2020 Ram 2500

Defect. Chrysler (FCA US, LLC) is recalling certain 2016-2019 Ram 3500, Ram 1500, 2016-2020 Ram 2500, and 2016 Ram 3500 Cab Chassis vehicles. The right and left side curtain air bag inflators may rupture due to a manufacturing defect.

Risk. An inflator rupture may result in sharp metal fragments striking occupants, resulting in injury.

Remedy. Dealers will replace one or both side curtain air bags, as necessary, free of charge. Owner notification letters were mailed February 13, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's numbers for this recall are 05C, 09C, and 10C.

Defect. Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 1500, 2500, and 3500 pickup trucks. The tailgate may not latch properly due to misaligned tailgate strikers, which could result in the tailgate opening while driving.

Risk. An unintended tailgate opening while driving may result in a loss of unsecured cargo, possibly creating a road hazard and increasing the risk of a crash.

Remedy. Dealers will inspect the tailgate striker alignment to the box latch and adjust, if necessary, free of charge. Owner notification letters were mailed December 22, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is ZB8.

Defect. FCA US, LLC (Chrysler) is recalling certain 2020-2023 Ram 2500 and 2020-2022 Ram 3500 vehicles. A build-up of pressure and heat inside the transmission may result in a transmission fluid leak from the dipstick tube.

Risk. Leaking transmission fluid may contact an ignition source within the engine compartment, increasing the risk of a fire.

Remedy. Dealers will replace the transmission dipstick and transmission vent assembly, free of charge. Owner notification letters were mailed December 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. Chrysler's number for this recall is ZA3.

Defect. Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 2500 and 2021-2022 Dodge Durango vehicles, and 2019-2022 3500 cab chassis with GVWR less than 10,000 lbs. The ABS control module software may prevent the electronic stability control (ESC) malfunction indicator light from illuminating during certain conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."

Risk. An ESC malfunction indicator light that fails to illuminate during an electronic stability control problem can increase the risk of a crash.

Remedy. Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed March 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z20.

Defect. Chrysler (FCA US, LLC) is recalling certain 2019-2020 Ram 2500 and Ram 3500 vehicles, Ram 3500 Cab Chassis, 4500 Cab Chassis, 5500 Cab Chassis and 3500 Cab Chassis with a gross vehicle weight rating (GVWR) of less than 10,000 lbs. The windshield wiper arms may loosen, possibly causing the wipers to function improperly and reduce the driver's visibility in certain weather conditions.

Risk. Reduced visibility increases the risk of a crash.

Remedy. Dealers will tighten the wiper nuts, free of charge. Owner notification letters were mailed February 15, 2022. This recall is an expansion of recall number 20V-208. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z08.

Defect. Chrysler (FCA US, LLC) is recalling certain 2019-2020 Ram 2500, 3500 pickup trucks, and Ram 3500, 4500, and 5500 cab chassis vehicles equipped with Cummins 6.7L Turbo Diesel engines. The High Pressure Fuel Pump (HPFP) may fail, resulting in a sudden engine stall without warning.

Risk. An engine stall increases the risk of a crash.

Remedy. Dealers will replace the HPFP, update the Powertrain Control Module (PCM) software, and inspect and replace additional fuel system components as necessary, free of charge. Interim owner notification letters to inform owners of the safety recall were mailed on January 4, 2022. Owner notification letters were mailed on May 17, 2022. Phase 2 owner notification letters are expected to be mailed on March 2, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y78.

Defect. Chrysler (FCA US LLC) is recalling certain 2020 Ram 2500 and 1500 vehicles. The driver side mirror glass can detach from the backing plate and no longer provide a reflective surface. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Risk. Missing driver side mirror glass reduces visibility and increases the risk of a crash.

Remedy. Chrysler will notify owners, and dealers will replace the driver side mirror glass, free of charge. The recall began November 5, 2020. Owners may contact FCA US customer service at 1-800-853-1403. Chrysler's number for this recall is W70.

Defect. Chrysler (FCA US LLC) is recalling certain 2020 Jeep Gladiator and Jeep Cherokee, 2019-2020 Ram 1500 Pickup, Ram 2500 Pickup, Ram 3500 Pickup, Chrysler Pacifica, Dodge Durango, Jeep Grand Cherokee, Jeep Wrangler, and Jeep Renegade and 2019 Dodge Challenger vehicles equipped with 8.4" or 12" radio displays. A software error can cause the rearview camera image to remain displayed after the vehicle has been shifted out of reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."

Risk. The lingering rearview image can distract the driver, increasing the risk of a crash.

Remedy. Chrysler has notified owners, and dealers will update the radio display software, free of charge. Optionally, owners can choose to remotely update their software via an Over-The-Air (OTA) update available as of May 1, 2020. The recall began April 27, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W30-W37.

Defect. Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 2500 and Ram 3500 Pick-up trucks equipped with an accessory bed step. In certain side loading conditions, the bed step may unexpectedly fail while in use.

Risk. A bed step that unexpectedly fails while in use increases the risk of injury to the user.

Remedy. Chrysler will notify owners, and dealers will replace the bed step support brace, free of charge. The recall began on July 9, 2020 (RAM 2500) and began on October 6, 2020 (Ram 3500). Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's numbers for this recall are W24 and W44.

Defect. Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 2500 and 3500 Pickup vehicles equipped with six-speed automatic (68RFE) transmissions. A build up of pressure and heat inside the transmission may result in a transmission fluid leak from the dipstick tube.

Risk. The leaking transmission fluid may contact the turbocharger or another ignition source within the engine compartment, increasing the risk of a fire.

Remedy. Chrysler will notify owners, and dealers will replace the transmission valve body separator plate and reprogram the powertrain control module. The recall began March 2, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W03.

The contact owns a 2020 Ram Promaster 2500. The contact stated that while reversing, the rear-view camera displayed a blank or inverted image. The contact later received notification of NHTSA Campaign Number: 25V552000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the failure but confirmed that parts were on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 77,000.

The contact owns a 2020 RAM 2500. The contact stated while driving at an undisclosed speed, the contact noticed that the engine was running unusually rough and the engine seized. No warning lights were illuminated. The vehicle was towed to an independent mechanic where it was diagnosed with a failed engine. The contact was informed that the heater intake bolt was detached and entered into the number 6 cylinder. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the failure was a known failure regarding the vehicle. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 150,128.

The contact owns a 2020 Ram 2500. The contact stated that while driving the vehicle at an undisclosed speed, a tapping sound was heard, which gradually grew louder. The next day, the vehicle was taken to a dealer where it was diagnosed with a piston 5 failure, and the dealer determined that the engine needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 46,000.

The contact owns a 2020 Ram 2500. The contact stated that while standing directly behind the tailgate, the contact heard an audible "click", and the tailgate independently unlatched and opened, striking the contact's chest, and the contact was forcefully knocked to the ground. Due to the severity of the impact and injury, the contact was immobilized on the ground for 45 minutes while calling out for emergency assistance. The contact sustained a broken femur. The contact related the failure to NHTSA Campaign Number: 22V904000 (Structure), in which the vehicle did not have the recall remedy performed to prevent the failure. Prior to the failure, the vehicle was taken to the dealer for the recall repair; however, the dealer determined that no repair was needed and marked the recall as complete. The vehicle was taken back to the same dealer for a reinspection, with a diagnostic fee included, but the dealer was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact mentioned being concerned for their safety when driving the vehicle. The failure mileage was 35,272.

My 2020 Ram 2500 Mega Cab truck Dash Leather Covering is coming loose from it base and may interfere with the passenger Air Bag deployment that is under the loose material. My truck has only 36,000 miles on it and has been garaged kept since I purchased it new. *I found this information online. Ram 2500 trucks (2019–2023) frequently experience dashboard leather bubbling or delamination, particularly over the passenger airbag area. This bulging can compromise airbag deployment and is caused by adhesive failure, often requiring a full dashboard replacement. I contacted my local Ram service center. They advised my to contact Ram corporate regarding this Safety Issue. Key Details Regarding the Issue: •Cause: The glue holding the leather/vinyl to the dash substrate fails, leading to bubbling and peeling, which can create a ridge over the passenger airbag deployment zone. •Safety Risk: A warped or bulging dashboard can interfere with the proper deployment of the passenger-side airbag.

Massive oil leak that everyone has issues with also has a grid heater bolt that fails and causes engine damage. The oil leaks are terrible for the environment and causing leaks all over every road

The reverse went out while driving

Hood liner repeatedly drops down out of its mounting points on the edge near the engine firewall. This is a manufacturing engineering deficiency that relies on shaped material to hold the liner in place. The dealer has replaced it three times, and the same thing continues to happen. Chrysler refuses to address the issue. My concern is what happens if the liner completely drops down on the engine while in operation.

While towing, my trailer brakes and lights come off and on randomly. I've had the wiring repaired on my trailer and it did not fix the issue. I've almost been in several accidents while towing, It is very unsafe.

Def pump failed twice with this vehicle and with that it does not allow the vehicle to run any faster than 5 mph after the countdown ends. Unknown how the exhaust being plugged and service was done to clean the exhaust ended up having the fuel pump and turbo charger needing replaced. Not sure if they went hand in hand and one causing the other. So far the vehicle only has almost 78,000 miles on it. Change oil and fuel filters at the vehicles scheduled computer system reports on the vehicle. I was having issues from service center having trouble resetting the exhaust system, which they said the system was not sealing properly. Took them a couple of days to get part from dealership to get it to seal and reprocessed the test which they said passed exhaust reset. That would explain the poor fuel rating of only getting 9 miles per gallon. If there was a complete fuel pump failure, not sure if that would compare to this being a safety issue. Not sure how engine would react, due to it completely failing or if the turbo would cause the vehicle to be unsafe. The vehicle is currently at dealership and only 1 out of the 3 are even available to fix this problem. Def pump is available, but unknown when the others will arrive. Service shop said it could be 3 weeks or 8 months for parts to come in. Due to being a back ordered item. Spent $70k for this vehicle, just to have it spend over 2 months in the shop. I do my own oil and fuel filter changes, due to it being faster and cheaper than an

The contact owns a 2020 Ram 2500. The contact stated while driving 75 MPH, traffic started to slow down, and the vehicle failed to stop as intended while depressing the brake pedal. The contact depressed the brake pedal again, and the vehicle abruptly stopped and veered to the left. The contact was able regain control of the vehicle and pulled over to the shoulder. Several unknown warning lights were illuminated. The contact stated that the ABS, 4x4, and brakes warning lights were illuminated, and other unknown warning lights were illuminated. Additionally, a metallic burning odor was coming from the vehicle. The vehicle was towed to the residence. When the tow truck driver lowered the vehicle, the contact noticed that the front driver’s side wheel seemed bent. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 41,000.

2500 Truck randomly activates emergency braking for no reason. Occurs a couple times a month. Every occurrence has zero obstructions in front. I took it to the Tate Ram dealer (frederick MD) and they refused to update their software unless I pay them +$285.00. The Ram dealer is even aware of the software issue. I told them this is a life safety issue and not my fault. I requested the fix immediately but refused. I also have an active full MOPAR warranty, and they still said it's not covered. This is insane

As I was operating my vehicle on I95 northbound smoke began to pour out of my vents. I was able to pull over and was able to determine there was a fire behind the radio in my truck. I immediately grabbed the personal affects that I could grab and called 911. However within 5 minutes the cab of the truck.was engulfed im flames.

I pushed my breaks and the hydro booster started spraying fluid inside the cab I lost my breaks I was backing up down my sister's drive way hit a telephone pole with the back of the truck it made a little dent

Subject: Fuel System Failure Resulting in Engine Damage – 2020 RAM 2500 Pickup VIN: [XXX] Complaint Summary: I am submitting this complaint to formally report a dangerous and costly fuel system defect in my 2020 Dodge Ram 2500 Pickup (VIN: [XXX] ) that has resulted in catastrophic engine damage. Although Chrysler has issued a recall for the high-pressure fuel pump (HPFP) in many 2020 Ram trucks equipped with the 6.7L Cummins engine, I was told that my vehicle was not included in the recall—even though it exhibits all the classic symptoms of HPFP failure. This is a safety hazard and a potential emissions violation. Details of the Incident: In June 2025, I brought my truck to Tracy Chrysler Dodge Jeep RAM after experiencing engine misfires, loss of power, and a knocking noise. The dealership diagnosed a P0303 cylinder misfire and noted a fuel smell in the engine oil, as documented in repair order #[XXX]. Despite extensive diagnostic work—including compression tests, leak-down, and injector swaps—the misfire remained unresolved, and a tapping noise persisted. The technician explicitly noted fuel contamination in the oil and suspected internal engine damage due to a fuel system issue. To further investigate, I submitted an oil sample to Blackstone Laboratories. The lab confirmed the engine oil was heavily diluted with diesel fuel—over 10% fuel contamination, which reduced the viscosity from 5W40 to the equivalent of 5W20. This is consistent with HPFP failure leaking fuel into the

The parking brake will not operate. Upon inspection the teeth on the gear are broken causing it to lock at top position. Dealership would not warranty safety part at 30,059 miles on vehicle so now I am left with no parking brake to protect vehicle from rolling on hill. Keep in mind vehicle is always used for towing 12,000 pounds or more.

Ram and it's parent company know there is an issue with the brake systems on their 3/4 ton pickup trucks. The 2500's. There is excessive travel in the brake petal and not enough pressure builds up in the system to activate the brakes correctly and adequately. It's all over the ram 2500 online forums. Many people are experiencing this issue with new trucks. Ram and its parent company Stellantis are unwilling to do anything about it.

Too much travel in brake pedal. Feels spongy. Weak brakes, hard to stop vehicle. Have to put pedal to the floor. Was told this was OK and normal at the dealership. Has been like this since I bought the vehicle new.

Vehicle randomly shuts off during normal operation. Same as if the Start / Stop button were activated. Vehicle coasts until it self applies the emergency brake at about 3mph causing a sudden, jerky complete stop. Switches itself to Park. Dash indicates “sterp on brake to restart”. Vehicle restarts normally but may randomly shut down again. Safety risk is loss of steering, loss of power brake control, and total loss of power in traffic. Taking it to dealer today. Vehicle has not been inspected by anyone yet. No messages or warning lights display. This is a recent problem but recurring with increasing frequency.

Traction control kicks on while driving on dry pavement and the truck bogs down like there isn’t any power. The truck slows down abruptly and will not speed back up without pulling to the side of the road and I have to shut it off and reset. The drive selector knob lights starts flashing and now they don’t come on at all. This has happened on 4 occasions

Issue is that the on the Diesel intake heater core has a bolt that comes loose from inside the manifold and can fall down into the cylinder and can cause catastrophic failure.

I have a check engine light that came on. I took it to the dealer and they said it is a P0542 code for heating element relay. There is a technical service bulletin out for this known issue. I still have power train warranty left on my truck but they’re claiming it isn’t covered. I went as far as to add a bank ram air intake for over $1000 to help eliminate a complete engine failure. Any help would be appreciated

The contact's husband owns a 2020 Ram 2500. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that the diesel particulate filter had failed due to the high-pressure fuel pump (HPFP) failure, which caused metal shavings to enter the fuel system. The dealer determined that the HPFP and the entire fuel system needed to be replaced. The dealer informed the contact that the manufacturer had offered to partially cover the repair cost through goodwill assistance. The vehicle was not repaired. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 21V880000 (Fuel System, Diesel); however, the recall repair failed to fix the failure. The manufacturer was notified of the failure and a case was filed; however, the manufacturer had failed to respond to the contact's follow-up emails and calls. The failure mileage was approximately 126,513.

Throws code p2609 which is grid heater, this needs to be fixed at 38000 miles, I'm sure it'll cause a fire like the other model years that is being recalled for the same issue

The contact owns a 2020 Ram 2500. The contact stated that while driving approximately 65 MPH, there was a knocking noise coming from the engine compartment, with the check engine warning light illuminated. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that engine grid heater had overheated, causing damages to the engine. The engine was replaced, and the vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 300,000.

The contact owns a 2020 Ram 2500. The contact stated that after starting the engine, moments later the contact came back to discover fire coming from under the hood of the vehicle. The contact and co-workers used fire extinguishers to extinguish the flames. The vehicle was later towed away. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure but no assistance was offered. The failure mileage was 67,000.

The contact owns a 2022 Ram 2500. The contact stated that the vehicle was not properly aligned, and the tires were worn. The dashboard leather had detached. While driving at an undisclosed speed, the windshield wipers became inoperable. Additionally, after it had rained, the contact noticed there was water moving around in the engine bay. There were no warning lights illuminated. The contact completed an alignment. The vehicle was taken to the local, who broke an unknown part on the dashboard. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 10,000.

Dealer unable to get recall parts since the inception of the recall. Dealer says they only receive a couple of DIPSTICKS a month. Long waiting list. I called Chrysler to no avail. Ridiculous wait for a dipstick!

I was driving doing 55mph on the highway and the hood came lose and flopped back covering my windshield. Luckily there was nobody too close to me I and was able to avoid a collision.

The contact owns a 2020 Ram 2500. The contact stated while driving at approximately 45 MPH, the contact swerved to the left to avoid crashing into a deer. The contact stated that when he attempted to return the vehicle to the right lane the vehicle's front end continued to turn to the left as the rear end of the vehicle spun out to the right. The contact stated that the vehicle hit the shoulder of the road on the right side, rolled once, and stopped. The vehicle had rolled onto the passenger side of the vehicle. The contact stated that no air bags inflated. The contact stated that the right side of the vehicle was dented and heavily scratched, and the right front and rear passenger doors were crushed, and the glass of the rear cab window was broken. The contact had not noticed any warning lights. The contact stated that he had bruises on the left side of his forehead and an abrasion on his right ear. The contact was driven to a local ER by a friend and had a CT scan performed and was released. The contact stated that a state trooper had written a report and issued a citation. The contact had the vehicle towed to his residence. The vehicle had not been diagnosed and was not repaired. The contact had researched online and related the failure to NHTSA Campaign Number: 22V140000 (Service Brakes, Hydraulic, Electronic Stability Control). The manufacturer was informed of the failure. The failure mileage was approximately 115,000.

My 2500 RAM longbed crewcab is a "Tradesman", i am a contractor, so i put a lumber rack on my truck because i also am a TRADESMAN! Problem is this bed rail is 80% hollow and covered with cheap Chinese plastic. I have stress fractures on the outside sheetmetal body panels. And this is with an empty rack 99% of the time. If a work truck cannot be used for work then what the hell is it good for? What the hell do i do about a steadily growing fracture in the structural steel bed? Seatbelt springs are pathetic and barely retract, half the time they remain loose. Drivers side has been replaced and still does not properly retract

While driving around 40mph the vehicle shifted from D to P by itself and the 4 way flashers turned on. I immediately turned the knob back to D and it corrected itself and went back to normal operation.

Transmission dipstick threw out of the truck while moving and causes transmission fluid to spray out and now the truck will not move. It’s throwing 2 codes for the 3rd and 5th gears malfunctioning. There is a recall on the transmission we were not notified about until we called the dealership to explain what happened.

The contact owns a 2020 Ram 2500. The contact stated that on two separate occasions, while driving at highway speeds, the power steering assist failed to operate as designed. There was no warning light illuminated. The vehicle was initially taken to a dealer where the power steering assist was repaired under warranty. Despite the repair, the contact stated that the failure occurred a second time without warning. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 35,000.

Reverse camera too bright cannot see side mirrors while driving at night. Cannot dim or turn off camera to see mirrors. even worse when towing trailer and or when raining.

There is a known issue with the vehicle surging during normal driving situations. Doge has an article about this but will not address or fix the issue. Their article states that it’s possible that this will not create a code. I have 42000 miles on this engine.

On the night of 30 Oct 2023, I was travelling through St George, Utah on my way back to Las Vegas. I was in the middle lane of traffic doing roughly 75 mph when my passenger side front tire lost all pressure and shredded apart which nearly caused me to slam into the side of a tractor/trailer. After looking over the tire/wheel to determine what caused the failure I noticed the side of the valve stem had blown out. This is the second valve stem where the side of the stem blew out. After researching online it appears this is a recurring problem although something I have never experienced in 30+ years of driving. I have not brought the wheel/valve stem to anyone to inspect the item since the failure is obvious (see pics). There were no warning lamps, messages or other symptoms.

The contact owns a 2020 Ram 2500. The contact stated that after refueling, the vehicle experienced reduced power and sputtering before the vehicle stalled. The vehicle was towed to the local dealer and was diagnosed with a faulty fuel injector. The fuel injector was replaced but the failure eventually recurred. The vehicle was taken back to the dealer who discovered metal shavings in the fuel pump and advised that the fuel pump needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The contact was informed that the VIN was not included in NHTSA Campaign Number: 21V880000 (Fuel System, Diesel). The contact stated that the vehicle had experienced that failure listed in the recall. The failure mileage was 35,000.

Cracked Exhaust manifold, cracked bolts, broken. 17k miles

I was making a left turn and something under my feet or floorboard a loud crack. then as i completed the turn there was a continue cracking sound until I stop. I looked for a problem, finding nothing obvious. As I drove off there was a noticeable knocking sound. Did not notice and different in the driving except a slight drift to the left, there is more knocking on rough roads. My 2020 Ram 2500 truck has only 18946 miles driven. I purchased the truck new, have had several of the recalls taken care of. I live in north Texas as of now 38 days temp over 100F. On a web site there are several others with the same problem and several fixes some have worked others not.

The contact owns a 2020 Ram 1500. The contact stated his son became aware that the rear passenger’s side lug nut had fractured and separated from the wheel. The contact stated while rotating the tires, he noticed that the rear and front driver’s side lug nuts were also fractured. The contact replaced all the lug nuts. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed. The manufacturer had been informed of the failure. The failure mileage was approximately 40,000.

The contact owns a 2020 Ram 2500. The contact stated while driving 55 MPH and towing a 2,500-pound trailer loaded with a 9,000-pound vehicle in hot weather, the MIL warning light illuminated and the message "Service DEF System - See Dealer" was displayed intermittently. Several unknown dealers were notified of the failure and the contact was informed that the VIN was not included in Manufacturer Campaign Number: ZD4. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure but offered no assistance since the VIN was not under recall. The failure mileage was approximately 93,000.

The contact owns a 2022 Ram 2500. The contact received notification of NHTSA Campaign Number: 22V835000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Trailer brake controller issues. When you manually engage the trailer brakes it doesn’t produce enough voltage to the trailer to hold.dealer replace brake controller and module still the same issue. I unplugged the factory brake controller and installed a aftermarket brake controller and it will stop when manually engaged. I feel as if it’s a program issue. Any other vehicle I try on my travel trailer the brakes work. After reading ram truck forums it seems others man be having the same issue. I feel as it is some kind of software or the way the module is programmed only because if I bypass the factory controller with a aftermarket it works on on travel trailer

The contact owned a 2020 Ram 2500. The contact stated while her employee was driving up a low-grade inclined road, and towing a light trailer at approximately 35 MPH, he had noticed white smoke issuing from under the hood. The contact stated the driver had not noticed any warning lights. The contact stated that her employee stopped the vehicle and as soon as he had exited the vehicle had burst into flames, which started under the hood and then ignited the passenger cab in a matter of seconds. The vehicle and trailer were totally engulfed in flames prior to the fire department arriving. The contact stated that the fire department was called and extinguished the fire with water as well as the road surface and grassy areas on the shoulder which were also on fire. The contact stated that the fire marshal had written a report. The vehicle was towed to an impound lot and declared a total loss by the contact's insurance provider. The contact had related the failure to NHTSA Campaign Number: 22V835000 (Power Train) for which she had received a notification and was unable to schedule a recall appointment due to lack of staffing at the dealer. The manufacturer had been informed of the failure. The failure mileage was approximately 5,000.

At around 16000 miles the transmission began to slip and catch aggressively. RMPs would raise up to around 3000 before it slams into the next gear. Dealership stated they ran a computerized test and found no issues.

My name is [XXX]. I have a 2020 Ram Laramie. I purchased the truck June 2nd 2022. So then, my truck did not come with a fitting spare tire. Currently I have 40/13.5r17 on the vehicle. That the manufacturer placed with this truck when I purchased it. The spare that came with the truck, is a 18 inch spare. That doesn’t fit my truck. Also it’s a major safety hazard. My left front tire split on the side so I went to use my spare and it was a wrong tire. Also, I purchase the vehicle with only 17000 miles on it, and No personal owners. Only dealerships. I paid $135,000 cash for it on the spot. Only had it 1 year. Also, now my truck won’t start. Something is wrong with my fuel pump and batteries or something. There suppose to come get it today. I live 30 miles up the mountain in WA state. So I do not do a whole turn of driving. I’m not sure what’s wrong, but I’m kinda stuck without a vehicle now, til it gets fixed I suppose. But I thought I’d let you know, so you can double check you guys products and make sure there now like expired parts or something. Thank you and have a nice day. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

On 5/22/23 I started my vehicle and started to back out of the parking spot, I then received a power steering malfunction service required warning on the dash and lost power steering functionality. The increased steering effort almost resulted in a collision with another vehicle. I took the vehicle in for service and it was diagnosed with a faulty electric assist system on the vehicle and this is being replaced. The vehicle had about 45,000 miles on it at the time of the incident. The first warning light came on when the power steering failed to operate. If this had failed while on the road the results could have been much worse. This is a dangerous defect from early failure of a safety component.

The contact owns a 2020 Ram 2500. The contact stated that while parked, the vehicle failed to start. The contact was able to start the vehicle by banging on the starter underneath the vehicle. The vehicle was taken to the dealer, who informed the contact that the starter needed to be replaced. Additionally, the dealer confirmed the failure as a common issue. The manufacturer was not made aware of the failure. The failure mileage was 40,500.

The contact owns a 2020 Ram 2500. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed, and the vehicle made an abnormal sound and then shuddered. The vehicle was taken to the dealer to perform NHTSA Campaign Number: 21V880000 (Fuel System, Diesel); however, the dealer declined to perform the recall repair. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.