2001 Jeep Wrangler complaints

DRIVING ON THE FREEWAY AND MY ENTIRE JEEP STARTED TO SHAKE SO BADLY THAT I COULD BARELY HOLD ONTO THE STEERING WHEEL. I THOUGHT THAT I MAY HAVE BLOWN A FRONT TIRE BUT IT DIDN'T FEEL LIKE THAT. SO I STARTED SLOWING DOWN AND MAKING MY WAY TO THE RIGHT SHOULDER OF THE FREEWAY. WHEN MY SPEED DROPPED DOWN TO ABOUT 45 MPH IT JUST STOPPED. IT DID THAT ONE OTHER TIME APPROXIMATELY 1 YR LATER AND IT'S NEVER DONE IT AGAIN. *TR

HIT A SMALL ROUGH SPOT IN THE ROAD, NOTICED A RUMBLING RIGHT AFTER. STOPPED TO CHECK - NOTICED SKID PLATE HANGING DOWN ON ONE SIDE . FRAME HAD RUSTED THROUGH ALLOWING SKID PLATE AND TRANSMISSION TO SAG. FURTHER CHECKING REVEALED FRAME IS RUSTED THROUGH IN MULTIPLE PLACES. IN THE PROCESS OF GETTING AN ESTIMATE OF POSSIBLE REPAIR THOUGH THE MECHANIC WAS NOT ENCOURAGING.. APPARENTLY THIS IS VERY COMMON ON THE TJ SERIES OF WRANGLER. DISAPPOINTING, CONSIDERING A FEW WELL PLACED DRAINAGE HOLES MAY HAVE PREVENTED IT. HOPEFULLY JEEP HAS TAKEN STEPS TO PREVENT THIS HAPPENING IN THE FUTURE . I HAD A FORD F150 FOR 13 YEARS & THE FRAME WAS STILL SOLID THE DAY I PARKED IT. I REALLY ENJOY MY JEEP , BUT IT MAY BE TIME TO SWITCH. :-( UPDATED 4/24/15 *JS

I PURCHASED THIS VEHICLE NEW FROM A DEALER. THE VEHICLE HAS NOT BEEN MODIFIED IN ANY WAY. ABOUT 2005 IT STARTED TO SHAKE AT HIGHWAY SPEED. DID NOT KNOW WHAT IT WAS AND SINCE THE VEHICLE IS DRIVEN MOSTLY IN TOWN IT WAS NOT NOTICED VERY MUCH. NOW THAT THE VEHICLE IS DRIVEN MORE IT STARTS TO SHAKE UNCONTROLLABLY AT ABOUT 50 MPH AND THEN IT WILL STOP WHEN SLOWED DOWN TO AROUND 40 MPH. I HAVE TAKEN IT TO 2 DEALERS, A MECHANIC AND A TIRE STORE. SINCE STARTING TO TRY TO CORRECT THE PROBLEM I HAVE HAD SEVERAL REPAIRS DONE. THE TIRES WERE CHECKED, THE BALANCE WAS CHECKED, THE ALIGNMENT WAS CHECKED, NEW TIRES WERE PUT ON, SHOCKS WERE REPLACED, BRAKE ROTORS WERE REPLACED, TORSION BAR CLIPS WERE REPLACED, AND I DO NOT REMEMBER THE MANY OTHER THINGS THAT WERE REPLACED OR REPAIRED. THE LAST DEALER THAT IT WAS TAKEN TO TEST DROVE THE VEHICLE AND SAID THAT HE COULD FEEL THE SHAKE BUT HE DID NOT KNOW WHAT IT WAS OR HOW TO FIX IT. HE SUGGESTED THAT I TAKE IT TO A FRAME SHOP. SINCE THEN I FOUND OUT THAT OTHER WRANGLERS HAVE THIS PROBLEM AND THAT IT EVEN HAS A NAME. THEY CALL IT THE "DEATH WOBBLE." WHEN THIS STARTS THE VEHICLE SHAKES ALL OVER THE AND THERE IS LITTLE CONTROL UNTIL YOU GET THE VEHICLE UNDER 40. *TR

ALL JEEP WRANGLERS FROM 1987-2006 HAVE A MAJOR PROBLEM WITH THE FRAMES RUSTING OUT CAUSE THEM TO BE UNSAFE FOR DRIVING ON PUBLIC ROAD UNLESS THE FRAME IS REPAIRED OR REPLACED, MY FRAME ON MY 2001 JEEP RUSTED OUT WITH ONLY 92000 MILES ON IT. THIS IS CAUSED BY THE FRAME NOT BEING PREPED, PAINTED, AND DESIGNED PROPERLY ALLOWING WATER TO SIT IN THE FRAME BECAUSE THERE ARE NO DRAIN HOLES AT THE LOWEST POINT OF THE FRAME. *TR

KEY DISENGAGES AND FALLS OUT OF THE IGNITION SWITCH AND CAN HAPPEN AT ANY TIME WHILE DRIVING. *TR

REMOVED TRANSMISSION CROSS MEMBER TO REPLACE CLUTCH. FOUND COMPLETE BOTTOM OF FRAME RUSTED FROM INSIDE SO AS TO MAKE UNSAFE TO DRIVE. SINCE HAVE FOUND THAT NEW FRAME IS NOT AVAILABLE AND IF A USED FRAME IS FOUND IT TO IS RUSTED AS TO BE DANGEROUS. HAVE CHECKED ONLINE AND FOUND THIS TO BE A COMMON PROBLEM. I WORK IN COLLISION REPAIR AND FIND THIS TO BE A SERIOUS FAULT. THIS NEEDS TO BE ADDRESSED QUICKLY BEFORE A DEATH OCCURS. MY SON'S JEEP WOULD KILL HIM IN AN ACCIDENT. *TR

TIRE TREAD SEPARATION ,AT 60MILES PER HOUR IN 110 DEGREE WEATHER AT 19292 MILES OF USE ONE TIRE COMPLETELY THREW THE TREAD 3 OTHER TIRES STATED TO DISPLAY TREAD SEPARATION. ONE TIRE COMPLETELY DESTROYED AND REPLACED BY THE DEALER WHERE THE TIRES WERE PURCHASED PN 04/17/2009 UNDER ROAD HAZARD WARRANTY THE OTHER 3 TIRES THEY REFUSED TO ACCEPT ASROAD HAZARD DAMAGE AND WOULD ONYLY PRO RATE A REPLACEMENT COST .

TL* THE CONTACT OWNS A 2001 JEEP WRANGLER. THE CONTACT STATED THAT WHILE HAVING THE VEHICLE SERVICED FOR ROUTINE MAINTENANCE, THE VEHICLE WAS DIAGNOSED AS THE FRAME BEING RUSTED AND CORRODED FROM THE FRONT CONTROL ARM TO THE REAR CONTROL ARM. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 140,000. THE VIN WAS UNAVAILABLE. *TR

I WAS DRIVING IN THE MOUNTAINS AND NOTICED AN UNUSUAL NOISE UNDER MY JEEP AND GOT OUT TO CHECK IT OUT AND FOUND THAT MY FRAME HAD CRACKED UNDER THE PASSENGER SEAT WHERE THE CONTROL ARM IS WELDED TO THE FRAME. AFTER LOOKING MORE CLOSELY, THE FRAME HAS COMPLETELY RUSTED THROUGH AND IS A HOLE HAS DEVELOPED FOR APPROXIMATELY 20 INCHES ALONG THE CENTER OF THE BOTTOM OF THE FRAME RAIL AND UP AND THROUGH WHERE THE CONTROL ARM BRACKET IS WELDED TO THE FRAME. THERE IS ONLY ABOUT 1 INCH OF WELD STILL HOLDING ON THE OUTSIDE BRACKET. I WAS AFRAID TO DRIVE HOME. FROM THE LOOKS OF THE RUST, THE ENTIRE FRAME COULD BUCKLE AT ANY TIME. I AM NOT A ROCK CRAWLER AND DO NOT ABUSE MY JEEP. IT IS ALL STOCK AND HAS REALLY ONLY BEEN DOWN DIRT ROADS AND NOT TRAILS. UPON SEARCHING ONLINE, I FOUND THAT MANY OTHER WRANGLER OWNERS ARE EXPERIENCING A SIMILAR PROBLEM SEVERAL ACTUALLY HAD THEIR CROSSOVER SUPPORT FOR THE TRANSMISSION FALL OUT OF THE VEHICLE. I KNOW THESE VEHICLES ARE 10 YEARS OLD BUT WE ARE TALKING ABOUT THE FRAME HERE. THIS IS UNSAFE AND CERTAINLY A MANUFACTURER DEFECT OR DESIGN OVERSIGHT. AFTER ALL, IT IS A JEEP WHICH IS EXPECTED TO GET SOME USE OFF ROAD. I CAN'T IMAGINE WHAT IT WOULD BE LIKE IF I TRULY SPENT SOME TIME OFF ROAD. PLEASE TAKE THE NECESSARY STEPS TO AT LEAST LET OWNERS KNOW THERE COULD BE A PROBLEM. I NORMALLY DON'T LOOK UNDER MY VEHICLE AND THIS COULD HAVE EASILY GONE UNNOTICED AND COMPROMISED THE ENTIRE FRAME STRUCTURE IF I HAD AN ACCIDENT. *TR

TL* THE CONTACT OWNS A 2001 JEEP WRANGLER. THE CONTACT STATED THAT THE ENGINE OVERHEATED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE RADIATOR WAS REPLACED TWICE AND THE ENGINE SEAL WAS ALSO REPLACED HOWEVER, THE FAILURE WAS NOT CORRECTED. THE VEHICLE WAS TAKEN BACK TO THE MECHANIC, WHO DETERMINED THAT THE ENGINE HEAD GASKET WAS CRACKED, CAUSING PISTONS 3 AND 4 TO FAIL. IN ADDITION, THE RADIATOR FLUID BEGAN TO DRAIN ABNORMALLY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 136,000 AND THE CURRENT MILEAGE WAS 148,000. ..UPDATED 11/28/12 *BF THE CONSUMER STATED THE ENGINE HEAD WAS CRACKED. UPDATED 12/03/12

LOOKS LIKE THERE WAS A SMALL FIRE BEHIND THE HEATER CONTROLS ALL THE WIRES AND THE BACK OF THE SWITCHES ARE MELTED THIS IS THE SECOND TIME THE FAN MOTOR CONTROL SWITCH HAS BEEN MELTED. *TR

THE A/C,HEATER BLOWER SWITCH MOPAR PART 305011214AA OVER HEATS AND THE WIRING START TO MELT,THE SWITCH STARTS TO MELT AND THEN THE SWITCH FAILS. THERE APPEARS TO BE TO MUCH CURRENT DRAW FROM THE BLOWER MOTOR. IT CAUSES THE DARK GREEN POWER LEAD CONNECTED TO THE SWITCH TO OVERHEAT MELTING THE INSULATION ON THE LEAD AND THE CONNECTIONS ON THE SWITCH. THIS HAS OCCURED AGAIN TODAY SEPTEMBER 22,2012. THIS CAUSED THE SAME PROBLEM,WIRES OVERHEAT,CONNECTIONS AND WIRES MELT AND SWITCH HOUSING AT CONNECTIONS START TO SMOLDER UNTIL SWITCH FAILS,WHEN SWITCH FAILS CURRENT CEASSES TO FLOW TO BLOWER MOTOR AND EVERYTHING COOLS DOWN ENOUGH TO PREVENT FURTHER DAMAGE TO SWITCH WIRING. FUSE FOR THE CIRCUIT DOES NOT BLOW OUT. TO REPAIR, SWITCH MUST BE REPLACED AND NEW WIRE CONNECTORS INSALLED,AND THE DARK GREEN WIRE WILL START TO GET HOT ENOUGH TO BE UNCOMFABLE TO THE TOUCH. DEALERSHIP PARTS DEPT. EMPLOYEES HAVE CONFIRMED THAT THESE SWITCH FAIL REGULARLY., *TR

TL* THE CONTACT OWNS A 2001 JEEP WRANGLER SPORT. THE CONTACT STATED THAT THE DRIVER WAS TRAVELING 65 MPH WHEN THE VEHICLE STARTED TO VIBRATE. THE CONTACT ALSO CONFIRMED THE FRAME WAS CORRODED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 78,105.

THE DASH BLOWER CONTROL WAS NOT WORKING. WHEN THE MECHANIC CHECK IT AND THE SYSTEM, IT WAS DISCOVERED THAT THE BLOWER HAD OVER HEATED THE PIGTAIL CONNECTORS AND MELTED THEM. THE BLOWER CONTROL WAS VISIBLY MELTED AND MULTIPLE SIGNS OF OVERHEATING WERE APPARENT. THE BLOWER CONTROL, ALL PIGTAIL CONNECTORS AND THE BLOWER HAD TO BE REPLACED. THIS WAS CAUGHT JUST SHORT OF ME HAVING TO DEAL WITH A FIRE BEING CAUSED BY THIS OVER HEATING OF THE ELECTRICAL PARTS OF THE A/C-HEATER SYSTEM. THIS IS THE SAME SITUATION AS REPORTED IN OTHER COMPLAINTS. REFER TO ODI ID NUMBERS: 10364281, 10283272, 10181912 AND 10145512. *TR

RE: MAJOR FRAME ROT: WE ARE THE ORIGINAL OWNERS OF THIS VEHICLE AND ALWAYS MAINTAINED IT PER THE SCHEDULE. I BOUGHT THE JEEP TO MY MECHANIC FOR SOME ROUTINE MAINTENANCE. WHEN HE REMOVED THE DRIVERS SIDE REAR WHEEL HE NOTICED SERIOUS FRAME ROT. HE TOLD ME THE JEEP IS NO LONGER SAFE TO DRIVE AND NOT WORTH PUTTING ANY MORE MONEY INTO. WHEN I GOT HOME, I SCRATCHED THE RUST WITH MY FINGERNAIL AND WAS EASILY ABLE TO POKE MY FINGER RIGHT THROUGH THE FRAME. A QUICK INTERNET SEARCH REVEALED THE FRAME ROT IS A VERY COMMON DESIGN FLAW FOR THE WRANGLER TJ SERIES. APPARENTLY MOISTURE, ROAD DEBRIS, ETC. IS ALLOWED TO ENTER THE INTERIOR OF THE FRAME BUT NOTHING IN THE DESIGN ALLOWS FOR ITS EXIT. SINCE THIS CREATES A CONDITION THAT ALLOWS THE FRAME TO ROT FROM THE INSIDE-OUT, BY THE TIME IT IS DISCOVERED IT IS TYPICALLY TOO LATE. MANY COMPANIES NOW MANUFACTURE SPECIAL FRAME PIECES TO REPAIR THE DAMAGE IF YOU ARE ONE OF THE LUCKY ONES WHO ARE MADE AWARE OF WHAT TO LOOK FOR BEFORE TOO MUCH DAMAGE HAS BEEN DONE. I SINCERELY HOPE JEEP WILL TREAT THIS DEFECT THE WAY TOYOTA DID WITH THE TACOMA IN 2008-2009! *JB

TL* THE CONTACT OWNS A 2001 JEEP WRANGLER. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, HE DROVE OVER A BUMP AND THE FRONT END OF THE VEHICLE VIOLENTLY VIBRATED. THE CONTACT HAD TO APPLY THE BRAKES TO STOP THE FAILURE. THE FAILURE RECURRED INTERMITTENTLY WHEN THE CONTACT DROVE OVER BUMPS. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 112,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2001 JEEP WRANGLER. THE CONTACT STATED THAT WHILE DRIVING OVER WATER, THE VEHICLE HYDROPLANED AND CAUSED THE CONTACT TO CRASH INTO A TREE. THE FRAME WAS SEVERELY FRACTURED AND THE VEHICLE WAS CRUMPLED AS A RESULT OF THE SEVERE IMPACT. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED A SEVERE CONCUSSION AT THE LEVEL TWO DEGREE. THE POLICE ARRIVED ON SCENE TO ASSIST AND STATED THAT DUE TO THE SEVERITY AND FORCE OF THE IMPACT, THE AIR BAGS SHOULD HAVE DEPLOYED. THE VEHICLE WAS TOWED TO A LOCAL REPAIR FACILITY WHO ALSO STATED THAT THE AIR BAGS SHOULD HAVE DEPLOYED. THE VEHICLE WAS NOT REPAIRED AND THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT INSPECTED FOR THE CAUSE OF THE HYDROPLANING FAILURE OR THE AIR BAGS FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGES WERE UNKNOWN.

FRAME IS RUSTED THROUGH AT ALL POINTS WHERE SKIDPLATE ATTACHES TO FRAME!! THE UNDERSIDE OF THE FRAME IS RUSTED THROUGH/GONE AT THE AREA WHERE SKIDPLATE BOLTS TO. AS A RESULT THE SKIDPLATE IS HANGING DOWN AND NOT PROPERLY SUPPORTING TRANSMISSION AND TRANSFER CASE.. BECAUSE OF THIS HANGING IT IS CAUSING MISALIGNMENT OF THE DRIVETRAIN.. DAMAGING COMPONENTS OF THE DRIVETRAIN. I CANNOT IMAGING IF THIS GOES UNDETECTED AND THE FRAME CRACKS AND/OR BREAKS WHILE THE VEHICLE IS IN MOTION, AT WHAT IS THE MIDDLE OF THE FRAME. *JS

JEEP FRONT END WOBBLES WHEN HITTING A BUMP AT HIGHWAY SPEEDS. AKA DEATH WOBBLE. MUST SLOW DOWN IMMEDIATELY, LOSS OF CONTROL.

TL* THE CONTACT OWNS A 2001 JEEP WRANGLER. WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS MANEUVERED TO A SAFE LOCATION. THE CONTACT NOTICED THE ENGINE OVERHEATED AND THE RADIATOR RESERVOIR WAS EMPTY. THE CONTACT DISPENSED COOLANT INTO THE RESERVOIR. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE BLOWN HEAD GASKET. ONE WEEK AFTER THE REPAIR WAS PERFORMED THE FAILURE RECURRED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE MALFUNCTION. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

I HAVE EXPERIENCED A TERRIBLE WOBBLE IN MY FRONT TIRE THAT MAKES MY VEHICLE HARD TO MAINTAIN TO EVEN KEEP ON THE ROAD IT IS VERY DANGEROUS AND I COULD NOT EVEN STEER. I CANNOT BELIEVE THIS VEHICLE IS ALLOWED ON THE ROAD WITH THIS PROBLEM AND IT IS ONLY A MATTER OF TIME BEFORE SOMEONE IS GOING TO BE SERIOUSLY HURT. I HOPE SOMETHING GETS WORKED OUT WITH THE "DEATH WOBBLE". *TR

FRAME RUSTED OUT AND TRANSMISSION WAS HANGING UNDER VEHICLE. FURTHER INSPECTION AND THE FRAME IS ROTTED AT REAR SUSPENSION MOUNTS. CHECKING ON WRANGLER FORUMS AND MANY PEOPLE ARE HAVING THE SAME FRAME ISSUES. I'D HATE TO SEE WHAT WOULD HAPPEN WHEN ONE OF THE REAR FRAME PIECES LETS GO WHILE SOMEONE IS GOING DOWN THE HIGHWAY. *TT

WHEN FILLING THE GAS TANK, GAS WILL SPIT BACK OUT AT YOU, GETTING ON YOUR HANDS AND CLOTHES. *TR

I HAVE AN 01 JEEP TJ WRANGLER, I HAVE RECENTLY NOTICED A DROP IN PERFORMANCE ALONG WITH SLOWLY VANISHING COOLANT. SEVERAL DAYS AGO WHILE IN TRAFFIC, THE OIL PRESSURE DROPPED LOW ENOUGH TO SET OFF THE CHECK ENGINE LIGHT. AS SOON AS I BEGAN DRIVING AGAIN THE OIL PRESSURE RAISED HIGH ENOUGH TO TO CLEAR THE LIGHT. HOWEVER AS SOON AS I CAME TO THE NEXT LIGHT THE OIL PRESSURE DROPPED AND THE CHECK ENGINE LIGHT CAME ON AGAIN. UPON RETURNING HOME I LOOKED UP THE SYMPTOMS ON THE INTERNET AND IT ALL LED ME TO A VERY COMMON CRACKED HEAD BETWEEN THE 3-4 CYLINDER. I WAS ALL TOO SURPRISED TO FIND OUT HOW EXTREMELY COMMON THAT IS. *KB

JEEP WRANGLER SE, 2001. THE FRONT WINDSHIELD GLASS CRACKED THREE TIMES IN THE SAME LOCATION (NEAR THE DRIVERS SIDE WINDSHIELD WIPER). I THINK THE STRESS CRACK IS DUE TO A DEFECT IN THE FRONT WINDSHIELD STRUCTURE OF POSSIBLYALL 2001 JEEP WRANGLER SE MODELS. *TR

2001 JEEP WRANGLER. CONSUMER WRITES IN REGARDS TO RUSTED AND CRACKED FRAME. *TGW CONSUMER SENT ADDITIONAL LETTER *TGW THE CONSUMER ALSO STATED THE HORN AND CRUISE CONTROL HASN'T WORKED IN YEARS AND THE AIR BAG LIGHT HAS ALSO BEEN ON FOR YEARS. *JB

THIS IS ONE MORE CONSUMER COMPLAINT REGARDING THE HEATER/FAN/BLOWER WIRING DESIGN FAILURE FOR THE 2001 MODEL OF THE JEEP WRANGLER. I UNDERSTAND THAT THIS CONTINUES TO OCCUR IN OTHER TJ MODEL YEARS AS WELL SO I THINK IT IS A SYSTEMIC DESIGN PROBLEM THAT IF NOT CORRECTED BY THE MANUFACTURER WILL EVENTUALLY CAUSE A SERIOUS INJURY OR DEATH. MY CASE IS TYPICAL OF THE FAILURES DESCRIBED BY OTHER 2001 WRANGLER OWNERS IN THAT THE HEATER BLOWER FAN SWITCH BEGAN TO DROP SPEEDS UNTIL ONLY THE HIGHEST SPEED WAS LEFT OPERATIONAL [WHICH I UNDERSTAND IS HOW THE UNDERLYING ELECTRONICS SPECIFICALLY A RESISTOR BANK FAIL IN THIS MODEL]. RECENTLY, THIS 4TH SPEED HAS FAILED AND I AM NOT DRIVING THE VEHICLE UNTIL I CAN RECEIVE SOME ASSURANCE THAT THE HEATER BLOWER WILL NOT CONTINUE TO HEAT UP UNTIL IT CATCHES FIRE AS HAS BEEN REPORTED IN OTHER INSTANCES. AS I WRITE THIS COMPLAINT, IT IS ABOUT 25 DEGREES OUTSIDE, SO DRIVING MY 2001 WRANGLER WITHOUT HEAT IS NOT AN OPTION. I GUESS I AM LUCKY THAT (A) IT FAILED COMPLETELY IN COLD WEATHER FORCING ME TO (B) RESEARCH THE ISSUE LEARNING THAT (C) THIS OBVIOUS VEHICLE DEFECT CAN RESULT IN THE WRANGLER CATCHING FIRE WHICH HAS FORCED ME TO (D) GO WITHOUT THE USE OF THE WRANGLER UNTIL A FACTORY DESIGNED AND SPONSORED FIX IS ENGINEERED AND INSTALLED. SO, IN SUMMARY, 2001 WRANGLER ' FAILED HEATER/FAN/BLOWER SWITCH ' MANY OTHER CASES FOR THIS MODEL YEAR AND SURROUNDING MODEL YEARS ' HAS A HISTORY OF CAUSING VEHICLE FIRES ' THIS NEEDS TO BE A FACTORY SPONSORED RE-

LITTLE TO NO REAR BRAKE PERFORMANCE. FRONT BRAKES LOCK UP WITH LITTLE PRESSURE BUT REAR BRAKES DO VERY LITTLE EVEN IF YOU USE THE EMERGENCY BRAKE. *TR

TL* THE CONTACT OWNS A 2001 JEEP WRANGLER. THE CONTACT WAS DRIVING 5 MPH WHEN THE BOLTS THAT HELD THE FUEL TANK BECAME LOOSE AND FRACTURED FROM THE VEHICLE. THE FUEL TANK WAS HANGING TWO INCHES FROM THE GROUND. THE DEALER WAS NOT INFORMED OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 54,000 AND THE CURRENT MILEAGE WAS 54,004.

2001 JEEP TJ, 40,000 MILES, SLOWLY LOSING COOLANT OVER THE COURSE OF 4 YRS. USED A PRESSURE TESTER AND VERIFIED NO EXTERNAL LEAKS. HOWEVER, USED THE SAME PRESSURE TESTER WITH ENGINE RUNNING, PER THE INSTRUCTIONS, AND THE SYSTEM GRADUALLY BUILT PRESSURE FROM 18 LBS TO 25 LBS BEFORE I STOPPED THE TEST. THIS INDICATES COOLANT LEAKING INTO THE COMBUSTION CHAMBER. CURRENTLY MY OIL PRESSURE IS GOOD AND THERE IS NO COOLANT CONTAMINATION ON THE DIP STICK OR UNDER THE OIL FILL CAP. AT RISK (LONG TERM) IS THE INTERNAL ENGINE BEARINGS: CAM AND CRANKSHAFT. I FOUND A THREAD ON THE INTERNET THAT COVERS MANY JEEP TJ OWNERS WITH THE EXACT SAME PROBLEM OF COOLANT LOSS. THIS IS ALL DUE TO A BAD BATCH OF CYLINDER HEADS WITH CASTING # 0331, MANUFACTURED FROM 2000 THROUGH 2006. *TR

EVERY TIME I FILL MY JEEP UP WITH GAS IT OVER FLOWS I THOUGHT IT MIGHT JUST BE THE PUMP BUT IT HAPPENS AT EVERY STATION I GO TO. *TR

THERE IS A SERIOUS PRODUCT DEFECT IN THE FAN MOTOR-SWITCH-RESISTER ASSEMBLY IN MY 2001 JEEP WRANGLER. THIS CONDITION HAS BEEN REPAIRED SEVEN TIMES, SIX TIMES UNSUCCESSFULLY (THE FIRST TIME WAS IN 2004, THE YEAR I BOUGHT MY JEEP FROM A DEALERSHIP) AND THE LAST ONE ACCOMPLISHED AUGUST 20, 2009 AND WHO KNOWS HOW LONG THIS WILL LAST. THE PROBLEM IS THAT THE FAN SWITCH SUDDENLY FAILS TO OPERATE AND WHEN THE MATTER IS INVESTIGATED THE MECHANIC FINDS THAT THE BLOWER MOTOR, RELAY AND SWITCH HAVE MELTED. THERE IS SOME SORT OF ELECTRICAL PROBLEM OR SURGE WHICH SIX REPAIRS HAVE FAILED TO CORRECT AND MY FEAR IS MY JEEP WILL CATCH ON FIRE AS HAS BEEN REPORTED IN A NUMBER OF CASES. *TR

DRIVING 2001 JEEP WRANGLER WITH BESTOP SLIDER WINDOWS, INSTALLED ABOVE FACTORY HALF DOORS. UPPER DOOR SLIDER FOR TJ WRANGLER PART NUMBER 51787. *TR PLASTIC TABS ON WINDOW UNIT ALL OF A SUDDEN BROKE AND WINDOW FLEW INTO DRIVER'S HEAD AND FACE. BESTOP IN BROOMFIELD COLORADO800 845 3561 REFUSED TO REPLACE OR REPAIR PRODUCT AND REFUSED TO COMMENT ON FAILURE OR SAFETY.

WE PURCHASED A SET OF BRIDGESTONE DUELER APT III TIRES FROM SEARS ON JULY 14, 2007 FOR OUR 2001 JEEP WRANGLER. AT THE TIME OF INSTALLATION THE JEEP HAD 69,903 MILES ON THE ODOMETER. THIS JEEP HAS THE 2.5L 4-CYLINDER ENGINE AND 5-SPEED MANUAL TRANSMISSION. ON JUNE 23, 2009 MY SON DROVE THE JEEP TO HIS AUTOMOTIVE CLASS AT CAPE FEAR COMMUNITY COLLEGE TO CHANGE THE OIL. WHILE ON THE LIFT, THE TEACHER NOTICED THAT THE RIGHT REAR TIRE WAS MISSING A SECTION OF TREAD. THEY REMOVED THE TIRE AND INSTALLED THE SPARE. THE JEEP HAS 80,104 MILES ON THE ODOMETER. THIS MEANS THAT THE TIRE FAILED WITH ONLY 10,201 MILES AND APPROXIMATELY 2 YEARS OLD. IF MY SON HAD BEEN DRIVING ON THE HIGHWAY, THIS COULD HAVE BEEN A DISASTER. THE TIRE SIZE IS 265 70 R16 111S AND THE CODE IS DOT V672 JLP 4506. WE ARE CONCERNED ABOUT THE REMAINING TIRES ON THE VEHICLE AND IF THESE SHOULD BE REPLACED. *TR

I BOUGHT THIS USED WITH ONLY 54,000 MILES ON THE ENGINE. WITHIN A YEAR AND AT 65,000 MILES, IT BEGAN OVERHEATING AND LEAKING COOLANT. MY BROTHER THOUGHT IT WAS A CRACKED HEAD OR GASKET. AFTER TEARING THE MOTOR APART AND SENDING THE HEAD TO BE CHECKED, TWO LARGE CRACKS WERE FOUND. THE CASTING # IS 331. MY BROTHER HAS BEEN TRYING TO FIND ANOTHER HEAD FOR ME AND WAS TOLD BY ONE OF THE SELLERS THAT HE CAN'T KEEP THE PARTS IN STOCK DUE TO THE HIGH NUMBER OF DEMAND FOR THIS PART. *TR

AIR BAG SUDDENLY WAS DISABLED DUE TO CLOCKSPRING FAILURE. *TR

TL*THE CONTACT OWNS A 2001 JEEP WRANGLER. THE CONTACT RECEIVED MULTIPLE RECALL NOTICES ON HIS VEHICLE REGARDING NHTSA CAMPAIGN ID NUMBER 00V366000 (CHILD SEAT). EACH TIME THE NOTICE WAS RECEIVED, HE WENT TO THE DEALER AND THEY REFUSED TO GIVE HIM THE REQUIRED OWNER'S MANUAL ADDENDUM. HE CALLED THE MANUFACTURER ON NUMEROUS OCCASIONS, BUT THEY REFUSED TO SEND HIM THE COPY THAT THEY WERE SUPPOSED TO PROVIDE. THE OWNER'S MANUAL EXPLAINS HOW TO PROPERLY INSTALL THE ANCHORAGE SYSTEM IN THE VEHICLE. SINCE THE CONTACT'S GRANDCHILD RIDES IN THE VEHICLE OFTEN, HE BELIEVES IT IS VERY IMPORTANT TO GET THE MANUAL. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 7,000.

WE PURCHASED A 2001 JEEP WRANGLER ABOUT TWO YEARS AGO. BACK IN NOVEMBER, THE VEHICLE BEGAN TO OVERHEAT. THINKING IT WAS THE HOSES OR RADIATOR CAP, WE REPLACED BOTH, WHICH STOPPED IT FOR AWHILE. IN DECEMBER, IT BEGAN TO LEAK AGAIN, SO WE REPLACED THE RADIATOR. IT IS NOW JANUARY AND IT HAS BEGUN TO LEAK AGAIN. WE HAVE ORDERED A NEW RADIATOR, BUT IT DOESN'T APPEAR THAT THE LEAK IS COMING FROM THE RADIATOR, AND AFTER READING SOME OF THE COMPLAINTS ON THE INTERNET REGARDING THE 2001 WRANGLER, WE ARE AFRAID IT MAY BE A CYLINDER HEAD. HAS THERE BEEN A RECALL ON THIS? THERE SEEMS TO BE A LOT OF COMPLAINTS RELATED TO IT' *TR

FAILURE OF HEATING SYSTEM (EXTREMELY COMMON IN ALL JEEPS & CHRYSLER CARS IN GENERAL) EITHER BLOWER SWITCH (REPLACED), BLOWER FAN RESISTOR (REPLACED), AND / OR BLOWER FAN ITSELF. BLOWER SWITCH ASSEMBLY MELTED, WHICH COULD LEAD TO A POTENTIAL FIRE. *TR

NEEDED TO REPLACE RADIATOR AFTER JUST 60,000 MILES. THEN STILL HAD PROBLEMS WITH RADIATOR FLUID LEAKING WITHOUT BEING ABLE TO FIND WHERE IT IS LEAKING. EVENTUALLY THE CYLINDER HEAD CRACKED AT 80,000 MILES. NOW IT NEEDS A NEW ENGINE COSTING ME $5,000. *TR

HAD VEHICLE FOR THREE YRS AND IN DECEMBER STARTED LOOSING COOLANT AND COULDN'T FIND THE LEAK. I TOOK IT TO JEEP AND TOLD THEM THE HEAD GASKET IS GOING . THEY SAID THEY WOULD CHECK IT OUT AND LATER TOLD ME IT WAS A AIRPOCKET. I PICKED IT UP AND RAN IT FOR ANOTHER WEEK, STILL LOSING FLUID. THIS HAPPENED OF AND ON FOR 3 TIMES. ON THE 3 TIME OF ME TAKING IT BACK THEY ADMITTED THE HEAD GASKET WAS SHOT AND THEY HAD TO REPLACE THE HEAD. I WENT TO TAKE IT HOME AND 1/2 WAY THERE MY ENGINE STARTED MAKING HORRIBLE NOISES AND JERKING. I CALLED THE DEALERSHIP AND HAD IT TOWED BACK THE NEXT DAY. THEY THEN TOLD ME DUE TO COOLANT CONTAMINATION THE ENGINE WAS RUINED AND HAD TO BE REPLACED WITCH WAS COVERED UNDER WARRANTY. I NOW HAVE 3410 MILES ON NEW ENGINE AND IT HAS STARTED MAKING NOISE. TOOK IT BACK TO JEEP AND THE WILL NOT COVER THE WARRANTY SAYING I HAVE WATER AND DIRT MARKS IN AIRBOX. THESE WERE IN THERE WHEN THEY FIRST REPLACED ENGINE AND I AM NOW SEEKING LEGAL COUNSEL. *TR

I BOUGHT THE VEHICLE IN MAY 07. 2001 JEEP WRANGLER SAHARA WITH 4.0L. @ MONTHS AFTER BUYING THE VEHICLE I LOST OIL PRESSURE. VEHICLE RETURNED TO DEALERSHIP AND THE OIL PUMP WAS REPLACED. LESS THAN 500 MILES I RETURNED THE VEHICLE TO SAID DEALER WITH A NASTY INTERNAL ENGINE RATTLE. DEALER REPLACED COLLAPSED LIFTER AND BENT PUSHROD. LESS THAN 100 MILES LATER VEHICLE RETURNED TO DEALER AGAIN WITH THE INTERNAL NOISE. VEHICLE TORN APART AND HAD THE CAMSHAFT, LIFTERS PUSHRODS REPLACED. IT HAS BEEN 7500 MILES SINCE MY LAST VISIT. I NOW HAVE A SLOW COOLANT LEAK THAT IS MAKING ITS WAY INTO THE OIL SYSTEM. I HAVE REMOVED THE CYLINDER HEAD AND FOUND A CRACK IN THE CASTING. THE CASTING # IS 0331. I HAVE SPENT NUMEROUS HOURS RESEARCHING THIS SPECIFIC CASTING # AND IT IS NOTORIOUS FOR CRACKING AND SLOWLY LEAKING COOLANT INTO THE OIL SYSTEM. MY JEEP ONLY HAS 71,000 MILES!! THIS IS AN ABSOLUTE LET DOWN AND HAS TARNISHED MY OUTLOOK ON CHRYSLER AND THE QUALITY OF THEIR PRODUCTS. THE TYPICAL LIFETIME FOR THESE HEADS IS BETWEEN 60-85,000 MILES. DO A SEARCH FOR JEEP 0331 ON GOOGLE, YOU'LL SEE THE OVERWHELMING NUMBER OF JEEP OWNERS WITH THIS PROBLEM. CHRYSLER NEEDS TO BE HELD RESPONSIBLE FOR THEIR LACK OF QUALITY AND MANUFACTURING AND SELLING A DEFECTIVE PRODUCT. *TR

MULTIPLE FAILURES OF THE HEATING FAN BLOWER MOTOR SWITCH AND THE FAN RESISTOR. *TR

HOW DO YOU CONVINCE AN AUTOMAKER TO DO A RECALL? DO YOU HAVE TO FILE A CLASS ACTION SUIT? IF YOU GO OUT TO YOUR PARKING LOT AND LOOK AT ALMOST ANY JEEP WRANGLER, 4 CYLINDER ENGINE, YOU WILL SEE THAT THE FRONT BOLT FOR THE EXHAUST MANIFOLD IS BROKEN OFF. THIS WILL OFTEN LEAD TO EXHAUST LEAKS AND MAY CAUSE THE VEHICLE TO FAIL A SAFETY INSPECTION. THE HEAD MECHANIC AT THE JEEP DEALERSHIP TOLD ME THAT ALL WRANGLER 4 CYLINDERS DO THIS. HE WENT ON TO SAY THAT HE HAS DONE A HUNDRED OF THEM. THE DEALER SHIP WANTS HUNDREDS OF DOLLARS TO FIX THIS. I HAVE ASKED AROUND AT OTHER AUTO REPAIR SHOPS AND THE COST IS NOT THAT MUCH LESS. IF ALL WRANGLER 4 CYLS DO THIS, AND IT IS A SAFETY ISSUE, WHY ISN'T IT A RECALL ISSUE? MICA CALFEE FLOWER MOUND, TEXAS *TR

TL*THE CONTACT OWNS A 2001 JEEP WRANGLER. THE CONTACT STATED THAT HIS VEHICLE WAS INVOLVED IN A FRONTAL ROLLOVER CRASH WHILE DRIVING 45 MPH. THE AIR BAGS FAILED TO DEPLOY. THE REAR SEAT WAS THROWN FROM THE VEHICLE. FORD STATED THAT THE AIR BAGS SHOULD NOT HAVE DEPLOYED BECAUSE IT WAS A ROLLOVER CRASH. THE DRIVER SUSTAINED A CONCUSSION. A POLICE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 62,000.

REFER TO ODI ID NUMBER : 10185714; AIRBAG WARNING LIGHT NOW STAYS ON CONSTANTLY; HORN NO LONGER WORKS; DEALERSHIP WHERE PRUCHASED NOTIFIED; SERVICE SCHEDULED; APPEARS TO BE COMMON PROBLEM WITH THE AIR BAGS FRONTAL SENSOR/CONTROL MODULE WHERE WATER AND/OR ROAD SALT IN THE PROXIMITY OF THE AIR BAG CONTROL MODULE COULD LEAD TO CORROSION ,AND SUCH CORROSION CAN LEAD TO ILLUMINATION OF THE AIR BAG WARNING LIGHT OR COULD ALLOW INADVERTENT DEPLOYMENT OF THE AIR BAGS. *AK

2001 JEEP WRANGLER SE . AIR BAGS WARNING LIGHT FAILURE. INTERMITTENT ILLUMINATION OF THE AIR BAG WARNING LIGHT OCCURRED WHEN VEHICLE WAS OPERATING IN REVERSE GEAR.WHEN OPERATING THE VEHICLE IN REVERSE GEAR , 5-SP MANUAL TRANSMISSION , THE AIRBAG WARNING LIGHT ILLUMINATES, AFTER GOING FORWARD A SHORT DISTANCE, WARNING LIGHT WENT OUT. IT HAS OCCURRED 3 TIMES OVER 3 DAY PERIOD. AIRBAG HAS NOT DEPLOYED; NO CORRECTIVE ACTION HAS BEEN PERFORMED; DEALERSHIP HAS NOT BEEN NOTIFIED. *AK

WIRES FOR HVAC CONTROLS ARE MELTING IN THE PLASTIC CONNECTOR BEHIND THE DASH. SOME OF THE CONTROLS DON'T WORK RIGHT ANYMORE. WIRES COULD SHORT AND CAUSE FIRE. *NM

DT*: THE CONTACT STATED WHILE DRIVING 40 MPH ON THE HIGHWAY, THE REAR SUSPENSION BEGAN TO SHAKE THROUGHOUT THE VEHICLE. THE CONTACT MANAGED TO DRIVE THE VEHICLE HOME WITHOUT INCIDENT. UPON INITIAL INSPECTION OF THE REAR SUSPENSION BY THE CONTACT, IT WAS DETERMINED THE LEAF SPRING BRACKET ON THE LEFT SIDE WAS FRACTURED. ADDITIONALLY, THE LEFT SIDE WAS NOT WELDED TO THE SPRING ASSEMBLY, BUT THE RIGHT SIDE BRACKET WAS ATTACHED BY WELDS. THE MANUFACTURER WAS NOT NOTIFIED. UPDATED 12/01/06. *JB

DT*: THE CONTACT STATED THE VEHICLE WAS INVOLVED IN A CRASH AND THE DRIVER SIDE AIR BAG FAILED TO DEPLOY. UPON EXITING A BLIND CURVE AT 40 MPH, IN NORMAL WEATHER CONDITIONS, THE CONTACT WAS BLINDED BY HEADLIGHTS FROM ANOTHER VEHICLE. THE CONTACT LOST CONTROL OF THE VEHICLE AND HIT A TELEPHONE POLE HEAD ON. THE DRIVER WAS WEARING A SEAT BELT, HOWEVER SUFFERED A LACERATION TO THE FACE THAT REQUIRED STITCHES. THE POLICE FILED A REPORT AT THE SCENE. THE VEHICLE WAS INSPECTED BY THE INSURANCE COMPANY AND WILL BE REPAIRED. *NM