2003 Ford F-250 SD

Defect. FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

Risk. NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

Remedy. DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

Defect. FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Risk. A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Remedy. FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Defect. CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.

Risk. WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.

Remedy. FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.

Defect. ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

Risk. IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

Remedy. DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

Defect. ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Risk. OVERHEATING COULD RESULT IN SMOKE, BURN, OR AN UNDERHOOD FIRE.

Remedy. DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON MARCH 12, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017, 05V388, AND 06V286)

Defect. CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy. PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

TL* THE CONTACT OWNS A 2003 FORD F-250 SD. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THAT THE FUEL TANK WAS HANGING DOWN. THE CONTACT LOOKED UNDERNEATH THE VEHICLE AND SAW THAT THE FUEL TANK STRAP WAS FRACTURED AND THE FUEL GAUGE WAS DAMAGED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS 49,000.

THE REAR FUEL TANK STRAP FAILED WHILE TRAVELING ON A STATE HIGHWAY.

I HAVE AMERICAN EAGLE - 20 " EAGLE ALLOY WHEELS. THEY ARE APPROXIMATELY 24 MONTHS OLD. THIS SUMMER A SPOKE CRACKED ALL THE WAY THROUGH ON ONE WHEEL. THE DEALER WOULD NOT WARRANTY IT AND I HAD TO PURCHASE A REPLACEMENT. THIS WEEK I NOTICED ANOTHER OF THE WHEELS CRACKED ALL THE WAY THROUGH. I HAVE NOT HIT ANY MAJOR POT HOLES, CURBS OR ANYTHING ELSE. MY TRUCK IS NOT A WORK TRUCK OR USED FOR MUDDING OR OFF ROAD, IT IS A PAVEMENT PRINCESS DRIVEN BACK AND FORTH TO WORK. I AM WORRIED THERE IS A MANUFACTURER DEFECT AND THAT THE WHEELS ARE NOT SAFE.

I HAVE HAD SEVERAL PROBLEMS WITH THE SPARK PLUGS BLOWING OUT OF MOTOR AND BREAKING COIL CAUSING IT TOO LEAK FUEL VAPORS OUT POSSIBLY CAUSING A FIRE THIS HAS HAPPENED SEVERAL TIMES. THREE DIFFERENT CERTIFIED MECHANICS HAVE ADVISED THIS IS CAUSED TO DEFECT IN THE ALUMINUM HEADS FROM FACTORY NOT HAVING ENOUGH THREADS CAUSING THE SPARK PLUG TO BLOW OUT. POSSIBLY CAUSING INJURY OR FIRE. THIS ISSUE NEEDS ADDRESSED AS IT IS A SAFETY CONCERN. WE HAD A SMALL ENGINE FIRE CAUSING SLIGHT DAMAGE TO ENGINE COMPARTMENT THAT HAD TO BE REPAIRED.

TL* THE CONTACT OWNS A 2003 FORD F-250 SUPER DUTY. WHILE ATTEMPTING TO USE THE CRUISE CONTROL, THE VEHICLE SPEED FUNCTION WOULD NOT WORK. THE CONTACT STATED THAT THE SWITCH BECAME HOT AND FAILED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V399000 (VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS 85,000.

5.4 LITER MOTOR BLOWS SPARK PLUGS OUT OF THE ENGINE, BECAUSE SOME MORON AT FORD DESIGNED AN ENGINE WITH 2 OR 3 THREADS PER PLUG PORT ON ALUMINUM HEADS. FORD IS PAYING A CLASS-ACTION LAWSUIT FOR MODEL YEARS 2004 - 2008, BUT MINE IS A 2003. THANKS FOR THE SCREW-JOB, FORD.

A SPARK PLUG BLEW OUT WHILE ACELERATING FROM A STOP SIGN, THIS HAS HAPPENED 3 SEPARATE OCCASIONS. A SMELL OF UNBURNT FUEL WAS PRESENT WHILE DRIVING TO FORD DEALER FOR REPAIR.

1 OF THE TANK STRAPS BUSTED OFF AND THE TANK BEGAN SAGGING AND ALMOST TOUCHING THE GROUND, THUS CAUSING A SEVERE FIRE HAZARD.

TL* THE CONTACT OWNS A 2003 FORD F-250 SD. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT NOTICED SMOKE FROM THE REAR OF THE VEHICLE AND THERE WAS A LOUD POPPING NOISE. THE VEHICLE WAS COMPLETELY SURROUNDED BY SMOKE RESULTING IN A FIRE. THE VEHICLE STALLED. THE FIRE WAS EXTINGUISHED INDEPENDENTLY. THE VEHICLE WAS TOWED TO THE CONTACTS RESIDENCE AND WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V553000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 81,000. UPDATED 7/1/15*CN THE CONSUMER STATED THERE WAS NO FIRE, JUST EXCESSIVE PRESSURE IN THE CRANKCASE CAUSING THE ENGINE TO BLOW OIL OUT THE GLOW PLUG. UPDATED 03/31/16.*JB

TL* THE CONTACT OWNS A 2003 FORD F-250 SD. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT MENTIONED THAT THE TRANSMISSION HAD TO BE SHIFTED INTO NEUTRAL AND THEN TO DRIVE BEFORE THE VEHICLE WOULD RESUME NORMAL FUNCTION. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP RELAY BOX NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 89,919.

TL* THE CONTACT OWNS A 2003 FORD F-250 EQUIPPED WITH BF GOODRICH ULTRA ALL RANGE TIRES, LINE SIZE: P235/85/R16. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE REAR PASSENGER SIDE TIRE BLEW OUT. THE CONTACT MENTIONED THAT AFTER INSPECTING ALL THE TIRES, HE NOTICED THAT THE TIRE TREAD WAS WEARING PREMATURELY AND HAD STARTED SEPARATING. THE VEHICLE WAS TAKEN TO A TIRE SHOP. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE TIRES WERE NOT REPLACED. THE TIRE FAILURE MILEAGE WAS 85,151. THE VEHICLE CURRENT MILEAGE WAS 86,000. UPDATED 03/17/15*LJ UPDATED 08/25/2017*CT

2003 FORD F-250. CONSUMER WRITES IN REGARDS TO SPEED CONTROL DEACTIVATION SWITCH FIRE. *SMD THE CONSUMER STATED THE VEHICLE WOULD OCCASIONALLY STALL AND RE-START, DUE TO VEHICLE MOMENTUM, BUT IT STALLED COMING TO A LOW RPM IDLE, OR STOP. WHEN IT STALLED, IT GAVE NO CODE WARNINGS OR DASH LIGHT INDICATOR. HE RESET THE IGNITION KEY AND RE-STARTED THE VEHICLE. THE LOCAL FORD DEALER COULD NOT FIND A PROBLEM. AFTER THE RECALL WAS PERFORMED, THE CONSUMER DID NOT EXPERIENCE ANY MORE PROBLEMS. *JB

I WAS TRAVELING ON THE HIGHWAY DURING FIVE O CLOCK TRAFFIC AT A SPEED OF APPROXIMATELY 40 MPH WHEN SUDDENLY THE VEHICLES IN FRONT OF ME BEGAN CRASHING INTO EACH OTHER. I PRESSED MY FOOT ON THE BRAKE PEDAL TO STOP AND SUDDENLY THE PEDAL WENT STRAIGHT TO THE FLOOR AND I SMASHED INTO THE BACK OF THE CAR IN FRONT OF ME. TODAY THE AUTO SHOP HANDLING THE REPAIRS CALLED ME IN TO LOOK AT WHAT HAPPENED. THE MASTER CYLINDER BROKE COMPLETELY FREE FROM THE BOOSTER. THE METAL BRACKETS BROKE IN HALF AND SEPARATED CAUSING THE LOSE OF BRAKES AND THE ACCIDENT. I HAVE PHOTOS OF THE MASTER CYLINDER BLOWN AWAY FROM THE BOOSTER. *TR

TRUCK IS LIGHTLY USED. TODAY I HOOKED UP THE HORSE TRAILER TO HAUL HORSES AND WHEN I WAS HEADED DOWN THE DRIVEWAY AND USED THE BRAKES THEY COMPLETELY FAILED. I ENGAGED THE TOW MODE ON THE TRANSMISSION AND USED THE E-BRAKE TO STOP. THERE WAS NO WARNING JUST BRAKE PEDAL TO THE FLOOR FAILURE. IF THIS FAILURE OCCURRED 2 MINUTES LATER I WOULD OF BEEN AT HIGHWAY SPEED. THERE WAS A LARGE LEAK ON THE MAIN BRAKE LINE ABOVE THE REAR FUEL TANK. I INSPECTED THE MAIN BRAKE LINE AND EVERY PLACE THE BRAKE LINE IS ATTACHED TO THE FRAME THERE IS SIGNIFICANT CORROSION OF THE BRAKE LINE . 2 INCHES FROM THE ATTACHMENT THE BRAKE LINE LOOKS BRAND NEW. LOOKS LIKE THE ENGINEERS USED A DISSIMILAR METAL AND CAUSED A CORROSION CELL. 10 YEAR OLD TRUCK AND I AM SPENDING $800.00 TO REPLACE THE ENTIRE MAIN BRAKE LINE. THIS TYPE OF FAILURE ON A $50,000 TRUCK SHOULD NOT BE HAPPENING. DEALER SAYS HE HAS NEVER SEEN THIS BEFORE. THIS IS A SERIOUS SAFETY FAILURE. *JB

THREAD SEPARATION , THIS IS THE SECOND BFG TIRE THAT HAS SEPARATED REFER TO ODI NUMBER 10508448. *TR

TL* THE CONTACT OWNS A 2003 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 170,000 AND THE CURRENT MILEAGE WAS 228,000. *TR

TIRE TREAD CAME OFF THE TIRE AT THE STEEL BELTS. *TR

TL* THE CONTACT OWNS A 2003 FORD F250 SD. THE CONTACT STATED THAT WHILE DRIVING UP AN INCLINE APPROXIMATELY 45 MPH, THERE WAS A SUDDEN REDUCTION IN THE ENGINE POWER AND THEN STALLED. THE VEHICLE RESTARTED AFTER NUMEROUS ATTEMPTS. A CHEMICAL BURNING ODOR EMITTED OUTSIDE OF THE VEHICLE. THE FAILURE OCCURRED SPORADICALLY AND WHENEVER THE FUEL TANK LEVEL REGISTERED QUARTER OF A TANK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THE FUEL TANK LINING WAS SEVERELY DAMAGED AND THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

TL* THE CONTACT OWNS A 2003 FORD F-250 SD. THE CONTACT STATED THAT WHILE PERFORMING AN OIL CHANGE, HE NOTICED THAT THE FRAME WAS RUSTED SEVERELY.THE CONTACT PERFORMED A THOROUGH INSPECTION OF THE VEHICLE AND ALSO DISCOVERED THAT THE FUEL TANK STRAPS WERE SEVERELY RUSTED. THE FRONT STRAP WAS COMPLETELY DETACHED FROM THE VEHICLE AND THE SECOND STRAP WAS PARTIALLY HANGING FROM THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND ADVISED HIM THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 125,000.

TL* THE CONTACT OWNS A 2003 FORD F250 SD. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE CLUTCH FAILED. UPON FURTHER INSPECTION THE CONTACT NOTICED THAT THE PLASTIC BUSHING HAD FAILED AND THE ROD WAS DETACHED FROM THE CLUTCH. THE CONTACT WENT TO THE DEALER, PURCHASED A NEW BUSHING AND REPAIRED THE VEHICLE HIMSELF. THE RECENT FAILURE WAS THE SECOND CLUTCH FAILURE ON THE VEHICLE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 58,000. UPDATED 10/24/12 *CN UPDATED 11/9/2012 *JS