2023 Chevrolet Silverado 1500

Defect. General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.

Risk. Engine failure increases the risk of a crash.

Remedy. Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.

Defect. General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."

Risk. Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.

Remedy. The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.

Defect. General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk. DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.

Remedy. The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.

I have noticed a ticking noise that is coming from the engine, driver side, the tick after the recall was preformed, 5-23-2025. The tick has grown in loudness from that date. Took the truck to the dealership and they did a check but was unable to locate anything, no parts were removed and no witness marks on any of the engine areas Example oil pan and so on. I was told that they would charge me if the truck was brought back for the same issue per GM not the dealership. They have been doing my oil changes at a 3,000 mile interval. The tick has gotten progressively louder, and I am nervous about driving my truck but I can't not work.

My truck had done the oil update and pico test per gm’s requirements before I had bought it in October of 2025. 8 months later and about 15,000 miles, the engine seized and needed to be replaced. The new engine went in, in late July of this year.

While operating at highway speeds this truck lost all engine power and would not start back up. Vehicle was towed to local dealer and determined to be a catosrophic failure of the crank shaft. Repairs are being made as covered under warranty.

The engine in my 2023 Silverado ZR2 (6.2L L87 V8) failed. It is available for inspection at Rick Hendrick Chevrolet ([XXX]). On XXX at about 67,000 miles, and the days leading up to it, the truck repeatedly struggled to start due to metal on metal contact, almost leaving me and my family stranded multiple times. Driving the vehicle produced a loud rattling noise at 2200 to 2700 rpm, and felt unsafe to drive. Especially with my family. The problem was reproduced and confirmed to be an engine failure by the Rick Hendrick Chevy dealership a week after being dropped off with an appointment. I have been told the engine needs to be replaced under the special coverage program (N252494003). The L87 recall inspection and oil change was completed on XXX also by Rick Hendrick Chevy. There were not warning lights or other symptoms leading up to this engine failure. The symptoms of struggling to start and the ticking noise as 2200 to 2700 RPM started that weekend before I brought to dealership. They got progressively worse. Dealership has said I will receive a new engine under warranty but no timeline for completion. Additionally I have not been furnished with a service loaner or option for one. Leaving me with no vehicle to replace it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Engine failed and was replaced at 38k. Transmission shudders, have been back to dealership multiple times for transmission shudder, have been told it was tires, torque converter, and valve body. When those items didn’t fix the issue, I was told it was the engine dfm and that it was normal and not a problem, AFTER they had already acknowledged the transmission issue by trying to fix it with a torque converter and valve body. Engine failed again at 54,604 miles while at high way speeds in rush hour like traffic in between [XXX] and [XXX], while pulling a camper. Truck oiled down the interstate and produced a blueish/milky looking cloud that caused drivers behind me to lock up their brakes because of bad vision, creating a hazard. I was told by gm that they wouldn’t tow the camper that I had to take care of that but they wouldn’t tow send a truck for my truck. Tow truck gets there and says my truck is too big and leaves. I called my own rollback to get my truck 3 1/2 hours later and they came and got it. Was stranded on the side of the interstate for 4 1/2 hours in 90 degree weather, to my knowledge the 2nd truck gm was supposed to send never showed up. Requested a buyback and was denied with no reason given. I have a lot of records if anyone wants them. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Catastrophic Engine failure - Chevy, Silverado 1500, Yr: 2023; Odometer: 33,183: On 8/16/2026 we were traveling down a busy highway towing our camper and the engine completely stopped, no propulsion, no warning lights, no check engine lights; complete failure; we had to coast to side of road. The only thing that indicated a problem is that we started hearing what sounded like marbles rattling, it wasn't loud but noticeable. We pulled over at gas station to check oil, even though we just had the oil changed for maintenance on 7/17/2026 (Odometer: 32,587). Everything checked out ok; however, the marble sound became louder; then within 5 minutes of leaving the gas station, we lost all engine propulsion; the engine completely shut down. Our safety was put at risk as we had no truck engine and were towing a camper on a busy highway; and had to try and coast to a safe location on side of road; miles away from home. We had to call a tow truck to come get us and unfortunately, they could not help us with our camper so then had to call our son to come with his truck to get our camper and us home safely. The tow company also had a difficult time getting the truck into neutral to tow. The truck was towed to our hometown Chevy Dealer. The dealer said that they were not going to diagnose the problem and instead are ordering a new 6.2 engine; same as the 6.2 that failed. We asked if this would fix the problem and they said there were no guarantees as it is the same engine with the same pro

I had the 6.2 engine replaced at 38k miles. Now at 78k miles my new engine replacement is using 1.5qrt of oil within 4k miles. I am being told i have to watch the oil every 800 miles and report back to Chevrolet. I feel my investment is completely a loss of $60,000.00 + . I was told by the service tech that i will probaly have to have another engine replaced again.. My resale value is NO WHERE near worth anything and I am stuck.

My Second motor blew up while towing my camper with my entire family in the vehicle, leaving us stranded 1 foot from interstate traffic for over an hour as we waited for a tow truck—this was GM's 3rd attempt to fix the problem. There were no warning signs. The motor had roughly 4 thousand miles on it. I have since gotten rid of this truck (and suffered financial loss) before it gets me or someone else killed. GM needs to fix this. o30,317 miles – Started using Heavier oil 6/18/2025 o36,732 miles – Recall “fix” 11/10/2025 o38,917 miles – 1st Engine Failed 1/9/2026 oTruck returned to me – 1-24-26 o43617 miles – 06/20/2026 Replacement motor blew up I can't remember the exact speed, but I was going with the flow of traffic, so I'm going to guess it was 70-75. The file CTCS654636 is the second motor failure. Starr RO 626023.pdf is the first engine failure. and i have also uploaded the two files of when i swapped oil and had the recall fixed.

After the recall was done on my truck, it now makes a ticking noise that wasn't there before. When I bring this to the attention of the service department at the dealership where I purchased it, they say that noise is completely normal and sent me on my way.

Front. Camera keep freezing up and failed at 40000 miles its a defect and should be replaced free you have a bulletin outTSB23-NA-095

Description of the Problem: My 2023 Chevrolet Silverado 1500 has a recurring transmission issue involving hard shifting and shuddering during normal driving. The transmission frequently hesitates, clunks, or jolts when changing gears, especially at low to moderate speeds. These symptoms occur consistently and have worsened over time. Safety Concerns: The harsh gear engagement and shuddering make the vehicle difficult to control smoothly. It feels like something will break while I'm driving. The unpredictable shifting behavior feels unsafe in traffic, during merging, and when accelerating from a stop, or driving on the freeway. I am concerned this may be related to widespread transmission complaints reported by other 2023 Silverado owners, including valve body and TCM failures. Service History: I have not contacted my dealership regarding the issue. Why I’m Reporting: I believe this transmission behavior presents a potential safety defect. I am submitting this complaint so NHTSA can review it as part of ongoing monitoring of similar issues reported for this model year.

On [XXX], my 2023 Chevrolet Silverado 1500 ZR2 (VIN: [XXX]) underwent GM's safety recall service for the 6.2L L87 V8 engine (Recall N252494000 / Special Coverage N252494003). The vehicle passed dealer inspection and received the prescribed higher-viscosity oil and calibration remedy. On [XXX], at 25,287 miles—less than five months and a few thousand miles after the recall was performed—the engine suffered a catastrophic internal mechanical failure, resulting in a sudden and complete loss of propulsion while I was getting off of the freeway. I had to coast to a stop on the side of the road. I had it towed to Murcock Chevrolet. The vehicle was serviced at Murdock Chevrolet (Woods Cross, UT), where technicians confirmed the internal failure and completed a full engine long-block replacement under GM Special Coverage warranty (Invoice total: $10,852.26). GM's initial recall remedy failed to prevent catastrophic failure, posing a serious safety hazard due to unexpected propulsion loss while operating the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Total Engine failure Was traveling at approximately 45 miles an hour and locked up. Thankfully on a 2 lane road with minimal traffic, highway could have been a totally different story. Problem has been confirmed by dealer I am unaware of inspection besides by dealer. No warning lamps or other symptoms until right before failure.

6.2 liter vehicle engine failure while moving on interstate April 1, 2026 … (I responded to first recall notice and Hendrick Chevrolet of Naples, Fl. completed inspection and oil replacement in 2025) … engine replaced by Estero Bay Chevrolet June 2026 at 72,495 miles on odometer … engine failure (76,004 miles on odometer) while moving August 6, 2026 towed to Hendrick Chevrolet (Naples, Fl.) … Hendrick Chevrolet refused to repair noting engine replacement required … vehicle towed to Estero Bay Chevrolet (Estero, Florida) and engine replacement confirmed again … my complaint includes Estero Bay ordered replacement engine and confirms same 6.2 liter engine to be installed in my truck (3rd engine for truck) suggesting same engine subject of recall to be installed will fail again while underway/moving endangering me and family … first incident April 1, 2026 second incident August 6, 2026

Main bearing failure at highway speed. Engine replaced by GM under warranty. Vehicle had the recall service done prior to the failure, the recall test and different oil was inadequate to predict or prevent this failure. Vehicle was serviced by the dealer for all oil changes on time.

I needed a replacement driver-side windshield wiper arm for my 2023 Chevrolet Silverado 1500 LTZ Z71 with factory rain-sensing wipers. GM's electronic parts catalog directed the Chevrolet dealer to part #23387855. The dealer physically compared the part to my original arm and confirmed it was the wrong shape and would not fit. The dealer opened a formal Catalog Omission/Error (COE) ticket with GM. I was then informed that GM redesigned the wiper arm on my truck. The correct redesigned arm has been ordered, but I was told there is no estimated availability date and that it is not currently available through GM dealerships or GM's parts distribution/warehouse system in North America. This is a safety concern because a damaged or failed wiper arm could leave an owner without proper windshield visibility during rain or severe weather. I am also concerned that the passenger-side arm may have the same catalog and availability problem, although this has not yet been confirmed. I am requesting that NHTSA investigate whether this issue affects both wiper arms and other 2023 and newer Silverado 1500 trucks with this wiper configuration nationwide.

Multiple times the truck has stopped running while driving. Once one the highway, once in an intersection, another time in a parking lot. It has not started when I have tried to turn it on. All the times I have called AAA. They have checked the battery and there is no battery issue. Twice AAA has come out, once the police have come and sat behind the truck to keep me safe. After about 10 minutes of the sitting with the truck off I can restart it and drive. Upon research, other Chevy trucks of similar age have a recall for a failed fuel pump module. This is the issue. If it is a known issue, and causing a dangerous situation it should be recalled on all trims of Chevy trucks. I will be getting this fixed, but don’t feel I should incur the $1,000 expense for a known defect.

Engine failed 6k miles after inspection and oil type changed to 0w40 from GM dealer Roger Dean Chevy Cape Coral FL

Was making a left turn with a left turn street light green for me to turn across an intersection. Pickup stalled in the middle of the intersection and would not start. With the help of another person we manually pushed the pickup out of the intersection and onto another side street. I received an email at that exact time from General Motors showing a code of P129F which is the Fuel Pump Power Control Module. I am a [XXX] man stranded in 90 degree heat with no AC or shade to get under. My safety was put at risk in the above instance but more so if I had been entering IH 10 into traffic traveling 70MPH and my truck had just stopped running without any warning. This is a known problem as described in GM Service Bulletin 24-NA-139 with both the NHTSA and DOT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

A week ago I was backing up and this truck is supposed to be equipped with a "REAR CROSS TRAFFIC BRAKINGF – When in Reverse, the system warns of detected cross-traffic approaching in either direction and provides alerts and hard emergency braking to help reduce the severity or help avoid collisions at very low speeds", I backed into another vehicle that was parked behind me. I did not receive any warnings and the automatic braking did not activate. I was fortunate that I was going slow and only damaged the other drivers door and my tailgate and bumper.