2025 Toyota Highlander

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2021-2025 Highlander and Highlander Hybrid vehicles. The second-row seat backs may fail to lock into position during seat back adjustment.

Risk. A seat back that fails to lock may not properly restrain an occupant during a crash, increasing the risk of injury.

Remedy. Dealers will replace the return springs in the seat back recliner assemblies, free of charge. Owner letters were mailed September 9, 2026. This is a phased recall. Owners may contact Toyota’s customer service at 1-800-331-4331. Toyota's numbers for this recall are 26TB06 and 26TA06.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2024-2025 Highlander and Highlander Hybrid vehicles. The third row center seat belt roof anchor may have been installed at an incorrect angle, preventing the seat belt from properly restraining the occupant.

Risk. A seat belt that does not properly restrain an occupant increases the risk of injury during a crash.

Remedy. Dealers will reinstall the seat belt anchor with a new bolt, free of charge. Owner notification letters were mailed January 27, 2026. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 25TA16.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2026 Toyota, Lexus, and Subaru Solterra vehicles equipped with a Panoramic View Monitor (PVM) system. Please see the recall report for a complete list of models. A software error may cause the rearview camera to freeze or display a blank screen when the vehicle is in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Risk. A rearview camera that fails to display an image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy. Dealers will update the parking assist software, free of charge. Owner letters were mailed January 2, 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB13 and 25LB06. Subaru's number for this recall is WRE25.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2024 Toyota Venza, 2023-2025 RAV4 Prime, RAV4, Highlander, GR Corolla, Crown, 2024-2025 Lexus TX, LS, Toyota Tacoma, Grand Highlander, and 2025 Lexus RX, Toyota Crown Signia, Camry, RAV 4 Plug-in Hybrid (PHEV), and 4 Runner vehicles. Due to an error in the instrument panel software at vehicle startup, the instrument panel may fail to display vehicle speed, brake system, and tire pressure warning lights.

Risk. An instrument panel display that does not show critical information can increase the risk of a crash or injury.

Remedy. Dealers will update the instrument panel software over-the-air (OTA) for non-PHEV vehicles, free of charge. For PHEV vehicles, dealers will inspect the instrument panel assembly, and either replace it, or update the software, free of charge. Owner letters were mailed December 5, 2025. Additional letters will be sent, anticipated in May 2026. This is a phased recall. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB08 and 25TA08. Lexus' numbers for this recall are 25LB05 and 25LA05.

I was backing up the vechial accelerated the steering wheel was turning rapid & a grinding noise causing me too hit another vechial about a month before my husband was driving & the vechial accelerated going toward also we had had some issues with back camera not doing a warning signal with a object behind vechial when the accident happened my vechial has braking system that stops you if something is behind you this time it didn’t I called the dealership when accident happed which was May 21 2026 & reported it they said they had accelerations before & advised me to call Toyota engadgment which I did they did a diagnostic test June 5 & to this day I’ve never heard back from them

[XXX] was turning left onto [XXX] from [XXX]. Two lanes turn left. She was in the inside lane. The traffic light was red, and when it turned green, she started to turn. Partway through the turn, the steering became unresponsive. She couldn't get it to turn left, and she could not complete the turn, and crashed into the pole that holds the traffic signal. She traveled less than 100 ft total from the light to the pole. The accident was at 1:30 PM on a dry and clear day. The car has 8087 miles on it. There were no observed indications of warning lights and no symptoms of a problem. The vehicle was towed to a salvage lot, the Insurance company inspected it and declared it a total loss. All the airbags went off. I mentioned to the adjuster that there was a mechanical problem, and he said they would not investigate that. [XXX] suffered a broken rib on her left side and has some serious cuts from the airbag below the dash, and of course, the seatbelt soreness. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2025 Toyota Highlander. The contact stated that while she and her husband were driving at 60 MPH, she heard a loud explosion noise from above her head and felt air whipping on top of her head. The contact stated that the sunroof exploded; however, the sunroof shield prevented the glass from entering the vehicle. The vehicle was steered to the side of the road and inspected, but the contact did not find anything wrong at that time. The vehicle was taken to a dealer where it was diagnosed that a rock may have hit the sunroof. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 8,498.

The speedometer registers speed up to 7mph over actual speed for the first 15 miles then returns to matching GPS speed. Reported to Toyota, dealer said they have seen this before but not identified a fix as of today

The contact owns a 2025 Toyota Highlander. The contact stated while driving at an undisclosed speed, there was an abnormally strong odor entering the cabin of the vehicle through the vents. The windows were rolled down due to the obnoxious odor. The vehicle was taken to the dealer and the contact was informed that the vehicle was tested for leaks in the exhaust; however, no leaks were found. The contact was informed that the fumes were possibly from burning wires or a new vehicle odor because the vehicle was a brand-new vehicle. In addition, the contact was offered the option to trade the vehicle in for a new vehicle. The contact stated that the odor was extremely strong and foul, and the odor stuck to clothing and the contact’s skin. In addition, the contact described the odor as an old lawnmower or snow blowing odor. The contact was advised by the state Attorney General Office of Illinois to contact NHTSA Hotline to report the failure. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 100. The VIN was not available.

I am reporting a safety defect in the 2025 Toyota Highlander Hybrid Nightshade involving the multifunction turn signal switch. The interior trim adhesive on the steering column has experienced a chemical breakdown (adhesive migration), causing the turn signal stalk to become stiff and bind. This obstruction makes it difficult to engage the turn signal and occasionally prevents the signal from "auto-canceling" after a turn. The dealership has acknowledged the adhesive failure by authorizing the replacement of the steering column covers but refuses to replace the contaminated turn signal switch. Operating a vehicle with a binding turn signal switch is a direct safety hazard, as it compromises the driver's ability to communicate intent to other motorists. Additionally, the dashboard material is experiencing systemic delamination and producing a white crystalline powder (crystallized adhesive). I am requesting an investigation into the heat-resistance standards of the interior bonding agents used in the 2025 Nightshade trim, as these materials are failing and compromising safety-critical electronic controls. Thank XXX XXX

Black Toyota Highlander Hybrid AWD 2025 ~15000 miles What component or system failed or malfunctioned, and is it available for inspection upon request? Without any warning, the braking action is delayed. It is a momentary loss and happens occasionally at light braking application, nowhere near hard enough to lock the wheels up The vehicle is available for inspection upon request How was your safety or the safety of others put at risk? If I were been closer to another vehicle/pedestrian/obstacle, an accident could happen Has the problem been reproduced or confirmed by a dealer or independent service center? No, yet, I will book an appointment to allow the dealer to verify the issue Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? NO Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? NO General: I have been driving the Highlander for a little bit more than a year, and this issue has happened at least 5 times, twice (2) this week

While waiting for a traffic light to change, I pressed the pedal to accelerate, and the car would not move. Like my pedal was dead. I have experienced this issue three times. I have also experienced bucking or jerking issues.

Passenger seat belt won't extend half of the time. We have tried with engine on or off, put it in park and in gear, door open or closed and every other trick. We have pulled the belt straight up and down and every other angle. We have adjusted the height for tall or short riders. We took to the auto dealership, and they said it would not work for them at first then it started to work. We have had riders in the passenger front seat ride with no seat belt on because they couldn't extend it and gave up. It should work every time there because it is a safety issue that should be fixed.