1999 Ford F-350

Defect. CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

Risk. IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.

Remedy. ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.

Defect. ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Risk. OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Remedy. DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)

Defect. ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, FAILURE OF THE FRONT PARKING BRAKE CABLE INPUT BUTTON COULD RESULT IN FAILURE OF THE PARKING BRAKE SYSTEM TO HOLD THE VEHICLE STATIONARY.

Risk. THIS COULD RESULT IN UNINTENDED VEHICLE MOVEMENT AND A VEHICLE CRASH.

Remedy. DEALERS WILL REPLACE THE FRONT PARKING BRAKE CABLE AND THE CONTROLLER AND VERIFY THE PERFORMANCE OF THE PARKING BRAKE SYSTEM. OWNER NOTIFICATION BEGAN APRIL 5, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

Defect. VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH GASOLINE ENGINES AND 8 FOOT BOXES, MAY NOT FULLY SATISFY THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." IN A 30 MPH FRONTAL BARRIER CRASH TEST, A FUEL TANK VAPOR RECOVERY VALVE SEPARATED INTERNALLY. DURING THE SUBSEQUENT STATIC ROLLOVER TEST, FUEL SPILLAGE EXCEEDED THE SPECIFIED RATE.

Risk. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy. DEALERS WILL INSTALL A STOP PLATE ASSEMBLY ON THE VEHICLE FRAME TO PREVENT RECOVERY VALVE CONTACT WITH A FRAME CROSSMEMBER DURING THE IMPACT SEQUENCE.

Defect. VEHICLE DESCRIPTION: GASOLINE AND DIESEL ENGINE PICKUP TRUCKS EQUIPPED WITH 8 FOOT BEDS, DO NOT FULLY SATISFY THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL TANK FRONT STRAP ISOLATOR MAY NOT BE PROPERLY POSITIONED WHICH COULD RESULT IN THE STRAP CUTTING THE TANK DURING A 30 MPH FRONT BARRIER TEST, RESULTING IN FUEL SPILLAGE.

Risk. DURING THE SUBSEQUENT STATIC ROLLOVER TEST, FUEL SPILLAGE EXCEEDED THE SPECIFIED RATE, INCREASING THE RISK OF A FIRE.

Remedy. DEALERS WILL REPOSITION THE FRONT STRAP ISOLATOR.

Defect. VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH 6" BEDS MANUFACTURED FROM JANUARY 5, 1998 THROUGH JUNE 4, 1999, DO NOT NOT FULLY SATISFY THE POST CRASH TEST STATIC ROLLOVER REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." CONTACT BETWEEN THE FUEL TANK AND A FUEL TANK LOCATOR BRACKET DURING A FRONT BARRIER IMPACT TEST RESULTED IN A CUT IN THE TANK, RESULTING IN FUEL LEAKAGE.

Risk. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy. DEALERS WILL REPLACE THE FUEL TANK LOCATOR BRACKET WITH A SIMILAR BRACKET WHOSE DESIGN HAS BEEN REVISED TO INCORPORATE MORE ROUNDED SURFACES WHERE CONTACT WITH THE TANK OCCURS.

Defect. VEHICLE DESCRIPTION: GASOLINE AND DIESEL ENGINE PICKUP TRUCKS EQUIPPED WITH 6" AND 8" BEDS MANUFACTURED FROM JANUARY 5, 1998 THROUGH MARCH 21, 1999, DO NOT NOT FULLY SATISFY THE POST CRASH TEST STATIC ROLLOVER REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." SIX ATTACHMENT BOLTS (M12 BOLTS) MAY HAVE BEEN DAMAGED DURING THE 30 MPH FRONT BARRIER TEST ALLOWING THE BOLTS TO SHIFT OR BECOME DETACHED, RESULTING IN FUEL SPILLAGE.

Risk. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy. DEALERS WILL AUGMENT THE BOX-TO-CHASSIS ATTACHMENT BY INSTALLING BOX-TO-CHASSIS RETAINING CABLES.

Defect. VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES AND CRUISE CONTROL BUILT FROM JANUARY 5, 1998 THROUGH MARCH 4, 1999; 1998-1999 MUSTANGS EQUIPPED WITH 3.8L, 4.6L 2-VALVE OR 4-VALVE ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; 1999 F250/F350/F450/F550 (OVER 8,500 LBS.) TRUCKS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; AND 1999 F-53 STRIPPED CHASSIS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999. A CRUISE CONTROL CABLE CAN INTERFERE WITH THE SPEED CONTROL SERVO PULLEY AND NOT ALLOW THE THROTTLE TO RETURN TO IDLE WHEN DISENGAGING THE CRUISE CONTROL.

Risk. IF THE CRUISE CONTROL IS USED AND THIS CONDITION IS PRESENT, A STUCK THROTTLE COULD RESULT, WHICH COULD POTENTIALLY RESULT IN A CRASH.

Remedy. DEALERS WILL REPLACE THE CRUISE CONTROL CABLES. AT THE PRESENT TIME, THE REPLACEMENT CABLES ARE NOT AVAILABLE. CUSTOMERS ARE BEING ADVISED NOT TO USE THE CRUISE CONTROL SYSTEM UNTIL A REPLACEMENT CAN BE MADE.

Defect. VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS. THE CAST TOW HOOKS CHANGES THE CRASH PULSE OF THE VEHICLE IN FRONTAL BARRIER IMPACTS AND THE AIR BAG SENSOR WAS NOT CALIBRATED TO THIS NEW CRASH PULSE WHICH MAY CAUSE THE AIR BAGS TO DEPLOY IN LOWER SPEED IMPACTS THAN DESIGN INTENT.

Risk. UNEXPECTED AIR BAG DEPLOYMENT CAN RESULT IN PERSONAL INJURY.

Remedy. DEALERS WILL REPLACE THE CAST TOW HOOKS WITH FORGED HOOKS.

Defect. VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS AND CHASSIS-CABS. ONE OR MORE OF THE FOUR RIVETS ON THE LOWER STEERING SHAFT FLEX COUPLING MAY NOT HAVE BEEN CRIMPED DURING THE SUB-ASSEMBLY PROCESS.

Risk. IF A RIVET IS NOT CRIMPED, THE FLEX JOINT CAN ROTATE ON THE SHAFT AND THERE WOULD BE A REDUCTION IN OR LOSS OF STEERING CONTROL.

Remedy. DEALERS WILL INSPECT THE LOWER STEERING SHAFT RIVETS AND REPLACE ANY SHAFTS WITH UNCRIMPED RIVETS.

Defect. VEHICLE DESCRIPTION: SUPER DUTY SINGLE REAR WHEEL PICKUP TRUCKS. THE PARKING BRAKE SYSTEM, WHEN ENGAGED WITH A FORCE OF 125 POUNDS APPLIED TO THE PARK BRAKE FOOT CONTROL, MAY NOT HOLD THE VEHICLES ON A 20 DEGREE GRADE. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS."

Risk. THIS COULD ALLOW A VEHICLE TO ROLL ON AN INCLINE, INCREASING THE RISK OF A VEHICLE CRASH, PERSONAL INJURY, OR PROPERTY DAMAGE.

Remedy. DEALERS WILL BURNISH THE PARKING BRAKE USING A SPECIFIED PROCEDURE.

Defect. VEHICLE DESCRIPTION: SUPERCAB PICKUP TRUCKS. THE POSITIVE BATTERY CABLE IS TAPED TO THE NEGATIVE CABLE WHICH CONTAINS A CLIP TO SECURE THE ASSEMBLY TO THE SIDE FRAME RAIL. IF INCORRECTLY POSITIONED, THE POSITIVE BATTERY CABLE CAN CONTACT THE AIR CONDITIONING COMPRESSOR PULLEY.

Risk. IF THE CABLE WEARS, A COMPLETE ELECTRICAL SYSTEM FAILURE CAN OCCUR AND POTENTIAL SPARKING AND/OR IGNITION OF FLAMMABLE MATERIAL.

Remedy. DEALERS WILL INSPECT AND/OR MODIFY THE BATTERY CABLE CLIPS TO ENSURE THAT THEY ARE PROPERLY LOCATED.

Defect. VEHICLE DESCRIPTION: SUPERCAB PICKUP TRUCKS WITH DUAL REAR WHEEL, AND WIDE FRAME. THE JACKS PROVIDED WITH THESE VEHICLES ARE TOO LARGE TO BE STOWED SECURELY UNDER THE SEAT AS INTENDED AND WERE PLACED LOOSE ON THE FLOOR IN THE REAR OF THE CAB.

Risk. THE JACKS CAN MOVE ABOUT THE PASSENGER COMPARTMENT CREATING THE POTENTIAL FOR PERSONAL INJURY DURING A CRASH OR SUDDEN STOP.

Remedy. DEALERS WILL REPLACE THESE JACKS.

On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 FORD vehicles with triton v-8 and v-10 engines.odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.as of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in …

Ea05-005 is closed with FORD?s actions in recalls 05v-017, 05v-388, and 06v-286, recalling approximately 6.7 million vehicles equipped with texas instruments speed control deactivation switches (scds).the brake systems in these recalled vehicles generate a vacuum that can potentially cause the scds to fail and, in certain switch installation orientations, catch fire.FORD is also including the entire population of 1998 explorers.FORD has informed odi that testing to determine the cause of failures in the 1998 explorers will continue after this investigation is closed.odi believes that the …

This investigation was opened on certain FORD pickup trucks and vans to evaluate the effects of a valve stem ejection (with rapid air loss) and a slow leaking valve stem on vehicle handing.during the investigation, odi evaluated over 1,100 complaints and warranty claims, conducted vehicle dynamic testing on a subject vehicle with the failure mode replicated, interviewed owners, and examined complaint vehicles in the field.the results of the test program indicates the effect of a valve stem ejection on these vehicles is easily controlled. Further, with a population of almost 900,000 vehicles, …

On may 11, 1998, FORD motor company filed a defect information report concerning parking brake failure on certain 1999 f-350 super duty vehicles built at the kentucky truck plant from january 26, 1998 through april 24, 1998; recall 98v-101.the reduction in parking brake effectiveness may occur on some of these vehicles, and is caused by the rust preventative coating the surface of the parking brake lining material which reduces the frictional characteristics at the lining and rotor interface.on march 13, 2000, odi opened rq00-010 on parking brake failures on 1999-2000 model year super duty …

INFORMATION ON TIRE PRESSURE. *TT

The contact owns a 1999 Ford F-350. The contact stated while driving at speeds in excess of 40 MPH, after driving over a pothole in the roadway, the vehicle started shaking and vibrating violently. The contact stated that after slowing down the failure ceased. The cause of the failure was not determined. The local dealer and manufacturer were notified of the failure but no assistance was offered. The failure mileage was 50,000.

This truck has the death wobble. It gets the death wobble at 20 mph. My next step is to sue Ford

TL* THE CONTACT OWNS A 1999 FORD F-350. THE CONTACT STATED THAT WHILE THE OWNER WAS OPERATING THE VEHICLE, THE POWER STEERING ASSIST MALFUNCTIONED. THE CONTACT INDICATED THAT THE POWER STEERING ASSIST WAS AVAILABLE WHILE TURING THE STEERING WHEEL TO THE LEFT HOWEVER, WAS NOT AVAILABLE WHILE TURNING THE STEERING WHEEL TO THE RIGHT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC HOWEVER, THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 190,000.

TL* THE CONTACT OWNS A 1999 FORD F-350. WHILE THE CONTACT'S FATHER WAS DRIVING 55 MPH, HE SWERVED TO AVOID STRIKING ANOTHER VEHICLE. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE DRIVER'S SIDE TIRES DID NOT STOP AND THE STEERING SEIZED. AS A RESULT, THE DRIVER STRUCK A TREE AND THE VEHICLE ROLLED INTO A DITCH. A POLICE REPORT WAS FILED. THE AIR BAGS DID NOT DEPLOY. THE CONTACT'S FATHER SUSTAINED BLUNT FORCE TRAUMA TO THE TORSO AND WAS FATALLY INJURED UPON IMPACT. THE VEHICLE WAS NOT DIAGNOSED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000. THE VIN WAS NOT AVAILABLE.

TAKATA RECALL. I WAS DRIVING DOWN THE ROAD AND MY TRUCK SHUT OFF RANDOMLY MY OVERDRIVE LIGHT STARTED FLASHING AFTER THIS AND CONTINUED TO FLASH AND STILL SHUTS OFF SO I REPLACED MY FUEL FILTER, CPS SENSOR AND IT STILL SHUTS OFF. IT'S LIKE I'M GOIN DOWN THE ROAD AND IT STALLS. IT DOES IT MORE THAN ONCE WHEN I'M DRIVING I JUST SHUT IT OFF AND START IT AGAIN.

TL* THE CONTACT OWNS A 1999 FORD F-350 EQUIPPED WITH HANKOOK DYNAPRO AS TIRES, SIZE: 235/85R16. WHILE DRIVING ABOVE 45 MPH, THE VEHICLE WOULD SWERVE UNCONTROLLABLY. THE CONTACT ALSO NOTICED THAT THE FRONT TIRES WERE WEARING DOWN QUICKLY AND UNEVENLY, BUT THE REAR TIRES SHOWED NO FAILURES. THE LOCAL TIRE STORE WAS CONTACTED AND STATED THAT THEY NO LONGER SERVICED OR SOLD HANKOOK TIRES. THE CONTACT CALLED THE MANUFACTURER AND LEFT A VOICE MESSAGE. THE VEHICLE FAILURE MILEAGE WAS 370,000. THE TIRE FAILURE MILEAGE WAS UNKNOWN.

01/2016: VEHICLE WAS BEING DRIVEN HOME FROM WORK WHEN THERE WAS A LOSS OF ENGINE POWER. VEHICLE WAS ABLE TO ROLL TO A STOP IN THE PARKING LOT OF A CHURCH. LATER IT WAS DETERMINED THIS RESULTED FROM FAILURE OF #7 CYLINDER INJECTOR UNIT, BELIEVED TO HAVE FAILED DUE TO DELAMINATION INSIDE OF FUEL TANK. ABOUT 02/23/2014, 207980 MILES: FUEL TANK HAD BEEN REMOVED AND INTERNAL SCREENS CLEARED DUE TO THE ENGINE STALLING WHILE DRIVING PRIOR TO INJECTOR FAILURE. INTERNAL PICK-UP TUBE SCREENS WERE BLOCKED WITH DELAMINATION MATERIAL FROM THE INSIDE OF THE TANK. TWO NEW FUEL PUMPS HAD BEEN PURCHASED AND INSTALLED PRIOR TO CLEANING THE INTERNAL PICK-UP SCREENS. I HAVE RECEIPTS FOR WORK AND PARTS RELATING TO THE FUEL SYSTEM PROBLEM. *TR

TL* THE CONTACT OWNS A 1999 FORD F-350, EQUIPPED WITH ALCOA WHEELS, SIZE: 16 X 6. WHILE DRIVING 55 MPH, THE WHEELS VIBRATED. THE CONTACT PULLED THE VEHICLE OVER AND NOTICED THAT THE FRONT DRIVER SIDE WHEEL SPOKES WERE FRACTURED. THE CONTACT WAS ABLE TO CHANGE THE WHEEL AND DRIVE THE VEHICLE HOME. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS NOT ABLE TO BE DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 130,000.

SPARK PLUG EJECTION FROM HEAD ON STARTUP.

TL* THE CONTACT OWNS A 1999 FORD F-350. WHILE DRIVING APPROXIMATELY 30 TO 35 MPH, THE FRONT END OF THE VEHICLE SHOOK UNCONTROLLABLY. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND THE CONTACT NOTICED THAT THE FRONT AXLE ASSEMBLY BRACKET WAS COMPLETELY RUSTED. THE FRONT AXLE ASSEMBLY BRACKET WAS REPLACED AND THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 167,000.

TAKATA RECALL WHILE TRAVELING AT HIGHWAY SPEEDS THE RIGHT FRONT TIRE LOST ALL AIR AFTER TAKING TIRE AND WHEEL IN TO GET FIXED THE TIRE SHOP SAID THE WHEEL HAD SEPERATED CAUSING THE TIRE TO LOOSE AIR LEFT FRONT TIRE NOW LOOSING AIR I HAVE TALKED TO SEVERAL PEOPLE WITH SAME PROBLEMS ON FORD F350 1TON DULLYS04

BOTH FRONT ALUMINUM RIMS CRACKED, FIRST ONE I REPAIRED IN 2006 THE SECOND ONE JUST HAPPENED AND IS NOT REPAIRABLE. 120 K ON TRUCK. DEALER TOLD ME NOTHING HE COULD DO ON THE FIRST ONE. THESE RIMS ARE DEFINITELY DEFECTIVE AND UNSAFE!

TL* THE CONTACT OWNS A 1999 FORD F-350. WHILE THE VEHICLE WAS AT THE DEALER FOR ROUTINE MAINTENANCE, THE MECHANIC INDICATED THAT THE REAR AXLE WAS FAULTY AND WOULD NEED TO BE REPLACED. ALTHOUGH THE VEHICLE HAD NOT EXPERIENCED ANY FAILURES, THE REAR AXLE WAS REPLACED. THE CONTACT INDICATED THAT APPROXIMATELY 30,000 MILES, LATER THE MECHANIC INDICATED THAT THE REAR AXLE WAS FAULTY AGAIN AND THE AXLE WAS REPLACED A SECOND TIME. AFTER HAVING THE AXLE REPLACED, THE CONTACT WAS UNABLE TO SHIFT TO THE SIXTH GEAR WHILE DRIVING APPROXIMATELY 65 MPH. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 363,000. UPDATED 7/14/15*CN UPDATED 10/16/2017*CN

TL*THE CONTACT OWNS A 1999 FORD F-350 EQUIPPED WITH MICHELIN TIRES, TIRE LINE: X RADIAL LT, AND TIRE SIZE: 265/75/R16. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 65 MPH, THE REAR DRIVER'S SIDE TIRE BLEW OUT WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TIRES WERE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE OF THE TIRE AND THE VEHICLE WAS 220,000. THE DOT NUMBER WAS NOT AVAILABLE.

DRIVING MY 1999 FORD F350 DIESEL DOWN THE HIGHWAY, APPROXIMATELY 50 MPH, HEARD A THUMP AND LOUD SCRAPING NOISE. COULD NOT PULL OVER DUE TO TRAFFIC, PULLED OVER WHEN TRAFFIC CLEARED, AROUND ANOTHER 100 FEET. I GOT OUT AND LOOKED AROUND AND UNDER TRUCK, TO DISCOVER FUEL TANK WAS DRAGGING ALONG THE HIGHWAY. REAR FUEL TANK STRAP HAD BROKEN. *TR

TL* THE CONTACT OWNS A 1999 FORD F-350. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE, THE MECHANIC NOTICED THAT THE FUEL STRAPS WERE DISCONNECTED AND COVERED WITH RUST. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 122,000. UPDATED 10/28/2014*LJ UPDATED 04/21/2015 *JS

LARGE AMOUNT OF TRANSMISSION FLUID LEAKED OUT ON DRIVEWAY MAKING TRUCK UNABLE TO DRIVE. *TR

TL* THE CONTACT OWNS A 1999 FORD F-350. THE CONTACT STATED THAT WHEN THE PARKING BRAKE WAS ENGAGED, THE VEHICLE CONTINUED TO ROLL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE PARKING BRAKE WAS REPLACED SEVERAL TIMES BUT THE DEFECT WAS NOT REMEDIED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 35,000.

TL* THE CONTACT OWNS A 1999 FORD F350 WITH UNIROYAL LIBERATOR TIRES, SIZE: LT265/75/16. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE REAR DRIVER'S SIDE TIRE BLEW WITHOUT WARNING. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 170,000 AND THE TIRE FAILURE MILEAGE WAS 10,000. THE DOT NUMBER WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 1999 FORD F-350. THE CONTACT STATED THAT THE PARKING GEAR AND THE EMERGENCY BRAKE FAILED. THE CONTACT WAS TOLD BY THE DEALER THAT THE PARKING BRAKE CABLE WOULD NEED REPLACING AND THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 02V068000 (PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE AND CABLE). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 120,000 AND THE CURRENT MILEAGE WAS 180,000.

TL* THE CONTACT OWNS A 1999 FORD F-350. THE CONTACT NOTICED THAT THE METAL SURROUNDING THE REAR LIFT GATE WINDOW WAS SEPARATING AND CAUSING A LEAK. ALSO, THE RIDGES ON THE ROOF WERE SEPARATING AND CORRODING. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 1999 FORD F-350. THE CONTACT STATED THAT WHILE TRAVELING 40 MPH, THE POWER STEERING FAILED AND CAUSED THE CONTACT TO CRASH INTO A SNOW BANK. THE CONTACT WAS UNINJURED. THE VEHICLE WAS TOWED TO A REPAIR SHOP WHERE THE VEHICLE WAS INSPECTED. THE TECHNICIAN ADVISED THE CONTACT THAT THE FAILURE WAS CAUSED BY CRYSTALLIZATION OF THE STEERING SHAFT, WHICH WAS FRACTURED. THE FAILURE AND THE CURRENT MILEAGE WAS 145,000. UPDATED 02/15/12*LJ THE CONSUMER STATED THERE WAS NO ROAD HAZARD TO CAUSE THE STEERING SHAFT FAILURE. UPDATED 02/17/12

I OWN A 1999 FORD F-350 I PARKED IN MY DRIVE WAY AT 8 PM ON JANURARY 1 AND WOKE UP AT TO A LOUD BOOM AT 5 AM IN THE MORNING . FORD SENT ME A RECALL NOTICE ON DECEMBER 30 WAS GOING TO SET A APPOINTMENT ON JANURARY 2 UNFORTUNATELY THE TRUCK BURNED MONDAY MORNING. ALSO HAVE A FORD EXPEDITION LOOKED UP THE VEHICLE IDENTIFICATION NUMBER AND IT TO HAS THE SAME PROBLEM FORD HAS YET TO SEND ME A RECALL NOTICE. NOW ARGUING WITH INSURANCE COMPANY THEY WANT TO GIVE ME NOTHING FOR MY TRUCK.

REAR FUEL TANK STRAP THAT HOLDS THE FUEL TANK IN POSITION FAILED. IN 2003 FORD HAD A RECALL ON THIS TRUCK TO INSTALL SAFETY STRAPS AROUND THE FUEL TANK IN CASE THERE WAS A FAILURE OF THE MAIN STRAPS. WHEN THE REAR STRAP FAILED THE SAFETY STRAP FAILED AND THE ONLY THING HOLDING THE TANK IN THE TRUCK WAS THE FUEL LINE. THE TANK WAS ABOUT 3/4 FULL IF IT HAD SEPARATED ALL TOGETHER IT WOULD HAVE BEEN A DISASTER AND PROBABLY A FIRE. *TR

TL* THE CONTACT OWNS A 1999 FORD F-350 PICK UP. THE CONTACT WAS DRIVING 60 MPH WHEN THE FUEL STRAPS DETACHED FROM THE FUEL TANK. THE VEHICLE WAS TOWED TO DEALER WHERE THE DEALER CONFIRMED THAT BOTH FUEL TANK STRAPS WERE RUSTED AND NEEDED REPLACEMENT. THE MANUFACTURER WAS CONTACTED AND THEY CONFIRMED THE VIN DID NOT QUALIFY FOR RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 99V311000 ( FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY). THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 121,000 AND THE CURRENT MILEAGE WAS 124,000.

THE TRUCK WAS BOUGHT IN CANADA AND SHIPPED TO GERMANY APROX. JUNE 2000. BECAUSE OF MUCH CORROSION AT THE CHASSIS I DECIDED TO REMOVE THE CHEAP BITUMEN PROTECTION AND TO COVER THE CHASSIS WITH SPECIAL PAINTS. DOING THIS, I DISCOVERED, THAT THE IRON BELTS OF THE FUEL TANK WAS COMPLETELY ATTACKED BY CORROSION. MAY BE 20 % OF IRON HAD CHANGED INTO FEO. IN THIS MOMENT, THE BELT WOULD NOT HAVE BROKEN, MAY BE 3 OR 5 YEARS LATER. IF MY REPORT IS NOT 100 % CLEAR IT'S BECAUSE ENGLISH IS NOT MY MOTHER LANGUAGE.

1999 FORD F-350. UNIT #1 WAS TRAVELING WESTBOUND IN THE RIGHT HAND LANE ON THE OHIO TURNPIKE. UNIT #1 HAD A RIGHT TIRE BLOWOUT CAUSING THE DRIVER TO LOSE CONTROL AND STRIKE THE GUARDRAIL OFF THE RIGHT SIDE OF THE ROADWAY. UNIT #1 CAME TO A CONTROLLED STOP AFTER STRIKING THE GUARDRAIL. *LN ACCORDING TO THE POLICE REPORT, ALL THE TIRES WERE IN GOOD CONDITION, BUT ALL WERE FROM DIFFERENT MANUFACTURERS AND ALL HAD DIFFERENT READ PATTERNS. THE DRIVER STATED THE TIRE BLOWN TIRE NEEDED TO BE REPLACED. (OHIO TRAFFIC CRASH REPORT # 10-0460-91)*JB

TL*THE CONTACT OWNS A 1999 FORD F350. THE CONTACT STATED THAT THE PASSENGER SIDE REAR DUAL WHEEL STUDS FRACTURED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY REPLACED THE EIGHT DEFECTIVE WHEEL STUDS. THE FAILURE MILEAGE WAS APPROXIMATELY 115,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 1999 FORD F-350. WHILE TRAVELING 70 MPH THE CONTACT NOTICED A LOUD POP SOUND COMING FROM OUTSIDE THE VEHICLE, SECONDS LATER, THE CONTACT NOTICED THAT THE PASSENGER SIDE TIRE HAD SUDDENLY EXPLODED WITHOUT WARNING CAUSING THE CONTACT TO CRASH INTO A NEARBY GUARD RAIL. THE CONTACT SUFFERED A CONCUSSION. A POLICE REPORT WAS FILED FOR THE INCIDENT. THE VEHICLE HAD NOT BEEN DIAGNOSED AND THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WAS 50000.

HERE'S WHAT HAPPENED ON 7-26-09 I WAS ON MY WAY BACK TO FORT WORTH FROM AUSTIN, TX FROM A TRADE SHOW WHEN ABOUT 3:00 PM ON HWY I-35E 19 MILES SOUTH OF WACO TX THE I FELT A SUDDEN VIBRATION AND THUMPING IN THE FRONT. I STARTED TO SLOW DOWN TO GET OFF THE ROAD TO CHECK IT OUT WHEN FRONT LEFT TIRE BLEW OUT, CAUSING THE TRUCK TO SEVERELY VEER TO THE LEFT TRYING MY BEST TO KEEP THE TRUCK FROM ROLLING, THEN HITTING THE CONCRETE GUARD RAIL WHICH DEFLECTED THE TRUCK ENOUGH TO SLIDE DOWN THE BARRIER FOR ABOUT TWO HUNDRED FEET TILL IT STOPPED. I FELT LUCKY TO BE ALIVE. IF I WOULD HAVE BEEN IN THE RIGHT LANE AT THE TIME I WOULD HAVE TAKEN CARS OUT AS WELL. I WAS ABLE PUT THE SPARE ON AND LIMP BACK HOME THIS IS THE THIRD TIRE OUT OF THE FOUR ALL THE SAME BATCH I HAVE HAD THROWN TREAD AND THE LAST WAS BLOW OUT! ALL INSTALLED AT THE SAME TIME AND BRAND. FIRST ONE THREW TREAD ON 10-14-08 LEFT REAR DID SOME DAMAGE. OK THINGS HAPPEN, I HAVE WARRANTY ON IT FROM DISCOUNT TIRES, THEY REPLACED IT.. THEN THE NEXT THREW OFF IT'S ON 7-21-09 RIGHT REAR TIRE. DISCOUNT TIRE REPLACES IT TOO.. I HAD THEM LOOK AT THE OTHERS TIRES AND CHECK FOR DEFECTS, EVERYTHING WAS FINE.. FIVE DAYS LATER THIS BLOW OUT ON THE DRIVERS FRONT' THREE TIRES THROWING TREAD IN 9 MONTHS AND TWO WITH IN A WEEK I WAS THINKING THIS IS NOT A COINCIDENCE, THIS IS THE DEFINITE SIGN OF DEFECTIVE TIRES. I STILL HAVE ONE MORE TIRE ON THE TRUCK WHICH LOOKS PERFECTLY GOOD.. I WILL ASK TO HAVE REPLACED AS WELL. I'M NOT HAVING ANY LUCK WITH

I HAVE A 1999 FORD F-350 WITH THE V-10 ENGINE AND ONLY 60,000 MILES. COMING BACK FROM DENVER - NOT HAULING ANYTHING - THE ENGINE BLEW OUT A SPARK PLUG. THIS IS A KNOW DEFECT AND WELL DOCUMENTED ON FORD PROBLEMS.COM. GIVEN THE NUMBER OF OCCURRENCES THAT THIS HAS HAPPENED, AND THE POSSIBLE SAFETY ISSUES WITH A BLOWN OUT PLUG I RESPECTIVELY REQUEST THAT THIS BE CONSIDERED AS A RECALL MATTER ON ALL SUCH EQUIPPED VEHICLES. *TR

I HAVE A 1999 FORD F350. I HAVE THE BRAKES WORKED ON 4 SEPARATE TIMES IN THE 5 YEARS SINCE THE TRUCK FROM MY FATHER IN LAW. THE FRONT START TO SHAKE VERY HARD AND FINAL SLOWS DOWN. I HAVE HAD THE ROTORS REPLACE THE CALIPERS REPLACED AND THE ROTORS TURNED. I HAVE ONLY PUT 60,000 MILES ON THIS TRUCK AND MY FATHER IN LAW HAD PUT 160,000. HE WAS HAVING THE SAME PROBLEM WITH THE BRAKES. I HAVE TAKEN IT TO THE DEALER EACH TIME AND THEY SAY IT IS HARD DRIVING. I HAVE NOT BEEN PULLING ANY TRAILERS WITH IT AND THE BRAKES USUALLY START SHAKING WITHIN A COUPLE THOUSAND MILES OF THE BRAKE JOB. *TR

DRIVING ON BLACKTOP DIVIDE HIGHWAY AND THE CABLE THAT HOLDS THE SPARE TIRE BROKE (CORRODED THROUGH) LETTING THE SPARE TIRE DROP OUT FROM UNDER THE TRUCK. THE TIRE THEN ROLLED ACROSS THE HIGHWAY AND JUST MISSED HITTING AN ON COMING CAR. THIS IS A COMMON PROBLEM WITH THE SPARE TIRE HOLDER FROM WHAT I READ ON THE INTERNET CHAT ROOMS. *TR

TL*THE CONTACT OWNS A 1999 FORD F350. THE VEHICLE HAS COOPER TIRES. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE BEGAN VIBRATING EXCESSIVELY. THE CONTACT PULLED OVER AND NOTICED THAT THE REAR DRIVER SIDE TIRE WAS COMPLETELY SEPARATED FROM THE VEHICLE. HE REPLACED THE TIRE. FOUR WEEKS LATER, THE TREAD SEPARATED FROM THE FRONT DRIVER SIDE TIRE. TWO WEEKS LATER, THE REAR PASSENGER SIDE TIRE EXPERIENCED THE SAME FAILURE. THE MANUFACTURER STATED THAT HIS VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 06T016000 (TIRES:TREAD/BELT); HOWEVER, ALL THREE TIRES WERE REPLACED. THE VIN, ENGINE SIZE, TIRE LINE AND SIZE WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 19,000.

TL*THE CONTACT OWNS A 1999 FORD F350. WHILE DRIVING 55 MPH, THE VEHICLE BEGAN TO SHAKE. THE CONTACT NOTICED AN AIR BUBBLE ON THE DRIVER SIDE TIRE. SHE TOOK THE VEHICLE TO THE TIRE PLUS STORE WHERE IT WAS REPLACED UNDER WARRANTY. THE FAILURE RECURRED, HOWEVER, THERE WERE FOUR AIR BUBBLES IN THE TIRE AND THE TREAD HAD SEPARATED FROM THE RIM. THE TIRE STORE STATED THAT THEY WILL NOT REPAIR IT UNDER WARRANTY AND THAT SHE WOULD HAVE TO PURCHASE NEW TIRES. THEY ALSO SUGGESTED THAT SHE WAS STRIKING THE CURB WHEN PARKING AND DRIVING, WHICH WAS THE CAUSE OF THE FAILURES. THE CONTACT REPLACED THE TIRES HERSELF. THE TIRES WERE BRIDGESTONE DUELER A/T 693, SIZE LT265/75R16. THE DOT NUMBER WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 100,000.

FUEL DRAIN O RING FAILS ALLOWING FUEL LEAKAGE DURING OPERATION IN FORD AMBULANCES F350 BUILT IN 1999. *JB

DT*: THE CONTACT STATED WHILE TRAVELING 65 MPH, A THUMPING NOISE WAS HEARD IN THE FRONT END. THE CONTACT SLOWED THE VEHICLE TO 5 MPH, AND PULLED OVER A MILE LATER. THE TREAD HAD SEPARATED FROM THE PASSENGER SIDE FRONT TIRE. THE TIRE WAS CHANGED AND HAS NOT BEEN TO A MECHANIC. THIS IS A CONTINENTAL LT23585R16 TIRE.

DT*: THE CONTACT STATED THE LEFT REAR TIRE BLEW OUT WHILE DRIVING 65MPH. THE FRONT DRIVER SIDE AIRBAG IMMEDIATELY DEPLOYED, ALTHOUGH THERE WAS NO CONTACT WITH THE SENSOR. THE VEHICLE WAS DRIVEN TO THE CONTACT'S GARAGE, BUT HAS NOT BEEN INSPECTED. THE POLICE WERE ALERTED IN ORDER TO ASSIST WITH TRAFFIC WHILE THE TIRE WAS BEING CHANGED. THE DRIVER RECEIVED MINOR INJURIES TO THE ARM, BUT WAS WEARING A SEAT BELT. THERE WAS NO CONCERN ABOUT THE SAFETY OF THE TIRE BECAUSE THE CONTACT FELT THE BLOW OUT COULD HAVE BEEN RELATED TO A NORMAL ROAD HAZARD. THE PRIMARY CONCERN EXPRESSED WAS WITH THE UNWARRANTED DEPLOYMENT OF THE FRONTAL AIR BAG.

DT: THE CONTACT STATED BOTH FRONT RIMS CRACKED. THE FIRST RIM CRACKED ABOUT SIX MONTHS AGO AND WAS REPLACED. THE SECOND RIM HAS NOT BEEN REPLACED. THIS STARTED WITH A HAIRLINE CRACK ON THE SPOKE, THEN AFTER DRIVING THE CRACK WENT ALL THE WAY THROUGH. *AK

1999 FORD F-350 LEFT REAR DUAL TIRES CAME OFF. *TS THE POLICE REPORTED STATED THE DUAL STUDS WERE ALL SHEARED OFF. THERE WAS A POSSIBILITY THE STUDS WERE BROKEN PRIOR TO THE INCIDENT. *JB

1) CRUISE CONTROL WOULD NOT ALWAYS SET & WHEN I TOUCHED THE BRAKE IT WOULD NOT ALWAYS STOP. *JB

DT: CONTACT STATED WHEN STEPPING ON THE BRAKES THE CAR JUMPED ALL OVER THE ROAD AND IT WILL NOT STOP. IT BOUNCED AROUND UNCONTROLLABLY. CONTACT NOTICED THIS PROBLEM WITH LESS THAN 3,000 MILES ON IT IN 1999. THE DEALER TOLD CONTACT THAT IT WAS THE BRAKES ON AND HE HAD BRAKES ON THE CHANGED. BUT, PROBLEM RECURRED AS LONG AS BRAKES WERE ON. WHEN CONTACT HAD THE ABS BRAKES DISCONNECTED PROBLEM DISAPPEARED. *AK

THE FRONT RIMS HAD CRACKS ON THEM. THIS CAUSED THE FRONT TIRES TO LOSE AIR PREMATURELY. DEALERSHIP REPLACED THE RIMS/TIRES. *AK

WHILE4 DRIVING AT 40 MPH CONSUMER HEARD A POPPING NOISE UNDER THE HOOD. CONSUMER HAD THE VEHICLE TOWED. DEALERSHIP INFORMED THE CONSUMER THAT THE PROBLEM PERTAINED TO THE SPARK PLUG FAILURE. THE PROBLEM WAS NOT RESOLVED. *AK THE CYLINDER HEAD FAILED. THE SPARK PLUG FELL OUT OF THE ENGINE. *TC

WHEN ACCELERATING VEHICLE SLIPPED GEAR OR JERKED FORWARD. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

WHILE DRIVING 70 MPH THE REAR DRIVER'S SIDE TIRE TREAD SEPARATED, AND ABOUT 50 MILES LATER THE REAR PASSENGER SIDE TIRE TREAD SEPARATED. *AK *SC

WHILE DRIVING 65 MPH CONSUMER HEARD A LOUD NOISE AND THE VEHICLE VIBRATED UNCONTROLLABLY. THE CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND PULLED OVER. THE CONSUMER INSPECTED THE VEHICLE AND NOTICED THAT THE PASSENGER REAR TIRED BLEW OUT. *AK THE TREAD SEPARATION REPEATED ON TWO OTHER OCCASIONS. *SC

WHILE DRIVING 50-55 MPH THE CONSUMER EXPERIENCED TREAD SEPARATION ON THE RIGHT FRONT TIRE. THERE WERE TWO ADULTS AND TWO CHILD PASSENGERS IN THE VEHICLE DURING THE INCIDENT. *AK *TS *SC *JB

WHILE DRIVING 65 MPH VEHICLE VIBRATED UNCONTROLLABLE. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND PULLED OVER. DRIVER INSPECTED THE VEHICLE, AND NOTICED THAT THE TREAD WAS SEPARATING. THE TIRES WERE TAKEN TO THE REPAIR SHOP FOR INSPECTION. MECHANIC DETERMINED THAT THE TIRES NEEDED TO BE REPLACED DUE TO TREAD SEPARATION. *AK THE TIRES WERE REPLACED. *TC

THE CONSUMER HAD TWO SETS OF SIX FIRESTONE STEELTEX TIRES WITH CRACKS IN THE SIDEWALL. *NM FIRESTONE WOULD NOT REIMBURSE THE CONSUMER FOR THE TIRES. *JB