2011 Toyota Highlander

Defect. Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Risk. If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Remedy. SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

Defect. Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.

Risk. If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

Remedy. Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.

Defect. Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Risk. Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Remedy. SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

Defect. Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."

Risk. An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.

Remedy. Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Defect. Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Risk. If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Remedy. Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Odometer Fraud. The contact purchased a 2011 Toyota Highlander. It was discovered that there was a mileage discrepancy. The vehicle was a private sale but contacted by a dealer. At the time of purchase, the vehicle mileage was 122,000, and at the time of registration, it was discovered that the mileage was 303,000.

1. The 3.5L V6 Engine (2GR-FE) failed due to the subsequent loss of lubrication caused by the rupture of the Oil Cooler Pipe (Rubber component), a manufacturing defect known under TSB T-SB-0201-11 (ZE2 Program). The failed engine is currently available for inspection by request at the independent service center before it is disposed of. 2. The defect causes a sudden and severe loss of engine oil. This creates a high probability of the engine seizing (losing all power) while driving at highway speeds, resulting in a complete loss of propulsion and placing occupants at severe risk of collision. 3. The failure was confirmed, not reproduced. The vehicle was initially diagnosed with misfire codes (P0300, P0301). New spark plugs and ignition coils were installed in an attempt to resolve the issue. As the misfire persisted, the mechanic performed a compression test, confirming catastrophic zero compression failure in cylinders 1 and 2. Professional diagnostics then revealed critical codes: P1603 (ECM Malfunction), P1604 (Startability Malfunction), and P1605 (Rough Idling). These codes confirm a severe internal engine issue, consistent with permanent damage sustained during the oil loss event caused by the ZE2 pipe defect in July 2024. 4. No, not physically inspected by the manufacturer. The manufacturer (Toyota Executive Office Case Manager) was provided with certified documentation of the failure, including the photo of the faulty pipe, maintenance records during our ownership, and

Steering wheel air bag did not deploy in front end MVA

Our car had a major oil leak from the engine Oil Cooler Pipe Manifold at the bottom of the engine (front). My research has concluded that this has been a known issue with various Toyota models with the 2GR-FE engine, however Toyota has not issued a recall and the local dealership has never mentioned it during services. The NHTSA has known about this issue, however it appears that little to no action has been taken with the vehicle manufacturer or public. The issue concerns a leak that is waiting to happen on all engines with the original Oil Cooler Pipe as it is designed with rubber pipes that degrade over time and even a pin hole oil leak will cause virtually all the engine oil to drain from the engine onto the pavement below and underside of the vehicle including brake components. It is not a matter of “if” but “when” it will happen, and the consequences can leave people stranded with a damaged engine and undriveable vehicle. Severe injury and deaths can and will result due to the ongoing lack of action by the NHTSA and vehicle manufacturer. As an aside, the cost to repair is in the thousands of dollars, unless the owner is fortunate like myself who was able to replace the Oil Cooler Pipe at my own time and cost with the vehicle out of service and significant clean up required. I still don’t know the long-term effects of our engine being almost drained of oil and because of this may now sell the car which was not in our plan. I have added a photo of the original inadequatel

Dear Sir/Madam, I am writing to file a formal complaint regarding persistent safety issues with my 2011 Toyota Highlander V6 AWD. Specifically, I have experienced significant problems related to the engine timing guide, timing chain, transmission system, which pose a risk to both vehicle occupants and other road users. Vehicle Information: Toyota Highlander V6 AWD, VIN: [XXX] Description of the Issue: The transmission in my Highlander has exhibited the following problems: 1) Low engine oil pressure, ticking Noise: There is low engine pressure, faulty guides timing chains, recurring ticking noise. This noise represents issues from the powertrain area and has raised concerns about potential mechanical flaws1. 2) Defective components, slipping Transmission: The transmission surges/slips affecting overall control and safety. This issue has been reported by other Highlander owners as well. Cross-Referencing Other Complaints and Recalls: 3) They did not go far back, Per the NHTSA database, there have been two documented complaints related to transmission issues in the 2011 Toyota Highlander V6 AWD, these complaints align with my experience, however they have not sent me the recall notice. In fact, Toyota has faced recalls and technical service bulletins (TSBs) related to transmission problems in various Highlander models: The 8-speed UA80E/UA80F automatic transmission used in the 2020 Highlander received a TSB for shift flare during wide-open throttle acceleration from 40 – 60 mph

The intake VVT-i gear on 2AR-FE equipped Rav-4s and other Toyota models Has failed after 113k miles. The vehicle is at risk of causing self inflicted damage due to this common issue many toyota owners are facing 2008-2013 highlanders. The part has not been inspected but was diagnosed by a mechanic based on their past experience with these vehicles and sound. No warnings or dash lights just a terrible metallic rattle upon cold start. This started around 2k miles ago.

As my family was driving down Interstate 85 in Atlanta going around 80 MPH a dash notification came on that said "Low Oil Pressure pull over" the notification came on then went away then came back on (car never ran hot). Thankfully we were near an exit so we pulled off and into the first parking lot we could find. There was a huge puddle of oil under the car and smoke coming from the engine. We got our Highlander towed back to our nearest Toyota dealership to our home to be inspected. It was discovered our Engine Oil Cooler Pipe had failed resulting in all of the oil in our car being released from the car. If we hadn't been able to pull over so fast most likely my engine would have seized up and caused a wreck in the middle of the interstate. After doing research on this issue I discover there was a Warranty Enhancement Program done by Toyota on this very part valid through 2021 or 150,000 miles. I have 163,000 miles on my car. I tried to explain to Toyota that like majority of people my car was not driven for 2 years due to covid so they should at the very least expand the warranty. The dealership also told me they couldn't have replaces the part until it failed which from what I can tell of the hundreds of other Toyotas experiencing this same issue there are no warning signs prior to the part failing, you discover it failed by it releasing all your oil while driving at a high rate of speed.

Pin hole in oil line causing excessive oil leak. Loose oil very quickly. Could cause permanent damage to engine. Had old line replaced by mechanic with a metal line only inspected by my mechanic and there was mention of past recall by my mechanic but it does not show this on your sight. There was no warning lights at all. A coworker noticed excessive oil on the ground when I left work and called me immediately to check oil. Very little left in engine and I could see it coming from under car. Incident happen on 1-9-2023 Had car towed to mechanic to avoid damage to engine. My issue was there a recall at some point ? If other Toyotas are having this issue need to be addressed before cars blow there engines from no oil ! Since no warning lights came on I would have no idea I was losing oil this fast just driving down the road! I only knew because my coworker saw massive spill on concrete at work .

Clicking in steering column light comes on dash for power steering then hard to make turn then well go back off then able to make turns with ease again

In the last 30 days, the steering has begun to feel "loose", as if I am driving on ice. At first it was barely perceptable. There has been more "play" in the steering. During the last 2 days, the car is now making a thud when I am steering right. I have an appointment for a mechanic to look at it. The car is a 2011 Highlander, AWD, with 89,000 miles on it. I feel the steering issue could be very dangerous at some point.

The power steering is clunky, locks in position when backing out of a parking spot, is clunky and unreliable at slow speeds. I can feel the steering column get far tighter feeling when turning at slow speed (3-10 mph)

The contact owns a 2011 Toyota Highlander. The contact stated that the sun visors on the driver’s and passenger’s sides were hanging down and would not stay in the upright position. The contact stated that the sun visors obstructed her vision while driving at various speeds. The contact called the dealer and was informed that there was a recall on the vehicle for the sun visors; however, the recall had expired. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 108,000.

My 2011 Toyota Highlander is burning engine oil. So much that I almost got into a major accident on the highway. So what happens is the engine starts burning oil. When the oil level is low the Highlander gives a warning sign saying “low oil pressure” and then the SUV TURNS OFF automatically (even if you’re on the highway). Thousands of people have complained about this and Toyota is ignoring all the complaints. This issue should be a recall as this is a major problem with highlanders year 2008-2013

A very common problem and a very expensive fix. There is a rattling noise at cold startup that is coming from the engine. This is a very common problem and many people have complained about this. I don’t know why Toyota is ignoring it. I believe the problem is with the camshaft timing gear but I could be wrong. There should definitely be a recall for this issue!

While driving on the parkway, an oil pressure warning light came on and said to turn off the car. The car immediately started making noise so we pulled onto the shoulder and turned the car off. We were with our 3 children stuck on the side of the very busy road and had to wait for a tow truck. After having it towed our mechanic said it is a known problem with our car. The rubber oil line hose ruptured and we lost all of our oil immediately. The engine could have seized at any moment while driving. Toyota knows of this issue and has since changed it to a metal system but never did a formal recall for this issue. We are currently waiting for it to be fixed so I don't have a bill yet. This seems like something dangerous that could be avoided with a recall. Toyota will not fix this issue.

Abs brake actuator started to fail.

I was going about 40 mph on the Taconic Pkwy over the amvet bridge in the far left lane of the highway. Traffic was heavy and slowing down. It had st finished raining. I was hit on the rear right rear side by a F150 truck that caused me to slide into the guard rail on the left side of the road. The car spun out of control and slid three lanes and hit the guard rail on the right side of the road. Both front sides over the tail lights and the entire front were badly damaged. The side airbags activated but the front airbags failed to activate. Because of this failure I was badly injured. My head hit the steering wheel. I was not protected by the seat belt. My passenger and I had to be cut out of the vehicle. My neck sustained a dislocated disk and I still have pain going from my left shoulder, down my arm, into my hand. I suffered a permanent loss of vision in my right eye, a concussion and lacerations to my left hand and rear scalp. My iris in the right eye was severely damaged and still needs to be surgically repaired. I have suffered both physical and mental damages because of the failure of the seat belts to restrain me and the failure of the airbags to inflate.

A major and catastrophic oil leak occurred while the car was being driven by my wife on a major thruway during early morning rush hour traffic. The low oil pressure light came on and she was able to maneuver to a parking lot and shut the vehicle off. If the engine had seized due to oil starvation, she may have been involved in a serious accident or seeping oil may have potentially ignited causing a vehicle fire.

When driving approximately 20-30mph multiple warning lights illuminated on dash along with Brake Malfunction warning on information display. Did not notice any issues with braking and no fluid loss / leaks noted. Codes stored were C1241 (Low or High Power Supply Voltage), C1253 (Pump Motor Relay), and C1391 (Abnormal Leak of ACC Press). Noticed that ABS pump would run 2-5 seconds every 1-5 minutes. Original part number 44510-48080. Research shows multiple Toyota “Warranty Extensions” on multiple models using same/similar components.

The contact owns a 2011 Toyota Highlander. The contact stated that the intermediate steering shaft was making an abnormal knocking noise while turning to the left or the right. Additionally, the driver’s side window failed to roll up or down because it was off track. There were no warning lights illuminated. The vehicle was taken to the local dealer but was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 80,000.

The contact owns a 2011 TOYOTA Highlander. The contact stated while adding engine oil, the oil would leak from front section of engine. The contact stated that the oil pressure warning light was illuminated. The vehicle was towed to a local dealer where it was in the process of being diagnosed. The manufacturer was not informed of the failure. The failure mileage was approximately 161,000.

WHEN YOU TURN THE STEERING WHEEL AND THEN THE TURN IS COMPLETED...THE STEERING WHEEL DOES NOT GO BACK INTO POSITION. THIS OCCURS WHEN YOU ARE IN MOTION.

I HIT A CONCRETE POST AT ROUGHLY 30 MPH, DEAD CENTER FRONT OF VEHICLE. THE CAR WAS TOTALLED, AND NONE OF THE AIRBAGS DEPLOYED. I BROKE MY NECK DUE TO THE SEATBELT HOLDING MY CHEST AND TORSO BACK ON THE SEAT, WHILE MY HEAD MOVED FORWARD, ALL THE WAY DOWN AND HITTING THE STEERING WHEEL. THIS HEAD MOVEMENT RESULTED IN A COMPLETE BREAK OF MY C2 VERTEBRAE. THIS HAPPENED AFTER ENTERING THE LARGE AREA OF A WALMART PARKING LOT FROM THE HIGHWAY.

ENGINE OIL COOLER HOSE BURSTED AND LEAKED OIL EVERYWHERE ON THE HIGHWAY, ENGINE OVERHEATED..WAS ALERTED BY THE SYSTEM AS LOW PRESSURE ENGINE OIL WARNING. ROOM TO CAUSE SIGNIFICANT DAMAGE. NEED TO RECALL THIS.

TURNING ON THE REAR DEFROSTER WILL CUT POWER TO THE ENGINE AND DASHBOARD. TURNING OFF THE DEFROSTER WILL RETURN POWER TO THE DASH. THIS HAPPENS REGARDLESS OF IF THE VEHICLE IS STILL OR IN MOTION.

ENGINE OIL COOLER HOSE "LEAKING". TOYOTA DID ISSUE A TECHNICAL SERVICE BULLETIN, BUT WAS NEVER CHECKED DURING REGULAR DEALER SERVICING AS PART OF THE HOSES. CONDITION IS ON THE 3.5L TOYOTA/LEXUS ENGINE AND CAN BE SEEN IN THIS VIDEO:HTTPS://WWW.YOUTUBE.COM/WATCH?V=67S7Y90OTIY NEW PART NUMBER IS 15767-31020 WITH GASKETS 15185-0P010 AND 11496-31010.

TIRE LOSS OF TRACTION AND GRIP ON WET PAVEMENT.

I NOTICED IN NOVEMBER 2016 THAT THE PAINT ON MY 2011 TOYOTA ROOF WAS PEELING OFF. I TOOK IT TO A TRUSTED BODY SHOP AND THE OWNER ADVISED MY TO TAKE IT TO THE DEALERSHIP AS IT APPEARED TO BE A MANUFACTURER DEFECT. I DID AS HE SUGGESTED AND I WAS SUBJECTED TO MONTHS OF UNRESPONSIVE BEHAVIOR BEFORE I WAS FINALLY TOLD MY CAR WAS BEYOND THE 3YEAR WARRANTY THEREFORE NOT THEIR PROBLEM IN OCTOBER OF 2017. SINCE THIS TIME, THE PAINT FAILURE HAS PROGRESSED TO INCLUDE NEARLY EVERY PANEL ON MY VEHICLE. I HAVE ALSO LEARNED THAT TOYOTA IS RECALLING BLIZZARD PEARL VEHICLES DUE TO THIS EXACT PROBLEM BUT MY VIN IN NOT INCLUDED. I FEEL THIS NEEDS TO BE REMEDIED IMMEDIATELY AS THIS MANUFACTURER DEFECT GREATLY IMPACTS THE VALUE OF MY INVESTMENT. **I AM UNABLE TO ATTACH MORE THAN ONE PICTURE TO MY COMPLAINT. HOWEVER, I HAVE MULTIPLE PHOTOS AND SOME DAMAGE IS IMPOSSIBLE TO SUCCESSFULLY DOCUMENT BUBBLING PAINT. *TR

FOR SEVERAL MONTHS, THERE'S A THUMP WHEN TURNING THE STEERING WHEEL IN EITHER DIRECTION, NO MATTER WHAT ROAD/STREET. WE HAVE LESS THAN 43,000 MILES ON IT & DO NOT DRIVE ON RUFF TERRAIN. WE PURCHASED THE 2011 TOYOTA HIGHLANDER NEW, TAKE IT TO THE DEALER EVERY 6 MOS FOR MAINT. & NOW TOLD IT NEEDS A STEERING SHAFT REPLACEMENT & 4 WHEEL ALIGNMENT. ($657.33 TOTAL!) THIS IS INCONCEIVABLE TO PASS ON TO CUSTOMERS. AND A ROAD HAZARD TO ALL ON THE ROADS.

ON FEB 13, I WAS DRIVING AN ANN ARBOR, MI, STREET THAT WAS DOWNHILL AND ICY. I PRESSED THE BRAKE PEDAL UNTIL THE ABS CAME ON, AND HELD IT ON FOR 15 TO 30 SECONDS. THIS DID NOT STOP THE CAR, BUT SLOWED IT, AND ALLOWED ME TO GO STRAIGHT, UNTIL AFTER 10 TO 20 SECONDS, THE ABS STOPPED WORKING (NO MORE PEDAL PULSING, NO MORE ABS NOISE), THE WHEELS LOCKED UP, AND I SLID INTO THE CURB. FORTUNATELY, THERE WAS NO DAMAGE. A TECHNICIAN AT TOYOTA DEALERSHIP SAID IT IS NORMAL ON ALL VEHICLES FOR ABS TO STOP WORKING, AND FOR WHEELS TO LOCK UP, AFTER ABS OPERATES FOR A PERIOD OF TIME. THIS MAY BE WHAT I EXPERIENCED. HE SAID ONE SHOULD RELEASE THE PEDAL AND THEN REAPPLY PRESSURE, OR PUMP THE PEDAL. THIS SUGGESTION IS QUITE DIFFERENT THAN THE USUAL INSTRUCTIONS, WHICH SAY TO CONTINUALLY PRESS BRAKE PEDAL. HE HAD AN EXPLANATION, WHICH I CANNOT REPEAT -- SOMETHING TO DO WITH BRAKE FLUID DEPLETING SOMEWHERE, PERHAPS THE MASTER CYLINDER. THE ABS PROBLEM PROBLEM LIGHT HAS NOT COME ON. AFTER THAT INCIDENT, THE ANTILOCK BRAKES HAVE WORKED FINE, THOUGH I HAVE NOT TESTED THEM IN THE SEVERE CONDITIONS OF FEB 13. SINCE THE ABS SYSTEM SEEMS TO BE WORKING NOW, AND THE ABS LIGHT IS NOT ON, THERE APPEARS TO BE LITTLE CHANCE THE TOYOTA DEALER COULD DO SOMETHING USEFUL. THERE APPEAR TO BE TWO POSSIBILITIES: 1. THERE'S A PROBLEM WITH TOYOTA HIGHLANDER ABS SYSTEMS WHEN APPLIED FOR AN EXTENDED PERIOD OF TIME. NHTSA WILL BECOME AWARE OF THIS IF MORE OWNERS MAKE REPORTS. 2. THE TECHNICIAN IS CORRECT THAT AFTER ACT

CLUNKING AND CLICKING WHEN TURNING THE WHEEL. TSB FROM TOYOTA CALLS FOR INTERMEDIATE STEERING SHAFT REPLACEMENT, BUT TOYOTA WILL NOT WARRANTY REPLACEMENT OF THE FAULTY PART. HUNDREDS OF COMPLAINTS ONLINE WITH THIS SAME ISSUE.

I WAS PARKING MY CAR AT A PARKING LOT. I ATTEMPTED TO STOP THE CAR (IT WAS ABOUT 2MPH) WHILE APPLYING BRAKE AND MY CAR DID NOT STOP, RATHER IT ACCELERATED, I PUSHED BRAKE AND DID NOT WORK, IT JUMPED ON THE CURB. I RELEASED BRAKE, REAPPLIED AND CHANGED TO PARKING MODE IMMEDIATELY AND IT STOPPED. THIS ISSUE HAS HAPPENED THIRD TIME WITH THIS CAR. WHEN CAR IS ABOUT TO SLOW DOWN AND STOP, THAT TIME BRAKE DON'T WORK AND CAR ACCELERATE FURTHER. BRAKE PEDAL WAS VIBRATING WHEN IT WAS A SNOW ON THE ROAD WHEN I WAS TRYING TO STOP AT STOPLIGHT AND IT ACCELERATE. THIS IS VERY VERY DANGEROUS AND UNSAFE. I HAVE READ SEVERAL SAME COMPLAINTS ONLINE. THIS IS A DEFINITE MANUFACTURER DEFECTS AND MUST BE RECALLED IMMEDIATELY. LUCKILY SO FAR, I HAVE NOT HIT ANYTHING BUT NOW AFTER THE PARKING LOT INCIDENT I AM AFRAID.

DRIVING ON A CITY STREET AT ABOUT 35 MILES PER HOUR I WAS HEADING HOME WITH MY KIDS (5 Y.O. AND 7 Y.O.) WHEN THE VEHICLE DECELERATED AND LOST POWER WHILE I WAS DRIVING IN TRAFFIC, I WAS FORTUNATE THAT THE CARE ROLLED LONG ENOUGH TO PULL OVER TO A SAFE SPOT WITH MY CHILDREN AND CALL FOR A TOW. LIGHTS THAT CAME ON CHECK HYBRID SYSTEM, CHECK BRAKE SYSTEM, CHECK 4WD SYSTEM, AND THE CHECK ENGINE LIGHT CAME ON. AFTER THE VEHICLE WAS INSPECTED AT TOYOTA OF CERRITOS I WAS INFORMED THAT THE MASTER MECHANIC HAD TO PLACE A TICKET WITH TOYOTA MOTOR COMPANY TO FIGURE OUT THE ISSUE DUE TO ALL THE CODES THAT WERE LOGGED AFTER THE DIAGNOSTIC. TOYOTA MOTOR INFORMED MECHANIC IT WAS HYBRID INVERTER FAILURE. THIS COULD OF BEEN A HORRIBLE SITUATION HAD I BEEN DRIVING ON THE FREEWAY AND MY CAR SUDDENLY STOPPED FUNCTION LIKE IT DID ON THE EVENING OF 11/05/2019.

TL* THE CONTACT OWNED A 2011 TOYOTA HIGHLANDER. WHILE DRIVING ON THE HIGHWAY, THE VEHICLE HYDROPLANED AROUND A CORNER AND WENT INTO A SMALL EMBANKMENT. THE VEHICLE T-BONED THE CENTER BARRIER OF THE FREEWAY. NONE OF THE AIR BAGS DEPLOYED. MOST OF THE FRONT END WAS CRASHED IN AND THE DRIVER'S SIDE WAS SEVERELY DAMAGED. THE ENGINE AND RADIATOR WERE PUSHED FAR BACK FROM THEIR ORIGINAL POSITIONS. THE VEHICLE WAS TOWED AND INSPECTED BY THE INSURANCE COMPANY THEN BY AN INDEPENDENT MECHANIC. THE CONSENSUS WAS THAT THE VEHICLE WOULD BE DEEMED DESTROYED. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE CAUSE OF THE FAILURE WAS UNKNOWN. THE FAILURE MILEAGE WAS 150,000.

WHILE DRIVING ON THE HIGHWAY IN CRUISE CONTROL AND NO CHECK ENGINE LIGHT VEHICLE LOST POWER STEERING SPEEDOMETER READINGS. REPORTED ABS BRAKE MALFUNCTION, BRAKE MALFUNCTION. OVER THE NEXT 45 MINUTES WHILE IN ROUTE TO A TOYOTA DEALER VEHICLE INTERMITTENTLY LOST POWER STEERING AND SPEEDOMETER READINGS. ALL MALFUNCTIONS HAPPENED WITH NO WARNING.

STEERING SHAFT U JOINT MAKES CLUNKING NOISE. DEALER ADVISED IMMEDIATE REPLACEMENT AS THIS IS A SAFETY CONCERN.

THERE IS A PROBLEM WITH MY POWER STEERING WHEEL, IT'S STIFF AND I UNABLE TO CONTROL IT WHEN ON THE ROAD. WHEN DRIVING ON THE FREEWAY WITH HIGH SPEED, THE STEERING WHEEL SWAY LEFT OR RIGHT AND I UNABLE TO CONTROL IT BACK TO STRAIGHT. ALSO, WHEN MAKING A TURN THE STEERING WHEEL NOT REFLEXES, FAST ENOUGH FOR ME TO MAKE A TURN. FOR INSTANCE, WHENEVER I MAKE A RIGHT TURN AND THEN TRY TO STRAIGHTEN THE VEHICLE BACK TO STRAIGHT, THE STEERING WHEEL DOES NOT REFLEX BACK ENOUGH THAT IT LEADS ME TO HIT THE CURB DAMAGING FRONT WHEEL RIM. SINCE, THE PROBLEM KEEPS ON OCCURRING, AS I GET WORRIED I TOOK IT TO THE DEALERSHIP REPAIR SHOP TWICE WITHIN THE PERIOD OF 2 MONTHS. THE FIRST TIME, I TOOK IT IN THE MECHANIC STATES THAT PROBABLY HAS A PROBLEM WITH THE ALIGNMENT, SO I PAID THE FOR THE PERFORMANCE. AND IT DIDN'T HELP AT ALL. THEN THE SECOND TIME, I TOOK IT BACK TO THE DEALERSHIP REPAIR SHOP AGAIN, I TOLD THEM THAT THE ALIGNMENT DIDN'T HELP AT ALL AND ALSO I SPECIFY THAT THE PROBLEM IS THE STEERING WHEEL THEN I LEFT THE VEHICLE THE WHOLE DAY FOR THE REPAIR SHOP TO FIX IT. LATER, WHEN I WENT TO PICK IT UP, THEY STATED THAT THEY CORRECTED THE CRADLE AND DO THE ALIGNMENT 4 TIMES AND I TOOK THE CAR OUT HOME. THE VEHICLE STILL HAD THE PROBLEM THAT I HAD WHEN I TOOK THE CAR IN TO REPAIR, THEN I DROVE BACK TO THE DEALERSHIP AND TOLD THE MECHANIC. THEN THE MECHANIC DROVE THE CAR WITH ME IN THE CAR, AND HE TOLD ME THE PROBLEM IS THE ELECTRIC STEERING WHEEL AND THERE NO WAY HE COULD DO ANYTHING ABOU

MY 2011 TOYOTA HIGHLANDER V6 AWD SUFFERED A SUDDEN OIL COOLER PIPE FAILURE/RUPTURE LEADING TO CATASTROPHIC ENGINE FAILURE/DAMAGE AT APPROXIMATELY 85,000 MILES. THIS IS A KNOWN DEFECT WITH CERTAIN 2008-2011 HIGHLANDERS AND WAS THE SUBJECT OF A SERVICE BULLETIN AND EVENTUALLY A WARRANTY ENHANCEMENT (ZE2) STARTING IN 2014, BUT WE WERE NEVER NOTIFIED OF THIS ISSUE VIA MAIL OR BY THE TOYOTA DEALER AT WHICH THE VEHICLE IS REGULARLY SERVICED. THE VEHICLE WAS TRAVELING ON THE HIGHWAY WHEN THE PROBLEM OCCURRED. THE VEHICLE WAS THEN TOWED TO THE DEALERSHIP WHERE IT WAS FOUND THAT THE SUDDEN LOSS OF OIL HAD CAUSED CATASTROPHIC ENGINE DAMAGE DUE TO A BENT ROD FROM RUNNING WITHOUT OIL. AS THIS PROBLEM CAN LEAD TO MAJOR SAFETY ISSUES DUE TO SUDDEN LOSS OF POWER (NOT TO MENTION THE POTENTIAL FOR SEVERAL THOUSAND DOLLARS IN DAMAGE IF A COMPLETE ENGINE REPLACEMENT IS NEEDED) A MANDATORY RECALL SHOULD BE PERFORMED.

SINCE LAST YEAR, WHILE VEHICLE IS IN MOTION THE REAR HATCH SENSOR BEGAN GOING ON. LIGHT AND SENSOR GO ON WHEN THE TEMPERATURE OUTSIDE IS HIGH AND WHEN THE CAR IS TURNING. THIS IS ONLY FOR THE REAR HATCH. I HAVE RESEARCHED ONLINE AND SEE THIS IS A PROBLEM WITH THIS MAKE AND MODEL OF VEHICLE. THE ISSUE IS THE SENSOR CONNECTED TO THE HATCH LOCK. THIS IS A SAFETY ISSUE WHILE DRIVING.

FRONT PASSENGER AIRBAG LIGHT OFF. EVEN WHEN A PERSON IS SITTING ON THE SEAT. CRUISE CONTROL ALSO STOPPED WORKING, LIGHT WOULDN'T EVEN COME ON. POWER LOCKING SYSTEM ALSO CEASED WORKING.

I STARTED EXPERIENCING A CLUNK IN THE STEERING WHEEL COLUMN WHEN TURNING THE WHEEL TO THE LEFT FOR PARKING . IT HAPPENED A COUPLE OF TIMES SO I TOOK IT TO MY REGULAR TOYOTA DEALERSHIP FOR SERVICE. AFTER TEST DRIVING THE CAR THEY TOLD ME IT WAS THE STEERING INTERMEDIATE SHAFT THAT NEEDED TO BE REPLACED. I FELT I HAD NO CHOICE SO HAD THEM DO THE WORK AND IT COST $782.30 FOR PARTS / LABOR PLUS $134.95 FOR ALIGNMENT. TOTAL OF $917.25. I FOUND OUT THAT TOYOTA HAD ISSUED A TECHNICAL SERVICE BULLETIN #T-SB-0034-13 ON FEBRUARY 21,2013 SENT TO ALL TOYOTA REPAIR SHOPS ADDRESSING THIS ISSUE. THEY TOLD THE MECHANICS HOW TO REPLACE THIS EQUIPMENT AND THAT "A NEW INTERMEDIATE SHAFT HAS BEEN DEVELOPED TO ADDRESS THIS CONDITION". TO ME THAT MEANS THAT IN 2013 THEY KNEW IT WAS A DESIGN FLAW AND CORRECTED THE PROBLEM BY DESIGNING A NEW SHAFT. IF THEY HAD NOTIFIED THE 2008-2013 TOYOTA HIGHLANDER CUSTOMERS THEN THAT THIS WOULD BE AN ISSUE, MANY WOULD HAVE STILL BEEN UNDER WARRANTY AND IT WOULD HAVE BEEN COVERED. BUT INSTEAD THEY WAITED UNTIL PEOPLE HAD THE PROBLEM, BROUGHT THEIR CARS IN FOR REPAIR AND THEN CHARGED THEM WHATEVER THE GOING RATE IS. IN THE TECHNICAL SERVICE BULLETIN IS CLEARLY STATES THAT THIS WOULD BE COVERED UNDER A BASIC WARRANTY FOR TOYOTA. I SPOKE TO MY SERVICE ADVISOR AND HE REFERRED ME TO TOYOTA HEADQUARTERS. I CALLED THERE AND SPOKE TO TWO "SENIOR CUSTOMER ADVISORS" AND BASICALLY WAS TOLD I WAS OUT OF LUCK...NO RECALL, NO CAMPAIGN AND NO CUSTOMER REMUNERATION. WHEN I LOOK O

AT A STOP OR AT LOW SPEED STARTS, TURNING THE STEERING WHEEL RESULTS IN A CLUNKING OR CREAKING NOISE. THIS DOES NOT HAPPEN AT HIGHER SPEEDS. THE NOISE HAPPENS WHETHER TURNING IT LEFT OR RIGHT. USUALLY HEAR IT COMING OUT OF A PARKING SPOT OR MOVING FROM A STOP. IT HAS BEEN DOING THIS FOR A FEW YEARS.

REAR DOOR SENSOR IS DEFECTIVE. LIGHT EITHER STAYS ON AND GETS EXTREMELY HOT WHICH DRAINS THE BATTERY OR LIGHT AND BACK DOOR AJAR INDICATOR FLASHES AND SOUNDS SIGNAL BEEP ON AND OFF CONSTANTLY AS YOU DRIVE. I READ ONLINE THAT MANY OTHERS HAVE THIS PROBLEM. ONE SOLUTION IS TO CUT WIRE, BUT THAT IS UNSAFE AS YOU COULD BE DRIVING WITH AN OPEN DOOR AND NOT KNOW IT.

TL* THE CONTACT COMPLAINED ABOUT A 2011 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE THE DRIVER WAS DRIVING ABOUT 60 MPH, THE VEHICLE CRASHED INTO THE VEHICLE IN FRONT WHICH STOPPED ABRUPTLY. THE AIR BAGS DID NOT DEPLOY AND THE SEAT BELT DID NOT LOCK IN PLACE (STAYED LOOSE). THERE WAS NO WARNING. THE DRIVER SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE CONTACT WHO WAS AN INDEPENDENT MECHANIC STATED THAT THE VEHICLE WAS TOTALED. THE VEHICLE WAS TOWED TO A BODY SHOP. THE DEALER AND THE MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 180,000.

THE ELECTRIC DOOR LOCKS HAVE FAILED AGAIN FOR THE THIRD TIME. I HAVE HAD ALL 4 DOOR LOCKS REPLACED, SOME TWICE, AT CONSIDERABLE EXPENSE. THE DRIVER'S DOOR LOCK AND THE DRIVER'S-SIDE REAR DOOR LOCK ARE NOW BROKEN AGAIN. THE DRIVER'S DOOR LOCK DOES NOT OPERATE ELECTRICALLY AT ALL AGAIN. THIS MEANS I MUST PULL THE MECHANICAL KEY OUT OF THE KEY FOB TO UNLOCK THE DOOR. WHEN THE CAR IS PLACED IN DRIVE, THE DRIVER'S DOOR REMAINS UNLOCKED, AS DOES THE DRIVER'S-SIDE REAR DOOR - A SERIOUS SAFETY ISSUE SINCE THEY ARE SUPPOSED TO LOCK AUTOMATICALLY, AND THEY WILL NOT LOCK MANUALLY WITH THE ELECTRIC DOOR LOCK SWITCH LOCATED ON THE DRIVER'S DOOR - I HAVE TO MANUALLY PUSH THE DOOR LOCK LEVER MECHANICALLY. I AM VERY DISAPPOINTED IN TOYOTA. THE PROBLEM LIES WITH THE CHEAP SOLENOIDS/MOTORS THAT ARE USED TO ACTUATE THE DOOR LOCKS - A DEVICE THAT COSTS LESS THAN $5 ON AMAZON, BUT IS DIFFICULT TO INSTALL FOR US NON-MECHANICS. I HAVE HEARD OF THE SAME PROBLEM HAPPENING WITH OTHER CAR MANUFACTURERS AS WELL.

WHEN TURNING OR OVER BUMPS THE STEERING COLUMN MAKES CLUNKING NOISE. HAS BECOME LOUDER WITH TIME

DRIVER SIDE SUN VISOR STUCK IN DOWN POSITION, AND WILL NOT MOVE UPWARD OUT OF THE WAY, OBSTRUCTING DRIVER'S VIEW. IT CAN BE MOVED TO THE SIDE WINDOW, BUT THEN THE SIDE VIEW IS OBSTRUCTED. I HESITATE TO TRY AND FORCE IT UP, BECAUSE IT FEELS LIKE IT WOULD BREAK AND JUST FLOP AROUND. RESEARCHING THE PROBLEM, I HAVE LEARNED OF MANY OTHER OWNERS OF SIMILAR-VINTAGE TOYOTA HIGHLANDERS WHO HAVE EXPERIENCED THE SAME PROBLEM. THE TOYOTA DEALER QUOTED OVER $300 TO REPLACE WITH A NEW PART. THIS IS SAFETY ISSUE THAT SHOULD BE RECALLED BY THE MANUFACTURER.

THERE IS A KNOWN DEFECT IN TOYOTA HIGHLANDERS (2010 - 2013) SUN VISORS. THE VISOR NO LONGER STAYS IN EITHER THE UPRIGHT OR DOWNWARD POSITION. IT IS EITHER AT A 45 DEGREE ANGLE WHEN PLACED IN THE "UP" POSITION OR IS IN A POSITION TO SLIGHTLY OBSCURE VISIBILITY IN THE "DOWN" POSITION. TOYOTA OFFERED A WARRANTY ENHANCEMENT (LETTER ZF1) HOWEVER I AM NOW PAST THE EXTENDED WARRANTY PERIOD. THIS IS A HAZARD IN DRIVING AND WOULD BE HAZARDOUS TO THE DRIVER SHOULD THERE BE AN ACCIDENT - THE VISOR WOULD HIT THE DRIVER IN THE FOREHEAD OR FACE SHOULD THERE BE AN IMPACT.

AT AROUND 90,000 MILES I NOTICED A DISTINCT CLUNK IN THE STEERING AS THE WHEEL UNWOUND FROM SHARP TURNS AT SLOW SPEED. THE CLUNK ALSO SHOWED UP WHILE DRIVING STRAIGHT ON ROUGH ROADS AND UNDER FIRM BRAKING. THIS IS APPARENTLY A KNOWN ISSUE HTTPS://STATIC.NHTSA.GOV/ODI/TSBS/2013/SB-10075792-2280.PDF. I HAVE HAD THE PART REPLACED WITH THE UPDATED VERSION, AND THE STEERING IS NOW GOOD AGAIN, BUT I EXPECTED SOMETHING LIKE TO BE COVERED IN A SAFETY RECALL.

SUN VISORS WILL NOT STAY IN UPRIGHT POSITION.