAS GARAGE KEPT. LESS THAN 90,000 MILES ON IT TODAY. UPSET THAT I CANNOT DRIVE IT BECAUSE OF THE FRAME AND CANNOT FIND FRAME TO REPLACE IT. I STILL OWN IT AND STILL WAITING TO FIND A FRAME FOR IT. NOW SITTING IN MY DRIVEWAY. EXCELLENT CONDITION, EXCEPT FOR THE FRAME! SEE PHOTO AS PROOF.

DEFINITELY HAD A BAD EXPERIENCE WITH THE DEATH WOBBLE IN MY JEEP ALMOST CAUSING ME TO BE IN A CAR ACCIDENT. I FEEL THE PAIN IN BACK AND NECK. WILL HAVE TO GO TO DOCTORS TO GET THAT CHECKED. I WAS DRIVING ON INTERSTATE 83 WHEN I HIT A BUMP ON THE ROAD NEAR CONSTRUCTION AREA WHEN JEEP BEGAN TO WOBBLE OUT OF CONTROL. LUCKILY ANOTHER JEEP ON THE ROAD SAW WHAT WAS GOING ON AND MADE SPACE FOR ME TO EXIT THE HIGHWAY. I CALLED THE TOW TRUCK AND HAD IT TOWED. *DSY

ENTIRE FRAME IS RUSTED CAUSING THE TRANSMISSION TO FALL OUT. ALMOST MADE MY SON CRASH INTO A TREE AFTER LOSING CONTROL OF THE VEHICLE.

FRAME ROTTING FROM INSIDE OUT.THIS IS A SEVERE SAFETY CONCERN.THIS IS A PROBLEM RELATED TO CERTAIN YEARS OF WRANGLERS. THE SEVERITY OF THE PROBLEM SHOULD RESULT IN A RECALL AS HAS BEEN WITH OTHER MANUFACTURERS WITH SAME PROBLEM TO RESOLVE THIS VERY UNSAFE CONDITION.

TL-CONTACT OWNS A 2001 JEEP WRANGLER--- SPOKE WITH CHRYSLER --- CHRSYLER STATED NO RECALLS ON VEHICLE---HORN IN VEHICLE DOES NOT WORK AT ALL AND AIRBAG LIGHT IS ON... CONTACT WAS GIVEN NUMBER TO JEEP REGARDING AIR BAG LIGHT....0 RECALLS ASSOCIATED WITH THIS VIN

FRAME RUSTING FROM INSIDE REAR CONTROL ARM FELL OFF CAUSING WRECK

FRAME IS COMPLETELY RUSTED ONLY 90K MILES. THE TRANSMISSION DROPPED BECAUSE THE STRUCTURE HOLDING IT UP WAS BOLTED TO THE FRAME AND BECAUSE THE ENTIRE FRAME IS COMPLETELY RUSTED IT CANT BE FIXED. ITS SO BAD A NO BODY SHOP WILL FIX IT, RUST KIT IS NO HELP WITH HOW BAD THIS FRAME IS RUSTED. THIS IS COMPLETELY RIDICULES THAT A FRAME IS THIS BADLY RUSTED AT 90K MILES.

I WAS DRIVING WITH THE AIR CONDITIONER ON WHEN I SMELLED BURNING PLASTIC, THEN SMOKE CAME OUT OF THE AIR VENTS. I PULLED OVER AND TURNED OFF THE AIR CONDITIONER AND GOT OUT OF THE VEHICLE. AFTER ABOUT 15 MIN THE SMELL DISSIPATED AND I CONTINUED ON WITHOUT THE AIR CONDITIONING. LATER I REMOVED THE COVERS AND FOUND THAT THERE HAD BEEN A FIRE IN THE PLUG THAT GOES TO THE BLOWER MOTOR RESISTOR

FUEL LEAKS FROM UNDER TANK AFTER FILLING UP WITH GAS AT GAS STATION

THIS 2001 JEEP WRANGLER TJ FAILED NY STATE SAFETY INSPECTION DUE TO FRAME RUST. PURCHASED NEW ON 06/01/2001 FROM A JEEP DEALERSHIP IN LINDENHURST, NY AND ONLY HAS 116,097 MILES ON A 4.0 ENGINE. THIS TUBULAR FRAME RUST IS PREMATURE DUE TO LACK OF "WEEP HOLES" THAT ALLOWS WATER TO EXIT THE FRAME, THEREBY PROMOTING RUST FROM THE INSIDE, OUT AND IS COSTLY TO REPAIR (SEE ATTACHMENT). NOTE... TOYOTA HAS HAD SIMILAR "RUSTY FRAME" ISSUES, BUT TOYOTA HAS DONE THE "RIGHT THING". SEE WRITE-UP AND VIDEO HERE: HTTP://AUTOWEEK.COM/ARTICLE/RECALLS/TOYOTA-FRAME-SETTLEMENT-COULD-COST-COMPANY-34-BILLION ... I LOVE MY WRANGLER, BUT IF JEEP REFUSES TO HELP WITH THIS (WIDE SPREAD) RUSTY FRAME ISSUE, I MAY VERY WELL MAKE A TOYOTA MY NEXT PURCHASE! THIS IS NOT JUST A CUSTOMER SERVICE ISSUE, THIS IS A BIG SAFETY ISSUE!!!

COMPLETE CORROSION THROUGH THE FRAME JUST BEHIND THE REAR UPPER AND LOWER TRAILING ARMS MOUNT LOCATIONS. TWO LARGE HOLES APPROXIMATELY 1" IN DIAMETER. STRESS CONCENTRATIONS DUE TO CORRODED METAL AND CYCLICAL FATIGUE HAS CAUSED CRACK PROPAGATION AND CONNECTION OF THE TWO HOLES WITH ONE ANOTHER.

TL* THE CONTACT OWNS A 2001 JEEP WRANGLER. THE CONTACT STATED THAT THERE WAS EXTENSIVE RUST AND CORROSION TO THE FRAME. THE DEALER AND THE MANUFACTURER HAD BEEN NOTIFIED OF THE FAILURE AND PROVIDED NO RECOMMENDED SOLUTION TO PREVENT THE CONDITION THE VEHICLE WAS TO BE INSPECTED AND DIAGNOSED BY AN INDEPENDENT MECHANIC AND A DEALER. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. UPDATED 06/13/17*LJ *CN

FRAME RUSTED COMPLETELY

I HAD A FIRE DUE TO A RECALLED IGNITION SWITCH THAT WAS NEVER REPAIRED, I HAD NO IDEA WHEN I BOUGHT THE USED JEEP FROM THE DEALER. CHRYSLER IS NOW DENYING ANY REQUEST TO FIX THE PARTS DAMAGED BY THE FIRE

I LEFT MY TOP OFF OF MY JEEP WRANGLER AND IT RAINED HARD INTO THE NIGHT AND NEXT MORNING. I HEARD THE HORN GOING OFF RANDOMLY SO I RAN OUTSIDE AND THE DRIVERS SIDE DASH AND STEERING COLUMN WERE ENGULFED IN FLAMES. I QUICKLY OPENED THE HOOD, DISCONNECTED THE BATTERY AND THEN PUT OUT THE FIRE WITH THE HOSE. THE WHOLE STEERING COLUMN AND SURROUNDING DASH AND WIRING HARNESS ARE COMPLETELY MELTED. THE INCIDENT HAPPENED WHILE THE JEEP WAS PARKED IN THE DRIVEWAY

I HAVE A 2001 JEEP WRANGLER WITH ONLY 89,000 MILES. THE ENTIRE FRAME AND UNDERCARRIAGE IS RUSTED OUT AND THE TRANSFER CASE HAS FALLEN OFF. I'M UNABLE TO DRIVE IT IS SO UNSAFE!! I CAN NOT BELIEVE THAT A VEHICLE ONLY 15 YEARS OLD WOULD BE IN THIS CONDITION!! I WILL BE GETTING AN ATTORNEY!! APPARENTLY THERE IS NOT PROPER HOLES FOR DRAINAGE IN THE FRAME AND IT HAS CAUSED THE WATER TO POOL AND RUST OUT THE FRAME. I STILL OWE $6000 ON THIS VEHICLE! I WILL NEVER BUY A JEEP AGAIN! I CALLED CHRYSLER AND BECAUSE IT'S SO FAR OUT OF WARRANTY AND NO RECALLS THEY ARE UNWILLING TO DO ANYTHING FOR ME...UGH

TAKATA RECALL MY VEHICLE WAS IN MOTION TRAVELING ABOUT 50 MPH WHEN IT LOST CONTROL ON A WET ROAD. THE CAR SLID ACROSS THE ROAD, OVER A SMALL DITCH, AND HEAD ON INTO A TREE. THE CAR BOUNCED FROM THE TREE AND SWIPED THE DRIVERS SIDE WITH ANOTHER TREE AND FINALLY BOUNCING BACK TOWARDS THE ROAD. THE ROAD WAS SLIGHTLY CURVED DOWNHILL IN A SMALL TOWN. I ATTEMPTED TO USE MY BRAKES WHILE OUT OF CONTROL BUT THEY WERE INEFFECTIVE. THE WEATHER CONDITIONS WERE THUNDERSTORMS ON AND OFF, RAINING IN THE AREA OF THE ACCIDENT. I BELIEVE THE AIRBAG IS THE SAFETY RISK. THE CAR HIT THE TREE IN THE CENTER OF THE GRILL WHICH CRACKED THE RADIATOR, TWISTED THE MOTOR MOUNTS, DAMAGED THE SUSPENSION, FOLDED THE FRAME AND SEVERAL OTHER FRACTURES. THE AIRBAG NEVER DEPLOYED, BOTH A BODY SHOP AND THE TOWING COMPANY SAID IT SHOULD HAVE DEPLOYED. THE CAR IS CONSIDERED TOTALED. I WAS IMMEDIATELY TAKEN TO THE EMERGENCY ROOM. INJURY'S TO THE DRIVER INCLUDE BROKEN RIBS, SPRAINED ANKLE, BRUISED MUSCLES, AND A CUT ON MY FOREHEAD THAT REQUIRED 5 STITCHES AMONG A FEW MORE MINOR INJURY'S. I ALSO BELIEVE THE TALL STEERING WHEEL KEPT ME FROM BEING EJECTED.

2001 JEEP WRANGLER SPORT, FRAME IS RUSTING FROM INSIDE OUT DUE TO IMPROPER DRAINAGE HOLES. CURRENTLY WITH 139,000 MILES THE CENTER SKID PLATE/TRANSFER CASE MOUNT IS READY TO DROP OUT OF THE VEHICLE. THE FRONT CONTROL ARM HAS ALSO BROKE OFF REQUIRING ESTENSIVE REPAIRS.

MY 2001 JEEP IS IN REAL GOOD SHAPE VISIBLY AND NO RUST ANYWHERE I CAN TELL ON THE BODY OR OUTSIDE OF THE FRAME. HOWEVER, WHEN PULLING THE CROSSMEMBER OFF THAT HOLDS THE TRANSMISSION/TRANSFER CASE TO THE FRAME, I NOTICED A MASSIVE AMOUNT OF RUST IN THE FRAME. IT LOOKS AS IF THE FRAME CAME OUT OF A 1920 MODEL CAR OR WORSE UNDER THERE. I MAY ATTEMPT TO HAVE THAT SECTION FIXED, BUT I HAVE NOTICED THE BOXED FRAME ON THE JEEP HAS NO WHERE FOR WATER TO GO ONCE INSIDE OF IT. MY ONLY OPTION WOULD BE TO MAKE DRAINAGE HOLES FOR WATER AND TRY TO SPRAY COSMOLINE OR SOMETHING INSIDE THE FRAME AND JUST "HOPE" THE REST OF THE FRAME IS NOT ROTTING FROM THE INSIDE OUT. I WOULD NOT EVEN COMPLAIN BUT A VEHICLE THAT IS BARELY 15 YEARS OLD ALREADY RUSTED OUT THIS BAD ON THE FRAME MUST HAVE BEEN DESIGNED POORLY OR MADE WITH GARBAGE STEEL AND COATED POORLY. I AM SURPRISED PEOPLE IN THE SALTY AREAS OF THE US HAVE NOT HAD THEIR CROSSMEMBER SIMPLY FALL OFF WHILE DRIVING. IF YOU NEED A PICTURE OF THE RUST IT IS IN MY PHONE AND CAN NOT ACCESS IT FROM THIS PC.

TL* THE CONTACT OWNS A 2001 JEEP WRANGLER. THE CONTACT STATED THAT WHEN THE VEHICLE WAS PLACED IN THE PARK POSITION, THE VEHICLE ROLLED BACKWARDS. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

FRAME IS RUSTING DUE TO LACK OF ENGINEERING AND ABSENCE OF DRAIN HOLES IN PROPER LOCATIONS. INSIDE OF FRAME IS FLAKING OFF AROUND CONTROL ARM FRAME MOUNTS FRONT AND BACK. JEEP IS GARAGE KEPT AND TAKEN CARE OF. WATER POOLS UP AND HAS NO WHERE TO GO SO A HOLE HAS RUST THROUGH PASSENGER SIDE FRONT BEHIND CONTROL ARM MOUNT. LOTS OF FLAKING OFF FROM INSIDE OF FRAME. INCREDIBLY BAD PLANNING ON MANUFACTURER'S PART AND NOW I HAVE A POTENTIALLY UNSAFE VEHICLE TO DRIVE WITHOUT SOME MAJOR FRAME WORK TO PERFORM. TOYOTA TRUCKS HAD A SIMILAR ISSUE AND THEY REPLACED THE FRAME.

FRAME IS RUSTING FROM THE INSIDE OUT. THERE ARE SPOTS IN THE FRAME WHERE PARTS ARE NOW MISSING, CREATING HOLES AND WEAKENING THE FRAME AS A WHOLE. THERE ARE NO ADEQUATE DRAIN HOLES IN THE FRAME, FROM THE FACTORY, TO ALLOW WATER TO DRAIN FROM THE FRAME. THIS HAS HAPPENED OVER TIME.

THIS IS BEEN AN ONGOING PROBLEM SINCE I PURCHASED THIS VEHICLE THE FRAME IS PRETTY MUCH COMPLETELY ROTTED AWAY BASICALLY SINCE THE DAY I BOUGHT IT IT IS COST ME ALMOST $4000 TO GET THE FRAME REPAIR OF REPEATABLY. ONE SUCH TIME MY TRANSMISSION AND TRANSFER CASE ACTUALLY FELL OUT BECAUSE THE SKID PLATE ROTTED OUT FOR BOLTS ON. THIS SPECIFIC REPAIR COST ME ALMOST $3000 TO FIX AS I HAD TO GET ANOTHER TRANSFER CASE AND A NEWPORT OF RAIL MADE. I ALSO HAVE MY REAR UPPER CONTROL ARM MOUNTS RUST OFF OF THE FRAME DESTROYING MY REAR AXLE . THAT WAS ANOTHER $2000 REPLACEMENT. I HAVE SEEN INSTANCES AT THE SHOP WHERE PORTS OF FALLING OFF OF THESE VEHICLES DUE TO THE SAME ISSUE. I RESPECT THE TOYOTA RECALL THE RUSTED FRAMES AND I THINK IT'S FINALLY TIME TO MAKE CHRYSLER DO THE SAME . THEY HAVE KNOWN THIS IS AN ISSUE SINCE THE 80S AND CONTINUE TO DO THIS.

ANOTHER VICTIM OF THE 2000-2001 JEEP 4.0L CYLINDER HEAD CRACKING BETWEEN CYLINDERS 3 AND 4 ON THE CYLINDER HEAD. CRACKED HEAD HAS CAUSED MANY OTHER EXPENSIVE PROBLEMS THROUGHOUT THE ENGINE SUCH AS (COOLANT SYSTEM FAILURE, CRANKCASE BEARING FAILURES, OIL PUMP FAILURE, VALVE STEMS BEING WARPED, ETC.) AFTER EXTENSIVE RESEARCH AND BEING A PART OF MANY ONLINE POLLS THIS IS OBVIOUSLY A PROBLEM WITH JEEPS OF ALL MODELS THAT HAVE THE 4.0L INLINE 6 CYLINDER HEADS OF THESE YEARS. THE VEHICLE WAS IN MOTION WHEN CRACKED HEAD OCCURRED CAUSING THE ENGINE TO OVERHEAT AS WELL AS OIL PRESSURE TO DROP. ALSO CAUSED MALFUNCTION AND RUINED O2 SENSORS ON VEHICLE. THE CYLINDER HEADS IN THESE 2000-2001 JEEPS OF ALL MODELS ARE FAULTY AND IT IS OBVIOUS CAUSE JEEP CHANGED THE HEADS THE FOLLOWING YEAR IN 2002. THEY CLAIM THAT THESE HEADS ARE CRACKING DUE TO THE ENGINE OVERHEATING. THIS PARTICULAR JEEP HAS NEVER BEEN OVERHEATED IN ORDER FOR IT TO CAUSE THE CYLINDER HEAD TO CRACK. THEY ARE FAULTY.

(*NOTE: I LIVE IN CT, USA. I PARK MY JEEP IN THE GARAGE WHEN IT SNOWS, AND IN THE DRIVEWAY THE REST OF THE TIME.) WHILE RETRIEVING SOMETHING OUT OF THE BACK SEAT, I STEPPED UP ON THE RUNNING BOARD (AKA. SIDE STEP) AND AS I LEANED IN, IT RIPPED RIGHT OUT OF THE FRAME. WITHIN A MONTH OF THIS, MY SKID PLATE ROTTED OUT OF THE FRAME AND LEFT MY TRANSMISSION UNSUPPORTED AND MY UNIVERSAL JOINT HANGING AT 30 DEGREE ANGLE. I BROUGHT IT TO MY MECHANIC, WHO TOLD ME TO TAKE IT STRAIGHT TO A BODY SHOP. IT'S BEEN THERE TWO WEEKS NOW! I PURCHASED 2 SKID PLATE MOUNT REPLACEMENTS WHICH THEY ARE WELDING ON RIGHT NOW. *NOTE: I'D UPLOAD PICTURES OF MY FRAME, BUT MY JEEP IS STILL IN THE SHOP. SO... (ATTACHED) ARE SOME PICTURES OF THE RUNNING BOARD AND RUSTED-OUT MOUNTS.

THE FRAME ON THE TJ MODEL YEARS WRANGLERS ARE MADE IN A BOX DESIGN WITH NO DRAIN HOLES AT THE BOTTOM SO WHEN WATER OR OTHER CORROSIVES GET IN THEY ARE TRAPPED AND THIS MAKES THE FRAME RUST FROM THE INSIDE OUT. BY THE TIME THIS IS DETECTED IT'S TO LATE ,THE FRAME IS UNSAFE AND WON'T PAS INSPECTION. DON'T WAIT UNTIL SOMEONE IS KILLED BECAUSE OFF THIS VERY UNSAFE DESIGN, DO SOMETHING NOW.

THE FRAME HAS RUSTED TO A UNSAFE CONDITION BECAUSE OF BAD METAL AND BAD DESIGN.

WAS TRAVELING DOWN DIRT ROAD AT AT 20 TO 25 MPH, THEN HEARD DIFFERENT NOISE LIKE METAL SCRAPING. SHIFTING SEEMED A LITTLE HARDER BUT WAS STILL WORKING. AFTER RETURNING HOME I LOOKED UNDER THE JEEP AND FOUND THE TRANSMISSION SKID PLATE HAD RUSTED AWAY FROM THE FRAME AND ONLY 3 BOLTS ON THE DRIVERS SIDE HOLDING THE TRANSMISSION IN PLACE. IF TRAVELING AT HIGHWAY SPEEDS AND IF BOTH SIDES BROKE LOOSE THIS WOULD HAVE BEEN A DIFFERENT STORY. I'VE DONE SOME CHECKING AFTER THIS HAPPENS AND LEARNED THIS IS A COMMON ISSUE AS WELL AS RUSTING OUT IN OTHER PLACES WITH JEEPS AND THINK THE MANUFACTURER HAS AND LEAST SOME LIABILITY WITH THIS ONGOING ISSUE.

WHEN SITTING IN MY DRIVEWAY WITH THE ENGINE RUNNING I NOTICED A BURNT ODOR SMELL FROM THE DASH AREA. THE AIR CONDITIONER WAS RUNNING ON HIGH BLOWER AND ON THE MAX SETTING OF INTERNAL AIR FLOW. THE BLOWER STOPPED WORKING SHORTLY AFTER THIS HAPPENED. UPON INSPECTION OF THE BLOWER SWITCH I FOUND THE SWITCH HAD STARTED TO BURN AND MELT AT THE CONNECTION FOR THE MAX BLOWER SPEED. I HAVE REPLACED THE SWITCH TWICE NOW WITH THE SAME PROBLEM,THE CIRCUIT NEEDS A RELAY IN IT TO PREVENT THE BLOWER SWITCH FROM OVER HEATING AND CAUSING THE WIRE FROM BURNING UP. AT NO TIME WAS THE FUSE BLOWN ON THE CIRCUIT.

MY FRAME RUSTED OUT. THIS IS A COMMON PROBLEM ON JEEP WRANGLERS. I WAS LUCKY ENOUGH TO BE IN THE PROCESS OF CHANGING MY TRANSMISSION FLUID WHEN I FOUND THE ISSUE. THE PART OF THE FRAME WHERE THE TRANSMISSION MOUNT ATTACHES TO COMPLETELY RUSTED THROUGH AND NOTHING WAS HOLDING THE TRANSMISSION/REAR ENGINE MOUNT TO THE FRAME. *TR

THE WRANGLER FRAME IS EXTREMELY PRONE TO RUST AND IS VERY EASILY ROTTED OUT OVER THE YEARS. I BELIEVE THIS IS DUE TO A DESIGN FLAW ON CHRYSLERS PART. THERE ARE NO DRAINAGE POINTS AT THE LOWEST PARTS OF THE FRAME WHICH HOLDS IN WATER AND ROAD SALT AND ACCELERATES RUST. *TR

I HAVE A JEEP THAT HAS A FRAME THAT IS RUSTED IN THE REAR TRAILING ARMS AND WERE THE TRANSMISSION IS HELD. NO INCIDENT HAS HAPPENED YET BUT IF THIS WERE TO BREAK ON THE ROAD COULD CAUSE AN ACCIDENT. I WORK FOR HYUNDAI WHO HAS A RECALL ON QUITE A FEW CARS AND SUVS FOR THE FRAME ROTTING OUT ON CARS AS OLD AS 2000 I ALSO NO TOYOTA AND NISSAN AND OTHER MANUFACTURES HAVE RECALLS ON FRAMES WHY NOT JEEP I REALIZE IT MAY BE SPECIFIC TO SALT BELT AREAS BUT THOSE OTHER COMPANIES ARE FIXING THE PROBLEM. ALSO THE CLIMATE CONTROL MELTED COULD HAVE CAUSED A FIRE I KNOW THIS IS ALSO A COMMON PROBLEM. *TR

TL* THE CONTACT OWNS A 2001 JEEP WRANGLER. THE CONTACT STATED THAT THE VEHICLE FAILED TO RESTART AFTER EXITING AND RE-ENTERING THE VEHICLE. THE VEHICLE HAD TO COOL DOWN BEFORE RE-STARTING. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE VAPOR LOCK WAS DEFECTIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000.

SKID PLATE THAT HOLDS TRANSMISSION FELL FROM RUSTED FRAME. IF I WAS GOING ON FREEWAY AT 55 OR PLUS THIS WOULD HAVE BEEN A VERY BAD SITUATION....LOOKING INTO FRAME I SEE THAT THIS IS COMMON WITH WRANGLERS FROM LIKE 1997 TO 2002 AND IT IS A FACTORY DEFECT....YOU HAVE RECALLED MAZDAS, TOYOTAS AND OTHER 2000ISH VEHICLES DUE TO RUSTED FRAMES...THESE SHOULD BE RECALLED AND FRAMES REPLACED BEFORE MORE FATAL THINGS HAPPEN....I AM LOOKING IN GETTING MINE REPLACED...BUT IF I DO AND THEN IT IS RECALLED DO I GET JEEP TO PAY ME BACK FOR MY REPAIRS??? *TR

TL*THE CONTACT OWNS A 2001 JEEP WRANGLER. THE CONTACT STATED THAT THE REAR SUB FRAME WAS CORRODED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

THE HVAC SYSTEM IN MY 2001 JEEP WRANGLER WAS BURNT AND MELTED, DUE TO LACK OF PROPER EQUIPMENT. THE HVAC BLOWER FAN, DUE TO BEING OLD, CAUSED RESISTANCE, SENDING TOO HIGH OF A CURRENT TO THE CLIMATE CONTROL HEAD UNIT, MELTING AND BURNING ALL WIRES, CONNECTORS, AND THE HEAD UNIT ITSELF. THIS COULD HAVE BEEN REMEDIED WITH THE EXISTENCE OF RELAYS FOR EACH SOURCE OF POWER HEADING INTO THE HEAD UNIT. *TR

FRAME RUSTED ON BOTH DRIVER AND PASSENGER SIDE AT BRUSH GUARD/TRANS SUPPORT, AND TRANSMISSION DROPPED WHILE DRIVING. BOTTOM OF FRAME UNDER DRIVER/PASSENGER SEAT WERE BRUSH GUARD ATTACHES IS COMPLETELY RUSTED AWAY AND THE FRAME HAS STARTED TO CRACK UP THE SIDES. I WOULD THINK THIS WOULD BE A CRASH SAFETY ISSUE. I HAVE NEVER SEEN A FRAME COMPLETELY RUST AWAY ON A 14 YEAR OLD CAR.

DRIVING OVER A RAILROAD TRACKS, HEARD A POP. DISCOVERED THE FRAME BY THE TRAILER ARM, ON RIGHT HAND SIDE BECAME COMPLETELY DETACHED, AS IT HAD RUSTED THROUGH. *TR

I WENT TO START JEEP THOUGHT DEAD BATTERY AND TRIED TO CHARGE BATTERY GAUGES ON DASH JUMPED AROUND FINALLY BATTERY ENOUGH TO TURN OVER BUT WOULD NOT START SAW WARNING LITE FOR KEY ON DASH.ENGINE WOULD TURN OVER BUT NOT START.TOOK TO JEEP DEALER REPLACED COMPUTER MODULE AND FOUND CORRODED MAIN POWER FEED IN ENGINE WIRING HARNESS SPLICED IN NEW WIRE AND SERIAL DATA ALL CAME BACK.I WAS RETURNING HOME JUST PULLING INTO DRIVEWAY ENGINE LITE CAME ON ALONG WITH OTHER LITES ENGINE STALLED TRIED TO START SAME PROBLEM AS BEFORE.RETURNED JEEP TO DEALER CURRENTLY WAITING FOR ANSWER TO PROBLEM COMPUTER DOES NOT ACCEPT MY KEY?I BROUGHT THIS JEEP USED THAT IS WHY I AM LOOKING INTO ANY RECALLS OR KNOWN PROBLEMS OF THIS NATURE. *TR

JEEP WRANGLER SPORT, 4.0L WAS PURCHASED AS SUBSEQUENT OWNER IN 2003(?) IN SAN JUAN, PUERTO RICO. THE PROBLEM APPEARED IN MAYBE 2008 AFTER MOVING TO PANAMA CITY (PANAM). AN AIRBAG WARNING LIGHT WAS OBSERVED, INTERMITTENTLY, WHEN FIRST STARTING. USUALLY A SECOND ATTEMPT WAS SUCCESSFUL. GRUPO Q CHRYSLER JEEP REPLACED THE IGNITION SWITCH, AT MY EXPENSE. I WAS UNAWARE THAT CHRYSLER DAIMLER HAD RECALLED THESE VEHICLES FOR IGNITION SWITCH PROBLEMS IN 2003/04, I THINK. MY RESEARCH REVEALED THAT GM/AC-DELCO WAS OEMING THESE SWITCHES TO CHRYSLER-DAIMLER, AND MAYBE OTHERS. THE ONLY THING I EXPERIENCED WAS AN ANNOYANCE, BUT THOSE SYMPTOMS SEEMED TO SUGGEST THAT I MAY HAVE BEEN DRIVING WITH DISABLED AIR-BAGS, HAD I NOT NOTICED THE LIGHT, OR IF HAD BEEN NON-FUNCTIONAL. THE QUESTION IS HOW MANY PEOPLE MIGHT STILL BE DRIVING NON-GM CARS WITH THESE DEFECTIVE SWITCHES, AND WHY HAS THIS NOT BEEN PUBLICIZED? *TR

THE BLOWER MOTOR SWITCH GROUND, CONNECTED TO THE MODE SELECTOR HAS MELTED IN MY JEEP. THIS IS THE SECOND TIME THIS HAS HAPPENED. BACK IN JULY 2013 THE CONNECTION TO THE MODE SELECTOR MELTED. I REPLACED THE HVAC AC A/C & HEATER CONTROL WITH BLOWER MOTOR SWITCH ONLY TO HAVE IT MELT AGAIN ONE YEAR LATER. *TR