2000 Ford F-250 SD complaints

MY 2000 F-250 SUPER DUTY HAD THE FAULTY CRUISE CONTROL DEACTIVATION BURN UP. THE F150 HAS THE RECALL BUT NOT THE 250, EVEN THOUGH ITS THE SAME FAULTY PART ON BOTH VEHICLES. THERE WAS A LOT OF SMOKE, BUT NO VISIBLE FLAMES. I WAS ABLE THE UNPLUG THE DEVICE BEFORE ANY MAJOR DAMAGE HAPPENED. *NM

DT: THE CONSUMER REPLACED THE WINDSHIELD WIPER MOTOR TWICE. THE DEALERSHIP TOLD HIM THAT THE PROBLEM WAS WITH THE BEARING ON THE MOTOR. THE FIRST WAS REPLACED IN JUNE OR JULY 2003. THE SECOND TIME IT HAD OCCURRED WAS IN AUGUST 2004, THE CONSUMER WAS UNABLE TO GET THE REPAIRS DONE UNTIL OCTOBER 2004. THE PROBLEM OCCURRED AGAIN ON 8-14-05. THE CONSUMER MADE AN APPOINTMENT TO HAVE THE REPAIRS DONE. EACH OF THESE PROBLEMS OCCURRED UNDER NO SPECIFIC CIRCUMSTANCES. AS SOON AS THE WIPERS WERETURNED ON THERE WAS A WINDING NOISE. *AK

WHILE TRAVELING MY LEFT FRONT FIRESTONE STEELTEX R4S II LT265/75/R16 SEPARATED FROM THE TIRE AND THEN BLEW OUT, CAUSING ME TO SWERVE LEFT OF CENTER, LUCKILY THERE WAS NO OTHER TRAFFIC COMING. WHEN I SENT MY TIRE TO FIRESTONE THEY HAD SAID THAT IT LOOKED LIKE SEPARATION. FIRESTONE/BRIDGESTONE STATED IN A LETTER THAT THE TIRE WAS OVER LOADED. THE TIRE IS OEM FOR MY 2000 FORD F-250. THE TIRES ON FRONT WE REPLACED FULL COST TO ME WITH TRANSFORCE. *NM

DT: WHILE BRAKING THE VEHICLE LURCHES FORWARD AND THEN IT SHUTS DOWN, WHICH CAUSES LIMITED STEERING AND BRAKING ABILITIES. THE CONSUMER HAS TAKEN THE VEHICLE TO THE DEALER APPROXIMATELY THREE TIMES, AND WAS TOLD THAT THEY COULDN'T DO ANYTHING ABOUT IT UNLESS THE PROBLEM OCCURRED FOR THEM. ON MAY 30, 2005 THE CONSUMER WAS DRIVING THE VEHICLE AND HAD TO BRAKE BECAUSE OF THE TRAFFIC IN FRONT OF HIM, WHEN THIS OCCURRED, THE VEHICLE LURCHED FORWARD AND THE ENGINE JUST CUT OUT, LIKE IT WAS NEVER STARTED. THIS CAUSED THE CONSUMER'S VEHICLE TO REAR END THE VEHICLE IN FRONT OF HIM. THE VEHICLE WAS TAKEN TO A BODY SHOP AND IT WAS REPAIRED. THE CONSUMER SPOKE TO FORD AND WAS TOLD THAT THERE WAS NOTHING THEY COULD DO. *AK *JB *NM PER CONSUMER, NONE OF THE ABOVE IS ACCURATE. THE CONSUMER WROTE: WHILE BRAKING, THE RPM REVVED UP, THE VEHICLE LURCHED FORWARD, THEN THE RPM DROPPED AND THE ENGINE HAD SHUT DOWN. THE CHECK ENGINE LIGHT ILLUMINATED. IT WOULD TAKE SEVERAL ATTEMPTS TO START THE VEHICLE . THIS WOULD OCCUR INTERMITTENTLY. EACH TIME THE CONSUMER HAD TAKEN THE VEHICLE IN FOR REPAIRS, THE DEALER WOULD BE UNABLE TO FIND THE PROBLEM. OTHER PROBLEMS: THE CRUISE CONTROL WAS INOPERATIVE AND THE VEHICLE WOULD DIE WHEN THE BRAKES WERE APPLIED AT TIMES. FORD RECALLED THE SAME MAKE MODEL YEARS 2003-2005. THE CONSUMER FELT THAT THE RECALL STARTED WITH HIS VEHICLE'S YEAR MAKE AND MODEL. *SC *JB

OCCUPANTS WERE DRIVING THE VECHICLE WHEN ALL OF A SUDDEN IT STARTED TO FLAME UP. THE FIRE WAS PUT OUT. BUT BEFORE THAT WAS COMPLETED THE FIRE HAD CONSUMED THE WIRING HARNESSES, FUSE PANEL, CRUISE DEACTIVACTION MECH. AND MISC. OTHER COMPONENTS, COMPUTER ETC. SHORTLY AFTER THIS FORD WAS ON THE NEWS ABOUT A RECALL OF THE EXACT THING THAT HAD HAPPENED TO THIS TRUCK. AT THE TIME THERE WAS ONLY LIABILITY INSURANCE ON THE VECHICLE. IT WAS PAID FOR... AND THAT IS ALL THAT IS REQUIRED. EXCEPT FOR THE FACT WHEN FORD DON'T WANT TO COVER THEIR MISTAKES... IN CONCLUSION FORD SAYS IT IS NOT THE RIGHT TYPE OF TRUCK BUT IF THE CRUISE MECHANISIM IS WHAT CAUSED THE FIRE AND THEN THEY DO A RECALL I THINK THEY SHOULD BE RESPONSIBILE FOR THE ITEM IN QUESTION, NO MATTER WHAT YEAR THEY SAY......

DEPRESSED CLUTCH PEDAL AND RELEASED IT. THE PEDAL ROSE AN ADDITIONAL 4 INCHES MAKING IT VERY DIFFICULT IF NOT IMPOSSIBLE TO USE THE CLUTCH. I WAS INFORMED BY THE DEALER THIS WAS A COMMON PROBLEM AND I HAD BEEN LUCKY THAT IT HAD NOT RISEN AN ADDITIONAL .25 INCH BECAUSE I WOULD HAVE HAD NO CLUTCH. FORD KNEW THERE WAS A PROBLEM WITH THE MASTER CYLINDER AND HAD AN UPGRADE KIT AVAILABLE WHICH I KNEW NOTHING ABOUT. I ASSUME THE SAME MASTER CYLINDER IS USED IN THE BRAKES.

2000F-250 SUPER-CREW HEAVY DUTY P/U CAUGHT ON FIRE AND BURNED UP THE WIRING AND FUSE PANEL ALONG WITH THE MASTER CYLINDER COVER. FORD HAS NOT RETURNED MY PHONE CALLS. FORD REPRESENTATIVE SAID IT WOULD BE 5 BUSINESS DAYS BEFORE ANYONE CALLED, IT WAS THE SECOND WEEK AND NO CONTACT WAS MADE. *AK

KNOCKING NOISE FRONT END WHEN BRAKING OR BACKING UP APPLYING BRAKES. INSPECTION REVEALED UPPER AND LOWER BALL JOINTS WORN OUT, RIGHT AND LEFT SIDES.

DRIVING HOME AT ABOUT 55MPH NOTICED A VERY BAD HESITATION IN 5.4L ENGINE AND APPARENT MISFIRE. AFTER PULLING OVER AND SHUTTING ENGINE OFF, NOTICED # 3 COIL BROKEN AND SPARKPLUG LAYING BY FUEL RAIL. SPARK PLUG SHOT OUT OF CYLINDER HEAD DUE TO POOR ENGINEERING BY FORD. 1999-2002 F250 5.4L HEADS ONLY HAVE 4 THREADS THAT HOLD SPARK PLUGS.*AK

PARKED VEHICLE ABOUT AND 25 MINUTES LATER SMOKE WAS COMING FROM UNDER THE HOOD OF THE VEHICLE. OPENED THE HOOD TO FIND THE CRUISE CONTROL SERVO WAS SMOKING. DISCONNECTED THE WIRES TO THE SERVO AND IT STOPPED. HAAD THE BURNED PART FOR INSPECTION. DURING THE TRIP BEFORE THE FIRE THE CRUISE CONTROL LIGHT ON THE DASHBOARD WAS COMING ON AND OFF AND WAS NOT USED. *AK THE CONSUMER STATED THAT THE CANCEL SWITCH WAS LEAKING. *TC

I WAS DRIVING MY 2000 F-250 7.8 DIESE AT APPROX. 5 MPH. IT WAS SNOWING OUTSIDE. I HAD MY WIPERS ON. THE WIPERS BECAME STUCK AND THEN MY TRUCK BEGAN TO FILL WITH SMOKE. I ATTEMPTED TO TURN THE WIPERS OFFS. THE WIPERS WOULD NOT SHUT OFF. I TURNED THE TRUCK AND THEN RESTARTED IT. THE WIPERS STOPPED FOR A MINUTE THEN CONTINUED TO FASTER. I ALSO SAW FLAMES COMING FROM THE HOOD AREA. MY WIPERS NO LONGER FUNCTION AND I THERE IS STRONG ODOR OF BURNT ELECTRICAL WIRING IN THE TRUCK. I CALLED FORD ABOUT THIS PROBLEM AND THEY SAID MY TRUCK WAS NOT PART OF THE RECALL AND THEY WERE NOT RESPONSIBLE.*AK

CONSUMER COMPLAINED ABOUT THE ELECTRICAL SYSTEM. AT FIRST, VEHICLE LOST CRUISE CONTROL. THEN IT LOST THE BRAKE LIGHTS. WHEN TAKEN TO BE SERVICED, IT WAS DETERMINED THAT THE FAILURE WAS DUE TO A BLOWN OUT WIRING HARNESS CONNECTED TO THE CRUISE CONTROL.*AK

VEHICLE WAS PARKED OUTSIDE THE OWNERS HOMEAND IT CAUGHT ON FIRE. OWNER CONTACTED THE MANUFACTURER. CURRENTLY THE MANUFACTURER WAS RECALLING SEVERAL SIMILAR VEHICLES FOR THIS PROBLEM. HOWEVER, THIS VEHICLE WAS NOT INCLUDED IN THE RECALL. *AK...*AK

KNOCKING NOISE FRONT END WHEN BRAKING OR BACKING UP APPLYING BRAKES. INSPECTION REVEALED UPPER AND LOWER BALL JOINTS WORN OUT, RIGHT AND LEFT SIDES. *AK

WINDSHIELD WIPER MOTOR ON MY 2000 FORD F250 TRUCK WAS REPLACED (SUPPOSEDLY)BY FORD IN 2002 DUE TO A RECALL. HERE IS THE NHTSA REFERENCE:"NHTSA CAMPAIGN ID: 01V258000" ON 12/27/04, MY VEHICLE HAD AN ELECTRICAL FIRE/BURN/MELTDOWN CAUSED BY THE WIPERS NOT BEING ABLE TO RETURN TO THE," PARK" POSITION BY SNOW AND ICE. THE WIPERS WERE IN THE,"OFF" POSITION HOWEVER. DAMAGE TO THE WIPER MOTOR ASSEMBLY AND THE SUPPLYING WIRING HARNESS WERE EVIDENT, ALONG WITH THE DISTINCT ELECTRICAL BURN SMELL THROUGHOUT THE VEHICLE( WHICH IS STILL PRESENT SEVERAL DAYS AFTER INITIAL INCIDENT). THE WIPERS ARE NOW INOPERABLE, MAKING THE VEHICLE INOPERABLE DUE TO SAFETY CONCERNS FROM LACK OF VISIBILITY (MELTING SNOW/ROAD GRIME QUICKLY MAKE THE WINDSHEILD VERY DIRTY). *AK

2000 FORD SUPERDUTY BUILT AT KENTUCKY TRUCK PLANT EXHIBITS EXCESSIVE SHAKING DURING BRAKING SINCE @ 3,000 MILES. REPLACED FRONT DISCS/CALIPERS 5 TIMES BY 100,000 MILES EVEN THOUGH TRUCK IS DRIVEN VERY LIGHTLY (NO TOWING, MOUNTAINS ETC. JUST NORMAL HIGHWAY AND TOWN DRIVING) FORD DEALERS (THREE CONSULTED SO FAR) SAY THIS IS A KNOWN PROBLEM AND THAT POST-2000 MY VEHICLES RECEIVE IMPROVEMENTS. WE HAVE PUT THE BEST POSSIBLE MATERIALS/PARTS THAT WE CAN IDENTIFY TO MINIMIZE PROBLEM. WE BELIEVE THAT REPLACEMENT PARTS REPRESENT POST-2000MY IMPROVEMENTS. BRAKES CONTINUE TO WEAR RAPIDLY, WARP AND CAUSE SIGNIFICANT VIBRATION DURING EVEN VERY MODERATE BRAKING. THIS IS NOT JUST AND ACCELERATED WEAR ISSUE BUT A SAFETY ISSUE IN TERMS OF BRAKING PERFORMANCE AND HANDLING DURING BREAKING.*AK

STARTED ENGINE, HEARD POP SOUND, ENGINE SUDDENLY RAN BAD. MECHANIC SAID SPARK PLUG BLEW OUT (STRIPPED). MECHANIC SAID THIS IS COMMON FORD PROBLEM, A DEFECT, AND EXPENSIVE. *NM

REAR TIRE EXPERIENCED A TREAD SEPARATION WHILE DRIVING 35 MPH WITH ONLY THE DRIVER. THE TIRE REMAINED INFLATED WHILE DRIVING HOME IN THIS CONDITION. THE TIRE WAS MOUNTED ON A 2000 FORD F250- SUPER DUTY TRUCK. AFTER MARKET EQUIPMENTS MADE BY GENERAL, MODEL NAME APACHE, INSTALLED AT 46,000 MILES, TIRE SIZE LT265/75R16, DOT# ADW81EE1202. TIRE DEALER WAS CONTACTED.*AK

THE LEFT REAR TIRE EXPERIENCED A TREAD SEPARATION WHILE DRIVING 35 MPH, THE TIRE WAS STILL INFLATED. WITH ONLY THE DRIVER. THE TIRE WAS ON A 2000, FORD, F250-SUPER DUTY TRUCK. AFTER MARKET EQUIPMENT INSTALLED AT 46,000 MILES, TIRE SIZE LT 265/75R16, AND DOT # ADW81EE1202.

VERY ROUGH SHAKING DURING HIGHWAY SPEED BRAKING AND TRUCK LUNGES DURING LOW SPEED STOPS. REPLACED MY ROTORS MULTIPLE TIMES AND FIX LASTS ONLY A SHORT TIME. I TRAVEL A LOT OF HIGHWAY MILES AND VERY LITTLE CITY. NO TOWING OR HEAVY LOADS INVOLVED. THIS GREATLY AFFECTS MY STEERING WHILE BRAKING ABILITY AND GREATLY LENGTHENS MY STOPING DISTANCE. VERY UNSAFE!!!! SAME PROBLEMS WITH EXCURSION USED BY MY FIRE DEPARTMENT. IF PROBLEMS CONTINUES I KNOW IT'S THE LAST FORD THE CITY WILL BUY.*AK

TIRE FAILURE/BLOW-OUT. BRIDGESTONE HAS ISSUED A SAFTEY COMPAIGN NOTICE ON AUGUST 26, 2004. THIS INFORMATION SUBSTANTIATES MY ORIGINAL FAULTY TIRE CLAIM BACK IN FEBRUARY. I AM SEEKING REIMBURSEMENT FOR THE TIRE(S) AND VEHICLE DAMAMGE. *AK PLEASE ADVISE AS TO HOW I SHOULD PROCEED. THANK YOU.

2000 FORD F250 5.4L 3RD FROM FRONT PASSENGER SIDE SPARK PLUG SHOT OUT. STRANDED HAD TO HAVE VEHICLE TOWED. HELICOIL INSTALLED AND IS HOLDING, BUT FOR HOW LONG?*AK

WHILE TRAVELING DOWN THE HIGHWAY AT AN ESTIMATED 70MPH TOPS. THE TIRE TREAD SEPERATED FROM THE STEEL BELT OF MY FIRESTONE STEELTEX AT LT265/75R16 LOAD RANGE E TIRES, ON MY 2000 FORD F-250 PICKUP. THIS SEPERATION CAUSED ME TO TEMPORARILY LOSE CONTROL AND ENDANGERED MY PREGNANT WIFE AND OTHER 2 CHILDREN IN THE CAR AT THE TIME. THE TIRES WERE NOT UNDER INFLATED BECAUSE I HAD CHECKED THEM NOT A WEEK BEFORE AND ALL OTHER TIRES ARE CURRENTLY STILL INFLATED TO CORRECT SPECS. THE TREAD WAS NOT OVERLY WORN THE TIRES STILL HAD QUITE ALOT OF MILAGE LEFT ON THEM. AND WHATEVER ELSE FIRESTONE MIGHT CLAIM WAS WRONG, DOES NOT MEAN THAT THE TREAD SHOULD FLY OFF THEYRE TIRES. QUALITY TIRES SHOULD BE ABLE TO STILL HOLD TOGETHER REGUARDLESS OF ANY SMALL LACK OF ATTENTION ON THE DRIVERS PART. ON A SECOND NOTE THIS ISNT THE FIRST TIME FIRESTONES HAVE FAILED ME IN AN IDENTICAL WAY. THE SAME THING HAPPEND TO THE FIRESTONE TIRES TWICE ON MY JEEP GRAND CHEEROKEE. AND EVERYONE KEEP IN MIND THIS TIRE I HAVE LISTED ABOVE IS THE ONE BEING USED TO REPLACE THE RECENTLY RECALLED IDENTICAL MODEL BUT LOAD RANGE D TIRE FROM FIRESTONE.

HAD A THROW OUT BEARING FORK BREAK INTO TWO PIECES ON MY 2000 F250 FORD PICK UP. CLUTCH BECAME TOTALLY INOPERATIVE AND THE TRUCK HAD TO BE TOWED. TRUCK HAD 52,000 MILES ON IT AT THE TIME OF THE FAILURE. ON EXAMINATION THE T.O. BEARING FORK APPEARS TO HAVE BEEN CRACKED SINCE NEW.*AK

TEN MINUTES AFTER PARKING THE VEHICLE IT CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS CONTACTED TO EXTINGUISH THE FIRE. THE FIRE SEEME TO HAVE STARTED UNDER THE HOOD ON THE DRIVER'S SIDE. *AK

ON MY WAY HOME FROM WORK I HEARD AN UNUSUAL NOISE EMINATING FROM UNDER THE HOOD OF MY 2000 FORD F-250 SUPER DUTY, 6.8 (V-10) TRUCK. I THOUGHT IT WAS AN XHAUST MANIFOLD LEAK. I PULLED ONTO A GRAVEL ROAD, LIFTED THE HOOD AND CLIMBED UP TO LOOK TO SEE WHAT I COULD FIND. IMAGINE MY SUPRISE TO SEE A LEFT BANK SPARK PLUG, #8 CYLINDER, LYING AGAINST THE FUEL RAIL AND THE COIL FIRING AGAINST THE HEAD. I LIMPED HOME, WONDERING ALL THE WHILE HOW MUCH FUEL WAS POURING INTO THE OIL PAN! I USED A STRONG FLASH LIGHT TO PEER INTO THE SPARK PLUG HOLE AND FOUND TO MY SUPRISE, VERY LITTLE IF ANY THREADS TO CONTIAN THE SPARK PLUG. I THEN USED A 90 DEG. PICK TO "FEEL" THE THREADS. NONE. I CALLED JOE MACHENS FORD IN COLUMBIA, MO. TO SEE IF THIS MIGHT BE A COMMON PROBLEM. THEY INFORMED ME THEY SEE QUITE A FEW OF THE 5.4 LITER CYLINDER HEADS IN FOR REPAIR AND HAD HAD ONE 6.8. THEY INFORMED ME THAT FORD HAD ISSUED A TSB FOR THE LIGHTNING WITH THE 5.4 ( I CAN SEE WHY, A COMPRESSOR ON TOP OF THE ENGINE CAN CREATE PROBLEMS) OTHER THAN THE AFORMENTIONED TSB, NO OTHERS EXIST AND FORD HAS YET TO ACKNOWLEDGE THE PROBLEM. I CHECKED FOR INFO VIA THE GOOGLE SEARCH ENGINE AND WASN'T ABLE TO FIND MUCH INFORMATION. I PROBABLY USED THE INCORRECT TERMINOLOGY. WHO KNOWS HOW MUCH OF THE ALUMNIUM THREADS WERE INGESTED INTO THE CYLINDER, WHICH IN TURN WILL CAUSE SCARRING AND OIL CONTROL PROBLEMS. I DO KNOW HOWEVER, DUE TO WHAT I WAS TOLD BY THE PERSON AT JOE MACHENS FORD IN COLUMBIA, MO., IT SEEMS AS THOUGH FORD HAS N

PROBLEMS WITH TRANSMISSION, FRONT AXLE AND VIBRATION.*MR THE CONSUMER HAS ATTEMPTED TO HAVE THE PROBLEMS RESOLVED APPROXIMATELY 6 TIMES IN TWO YEARS. THE CONSUMER IS SEEKING RELIEF UNDER THE MICHIGAN LEMON LAW. *NM

STEEL BELT & TREAD CAME OFF OF TIRE DOING ABOUT $200 DAMAGE TO LEFT REAR FENDER. *AK

WHILE DRIVING AT 40 MPH LEFT FRONT WHEEL LOCKED UP, CAUSING THE FRONT AXLE TO BREAK. ALSO, THERE WAS A BROKEN ROTOR AND A DESTROYED ANTI LOCK BRAKE SENSOR. CURRENTLY, THE RIGHT WHEEL BEARING MALFUNCTIONED. *AK

WHILE DRIVING AT 50 MPH CLUTCH DID NOT DISENGAGE TO CHANGE GEARS. VEHICLE WAS TAKEN TO A DEALER. *AK THE DEALER DETERMINED THAT THE HOUSING FOR ONE OF THE SPRINGS IN THE CLUTCH PAD BROKE BETWEEN THE SPRIND AND OUTER HOUSING. *NM

WARPING OF FRONT DISC ROTORS. THE ROTORS WARPED OUT THE FIRST TIME AT 30000 MILES. SINCE THEN THE ROTORS WARP BETWEEN 10 - 20000 MILES CONSISTENTLY. AGAIN GOING ONLINE I FOUND MANY PEOPLE ARE HAVING THE SAME PROBLEM. ALL WITH THE FORD F250, 350 MODEL YEAR 1999 - 2003. PRESENTLY I HAVE HAD MY FRONT ROTORS EITHER CUT OR REPLACED 4 TIMES. ESTIMATED TIME LINE THAT WORK WAS REQUIRED.; 30000, 44000, 60000 AND THE CHIMMY IS BACK AT 76000 . THIS PROBLEM CAUSES THE TRUCK TO SHAKE AND CHIMMY. GREATLY EXTENDING THE DISTANCE WHICH THE TRUCK CAN STOP. *AK

APRIL 2004. FAULTY CABLE IN STEEING COLUMN. THIS CABLE CAUSES A FAILURE WHICH DISABLES THE DRIVER SIDE AIR BAG IT ALSO DISABLES THE HORN AND CRUISE CONTROL. AFTER GOING TO SEVERAL DISCUSSION FORUMS THIS IS A COMMON PROBLEM AFFECTING 100'S PERHAPS 100 OF FORD SUPER DUTY F250, F350 VEHICLE. PER THE CHAT PAGES FORD WAS ABLE TO GET AROUND THIS ISSUE BY STATING THE FAULTY CABLING EFFECTS THE CRUISE CONTROL ONLY. THIS IS A MISCONSEPTION. ALSO BASED ON THESE CHAT PAGES THIS PROBLEM EFFECTS MOST F250,350 FROM 1999 - 2003. THE AVERAGE FAILURE TIMELINE IS 45000 - 70000 MILIES. MINE OCCURED AT 68000. *AK

TREAD SEPARATION ON INTERSTATE 80 WHILE TRAVELING AT 60 MPH CAUSING TIRE BLOWOUT. I AM ORIGINAL OWNER OF VEHICLE.

WHILE DRIVING IN RAINY WEATHER, INTERMITTENTLY THE FRONT WINDSHIELD WIPERS FAILED. THE DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *NM THE CONSUMER PROVIDED A COPY OF SAFETY RECALL 01S24 WHICH WAS FOR 2000 FORD F250 WITH DEFECTIVE WIPER MOTOR SWITCH. *NM

THIS VEHICLE IS EQUIPPED WITH BRIDGESTONE DUELER AT TIRES, SIZE 285/75R16 . THERE WERE 3 TIRE BLOWOUTS WITHIN 16,000 MILES. THERE WERE 2 BLOWOUTS ON THE REAR TIRES. 1 FRONT TIRE BEGAN TO VIBRATE BEFORE IT BLEW OUT. *AK

BRIDGESTONE DUELLAR AT LT285/75R16 S/N# K9801D693AZ. DRIVING E/B 210 FRWY BETWEEN SAN DIMAS AND FONTANA, NOTICED A VERY UNUSUAL VIBRATION ON THE LEFT SIDE OF THE TRUCK. THE LEFT MIRROR WAS ALSO VIBRATING. CAME TO THE END OF THE FREEWAY IN RIALTO, AS I SLOWED DOWN TO A STOPP LIGHT THE WHOLE TRUCK WAS SQUIRMING FROM SIDE TO SIDE. I FOUND THAT THE TREAD HAD BUBBLED UP FOR APPROX. A QUARTER OF THE TIRE, I PUT MY SPARE ON AND EXAMINED THE TIRE. THERE IS STEEL POPPING OUT OF THE INSIDE PART OF THE TREAD, IT'S OBVIOUS THE TREAD IS SEPERATING AND COMING APART. WHAT IS BRIDGESTONE GOING TO DO ABOUT THESE TIRES? I HAVE TWO FRIENDS WITH THE SAME TIRES THAT HAD THE SAME THING HAPPEN TO THEM, BOTH UNFORTUNATELY SUFFERED BLOWOUTS AND MAJOR BODY DAMAGE.*AK

STOPPED FOR FUEL. SMELLED SOMETHING HOT. RIGHT REAR BRAKE CALIPER PISTON STUCK IN CALIPER AND WOULD NOT RELEASE, WHEEL BECAME EXCESSIVELY HOT, WAS HOT ENOUGH TO CAUSE A BURN ON FINGER. DROVE TO NEARBY REPAIR CENTER FOR REPAIR. DURING REPAIR IT WAS ALSO DISCOVERED THAT LEFT FRONT CALIPER WAS ALSO STICKING.

WHILE DRIVING AT 60 MPH AND PULLING A TRAILER CONSUMER FELT A TREMBLE. THEN, HEARD A LOUD EXPLOSION. AFTER STOPPING THE VEHICLE CONSUMER FOUND THAT TREAD SEPARATED FROM THE RIGHT REAR TIRE. THE SEPARATED TREAD DAMAGED THE MUFFLER AND THE REAR FENDER.*AK

STEELTEX R4S TIRES ON MY 2000 F250. ONE DEVELOPED A SIDEWALL BULGE AT APPROX. 27000 MILES. I REPLACED ALL BASED ON WEB RESEARCH OF PROBLEMS OTHERS WERE HAVING. HAVE TIRES IF INTERSTED IN REVIEWING.. *AK

I WAS ON THE INTERSTATE WITH CRUISE CONTROL SET AT 70MPH WHEN TREAD SEPERATED FROM TIRE. THE VEHICLE WAS SENT ACROSS THREE LANES OF TRAFFICE INTO THE MEDIAN AND ALMOST INTO ONCOMING TRAFFIC. IT TOOK ALL MY STRENGTH TO KEEP THE VEHICLE FROM ENDING UP IN THE ONCOMING TRAFFIC. IT TOOK OUT THE ALL DASHBOARD CONTROLS AND DID EXTENSIVE DAMAGE TO THE FRONT DRIVERS SIDE QUARTER PANEL AND BUMPER. LUCKILY, NO ONE WAS INJURED BUT IT COULD HAVE ENDED UP A LOT WORSE.*AK

TRANSMISSION PROBLEMS THE TRANSMISSION HAS HAD TO HAVE 4 MAJOR REPAIRS IN 1.5 YEARS. *AK

FORD F-250 SUPERDUTY PICK-UP TRUCK EAD ON COLLISION WITH GARBAGE TRUCK OTH AIR BAGS DID NOT DEPLOY SEAT BELT (WORN BY DRIVER) DID NOT LATCH. *AK

HEADLIGHT PLUGS HEATING UP, CRACKING, AND FAILING. THE HEADLIGHTS WILL GO DIM OR GO OUT COMPLETELY AT ANY TIME WHILE OPERATING. FOUND THAT THE WIRES FEEDING INTO THE PLUG HEAT UP AND HAVE CAUSED THE PLASTIC PLUG TO DETERIORATE. JUST JIGGLING THE WIRES CAN CAUSE THE HEADLIGHTS TO DIM OR FAIL. *LA

BRAKE ROTORS WARP ALL THE TIME, CAUSING SEVERE VIBRATION WHILE BRAKING. I HAVE HAD THIS PROBLEM FIXED 5 TIMES. FIRST THE ROTORS WERE TURNED, THEN REPLACED, THEN TURNED ETC, ETC. I'M DUE TO GO IN AGAIN FOR THE 6TH FIX, WITH ONLY 5,000 MILES ON THE NEWEST SET OF ROTORS. I ONLY HAVE 52,000 ON THE TRUCK. SO FAR THE DEALER HAS STOOD BEHIND THE FIXES BUT THIS IS A SAFETY CONCERN FOR ME AS WELL AS A FINANCIAL CONCERN SINCE THEY WILL START TO MAKE ME PAY. I'VE BEEN A HIGHWAY PATROLMAN FOR 18 YEARS. I ABUSE MY CRUISER BRAKES ON A DAILY BASIS AND THEY LAST 40,000 MILES! MY TRUCK IS BABIED AND IT EATS UP BRAKES... UNACCEPTABLE. *LA

REAR END BOUNCES VIOLENTLY WHEN YOU HIT A BUMP ON EXPRESSWAY. LITERALLY HAVE TO SLOW DOWN TO 35 OR 40 MPH FOR IT TO STOP. *LA

WHILE PARKING AT 5 MPH CONSUMER DEPRESSED THE BRAKES AND VEHICLE WOULD NOT SLOW DOWN. THEN, VEHICLE COLLIDED INTO A BUILDING. A CERTIFIED MECHANIC WAS CALLED TO THE SCENE, AND INFORMED THE CONSUMER THAT THE ACTUATING ROD RETAINING CLIP BROKE, AND WAS LAYING ON THE FLOOR OF THE VEHICLE.*AK

2000 F250 CREW CAB TRUCK: STEERING CONTROL PROBLEMS, I.E.; STEERING WANDER, "BUMP STEERING". VEHICLE HAS BEEN TO FORD DEALERSHIPS FOR REPAIR BUT PROBLEM STILL EXISTS. *AK

UNABLE TO STEER WHILE BRAKES ARE APPLIED. THIS OCCURS WHEN THE VEHICLE IS STOPPED. THE WHEELS BARELY TURN AT ALL IF THE BRAKES ARE APPLIED, AND THE VEHICLE IS NOT MOVING. *LA

THESE TIRES (GENERAL GRABBER TR, SIZE 235/85R16) CAME AS ORIGINAL EQUIPMENT ON A 2000 FORD F250 SUPER DUTY. THIS TRUCK IS USED MAINLY ON PAVED ROADS; OCCASIONALLY ON GRAVEL ROADS. THE WORST "OFF ROAD" DUTY THIS TRUCK EVER SEES IS A RARE TRIP ONTO DIRT OR GRASS. I AM CAREFUL ABOUT KEEPING WHEELS BALANCED AND TIRES PROPERLY INFLATED AND ROTATED. IN THE SPRING OF 2003, WITH ABOUT 20,000 MILES ON THE TIRES, I DISCOVERED A GRAPEFRUIT SIZED BULGE IN THE INSIDE SIDEWALL OF ONE OF THEM. A FIELD REPRESENTATIVE FROM GENERAL TIRE PROCLAIMED THAT THIS BULGE WAS DUE TO A "ROAD HAZZARD." [MY FIRST SIDEWALL BULGE IN 37 YEARS OF DRIVING, BUT I GUESS IT CAN HAPPEN. HOWEVER, DON'T LET THE LOW MILAGE ON THE TRUCK FOOL YOU. ALTHOUGH I DRIVE LESS NOW THAN I USED TO, WITH OTHER VEHICLES I STILL AVERAGE OVER 35,000 MILES PER YEAR. I HAVE OWNED A LOT OF TIRES.] I WAS NOW SUSPICIOUS OF THESE TIRES, SO IN AUGUST 2003 (AT 22,000 MILES) BEFORE A 2,000 MILE TRIPT WHICH I HAD TO MAKE WITH THE TRUCK, I CAREFULLY INSPECTED THE TIRES AND DOUBLE CHECKED THE INFLATION. UPON MY RETURN HOME I DISCOVERED A LEMON SIZED BULGE IN THE OUTSIDE SIDEWALL OF ANOTHER ONE OF THIS SET. I THEN IMMEDIATLY REPLACED THE TIRES ON THE TRUCK WITH ANOTHER BRAND. UPON INSPECTION OF THE REMOVED TIRES, I DISCOVERED THAT A THIRD TIRE HAD A WALNUT SIZED BULGE IN A SIDEWALL. SO, IN 24,000 MILES, THREE OF THE ORIGINAL FOUR TIRES DEVELOPED SIDEWALL BULGES. INTERESTINGLY, ALL OF THE BULGES WERE BETWEEN THE BEAD AND THE WIDEST PART OF THE SI

WHILE ACCELERATING AND STOPPING THERE IS A CLUNK AND YOU CAN FEEL IT UNDER THE TRUCK. THE DEALER SUGGESTED IT WAS THE BRAKES. I HAD THE BRAKES CHANGED AND THE ROTORS AND DRUMS CHECKED BUT IT IS STILL HAVING THE PROBLEM. I RECENTLY VISITED THE FORD -TRUCKS. COM SITE TO FIND SEVERAL CASES OF THIS AND IT APPARENTLY IS DUE TO AN IMPROPERLY GREASED DRIVE SHAFT AT THE REAR BEARING. THIS IS A PROBLEM THAT FORD SHOULD CORRECT DUE TO THEIR NEGLIGENCE IN IMPROPERLY GREASING THE JOINT. *JB