2005 Toyota Tacoma

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.

Risk. If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.

Remedy. Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.

Defect. Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.

Risk. If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.

Remedy. Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.

Defect. TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVER’S AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.

Risk. IN THE EVENT OF A CRASH, THE DRIVER’S SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.

Remedy. TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Defect. GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Risk. THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy. DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

Defect. SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Risk. A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy. DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

Defect. TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Risk. A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy. TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.

Defect. TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."

Risk. INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.

Remedy. TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.

Defect. ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.

Risk. THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.

Remedy. DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.

Defect. ON CERTAIN REGULAR CAB PICKUP TRUCKS EQUIPPED WITH A BENCH SEAT, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR CONNECTOR PINS ARE INCORRECTLY POSITIONED DUE TO A WIRE HARNESS MANUFACTURING PROCESS ERROR.

Risk. IN THIS CONDITION, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR MAY NOT FUNCTION AS DESIGNED, AFFECTING THE ADAPTIVE AIR BAG DEPLOYMENT, WHICH IF THE VEHICLE IS INVOLVED IN A CRASH, COULD RESULT IN IMPROPER OCCUPANT RESTRAINT.

Remedy. DEALERS WILL INSPECT THE SEAT POSITION AND SEAT BELT FASTENING CONDITION SENSOR CONNECTOR. AN ADDITIONAL SUB-WIRE HARNESS WILL BE INSTALLED TO CORRECT THE CONNECTOR PIN MANUFACTURING ERROR, IF NECESSARY. THE RECALL BEGAN ON JULY 25, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-431-4331.

Defect. ON CERTAIN PICKUP TRUCKS EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THERE IS A POSSIBILITY THAT THE PARKING BRAKE PEDAL CABLE LOCK NUT MAY NOT HAVE BEEN TIGHTENED TO THE PROPER TORQUE SPECIFICATION. IN THIS CONDITION, THE LOCK NUT MAY LOOSEN AND COME OFF, WHICH WILL REDUCE THE EFFECTIVENESS OF THE PARKING BRAKE.

Risk. THIS CONDITION COULD ALLOW THE VEHICLE TO ROLL IF THE TRANSMISSION IS NOT PLACED INTO THE "PARK" POSITION AND THE VEHICLE IS PARKED ON A SLOPE, THUS RAISING THE POSSIBILITY OF A CRASH.

Remedy. DEALERS WILL INSPECT AND TIGHTEN THE PARKING BRAKE PEDAL CABLE LOCK NUT TO THE PROPER TORQUE SPECIFICATION FREE OF CHARGE. THE RECALL BEGAN ON MARCH 3, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Dealer Package: Modified warranty claim submission flowchart. See Appendix A. In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for Frame Corrosion on certain 2005 ? 2010 model year Tacoma vehicles. On May 21, 2017, a settlement of claims in a class …

Dealer Letter: March 2, 2018. Rental sublet period added for use during repair. ? Primary Coverage expiration date changed. ? Ancillary parts coverage section added. Warranty Enhancement Program ZH6 Certain 2005 ? 2010 Model Year Tacoma Extension of Warranty Coverage for Frame Corrosion. In our continuing efforts to ensure the best in customer satisfaction, …

Reference Guide: ASM Reference Guide for Warranty Extension Program (WEP) ZH6 - Covered Components: if Frame Replacement is Needed.

Technical Instructions for Warranty Extension Program ZH6, ZH7, ZH8, and ZH9.

Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical impurities in the atmosphere. If these acidic compounds settle on an exposed vehicle, especially the horizontal areas such as the hood, roof, and decklid, significant damage to the painted surfaces can occur. Acid rain damage can typically be identified …

To prevent brake rotor rust from forming during transportation and storage, wheel film will be used instead of a cardboard type of anti-rust cover. The purpose of the wheel film is to shield the disc brake rotor from weather elements and initial rust before the vehicle is delivered to the customer. Consequently, the film should remain on the wheel for as …

The condition known as acid rain is caused by airborne chemicals or particles in the atmosphere, which mix with rainwater, nighttime dew, or high humidity to form acidic compounds. If these contaminants settle and remain on a painted vehicle surface, especially the horizonal areas of the hood, roof, and decklid, significant damage can occur. This damage is …

Toyota vehicles are currently protected with RapgardTM protective film designed to protect the horizontal painted surfaces. This material protects from acid rain, environmental fallout, and rail contamination. Follow the Removal Procedure in this bulletin to remove the RapgardTM protective film within 90 days from initial application.

Vehicles may occasionally be subjected to contamination by airborne iron particles shed from railroad tracks, train wheels, exposure to heavy machinery facilities, grinding, welding, etc. This type of contamination can be identified by the presence of small, red or brown particles on the paint surface. These particles are often difficult to see on dark …

Some 2005 – 2024 Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Service Bulletin is to provide general guidelines and procedures for odor remediation. This Service Bulletin provides a …

I discovered frame perforation rust, for which Toyota sent letters offering to repair or compensate. I have moved to Florida and the letters didn't forward. So I notified Toyota and they said they would not do anything to help. There was a prior class-action lawsuit about this, which prompted Toyota's action. I have sent Toyota mechanic statements and photos of the rust along with m y nice letter requesting help. They offered that I could get my vehicle inspected at a Toyota dealer, at my expense, which would auto-enter it into their warranty database, repair order # [XXX] which I did this week. I am writing them back again, appealing for their help. In the interim, I am making this report. I will also be notifying the Florida Attorney General's Consumer Protection Division. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The frame had rust a lot,had one spot was repaired,still have some need fix

Odometer Fraud. The contact purchased a 2005 Toyota Tacoma. The contact discovered a mileage discrepancy after the purchase. The vehicle was a private sale through OfferUp. At the time of purchase, the vehicle mileage was 139,900. It was later discovered that the mileage on the Title was 339,740.

Corrocion en el chasis, el motor se encuentra inclinado

The frame is rusting out substantially. The dealer advised me not to drive because the frame could fail at anytime. I have been driving around unaware of the problem. I could have been killed if the framed failed on the highway. There was no warning light. The Vehicle has been into the dealer and no one mentioned the problem until 08/30/2024. The Vehicle has been maintained and garaged. The vehicle is in good condition and has not been in an accident. I called Toyota and was told I was out of luck because the warranty expired even though the frame problem was Toyotas fault. A truck frame should outlast the engine and the body. I plan to keep the truck for 400,00 miles and my finances are very tight. Toyota is penalizing me because the frame didn't rust out sooner and on Toyotas time frame.

The frame has failed and is well beyond unsafe for the road due to the amount of rust and decay. The vehicle was part of the 'Corrosion Resistance Compound Application to Vehicle Frame' recall. I will bring the vehicle for inspection ASAP, if requested. There is absolutely nothing safe when a vehicle has a faulty structural issue. When I purchased the vehicle there were step rails and spray painted portions of the frame, the parts you could see. Also, when looking up the vehicle, I didn't see any recall issues at that time and thought it was a good sign. After driving it for 6th months, I started feeling a slight resistance feel when accelerating and turning at the same time. I took it to a mechanic and they delivered the news that the frame was deemed unfit for the roads. I found out that the vehicle was brought in for the recall when it came out and at that time the frame was labeled 'not exchangeable' and a slight bandage was applied to the unsafe defective body component that was sold as 'safe.' I filed a claim with a local dealership and they told me that it was still safe for roads. Right now, the frame clips and portions of the frame are visibly rusting off, visible from solely walking up to the truck. Reaching out to Toyota I am very much hoping that the care for their loyal customers equally matches the product that they produce, superior to the competition. I have owned a Toyota for 10 years and never considered purchasing anything else for life, however, coming to

The contact owns a 2005 Toyota Tacoma. After a visual inspection of the exterior of the vehicle, the contact observed extreme corrosion on the sub frame. There was no warning light illuminated. The vehicle was taken to the dealer, who confirmed the corrosion of the sub frame and deemed the vehicle unsafe for driving. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 130,000.

Frame failure due to rust. Suspension is detached with springs hitting frame. NOTE: fuel tank partially detached previously due to rusted brackets 3-4 years ago and all components were replaced. Filed NHTSA report at that time however had technical issues completing… Still have photos.

Where the motor mount sits the bracket below collapsed into the Frame itself causing the engine to lower

The contact owns a 2005 Toyota Tacoma. The contact stated while changing the oil and inspecting the vehicle, there was rust on the driver's side frame. The dealer had not been contacted. The vehicle had not been repaired. The manufacturer was made aware of the failure and confirmed that a repair was no longer covered under warranty. The approximate failure mileage was 169,000.

Drivers the problem drunk speeding Hitman killed man do you watch hard no manslaughters still driving just got another traffic ticket and let go again super unfair

The contact owns a 2005 Toyota Tacoma. The contact stated that while performing an oil change, he noticed excessive corrosion on the subframe of the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure; however, the manufacturer informed the contact that the vehicle was out of warranty. The failure mileage was approximately 250,000.

Hello good afternoon my name is [XXX] I have a Toyota Tacoma 2005 could you help me with some information it has a chassis with holes and rotten. Toyota was changing all chassis that had this defect in 2018 to 2020 at no cost, the first owner didn't know about it and I wasn't even warned. I would like to know if I am entitled to a free chassis exchange? INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Hi, I have a 2005 Toyota Tacoma, the chassis is rusty and has holes in it. I went to complain at Toyota, they said the car didn't have a Recall but neither the first owner nor I had news that I would have to change the car's frame. I would like help to resolve this. all parts under the car are very rusty

In May of 2018, I purchased a 2005 Toyota Tacoma. After arrival of new title, I received a safety recall notice from Toyota in regards to possible abnormal frame rust. I was instructed to take my Tacoma to nearest Toyota dealership for frame inspection. Prior to taking Tacoma in for frame inspection, I scoped the frame myself, and noticed abnormal rust forming throughout both sides of the frame. Therefore, I took my Tacoma to Berge Toyota in Mesa AZ. for further inspection and to have some other repairs done. Upon my arrival to Berge Toyota, l informed the service writer of the repairs that were needed done and showed him the request from Toyota for the frame inspection. My vehicle was taken to a lift, where a brief frame inspection was performed with a flashlight only and I was told the frame was fine, and the rust I had witnessed during my personal inspection was within a standard tolerance of "normal". On September 12, 2022 my frame cracked in a horseshoe formation around the driver side motor mount, causing the engine to shift and sink approx. 3/4" towards the driver side. This frame failure has caused numerous problems to occur, such as the fan to continuously rub against the shroud, abnormal shifting of the transmission, ramping up and down of RPM's, vehicle's steering locks up and cannot be safely driven, leaving me without transportation After detailed inspection was performed on my Tacoma, the horseshoe crack around the motor mount was found and it was determined thi

My 2005 Toyota Tacoma had a recall due to potential frame rusting. I brought my Truck to my local Toyota Dealership for the frame inspection as stated in the recall notice I received. The frame did not need to be replaced and at a later date the frame was sealed per Toyota's remedy. In March of 2022 I had an issue with my truck that required the gas tank to be removed. As it turned out there was major rust to the frame that was located behind the gas tank that was never sealed during the original remedy to the frame rusting issue. I contacted Toyota about the issue and was told that the extended warranty for the Issue had expired. I was told to contact the local dealership. In conversation with the dealership I was told there was nothing they can do. I feel that if this issue has happened to my truck, there must be other trucks on the road with the same issue that the owners have no Idea what is happening to their frames that may cause a safety issue should the frame completely fail. My truck is available for inspection. Neither the dealer or Toyota inspected the Issue. I feel Toyota should have had the hindsight to have the dealers remove the gas tank and seal the frame behind the tank.

The driver side seat belt does not go up and down to adjust position. It is attached to the access door. By not being able to adjust it from going up and down, it makes it hard to strap it into place next to the seat. This may wear out the sides of the seat belt in time. I have not had a Toyota dealer look at it yet. Thanks.

Rusty Frame Issue Toyota Tacoma had a warranty enchantment program that expired in 01/31/2019 . I took the Tacoma July 18 2022 to the dealership for regular maintenance and they told me “THE TECH NOTICED 2 LARGES HOLES IN THE FRAME WHICH IS GOING TO COMPROMISE THE STRENGTH OF THE FRAME”. When I asked why they didn’t change the frame during the inspection back in 2015 if they knew it was going to be a problem. They refused to give a good answer. I took the Tacoma to the dealership back in 2015 for a frame inspection the nonprofessional inspector chose not change the frame. I contacted Toyota Motor Sales USA and basically was told they couldn’t do anything because the warranty enchantment program already expired. I understand that the warranty enchantment program has expired but I don’t understand how I have full responsibility when I did my part as the customer by taking my Tacoma during the time window of the warranty enchantment program. This is not safe for me, my family of the citizens. I believe there are going to be many more Toyota pickups with this problem.

The contact owns a 2005 Toyota Tacoma. The contact stated that while his vehicle was parked, he noticed that the subframe was extremely rusted. The contact noticed a 10-inch crack on the inside driver’s side rear of the vehicle. The vehicle was taken to the dealer dealer and the contact was informed that the subframe needed to be repaired. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 170,000. Consumer stated rust is the worst near the catalytic converters. It is also bad just in front of the rear tires. It’s a manufacturer flaw where they designed the double wall to where water could get in but not get out and the frame rots from the inside out. This truck was garage kept.

The differential drive housing failed due to corrosion resulting in the differential oil leaking out at a significant rate and in loss of lubrication of the differential gears. The condition was detected before any significant loss of material condition or function but could have lead to a loss of vehicle control if the differential had failed. The local Toyota Dealer has not reviewed the condition as of yet. A review of several Tacoma internet forum sights finds similar corrosion failures described (oil leaking from differential housing). There is no monitoring/warning indicator for the oil level condition in the differential housing in this vehicle.

My problem was associated with the air bag warning light. It came on and so I took my truck to Big Two Toyota in Chandler AZ. Dealer said I had a faulty clock spring assembly that will prevent the air bag system from functioning properly and was a major safety risk.... So I let Dealer remove and replace it for $511.82. THIS SHOULD HAVE BEEN SAFETY RECALL.... Please look into this issue for me and other Toyota Tacoma truck owners. Thank you.

The frame of my truck failed at the motor mount. The motor mount has sunk into the frame shifting the motor and effecting performance and other parts. This can be confirmed by anyone. I never received recall information, I can’t find evidence of one issued for this year or my state.

The frame caved in to the motor mounts. The motor mounts on the drive side are intact however the frame has broken and the motor mount has fallen into the frame.

The contact owns a 2005 Toyota Tacoma. The contact stated while inspecting the vehicle, he noticed punctures and corrosion on the main subframe. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had been informed of the failure. The contact stated that an unknown recall repair was performed to the subframe in August 2014. The failure mileage was approximately 255,000.

We took our truck to a mechanic to have it looked over before our 18 year old son takes it to college. The mechanic said the frame had so much rust it is unsafe to keep driving it. Once I searched for this problem, Toyota had an extended warranty to cover it, but a recall had never been issued. Therefore, we did not know about it and the warranty time period is up. Now we have a vehicle too unsafe to drive and we didn't know in time to fix it.

I own a 2005 Toyota Tacoma xtra cab with 140445 miles on it. When it had 36000 miles I noticed the driver side seatbelts wearing down that was in 2011 . It’s just me so the passenger side is still good. I contacted Toyota about this problem asking them if there were any recalls or any complaints about the seatbelt wearing down. I was told no complaints. I told them my safety concerns they agreed on having my local dealership take care of the problem. It took some convincing to have it approved. So now I’m having the same issue again I haven’t contacted them yet. I just hope they will fix the problem again. Like I told the person I spoke to none of my other many vehicles have had a safety belt wearing down on the sides. It could be a poor design that’s causing it but none the less it’s needs to be corrected.

I got a recall on my 2005 Toyota frame for rust problem. I took it to magness Toyota in Harrison Arkansas they checked the frame and said it was ok. 2 years later when I had my 2005 toyota serviced they found on both sides the frame was severely rusted through and can and will be a dangerous circumstance

THE VEHICLE WAS IN THE SHOP FOR SERVICE,THE TEC INFORMED ME IT WOULD NOT PASS NYS IINSPECTION DUE TO RUST HOLES IN THE FRAME.

FRAME HAS RUST HOLES IN IT AND WILL NOT PASS NEXT NYS INSPECTION.

INTERMEDIATE STEERING ROD LOWER BALL JOINT HAS FAILED , UNABLE TO STEER TRUCK SAFELY THIS IS VERY DANGEROUS TOYOTA NEEDS TO LOOK INTO THIS I BOUGHT THIS TRUCK BRAND NEW IN 2005 OFF THE FLOOR

TRUCK WAS TAKEN IN FOR COOLANT LEAK. TECHNICIAN FOUND THE FRAME TO BE RUSTED THROUGH AND WAS ADVISED TRUCK WAS NO LONGER SAFE TO OPERATE. TRUCK WAS STATIONARY IN DEALERS REPAIR BAY.

FRAME RUSTED SEVERELY. HAVE BEEN ADVISED IT IS UNSAFE TO DRIVE.

CHASIS IS SOO RUSTY THAT I JUST DID THE VIRGINIA STATE INSPECTION AND THE INSPECTOR ALMOST DID NOT PASS THE INSPECTION BECAUSE OF RUST UNDER CHASIS AND UNDER PARTS.. SUSPENSIONS... I ACTUALLY REPORT THIS ISSUE AT THE TOYOTA DEALER BUT THEY DID NOT CHECK IT OR FIX IT??

THERE WAS A RECALL ON THE FRAME AND IN 2015 MY FATHER-IN-LAW OWNED THE VEHICLE AND HAD IT INSPECTED AND ALL I KNOW IS IT PASSED. HE IS DECEASED NOW AND I OWN THE VEHICLE AND RECURVED NOTIFICATION ABOUT A RECALL ON THE REAR SPRINGS SO MADE AN APPOINTMENT AND THEY TOLD ME THAT THEY COULDN'T FIX THE PROBLEM BECAUSE THE FRAME WAS TO RUSTED TO SAFELY TAKE SPRINGS OFF TO REPLACE. THE FRAME RECALL HAS EXPIRED BUT THE SPRING RECALL IS STILL IN EFFECT. SO I FEEL THAT TO FIX THE SAFETY ISSUE THEY SHOULD FIX THE FRAME SO THAT THEY CAN FIX THE SPRINGS TO SOLVE THE SAFETY ISSUE. ANY ADVICE OR HELP WOULD BE GREATLY APPRECIATED.

I AM THE SOLE OWNER/PURCHASER OF A 2005 TACOMA. LAST WEEK A LOUISVILLE, KY TOYOTA DEALER, OXMOOR TOYOTA, WAS REPLACING THE REAR U-JOINTS AND NOTICED RUST AND CORROSION THROUGHOUT THE FRAME. IT WAS SO BAD, THE TOYOTA TECHNICIAN CONSIDERED IT UNSAFE TO DRIVE. I HAVE CALLED TOYOTA USA BUT THEY OFFERED NO ASSISTANCE. WHAT ELSE CAN I DO... THERE SEEMS TO BE NEGLIGENCE AND LIABILITY HERE. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TRUCK FRAME WAS INSPECTED FOR RUST DAMAGE BY TOYOTA IN 2016 AS PART OF A RECALL. TOYOTA FOUND THE FRAME TO BE SOUND AND TREATED IT WITH ANTI-CORROSIVE MATERIAL. JUST FOUR YEARS LATER, THE TRUCK FRAME HAS RUSTED THROUGH IN SEVERAL SPOTS MAKING IT UNSAFE TO DRIVE.

AS I WAS DRIVING I WENT TO MAKE A TURN AND THE STEERING BECOMES VERY DIFFICULT AND DOSE NOT RESPOND AS IT SHOULD, TOYOTA IS AWARE OF THIS PROBLEM AND TOLD ME THE STEERING SHAFT MUST BE REPLACED, I ALMOST RAN INTO ONCOMING TRAFFIC BECAUSE OF THE STEERING PROBLEM. THIS PROBLEM HAS OCCURRED NUMEROUS TIMES ON CITY STREETS COUNTY ROUTES AND US HIGHWAY ROUTE 22 IN THE STATE OF NEW JERSEY.

RUSTY AND CRACKED FRAME.

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE INSPECTING THE SUBFRAME OF THE VEHICLE AT THE RESIDENCE, THE CONTACT NOTICED THE REAR DRIVER'S AND PASSENGER'S SIDE WAS SEVERELY CORRODED. THE VEHICLE WAS TAKEN TO TOYOTA OF LA CROSSE (800 3RD ST S, LA CROSSE, WI 54601) HOWEVER, THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 122,000.

THE FRAME OF THIS TACOMA IS RUSTED AND HAS SIGNIFICANT HOLES, VERY UNSAFE. I HAVE BEEN TOLD MIXED MESSAGES BY DIFFERENT TOYOTA DEALERSHIPS. THE TOYOTA DEALERSHIP NEEDS TO TAKE CARE IF THIS RECALLED FRAME AND STOP TELLING ME THEY DO NOT COVER MINE. I WILL NOT ACCEPT THE EXCUSE OF THE RECALL HAS EXPIRED. IT'S THEIR RESPONSIBILITY TO FIX THIS DANGEROUS PROBLEM. *TR

VEHICLE HAS PROBLEM WITH THE STEERING COLUMN, SPECIFICALLY IN THE UPPER INTERMEDIATE SHAFT. IT MAKES NOISE WHILE DRIVING.

THE HEAD GASKET HAS CAUSED COOLANT TO LEAK INTO THE CYLINDER. ACCORDING TO MANY OTHER OWNERS THIS IS A COMMON PROBLEM WITH THE 2005 AND 2006 TOYOTA TACOMA 4.0L V6 ENGINES AND THE HEAD GASKET WAS FINALLY REVISED IN 2007

I RECENTLY PURCHASED A 2005 TOYOTA TACOMA NEEDING A NEW BATTERY AND ALTERNATOR. I'M A MECHANIC THE PRICE WAS RIGHT SO I BOUGHT IT WITHOUT A SECOND THOUGHT WHEN INSTALLING THE ALTERNATOR I SAW RUST HOLE IN THE FRAME IN FRONT OF THE DRIVERS SIDE TIRE A LITTLE MORE INSPECTION SHOWED THERE IS NOT MUCH FRAME LEFT THERE IS A WHOLE CROSS MEMBER MISSING THE FRAME IS BROKEN IN FRONT OF THE REAR SPRING HANGER AND ONE OF THE STRUTS IS SEPARATING FROM THE FRAME THE WHOLE FRAME SEEMS TO BE DELAMINATING BUT NO RUST IN THE BODY ANYWHERE I NOTICED ANYWAY I WAS UNDER THE IMPRESSION THAT TOYOTA HAD FIXED THIS PROBLEM I CHECKED THE SERVICE REPORT 2/9/16 169000 MILES RUST PRESENT BUT NO PERFORATION FOUND. OK AT THIS TIME. EXACT WORDS SO HERE I AM FOUR YEARS LATER 189000 MILES WITH A ROTTEN FRAME AND TOYOTA SAYING YOU MISSED THE WINDOW I HAVE TO WONDER HOW MANY MORE OF THESE DANGEROUS PICKUPS ARE ON THE ROAD THIS ONE RUNS AND DRIVES WELL.

BOUGHT TRUCK IN VIRGINIA AND BROUGHT TO SOUTH CAROLINA IN 2016. SOON AFTER I GOT RECALL ON FRAME RUST. DAVE EDWARDS TOYOTA SPARTANBURG, SC INSPECTED AND DOCUMENTED "OK". NEEDING TO SELL TRUCK IN 2019 I CLEANED/SCRAPED FRAME AND REMOVED 6 POUNDS OF RUST FROM ONLY 1/2 OF THE TRUCK--TOOK TRUCK AND PICTURES IN TO DAVE EDWARDS AND THEY LOOKED AT PICTURES AND REFUSED TO LOOK AT TRUCK OR DO REPAIRS TO FRAME OR LEAF SPRINGS (ON RECALL). SO, I SPENT $20,000 ON A TRUCK THAT THE DEALERSHIP WANTS TO CONDEMN. SO, IS TRUCK UNSAFE TO DRIVE? WILL TOYOTA BE RESPONSIBLE IF SOMETHING HAPPENS TO TRUCK, OR MY FAMILY, OR SOMEONE ELSE?

UNINTENDED ACCELERATION ON 3 OCCASIONS. 12/23/19, 12/24/19 & 2/22/20. SEEMS TO HAPPEN DURING SLOW CREEPY SPEED WITH FOOT ACTION ON THE BRAKE IN SLOW TRAFFIC OR GOING THRU A PARKING LOT. I HAVE BEEN FORTUNATE TO BE PREPARED FOR THIS TO PUT PRESSURE ON THE BRAKE, SLAM IN PARK AND TURN OFF IGNITION DUE TO A SIMILAR OCCURRENCE ON 10/7/19. IF NOT PREPARED IT COULD EASILY RESULT IN AN ACCIDENT. IT BOTHERS ME HOW RANDOM THIS OCCURS FOR NO REASON.WITH FOOT NOWHERE NEAR OR ON THE GAS PEDAL. VEHICLE ACTS LIKE YOU SLAMMED THE ACCELERATOR TO THE FLOOR.

THE FRAME IS RUSTED THROUGH ON THE DRIVER'S SIDE NEXT TO THE CATALYTIC CONVERTER. IT HAS TWO RUST HOLES THAT ARE CONNECTED WITH A CRACK THAT THE RUST IS STARTING TO WIDEN. THE HOLES ARE APPROXIMATELY 1-2 INCHES IN SIZE. I FIRST BOUGHT THE VEHICLE IN 2013 AT MY HOME OF RECORD (MINNESOTA) IN-BETWEEN DUTY STATIONS. I'M ACTIVE MILITARY AND I'M STATIONED IN NORTH CAROLINA. I DEPLOYED IN 2017 AND DIDN'T GET BACK UNTIL LATE 2018. IN EARLY 2019 STEVENSON HENDRICK TOYOTA CONTACTED ME TO HAVE RECALLS PERFORMED ON MY TRUCK. I TOOK IT IN AND THEY DID THE SEAT BELT, THROTTLE PEDAL, AND LOAD RATING STICKER. HOWEVER, I WAS NEVER INFORMED THAT MY FRAMED WAS RUSTED THROUGH. I FOUND OUT AFTER I HAD TO TROUBLESHOOT MY O2 SENSORS. AT WHICH POINT I CONTACTED TOYOTA HEADQUARTERS IN REGARDS TO UNITED STATES DISTRICT COURT FOR THE CENTRAL DISTRICT OF CALIFORNIA CASE NO. 2:15-CV-02171-FMO-FFM TO SEE IF THEY WOULD REPLACE MY FRAME OR AT LEAST REPAIR IT; AS I UNDERSTOOD THE TIMEFRAME HAD PAST THAT TOYOTA WOULD REPLACE THE FRAME. I EXPLAINED TO THEM THAT I NEVER RECEIVED ANY NOTIFICATION ABOUT THIS AND THAT I WAS DEPLOYED AS WELL DURING THIS TIME. TOYOTA STILL REFUSE TO FIX THE FRAME. WHEN I TAKE THE TRUCK IN TO GET SERVICED SOMETIMES THEY TURN ME AWAY; AS THEY DON'T WANT TO HELD LIABLE BECAUSE OF THE FRAME. FOR THE PRICE TO REPLACE THE FRAME I CAN PURCHASE A USED VEHICLE. I SHOULD NOT HAVE TO DISPOSE OF MY VEHICLE WHEN IT RUNS FINE AND IS PAID FOR. SINCE THEN I HAVE TRIED TO FIND SOMEONE WITH THE EXPER

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING, THE VEHICLE PULLED TO THE RIGHT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND WAS INFORMED THE CHASSIS WAS BENT AND WAS TO TAKE THE VEHICLE TO A TOYOTA DEALER. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE CONTACT STATED THAT THE CHASSIS WAS PREVIOUSLY REPLACED AT TOYOTA OF BRISTOL DEALER, (3045 W STATE ST, BRISTOL. TN 37620, (423) 212-4266), HOWEVER THE FAILURE RECURRED AND WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 264,488.

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT TOOK THE VEHICLE TO HALTERMAN'S TOYOTA (1741 PARADISE TRAIL, EAST STROUDSBURG, PA 18301, (570) 273-9454) TO HAVE THE BRAKES SERVICED. THE MECHANIC POINTED OUT THAT THERE WERE MULTIPLE HOLES FOUND WITHIN THE FRAME OF THE VEHICLE. THE CONTACT WAS INFORMED THAT THERE WAS AN UNKNOWN MANUFACTURER RECALL ON THE VEHICLE AND THAT IT NEEDED TO BE SERVICED. THE CONTACT WAS PROVIDED A RENTAL VEHICLE AND, AFTER SIX WEEKS, THE CONTACT WAS INFORMED THAT THEY DID NOT HAVE THE PART TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED AND REFERRED THE CONTACT TO NHTSA. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 167,000.

THE FRAME ON MY TOYOTA TACOMA IS ROTTING AWAY. WHEN I SPOKE TO A REP FROM TOYOTA ON 9/27/19 HE SAID THE RECALL ENDED JANUARY OF THIS YEAR. SENSE WHEN DOES A RECALL END. ISN'T IT GOOD FOR THE LIFE OF THE VEHICLE. WHEN I BROUGHT THE VEHICLE IN FOR THE LEAFSPRING RECALL THEY INSPECTED THE FRAME TO AND SAID NOTHING WAS WRONG WITH IT THAT WAS A FEW YEARS AGO OBVIOUSLY THEY WERE WRONG BUT THEY WILL NOT HONOR IT SO NOW THAT I PAID ALL OF THAT MONEY FOR MY TRUCK. WHAT AM I SUPPOSED TO DO. I I HAVE NO CHOICE BUT TO DRIVE UNSAFELY VEHICLE. I'M SURE I'M NOT THE ONLY ONE THAT HAS THIS COMPLETE. SOMEBODY REALLY NEEDS TO DO SOMETHING ABOUT THIS IT'S NOT FAIR THAT YOU SPEND YOUR HARD EARNED MONEY ON A VEHICLE FOR THE FRAME TO ROT AWAY. I FEEL THIS RECALL SHOULD BE HONORED. I TAKE VERY GOOD CARE OF MY VEHICLE SO IT WOULD LAST BECAUSE I CAN'T AFFORD TO PURCHASE ANOTHER ONE AND IT'S REALLY NOT FAIR THIS IS TOYOTA'S FAULT NOT MINE. AND IN MY OPINION THIS IS EXTREMELY UNSAFE

UNINTENDED ACCELERATION: STOPPED IN TRAFFIC WITH FOOT ON THE BRAKE PEDAL. SUDDENLY VEHICLE STARTED TO ACCELERATE WITH MY RIGHT FOOT ON THE BRAKE PEDAL THE ENTIRE TIME. BACK WHEELS STARTED TO SPIN WITH VEHICLE LURCHING FORWARD. FORTUNATE TO HAVE ENOUGH SPACE BETWEEN VEHICLE IN FRONT OF ME TO AVOID HITTING IT. THE UNINTENDED ACCELERATION EVENT LASTED ABOUT 10 SECONDS OR SO.