2012 Ford F-350

Defect. PJ's Truck Bodies & Equipment Co., (PJ's) is recalling certain 2009-2013 Ford F-350, F-450, and F-550 Super Duty chassis modified by PJ's and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.

Risk. The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.

Remedy. PJ's has notified owners and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began on August 28, 2014. Owners may contact PJ's customer service at 1-866-475-8782.

Defect. Ford Motor Company (Ford) is recalling certain model year 2011-2012 F-350/450/550 Ambulance Package vehicles manufactured February 22, 2010, through October 19, 2012 and equipped with a 6.7L diesel engine. Due to an exhaust sensor problem, the vehicles may experience loss of power followed by an engine stall.

Risk. An unexpected engine stall increases the risk of a crash. Additionally, if this were to occur when the ambulance is transporting a patient, there is an increased risk of injury to the patient.

Remedy. Ford will notify owners, and dealers will replace the exhaust gas temperature sensor, free of charge. The recall began on November 25, 2013. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332. Ford's recall campaign number is 13S10.

Defect. Manning Equipment Inc. LLC (Manning) is recalling certain model year 2012 Ford F-350, F-450 and F-550 gasoline engined dual rear wheel chassis vehicles manufactured October 2011 through June 2012. The tailpipe on the exhaust system does not extend out beyond the edge of the body, allowing heat to build up in rear curbside storage compartment.

Risk. Excessive heat build up in rear compartment could result in fire.

Remedy. Manning Equipment has notified owners, and dealers will install tailpipe extensions free of charge. The recall has already begun. Owners may contact Manning Equipment at 1-502-426-5210.

Defect. FORD IS RECALLING CERTAIN MODEL YEAR 2011 F-150 VEHICLES MANUFACTURED FROM SEPTEMBER 9, 2011, THROUGH SEPTEMBER 22, 2011, AND MODEL YEAR 2012 F-250, F-350, F-450 AND F-550 HEAVY DUTY VEHICLES MANUFACTURED FROM SEPTEMBER 12, 2011, THROUGH SEPTEMBER 22, 2011. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 114, “THEFT PROTECTION.” THE TRANSMISSION CAN BE SHIFTED OUT OF THE PARK POSITION WITHOUT PRESSING THE BRAKE PEDAL DUE TO BRAKE SHIFT INTERLOCK SWITCH PROBLEM.

Risk. THIS WILL ALLOW THE OPERATOR TO INADVERTENTLY SHIFT THE VEHICLE INTO GEAR WITHOUT THE BRAKE PEDAL BEING DEPRESSED, INCREASING THE RISK OF A CRASH OR INJURY TO A NEARBY PEDESTRIAN.

Remedy. FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE BRAKE SHIFT INTERLOCK SWITCH FUNCTION AND REPLACE THE SWITCH IF NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 22, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

The contact owns a 2012 Ford F-350. The contact stated that while driving at approximately 65 MPH, the message "Loss of Engine Power" was displayed before the vehicle stalled. The vehicle was towed to a dealer, where it was diagnosed and DTC: P0087, P2291, and P2A00 were retrieved. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 128,843.

Death wobble

Bosch CP4 High Pressure Fuel Pump failed in transit cost $10,713 to repair only 155k miles on new engine. Diesel fuel spilled from engine on highway, lucky no fire. Ford no help.

The contact owns a 2012 Ford F-350. The contact stated that while his son was driving 25 MPH, the front track bar unexpectedly fractured into two pieces, causing the vehicle to swerve off the road. Additionally, the vehicle had experienced the death wobble. The vehicle was towed to the dealer, where the contact was informed that the front track bar fracture caused the rear axle to be pushed into the fuel cooler, which caused the fuel cooler to be punctured and to leak. The contact was informed that the front track bar and the fuel cooler needed to be replaced, and a coolant flush needed to be performed. The vehicle had not been repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 300,000.

The contact owns a 2012 Ford F-350. The contact stated while driving at approximately 65 MPH, the contact rolled over a bump and the vehicle started to shudder and sway to the left and right violently. The contact slowed down to 20 MPH and regained control of the vehicle. The contact stated there were no warning lights illuminated. The contact stated that the failure had occurred two years prior. The contact had taken the vehicle to a local dealer who installed dampers and a track bar on the front end. The contact had not yet taken the vehicle to a local dealer or independent mechanic following the failure. The vehicle was not diagnosed and was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 200,000.

I'm currently experiencing the "Death Wobble" with my vehicle, making it unsafe to drive past 60 mph due to intense shaking. This is a serious safety concern for both me and my family. This issue happens frequently on the freeway, and we all fear that the wheels could fall off or the vehicle might flip over. When I took the vehicle to the service center, the advisor told me I needed to add a stabilizer to my front wheels and suggested that I buy the part online and install it myself, recommending YouTube for guidance. However, I have no idea what part to buy or where to get it. I’m not the designer of the truck, and I shouldn’t have to add extra parts for it to drive properly. I also believe this is a manufacturer issue, especially since multiple people seem to be experiencing the same problem.

The contact owns a 2012 Ford F-350. The contact stated while driving at approximately 40 MPH, the vehicle stalled and failed to restart. The vehicle was towed to the residence and a friend diagnosed the vehicle. The contact was informed that the CP4 pump, hard lines, and injectors needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 262,000.

Truck has a random death wabble and differnt speeds. I've taken the truck to three differnt ford dealers multiple times and they alll can't find any worn parts, the dealers all with say ford knows there is a saftey issue with the trucks but don't have a real fix for the issue. several other ford owners have the same issues

Death whoble

2012 F350 Lariat 4x4, 125000 miles. While driving at 65 mph. I hit a spilt in the highway and the truck went into a death wobble, the most violent and scary thing to experience on the crowded highway. Only thing I could do was let it slow down coasting when it finally went away I accelerated back to highway speed and hit yet another bump in the highway and it went into another death wobble so violent I could not control the truck. This truck has no lift and is stock. This will kill someone one day or cause a serious accident. Ford should own this defect and fix it before they responsible for actual death.

I was on the road and I hit a bump on the freeway only going between 55 and 65 mph and the Truck immediately started to whobble out of control I almost hit the car next to me because I could not control it . It was a life and death experience I could never shake off . I spoke to the dealer and they claimed they had never heard of such thing and acted like they didn’t believe me. What ever is wrong with it needs to be recalled because I’m surprised that no one was hurt on rush our in a busy city like Salt Lake City. Ford is being very irresponsible for not fixing the problem.

We have a 2012 Ford F30 Diesel and We are having issues with one of the Exhaust Gas Temperature Sensors (Bank 1 Sensor 3) which would have been covered under Ford's Recall Campaign# 15M02. However, since our vehicle is 11 years and 9 mo old, they are declining coverage as the campaign is limited to 11 years.

The contact owns a 2012 Ford F-350. The contact stated that on several occasions while driving at various speeds, while driving over a small bump in the roadway, the vehicle began violently shaking. The vehicle was brought to a complete stop, and the shaking stopped. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The manufacturer was notified of the failure. The failure mileage was unknown.

Twice in the last 60 days while driving on the Interstate, once at 75mph and this last time at 60mph my Ford F350 has gone into violent shaking, so much so that I was barely able to contain it. I was able to force it off the road and come to a stop. I had to sit there for several minutes then decided to drive slowly to the off ramp. I was able to drive without any wobble and get off the interstate. I took it the first time to Lynn Wood Automotive in Layton, they kept it for several days and found nothing. The second time I took it to Ed Kennely Ford Service. A few of the service writers gathered around as I explained what happened then were nodding there heads and smiling indicating that they had seen is happen several times. I made an appointment next week on July 11th 7:30 am. This was a very dangerous situation and one that I feel very lucky to have gotten it off the road. THis should be a definite RECALL as lives are being put to risk.

The contact owns a 2012 Ford F-350. The contact stated that while driving approximately 45-50 MPH, the vehicle drove over a bump and experienced the death wobble. The contact pulled over and restarted the vehicle. The contact was able to drive to the residence. The vehicle was taken to the dealer, where it was diagnosed that the tie rods and shock absorbers needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but informed the contact that there was no recall associated with the VIN. The contact related the failure to Technical Service Bulletin: 05UPF250SW (05-16 Ford F250 / F350 4WD Vehicles with Steering Wheel Oscillation); however, the vehicle was not covered under the TSB. The failure mileage was approximately 98,000.

The contact owns a 2012 Ford F-350. The contact stated while driving 70 MPH, the vehicle lost motive power and the vehicle was smoking. Additionally, the contact noticed a clinging sound coming from the engine compartment. The contact stated that an 18-wheeler that was driving behind the vehicle, almost crashed into the rear of the vehicle. The contact was able to get the vehicle to the shoulder of the road safely and exited the vehicle. The contact stated the vehicle was engulfed with heavy smoke, but a fire was not present. The contact was concerned for her safety. The vehicle was towed to the dealer where it was diagnosed with a failed fuel system. The contact was informed that the fuel system needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 116,000.

The upper oil pan is leaking and getting worse. Seems to be happening on all 6.7 motors.

Summary: We purchased a brand new 60000 dollar truck in 2012 or 2013 and was assured by the dealer that it had a warranty to cover any issues until either 100,000 miles or 5-6 years, whichever came first. After 4 years of ownership and around 67,000 miles, the truck started experiencing problems with a high idle and then abruptly shutting off. When taken to the dealer, they couldn't replicate the issues during a brief evaluation. However, a week later, while on the way to the bank, to get cash out for are stay at the hospital to give birth to are 6th child the truck shut off and wouldn't start again. The dealer diagnosed the problem as a faulty high-pressure fuel pump due to water in the fuel and tried to charge the author $15,000 for repairs. The author questioned why the diesel fuel water separator and the second fuel filter system on the truck didn't catch the issue earlier and criticized the dealer for their negligence in ensuring safe and reliable transportation.

The contact owns a 2012 Ford F-350. The contact stated that the check engine warning light was illuminated. The contact took the vehicle to the dealer who replaced the reductant heater however, the failure reoccurred. The contact stated that the first repair was covered under Manufacturer Communication Number: 10137151 (Engine and Engine Cooling). The contact took the vehicle to a certified mechanic who determined the same failure had occurred and a similar repair needed to be completed. The vehicle had not been repaired. The manufacturer was made aware of the failure and confirmed that the fix was not covered under warranty. The contact was referred to the NHTSA Hotline. The approximate failure mileage was 56,000.

The contact owns a 2012 Ford F-350. The contact stated while driving at an undisclosed speed, he became aware that the horn was not functioning properly. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the clockspring. The vehicle was repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 22V337000 (Air Bags) however, the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 90,000.