2012 Ford Fusion

Defect. Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Risk. An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy. Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.

Defect. Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Risk. In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy. Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.

Defect. Ford Motor Company (Ford) is recalling certain air bag inflator and/or module replacement service parts that may have been used as part of a collision repair. The parts include certain driver-side air bag inflators and/or modules, designed to fit 2005-2014 Ford Mustang and Mustang GT500. It also includes certain passenger-side air bag inflators and/or modules designed to fit 2005-2014 Ford Mustang, 2010-2012 Lincoln MKZ, 2010-2012 Ford Fusion, 2010-2011 Mercury Milan, 2007-2011 Ford Ranger, and 2007-2010 Lincoln MKX vehicles. Please see Ford's recall report for the specific part numbers. These parts may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Risk. In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy. Ford will notify dealers that purchased the affected parts, and dealers will provide replacement parts to purchasers, free of charge. The recall began March 18, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.

Defect. Ford Motor Company (Ford) is recalling certain 2014 Ford Mustang vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Ford is recalling certain 2011 Ford Ranger and Mercury Milan vehicles, 2011-2012 Ford Fusion and Lincoln Zephyr/MKZ vehicles and 2011-2014 Ford Mustang vehicles sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Ford is also recalling certain 2010 Ford Edge and Lincoln MKX vehicles, 2010-2011 Ford Ranger and Mercury Milan vehicles, 2010-2012 Ford Fusion and Lincoln Zephyr/MKZ vehicles, and 2010-2014 Ford Mustang vehicles sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules, used as original equipment or replacement equipment (such as after a vehicle crash necessitating replacement of the original air bags), that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Risk. An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy. Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 13, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall 19S01.

Defect. Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Risk. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy. Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.

Defect. Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with a 3.5L GTDI engine and 2013 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with any available engine. The affected vehicles have electric power steering assist systems that may shut down as a result of a steering motor sensor fault.

Risk. If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash.

Remedy. Ford will notify owners, and dealers will check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTC). If dealers find any loss of steering assist DTCs, the steering gear will be replaced, free of charge. If, no codes are found during the PSCM inspection, the PSCM software will be updated, free of charge. The recall began on July 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S18.

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at …

On September 28, 2016, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE16-011) to investigate claims of power steering assist loss on model year (MY) 2010 Ford Fusion vehicles. During the PE, ODI received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at various speeds with no warning. Ford Motor Company (Ford) provided 1,851 unique reports and 1,720 warranty claims related to the alleged problem. It should be noted that as the result of investigation PE14-030, Ford conducted a safety …

The Office of Defects Investigation (ODI) opened a preliminary evaluation to investigate complaints of the loss of power steering while driving. The subject vehicles are equipped with a rack mounted Electric Power Assisted Steering (EPAS) unit.Some of the complaints alleged that the steering assist failed and resulted in increased steering efforts that contributed to a loss of control and in some cases a crash.The EPAS system was manufactured by TRW Automotive for Ford and was designated as Generation I.These units were first produced and put into vehicle production in July 2008 beginning …

On February 21, 2013, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE13-003 to investigate allegations of electronic throttle body (ETB) failures resulting in sudden reduction of engine power in model year (MY) 2009-2013 Ford Escape, Fusion, Mariner and Milan vehicles. During this investigation, Ford identified a condition in subject vehicles equipped with 2.5L and 3.0L engines that may result in a sudden reduction of engine power.According to Ford, the ETB internal motor contacts may develop a high resistance material buildup condition on the commutator, resulting …

FORD/LINCOLN: THERE IS AN EXTENDED WARRANTY COVERAGE FOR THE LOSS OF ABS SPEED SIGNAL RELATED COMMUNICATION THAT DISABLE OBDII SYSTEM MONITORS FOR PCM REPROGRAMMING. MODEL 2011-14 F-SUPER DUTY, ESCAPE, TAURUS, FUSION, MKT, MKZ. *PE

Some 2010-2012 Fusion/Milan and 2011-2012 MKZ vehicles equipped with a 2.5L or 3.0L engine and electronic power assist steering (EPAS), a remanufactured replacement steering gear (MU2Z-3V504-ARM) is available which is significantly less expensive than a new replacement gear. When conducting repairs that are customer pay, offer the customer a remanufactured …

SOME 2010-2016 EPAS EQUIPPED VEHICLES MAY EXHIBIT STEERING RELATED NOISES. THE WORKSHOP MANUAL (WSM) DIAGNOSTIC PROCEDURES HAVE BEEN UPDATED IN SECTION 211-02. WHEN DIAGNOSING AND REPAIRING EPAS STEERING NOISES USE THE UPDATED PROCEDURES.

LINCOLN/FORD: STEERING SYSTEM SENSES, HALF FRONT LOWER CONTROL ARMS/REARWARD IS EXPERIENCING A HIGHER FRICTION CONDITION AND CAUSING THE INSTRUMENT CLUSTER STABILITY/TRACTION TO ILLUMINATE. MODEL 2011-2012 FUSION, MKZ. *PE

The contact owns a 2012 Ford Fusion. The contact stated that while entering the vehicle to start the engine, the power steering became inoperable. The contact associated the failure with NHTSA Campaign Number: 15V340000 (Steering); however, the dealer refused to perform the steering gear recall repair because no Diagnostic Trouble Codes (DTCs) were present. The contact stated that the dealer was withholding Diagnostic Trouble Code (DTC) information to avoid replacing the steering gear. The manufacturer was notified of the failure by telephone. The failure mileage was approximately 120,000.

Our 2012 Fusion suffered a sudden loss of power steering, was diagnosed with code U3000 at a Ford dealer, and that the dealer confirmed it matches the 15S18 recall symptoms despite being built two months outside the window. Our vehicle was manufactured at the Hermosillo plant in 2012, just two months outside the 15S18 recall window. It suffered an identical, sudden loss of power steering assist while driving, indicating Ford's recall parameters failed to capture all vehicles fitted with the defective component.

The contact owns a 2012 Ford Fusion. The contact stated that while driving 50 MPH, the vehicle lost power steering assist, causing the steering wheel to be significantly difficult to turn. The contact was able to drive to the nearby residence and parked in the driveway. The message "Service Power Steering Assist" was displayed after the failure. The contact associated the failure with NHTSA Campaign Number: 15V340000 (Steering). The failure mileage was approximately 98,000.

I got a 2012 ford fusion se 2.5 4l power steering gone out in it,I put in the vin number to see if mine was recalled it said 0 but my car has the part in the car that made the car recalled ,on the dash its says power steering service its dangerous and I had my child in the car vin number on my car is [XXX] I seen where other 2012 ford fusion se 2.5 4l was recalled for the power steering going out INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While I was driving my 2012 Ford Fusion on August 3rd the steering cut out. I parked the car and re-started it and it worked again. It went to the shop (Extra Mile Automotive) on XXX where they informed me of the 2015 recall on the steering. Recall number 15S18 and program 15N01 When I spoke with [XXX] Ford in [XXX], they said they replaced the electrical piece of the recall on December 7th 2015, but not the steering shaft. [XXX] (the westlie ford employee) said because the electrical was completed, the recall procedure was marked as completed, even though [XXX] said that this is very much tied to the original recall. I asked him to submit a Special Service Support Center request to get this fixed and he did submit that on XXX. On XXX it was denied. On XXX I also requested to speak to [XXX] supervisor and was connected to [XXX] (id # XXX) who also said there was nothing she could do because this was already "solved" in 2015. This is not a new or unrelated repair request, it is the unresolved second half of a federally mandated safety recall. Ford's own dealership confirmed that my steering gear failure is directly connected to the original defect covered under Recall 15S18, and Ford's own extended coverage program, 15N01, exists specifically to remedy this exact scenario. Despite this documented connection, Ford has now denied a remedy twice, once through the dealer's SSSC request, and once directly through Ford Customer Service, without providing any technical explanation fo

Vehicle experienced loss of power steering so it was hard to steer.When I called a ford dealership I was told my vehicle didn’t qualify for any power steering recalls so I would have to pay full price which is unaffordable

The contact owns a 2012 Ford Fusion. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop as intended. The contact stated that the brake pedal was soft and spongy. The brake pedal was depressed to the floorboard before the vehicle stopped. No warning lights were illuminated. The vehicle was taken to an independent mechanic, and the contact was informed that the failure was not duplicated. The contact was informed that an inspection was completed, and the brake pads and rotors were in good working order. The contact stated that the failure had occurred two months after the brake pads and rotors were replaced by an independent mechanic. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 149,000.

I am submitting this formal complaint against Ford Motor Company and its authorized dealership network for falsely reporting a safety recall repair as "resolved" while applying an unauthorized, temporary workaround that left the primary safety defect active. In 2023, I brought my vehicle to an authorized Ford dealership to perform mandatory safety recall service regarding the Electric Power Assist Steering (EPAS) failure. The dealership subsequently updated Ford’s central database (OASIS) to show that the safety recall was fully resolved and completed for my VIN. However, the official Repair Order / Invoice provided to me by the technician explicitly documents that a permanent remedy was not performed due to a lack of replacement parts. The technician’s exact written notes state: "Customer states power steering is not working. Tech and advised verified concern finding that the ground wire pin on the high current wiring harness to PSCM had backed out of the connector. Reconnected pin and cleared codes finding issue resolved. Issue will continue to happen until the harness is replaced. Harness is unavailable at this time. Glued pin into connectors."Because the dealership glued the loose pin rather than replacing the backordered wiring harness, the temporary repair failed shortly thereafter, resulting in a total loss of power steering assist. For the past three years (approximately 47,698 miles driven), I have been forced to operate this vehicle without functional power steering

I had purchased these tires P225/50R17 for my son‘s car in 2022. They have an 85,000 mile tread life warranty in April of this year. He had a blowout on the left rear tire where the tread separated from the tire and in late July this year is preparing for a 3500 mile trip as I was inspecting his car before his trip. I noticed the tire on the right rear looked to be defective. It looks like the tread where it meet the sidewall is separating from the tire on the inside with a tear about 8” long where the metal is showing. Two tires out of 4 losing their tread is disturbing and a concerning safety issue with these tires, see the Photos I have supplied.

The contact owns a 2012 Ford Fusion. The contact stated that while driving at an undisclosed speed, the steering wheel became difficult to turn. The message "Power Steering Assist Fault" was displayed. The failure was a recurring failure. The first failure was serviced by the dealer under NHTSA Campaign Number: 15V340000 (Steering); however, a year later, the failure reoccurred. The vehicle was then taken to an independent mechanic where the rack and pinion was replaced but the failure persisted. The manufacturer was made aware of the failure. The failure mileage was approximately 138,000.

No check engine, light or anything lost my electronic steering capabilities I’m going down the road

The power steering system, failure. completely without warning I see recalls on this model. But do not see it on the website. Nor will ford repair it

My car does not always respond when the brakes are tapped. They are soft/squishy at times and I have to push the pedal all the way to the floor for the car to stop. This issue has been occuring off & on for approximately 3 years though it's been more frequent since June of 2026. I have never seen any warning or failure light/notification any of the times this has happened. The issue was determined to be a faulty master cylinder by the service department at Colley Ford in Glendora, CA.

The contact owns a 2012 Ford Fusion. The contact stated that while driving 50 MPH, the vehicle lost power steering functionality and almost caused a crash. The message "Service Power Steering Now" was displayed. The contact was able to drive to the destination. The contact stated that the vehicle had become undrivable due to the failure. The contact related the failure to NHTSA Campaign Number: 15V340000 (STEERING); however, the VIN was not included. The dealer and the manufacturer were not contacted. The vehicle was not diagnosed or repaired. The failure mileage was approximately 130,000.

Unknown. just bought this car

Brake system. Pedal is soft and braking force to stop is reduced. Yes, at first they thought it was the brake booster, and know thinking it is the master cylinder, now they aren't even sure what it might be. Ford dealership techs. No, pedal was "squishy" when braking

I was just driving and I lost power steering, it was incredibly difficult to steer and it was Heavy Steering, and warnings appeared on the dash.

Se traba y se pone duro el "gobierno" junto con la cremallera electroasistida el volante no gira ni con el carro prendido, no eh echo uso de la campaña 15S18, nunca ah Sido asistido por el fabricante Ford, ni mucho menos lo eh metido a un taller de servicio independiente ni con aseguradoras y no me marco algún sensor del tablero antes de que me sucediera este problema con la "dirección asistida averiada"

The contact owns a 2012 Ford Fusion. The contact stated that while driving at 40 mph, the steering wheel was hard to turn. The low tire pressure message was displayed. There was another unknown system message being displayed. The contact indicated the failure was related to NHTSA Campaign Number: 15V340000 (Steering). The vehicle was taken to the local dealer, where it was diagnosed and determined that the power steering pump was the cause of the failure. The vehicle was not repaired. The manufacturer was not notified. The failure mileage was unknown.

Our 2012 Ford Fusion had a sudden and complete loss of power steering & “Power Steering Assist Fault’ flashed on dash. The steering immediately became extremely difficult to operate, requiring both hands and excessive physical force just to turn the wheel. It felt less like driving a passenger car and more like wrestling a fully loaded dump truck with flat tires. This created a serious safety concern because the failure occurred without warning and fundamentally affected our ability to steer the vehicle safely. Fortunately, my wife was not driving at the time. The amount of force suddenly required to turn the wheel could easily be overwhelming, particularly during an emergency maneuver, in traffic, or while entering an intersection. After the failure occurred, we discovered vehicle had previously been subject to recall 15V340000 and Ford Safety Recall 15S18, both involving the exact electric Power Steering Control Module (“PSCM”) that has now failed. Under that recall, a Ford dealer performed only a software update on 10/17/2016. We opened a case with Ford, brought the vehicle to a local dealer & paid for a diagnostic inspection. Using Ford IDS equipment, dealer confirmed the condition and documented ‘NO COMMUNICATION WITH PSCM’. The dealer report quoted “Steering Gear Assembly - Rack & Pinion Assembly Replace: $3,215.81.” The diagnosis was reported directly to Ford under the active case number. Despite the recall history and confirmed failure of the same steering system cove

The contact owns a 2012 Ford Fusion. The contact stated that while driving at an undisclosed speed, the power steering became inoperable with the electronic power steering warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the rack and pinion had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 176,020.

The contact owns a 2012 Ford Fusion. The contact stated that while driving at 20 MPH, the vehicle lost power steering functionality. There was no warning light illuminated. The contact was able to continue driving, but the steering wheel was difficult to turn. The vehicle was driven to an independent mechanic, where it was diagnosed, and determined that the steering gear had failed and needed to be replaced. The vehicle was not repaired due to the cost. The contact related the failure to NHTSA Campaign Number: 15V340000 (Steering); however, the VIN was not included in the recall. The manufacturer was notified of the failure but denied assistance due the manufacturing date of the vehicle. The failure mileage was approximately 56,000.

The contact owns a 2012 Ford Fusion. The contact stated that while driving at various speeds and making a left turn, the driver's side door unexpectedly opened. The contact stated that the door ajar warning light was illuminated. The failure became a recurring failure. The contact had taken the vehicle to a local dealer where it was diagnosed, and determined that the door latch needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to NHTSA Campaign Number: 20V177000 (Latches/Locks/Linkages). The contact informed the dealer of the recall and was informed that the VIN was not included in the recall. The manufacturer was informed of the failure. The failure mileage was approximately 124,000.

The contact owns a 2012 Ford Fusion. The contact stated that while operating the vehicle, the power steering malfunctioned, and the steering wheel was extremely difficult to turn in either direction. The vehicle was driven to the local dealer, and the power steering control module was updated under NHTSA Campaign Number: 15V340000 (STEERING); but the failure was not corrected. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was approximately 190,000.

The contact owns a 2012 Ford Fusion. While the contact’s girlfriend was driving at an undisclosed speed, the steering wheel jerked and pulled to the right. Due to the failure, the steering wheel seized, and excessive force was needed to turn the steering wheel. The driver was able to avoid striking the curve. An unknown code was displayed. The contact was called and went to the scene of the failure. The vehicle was driven back to the residence nearby. The contact stated that the steering wheel was difficult to turn. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. While researching, the contact became aware of NHTSA Campaign Number: 15V340000 (STEERING) and associated the failure with the recall; however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 160,000.

The steering locked up and was completely unable to turn the wheel. This resulted in an accident that sent the car into a ditch. The safety recall for the steering was fixed and it failed again, in which it cost me 1700 to replace the same part again. It has AGAIN failed!!! This is extremely unsafe and should not fail on multiple occasions. This problem needs to be resolved!!!!

Good evening, I’m emailing to you regarding my ford fusion q20212. My steering has went out non drivable. I did see where that year had a lot of power steering issues.. could you help me out on the power steering recall and the power train.. also need to get airbag completed. Text me a Time to meet I can’t drive it ar all will need towed. Thank you for print ur time… I really need to get fix so I have ride to work… [XXX] ’s [XXX] text me . Vin number is [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The Power Steering Assist Fault notice keeps popping up on the dashboard screen. When this happens, the power steering is inoperable leaving me stranded. I've had my mechanic fix it several times (after the Ford Recall on steering didn't properly repair the issue) costing an insane price. It's very unsafe to be on the road & have the power steering go out. It is unsafe not only for me & my family but also for the vehicles traveling around my vehicle. It causes mental distress & anxiety as I never know when I'm going to be left stranded. This time, I'm stranded at the laundromat, on a Sunday. Not knowing how I'm going to get home or to work tomorrow. My receipts for repairs are at home. Until Ford makes this right, I'll never see the Ford brand as a reliable manufacturer nor will I ever purchase or recommend the Ford brand.

I have a recall, I need to know where I have to fix that

I am writing to formally report that the safety recall repair on my 2012 Ford Fusion has failed to resolve the dangerous loss of power steering. My vehicle underwent the 15S18 recall update only at Tom's Ford back in 2015. On January 20 2026, the steering failed again while driving, creating an immediate safety risk. The dealer has failed to provide a permanent remedy at Jim Hudson Ford in Lexington SC. As safety recalls do not expire, I request a permanent fix of the steering gear replacement within 14 days of this letter, per NHTSA guidelines. If this is not resolved, I will pursue further legal action.

I am writing to formally file a complaint and request resolution regarding a serious safety issue involving my 2012 Ford Fusion SEL (VIN: [XXX] ). I have been a loyal Ford customer for over 20 years and have owned only Ford vehicles. Unfortunately, my recent experience with Ford Customer Care and my local dealership has been extremely disappointing and concerning. A few weeks ago, my 2012 Ford Fusion suddenly lost power steering while my young son was driving home from school. This created a terrifying and dangerous situation that could have resulted in a serious accident or injury. Thankfully, he was able to safely pull over, and no one was hurt. However, this was clearly a major safety failure. After this incident, I contacted Ford Customer Care and my local Ford dealership to seek assistance. I was informed that the Customer Satisfaction Program related to the EPAS steering system had expired for my vehicle and that Ford would not provide further support. However, this directly contradicts the information shown in my Ford app. The Ford app clearly lists Customer Satisfaction Program Campaign 15N01 – “EPAS Steering Effort” and instructs me to schedule a free service with a dealer. I later learned that an update was performed in 2015, but the EPAS steering system itself was never replaced—only updated—and that the program was considered a one-time offer. It is extremely upsetting to now face costly repairs for a known safety-related issue that was clearly not resolved correc

My vehicle all of a sudden showed a "power steering assist fault," luckily it was parked. This is a problem with the 2012 Ford Fusion and I called Koon's Ford in Baltimore to see if this would be covered since my vehicle has never had steering issues before. They said yes, but after a couple days they called to tell me that Ford denied the claim since it is outside of the ten year warranty window. My car does not have a lot of miles for being over ten years old. I understand the warranty is in place for a reason but this is a dangerous manufacturer issue. I could have gotten seriously hurt if it happened on the road so it is upsetting to hear that Ford refuses to cover it. I will try to call customer relations to see if there could be another verdict. It is concerning that the manufacturer does not have an extended warranty for such a dangerous issue and I would like to make it known.

The contact owns a 2012 Ford Fusion. The contact stated that after starting the vehicle, the message "Electric Steering Fault" was displayed. While driving out of the driveway, the steering wheel became extremely difficult to turn, causing the vehicle to drive across two lanes of traffic. The vehicle was driven to the local deale,r who diagnosed that the steering gear was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 15V340000 (STEERING); and was no longer eligible for a related Customer Satisfaction Program to address the steering failure. The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 170,000.

What component or system failed or malfunctioned, and is it available for inspection upon request? Power Steering How was your safety or the safety of others put at risk? The likelihood of accidents when traveling at lower speeds is increased. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the Ford dealership reproduced the issue. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? UNKNOWN Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, the message appeared only when the power steering stopped functioning.

I recently started to experience hard steering while in transit the power assist light came on and so does the advanced track warning light. I discovered there was a recall so I took it in to the Ford dealership, which was JC Lewis Ford in Savannah, Georgia, but the technician told me that there were too many miles and after 150,000 miles, the recall was null and void

UNKNOWN. I have no power steering. I have contacted Ford and they were supposed to fix my car for free which they did not because it was up for recall.

My car lost my electric power steering on November 15, 2025. Ford has a Safety Satisfaction Program15V340000 for this vehicle. The Dealership refuses to honor the program since it has over 150,000 miles on it. Reading through the paper work for the program 15v340000 I never noticed a mileage exclusion. Any help on this issue would greatly be appreciated.

The contact owns a 2012 Ford Fusion. The contact stated while driving approximately 55 MPH, the messages "Service Power Steering Assist Fault" and "Advancetrac" were displayed, and the steering wheel suddenly became very difficult to turn in either direction. The vehicle was taken to the local mechanic who diagnosed that the steering rack had failed and needed to be replaced. The vehicle was not repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 15V340000 (Steering); however, the contact related the failure to the recall. The failure mileage was 150,000.

The contact owns a 2012 Ford Fusion. The contact stated that while driving approximately 40 MPH, the “Service Advancetrac” and “Service Power Steering Now" messages were displayed. The contact stated that the traction control warning light was illuminated. The contact stated that the vehicle was taken to the residence, and the vehicle was shifted into reverse(R), and the steering wheel became firm. The contact stated that when the vehicle was shifted into drive(D), the steering wheel remained firm. The vehicle was towed to a dealer, where it was diagnosed, and determined that the power steering control module needed to be replaced. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 111,000.

The contact owns a 2012 Ford Fusion. The contact stated that upon starting the vehicle on two occasions, the "Power Steering Assist Fault" message was displayed on the instrument panel, and excessive force was required to steer the vehicle. The vehicle was taken to the dealer, where it was diagnosed with a defective electric rack and pinion. The vehicle was not repaired. Upon investigation, the contact related the failure to NHTSA Campaign Number: 15V340000 (Steering); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was approximately 71,000.

The contact owns a 2012 Ford Fusion. The contact stated while driving 20 MPH in the snow, the message "Service Power Steering" was displayed, and the steering wheel seized. The vehicle became difficult to maneuver, and the contact had to use force to maneuver the vehicle. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact's stepfather used a handheld scanner to diagnose the vehicle and retrieved DTC: C1963-20 and C1511. The vehicle remained at the residence. The contact related the failure to NHTSA Campaign Number: 15V340000 (Steering). The manufacturer was notified of the failure. The failure mileage was approximately 200,000.

The power steering of the vehicle was lost along with illumination of “power steering sensor assist fault” and “service advance trac.” The difficulty of steering made it very dangerous on the road. The problem has been diagnosed and confirmed as code 15N01 (formerly safety recall 15S18). The 15N01 is an extended program under safety recall 15N01. I am issuing this complaint as the 15N01 program has an expiration of 150,000 miles and/or date of 10 years since purchase. My car had the original safety recall 15S18 done in 2015 but now is not qualified for the steering gear (15N01). This shows that this program shouldn’t have any limits as these steering gears were shown defective from the factory. Safety recalls never die and what they did as a quick fix for those cars in 2015 that were not showing those DTC’s was not an adequate repair . They should have addressed the steering gear issue instead of just the reprogramming of the PSCM.

Warning light on dash indicating "Service Power Steering Now" suddenly while driving car. Nearly complete loss of steering.

Power steering has recently failed. Vehicle unsafe to drive (had to cancel recall appointment to replace air bags). Found an old Ford Steering Technical Bulletin 15S18-S3 for this issue. Never received a recall notice & would never have known of the recall until the issue affected me. This seems to be a safety bulletin. Am I able to get this repaired by Ford on their dime? They are telling me no.

Purchased in October of 2024,12 Ford Fusion steering failure. Vehicle suddenly became difficult to steer. Issues match 15N01 recall by Ford. Car has under 60,000 miles and Ford refuses to repair. After stating that it should be covered under the recall. Definitely a safety concern. Now stating it was not an actual "recall" now listed as a customer satisfaction program instead of a recall.

The contact owns a 2012 Ford Fusion. The contact stated that while her daughter was driving approximately 50 MPH, the steering wheel locked up. The vehicle was pulled over to the side of the road and restarted; however, the failure reoccurred. The vehicle was towed to a dealer, where it was diagnosed, and determined that the steering gear and power steering control module needed to be reprogrammed or replaced. The vehicle was not repaired. The contact stated that on the inspection notice, she observed NHTSA Campaign Number: 15V340000 (Steering). The manufacturer was not notified of the failure. The failure mileage was 197,150.

On [XXX] ,I was driving in my car heading home with my [XXX] son in the backseat when my steering wheel just locked up on me and didn't want to turn and it was just stiff. I turn off my car immediately and waited about ten minutes to turn on. The car started up and the steering wheel became un loosen but this situation is off and on and it's scary . It's the third time now it happened. Next im experience a airbag warning symbol on my dashboard today [XXX] and that's even scarier driving in the car with a toddler because it's not safety. I don't know how to remove it off my dashboard and don't know how to fix the problem either. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2012 Ford Fusion. The contact stated that while driving at various speeds, the vehicle lost power steering functionality, and the contact had to drive the vehicle in manual steering mode. The failure had occurred three times. The contact became aware that the vehicle was previously included in NHTSA Campaign Number: 15V340000 (Steering), and the previous owner had taken the vehicle to be repaired under the recall. The vehicle was taken to an independent mechanic and was diagnosed with Advancetrac failure, causing the steering wheel angle sensor to fail. The steering wheel angle sensor was repaired; however, the failure persisted. The mechanic reset the power steering function after each failure. The dealer was contacted and confirmed that there was no recall associated with the VIN. The manufacturer was informed of the failure. The failure mileage was approximately 118,000.

The contact owns a 2012 Ford Fusion. The contact stated that while starting the vehicle, the power steering assist fault message was displayed. The power steering function was inoperable. The check engine warning light was illuminated due to a possible canister purge valve failure. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 15V340000 (Steering). The local dealer was not contacted, and the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 165,461.

The contact owns a 2012 Ford Fusion. The contact stated that while driving at an undisclosed speed, the electronic power steering was not functioning properly, requiring an increased effort to maneuver the vehicle. The message "Power Steering Assist Fault" was displayed. There was no warning light illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the rack and pinion. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 15V340000 (Steering); however, the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 126,000.