2000 Ford F-250 SD

Defect. FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Risk. A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Remedy. FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Defect. CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.

Risk. WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.

Remedy. FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.

Defect. ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

Risk. IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

Remedy. DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

Defect. CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy. PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

TL* THE CONTACT OWNS A 2000 FORD F-250 SUPER DUTY. WHILE DRIVING 40 MPH, THE CONTACT HEARD AN ABNORMAL THUMPING NOISE AND NOTICED THAT THE FUEL TANK HAD DETACHED AND WAS DRAGGING ON THE ROAD. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE FIRE AND POLICE DEPARTMENTS WERE ON THE SCENE. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 165,000. *BF THE REAR STRAP SECURING THE GAS TANK FAILED. *TR

FORD AND "TAKATA RECALL" THE SAFETY BELTS IN THE BACK OUTSIDE AS WELL AS THE MIDDLE SEAT BELT DOES NOT LOCK AT ALL, THE MUFFLER ON THE BOTTOM BACK UNDERNEATH THE CAR IS HANGING ENOUPH TO STRAP IT TO CAR. THE FRONT BUMPER IS CRACKED AND HELD TOGETHER BY PLASTIC TYWRAPS. THE LIGHT IN THE DASH LIGHT IS OUT AND DOESN'T LIGHT UP AT ALL BESIDES A PERSON WITH THE AIRBAG DIPLOID SHOWING. BACK SEAT DOOR LOCK SWITCH DOESN'T WORK AND THE BACK DOOR RIGHT SIDE WINDOW DOESN'T GO UP AND DOWN. THE BACK SEAT LITTLE WINDOW IS BROKEN OUT. THE BACK BRAKE LIGHT DOESN'T WORK. THE HEATING AND COOLING SYSTEM DOESN'T COME ON AT ALL INCLUDING DEFROSTERS. THE WIND SHIELD IS HELD ON FROM WHAT LOOKS LIKE FOAM GLUE. THE UNDERSIDE OF THE VEHICLE IS RUSTED AND THE FRONT SIDE WHEEL AND BRAKE ARE RUSTED, AS WELL AS THE FRONT SIDE BACK WEAL BARING AND BREAK, DRIVERS SIDE BACK REAR WHEEL BARRING AND BREAK ARE RUSTED. THE HORN DOES NOT WORK AT ALL AND THE AIR BAG LIGHT IS ON. THE FAN DOESN'T BLOW AT ALL, THE CAR JUST STARTS MAKING LOUD NOISES, AND THE THEFT LIGHT SEAMS TO BE ON IN THE MIDDLE OF THE FRONT DASH BORD. THE REASON IS DUE TO PREVIOUSE OWNER AS THE CAR WAS LIKE THIS BEFORE I BAUGHT THE VEHICLE SO THE REASON FOR THE CONDITION IS DUE TO UNKNOWN REASON OF PREVIOUSE OWNER NOT TAKING CARE OF IT. I PERCHASED THE VEHICLE AT BRITNEY VANSTRATENS HOME 122 NORTHGATE EASTATES NEW LONDON, WI, 54961 ON 6/5/2018.

THE TOW HOOKS ON THE FRONT BUMPER OF A 2000 FORD F250 SUPER DUTY PIERCED THE DOOR PANEL OF A PASSENGER SEDAN DURING A T-BONE IMPACT AT A STOPLIGHT, CAUSING MASSIVE PUNCTURE WOUNDS TO THE DRIVER OF THE SEDAN, WHICH RESULTED IN HER DEATH.

I JUST RECENTLY BOUGHT THIS CAR LAST MONTH. IT WAS ADVERTISED WITH 97,000 MILES. I WAS SHOWN A CARFAX THAT SHOWED 97,000 MILES. JUST FOUND OUT THE CLUSTER WAS SWAPPED OUT BEFORE I PURCHASED THE VEHICLE. THE ACTUAL MILEAGE WITH THE DMV IS ABOUT 382,000 MILES. I NEED TO TAKE LEGAL ACTION.

VEHICLE CAUGHT FIRE WHILE WE WERE AWAY AT A MEETING. VEHICLE WAS STARTED, MOVED OUT OF THE WAY OF ANOTHER CAR AND THEN SHUT OFF AND LOCKED. ALSO BURNED DOWN FAMILY WEEKEND CABIN. AFTER RESEARCH, FOUND OPEN RECALL THAT CAN CAUSE THIS EXACT ISSUE. FORD RECALL FOR TEXAS INSTRUMENTS SPEED/CRUISE CONTROL DEACTIVATION SWITCH. THE INCIDENT TOOK PLACE IN COLMESNEIL, TX ON 2/18/2017 BETWEEN 1:50 PM AND 3:00 PM. FIRE COMPLETELY DESTROYED THE CABIN AND THE TRUCK. WELL PUMP HOUSE WAS DESTROYED, AS WELL AS AN ALUMINUM BOAT THAT WAS PARKED CLOSE BY. VERY RURAL AREA. VOLUNTEER FIRE DEPT RESPONDED. NO INVESTIGATION OF ANY KIND AT THIS POINT.

TL* THE CONTACT OWNS A 2000 FORD F-250 SD. WHILE DRIVING APPROXIMATELY 55 MPH, A LOUD NOISE WAS HEARD UNDER THE HOOD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SPARK PLUG THREAD IN THE ENGINE HEAD FAILED AND CAUSED THE SPARK PLUG TO SEPARATE FROM THE ENGINE. THE CONTACT INDICATED THAT THE FAILURE OCCURRED ON THREE SEPARATE OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 135,000.

THE DRIVER SIDE FRONT TIRE SPONTANEOUSLY BLEW WHILE DRIVING IN NORMAL CONDITIONS ON THE HIGHWAY, CAUSING THE VEHICLE TO ROLL MULTIPLE TIMES. THE TIRE HAD BEEN REGULARLY MAINTAINED AND HAD MORE THAN ADEQUATE TREAD.

SPARK PLUG BLEW OUT OF MOTOR I AM THE ORIGINAL OWNER OF MY TRUCK. I HAVE ALWAYS HAD THE FORD DEALERSHIP PERFORM THE TUNE-UPS BECAUSE I AM AWARE OF THE ONGOING PROBLEMS WITH THE FORD 5.4 ENGINE AND SPARK PLUGS. I HAD MY DAUGHTER IN THE TRUCK WITH ME AT THE TIME OF THE SPARK PLUG COMING OUT AND CATCHING ON FIRE. THIS IS COMPLETELY UN-ACCEPTABLE, FORD MOTOR COMPANY OBVIOUSLY KNOWS ABOUT THE PROBLEM. BUT NOTHING HAS BEEN DONE TO CORRECT THE PROBLEM. I AM EXTREMELY UPSET ABOUT THE DANGEROUS SITUATION THIS PUT ME AND MY FAMILY IN. THERE IS NOTHING FORD COULD EVER DO TO HELP "MAKE THINGS RIGHT" IF SOMETHING WERE TO HAPPEN TO MY FAMILY. I SURE HOPE THAT FORD CAN BE RESPONSIBLE ENOUGH TO CORRECT THIS PROBLEM BEFORE SOMEONE GETS HURT. *TR

PULLING OUT OF A PARKING LOT AND THE STRAP THAT HOLDS THE GAS TANK BROKE (RUSTED THROUGH) AND THE GAS TANK FELL ONTO THE ROAD SURFACE. THE TANK WAS ALMOST FULL AT THE TIME OF THE INCIDENT. *TR

I RECENTLY PURCHASED A USED F-250. WHILE TRYING TO PARK IT IN A PARKING LOT, I WAS TRAVELING AT ABOUT 1 MPH. WHILE STOPPED OR BARELY MOVING, THE STEERING WHEEL IS IMPOSSIBLE TO TURN. IT MAKES PARKING EXTREMELY DIFFICULT WHILE IN CLOSE PROXIMITY TO OTHER VEHICLES, AND/OR PEOPLE. THIS IS A POTENTIAL SAFETY ISSUE, MAKING AN ACCIDENT EXTREMELY LIKELY. THE TRUCK HAS THE 7.3L POWER STROKE DIESEL. *TR

I WAS JUST SECONDS AWAY FROM GETTING ON THE HIGHWAY WHEN THE STEERING WENT COMPLETELY OUT!! IT HAPPENED IN THE FOLLOWING WAY. AFTER MAKING A LEFT TURN, FORTUNATELY I LOOKED DOWN AND NOTICED THE STEERING WHEEL WAS ABOUT 90 DEGREES OFF FROM CENTER. WITH MY MECHANICAL BACKGROUND I KNEW THAT THIS WAS SERIOUS AND PULLED OFF THE ROAD. I CHECKED THE TIE RODS, SUSPENSION, TIRES LOOKING FOR ANYTHING OBVIOUS AND DIDN'T FIND ANYTHING. GOT BACK IN THE TRUCK TO TEST THE STEERING WHEEL AND AS I TURNED THE WHEEL THERE WAS A SLIGHT RESISTANCE THEN POP AND THE WHEEL SPUN FREELY. OPENED THE HOOD AND THE SHAFT WAS CONNECTED TO THE BOX SPINNING FREELY. I WAS SECONDS AWAY FROM GETTING ON THE HIGHWAY!

BOUGHT THE TRUCK 2000 FORD F250 USED IN 2006 AND THE SEAT BELT RETRACTOR WOULD NOT RETRACT THE BELT WHEN NOT IN USE. THE BELT WOULD GET CAUGHT IN THE DOOR WHEN IT WAS CLOSED. I WOULD HAVE TO OPEN THE DOOR TO GET THE SEAT BELT LOOSE SO IT COULD BE USED. THIS PROBLEM MAKES USING THE SEAT BELT A MAJOR PROBLEM EACH TIME I GET INTO THE TRUCK. I BOUGHT A NEW BELT AND RETRACTOR FROM FORD FOR ABOUT $120 AND IT WORKED FOR ABOUT A MONTH AND IT BECAME THE SAME AS THE OLD SEAT BELT. THIS IS A PROBLEM ON ALL 2000 MODEL TRUCKS AND FORD WILL NOT CORRECT THE PROBLEM. THIS PROBLEM CAUSES YOU NOT TO WANT TO USE THE SEAT BELT BECAUSE OF HOW MUCH TROUBLE IT IS TO BE USED. *TR

DATE: SEPTEMBER 18, 2011 DRIVING SOUTH ON THE 605 FREEWAY REAR LEFT TIRE BLEW OUT THE TREAD BELT PORTION OF THE TIRE TORE OF AND CAUSED BODY AND PAINT DAMAGE TO THE REAR FENDER. I CAN PROVIDE PICTURES OF THE TIRE AND BODY DAMAGE IT CAUSED. I RECEIVED A RECALL NOTICE AND I MAILED THE DOCUMENTS REQUESTED. BF GOODRICH NOTIFIED ME THAT MY TIRES ARE OUT OF WARRANTY DUE TO AGE AND MY TIRES ARE NOT PART OF THE RECALL NOTICE. I TOLD THE PERSON ON THE PHONE THE INCIDENT IS THE SAME AS NOTED "TIRE TREAD SEPARATION" AS ON THE RECALL NOTICE. I ONLY HAD APPROXIMATELY 10,000 MILES ON THE TIRES WHEN IT HAPPENED. *TR

I OBSERVE THE VOLUNTARY RECALL ISSUES BY GOODYEAR (NHTSA 12T0030000) AND SINCE I OWN A 4 WHEEL SET OF THOSE TIRES ON MY FORD F-250 SUPER DUTY, I NOTICED THAT MY SIZE WASN'T LISTED. I HAVE HAD TROUBLE WITH MY SET OF SILENT ARMOR TIRES IN THAT THEY CAN NOT BE BALANCED AS THEY SHOULD BE AND VERY PRONOUNCED CRACKS HAVE APPEARED ON THE SIDE WALLS CLOSE TO THE TREAD LINE. I LIMIT MY SPEED TO NO MORE THAN 50MPH. MY TIRES WERE PURCHASED IN SEPTEMBER, 2009 AND IF I COULD CRAWL UNDER MY TRUCK IN SEARCH OF THE PRODUCTION DATES, I'M SURE THEY WOULD BE IN OR CLOSE TO THE LISTED PRODUCTION DATES. THE PROBLEM APPEARS TO BE WITH THE SILENT ARMOR PRODUCTION TECHNOLOGY AND SHOULD NOT BE RECALLED IN SUCH A NARROW DATE RANGE OR SIZE RANGE. PLEASE EXPAND THE RECALL TO ALL SIZES AND A BROADER PRODUCTION DATE RANGE. *TR

TIRE SEPARATED LIKE A RETREAD AND CAUSE OVER $3500 DAMAGE TO THE BED OF THE PICKUP ON THE DRIVER'S SIDE. *TR

APPROXIMATELY 1 HOUR AFTER BEING PARKED IN PARKING STALL AT MY RESIDENCE, NEIGHBORS NOTICED FIRE COMING FROM THE HOOD AND UNDERNEATH THE VEHICLE (THE FIRE ORIGINATED ON THE DRIVER'S SIDE).THEY ATTEMPTED TO PUT OUT THE FIRE AND CALLED 911. SAN JOSE FIRE DEPARTMENT RESPONDED TO THE CALL AND FINISHED PUTTING OUT THE FIRE. THE VEHICLE HAD VISIBLE BURNT WIRING, RIGHT SIDE FENDER DAMAGE FROM HEAT (INSIDE AND OUTSIDE) AND THE RIGHT DRIVER'S SIDE TIRE SUSTAINED DAMAGE DUE TO MELTING DEBRIS FALLING ON TIRE. THE FIRE DEPARTMENT TOOK A REPORT OF THE INCIDENT. AS I HAVE RELAYED THIS EVENT TO OTHERS, THEY HAVE MENTIONED THAT THIS IS PROBABLY A "RECALL FIRE" AND THAT I SHOULD REPORT THIS INCIDENT. *TR

THE REAR BRAKE LINE FAILED DUE TO CORROSION. THE FAILED BRAKE LINE ALLOWED THE BRAKE FLUID TO TOTALLY DRAIN THE RESERVOIR ON THE MASTER CYLINDER. THE RESERVOIR FOR THE REAR BRAKES IS SHARED WITH THE FRONT BRAKES SO THAT THE FRONT BRAKES WERE NO LONGER ABLE TO FUNCTION AS WELL. THE OPERATOR THEN HAS NO BRAKES AT ALL ON THE VEHICLE WITH THE EXCEPTION OF THE PARKING BRAKE. IN THE CASE OF THE FIRST FAILURE, I WAS ABLE TO USE THE MANUAL TRANSMISSION TO SLOW THE VEHICLE AND THEN SHIFT INTO REVERSE (IT HAS SYNCHROS IN REVERSE AS WELL) TO STOP THE VEHICLE. IN THE CASE OF THE SECOND FAILURE, THE VEHICLE WAS IN MY DRIVEWAY WHEN THE FAILURE OCCURRED. EVEN THOUGH THE BRAKE PEDAL WAS ONLY PUSHED ONCE, THE RESERVOIR STILL COMPLETELY DRAINED LEAVING ABSOLUTELY NO BRAKES. I FEEL THAT THIS BRAKE FAILURE MODE DOES NOT COMPLY WITH THE INTENT OF WHAT I UNDERSTAND THE LAW TO BE, THAT REQUIRES A SPLIT BRAKE SYSTEM THAT ENABLES THE OPERATOR TO STOP THE VEHICLE WHEN EITHER FRONT OR REAR BRAKES FAIL. THE CURRENT BRAKE SYSTEM DOES HAVE A SPLIT MASTER CYLINDER BUT THE COMMON RESERVOIR FEATURE PREVENTS THE SPLIT MASTER CYLINDER FROM OPERATING AS INTENDED/REQUIRED.

I WAS TRAVELING ON I-90 IN ERIE,PA AND A SPARK PLUG BLEW OUT OF THE MOTOR. I LOST ALL POWER AND WAS NEARLY HIT FROM BEHIND. THE TRUCK IS A FORD F-250 WITH A TRITAN 5.4 L MOTOR. *TR

I HAVE A 2000 FORD F250 3/4 TON 5.4 GAS 2 WHEEL DRIVE LONG BED EXTENDED CAB PICKUP. THE TRUCK SHAKES AND CUPS TIRES BADLY AT HIGHWAY SPEED IF WEIGHT IS PUT ONTO THE RIGHT FRONT WHEEL. I HAVE HEARD OF SEVERAL INCIDENTS OF THE DEATH WOBBLE ON THE F250 BUT MOST WERE 4X4 TRUCKS. I THINK THAT THIS IS DANGEROUS. MY TRUCK ONLY HAS 60K MILES ON IT. *KB

WAS PULLING MY BOAT OUT OF THE WATER AND WHEN STOPPING HEARD A LOUD BANG. STOPPED TRUCK AND SAW FLUID LEAKING ON TO THE GROUND FROM JUST FORWARD OF THE DRIVERS SIDE REAR TIRE. FOUND FLUID TO BE BRAKE FLUID. BRAKE STEEL LINE THAT RUNS DOWN THE LEFT FRAME RAIL HAD BURST NEAR FUEL TANK. THIS AREA HARD TO SEE UNLESS USING A MIRROR AND LIGHT. THE BRAKE LINE WAS VERY CORRODED AND HAD RUSTED THRU IN THE AREA THAT IS HARDEST TO SEE. REPLACED THE STEEL BRAKE LINE TO REPAIR. I AM THE ORIGINAL OWNER OF THIS TRUCK. I HAVE PICTURES AND HAVE THE OLD BRAKE LINE. *TR