2020 Toyota Tacoma

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.

Risk. If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.

Remedy. Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.

The steering rack has failed multiple times. The rack that was installed in the vehicle when I bought it new had cracked by 53,000 miles - not ideal, but these things happen. (This was discovered by my local Toyota dealership when I brought it in for service.) I returned for a six-month service with no problems. When I returned for my 60,000-mile service, thirteen months after the rack was replaced, the new steering rack had also cracked. This was after less than 7,000 miles driven on the new rack, almost entirely on paved roads in a temperate part of the country. At about twelve months, the rack began to make significant groaning sounds when making turns at low speeds. No warning lights have come on to indicate a problem with either rack's failure. The rack is currently being replaced by the dealership. However, I received a call today that the new rack they had installed has also been shown to be deficient, so they are removing it and replacing it with another part they had in stock. At this point, that's 3 problematic steering racks by 60,000 miles. From what I've read online, this is a relatively common problem for third-generation Tacomas. I'm concerned that the parts Toyota is producing are deficient and need to be re-evaluated. I'm worried that if I were not monitoring this problem so closely, I might be in danger of a crash if the rack were to have worsening issues at high speeds.

Occasionally Center cluster on start up is black it has gotten more frequent. No odometer, No cruise control, no digital speedometer. The truck has 12,000 miles on it now today October 13,2026. Selling dealer out of town has no knowledge of issue. Local dealer at time it exhibited issue said never seen that before just disconnect battery for 30mins that will fix it that’s what we do. Was waiting for recall or TSB but am tired of waiting.

The rear quarter panel pressure vents failed which allowed water intrusion into the cabin of the truck. Severe mold and smell has occurred due to water damage. There were no warnings from toyota or dealership about these pieces failing and causing damage. To have a dealership replace just the parts, NOT including ruined carpet and pads due to mold, I was quoted $800- $5000 to replace a $60 piece of plastic

The wiper motor does not move fast enough to keep the windshield clear in heavy rain. Yes it is available to be inspected. Unable to see while driving even after slowing down. Only when encountering heavy rain. No No

The Clutch in the Manual Transmission makes a "creaking" noise, and you can feel it when driving too, when depressing the clutch pedal... The creaking noise is annoying, but the feel of the creaking is very distracting when driving the manual transmission, depressing the creaky clutch can distract you from the road because you can feel it; and it only get's worse when left alone. This is a recurring issue on my 2020 Tacoma. It was "fixed" by the dealer in 2022, I think, and now it's happening again... same "creaking" issue that starts out small and gets louder and more violent (you can feel the "creaking" in the pedal more) with time. This really seems like a parts failure and not a lube job. There is a TSB out for this issue (T-SB-0112-19), but this really should be upgraded to a recall.

I am reporting a safety-related failure of an aftermarket bull bar / grille guard purchased through Amazon. The bull bar detached from the vehicle while the vehicle was in motion on a public road. After detaching, the bar was dragged on the road and was only partially held by the fog light wiring. This created a road hazard and could have caused loss of control, damage to other vehicles, or injury to pedestrians or other drivers. The failure appears to be at or near the welded joint / mounting area, suggesting a possible manufacturing or weld defect rather than normal wear. The product was installed on the vehicle before the incident and failed during normal driving. Product: - Product type: Aftermarket bull bar / grille guard - Brand / seller: Topline_autopart / Amazon - Purchased from: Amazon - Order number: 114-8975268-2481806 - Purchase date: November 21, 2025 Vehicle: - Year / Make / Model: 2020 Toyota Tacoma - Incident date: Mar. 7th 2026 - Approximate speed: 45mph - Location: Exit 111 at I-16 EB I have photos of the failed weld / mounting area, the damaged bull bar, and Amazon order information. I am concerned that other units of this product may have the same defect and could detach while driving.

Fluid weeping/leaking/staining on differential housing

On Sunday, March 15,2026, I was driving from Houston, TX to Pharr, TX at the speed of 75mph on the left lane to pass an 18 wheeler, with another 18 wheeler behind me, and my truck started idling erratically. I lost speed and my service engine light came on. My truck slowed down and I almost got in a car accident with the 18 wheelers because the truck did this. The truck behind me slowed down on time and it went immediately to the right lane to avoid hitting my truck. I feared for my life. All the vehicles behind me and the 18 wheelers also went to the right lane to avoid me. By this time, the TRAC light had already come on also. I managed a space of no vehicles and steered towards the right safety lane. I pulled over at the local truck stop and stoped my truck to rest. After about 5 minutes I tried starting my truck and it wasn’t starting. I am a little mechanically inclined, so I started troubleshooting the truck. My code reader gave these codes: P1605-00, P0300-27, P0300-85, and P0302-00. Unscathed to start the truck after a while and got back on the road. The drive was brutal, as the truck kept burping erratically, but I made it home safely. I took my truck to the mechanic and he did some repairs and told me the issue is the fuel pump. I have checked the recalls for my truck but it shows zero recalls for my truck. Luckily I am alive to report this life threatening safety issue that Toyota has on this model. How do I get Toyota responsible to make the repairs on my truck? T

This is a safety issue and a known issue. Toyota is reporting that it is wear and tear and denying my goodwill repair but it is a technical service bulletin TSB #0082-21 - so it is a safety issue. I emailed and called and have case number with Toyota - 260225002292

I am having same issue as the incident i found here 12/06/2025, LISTED UNDER COMPLAINTS-I live in Rio Rancho NM- Concern it involves the automatic transmission torque converter specifically torque-converter lock-up behavior, The issue presents as a vibration/shudder during steady -speed driving , we are driving around 30-40 miles per hour when it happens, The vehicle remains in my possession and is available for inspection upon request. The vibration/shudder occurs during steady cruising at moderate speeds which affects vehicle smoothness and driver confidence, while no accident has occurred yet, the behavior is unexpected and distracting and could impact safe vehicle operation, particularly during highway driving or when maintaining steady speed in traffic, I Took it to my Toyota dealer a few months ago they said they could not find any issues, I am taking it again tomorrow and now I CAN SHOW THEM THAT I FOUND THE SAME ISSUE UNDER COMPLAINTS, I NEED TO TOYOTA TO FIX MY ISSUE ASAP,

Toyota has a manufacturing defect going on with their v6 in Gen 3Tacoma's. I have a 2020 Limited with 48,200 miles that needs a new cylinder head. It threw a check engine light on me, and luckily enough I took it to the dealership within about 30 miles, otherwise my engine could have exploded. I have videos from the dealership inspection that I cannot attach here. I have since found via the error code a history of these issues on newer trucks. [XXX] [XXX] [XXX] [XXX] [XXX] [XXX] I believe that this issue could pose serious safety issues for someone who is not as immediate on stopping driving, as it was just a check engine light. If you were to drive on this light down the highway, and have catastrophic failure, the Tacoma becomes a completely unpowered hazard. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The concern involves the automatic transmission torque converter, specifically torque-converter lock-up behavior. The issue presents as a vibration/shudder during steady-speed driving. The vehicle remains in my possession and is available for inspection upon request. The vibration/shudder occurs during steady cruising at moderate speeds, which affects vehicle smoothness and driver confidence. While no accident occurred, the behavior is unexpected and distracting and could impact safe vehicle operation, particularly during highway driving or when maintaining steady speed in traffic. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The concern has been reported to and evaluated by a Toyota dealership. Diagnostic checks did not produce fault codes, but the symptoms are consistent with torque-converter lock-up issues that occur without triggering warning lights or diagnostic trouble codes. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle has been inspected by a Toyota dealership service department. It has not been inspected by police or insurance representatives, as no accident or collision occurred. Were there any warning lamps, messages, or other symptoms prior to the failure, and when did they first appear? No warning lights or messages were displayed. The primary symptom was a noticeable vibration/shudder during steady-speed driving, which began after the vehi

The contact owns a 2020 Toyota Tacoma. The contact stated that while driving approximately 35 MPH, the vehicle stalled. The vehicle lost power steering assist and brakes, but was able to coast to the side of the road. The contact stated that the low oil and brake warning lights were illuminated, and a message to “Contact Dealer” was displayed. The vehicle was hauled by a friend's truck to a parking lot. The contact used a hand scanner and retrieved fault codes for the fuel pump, brake override, drive start control malfunction, and low oil pressure. The vehicle was towed back to the residence. The contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 20V682000 (Fuel System, Gasoline). The manufacturer was informed of the failure, and the contact was informed that the VIN was not included in the recall. The failure mileage was approximately 120,000.

Vehicle accelerated on its own at highway speed, had to hit the brake in order for it to stop accelerating. Other more common issue is that vehicle RPMs go up when trying to accelerate but vehicle does not accelerate, just RPMs go up. This happened about 5 times over the past year and a half. Most noticeable time was where I couldn’t accelerate after at all until I pulled over and put it in park. Then back to drive again and worked fine. This car has been brought over to Lia Toyota of rockland numerous times with this second issue and they can never duplicate nor fix the problem

Brake fluid leaking into cab from master cylinder

Unknown

Driving the car on the freeway and upon exiting it stalled going up an incline without any warning. Could have caused a major accident and I am lucky that it did not happen on the freeway. I researched and found out that 2019-2020 Toyota pickups had this known issue in which the fuel pump fails without any warning. As a result, Toyota did issue a recall, however when I contacted them and provided the Vin number, they indicated my truck was not covered under the recall. I am very upset that a 5 year old truck failed on the fuel pump and Toyota is not covering it under the recall since this is a known issue that could have resulted in a serious accident.

The contact owns a 2020 Toyota Tacoma. The contact stated that while in reverse, the rearview camera failed to display a centered rearview image. The contact observed that the rearview image was misaligned, potentially compromising the back over prevention system. No warning lights were illuminated. The vehicle was not repaired. The failure mileage was unknown. The VIN was unavailable.

The contact owns a 2020 Toyota Tacoma. The contact stated that while reversing, the rear-view camera failed to display a centered rear-view image. The contact observed that the rearview image was misaligned, potentially compromising the back over prevention system. No warning lights were illuminated. No warning lights were illuminated. The vehicle was taken to the local dealer; however, the vehicle was not diagnosed or repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 12,000.

Pressure release vents mounted on rear of the cab are leaking water during rain storms causing mold build up in carpet.

My brake master cylinder is leaking brake fluid under the steering column and dripping inside. This seems to have a recall but they only did it for trucks up to 2019 and my 2020 has the same exact issue.

The timing chain cover is leaking oil which will render the vehicle inoperable which is a safety concern. The diagnosis was done at Toyota and I am being told to repair the truck already at 84,000 miles. The cost of the repair is astronomical ($6,666). The problem appears to be a gasket which to reach for repair requires dropping the engine. It is not fair that consumers bear this burden for faulty design linked directly to a safety concern (engine will stop working because of oil leak).

The truck suddenly stopped Took it to a mechanic and had to replace the fuel pump. AAA tow company along with the mechanic that fixed the issue said that it is odd a truck so new with fuel pump issues I have the bad fuel pump and invoices. The truck stopped working at 55,247mi on the odometer

Throwout bearing premature failure. Saftey was put at risk with harsh shifting and potential transmission failure while merging into traffic due to not going into gear. Was brought to a shop to install a new TOB and had to replace my pressure plate as well due to wear. TOB is now doing something similar causing noises due to wear on the shaft it rides on. This is a very very common problem and should be addressed as a failure point especially for what little milage is on the truck.

Front passenger seat belt/SRS lights flashing and staying on. I recently gave someone a ride and when they adjusted the seat/seat belt these lights on the dash came on and will not go off. My guess it is the SRS/seatbelt/seat pretensioner.

The check Engine light came on two different times for us on the 2020 Toyota Tacoma. We called Toyota to see if we could continue to drive it and they asked if the light stayed on or was blinking, and if it stayed on we could still drive the vehicle . We did not feel comfortable doing that so made an appointment on February 5th,2025 and after we parked the truck at the dealership, they started it again the check engine light did not come on. They were going to send us home. The service man then asked if we wanted do a Diagnostic test to check the system and that is when they found it was the low pressure fuel pump, He said that was a good call to have not drove it home because if you're driving at a high rate of speed the truck could just stop and could cause and accident [ which is a serious safety issue for us] We checked for a recall with our VIN # and found they extended the recall and some vehicles might get a recall letters by Late March of 2025. But to keep checking if your VIN is covered. We have to pay over $1200 to get this fixed and feel that for a New 2020 vehicle purchased this is enough of a safety issue that this should be covered by Toyota. We read that these fuel pumps should last at least over 100,000- 200,000 miles. Please respond ASAP how you are going to handle this. We could have had an accident due to this and been killed. The Toyota Dealership in Lincoln, NE. has the part on order and should be trying to get it installed by the end of the week if you n

Started my truck up to go to the store started driving and all of a sudden it acted like it was running out of fuel check engine light came on and a ! Symbol came to barely make it back home it sat for three weeks and had to have it towed to dealer they diagnostic on it and said it was a fuel pump problem the thing is there's a recall on this same vehicle but not mine $1400 is what they want to fix there problem my truck should on the recall

IT'S DEFIANTLY A FUEL PUMP ISSUE CAUSE WHEN CHECK TO SEE IF FUEL PUMP COMES ON IT DON'T I WAS DRIVING ABOUT 30 MPH IT STARTED JUMPING AND JERKING LIKE IF IT WAS OUT OF FUEL I BARELY MADE IT HOME It HAS BEEN TWO TO THREE WEEKS NOW WITH NO RESPONSE BACK FROM TOYOTA DEALER

The contact owns a 2020 Toyota Tacoma. The contact stated that the vehicle failed to start. The contact was able to jumpstart the vehicle. The contact became aware that the battery terminal was corroded. The vehicle was taken to the dealer, where the battery was replaced, and the repair was partially covered; however, the failure persisted. Additionally, the contact stated while driving at various speeds, the infotainment system turned off and on independently. The contact stated that while driving at various speeds, the vehicle shuddered, and the engine made an abnormal sound. The check engine warning light and several other unknown warning lights were illuminated. The vehicle was taken to the dealer, where it was determined that the battery needed to be replaced, and the contact was informed that the repair would be partially covered. The contact stated that the battery failure had caused further electrical damage to the vehicle and was concerned that the battery replacement would not correct the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 50,000.

Vehicle fuel pump went out without any notice and fuel gauge and cluster not showing any data on the instrument cluster. vehicle loss power and would not go over 40mph on the freeway take over 5 minutes to reach 60 mph per hour. Always serviced at the Toyota dealer and they won't help to fix the problem since its over 49K. they won't even look at emissions problem even it under warranty for 8 year/ 80K per emission warranty for ecu.

Was driving to the store, and it started cutting out jumping and jerking with tremendous loss of power barely made it home had to push it in my DRV way and still no start it says my truck is not in the recall for faulty fuel pump warning check engine lights came on and says malfunction in the throttle body censer and automatic transmission sender

The other day I was slowing down on an off-ramp and all the sudden had no brakes, or at least no power brakes for maybe 30 feet and then all of the sudden power assist came back and slammed hard on the brakes. If there would have been a car at the stop sign I would have rear ended them. Pavement was dry, No ABS light, no codes, everything has been normal since then. I have noticed that the electronic brake booster on this truck "cycles" every few brake applications resulting in inconsistent braking power, which is especially noticeable at low speeds. I have been told this is normal for these trucks. Has not been inspected by anyone as I cannot replicate the issue.

The truck has been jumping/idling oddly & after getting gas, is very difficult to restart. Our mechanic said the fuel pump is bad & that it was recalled, but when I contacted the dealership, they are claiming it is not covered under the recall.

Whenever I’m driving my truck before it hits 40 miles it shakes bad but then when it passes 40 miles it stops and drives like if there’s nothing wrong with it

The rear brake pads are locking.I had to towed the truck to the dealer this week.I’m afraid that while driving on the highway the brakes lock.yes, but the problem has not been resolved yet.no it hasn’t been checked by the manufacturer No warning lights has come on the brakes are locking up while the truck is parked in my garage.

The person run away, she left, i took a pic of the car and vin problale she left because doesnt have DL

While traveling with cruise set at 62mph and a truck was in the right turn lane the automatic collision went off and hard brake when nothing was in front of the truck this has happen also with out cruise control on pulling up to a stop light and being first person no other vehicle was on the road I also don't have forward collision turned on or lane departure

While driving my Tacoma truck it has gone into "limp mode" (looses power and you can get but about 25mph) when I have pulled out into traffic 5 times over the last 3 years. I took it to a Toyota dealership on 4/28/2023 for evaluation but no codes where found to indicate a problem. When the truck goes into limp mode I pull over and cut the engine off. I immediately turn the engine back on and the truck operates normally. I know this is a protective system but if you are pulling out into traffic and the truck goes into limp mode for no good reason, it could result in an accident. In addition, the trucks computer system is not registering the event. I haven't noticed any warning lamps, messages prior to the failure. I did notice that the truck shuck prior to going into limp mode.

Was driving doing 35mph and some one ran stop sign T boned Car who ran stop sign my air bags didn't deploy all air bags of other car deployed. My car was totaled . None of the air bags deployed according to recall my vin is not in takata recall. I was tosses all over car

The contact owns a 2020 Toyota Tacoma. The contact stated while driving 50 mph in the morning and in heavy fog, she was unable to visibly see the road which caused her to impact a stationed vehicle in the middle of the road. The contact stated the vehicle was stationed due to a prior crash incident. The contact stated she steered to the right and ended up in a ditch. The contact stated no warning light was illuminated. No air bags deployed. The contact stated she thinks she hit her head on the front windshield since it was fractured. The contact stated she sustained a concussion and has bruises on her right chest and right arm. The contact sought medical attention at a near hospital. A police report was filed. The vehicle was not drivable. The contact towed the vehicle to a towing lot. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 45,000.

The issue is that I and as well as many others live in cold winter climates. LED headlights do not put off the heat required to keep snow and ice off of them. This is a hazardous and accident causing issue when you can not see any longer. Getting out of the vehicle every few miles poses a hazard in it's own that you are pulling over on a roadway to clear the headlights. I don't feel the manufacturers thought this through and is getting worse that most newer vehicles & all electrical vehicles have LED lighting. There needs to be a heater system or film/built in heat source for the lens.... Also the front sensor for collision detection will freeze over or become snow covered. Thus the vehicle turning it off. Seems it is most needed during this weather condition???

The truck has died while driving two separate times. It seems that the problem is the fuel pump, just like we now know have been recalled by Toyota in this model and others. The symptoms are exactly what have been reported by people experiencing faulty fuel pumps that are covered by the recall. My truck is not currently covered by the recall and toyota is refusing to replace the fuel pump, saying that they can’t duplicate the problem after having the vehicle for a week. No resolution has been offered. Just, “Sorry we can’t make it fail and we can’t replace it.” I have spoken with toyota corporate and got the same response. The company is not doing the right thing with this problem, as evidenced by the class action lawsuit ongoing. A major disappointment to say the least. I’m getting absolutely no help from dealer or manufacturer on a major safety issue on a vehicle in its power train warranty period on a known issue. Not even a loaner car.

The contact owns a 2020 Toyota Tacoma. The contact stated while driving 79 MPH, the vehicle lost motive power and stalled without warning. The vehicle was taken to the dealer to be diagnosed; however, no cause for the failure was found. The contact stated that an unknown software update was performed. The manufacturer was not notified of the failure. The approximate failure mileage was 48,000.

Tire failed. The tire is not in my possession anymore. The tire was replaced by America's Tire. I had purchased a tire warranty. Tire failed while traveling at 65 MPH in lane 2 of Interstate 5 northbound at the 5/405 split at approximately 12:35 pm. The traffic was moderate. My vehicle was difficult to control and the noise very loud. The tire pressure warning light did come on. P 265 / 65 R17 1127 SL BSW DOT Code: 1APLV00VX4721

My wife was backing up in our driveway, and hit another vehicle parked in our driveway. The backup pre-collision system did not issue any warning, and did not stop the vehicle (as it is supposed to do).

The contact owns a 2020 Toyota Tacoma. The contact stated that while driving at 60 MPH, the vehicle inadvertently stalled temporarily. There were no warning lights illuminated. The contact was able to continue to drive the vehicle. The contact stated that the failure reoccurred for a second time while driving. The vehicle was taken to the dealer who diagnosed that no issues were found; however, the failure persisted. The manufacturer was notified of the failure but did not provide any assistance. The vehicle was not repaired. The failure mileage was approximately 5,000.

I recently changed tires from the factory originals. While tightening the lug nuts 4 wheel studs sheared off while tightening (2 on passenger front tire and 2 on passenger rear tire). In light of this issue I decided to replace all 12 wheel studs on the affected tires. The 8 remaining wheel studs that were still intact all had evidence of thread stretch visible to the naked eye.

A child infant passenger car seat was placed in the rear passenger center seat position. The the shoulder/lap-belt was used to install the car seat rear-facing. Once the install was complete. The shoulder belt was slowly pulled and extended all the way out. The purpose was to have the shoulder belt reach its maxed length. This would position the belt to be placed into retracting mode only. This would prevent the child or an infant to possibly extend the belt once its been retracted. This would minimize the free play with the belt such as being tangled with child's arm, head, body parts, and potentially becoming a choking hazard. The issue now, is the shoulder/lap-belt retracting mechanism is malfunctioning. The shoulder/lap belt is not retracting. Rather it is stuck and now the entire shoulder/lap belt is extended all the way out. There is no resistance in the seat-belt and cannot will not secure a rear passenger in the center seat position. The rear center seat does not have a working safety car passenger safety belt.

The contact leased a 2020 Toyota Tacoma. The contact stated that after driving the vehicle off the dealer parking lot, the brakes would pulsate upon depression without warning. The contact had taken the vehicle to the dealer on four separate occasions and had the brake drums replaced each time; however, the failure persisted. The manufacturer was notified, and the contact was informed that a service representative would contact him. The contact had not yet heard from the manufacturer. The vehicle was not repaired. The failure mileage was 1. The VIN was not available.

The contact owns a 2020 Toyota Tacoma. The contact stated while driving approximately 80 MPH, the brakes activated independent of the driver input and the vehicle slowed to 60 MPH abruptly. There was no warning light illuminated. The vehicle was not taken to a dealer to be inspected. The manufacturer was not informed of the failure. The failure mileage was approximately 20,000.