1993 Ford F-250 SD

Defect. FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Risk. A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Remedy. FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

STARTED VEHICLE NORMALLY AND AS SOON AS THE BRAKE WAS APPLIED, A LOUD 'POP' SOUND WAS HEARD BEHIND THE DASH AND A LARGE AMOUNT OF SMOKE CAME INTO THE CAB FROM THE A/C VENTS. I CONTINUED FOR ABOUT ONE MINUTE. THE VEHICLE WAS SHUT OFF AND PARKED IN PLACE. THE SMOKE SUBSIDED. THIS IS CONSISTENT WITH THE PROBLEMS INDICATED IN THE SPEED CONTROL DEACTIVATION SWITCH RECALL AFFECTING 1993 FORD F-250 VEHICLES CAUSING UNDER HOOD FIRES. HOWEVER, AFTER CONTACTING FORD, THEY INDICATED THAT MY PARTICULAR VIN WAS NOT INCLUDED IN THE RECALL, AND I WOULD BE RESPONSIBLE FOR THE COST OF TOWING AND ANY REPAIRS.

THE CAPACITY OF THE RECEIVING TANK MAY BE EXCEEDED AND FUEL MAY OVERFLOW FROM THE FILLER CAP. *NM

DT: CONSUMER RECEIVED NHTSA CAMPAIGN RECALL 93V125000 CONCERNING FUEL SYSTEM CHECK VALVE. WHEN THE CONSUMER CONTACTED FORD THEY TOLD HIM THAT BECAUSE THE TWELVE YEAR WARRANTY EXPIRED HE WOULD NOT BE REIMBURSED. THE CONSUMER TOOK THE VEHICLE TO A REPAIR SHOP ABOUT A WEEK AGO AND THEY TOLD HIM TO CALL A FORD DEALERSHIP, WHO THEN ADVISED HIM TO CALL THE MANUFACTURER.*AK

6 SERP. BELTS & 3 TENSIONER ASSYS IN 65000 MILES. LAST ONE AT FREEWAY SPEED PULLING TRAV TRL. VERY LITTLE BRAKES OR STEERING. THE ONE AT 59000 MILES PULLED TRANS COOLING LINES INTO DAMP PULLEY, NOW MY TRANS (AUTO) IS MAKING NOISES. OCCURRED ON 3/94 7/96 9/96 2/03 6/03 8/03. *JB