2022 Ram 2500

Defect. Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 1500, Ram 2500, Ram 3500, Ram 4500, and Ram 5500 vehicles. The steering column control module may cause the driver's side air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk. A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.

Remedy. Dealers will replace the steering column control module, free of charge. Owner notification letters were mailed beginning December 11, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 14C. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning November 13, 2025.

Defect. Chrysler (FCA US, LLC) is recalling certain 2021-2022 Dodge Durango, 2021-2023 Chrysler Pacifica, Jeep Grand Cherokee L, 2022 Ram 1500, 2500, 3500, Chrysler Voyager, 2022-2023 Jeep Compass, Grand Cherokee, Wagoneer, Grand Wagoneer, and Ram Promaster vehicles. The radio software may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk. A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash.

Remedy. Dealers will update the radio software or the software will be OTA, "Over-The-Air," free of charge. Owner notification letters were mailed beginning July 9, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's numbers for this recall are 66B and 79B.

Defect. Chrysler (FCA US, LLC) is recalling certain 2022 Dodge Durango and Ram 2500 and 3500 vehicles. Due to a software malfunction, the ABS control module may disable the electronic stability control system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."

Risk. Driving with a disabled electronic stability control system can increase the risk of a crash.

Remedy. Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed beginning July 11, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 55B.

Defect. Chrysler (FCA US, LLC) is recalling certain 2022-2023 Ram 1500, Ram 3500 Cab Chassis with GVWR less than 10,000 lbs., and 2022-2024 Ram 2500 vehicles. The radio software may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk. A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.

Remedy. Dealers will update the radio software, free of charge. Owner notification letters were mailed October 24, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 97A.

Defect. Chrysler (FCA US, LLC) is recalling certain 2021-2023 Ram 2500, 3500, 3500 Cab Chassis, and 4500, 5500 Cab Chassis vehicles equipped with a Cummins 6.7L Turbo Diesel engine. An electrical short may occur in the heater grid relay with the ignition on or off.

Risk. An electrical short in the relay can result in an engine compartment fire with the ignition on or off, increasing the risk of injury.

Remedy. Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the relay, free of charge. This will be a Phased campaign. Phase 1 will include 2023 model year vehicles. FCA US will notify dealers on or about 3/23/2023 and begin notifying owners on or about 4/5/2023. Phase 2 will include 2022 model year vehicles and Phase 3 will include 2021 model year vehicles. FCA US will notify dealers and owners on or about 4/27/2023 for Phase 2 and 5/11/2023 for Phase 3. Interim owner notification letters informing owners of the safety risk were mailed March 28, 2023. Owner notification letters are expected to be mailed April 5, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 13A. This recall is an expansion of and supersedes recall number 21V-798.

Defect. Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 1500, 2500, and 3500 pickup trucks. The tailgate may not latch properly due to misaligned tailgate strikers, which could result in the tailgate opening while driving.

Risk. An unintended tailgate opening while driving may result in a loss of unsecured cargo, possibly creating a road hazard and increasing the risk of a crash.

Remedy. Dealers will inspect the tailgate striker alignment to the box latch and adjust, if necessary, free of charge. Owner notification letters were mailed December 22, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is ZB8.

Defect. FCA US, LLC (Chrysler) is recalling certain 2020-2023 Ram 2500 and 2020-2022 Ram 3500 vehicles. A build-up of pressure and heat inside the transmission may result in a transmission fluid leak from the dipstick tube.

Risk. Leaking transmission fluid may contact an ignition source within the engine compartment, increasing the risk of a fire.

Remedy. Dealers will replace the transmission dipstick and transmission vent assembly, free of charge. Owner notification letters were mailed December 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. Chrysler's number for this recall is ZA3.

Defect. Chrysler (FCA US, LLC) is recalling certain 2022 Ram 3500, 3500 Cab Chassis, Ram 2500, and 4500 and 5500 Cab Chassis vehicles equipped with Cummins 6.7L turbo diesel engines. The engine control module (ECM) may have been built with a misaligned capacitor that can short-circuit, resulting in an internal loss of communication.

Risk. An internal loss of communication can result in a loss of drive power, increasing the risk of a crash.

Remedy. Dealers will replace the ECM, free of charge. Owner notification letters were mailed October 20, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z87.

Defect. Chrysler (FCA US, LLC) is recalling certain 2022 Ram 1500, 2500 pickup trucks, and 3500 Cab Chassis vehicles with GVWR less than 10,000 lbs. The radio software may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk. A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.

Remedy. Dealers will reprogram the radio software, free of charge. Owner notification letters were mailed July 5, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLS's number for this recall is Z47.

Defect. Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 2500 and 2021-2022 Dodge Durango vehicles, and 2019-2022 3500 cab chassis with GVWR less than 10,000 lbs. The ABS control module software may prevent the electronic stability control (ESC) malfunction indicator light from illuminating during certain conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."

Risk. An ESC malfunction indicator light that fails to illuminate during an electronic stability control problem can increase the risk of a crash.

Remedy. Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed March 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z20.

Defect. Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 2500, Ram 3500, and 2021 Ram 1500 Classic pickup trucks. The side air bag inflatable curtain (SABIC) assemblies may have been manufactured with the incorrect amount of compressed gas, which can result in an improper air bag deployment.

Risk. An air bag that deploys improperly can increase the risk of injury in a crash.

Remedy. Dealers will replace the SABIC assemblies, free of charge. Owner notification letters were mailed January 17, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y99.

Defect. Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 3500, 2500 pickup trucks, and Ram 3500, 4500, and 5500 cab chassis vehicles equipped with Cummins 6.7L Turbo Diesel engines. An electrical short in the relay may cause a vehicle fire with the ignition on or off.

Risk. A vehicle fire increases the risk of injury.

Remedy. Owners are advised to park these vehicles outside of buildings or structures, and not near other vehicles, until the vehicle has been remedied. Dealers will inspect and, if needed, replace the Solid State Intake Heater Grid Relay ("Relay"); if FCA US Recall ID Y08 (NHTSA Recall ID 21V-163) is open, then insulating material will be applied to the Relay after inspection. Owner notification letters were mailed November 10, 2021. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y76. This recall has been superseded by 23V060.

The DPF system failed prematurely at 68k. My truck as working fine with zero problems until I took it in for the Y43 safety recall July 2025. the dealership performed the software update without verifying if parts were in stock first. They took the part (dpf module) off a used truck from the lot and installed it on mine without asking me first. They told me they would call me when the parts became available. They never called so I took it in for a battery issue were the batteries were overheating and dying. I asked that they replace the used part and look into the fried battery issue. Knowing how this dealership operates I went ahead and marked the old part with nail polish. when I was called to pick up my truck I met with the GM and he assured me everything was taken care of and the new DPF Module was replaced. I got under my truck and the used part as still there. The GMs face went pale and couldn't believe that they had lied. He asked that I leave it so he could make things right. They replaced the DPF module and the batteries. I met with the service manager and he took full responsibility for the lies and theft. ( I have the conversation recorded). I went back a few days later to ask why my truck kept doing Regens like every 3 days and they informed me it was normal. fast forward to July 2006 same issues batteries fried and died then the DPF notification came up saying "DEF Filter Full Power Reduced See Dealer". I take it back to the same dealership and they informed me m

The front right strut/shock is leaking and now both have to be replaced at only 48,000 miles and 4 years old.

The contact owns a Rexing R4 MD 4-Channel Dash Camera purchased at Walmart. The camera was designed with a 4-channel dash camera system used to record the front, rear, left, and right sides of the vehicle simultaneously. The contact stated that after installing the camera on a 2022 Ram 2500, the unit failed to turn off as intended and remained continuously powered and overheated. The contact expressed safety concerns that the failure presented a fire hazard. The contact attempted to notify the manufacturer via email and telephone at 877-740-8004; however, no response was received, and the telephone number was recently out of service.

The contact owns a 2022 Ram 2500. The contact stated that while attempting to exit the vehicle, the front driver's door became inoperable. The window and door actuator failed to function during the failure, requiring the contact to repeatedly pull the door handle and engage the actuator to exit the vehicle. The vehicle was taken to a dealer, where it was diagnosed that a piece of plastic near the wiring caused the wiring to fail, and the wiring needed to be replaced. The vehicle was not repaired. The contact expressed concern that the failure was hazardous due to a disability and presented a safety risk in the event of an emergency. The manufacturer was notified of the failure. The failure mileage was approximately 45,000.

I have dead pedal going on with my truck and when pulling out into traffic and truck does not go almost get hit by oncoming traffic and cause an accident and could end up deadly when the truck just losses the possibility to be limited to truck not being able to accelerate because it is having issues with the computer communicating with the sensor on the truck.

The contact owns a 2022 Ram 2500. The contact stated that while driving 30-35 MPH, the steering wheel failed to turn to the left or the right. There were no warning lights illuminated. The contact associated the failure with NHTSA Action Number: PE26002. The vehicle was taken to an independent mechanic who determined that there was a loss of power steering assist function, which was caused by water intruding into the power steering module connector. The vehicle was towed to the local dealer, where it was diagnosed with a loss of power steering assist caused by water intrusion into the power steering module connector. The dealer informed the contact that there was no warranty coverage on the vehicle. The vehicle was not repaired. The manufacturer confirmed that there was no warranty coverage for the repair. The failure mileage was approximately 14,900.

My vehicle was brought to my dealership for service on December 13, 2024, and again on January 13, 2026, due to a recurring Uconnect software/application failure. The system repeatedly displayed the message: “Uconnect Box requires service. Please visit an authorized dealer.” Over time this message continuously reappears while driving even after acknowledging the message earlier. This message would overlay critical driving information such as navigation, engine status, and trailer towing data. This message forces the driver to divert my attention from the road to locate and press “OK” on the screen, creating an ongoing and unacceptable safety hazard. I believe this distraction qualifies as a valid safety issue, under the NATSA guidelines for

ABS system HCU leaking internally Vehicles stopping ability may be impaired Vehicle brake pedal slowly sinks to floor. Ram dealership diagnosed a failed master cylinder internal seal and replaced the master cylinder with 25,272 miles on the vehicle on 3/17/26. Returned to dealership with same issue on 8/3/26 with 28,488 miles on vehicle. Ram dealership diagnoses the hydraulic control unit (HCU) is leaking internally on the ABS system. No warning lamps or other messages. First reported soft brake issue on 2/11/26.

The contact owns a 2022 Ram 2500. The contact stated that while driving approximately 70 MPH, the steering wheel jerked to the right and the traction control warning light illuminated. The contact stated that while the vehicle was parked, the electronic stability control, Forward Collision Avoidance, check engine, and power steering warning lights were illuminated. The vehicle was taken to a dealer, where it was diagnosed and determined that there was water intrusion in the rack and pinion, causing corrosion of the electronic power steering system and several other unknown components that needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 31,000.

The contact owns a 2022 Ram 2500. The contact stated that while driving at an undisclosed speed, the vehicle intermittently went into LIMP Mode and failed to accelerate as needed. The contact pulled over and turned off the vehicle. The failure failed to be self-corrected after the vehicle was restarted. The vehicle was taken to a transmission specialist, who was unable to duplicate the failure. The contact was informed that the failure was electrical, and an unknown sensor was replaced; however, the failure persisted. The vehicle was taken to the dealer, who discovered a leak in the transmission pump. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and directed the contact to the dealer to have the transmission replaced. The failure mileage was approximately 120,000.

While driving the rear tail gate drops. This has happened on several different occasions. Once it dropped while towing a trailer and I damaged the tailgate on the trailer tongue jack. There is no indicator in the cab of the truck to inform you that the tailgate has dropped, unlike the door indicators. I am positive that the tailgate was up and latched, so it’s not an instance where the tailgate is not fully closed. This could lead to other vehicles or motorcycle riders hitting objects that may fall out of the open tailgate, causing damage or injuries.

Lifter failure occurred on dangerous interstate interchange complete loss of power while towing a 14k pound mobile restroom bumper pull trailer in 6 lanes merging traffic from center lane 45 mph exit onto 60 mph interstate speeds XXX going onto XXX/[XXX] my scanner said dpf plugged stellantis mechanic claims lifter failure problem is complete loss of power happened in a dangerous area and waiting for a tow while hooked to a trailer was also dangerous due to high traffic area INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2022 Ram 2500. The contact stated that while operating the vehicle, the messages “Auto Park Disabled”, “Service Electronic Stability Control”, and “Trailer Brake System” were displayed. Additionally, while hauling a camper, the message “Trailer Brakes Disabled” was displayed, and the trailer brakes became inoperable. After restarting the vehicle, the failure was self-corrected, and the trailer brakes operated normally. The vehicle was taken to the local dealer, but the cause of the failures was not yet determined. The manufacturer was not yet contacted. The failure mileage was 65,000.

Vehicle would not start. I put a new battery in, the vehicle still would not start, and the break pedal was stiff. Had someone jump the vehicle, i started it and drove to the dealership service department where I originally bought the vehicle. They said it may be the starter. but they hadn't looked at the vehicle. I told them I would drive to a different shop because it's cheaper. When I tried to put it in drive the vehicle would not move it was giving an error message on the dash. I had to leave the truck there. 2 days later they called me and told me the issue was caused by a recalled part and they fixed the issue. When I arrived they told me I would have to pay $215 diagnostic fee. I told them it's federally prohibited to charge for a recalled part. I had to argue with them to get my vehicle back. They told me next time I should tow the vehicle if I dont want to pay a diagnostic fee. I attached proof of the recall service and the $215 fee listed that they tried to charge me.

The contact owns a 2022 Ram 2500. The contact received notification of NHTSA Campaign Number: 25V720000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

The vehicle has experienced repeated failures related to the diesel emissions system despite multiple repair attempts. The primary symptom is an illuminated check engine light accompanied by diagnostic trouble code P2459 (Diesel Particulate Filter Regeneration Frequency). The vehicle frequently enters regeneration cycles and continues to exhibit the same symptoms after major emissions system repairs. The emissions system components, including the Diesel Particulate Filter (DPF) and related DEF system components, were previously replaced by an authorized dealer. Following those repairs, the same warning light and fault code returned. The vehicle was subsequently inspected by another authorized dealer, which was unable to identify a definitive cause of the recurring condition. The check engine light was cleared, but it returned less than a week later with the same symptoms. The failure creates a safety concern because the vehicle may enter reduced-power or limp-home operating modes without warning, potentially limiting acceleration and the ability to maintain traffic speed. This is especially concerning when merging onto highways, crossing intersections, towing loads, or operating in heavy traffic. The recurring nature of the failure has reduced confidence in the reliability and safe operation of the vehicle. The condition has been reproduced multiple times and has been documented by authorized service facilities. Warning lamps and fault codes have repeatedly reappeared followi

The contact owns a 2022 Ram 2500. The contact stated that the trailer wiring pigtail produced only 9 to 10 volts to the trailer lights and brake system. Even when the brake pedal was depressed, the voltage output was insufficient. While towing a trailer, the trailer brakes failed to operate adequately. The vehicle was taken to a local dealer, who stated that the vehicle was operating as designed. The vehicle was not diagnosed nor repaired. The manufacturer was notified, and a claim was opened. The approximate failure mileage was 110,000.

Per mopar recall ZA3 transmission tube and dipstick recall. When completed at Orange Coast Ram [XXX] , dealership completed recall, removed original dipstick, and provided a 15" locking dipstick the does NOT provide needed transmission fluid level. Inquired in Orange Coast Ram service department, stated they will not provide needed 44"dipstick to monitor trans fluid. I cannot order, purchase the needed dipstick, creating a dangerous situation if fluid is low, and will result in transmission damage and possible dangerous condition if transmission fails while driving/.towing. I was told I will have to go to dealership and have the level checked, which is a routine needed owner maintenance job CORRECTIVE MEASURE: PROVIDE NEEDED 44" DIPSTICK TO MONITOR TRANSMISSION FLUID LEVEL INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My truck was started in the morning and as it sat idle in the driveway I started attaching my trailer. By the time I got the trailer attached(20 seconds) there was smoke pouring out from under the hood. I immediately turned off the truck popped the hood and it was engulfed in flames. I was able to put out the fire with the garden hose. No check engine lights, no warning lights on dash, and I had just got it back from the dealership 2 days earlier and it passed a safety inspection before I picked it up. Im not sure what component failed but whatever did caused a fire

The contact owns a 2022 Ram 2500. The contact stated that while driving approximately 35 MPH on the local roadway, the tailgate unexpectedly detached and remained suspended by the support cables. Due to the failure, the rear-view camera became inoperable. The vehicle was taken to the dealer, but was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 40,000.

I had to hard brake on a damp roadway at about 50 mph. The truck began to rotate and skid. I had no control over the vehicle until it stopped. The dash lights came on for a failure of the brakes, abs, traction control, and stability control. All of the lights went off then the truck seemed to drive normally. A short time later the lights came on and would not go off. Took the truck to the dealer. The hydraulic control unit was bad and was replaced. This did not fix the truck. Now it needs an abs control module. The truck remains at the dealer awaiting this repair. This appears to be a problem in the previous model year Ram 2500’s and it looks like my 2022 is affected also. There are recalls for these trucks but not for my model year.

The contact owns a 2022 Ram 2500. The contact stated that while driving at an undisclosed speed, the RPM fluctuated. Additionally, the vehicle made an abnormal sound while slowing down to come to a stop. The vehicle was taken to the dealer, who discovered burnt transmission fluid and replaced the transmission, but the failure persisted. The vehicle was taken back to the dealer; however, the cause of the failure could not be determined. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 10,000.

What component or system failed or malfunctioned, and is it available for inspection upon request? FACTORY TRAILER BRAKE CONTROL UNIT. How was your safety or the safety of others put at risk? BRAKE CONTROL INTERMITTENTLY FAIL TO WORK. NOT ABLE TO STOP 15,000 LB TRAILER. WEIGHT PUSHS VEICHLE OUT OF CONTROL. Has the problem been reproduced or confirmed by a dealer or independent service center? NEVER DOES IT FOR THE DEALER OR INDEPENDENT SERVICE CENTER AND THEY TOW MY TRAILER AROUND SEVERAL TIMES. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? DEALER & SERVICE CENTER Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO NO HOW DO I GET HELP IT IS A 2022 RAM 2500 BROUGHT NEW BY ME AND STARTED HAVING TROUBLE OFF AND ON SINCE THE FIRST 1,000 MILES AND NOW HAVE 26,000 MILES. I READ ABOUT THE RECALLS ON THE 2024 2025 RAM 2500 3500 MODELS WITH AN ENGINEERING PROBLEM ON TWO DIFFERENT VENDORS MAKING CONTROLERS FOR FCA.

The ABS, traction control, and 4x4 lights all came on at the same time. None are operable. During my research I was able to find recall 75b that aligns with the exactly with my current set of issues. 24v-653 is the NHTSA recall number associated. I need that recall added to my vehicle so I can get the very unsafe issue fixed

Clock spring is broken. You can hear it popping when turning the steering wheel. I see other years are covered by my vin is not.

I have a clunk to when coming to a stop, the transmission is down shifting, and just before it comes to a complete stop, the truck has a clunk that is felt through the vehicle and heard. at times while stopped the vehicle will lurch forward as though you have been hit from behind. The truck has been back to the dealership several times for this problem, two different dealerships because the first one gave up and was suggested to take it to another dealership per Ram. The truck has been shut down completely two time to put in relearn mode, three transmission replacements, four valve body replacements, and they wanted to put a fourth transmission in the truck, but the mechanic said he doubts thats the problem to Ram, and so now they want to say that its operating as design, Ram asked me to take it to a third dealership, so I did, the mechanic and I went for a drive in the truck, the mechanic said there is definitely a problem, but he would not take on this job because he would not want to deal with Ram and there politics. So that leaves me driving a 2022 Ram 2500 truck I purchased [XXX] that did not have this problem until after purchase six months later. Ram customer care has offered money for my inconvenience, I said I just want my truck fixed, they said they are not going to do anymore. I have a vehicle that has been in the shop for a total of eleven months since i have purchase it, has not been fixed, and every time I come to a stop I cringe because I know it is going to cl

My 2022 Ram 2500 6.4L HEMI has a long crank/hard-start issue every morning. It takes 5–6 attempts to start when the vehicle sits overnight. After starting once, it runs normally the rest of the day. I also had issues where the truck struggled to start after refueling. I replaced the gas cap and EVAP purge valve, which improved the refueling issue, but the long-crank cold start continues. I suspect a fuel pump internal check-valve failure causing fuel pressure to bleed down overnight. This is common on these trucks and is a safety concern because the vehicle may fail to start in emergency situations or stall unexpectedly. No check-engine light is present. The issue is repeatable daily.” Faulty fuel pumps in these specific RAM models can suddenly fail while driving. This failure can lead to a complete loss of engine power without warning, increasing the risk of a crash.

I am reporting a recurring safety defect involving hydraulic lifter failure in Ram trucks equipped with the Cummins diesel engine (model years 2019–2024). This issue is widely acknowledged by Stellantis and multiple dealers. It typically begins with a knocking sound and has been documented in many cases to progress to complete engine failure. My vehicle has fewer than 20,000 miles. The lifters were already replaced once, which required the cab to be removed. Within less than 400 miles of that repair, the knocking sound has returned. I brought the truck to a second dealer, who confirmed the problem and informed me that Stellantis has an active STAR case acknowledging the defect. They stated there is currently no known permanent fix. This defect presents a serious safety concern. Sudden engine failure while driving, especially under load or at highway speeds, could lead to loss of power, loss of steering/braking assist, and potential accidents. In my situation, I frequently travel with family members who have medical conditions, and being stranded in hazardous or remote conditions poses significant risk. At this point, my vehicle is not reliable or safe to operate. I am requesting NHTSA investigate the hydraulic lifter defect in 2019–2024 Ram Cummins trucks due to the safety implications and the lack of an available permanent repair.

While slowing for traffic, I was struck in the rear by a large pickup. On impact, the driver seat broke, causing the whole seat to tilt back to more than 45 degrees backwards tilt. This caused me to impact the seat at a greater impact than I would have had if the seat remained in place. The seat being in that position after the impact, made it so I could not reach the pedals (brakes) to stop the vehicle from rolling forward until I used the steering wheel to pull myself forward. Upon inspection after the collision, it was observed that part of the adjustment assembly detached from a bolt causing the seat to come loose from its proper position.

My screen on my truck went out and had to be reset manually, next my heated steering wheel stopped working. The problem is the cool spring in my steering wheel. Upon research there is a common problem with this said coil spring. This can cause multiple problems including loss of air bag function and front end collision indicator which comes on time to time saying it’s disabled due to this same said coil. Why this is not a recall and the owner’s responsibility is unknown. There is also no indicator telling you if the airbag may or may not deploy when need from this issue.

Clock spring in steering column Clock spring controls: Buttons on steering wheel Heated steering wheel Turn signals/lights Air bag in steering wheel My issue was just starting at making the heated steering wheel not work. And could potentially effect the other functionalities (ram had a previous recall on later models) This was reproduced at the service center Not sure if it was inspected by anyone besides dealership and myself No warning lamps. And problem started 2 days before this submission

After the y43 recall that Dodge did on 2022 Cummins Ram vehicles I have had four issues. The first one being the recall itself having sensors stuck while replacing, the second being the particulate filter sensor, third being DPF pressure sensor, and fourth being the maf sensor. During my most recent visit of getting the math sensor replaced I was not given any reason to why this was being replaced when they said everything seem to be within parameters. The dealership had stayed in one talking to the TA or tech advisor that they wanted to try this to see if it fixed the issue. I am now back again at the dealership just days later after the dealership having my truck for 2 weeks for the same issue. This all stems from the y43 recall and I've only had issues since. I've asked for specific answers to specific questions in Dodge seems to pass technical engineering questions back to the dealership without providing educated answers instead of educated guesses. During the y43 recall it stated that there is potential fire hazards in other issues that could happen. I'm not okay with ram allowing for guessing games when it comes to my safety. I would like answers in educated fixes put into place while ensuring that the y43 recall they guaranteed the government is resolved without any further issues during this fix.

We are the subrogees of State Farm mutual Insurance. We are reporting that on 7/31/24 the insured vehicle a 2022 Ram 2500 caught fire due to electrical issue while being driving on the highway in Baltimore, maryland INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

DPF regeneration frequency. Truck began exhaust regeneration at frequent intervals. Truck produced check engine light for "regen frequency P2459". Problem verified by dealer. Cause of the issue is unknown.

While towing a (new) travel trailer, the trailer brakes stop working intermittently. The local RAM dealer could not find any problems. A DTC code C10C7-19 was discovered with no way to repair according to the Ram dealer. I contacted the RV dealer about this problem. They said they have never seen this problem. Test were made on the electrical brake system, All wiring and brakes checked OK. I do not feel safe towing not knowing if my brakes will work or not.

This vehicle is 3 years old and has 29k miles driven. The forward collision avoidance system stopped working and can no longer be turned on. This installed safety feature is no longer usable and is a risk to passengers in the event of a road Hazzard situation presents itself. The system failed without warning. The vehicle was taken into the dealer for inspection and the dealer confirmed that the Drivers Assistance System Module (DASM) has failed and requires replacement.

Bought 2022 Dodge Ram 2500 equipped with Firestone LT275/70R18E 125 tires on Dec2023. Truck has 21000 miles, sidewalls on all 4 tires are splitting and have a ring around them in the same exact spot on the sidewalls. Dealer said it appears to be a defect on all tires. Dodge referred me to Firestone, got no where with them. Tires appear the sidewalls could blow out on highway and unsafe. Caught defects before possible premature blowouts on all 4 tires due to premature cracking on sidewalls. No towing or hauling done with truck, never been off pavement either, truck parked under cover from sun etc. Dealer advised tires not worn and had great tread depth. Dodge Ram installed these tires to sell the truck but referred me to Firestone for replacement, still trying to get someone to own up to these defective tires besides me.

Dodge Ram started making typewriter sound coming from the engine. Took the Ram to the dealership and they found 3 damaged push push rods and 3 damaged rocker arms. Dealer refused to address the metal shaving from the internal damage floating around the engine. Engine had 32k miles on it and oil was changed at 7 to 8k miles intervals.

Crankshaft position sensor went out at highway speed pulling a 5th wheel. Truck shut down in traffic and all power was lost. The throttle position engine light came on and the truck overheated and completely shut down nearly causing a high speed crash on I/40 east of amarillo. The 5th wheel was 17000 pounds and the truck had 37000 miles on it. The dealer (Lipscomb Dodge Elk City , OK) advised it was the crankshaft position sensor and that it was on the same circuit as numerous other sensors that are vital to keeping the engine running and the truck operating safely. The truck is available for inspection, and now has a loud ticking noise (possibly an injector, lifter, or exhaust leak due to the over heating caused by the faulty sensor.

The rear passenger side seatbelt is locked. Our son was exiting the car ( and told us he couldn’t get his belt to retract. We also tried to get the belt to retract but were unable to do so. The truck has not been in any accidents, no visible wear on the seatbelt. We typically use the rear seatbelts for our children but now we cannot ride with 5 passengers safely in the vehicle. We took the truck to a RAM dealership in Hendersonville, NC who told us we would need to pay nearly $600 to repair the belt. With the truck only being a few years old and no collisions or incidents, it seems like a manufacturer defect.

Truck has had lifters replaced due to tick, sluggish performance and engine vibration. Truck was driven less then 500 miles and problem re-occurred. With research I have learned this is a widespread problem, and ram techs have reported complained there is no fix, and they are just reinstalling parts that will fail again. I feel the engine has had metal ran through it which in my opinion could cause this engine to seize up at. T tow a larch travel trailer with my family an and small pets in this vehicle.i live in the Desert where temperatures reach in the 120s. I can’t have a vehicle that could stop running leave myself and my family in a situation where the truck stops running, to be either hit by another vehicle or on the road side broken down. Problem was documented at 17000 miles and still under the 3 year 36 warranty.

Truck will regen every 100 miles, then Truck will come up with regen message then immediately come up with see dealer full dpf. Truck will start shutting down causing a safety hazard for family in truck. Dealer and ram will claim nothing is wrong with truck. And that we need to continuously pay for dpf manual regen $500 per manual regen (happens once a year). Truck has 32,000 miles and is a 2022. Dealer claims they did the recalls.

Engine had a tick, dealer said it was lifters. Dealer replaced lifters after having the truck for three weeks. Noise is back 2022 ram 6.7 with 17000 miles. This issue could cause engine failure at any speed and I use this truck to pull a large travel trailer. I’m concerned the noise is back and putting metal shavings into the engine will cause catastrophic engine failure at some point.

Hydraulic roller lifter failure. Very common these pickups . Mine went in for a ticking noise hydraulic roller lifter failed got stuck in the bore. They replaced all 16 they test drove it stuck exhaust lifter #2 they replaced that lifter and the camshaft. Engine still has a very loud clatter and ticking noise. Did not do this when it was brand new

The Mass Air Flow (MAF) sensor on my 2022 Ram 2500 failed, causing multiple system malfunctions. It triggered inaccurate Diesel Particulate Filter (DPF) codes and showed abnormally high idle hours that do not reflect actual vehicle use. This defect is tied to a known issue identified by Stellantis in Technical Service Bulletin #18-002-24, which acknowledges improper MAF sensor calibration or compatibility on vehicles like mine. The bulletin was verbally confirmed by the dealership as applying to my truck. This faulty sensor caused emissions system errors, degraded engine performance, and may impact emissions compliance. There was a persistent check engine light, reduced fuel economy, and the risk of engine derating. The problem was reproduced and confirmed by Encore Chrysler (Mobile, AL), an authorized Ram dealership. Stellantis has agreed to cover the repair under Goodwill, but the issue appears systemic. Safety was potentially compromised by inaccurate sensor data that may cause sudden engine derate or failure during operation. Additionally, the incorrect idle hour readings could affect warranty determinations and long-term diagnostics if not corrected. The check engine light first appeared on May 21, 2024. The vehicle has been out of service since May 22, 2024, and repairs are still pending. The MAF sensor and affected systems are available for inspection upon request. This issue may affect a broader set of Ram 2500 trucks, and given the manufacturer’s internal bulletin, i

The radio screen will cut out and turn black randomly but will continue playing music. When this occurs, the screen will not turn back on even if the truck is put in reverse. This is a serious safety concern since the back up camera is inoperative. This has happened three separate times in the past month, and I have video of two instances that was provided to the dealership.

I bought my 2022 Ram 2500 brand new as a factory order. It is currently in the shop at Ron Lewis Ram in Cranberry Twp, PA to get a rear window water leak diagnosed. The dealer has told me that the rear windows frame is cracked in multiple places and wont be covered by my 8 year/125,000 mile max care warranty. I told them that it should be covered since its apparently a factory defect that caused the issue. They informed me that since I am at 55,000 miles, Ram wont pay to repair the issue, that I had until 36,000 miles to have this issue and have it repaired. Through the power of Google search, I was able to find that countless Ram 1500 trucks have had this identical issue and a TSB exists for it. The TSB for the Ram 1500 (23-098-23 Rev A) states that it was caused by a manufacturing issue, that the repairs will be made, and that Ram will cover the repair until the truck hits 8 years/ 150,000 miles. I cannot find a TSB for the 2500 trucks that have the identical issue and I can't believe for a second that I have the only 2500 Ram on the road with this issue, especially after seeing the identical problem with the Ram 1500 and even the Jeep Gladiator, all from the same manufacturer of Stellantis- who owns both Ram and Jeep. The dealer says that I will have to pay a couple of thousand dollars out of pocket to have these repairs made on my own.

5th gen ram with the 6.7 Cummins diesel have a massive problem with lifters. Extremely common for trucks with under 10k miles needing the extensive repair done. I’ve read in some cases people whole motors breakdown due to this failure while on the highway pulling a load. My specific truck had to have all the lifters replaced at 76k miles. There needs to be a manufacture recall on these.

Seat belt system seems to have stopped retracting on both front seats. Truck has a little over 36k miles. Almost never has a passenger.

I was out plowing when my wipers stopped working. brought it in for service and they first said the wiper motor was bad cost for diagnoices was $169.00 issue was not the motor. after second trip for service they found a defaulty fuse box additional charge over $800.00. I have read severl other complaints about the fuse boxes causing issues such as lose fuses etc. Repair Estimate Service Advisor Jonnah Matthews (031) [email protected] PREPARED FOR [XXX] [XXX] Date 03/29/2025 03:53 PM 2022 Ram RAM PICKUP 2500 VIN [XXX] Mileage 40,478 RO# [XXX] Service Name Price [Primary]: DIAG2 - STANDARD DIAGNOSIS SYSTEM STANDARD DIAGNOSIS SYSTEM WIPER MOTOR IS INOP, WIPERS WILL NOT WIPE. INSTALLED IN ANOTHER TRUCK AND IT WORKED OKAY, PLEASE CHECK $0.00 Fuses: fuse box $798.88 Printed on March 29, 2025 Quote expires on April 28, 2025 Subtotal $798.88 Total $798.88 McGee Chrysler Dodge Jeep Ram of Barre 1365 U.S. Route 302 Barre, VT 05641 8024764724 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)