2003 Ford E-150

Defect. FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Risk. A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Remedy. FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Defect. FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Risk. AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Remedy. DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Defect. ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Risk. THIS COULD RESULT IN AN UNDERHOOD FIRE.

Remedy. DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Defect. CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.

Risk. FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Remedy. UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.

Defect. ON CERTAIN VANS, A DIODE IN THE ANTI-LOCK BRAKING SYSTEM (ABS) MODULE MAY EXPERIENCE AN ELECTRICAL SHORT.

Risk. THE ELECTRICAL SHORT MAY CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, OR THE MODULE MAY OVERHEAT RESULTING IN A BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS BEING DRIVEN OR UNATTENDED.

Remedy. DEALERS WILL INSTALL A NEW FUSE IN THE ABS CIRCUIT AND INSTALL A HEAT SHIELD OVER THE ABS MODULE. THE RECALL BEGAN ON OCTOBER 15, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. ALSO FORD IS EXTENDING THE LIMITED WARRANTY (FOR A ONE TIME REPLACEMENT) OF THE ABS MODULE FOR A TOTAL OF 10 YEARS OR 150,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF YOUR VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL SEPTEMBER 30, 2005.

Defect. ON CERTAIN VANS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES.

Risk. THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.

Remedy. DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. THE RECALL BEGAN SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. ALSO FORD IS EXTENDING THE LIMITED WARRANTY (FOR A ONE TIME REPLACEMENT) OF THE ABS MODULE FOR A TOTAL OF 10 YEARS OR 150,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF YOUR VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL SEPTEMBER 30, 2005.

SPARK PLUG BLOW OUT X3 IT HAS BEGAIN TO GET VERY ANOING.

TL* THE CONTACT OWNS A 2003 FORD E-150. THE CONTACT STATED THAT THE CRUISE CONTROL AND HORN FAILED TO WORK AND THE AIR BAG LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 125,000.

TL- THE CONTACT OWNS A 2003 FORD F1-50. THE CONTACT EXPERIENCED THE FAILURE APRIL 26, 2014. THE VEHICLE AIR BAGS DEPLOYED WHILE SITTING IN TRAFFIC. THE CONTACT CURRENT MILLAGE OVER 240,00. THE CONTACT WAS DRIVING 5 MPH IN TRAFFICE . THE CONTACT HIT THE VEHICLE IN FRONT OF HIM. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT TAKEN IN FOR REPAIRS. THE CONTACT DID NOT NOTIFY THE MANUFICATURE. LG

I WAS SITTING AT A STOP SIGN. WHEN I ACCELERATED TO MOVE, I HEARD A LOUD BANG NOISE AND THEN I HEARD A FLAPPING NOISE. I TURNED THE ENGINE OFF AND CALLED A TOW TRUCK. AFTER TOWING MY HANDICAPPED VAN TO THE FORD DEALER, I WAS TOLD THAT THE ENGINE HAD A SPARK PLUG BLOW OUT. I WAS ALSO INFORMED THAT THE VEHICLE MIGHT HAVE CAUGHT ON FIRE IF I HAD TRIED DRIVING MUCH FURTHER. THIS IS VERY SCARY FOR PEOPLE LIKE ME THAT EQUIP THESE VANS FOR SPECIAL USE. THE MILEAGE IS 99% CITY DRIVING. THERE SHOULD BE A RECALL ON THIS ENGINE.

WHILE TRAVELING ON THE HIGHWAY, MY 2003 E150 FORD VAN BLEW THE #2 SPARK PLUG OUT. THERE WAS A POPPING SOUND AND THEN THE ENGINE SOUNDED AS IF IT BLEW A ROD. AFTER CHECKING IT OUT, IT WAS DISCOVERED THAT IT WAS THE SPARK PLUG. A FEW DAYS PRIOR TO HIS EVENT, I COULD HEAR A SLIGHT TAPPING SOUND COMING FROM THE ENGINE. I HAD THE OIL CHANGED JUST TO BE SURE. THE SPARK PLUG HAS BEEN REPLACED, WITH A HELICOIL INSERTED, BUT THE WALL OF THE HEAD WAS EVEN DAMAGED. MY MECHANIC DID AN AWESOME JOB REPAIRING IT BUT EVEN SAID HE COULDN'T GUARANTEE IT WOULD LAST A 100 MILES OR 100,000 DUE TO THE HEAD DAMAGE. HE EVEN RECOMMENDED I TRADE IT IN. WITH ONLY 138,000 MILES ON IT I'M NOT READY TO LET IT GO. HOPEFULLY THE NEW PLUG WILL HOLD AND I WON'T HAVE TO TRADE IN MY VAN. *TR

PROBLEM: SEVERE SHIMMY IN STEERING WHEEL, POSSIBLY LEADING TO LOSS OF CONTROL. CONDITIONS: OCCURS WHENEVER BRAKES ARE HOT AND VEHICLE SPEED IS ABOVE 45 MPH. PROBLEM OCCURS WHEN DESCENDING LONG & STEEP INCLINES. PROBLEM DOES NOT OCCUR WHEN BRAKES ARE NOT HOT FROM HEAVY USE. TEMPORARY ABATEMENT: DRIVE AT SPEEDS OF 45 MPH OR LESS DOWN INCLINES. *TR

2003 FOCUS- MY IGNITION KEPT LOCKING ON ME. ANYWHERE I TURNED OFF THE CAR, I HAD TO SPEND A GOOD 15MIN TURNING AND TURNING THE KEY TO GET IT STARTED. MY CAR HAS ONLY 32,000.00 MILES AND IT STARTED AT 18,000.00 MILES. TODAY I HAD TO GET A LOCKSMITH TO COME IN AND FIX IT. *TR

2003 FORD E150 VAN WITH TRITON 5.4 ENGINE SPARK PLUG BLOW OUT ON (2) SEPARATE OCCASIONS. SPARK PLUG BLOWS WITHOUT ANY WARNING. THE LAST BLOW OUT HAPPENED ON JAN 8TH 2009 WHILE TRAVELING ON THE NY STATE THRUWAY DURING SEVERE WINTER WEATHER. THE INCIDENT CAUSED IMMEDIATE LOSS OF POWER TO MY ENGINE AND AN INABILITY TO NAVIGATE MY VEHICLE SAFELY. AN ACCIDENT NEARLY OCCURRED, HOWEVER I WAS LUCKY TO MAKE IT OFF THE HI-WAY WITHOUT SERIOUS INJURY. HOWEVER, I WAS STRANDED IN SUB-ZERO TEMPERATURES UNTIL HELP ARRIVED. THIS IS A DESIGN FLAW IN FORD MANUFACTURING AND NEEDS TO BE RECALLED. *TR

I OWN A 2003 FORD F150 SUPER CREW FOUR WHEEL DRIVE PICK UP. WHEN ENGAGING THE FOUR WHEEL DRIVE SYSTEM MOST OF THE TIME THE FRONT WHEELS WILL NOT ENGAGE. THE TRANSFER CASE ENGAGES EVERY TIME, BUT I WOULD ESTIMATE THE FRONT WHEELS ENGAGE ABOUT TWENTY PERCENT OF THE TIME. THE SYSTEM IS VERY UNPREDICTABLE AND YOU CAN NOT COUNT ON IT WORKING WHEN YOU NEED IT. IT HAS NOT CAUSED AN ACCIDENT FOR ME YET, BUT I HAVE BEEN STUCK SEVERAL TIMES BECAUSE OF THE POORLY DESIGNED SYSTEM. *TR

E-150 1.CRUISE CONTROL USE. 2.OCCURS INTERMITTENTLY WHILE DRIVING. 3. FORD REFUSED. MY SYMPTOM, MODEL, AND YEAR OF VEHICLE IS INCLUDED ON FORD RECALL UPDATE OF 6/26/08 AS FIRE HAZARD BUT BECAUSE MY VIN IS NOT LISTED FORD REFUSES EVEN TO EXAMINE MY VEHICLE UNDER THE RECALL. HTTP://WWW.FORD.COM/DYNAMIC/METATAGS/ARTICLE-DETAIL/223_IMPORTANT_NOTICE_VOLUNTARY_RECALL_UPDATE. *TR

TL*THE CONTACT OWNS A 2003 FORD E150. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 07V33600 (VEHICLE SPEED CONTROL). THE PART WAS UNAVAILABLE. HIS WIFE IS DISABLED AND CANNOT DRIVE WITHOUT THE CRUISE CONTROL FEATURE. THE SWITCH WAS DISCONNECTED. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 52,200. UPDATED 03/26/08. *LJ

DT*: THE CONTACT STATED WHILE DRIVING 70 MPH ON NORMAL ROAD CONDITIONS, A LOUD NOISE CAME FROM THE REAR DRIVER SIDE TIRE. AFTER A VISUAL INSPECTION, IT WAS NOTICED THE TIRE TREAD HAD SEPARATED. AFTER 500 MILES, THE SAME PROBLEM RECURRED TO THE FRONT PASSENGER SIDE TIRE. THE TIRE DISTRIBUTOR WAS CONTACTED WITHOUT A POSITIVE RESPONSE FROM THE CORPORATE OFFICE. THE TIRE MANUFACTURER REFERRED THE CONTACT TO THE DISTRIBUTOR WHERE THE TIRES WERE PURCHASED. THE TIRES WERE SOLD WITH 60000 MILES TROUBLE FREE GUARANTEE. THE CONTACT WAS VERY CONCERNED BECAUSE OF THE SERIOUS SAFETY RISK INVOLVED IN BOTH INCIDENTS. UPDATED 12/28/2006 - *NM

WITH LESS THAN 12,000 MILES THE LEFT FRONT BRAKES LOCKED UP...NO WARNING LIGHTS CAME ON... BRAKE PADS BURNT TO A CRISP...WARPED ROTORS AND CALIPERS...HAD TO GET WORK DONE BY OTHER THAN FORD...2006..OR COULD DRIVE IT !!!! FORD FAILED TO PAY UNDER THEIR WARRANTY... HAVE HAD HOWLING IN REAR END ??? SINCE NEW...FORD CAN'T REPAIR, THEY TRIED THREE TIMES... THEN SAID THEY WOULD HAVE A DISTRICT FORD REP LOOK AT IT...FAILED TO DO SO UNTIL AFTER WARRANTY RAN OUT... UNABLE TO USE THE ESP WARRANTY ANYWHERE BUT A FORD DEALERSHIP... LIKE I WANT TO TAKE IT BACK TO THE SAME PEOPLE THAT CAN'T FIX IT !!!! *NM

2003 E150 CONVERSION VAN GAS PEDAL GOT STUCK 3 TIMES CAUSING AN ACCIDENT. *TS THE REAR CARGO DOOR WAS REPAIRED, THE FAN CLUTCH WAS REPLACED. THE RUNNING BOARD DID NOT FIT CORRECTLY. AIR CONDITIONER BLOWN WARM AIR. THE EXHAUST WAS BLOWING OUT WHITE SMOKE. THERE WAS A KNOCKING SOUND COMING FROM THE ENGINE. THE GAS TANK WAS NOT COMPLETELY FULL EVEN THOUGH THE CONSUMER FILLED UP THE TANK. *JB

DT*: THE CONTACT STATED THE STEERING WHEEL VIBRATEED CONTINUOUSLY WHEN THE ENGINEWAS RUNNING. THE VEHICLE WAS TAKEN TO THE LOCAL DEALERSHIP FOR INSPECTION, AND THE DEALER REPLACED THE POWER STEERING PUMP. THIS HAS NOT SOLVED THE PROBLEM.*AK

DT: CONSUMER STATED THE FRONT BRAKE ROTORS WORE OUT AND WARPED ALL THE TIME. THEY WERE EATING THE BRAKE PADS UP. THE ROTORS WARPED WITHIN THE FIRST 5, 000 MILES OF USAGE. THEY WERE CHANGED, AND THE PROBLEM RECURRED. CONSUMER FOUND ON THE INTERNET THAT THERE WAS A SPECIAL PAD FOR THIS PROBLEM, BUT HE COULD NOT GET ANY OF THESE PADS. DEALER INSPECTED THE FRONT BRAKES, AND SAID THEY COULD NOT FIND THE CAUSE OF THE PROBLEM. THE ROTORS HAD TO BE CHANGED TWICE, AND WERE TURNED ONCE, BUT THEY WARPED AGAIN. CONSUMER NOTICED THAT VEHICLE VIBRATED AT ABOUT 5, 000 MILES, AND AT 6000-7000 MILES THE VEHICLE WAS TAKEN IN.*AK

THE SEAT BELTS ON ALL THREE ROWS ON THE RIGHT HAND SIDE, THE HARNESS IS SHREDDING. WHEN YOU SIT IN THE SEAT THE SHRED GETS INTO THE BUCKLE. THE DEALER STATED THE SEAT BELTS HAVE BEEN ABUSED. *NM

THE THREADS ON THE SEAT BELTS ARE TEARING APART, CAUSING THEM TO BE INOPERABLE , WHICH IS DANGEROUS IF INVOLVED IN AN ACCIDENT. MANUFACTURER WAS CONTACTED, AND OWNER WAS INFORMED THAT THE VEHICLE WAS OUT OF WARRANTY.*AK

AIR CONDITIONING SYSTEM NOT COOLING. AIR VENT TEMPS AT CITY DRIVING IS 52 TO 65 DEGREES. FREEWAY DRIVING CAN BE 44 DEGREES IF SPEED IS CONSTANT AND OUTSIDE TEMP IS NOT ABOVE 90 DEGREES. DEALER STATES VEHICLE IS OPERATING AT FACTORY SPECS, BUT THE VEHICLE (VAN) NEVER GETS COOLED OFF ON MOST CITY DRIVING ESPECIALLY IF NOT OUTSIDE. I HAVE HAD FIVE TRIPS TO DEALER TO REPAIR BUT NO REPAIRS MADE. *JB

WHILE IDLING IN THE DRIVEWAY CONSUMER STEPPED OUT OF THE VEHICLE AND WENT INSIDE THE HOUSE, VEHICLE WENT INTO REVERSE ON ITS OWN, AND DROVE BACKWARDS INTO THE GARAGE, BENDING THE DRIVER SIDE DOOR WHICH WAS OPEN. CONSUMER TOOK THE VEHICLE TO THE DEALER, WHO CLAIMED THAT HE UNDERSTOOD WHAT HAPPENED BUT DID NOT THINK THAT WHAT HAPPENED WAS A DEFECT. *AK