2008 Ford E-150

Defect. MobilityWorks (WMK Inc.) is recalling certain model year 2006-2014 Ford E-150, E-250, and E-350 vans modified by MobilityWorks to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Risk. If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Remedy. MobilityWorks will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on December 15, 2015. Owners may contact MobilityWorks customer service at 1-800-769-8267, or Ricon Customer Service at 1-800-322-2884. Note: These vehicles and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.

Defect. Cummings Mobility Conversion & Supply (Cummings) is recalling certain model year 2006-2014 Ford E-150, E-250, E-350, Chevrolet Express, 2006-2008 Dodge Sprinter, and 2009-2014 Mercedes-Benz Sprinter, and 2013 Ford Transit Connect vehicles manufactured January 1, 2006, to October 8, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.

Risk. If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Remedy. Cummings will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began January 13, 2015. Owners may contact Cumming's customer service at 1-800-639-5438 or Ricon customer service at 1-800-322-2884. Cumming's number for this recall is 14E-041.

Defect. Mobility Works (WMK Inc.) is recalling certain model year 2006-2014 Ford E150, E250, and E350 vans modified by Mobility Works to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

Risk. If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Remedy. Mobility Works will notify owners, and Ricon will supply supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on November 10, 2014. Owners may contact Mobility Works customer service at 1-800-769-8267 or Ricon customer service at 1-800-322-2884.

Defect. National Van Builders, Inc. (National Van) is recalling certain 2007-2014 Ford E-150 and E-250 vehicles manufactured February 26, 2007, to August 19, 2014, and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

Risk. If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Remedy. National Van will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on October 3, 2014. Owners may contact National Van customer service at 1-800-527-7477. National Van's number for this recall is Ricon2014.

Defect. Mobility Specialists, Inc. (Mobility Specialists) is recalling certain model year 2007-2008 Ford E-150 vans modified by Mobility Specialists and equipped with Braun NCL-2, and NVL-2 wheel chair lifts. Over time, and with frequent use, the roll stop latches on the outer barrier of the lifts in these vans may become bent or misaligned.

Risk. A wheelchair occupant may defeat or ride over the insufficiently latched roll stop. If this occurs when the lift platform is in an elevated position, the wheelchair's occupant could fall and sustain injury.

Remedy. Mobility Specialists will notify owners and will replace the affected parts, free of charge. The recall began in July 2014. Owners may contact Mobility Specialists customer service at 1-877-777-5438.

Defect. Mobility Works is recalling certain model year 2006-2012 Ford E-150, E-250 and E-350 vehicles manufactured August 2006 through August 2012. The vehicles are equipped with certain Ricon S series and K Series wheelchair lifts with an optional armored pendant cable. The armored cable may be positioned such that it does not clear the wheelchair lift.

Risk. If the cable does not clear the wheel chair lift it may contact the power lug and, if it does not have a nonconductive cover, or it has an improperly installed non-conductive cover, a short circuit may occur that could result in a fire.

Remedy. Mobility Works will notify owners and Ricon will provide a supplemental cover kit and instructions, free of charge. This recall campaign is expected to begin July 15, 2013. Owners may contact Mobility Works at 1-877-275-4912 and Ricon at 1-818-267-3000.

Defect. FORD IS RECALLING CERTAIN REPLACEMENT FUEL TANKS THAT COULD BE INSTALLED INTO MODEL YEAR 2004 THROUGH 2008 E-150, E-250, AND E-350 VANS AND WAGONS. THE AFFECTED FUEL TANKS HAVE AN EXTRA OBDII SENSOR HOLE ON THE TOP OF THE TANK THAT MAY NOT BE PROPERLY SEALED AND MAY LEAK FUEL.

Risk. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.

Remedy. FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE FUEL TANKS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 28, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-800-232-5952.

Defect. MOBILITY TRANSPORTATION (MTS) IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 CONVERSION VANS BUILT ON FORD E150, E250, AND E350 CHASSIS FROM SEPTEMBER 16, 2008 THROUGH APRIL 15, 2009 AND FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

Risk. THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE WITHOUT THE RESTRAINT BELT PROPERLY BUCKLED.

Remedy. MTS IS WORKING WITH RICON AND RICON WILL BE PERFORMING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE RICON'S DEFECT REPORT 09E-060. RICON WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE SAFETY RECALL BEGAN ON OCTOBER 18, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MTS AT 1-734-453-6452.

Defect. MOBILITY TRANSPORTATION (MTS) IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 CONVERSION VANS BUILT ON FORD E150, E250, AND E350 CHASSIS FROM SEPTEMBER 16, 2008 THROUGH APRIL 15, 2009 AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION, SHOULD THE "UP" BUTTON BE RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL AND MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.

Risk. WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.

Remedy. MTS WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED RICON DEALERS FREE OF CHARGE. A SOFTWARE SOLUTION FOR THIS SAFETY DEFECT IS UNDER INVESTIGATION. UNTIL THE SOFTWARE SOLUTION IS AVAILABLE, RICON WILL PROVIDE OWNERS WITH A BULLETIN OUTLINING PROPER WHEELCHAIR LIFT OPERATION AND WILL SHIP OWNERS A DVD-BASED TRAINING AID TO PROMOTE PROPER LIFT OPERATION AT NO COST. THE SAFETY RECALL BEGAN ON OCTOBER 18, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MTS AT 1-734-453-6452.

Defect. MOBILITY WORKS IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 CONVERSION VANS BUILT ON FORD E150, E250, AND E350 CHASSIS AFTER NOVEMBER 2007 AND FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

Risk. THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE WITHOUT THE RESTRAINT BELT PROPERLY BUCKLED.

Remedy. MOBILITY WORKS IS WORKING WITH RICON AND RICON WILL BE PERFORMING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE RICON'S DEFECT REPORT 09E-060. RICON WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE SAFETY RECALL BEGAN ON AUGUST 20, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITY WORKS AT 1-800-769-8267.

AIR BAG CODE 33 FLASHING ON DASH . FORD STATES DRIVER SIDE SEAT BELT BUCKLE TO BE REPLACED AT $ 527.00 . IS THIS NOT A SAFETY ISSUE BY THAT FORD SHOULD ADDRESS AT NO COST TO THE CONSUMER ? PLEASE HELP .

TL* THE CONTACT OWNS A 2008 FORD E-150. THE CONTACT STATED THAT THE VEHICLE RODE ROUGHLY AS IF IT WERE BEING DRIVEN OVER ROCKY TERRAIN. IN ADDITION, THE AIR PRESSURE INDICATOR WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT IT COULD NOT BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000. THE VIN WAS INVALID.

TL* THE CONTACT OWNS A 2008 FORD E-150 EQUIPPED WITH MICHELIN LTX M/S TIRES, SIZE: LT225/75R16. WHILE DRIVING APPROXIMATELY 70 MPH, THE FRONT DRIVER SIDE TIRE EXPLODED. THE CONTACT COASTED TO THE SIDE OF THE ROAD AND NOTICED BUBBLES ON THE SIDEWALLS AND TREAD SEPARATION ON THE FRONT DRIVER SIDE TIRES. THE VEHICLE WAS TAKEN TO THE DEALER AND ALL FOUR TIRES WERE REPLACED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13T012000 (TIRES). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 50,000. THE TIRE FAILURE MILEAGE WAS 20,000.

BURNT CAM FROM LACK OF OILING. DEALER UNABLE TO REPAIR, SAID NEW ENGINE ONLY OPTION. FORD WOULD NOT PAY FOR NEW ENGINE. WARRANTY STATED DRIVETRAIN WARRANTY GOOD FOR 60,000 MILES OR FIVE YEARS.

WHILE APPLYING THE BRAKES TO PARK THE CAR THE WAS A LOUD RIFLE SHOT SOUND, FLASH AND VEHICLE JOLT FROM UNDER THE HOOD. AND THE BREAK WARNING LIGHT CAME ON. DURING REPAIR THE MECHANIC FOUND THAT THE PROBLEM WAS THE WITH THE MASTER CYLINDER CRUSE CONTROL CANCELLING SWITCH. THE SWITCH BLEW APART AND IGNITED THE ATOMIZED BREAK FLUID THAT WAS EXPELLED FROM THE MASTER CYLINDER. FORTUNATELY THE EXPLODING BREAK FLUID SELF EXTINGUISHED AVOIDING AN ENGINE COMPARTMENT FIRE. SINCE THE TRIGGERING OF THIS EVENT WAS THE ACT OF APPLYING THE BRAKES IT WAS ONLY BY CHANCE THAT IT DIDN'T HAPPEN AT HIGHWAY SPEEDS. THE EVENT TOTALLY DISABLED THE FRONT BRAKES AND AT HIGHWAY SPEEDS THE BRAKE FLUID MIST WOULD HAVE LIKELY IGNITED FURTHER BACK IN THE ENGINE COMPARTMENT OR UNDER THE CHASSIS. THERE HAVE BEEN NUMEROUS RECALLS OF FORD PRODUCTS OVER A 20+ YEAR PERIOD FOR THIS SWITCH COMPONENT CAUSING BOTH FIRES AND DEATHS BUT THIS VEHICLE'S S/N WAS NOT ON THE LIST FOR GETTING NOTIFIED. LOOKS LIKE SOMEONE DIDN'T DO THEIR "HOMEWORK" ON THIS ONE, I AM NOT SURE THIS VEHICLE IS SAFE TO DRIVE. I HAVE THE REPAIR BILL FOR THE REPLACEMENT WORK AND THE GENTLEMAN SHOWED ME THE BLOWN OUT SHELL OF THE SWITCH. I PICKED UP ONE OF THE PARTS FROM OUR PARKING SLAB. I HAVE NOTIFIED FORD BY EMAIL.

TL* THE CONTACT OWNS A 2008 FORD E-150. THE CONTACT STATED THAT THE VEHICLE FAILED TO SHIFT FROM REVERSE INTO DRIVE. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 53,000.

TL* THE CONTACT OWNS A 2008 FORD E-150. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, A RATTLING NOISE EMITTED FROM THE UNDER CARRIAGE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO FOUND THAT THE CATALYTIC CONVERTER WELDING HAD FAILED AND CAUSED THE PIPES TO FRACTURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 89,000 AND THE CURRENT MILEAGE WAS 93,000.

TL* THE CONTACT OWNS A 2008 FORD ECONOLINE VAN E150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT TRIED TO RESTART THE VEHICLE. THE CHECK ENGINE AND ELECTRONIC THROTTLE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS ABLE TO BE RESTARTED BUT WHEN THE FAILURE WOULD RECUR WHEN THE ENGINE RPMS INCREASED OVER 2,000. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 66,325.

I HAD TO REPLACE ALL 5 TIRES WITHIN 2 YEARS OF MY VEHICLE PURCHASE. THE NEW TIRES ARE NOW JUST OVER 2 1/2 YEARS OLD. ONE BLEW OUT ON A RESIDENTIAL STREET WHILE GOING 35 MILES/HOUR. THE 2ND TIRE REPLACED WAS ALSO SEPARATING AND CAUSING THE VAN TO VIBRATE JUST AS THE FIRST ONE SO I TOOK IT IN 6 WEEKS AFTER THE FIRST BLOWOUT. LEAVING THE TIRE STORE MY VAN IS STILL VIBRATING AND NOW I NOTICE THE 3RD TIRE IS BUCKLING ON THE OUTSIDE WALL. THE 4TH TIRE DOES NOT APPEAR TO HAVE ANY MAJOR ISSUE YET. THE 5TH IS MY SPARE-NEVER USED. DISCOUNT SAID THEY WOULDN'T REPLACE THE 2 FRONT TIRES UNTIL THEY HAD THE SAME ISSUE AS THE REAR TIRES, WITHOUT COST TO ME. THESE TIRES ARE FROM THE SAME LOT #S. THEY SHOULD ALL BE REPLACED BEFORE ACCIDENTS, OR WORSE, OCCURS. ALL TIRES WERE MICHELIN LTX M/S LT225/75 R16. *TR

TL* THE CONTACT OWNS A 2008 FORD E-150 VAN. THE CONTACT WAS DRIVING 45 MPH WHEN THE ELECTRONIC THROTTLE CONTROL WARNING LIGHT ILLUMINATED AND THE VEHICLE PROCEEDED TO STALL. THE VEHICLE WAS TAKEN TO THE DEALER SIX TIMES REGARDING THE FAILURE. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 98,452 AND THE CURRENT MILEAGE 101,600. UPDATED 04/25/12 *BF UPDATED 06/07/12 *JS

MY AGENCY OPERATES 7D VEHICLES THAT TRANSPORT YOUNG CHILDREN. THE SEATS IN WHICH WE MUST PLACE REAR-FACING INFANT CAR SEATS DO NOT ALLOW US TO PROPERLY SECURE THE CAR SEAT. THERE IS ONE TETHER INSTALLED ON THE BACK OF THE SEAT AND 2 INSTALLED WHERE THE CUSHIONS MEET. THE STRAP THAT IS SUPPOSED TO CLIP TO THE TETHER ON THE BACK OF THE SEAT IS TOO SHORT FOR REAR FACING CAR SEATS. THE CAR SEAT CAN BE SECURED USING THE SIDE TETHERS, BUT THE INABILITY TO SECURE TO THE REAR TETHER RESULTS IN THE CAR SEAT MOVING FORWARD & BACKWARD. IF THERE WERE A FRONT-ON COLLISION, THE INFANT'S HEAD WOULD THRUST FORWARD. I AM NOT SURE IF THIS IS A PROBLEM WITH THE VEHICLE DESIGN OR THE CAR SEAT. (RELATED VEHICLE INFORMATION: MODEL YEAR=2008, MAKE=FORD, MODEL=ECONOVAN E150). *TR