2024 Ford Expedition

Defect. Ford Motor Company (Ford) is recalling certain 2018-2024 Expedition vehicles. The chrome plating on the center console may bubble and peel, resulting in sharp edges.

Risk. Vehicle occupants may contact the center console's sharp edges, increasing the risk of injury.

Remedy. Dealers will inspect and replace the center consoles as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 16, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S38. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 10, 2026.

Defect. Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

Risk. Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.

Remedy. The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.

Defect. Ford Motor Company (Ford) is recalling certain 2022-2024 Navigator and Expedition vehicles. The front brake lines may contact the engine air cleaner outlet pipe and become damaged, possibly resulting in a brake fluid leak and reduced brake function.

Risk. A loss of brake function increases the risk of a crash.

Remedy. Dealers will inspect the front brake line and replace the brake line or air cleaner outlet pipe, as necessary, free of charge. Owner notification letters were mailed May 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S47.

Defect. Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.

Risk. A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy. The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.

Defect. Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, Expedition, and 2024 Lincoln Navigator vehicles equipped with 3.5L GTDI engines. The engine may have a misaligned engine cup plug, which can result in a rapid oil leak.

Risk. A rapid oil leak can result in an engine stall, increasing the risk of a crash. In addition, an oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Remedy. Dealers will inspect the engine cup plug alignment, and replace the plug if necessary, free of charge. Owner notification letters were mailed May 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S30.

Defect. Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, 2024 Expedition and 2024 Lincoln Navigator vehicles equipped with a 3.5L GTDI engine. The engines may have a misaligned engine cup plug, which can result in a rapid oil leak.

Risk. A rapid oil leak can result in an engine stall, increasing the risk of a crash. In addition, an oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Remedy. Dealers will inspect the engine cup plug alignment, and replace the plug if necessary, free of charge. Owner notification letters were mailed on May 23, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S70.

Defect. Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk. Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

Remedy. Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

I recently discovered that the car seat harness is fraying on both sides. This is near the base (by hips of child in seat) where they enter the cushion and connect to the car seat. I think this is a defect and poses a risk, especially if I were to get in an accident. When I submitted a complaint with photos to Baby Jogger they replied "After reviewing the concern, please note that fraying is not considered a manufacturing defect. Fraying occurs gradually through normal use and wear over time rather than from a single incident and should be addressed before it gets worse. As a result, this type of condition is not covered under our warranty policy." They did offer a whopping $100 off an item over $500. In my opinion this should be remedied by the vendor.

The contact owns a 2024 Ford Expedition. The contact received notification of NHTSA Campaign Number: 26V368000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Intermittent warning of front camera collision / braking malfunction. Usualy less then 10 seconds but on one occassion persisted for about 10 minutes. Has been to dealership for investigation without resolution. Happened last on 7/16/2026. Arrived at dealership withing 20 minutes, they were able to call up the alert on there service advisors computer but could not do further investigation at the time. Vehicle is again scheduled to go to dealership on 3 August 26. Prolonged alert was 6/2/26, immeadiatly went to dealer (within 3 miles) vehicle into dealer fror a week on 7/6/26 without resolution

The contact rented a 2024 Ford Expedition from Enterprise Rent-A-Car. The contact stated that while the vehicle was parked and occupied, the contact was informed by his grandson that the seat belt was not operating properly. The contact inspected the seat belt and became aware that the third-row seat belt rear passenger’s side seat belt buckle assembly was damaged. Neither a dealer nor an independent mechanic was contacted. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure, and no assistance was provided. The failure mileage was 80,240.

Forward collision system does not work or alert under any circumstances. Vehicle has forward collision mitigation as well as collision mitigation alerting, but neither systems work. Dealer able to verify these systems do not work, but have no recourse for repair, as Ford engineering has not provided a solution.

Incident happened 06/26/2026. My wife was driving with our 4 kids down the highway to family event. My wife smelled a funny odor coming from the vents and was going to drive to the next exit and then noticed smoke. At that moment she wasn’t sure where the smoke was coming from. She put the hazards on and started pulling off to the shoulder thinking possibly it was the radiator. She came to a stop and called me (husband) that something was wrong with the vehicle. She was going to leave the kids in the car, get out and check the radiator. That’s when smoke started coming in through the air vents. She didn’t want the kids to breath in the smoke so they exited the vehicle, that’s when she noticed a fire under the engine. At that point a state trooper arrived on scene. He checked on my wife and kids and brought them back to his patrol car. The trooper went back to the vehicle to grab the baby’s diaper bag and wife’s purse. The trooper tried to extinguish the flames but the front of the vehicle was well involved already. Within 10-15 minute from my wife stopping the whole car was burnt to the ground and nothing left of the car. Looking back my wife only had a couple minutes to get to safety, had they lingered before getting out of the vehicle this could have been a tragic fatality incident. Our children do not feel safe riding in a vehicle since the incident happened. The safety of the trooper on scene was at risk helping get everyone to safety. It seems that something on the engin

The spring for the door for the 4-flat trailer plug on vehicle is too powerful. This resulted in the door wearing away at the trailer plug and has resulted in the wires of the trailer light plug breaking. This is available upon request. It puts our safety at risk as our trailer lights can go out and result in less information for other drivers, possibly resulting in a rear-end crash. The problem has not been reproduced, and has not been inspected. The only symptom of the problem in the vehicle is it telling us the trailer was disconnected. The trailer was a 2020 Malone microsport trailer.

Several of automatic sensors were not working (tire pressure) and the horn. The dealer stated I had road damage and wires were torn loose. I'm a 76 year old woman and I do not take this car off road or have any recollection of such an incident. I maintain the underside of the vehicle is improperly protected. They charged me $2300 to fix it.

No accident, malfunction, warning lights, or safety-related issues occurred. Vehicle is operating normally at this time.

The third row seats both have reachable access to the third-row PowerFold buttons even in car seats. My two toddlers can easily reach the fold buttons while strapped in to their seats and are able to recline and move their seats forward and backwards. This caused major safety hazard because their car seats become loose. The buttons are placed very close to the third row seat and are accessible to 35 lb children to press and play with them. While strapped into their car seats, my children easily reached and both touched the buttons and loosened their car seats while the car was in motion and I was driving. There is no software setting or built-in dashboard switch to disable the third-row PowerFold buttons in a Ford Expedition. To prevent the seats from accidentally folding, the most effective permanent solutions are removing the associated fuse, disconnecting the physical wiring harness from the button panel, or physically blocking the switch. This is extremely dangerous and needs to be fixed

Transmission failure. Vehicle has failed to accelerate and then failed to move at all. Still under warranty and no codes shown. Vehicle left immobile on interstate due to intermittent transmission failure. Initial repair was not sufficient as issue has returned. No solutions for additional repair to address safety issue.

This is a report of a recurring, life-safety defect involving unintended vehicle movement in a 2024 Ford Expedition. The vehicle has experienced two separate incidents where it was placed in 'Park,' remained stationary for 13-30 seconds, and then began driving itself backward without driver intervention or throttle input. Incident 1: Occurred on March 29, 2026 and I have this one on video. Incident 2: Occurred on April 8, 2026. The video clearly shows the vehicle remaining stationary and in 'Park' for 13 seconds before the unintended movement begins. This delay proves the movement is not a 'start-up rocking' sensation or 'normal clutch drag,' but a delayed mechanical or electronic failure of the park actuator or transmission system. I presented the vehicle for service at a Ford dealership on April 17, 2026. Despite my report of a delayed-onset rollaway, the dealership documented the issue as a 'normal and desired characteristic' of the 10-speed transmission. They characterized the event as a minor 'rocking' sensation that occurs immediately, which is factually contradicted by my video evidence showing a 13-second delay. This leaves me with an unsafe vehicle prone to unintended movement. I am requesting a formal investigation into a potential park-engagement failure.

Since I purchased the vehicle brand new, none of the safety features have been functional. The following sensors are faulty and none of them have worked since I bought the vehicle: 1) Cross Traffic Alert; 2) Blindspot System Fault; 3) Pre-Collision Assist; 4) Front Camera Fault; 5) Parking Sensor Fault; 6) Lane Keeping Assistance. I tried to take the vehicle into the service department of the dealership to fix the problem several times, but as of this time, there has been no solution. The dealership said the problem cannot be fixed, because only Ford Corporation can create a computer software fix for the problem. I was instructed by the dealership not to bring the vehicle back for the same issues, because nothing can be done, and they will not touch it. However, Ford has failed to launch a computer software fix, since I had had the vehicle to 2 years. Since the dealership can't fix it and Ford can't fix it, I am stuck with a defective vehicle that is "Unsafe" to drive, because all of these safety features that are not functional help prevent and reduce the probability of motor vehicle accidents. Ford is refusing to help me and rejected my claim even though they can't fix it.

I bought this vehicle brand new in 2024 and none of the safety features are functional and can't be fixed. Ford corporation cannot find a a computer software fix for it and the dealership can't fix it. The vehicle in unsafe to drive. The following sensors are faulty and have continued to give failure alerts since I purchased the vehicle: 1) Cross Traffic Alert; 2) Blind Spot System Fault; 3) Pre-Collision Assist; 4) Front Camera Fault; 5) Parking Sensor Fault; 6) Lane Keeping Assistance, 7) Rear backup assistance. It is a safety hazard and unsafe to drive because none of the "Safety Warning" or "Driver Assistance" features work, that would help prevent accidents. For the past 2 years, I have been driving this defective vehicle that is a safety hazard, which is not repairable, nor is the vehicle marketable. I have tried to resolve this issue numerous times, but there is no solution. The dealership advised me to not bring it in for service again, because there is nothing that can be done. I tried to file a claim with Ford Corporate and requested they buy the vehicle back, because it meets the criteria and the elements under the Texas Lemon Law, regarding electrical and safety concerns. However, my claim was rejected. As of right now, there is no solution for this issue.

I have had my car at the dealership twice, once in August of 2025 and once in February of 2026 because when I start I get a warning, front collision assist malfunction, lane keep assist malfunction, blind spot monitoring malfunction, and as a result, I have no cruise control, even in normal cruise control mode. I have been told it’s an electrical update, and it was October, then January, now it’s March. Just saw a recall was issued for Navigator, Nautilus, Aviator, and Explorer with this exact problem, but no recall for the expedition.

Bought the car on Feb 14th 2026. We were told Avis car sales in fontana does their vehicle inspection on every car before its sold. We noticed the two back tires on the expedition were bald and showing cords. We told Tawnya and George about the tires and they said they would order them, they'd be in within two days and to bring the car back to get them replaced. When we got home we setup ford diagnostics and found out the oil life was at 29% so they also lied and sent us out with bad oil. We checked the dip stick and yeah super dark oil. We've called two days in a row and keep getting told they are busy and they will call us back, they have not. We have tried to reach corporate but they dont have a department for this. The vehicle is currently sitting because of how bad the tires are, its 100% not safe to drive. Trying to get the dealership to honor the safety fix they promised but they are avoiding it.

The rear portion of the panoramic moonroof shattered spontaneously while the vehicle was being operated, without any impact or external cause.

On Monday, January 12, I was driving down the highway with 2 of my coworkers, when all of a sudden there was a loud pop and glass shattered. My sunroof had exploded. It was a sunny clear day, there were no vehicles in front of us and we were not going under an overpass. We pulled over to take pictures and drove the vehicle straight to Ford. We have since read that this type of incident has occurred before with multiple other Expeditions.

My wife tried to move my expedition from spot to another in our parking lot During that maneuver the gas pedal assembly broke down and the car in high speed created some personal and property damages I have the part handy and ready for inspection up on request The insurance knows about it And I had a police report No warning prior to the incident

Vehicle was driving approximately 65 miles per hour on interstate. Upon crossing a bridge the sunroof exploded sending glass flying inside the vehicle. The vehicle was equipped with a dash camera which also captured audio. No external object struck the vehicle. Two children and an adult in the vehicle were struck with flying glass. The video has been saved and can be provided in addition to the pictures.