Chrysler (FCA US, LLC): Electrical System › Wiring › Relays/Solenoids
Chrysler (FCA US, LLC) reported this defect to federal regulators on Oct 14, 2021 and put the number of vehicles at risk at 131,177. The repair is free for as long as the recall stands.
Park away from buildings
NHTSA attached a park-outside advisory to this campaign. It applies to specific production runs, so check your own VIN with the manufacturer or at nhtsa.gov/recalls before driving the vehicle.
The defect
Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 3500, 2500 pickup trucks, and Ram 3500, 4500, and 5500 cab chassis vehicles equipped with Cummins 6.7L Turbo Diesel engines. An electrical short in the relay may cause a vehicle fire with the ignition on or off.
The risk
A vehicle fire increases the risk of injury.
The remedy
Owners are advised to park these vehicles outside of buildings or structures, and not near other vehicles, until the vehicle has been remedied. Dealers will inspect and, if needed, replace the Solid State Intake Heater Grid Relay ("Relay"); if FCA US Recall ID Y08 (NHTSA Recall ID 21V-163) is open, then insulating material will be applied to the Relay after inspection. Owner notification letters were mailed November 10, 2021. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y76. This recall has been superseded by 23V060.
8 model years covered
Newest first| Vehicle | Complaints | Recalls | Fires | Crashes |
|---|---|---|---|---|
| 2022 Ram 2500 | 181 | 12 | 5 | 9 |
| 2022 Ram 3500 | 191 | 12 | 5 | 4 |
| 2022 Ram 4500 | 3 | 4 | 0 | 0 |
| 2022 Ram 5500 | 26 | 4 | 0 | 1 |
| 2021 Ram 2500 | 109 | 8 | 8 | 6 |
| 2021 Ram 3500 | 62 | 9 | 4 | 0 |
| 2021 Ram 4500 | 0 | 5 | 0 | 0 |
| 2021 Ram 5500 | 4 | 5 | 2 | 1 |
What this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 21V798000.
Full record for the 2022 Ram 2500 → · Recalls carrying a do-not-drive advisory → · Where this data comes from →