2008 Toyota Highlander

Defect. Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Risk. If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Remedy. SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

Defect. Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.

Risk. If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

Remedy. Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.

Defect. Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Risk. Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Remedy. SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

Defect. Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.

Risk. If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.

Remedy. Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.

Defect. Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.

Risk. If the switch overheats, it may melt, possibly resulting in a fire.

Remedy. Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.

Defect. TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.

Risk. INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.

Remedy. TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Defect. GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Risk. THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy. DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

Defect. SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Risk. A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy. DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

Defect. TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).

Risk. A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy. TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Defect. TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."

Risk. INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.

Remedy. TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.

Defect. SOUTHEAST TOYOTA IS RECALLING 3,499 STAINLESS STEEL EXHAUST TIPS SOLD BY SOUTHEAST TOYOTA AS AN OPTIONAL ACCESSORY FOR USE ON MY 2008 HIGHLANDER AND HIGHLANDER HYBIRD VEHICLES. DUE TO IMPROPER HEAT TREATMENT DURING THE MANUFACTURING PROCESS, THE ORIGINAL CLAMP USED TO SECURE THE STAINLESS STEEL EXHAUST TIP TO THE EXHAUST PIPE MAY DEVELOP MICROSCOPIC CRACKS. EVENTUALLY THE CRACK MAY EXPAND CAUSING THE CLAMP TO BREAK.

Risk. THE ORIGINAL CLAMP AND THE TOYOTA STAINLESS STEEL EXHAUST TIP MAY FALL OFF THE VEHICLE'S EXHAUST PIPE AND BECOME A ROAD HAZARD WHICH WOULD INCREASE THE RISK OF A VEHICLE CRASH.

Remedy. SOUTHEAST TOYOTA WILL NOTIFY OWNERS AND REPLACE THE CLAMP FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY/JUNE 2009. OWNERS MAY CONTACT SOUTHEAST TOYOTA CUSTOMER LOYALTY DEPARTMENT AT 1-800-301-6859.

Defect. TOYOTA IS RECALLING 39,100 STAINLESS STEEL EXHAUST TIPS SOLD BY TOYOTA AS AN OPTIONAL ACCESSORY FOR USE ON MY 2008 HIGHLANDER AND HIGHLANDER HYBRID VEHICLES. DUE TO IMPROPER HEAT TREATMENT DURING THE MANUFACTURING PROCESS, THE ORIGINAL CLAMP USED TO SECURE THE TOYOTA STAINLESS STEEL EXHAUST TIP TO THE EXHAUST PIPE MAY DEVELOP MICROSCOPIC CRACKS. EVENTUALLY THE CRACK MAY EXPAND CAUSING THE CLAMP TO BREAK.

Risk. THE ORIGINAL CLAMP AND THE TOYOTA STAINLESS STEEL EXHAUST TIP MAY FALL OFF THE VEHICLE'S EXHAUST PIPE AND BECOME A ROAD HAZARD WHICH WOULD INCREASE THE RISK OF A VEHICLE CRASH.

Remedy. TOYOTA WILL NOTIFY OWNERS AND REPLACE THE CLAMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 4, 2009. OWNERS MAY CONTACT TOYOTA CUSTOMER EXPERIENCE CENTER AT 1 888-270-9371 MONDAY THROUGH FRIDAY, 5:00 AM TO 6:00 PM, SATURDAY 7:00 AM THROUGH 4:00 PM PACIFIC TIME.

Defect. TOYOTA IS RECALLING 90,189 MY 2008 HIGHLANDER AND HIGHLANDER HYBRID PASSENGER VEHICLES EQUIPPED WITH A THIRD ROW SEAT. THESE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE NON-DRIVER DESIGNATED SEATING POSITIONS (DSP) ON THESE VEHICLES IS EQUIPPED WITH SEAT BELT ASSEMBLIES THAT HAVE A FEATURE THAT CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) TO AN AUTOMATIC LOCKING RETRACTOR (ALR). THE BELTS CONVERT TO THE ALR MODE AFTER THE WEBBING HAS BEEN FULLY WITHDRAWN FROM THE RETRACTOR. THE SYSTEM IS DESIGNED SO THAT AS THE BELT IS RELEASED INTO THE RETRACTOR, THE SYSTEM REMAINS IN THE ALR MODE SO THAT A CHILD RESTRAINT SYSTEM (CRS) CAN BE TIGHTLY SECURED.

Risk. HOWEVER, FOR THE TWO THIRD ROW DSP'S ON THESE VEHICLES, THE ALR MODE DEACTIVATES BEFORE THE WEBBING IS FULLY RETRACTED, SO THAT IT WILL NOT LOCK WHEN CERTAIN REAR-FACING CRS'S THAT HAVE A SHORT SEAT BELT ROUTING PATH ARE INSTALLED IN THE VEHICLE. THIS CAN ALLOW THE SEAT BELT WEBBING TO SPOOL OUT DURING NORMAL DRIVING MANEUVERS, WHICH COULD AFFECT THE STABILITY OF A CHILD RESTRAINT INSTALLED AT THOSE SEATING POSITIONS. AS SUCH, THIS COULD DISCOURAGE THE USE OF A CHILD RESTRAINT AND IN THE EVENT OF A CRASH, THE CHILD MAY NOT BE ADEQUATELY PROTECTED POSSIBLY RESULTING IN INJURY.

Remedy. DEALERS WILL INSTALL A NEWLY DESIGNED SEAT BELT COMPONENT FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT DECEMBER 18, 2008. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, …

On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information …

Region Email: Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for the Power Back Door on certain 2008 - 2013 model year Highlander and Highlander Hybrid vehicles.

Dealer Email: Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for the Power Back Door on certain 2008 - 2013 model year Highlander and Highlander Hybrid vehicles.

Region Letter email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop Technology on the below listed model and model year vehicles. This feature will cut engine power in case of …

Region Letter: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop Technology on the below listed model and model year vehicles. This feature will cut engine power in case of simultaneous …

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

TSB: Some 2008 ? 2010 model year Highlander Hybrid vehicles may exhibit a condition where the brake, ABS, and/or TRAC warning light(s) are on and/or a Check VSC message displays. Diagnostic Trouble Codes (DTCs) C1391, C1252, C1253, and C1256 may be stored. This condition may be caused by a small internal brake fluid leak inside the brake actuator. Follow …

We own a 2008 Toyota Highlander. The SRS airbag warning light on the dash is lit. It is a sensor issue that has been fixed once. It is a safety issue because, as I understand it, the airbags will not deploy when this warning light is on. I would like to know if this is an issue with other 2008 Highlanders. This has happened twice since we have owned the vehicle. The dealership fixed the issue the first time but has no record of the repair. This time the repair could be over $1000.00 for me to drive a safe vehicle. I believe this should be looked into to see if it is an issue with other 2008 Toyota Highlanders.

Odometer Fraud. The contact purchased a 2008 Toyota Highlander. It was discovered that there was a mileage discrepancy. The vehicle was a private sale. The contact stated that at the time of purchase the mileage was 106,000. After obtaining a Carfax report, the contact became aware that the mileage listed was 264,000.

The contact owned a 2008 Toyota Highlander. The contact stated that while driving at approximately 20 MPH, an abnormal, booming sound was emitted from the vehicle as heavy, black smoke entered her vehicle. Due to the smoke, the contact's vision became obstructed, and the contact immediately shifted into park and jumped out of her vehicle for safety. It was unknown if there were any warning lights. As a result, the contact injured her right hip and strained her vocal cords. The vehicle quickly became engulfed in flames as authorities were called to the scene. The fire department extinguished the flames as both a fire and a police report were filed. The vehicle was towed to an independent mechanic, where it was deemed a total loss. There was no property damage. The origin of the fire was unknown, and an investigation was opened by the insurance company. The contact sought medical attention the next day and was treated for the strain on her right hip. The manufacturer was notified of the failure, and the contact was given a case number. The contact was also informed that she would receive a response from them within 45 days. The vehicle was destroyed. The failure mileage was approximately 100,000.

THERE WAS NO INCIDENT. WHEN THE BRAKE MALFUNCTION SCREEN DISPLAYED, I DROVE THE VEHICLE TO THE NEAREST TOYOTA DEALER IN PUEBLO, COLORADO. I RECEIVED THE ATTACHED SERVICE MESSAGE AND PICKING TICKET; 17june2025. IT ALSO NEEDS NEW BRAKE PADS, ROTOR ADJUSTMENT, AND 5 NEW TIRES. TOTAL~$6000. WAY TOO PRICY! I PAID FOR THE DIAGNOSTIC TEST, AND DROVE HOME CAREFULLY! THE VEHICLE HAS BEEN SITTING IN MY CARPORT SINCE, AND I AM WALKING THE CITY LIMITS FOR ALL PURPOSES. THE 12V BATTERY DIED MID-JULY, WITHOUT REPLACEMENT SINCE. I LIVE IN LA JUNTA, 70 MILES EAST OF THE DEALER. SO WE'RE LOOKING AT 99,000 TOTAL MILES AS IT SITS.

My 2008 Toyota Highlander Hybrid is having severe issues with the ABS system. Toyota is reporting that it needs an ABS actuator and ABS pump replacements. These were a part of Toyota's previous Customer Support Program, but the program expired before I owned the vehicle. That is EXTREMELY dangerous and the issue with the ABS system should be considered a Safety Recall that is ALWAYS available to Toyota customers to rectify and paid for by Toyota. It is a BRAKING ISSUE. It is not just brake pads, or normal wear and tear. This is a known issue and regardless of the timeline, Toyota should absolutely pay for the repair.

The Intelligent power module failed on the vehicle. I read this is common for my vehicle however there is no recall matching my VIN. Vehicle was purchased out of state one year ago. We took the vehicle to a Toyota dealership who suggested I inquire about the issue because it’s possible this VIN should have been included.

Odometer Fraud. The contact purchased a 2008 Toyota Highlander. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 123,399, and at the time of registration, it was discovered that the mileage was 271,890.

Good Afternoon, The brake actuator and booster pump failed on my 2008 Toyota Highlander Hybrid. ABS, Brake, and VSC warning lights came on, and the brakes became weak and unsafe. A repair shop confirmed the issue with codes C1252, C1256, and C1391. I tried to fix it at a local shop last year, but the problem came back. It seems this repair can only be fully done at a Toyota dealer due to software requirements. However, the dealer repair cost is very high. I cannot afford the repair or a new car right now because of family budget limits — we have three children and rely on this vehicle every day(only one car). Toyota declined to help, even though I later found this issue was once covered under Program ZKC, which I missed. The vehicle is still unsafe and available for inspection. Thank you very much for considering my issue!

Brake actuator failure. Have to manually brake, stopping distance significantly increased. 3,145$ to replace at Toyota dealership.

In June 2019, Toyota issued a recall for ABS malfunction, diagnostic code C1391 - brake actuator and accumulator. New parts were issued by Toyota in 2019 as part of the recall. My vehicle experienced ABS malfunction, diagnostic code C1391 in March 2022 and was repaired by Toyota with the new and improved parts issued as part of the recall. As of October 14, 2024, my vehicle is experiencing the same issue again - ABS brake malfunction diagnostic code C1391, with the brake system light, master warning light, abs light and ABS Malfunction warning noted on the screen. The vehicle can be inspected. Toyota has inspected and confirmed it is the same issue again. The new and improved parts from 2019 should not fail within 20,000 miles. Toyota did confirm that they used the new parts issued as part of the recall and cannot explain why they failed faster than the original parts causing dangerous braking issues.

We were driving at about 40 MPH and approached our turn. When I depressed the brakes, they felt spongy and I had trouble slowing quickly. The yellow triangle illuminated on the dash and a long warning beep sounded. I was able to get safely parked in a parking lot, and my son came and took a look as well. We had the car towed to a shop, who diagnosed the problem, stating that we needed to replace the brake booster pump and actuator assembly. A family member noted that Toyota had issued a recall for vehicles with the same year/make/model for the braking system, so we had it towed to our local Toyota dealership to verify that they had no open recalls on the brakes and complete a full inspection otherwise. They validated that the brake booster pump and actuator assembly needed to be replaced. I am left wondering why my vehicle was not included in Toyota's recall.

There was a customer support program from Toyota for certain Highlander from 2008 to 2010. The deadline was in 2020. The same issue started for me three weeks ago. Local Toyota Service center confirmed that it is the same code and issue but quoted me over $3000 to replace the whole thing. Since Toyota admitted that this is a faulty part and had support program to replace the parts, there should not be expiration date on the support program. This issue can only be fixed by Toyota Service center since it requires specialized tool and software. Customer should not be forced to pay the excessive fees because Toyota used faulty parts in the beginning.

The brake pedal gave no resistance, going right to the floor. The ABS system warnings lit up on the dashboard at the same time. I was able to pull the car over safely, but it was not driveable and needed a tow to a repair shop. The repair shop noted that the brake actuator assembly and skid module failed and needed replacement. AFTER DOING RESEARCH WE ARE CONFIDENT THE ISSUE IS EXACTLY AS HUNDREDS OF OTHER OWNERS HAVE PREVIOUSLY REPORTED TO TOYOTA, BBB, AND NHTSA. TOYOTA HAS SINCE ISSUES RECALLS AND WARRANTY EXTENSIONS FOR THE OTHER TOYOTA HYBRID MODEL THAT UTILIZE THE SAME PLATFORM/SYSTEM BUT JUST NOT FOR THE LATER 2008 HIGHLANDER HYBRID. SOMEONE NEEDS TO STEP UP AND HOLD TOYOTA ACCOUNTABLE FOR THE SAME FAULTY PARTS THEY CONTINUED TO INSTALL IN THEIR OTHER HYBRID VEHICLES THEY SOLD TO CONSUMERS. THE ABS SYSTEM IS CLEARLY NOT FUNCTIONING PROPERLY AS HUNDREDS OF CONSUMERS HAVE PREVIOUSLY NOTED. WHY WOULD TOYOTA COVER THE COST OF REPAIR FOR OTHER HYBRIDS WITH THIS SAME DEFECT BUT NOT OTHERS? THERE NEEDS TO BE A RECALL OR WARRANTY EXTENSION ISSUED FOR THIS MODEL/YEAR AS TOYOTA HAS ISSUED FOR OTHER HYBRID MODELS USING THE SAME PLATFORM. THIS IS CLEARLY A WELL-DOCUMENTED PROBLEM FOR THE 2008 MODELS.

The ECU requires a reflash or replacement. The hybrid batteries over heat and regen braking randomly shuts off during braking or before/after due to overheating becuswe the cooling fans do not engage past level 1 or 2. The fans in fact never go full speed unless commanded by a Toyota service tech via the software during fan testing. Upon testing I noticed they not once went high enough to be audible and thus overheated. Manu forms indicate this is a common issue and requires 180-$300 for a reflash and/or replacement of the compu) ECU to alleviate this issue. Second issue I've found is the 3rd row seat belts just like some other MY Highlanders have their restraints cut at the shackle holding them to the body of the vehicle. I have seen several sheered this way including my own vehicle.

The engine burns Coolant and yet doesn't overheat. The engine on cyl 4 misfires. Changing the head gasket didn't repair the issue, replacing all fuel Injectors and ignition parts didn't either. Heads inspected and passed. Compression testing passed. Always misfires on cyl 4. No repair aside from an ecu reflash or replacement seems to be possible. 4 shops looks at it and couldn't find any reason why it was misfiring and no traces of water were found in the interior, on the floor, in the oil or exhaust in the cooling system.

Intermittent warnings "Check ABS", "Check Brake System", "Check VSC System" have been showing up on the vehicle display along with the brake and traction control warning lights. This has been happening on and off for several months. Diagnostic Trouble Code reader shows "C1391 Abnormal Leak of Accumulator pressure".

Myself, and many other 2008 Toyota Highlander Hybrid owners, have a vehicle code labeled C1391 "Leak in Accumulator" wherein the vehicles brake actuator and brake booster pump malfunction. The dash of my vehicle has the following indicators on; Check ABS, Check Brake System, Check VSC System, Yellow Master Warning Light, Red Brake System Light & Buzzer, Yellow ABS Warning Light, and Yellow Slip Indicator Light. This has been a significant cause of concern for me over the past two-three years since purchasing this vehicle. This is a known issue throughout the Toyota Highlander Hybrid community and the dealership is not upholding their previous recall which occurred in late 2019 and ended in 2020, after I had purchased the vehicle. The cost of repairs is upwards of $4,000 and Toyota has not given the proper opportunity for recall repairs to owners. This is a significant safety issue because if the brakes fail, a severe crash may injure myself or others. The problem has been reproduced by several other owners, dealerships, and independent service centers (this is a well known and common issue). This vehicle is available for inspection if requested. I plead that you please insist on Toyota reopening their recall to provide service to the owners of this vehicle, this is an issue with their manufacturing and not on the owners/operators. This problem occurred immediately after receiving scheduled maintenance to my vehicle from a certified Toyota Dealership, whom have quoted me the a

The contact owns a 2008 Toyota Highlander. The contact stated while driving at various speeds, the front end of the vehicle was making an abnormal clunking sound. The vehicle was taken to an independent mechanic, where it was diagnosed that the entire subframe was severely corroded and needed to be replaced. The vehicle was not repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 175,000.

I was in a car accident yesterday two cars hit me from behind my daughter was in the third row and my other kids in the second row. The air bags didn't deploy and my daughters seatbelt in the third row didn't lock when the cars impacted my vehicle her seat belt kept going forward with her. Also my seat belt unlocked and came off upon impact of car

Brought this sport utility truck from a dealership out of Sandersville, Geogia in 2018. Never had an issue with this vehicle. All services are done in the dealership. It previously has 168k mileage. I have always heard sounds from as i have learned is the ABS motor\pump system since purchasing the vehicle in 2018, but never any issues. Now November 2023 this ABS situation has my whole dashboard lit up. This got full attention due we were traveling when this occurred to us telling me to stop the vehicle, pull over, shut the car off and contact a dealer. We exited the freeway at a gas station to see what the matter was about. I didn't since any tightness in the brake pedal so I drove back home to be safe. Warning messages read: Check VSC System, BRAKE Malfunction, Cheak Brake , Check ABS. I have not been able to get it fix due to the cost of the repair on an issue Toyota already knew about. It's our brakes Toyota. Has money over ridden the performance of these vehicle's? Safety for the customer is first, I thought.

I own a 2008 Highlander Hybrid Limited. The ABS actuator and assembly have gone bad. The following dash lights are illuminated: ABS, VSC, brake warning, and parking brake. The issue has been confirmed by toyota dealer. This defect has been reported HUNDREDS of times and Toyota has yet to issue a recall for 2008 and above models. In 2019 there was a Customer Support Program Bulletin(CUSTOMER SUPPORT PROGRAM BULLETIN (ZKC): REPAIR COVERAGE FOR BRAKE ACTUATOR ASSEMBLY AND BRAKE BOOSTER PUMP ASSEMBLY ON CERTAIN 2008-2010 MY HIGHLANDER HYBRID VEHICLES) stating, " Toyota is providing coverage for repairs related to the certain internal malfunctions of the brake booster assemblies. One or more of the following specific Diagnostic Trouble Codes (DTCs) C1391, C1252, C1256 or C1253 will be stored in the vehicles memory to be used as verification." This 'customer support' bulletin was published June 6TH, 2019 and revised August 28TH, 2019. The bulletin continues, "Primary Coverage offers the Customer Support Program until December 31, 2020, regardless of mileage. After the Primary Coverage, the Secondary Coverage is applicable for 10 years or 150,000 miles from the vehicle’s date of first use, whichever occurs first." However, as this document clearly states that the affected and covered vehicles range from those manufactured in the years 2008-2010, the owners of a 2008/2009 model would only be eligible for primary coverage; allowing only about 1 year and 7 months for possible brake fai

This exact issue has occurred before and was already recalled and repaired. The issue is the brake system malfunctions and the vehicle information center states to take vehicle to dealership for repair immediately. Brakes can fail and multiple warning system are displayed.

Air bag lights continue to show. Vehicle had not been in any accidents. Seat warms do not work light comes on when you turn them on. Driver window will go up half way occasionally. Back wiper motor makes loud noise and doesn’t work anymore. Tire sensor also comes out.

My 2008 toyota highlander gas pedal must be lose.because I barley push the gas and it takes on fast.i was driving home on the highway and the truck just died .the battery dies I couldn't turn my wheel I could not press the break

I checked by local car repair shop found out failure code C1391. Mean- Brake Actuator Assembly fault. Recall program ended already by 2020. But is not my mistake, i every time on time change oil, tire, brake pads and do State inspection. this is Part defect from beginning some cars failing low mileage some failing after. This is whole part failure only by Toyota Hybrid vehicles. This repair only done by Toyota dealership because of Toyota software to install. Repair cost about 3500$ and i can't afford this repair cost i have 3 children 6years, 3years, 10 month old. Dangerous to drive with kids. Toyota USA already denied my request. Sincerly, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The Hybrid inverter failed on the car instantly stopping the car without any sort of warning what so ever. Car did not have a limp mode or any way to get the car off to the side of the road. It stopped in the traffic lane and had to be pushed out of harm's way. A search shows like it's becoming a common problem, $12,000.00 to fix it is another problem.

The contact owns a 2008 Toyota Highlander. The contact stated while driving at an undisclosed speed, the ABS and stabili-trak warning lights were illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The mechanic retrieved DTC: C1391, indicating that the brake actuator assembly was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the Extended Program had expired, and the contact was advised to call the NHTSA Hotline for assistance. The failure mileage was approximately 180,000.

Unable to buckle 3rd row passenger side seat belt buckle. Safety of my children were put at risk as I didn’t realize this until recently since our family grew. No warning indicating lights are on.

Airbag failed to deploy in a front-left collision with another vehicle. The other vehicle's airbags did deploy. The vehicle is totalled and not available for inspection. The lack of deployment resulted in a head injury and whiplash. There was no advanced warning of this being a problem.

All the lights relating to brakes and ABS flashed up on the dashboard. We continued home slowly. Upon investigation from a trusted mechanic it seems it is the brake actuator. From numerous reviews and complaints online this is a reoccurring issue with Toyota cars but recalls were only issued for 2006-2007 models even though the 2008 Highlander hybrids use the same part.

While driving the vehicle the back door and glass back panel sometimes release and open unexpectedly . I saw that a "service bulletin" was issued for a problem with the rear door, (T-SB-0091-12), but a dealership told me my vehicle wasn't "covered".

Needed to have hub and bearing and spindles replaced in front driver's side wheel (AWD). Repair shop completed repairs and aligned the vehicle. Computer needed to be reset after alignment. Shop followed reset instructions and vehicle then showed codes for the ABS system (ABS pump and actuator and skid control module). Repair shop cannot reset computer without replacing parts estimated cost is over $5,600. No work on brakes or ABS system was done. No errors or codes previously existed prior to replacement of bearing and hub. No codes existed until after the alignment was completed. ABS system no longer works. Repair was completed at an independent repair shop. Have appointment with dealership on 9/29 to see if code can be reset. These codes were an issue in 06-07 Highlander hybrids and Prius models and part of a recall.

ABS warning light at 118,000 7/8/2022 C1391 This is a known recall and problem on the earlier model Highlanders, as well as the second generation Highlanders, but not recalled as of today 8/19/22. It is a flawed ABS design and safety hazzard.

Brake system failed in hybrid and issue is well documented. Current lawsuits however not including this make/model.

Slowing down, but the car surged forward colliding into a building. The dealership only ran a .5 hour diagnosis and couldn't find anything. Did not proceed w/further diagnosis as did not want to pay out of pocket.

No nothing has been inspected I didn’t even know it had a recall all my lights on my truck are on now

This vehicle has had ongoing issues with the O2 sensors not working, I have researched online for years and have read that there are several online forums of 2008 Highlander owners complaining of the same issue. The problem that I (we all) face with this, is that it constantly fails, never being able to know if there is an actual issue becuase of the faulty sensors or wiring causing the sensors to go out. I am always frightened that something is wrong with the car and spent hundreds and continue to spend having my car checked. I am a single mom who lost my job at the beginning of the pandemic, I have two school aged kids. Having them in a car that I can not be sure we are safe in, is scary. The cost to replace the sensors as there are 3 that have been a constant pain of not working correctly is insane! It is going to be in upwards of $600 to repair! I absolutely can't afford that, being an unemployed single mother of two. Even when I was employed, living paycheck to paycheck to have to pay out almost a thousand dollars when from what I've read from others that replacing will still result in it failing again. So I have to drive around in a car that has all the sensor lights on, something really bad could happen to the car and since all the sensor lights remain on, I'll never know if something is wrong with the car- something bad could happen to me and my children while we are driving in the car. How can someone replace the sensors only for them to keep going out. This is a ser

ABS system failure for the second time after repair, cost $3400 to replace after causing complete loss of brakes. 4 years after incident same exact ABS warning and VCS system failure with message to immediately take vehicle to dealership. There is a class action lawsuit on other hybrid models but Toyota inspected and said it would cost another $3500 to fix because there is no recall on the part.

Chief complaint ISSUES were as follow : " BRAKE MALFUNCTION STOP The vehicle in a safe plase immediately and contact Dealer." Warning lights were illuminated on the instrument cluster or information display: yellow master warning light, the red brake system warning light and buzzer, yellow ABS warning light, yellow SLIP indicator light. After carefull diagnosis, it was determined that the brake booster pump was turning on frequently or working constantly. Unusual squeaky noise can be heard when depressing the brake pedal. In addition, the ABS Diagnostic Trouble Codes were identical as the problem. From research it should be noted. Toyota has previously identified and issued safety recall for the same vehicle however stopped short of including the 2008 Toyota Highlander hybrid model with the aforementioned Vin number.

The drivers door either locks or doesn’t when hitting the lock button it shake (unlocks an locks rapidly.

The radio started skipping and the DVD player won’t turn on

The driver door lock either won’t unlock or won’t lock it does a back n forth montion

When I started my 2008 Highlander Hybrid on Valentine’s Day and drove 3 car lengths from my drive way, my dash screen notified me with “Check ABS, Check Brake System, and Check VSC System” all with “Have your car checked by a dealer”. I reversed the car and returned to my driveway. My husband called a friend mechanic shop owner who ran the diagnostic report that showed a C1391code. I remembered I received a notification letter regarding this issue and called the dealer. Service agent indicated that without Toyota doing the diagnostic run on my vehicle, they could not give me any quote on the price, but notified me that the letter I received had expired on December 31, 2020 or 10 years or 150,000 miles. My Highlander had this alert screen notification at 144,000 miles. I was told I would be responsible for repair charges. Feeling very frustrated, I called the Toyota corporate number and spoke to a female who then connected me with a supervisor. I explained my experience and the representative explained the notification letter had expired and was unlike a recall, which was indefinite. I emphasized to him that since Toyota knew this was a problem, how could they put an expiration date on the failed Brake Booster Actuator Pump Assembly that they clearly knew was a brake problem. Furthermore, Toyota, which I have been a loyal owner of five vehicles, had only allowed one year + for their accountability to the fixing the brake assembly parts. This meant it was a luck of the draw dep

The Brake Actuator Assembly and Brake Booster Pump Assembly have failed on my 2008 Toyota Highlander Hybrid. As I understand, this is a common problem for my vehicle and Toyota has agreed to fix it if the mileage is under 150,000 miles (which mine is) AND the time since first use is less than 10 years (which is not the case.) For this safety issue, I think Toyota should be standing behind the safety of their vehicles and fix my brake pump. This is putting my family at risk. This issue has been confirmed by my local independent auto service company. The warning lights came on after the failure (brake, ABS, master warning, traction control).

The ABS ACTUATOR failed in my 2008 Toyota Highlander Hybrid. The screen inside the car flashed ABS // VSC // CHECK BRAKE SYSTEM. Vehicle is at 144,000 miles The component is out of stock nationwide and Toyota dealer has issued a warranty extension.

On November 26, 2021 my 2008 Highlander Hybrid started displaying Check ABS, Check VSC System, Check Brake System and Brake Malfunction, errors on the display screen. I could feel the the grinding noise and brake pedal seemed different than normal. The Brake Malfunction error was displayed with a warning to "Stop the vehicle in a safe place immediately, and contact a dealer". I bought a vehicle diagnosis code reader and it showed C1391 (Abnormal Leak in Accumulator Pressure). I received the same code late last year in 2020 and took my vehicle to dealer. They told me that I was not driving my vehicle due to pandemic and the 12V battery went bad. They removed the errors and I replaced the battery from Walmart. I did not see the error code again until now (after 1 year). I received a Customer Support Program Bulletin letter (POL19-06) from Toyota in 2019 or early 2020 which mentioned C1391 as a verification of problem in vehicle. I showed it to the dealership during my 2020 visit and they said my vehicle is not covered. I believed them since I did not see the error again after replacing the 12V battery. Now I am having the same problem again. The ABS error was displayed on 11/26/2021. I was able to read and reset the ABS error code C1391 on 11/30/2021. The ABS error showed up again on 12/2/2021 while I was driving the car with my family in it. I had to reset it to reach home safely. It ABS error came back ON again before reaching home. I am unable to get it fixed because the ext

On January 19, 2021, after driving for about two hours, I suddenly started to hear an unusual knocking noise from the engine. I slowed down, but I was unable to pull over immediately because I was driving on a very dark two lane highway, with no safe shoulder. After the same noise continued for about five to ten minutes, a light began to flash indicating extremely low oil pressure, and warning that the car should stop immediately. At that point, fortunately, I was able to pull over at a gas station, where I discovered that oil was gushing from my engine onto the ground. I checked my oil dipstick and noted that the car had no oil, and was thus inoperable. I was extremely concerned that the engine had been damaged while being driven with little to no oil. In 2014, Toyota issued a notice of a Warranty Enhancement Program – ZE2, related to extending warranty coverage for repairs related to a leaking or seeping engine oil cooler pipe. I never received any owner notification of this issue in 2014. Toyota refused to pay for the repair in 2021, and now in November 2021, the engine has quit due to the damage incurred in January 2021. The engine oil cooler pipe is defective and my family could have been seriously injured or killed by its catastrophic failure.

On September 25, 2021, my husband was driving our 2008 Highlander locally to the store. The low pressure light came on and said pull over immediately. He pulled over and and checked the oil dip stick and our car was totally out of oil. He also notice oil under our car and a line of oil going up the street. The following day, I contacted Toyota Experience Center and was informed their were no service campaigns on my Highlander. I had the car towed to my local mechanic and he verified that the car had no oil and replaced the failed oil cooler hose. My concern is that the oil cooler hose failed, draining all of the oil in minutes. I feel this is a safety issue because of how rapidly it occurred and If we couldn't immediately stop the car our engine could have seized up and made the car stop.

On approx. August 13, 2021, my 2008 Toyota Highlander Hybrid vehicle began making grinding sounds when the brake is fully depressed while the transmission lever is set to "drive". On approx. August 20, 2021, my vehicle started showing 4 error messages on the display: Brake Malfunction, Check ABS, Check VSC System, and Check Brake System. The Brake Malfunction error was displayed with a warning to "Stop the vehicle in a safe place immediately, and contact a dealer". At the same time, these 5 warning lamps became illuminated: Brake System Warning Light and Warning Buzzer (Red), Brake System Warning Light (Yellow), Master Warning Light (Yellow), ABS Warning Light (Yellow), and SLIP Indicator (Yellow). A car repair technician obtained the following error codes from the vehicle in a diagnosis: C1241 (Low or High Power Supply Voltage), C1253 (Pump Motor Relay), and C1391 (Abnormal Leak in Accumulator). I was informed that the VSC (vehicle stability control) safety feature of the vehicle is disabled while the error codes and messages are present. Toyota previously issued a customer support bulletin (No. POL19-06) on June 6, 2019, titled "Customer Support Program ZKC: Certain 2008-2010 Model Year Highlander Hybrid Vehicles Coverage for Brake Actuator Assembly and Brake Booster Pump Assembly". In the bulletin, Toyota acknowledged that its 2008-2010 Highlander Hybrid models had "certain internal malfunctions of the Brake Actuator Assembly". Affected error codes include C1391, C1252, C1

2008-2010 Toyota Highlander (hybrid, in my case) has an ongoing problem with the brake actuator and brake booster. In my case, within a year I will have had these items replaced twice. The cost to me will be about $3000. According to many website chats and blogs, this is a repeated repair even after having replaced it.