2022 Ram 1500

Defect. Chrysler (FCA US, LLC) is recalling certain 2019-2026 Ram 1500 vehicles. The second-row center and left-side seat belt buckle anchors may have been improperly installed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."

Risk. An improperly installed seat belt buckle anchor may fail to properly restrain occupants, increasing the risk of injury during a crash.

Remedy. Dealers will inspect and attach the seat belt buckle anchor to the body structure as necessary, free of charge. Owner notification letters are expected to be mailed August 18, 2026. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is 67D. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov on August 6, 2026.

Defect. Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 1500, Ram 2500, Ram 3500, Ram 4500, and Ram 5500 vehicles. The steering column control module may cause the driver's side air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk. A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.

Remedy. Dealers will replace the steering column control module, free of charge. Owner notification letters were mailed beginning December 11, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 14C. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning November 13, 2025.

Defect. Chrysler (FCA US, LLC) is recalling certain 2019-2024 Ram 1500 vehicles. The driver's side air bag may not be connected properly, which can cause the air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk. A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.

Remedy. Dealers secured the connectors for the air bag, free of charge. All vehicles have been remedied. Owner notification letters were mailed May 27, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 08C.

Defect. Chrysler (FCA US, LLC) is recalling certain 2020-2023 Ram 1500 Classic vehicles equipped with heated trailer tow rearview mirrors. The mirror glass may detach from the driver's side heated trailer tow rearview mirror. As such these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk. Detached mirror glass can reduce driver visibility, increasing the risk of a crash.

Remedy. Dealers will replace the mirror glass, free of charge. Owner notification letters were mailed December 5, 2024. Owners may contact FCA Customer Service at 1-800-853-1403. FCA's number for this recall is 86B.

Defect. Chrysler (FCA US, LLC) is recalling certain 2019, 2021-2024 Ram 1500 vehicles. Due to a software malfunction, the anti-lock brake system (ABS) control module may disable the electronic stability control system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."

Risk. Driving with a disabled electronic stability control system can increase the risk of a crash.

Remedy. Dealers will update the ABS control module software, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed October 10, 2024. Owner notification letters were mailed beginning September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 85B.

Defect. Chrysler (FCA US, LLC) is recalling one 2022 Ram 1500 Classic vehicle. The wiring harness may short circuit and prevent the rearview image from displaying. As such, this vehicle fails to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk. A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash.

Remedy. Dealers will replace the wiring harness, free of charge. The vehicle has been remedied. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 65B.

Defect. Chrysler (FCA US, LLC) is recalling certain 2021-2022 Dodge Durango, 2021-2023 Chrysler Pacifica, Jeep Grand Cherokee L, 2022 Ram 1500, 2500, 3500, Chrysler Voyager, 2022-2023 Jeep Compass, Grand Cherokee, Wagoneer, Grand Wagoneer, and Ram Promaster vehicles. The radio software may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk. A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash.

Remedy. Dealers will update the radio software or the software will be OTA, "Over-The-Air," free of charge. Owner notification letters were mailed beginning July 9, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's numbers for this recall are 66B and 79B.

Defect. Chrysler (FCA US, LLC) is recalling certain 2022-2023 Ram 1500, Ram 3500 Cab Chassis with GVWR less than 10,000 lbs., and 2022-2024 Ram 2500 vehicles. The radio software may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk. A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.

Remedy. Dealers will update the radio software, free of charge. Owner notification letters were mailed October 24, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 97A.

Defect. Chrysler (FCA US, LLC) is recalling certain 2022 Ram 1500 vehicles. The B-pillar impact sensors may be missing, which can result in delayed air bag deployment or non-deployment.

Risk. Air bags that do not deploy as intended increase the risk of injury in a crash.

Remedy. Dealers will inspect and, if necessary, install the B-pillar impact sensors, free of charge. Owner notification letters were mailed May 4, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 33A.

Defect. Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Wrangler, Gladiator, and 2022-2023 Ram 1500 vehicles equipped with a 3.0L diesel engine. The high pressure fuel pump (HPFP) may fail.

Risk. Fuel pump failure can result in an engine stall, increasing the risk of a crash.

Remedy. Dealers will replace the HPFP and replace additional fuel system components, as necessary, free of charge. Owner notification letters were mailed October 17, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 01A.

Defect. Chrysler (FCA US, LLC) is recalling certain 2021-2023 Ram 1500 and 2023 Ram 2500 vehicles. The trailer reverse steering control module (TRSCM) may prevent the rearview image from displaying when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk. A rearview image that does not display while in reverse decreases the driver's visibility of the rear view, increasing the risk of injury or crash.

Remedy. Dealers will update the TRSCM software, free of charge. Owner notification letters were mailed March 1, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 14A. This recall supersedes and expands previous recall numbers 21V-438 and 21V-918. FCA US Recall ID 63A is a vehicle population expansion of FCA US Recall ID 14A (NHTSA Recall ID 23V-059).

Defect. Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 1500, 2500, and 3500 pickup trucks. The tailgate may not latch properly due to misaligned tailgate strikers, which could result in the tailgate opening while driving.

Risk. An unintended tailgate opening while driving may result in a loss of unsecured cargo, possibly creating a road hazard and increasing the risk of a crash.

Remedy. Dealers will inspect the tailgate striker alignment to the box latch and adjust, if necessary, free of charge. Owner notification letters were mailed December 22, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is ZB8.

Defect. Chrysler (FCA US, LLC) is recalling certain 2022 Ram 1500, Jeep Gladiator, and 2021 Jeep Wrangler vehicles. The front seat belt retractors may have an improperly welded micro gas generator, which can result in seat belt pretensioner failure.

Risk. A seat belt with pretensioner failure may not properly restrain an occupant during a crash, increasing the risk of injury.

Remedy. Dealers will replace the front seat belt retractors. free of charge. Owner notification letters were mailed December 8, 2022. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is Z95.

Defect. Chrysler (FCA US, LLC) is recalling certain 2020-2022 Jeep Wrangler, Ram 1500, and 2021-2022 Jeep Gladiator vehicles equipped with 3.0L diesel engines. The high pressure fuel pump (HPFP) may fail, causing an engine stall.

Risk. An engine stall can increase the risk of a crash.

Remedy. Dealers will replace the HPFP and inspect and replace additional fuel system components, as necessary, free of charge. Owner notification letters were mailed October 17, 2023. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is Z96.

Defect. Chrysler (FCA US, LLC) is recalling certain 2022 Ram 1500, 2500 pickup trucks, and 3500 Cab Chassis vehicles with GVWR less than 10,000 lbs. The radio software may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk. A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.

Remedy. Dealers will reprogram the radio software, free of charge. Owner notification letters were mailed July 5, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLS's number for this recall is Z47.

Defect. Chrysler (FCA US, LLC) is recalling certain 2022 Ram 1500 vehicles. These vehicles may have been built with incompatible heating, ventilation, and air conditioning systems (HVAC), resulting in the windshield defrosting and defogging system being inoperable to drivers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."

Risk. An inoperable defrosting and defogging system can reduce visibility for drivers in certain conditions, increasing the risk of a crash.

Remedy. FCA US, LLC will repurchase the affected vehicles, free of charge. Owner notification letters were mailed November 22, 2021. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y88.

The Office of Defects Investigation (ODI) has received 80 consumer complaints alleging an engine stall and loss of motive power on model year (MY) 2022 RAM 1500 pickup trucks and 2022 Jeep Wagoneer SUV vehicles. The particular engines in the subject vehicles are equipped with the Fiat Chrysler Automotive Group LLC (FCA) 5.7L Hemi eTorque system. The eTorque system is a mild hybrid system that lets the vehicle partially power itself. It accomplishes this by converting the captured energy from the braking system into electricity for the battery pack, which is then used to power a variety of …

The Office of Defects Investigation (ODI) opened PE21-021 on October 14, 2021, to investigate incidents alleging a stall/loss of motive power as a result of high-pressure fuel pump failures in certain model year (MY) 2019-2020 Ram 2500, 3500, 4500, and 5500 heavy duty trucks equipped with 6.7L Cummins turbodiesel engines. During the investigation, ODI sought to determine if the related defect allegation was limited in scope to the recalled population. After review of information request response materials from both FCA and BMW, NHTSA determined that sufficient information to identify a …

FCA Caribbean Warranty Newsletter – Volume 11, Issue 6

Warranty Bulletin D-24-16 (XR1) Urea Delivery Module – Select 2019 - 2022 RAM Trucks (DJ/D2/DD/DP)

WARRANTY BULLETIN D-24-15 announces the addition of the Rear Axle Assembly replacement for 2019 - 2024 RAM 3500 Cab Chassis (DD), RAM 4500/ 5500 Cab Chassis (DP), RAM 3500 Pickup (D2), RAM 2500 Pickup (DJ), RAM 1500 Pickup (DS) and RAM 1500 Pickup (DT) vehicles to the Powertrain Pre-Authorization program for all dealers (Base, Plus & Premium) to ensure …

FCA Caribbean Warranty Bulletin ID-24-16 Rev. Announces the addition of the Rear Axle Assembly replacement for 2019 - 2024 RAM 3500 Cab Chassis (DD), RAM 4500/ 5500 Cab Chassis (DP), RAM 3500 Pickup (D2), RAM 2500 Pickup (DJ), RAM 1500 Pickup (DS) and RAM 1500 Pickup (DT) vehicles to the Powertrain Pre-Authorization program to ensure proper repair of Rear …

Engine PNs: MY 24-26 WD/DT (5.7L) Code P00B is being misdiagnosed and incorrect parts are being installed causing over repair. Refer to SOL S2609000006 The IAFM Foam Engine Valley Cover (PN 53013735AB) does not provide sufficient clearance for proper routing of the MDS solenoid jumper harness (PN 05148163AE). As a result, the harness may become compressed …

Check Engine Light (CEL) Illuminated with Diagnostic Trouble Code (DTC) P0106 Manifold Absolute Pressure Sensor Performance Setting In The Powertrain Control Module (PCM)

3-way valves are available in STAR Parts as two distinct components and must be selected correctly based on application. The High Temp 3-way valve (68309834AC) is located between the engine and the bulkhead at the rear of the engine compartment. The Low Temp 3-way valve (68448241AA) is located between the engine and the radiator at the front of the engine. …

Camshaft cap bolts within the cylinder head assembly may cause damage to other components. DO NOT replace entire long block when only left OR right cylinder heads need to be replaced.

Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must SYMPTOM: exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● **P0111-00 - Intake Air Temperature Sensor 1 Circuit Range Performance Bank 1. (In Active or Stored status) ● P0071-00 - Ambient Air …

Water Pump & Chain Case Cover

Incident 1 or 2. I am filing two separate formal complaints regarding two incidents in which my 2022 Ram 1500 eTorque unexpectedly shut down while driving, posing serious safety risks and raising concerns about an unresolved vehicle defect. First Incident: September 25–November 4, 2025-During rush-hour traffic on a major Idaho highway, my truck suddenly shut down while I was traveling in the far-left lane. I had to maneuver onto the left shoulder to avoid being struck by another vehicle. After waiting approximately 30 minutes for a tow truck, I was without my vehicle for nearly six weeks while the service center assessed the problem and awaited parts. Repairs included replacing the 12-volt battery at my expense and the 48-volt battery under warranty. Repeated, unexplained failures present an unacceptable safety risk to me, my family, and other motorists. I continue to drive with the concern that my truck could shut down in traffic or in a remote location, potentially resulting in serious injury or loss of life. The approaching expiration of the 48-volt battery warranty further compounds my concerns, as I could face significant repair costs for a problem that remains unresolved. I respectfully urge NHTSA to investigate these incidents and determine whether they indicate a broader safety defect requiring corrective action. I believe repeated failures and inability to identify the cause warrants serious regulatory attention before another event occurs.

Incident 2 of 2: I am filing two separate formal complaints regarding two incidents in which my 2022 Ram 1500 eTorque unexpectedly shut down while driving, posing serious safety risks and raising concerns about an unresolved vehicle defect. Second Incident: May 30–June 23, 2026-While traveling on a mountain road, my truck again shut down unexpectedly. Without cell service, I was unable to call for assistance. After approximately 15 minutes, I restarted the truck and drove home. The following day, the truck would not start, requiring a tow to another Ram service facility. Although the dealership again focused on the 48-volt battery, it could not confirm the cause of either shutdown. I was told a failed fuse prevented the truck from starting, but no underlying cause was identified. Repeated, unexplained failures present an unacceptable safety risk to me, my family, and other motorists. I continue to drive with the concern that my truck could shut down in traffic or in a remote location, potentially resulting in serious injury or loss of life. The approaching expiration of the 48-volt battery warranty further compounds my concerns, as I could face significant repair costs for a problem that remains unresolved. I respectfully urge NHTSA to investigate these incidents and determine whether they indicate a broader safety defect requiring corrective action. I believe repeated failures and inability to identify the cause warrants serious regulatory attention before another event occu

I have a 2022 RAM 1500 Longhorn Limited VIN [XXX]. It had a real problem a couple of years ago with stalling to a stop and die when making slow left hand turns. Went to the dealer twice. They claimed it was nothing but after the second visit, it no longer did it anymore. It’s done it twice in the past couple of months. This evening it did it at a three way stop sign with no turn. When it shuts off it’s in drive of course and it auto shifts to park and sets the emergency brake automatically. Then I can start the engine again but I have the press the emergency brake switch button to release it. Then the low voltage light appears on the instrument cluster and the voltage gauge stays only about a quarter of the way up above zero on the negative side. To remedy this I have to shut off the engine and sometimes open the door for a while, close it and then start the engine and all is well again. I know RAM plays dumb when I describe this to them. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The rear drivers side glass spontaneously shattered.

The contact owns a 2022 Ram 1500. The contact stated that the driver’s side sun visor became detached at the elbow hinge and was dangling in the view of the driver while driving. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The failure mileage was 65,000.

The contact owns a 2022 Ram 1500. The contact stated that while driving, the steering wheel seized and failed to function properly. The contact pulled over safely, and after restarting the vehicle, the vehicle temporarily operated normally however, the failure recurred. Upon restarting and driving the vehicle, the vehicle lost steering functionality, causing the vehicle to leave the roadway and drive up on the embankment on two wheels. The contact stated that the running boards previously failed to operate, creating a concern for passengers exiting the vehicle. While attempting to tow the vehicle to the dealer, a warning light flashed on the instrument panel. The manufacturer was notified, and the vehicle was taken to a dealer where it was diagnosed with an electric power steering (EPS) internal rack and pinion failure. The vehicle was repaired. The failure mileage was 53,000.

The truck has stalled twice while in motion. Leaving me stopped suddenly in middle of the street. This has happened on 2 separate occasions. I did not think to save the dates. Initially I thought maybe I wasnt giving it enough throttle, but after reading more into it I see there was a recall for the previous year model and this may be considered problematic as well. The truck made me apply the brake to restart, and release the emergency brake since it applied on its own. The first stall I had to turn sharp and fast to try getting to the side of the road to make room for coming and going traffic and avoid being in a collision. The second stall I was luckily the only driver on the road at the time. I'm reading it could be the MGU system and I have also noticed my battery voltage starting to fluctuate more. I jave not taken to the dealer yet as this is my means of transportation for work and we are a 1 income family of 4. I do not get a rental if I have to leave the truck at the dealer.

I am reporting a recurring engine defect involving the Multi-Displacement System (MDS) in my 2022 RAM 1500 Big Horn equipped with the 5.7L HEMI eTorque engine. Since purchasing the vehicle in March 2023 with approximately 4,555 miles, the truck has experienced four separate MDS-related failures despite multiple repair attempts by authorized RAM dealerships. On February 7, 2025, at approximately 38,115 miles, a RAM dealership diagnosed an MDS solenoid that had physically separated and required extraction and replacement. On May 1, 2026, at approximately 66,149 miles, another authorized dealership diagnosed an MDS failure involving cylinder No. 1 and performed repairs under warranty. Despite these repairs, the engine experienced another serious failure at approximately 73,000 miles. The most recent failure involved metal contamination and catastrophic internal engine damage, leaving the vehicle completely inoperable. I am concerned that the repeated MDS-related failures indicate a potential defect in the engine's cylinder-deactivation or valvetrain components. Failures involving these components may cause significant engine damage and potentially result in an unexpected loss of engine power while driving, creating a safety risk for the driver, passengers, and surrounding motorists. The vehicle has undergone multiple repairs for recurring MDS-related problems, but the issue has not been permanently resolved. I believe the final engine failure may be connected to the previously d

The sun visor (driver and passenger) break with normal use. This can cause the visor to suddenly drop into the drivers field of view or potentially strike the driver in the head depending on if it is being used in the standard down position or if the extension bar is being used on the front or side position. This could cause the driver to have a physical reaction even if the risk of injury from the strike is relatively small, thus causing the driver to lose control of the vehicle. Mine fell down into my field of view while I was stopped at a red light, when I attempted to lower the visor. Fortunately I was stoped at a stop light and was able to remove the obstruction prior to moving the vehicle.

The vehicle experienced a sudden powertrain failure at a busy intersection failing to automatically restart during an auto start/stop cycle on October 6, 2026. Upon manual override, the mild hybrid motor generator unit (MGU failed to adequately charge the 48V/12V electrical systems. This failure leaves the driver highly vulnerable to a total high-speed vehicle stall in active traffic due to rapid battery depletion. The manufacturer and dealership is unlawfully denying federal coverage for this emissions/hybrid component. At the time of the incident the vehicle had approximately 59,248 miles on it. I called the dealership (as I believed this would be covered under the 60,000 mile powertrain warranty) that day describing the failure. The earliest appointment I could get was October 16th. By the time my truck went in for the appointment the mileage was 60,130 miles. The dealership Identified the failure as the charging system for the Ram Hemi E-Torques motor. Specifically the Serpentine Belt Tensioner Part #: 05281543AD, 05281956AA, and 68518738AA. Also prescribed a software update. The total quote for the repairs was 1534.80. The dealership denied warranty coverage under the powertrain stating the vehicle had exceeded 60,000 miles. I showed them a picture of my odometer at 59,248 miles dated for the day i reported the problem and scheduled the appointment. They then informed me that standard accessory parts (belts, tensioners, etc.) are not covered under the 60,000mile warranty

Back up camera shows blue on reverse.

Three times in the past month, I have been turning left and had the vehicle turn off. Twice the emergency brake automatically applied and the truck auto-shifted to park, the 3rd time my steering and engine turned off. The 1st time I thought perhaps I had accidentally hit the start button, the 2nd time I was fairly sure I hadn't, and the 3rd time both hands were on the wheel so I could not have. This 3rd time, I continued to roll thru the intersection until I rolled to a stop and the gear selector remained in drive. I am taking the truck to the dealership today. Luckily, there was no other vehicle near me when any of these instances happened but im worried that will not be the case in the future.

The contact owns a 2022 Ram 1500 TRX. The contact stated that while driving over road bumps, the suspension system failed to engage. No warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed that the suspension control module had failed and required replacement. The vehicle was repaired; however, the failure persisted. The manufacturer was notified of the failure. The failure mileage was 27,000.

On three occasions over the last 6 months my truck has died completely. The first time all warning lights came on and there was no speed showing but the truck kept driving. When I finally parked and restarted everything was normal. The second time all warning lights came on the cool air turned hot and then it just died while driving. I was very close to parking so no danger there. This last time I was parked in a swamp hunting and when we got back to the truck it was completely dead. I was able to jump it thankfully as we were in the middle of nowhere and it was hard to get to, not sure help would have been able to get in there. When restarted it once again had all warning lights on, said I had no gas, and wouldn't provide my speed when driving.

The contact owns a 2022 Ram 1500. The contact stated that the vehicle failed to start. After waiting approximately 10 minutes, the vehicle was able to start. The vehicle was taken to an independent mechanic, who inspected the battery, alternator, and starter but found no failures. The contact was advised to replace the key fob battery; however, after replacing the key fob battery, the failure persisted. The failure mileage was approximately 84,000.

My 2022 Ram 1500 Big Horn V6 eTorque stumbles and cuts out during hard acceleration, this issue, when it happens has caused a dangerous performance issue to the point that I have almost been struck from behind while attempting to join the flow of traffic, the actions of either the PCM or some other engine control system cuts all motor RPM to barely an idle while traffic around me are at speeds of 40+ MPH while I am attempting to accelerate, I get a brief warning message on the display screen that flickers for less then one second (I am unable to read the warning) this is extremely dangerous. I also have been getting UCONNECT ERROR - none of these are leaving error codes in the vehicles memory.

The contact owns a 2022 Ram 1500. The vehicle was repaired under NHTSA Campaign Number: 23V263000 (Fuel System, Diesel); however, a failure occurred after the repair. The contact stated while driving at an undisclosed speed, the vehicle stalled. The vehicle was taken to an independent mechanic where it was diagnosed with high-pressure fuel injector pump failure. The contact was informed that the high-pressure fuel injector pump needed to be replaced. The manufacturer was contacted by phone. The failure mileage was approximately 31,000.

The contact owns a 2022 Ram 1500. The contact received notification of NHTSA Campaign Number: 23V263000 (Fuel System, Diesel) and the recall repair was performed. However, a year after the recall repair was performed, the fuel pump failed, causing damages to the fuel system. The contact stated that the fuel pump had no issues prior to the recall repair. The vehicle was towed to a dealer. The contact stated that the pump made an abnormal sound while driving 55 MPH, and the vehicle shut off. The manufacturer was notified of the failure. The dealer confirmed the failure; however, parts were not available to repair the vehicle. The dealer agreed to cover the repair under a recall warranty. The failure mileage was 144,000.

For the 6th time this year. I was going to take off from stopped when I went to accelerate and my truck shut off, showed switch to park. When I went to apply my brakes. It automatically engages the parking break while moving. This time. A vehicle near rear ended me with my kids in the car due to the abrupt halt. Truck had a full tank. Seat belts were worn. Just engine dying and slamming itself into park. I’ve been searching and seen lots of complaints about similar models and no recall for the 2022 1500. This is becoming a reoccurring issue that is endangering the safety of my children

On October 1, 2026, my 2022 Ram 1500 Rebel with the 5.7L HEMI eTorque mild-hybrid system failed to restart after an automatic engine stop-start event at a red light. The engine shut off as designed when I stopped. After about 90 seconds the light turned green and I released the brake, but the engine did not restart, and the truck sat motionless in the traffic lane. When I pressed the accelerator, the engine revved and the truck lurched forward unexpectedly. At that point a battery warning light and an auto stop-start warning (stop-start symbol with an exclamation mark) appeared on the dash. No warning lights appeared before the failure. I pulled over and was able to restart the truck, but the dash voltmeter read about 12.8V while running instead of the normal 14.4V, meaning the 12V battery was not being charged. I drove to my destination. After I shut the truck off and restarted it, voltage returned to about 14.4V. Note that this is not the first time this has occurred and I often keep the automatic start/stop off because it seems to have so many issues.

Approximately 10 mins into my drive there was a burning smell in my cab, then within a few seconds there was a loud popping/exploding sound. I pulled into a parking lot within 100 feet and exited vehicle. I went to front of vehicle to see if there was smoke and after finding none I leaned back inside my truck’s cab and realized not only was the burning smell stronger but there was visible smoke lingering. At that point I saw that one of the back stationary windows was shattered. Looking closer I saw that below the window the glass was charred and the plastic trim had melted slightly. I stayed out of the vehicle and started researching the possible cause. I read several reports of issues with 5th generation Ram trucks, like mine, experienced issues like mine caused from faulty rear defrosters. After consulting with someone over the phone, I pulled the fuse for the rear defrosters to be certain there would no longer be any type of electric current flowing to the defrosters.

Sunshade attachment point at the headliner breaks. The sunshade them falls down in front of the driver blocking visibility.

It won’t let me do cruise control and continues to throw some sort of TPMS isn’t working verbage

9.15.26 Vehicle came to an abrupt stop at a low speed and put auto brake on and vehicle shut off. I had to restart the vehicle manually. I had already shut of the auto shut off prior this. 9.17.26 Vehicle began to stall but started back up with gas pressure. 9.23.26 Vehicle stopped and went into auto brake, shut off at low speed again. Restarted with the start button. Got to my destination, while idle the hazards lights turned on all by itself. Also, the radio screen will flicker every now and again. 9.23.26 The vehicle was picked up by the dealership to have it looked at.

I was in an emergent situation and beyond for my own safety but also to follow the law i had android auto already connected and used [XXX] to hands free call [XXX] without taking my eyes off the road since the emergent situation was someone almost ran me off the road. When i told [XXX] to call [XXX] [XXX] wasted precious time asking me if im sure that i want to call [XXX] while im trying to report the person who almost ran me off the highway at 75 miles an hour while they went almost 85 90. That is ridiculously insane and when i probed [XXX] as to why it did this it said because it used too call [XXX] without need. I promise no one who is actually in need of it would ever give a XXXXXX if [XXX] occasionally called [XXX] by accident espcially when it involves precious milliseconds not minutes. I "sent feedback" but that never does a XXX thing and when i tried to follow the instructions i needed to use to grab the logs to add to this report the andoid auto section didnt even exist and ever so conviently the logs for that specific interaction couldn't be found either which i find extremely suspicious after the 100's of shady/illegal/harmful things that google/alphabet has done to hide their own fault whenever their products fail. I did after this finally get in contact with the police at XXX dispatch but since i was driving they just asked for my name and info if they needed to get ahold of me so i dont have any information on a police report yet or may not ever recieve info on

Power steering has an intermittent failure and have lost power steering multiple times on the highway. Warning lights come on a indicate steering issue. Have noticed this has been reported as an eps issue with the ram 1500's. This has been reproduced by an independent service center and they thought it might be a loose connection with water getting in. They tried to fix this but still getting the issue even when there is no rain. This just started once I passed the 36,000 mile mark and no longer under warranty This is a serious issue as power steering goes out unexpectedly

The contact owns a 2022 Ram 1500. The contact stated that while driving approximately 45-50 MPH in the rain, children in the rear of the vehicle informed the contact that the rear window was allowing water to leak into the vehicle. The water reached several electrical systems, including the rear braking assembly and the third brake light seal above the cab of the vehicle. The vehicle was taken to the dealer who informed the contact that the window and window seals needed to be replaced. The contact decided not to repair the vehicle out of pocket because of TSB Number: 23/098/23 Warranty Ext XL1, which addressed the failure. The dealer informed the contact that the parts for the repair were the same parts that needed to be replaced. The vehicle was not covered under TSB Number: 23/098/23 Warranty Ext XL1 because the TSB expired in 2021. The failure mileage was 53,467.

Truck for about the 6th time in 2 weeks, shut its self off while driving and slams into park. This has happened before and had to be towed to dodge because it wouldn’t restart. I told them what happened and they informed me it was low on fuel, that’s why it did it. But I was doing 60mph on a interstate and lost all power

Warning light appeared and there were issues with with the start/stop feature. It was determined by the dealer that is was caused by an MGU failure.

Dodge Ram Engine light and battery light turn on. I take it to a mechanic close to my house. Service manager connects the truck to the computer and vehicle shows error in alternator which. Dodge specific parts and he advises me to take the truck straight to dodge and not drive it anymore that the battery voltage is dropping and not charging. He sends me email breakdown of all error codes and tells me to give it to dodge. I drop off at dodge and provide all information to advisor including error codes. I tell them everything that happened and what the manager said about the battery voltage. They claim all information I provided wont all fit on the ticket so erases it and put basic information regarding voltage error. I offered to show him the pics and the report that was provided to me by other mechanic but he stated that they will have to do their own diagnostics anyway. Says that my truck has a bunch of software recalls that may clear the problem. I get a call they did a software update that cleared and fixed the problem and it wasn't the MGU. Vehicle was fixed and i could pick up. I pick up truck and the warning lights were cleared. Took it home no more driving. My 17 year old drives truck next day for school event, on his way to school event both lights turn back on. I tell him to come straight home we switch cars and i take directly to dodge. As i'm driving I'm paying attention to the voltage on battery, within a 10 mile drive to drop truck off at dodge the voltage goes f

On XXX at approximately 1:00 PM, while driving my 2022 Ram 1500 3.0L EcoDiesel on [XXX] east of [XXX]/north of [XXX], a rigid metal diesel fuel supply tube fractured at approximately 49,209 miles. The failure caused a substantial uncontrolled release of diesel fuel into the engine compartment and underneath the vehicle. Diesel fuel traveled underneath the truck and contaminated portions of the rear of the vehicle. The vehicle's check engine light came on, became disabled and required repair away from home. The failed component has been retained. Photographs show a visible crack/fracture in the metal tube itself rather than at a threaded connection. A replacement Mopar tube was obtained from a Ram dealer. The vehicle previously underwent the Ram/Stellantis high-pressure fuel pump (HPFP) safety recall, Recall 01A/NHTSA 23V-263, on XXX. I do not currently know whether the failed tube was replaced or disturbed during that repair and have requested the prior repair records. I am reporting this because a sudden pressurized diesel fuel leak into the engine compartment presents a potential fire hazard. I have retained the failed component and can make it available for inspection. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2022 Ram 1500. The contact stated that while driving on several occasions at various speeds, the ABS, brake, and other unknown warning lights illuminated, and the messages "Traction Control Disengaged", "Shift Knob Required Servicing", "Cruise Control Disconnected", "Video Display Need Servicing," and other unknown messages were displayed. The steering wheel was firm and difficult to turn. The vehicle was turned off and failed to restart immediately. The contact stated that after several minutes, the vehicle restarted. Additionally, while driving with the cruise control feature activated, the feature deactivated inadvertently and the message "Traction Control Disconnected" was displayed. The fuel gauge on the instrument panel was moving erratically and then became inoperable. The vehicle was pulled over to the side of the road, turned off, and then restarted. The vehicle was then taken to the residence. The vehicle was taken to the same dealer four times and was diagnosed with an unknown communication error. During the first visit, the ABS module was replaced. During the second, third, and fourth visits, the dealer was unable to duplicate the failure, but stated that there was a communication error. The manufacturer was not notified of the failure. The failure mileage was approximately 60,000.

The contact owns a 2022 Ram 1500. The contact stated that while driving 70 MPH on the interstate, the vehicle lost traction and fishtailed on the wet roadway. While at a stop and turning, the vehicle started spinning like the vehicle was driving on ice, even though the outside temperature was hot. The local dealer was contacted and scheduled an upcoming appointment. The manufacturer was contacted but was unsure if a complaint was taken due to a language barrier. The failure mileage was approximately 30,000.

I was driving down the highway, in light rain around 9pm, very little road traffic, when all of a sudden the forward glass of my sunroof exploded, it sounded like a gun shot. But then I heard wind noise and realized the glass on my sunroof just imploded towards the sky. Very alarming, no other sun roof issues previously on this vehicle. Safe lite replaced the sun roof, but it took several weeks for mopar/ram dealership to get the part in. It seems online I’m not the only person with a ram sunroof that’s exploded spontaneously.

My 2022 Ram 1500 with the 5.7L HEMI eTorque system illuminated the check-engine light at approximately 88,000 miles with diagnostic codes P0AEE and P0BD4 relating to the motor-generator/inverter temperature sensing system. An authorized Ram dealership diagnosed a failed Motor Generator Unit (MGU) and stated that the MGU requires replacement. I was advised that continued operation could eventually result in the vehicle becoming undrivable, so I am storing the vehicle rather than routinely driving it. The dealer has ordered a replacement MGU but reports a severe national backorder and cannot provide an estimated repair date. Stellantis Customer Care has opened a case and is attempting to expedite the part, but has not provided an ETA. I am reporting this because the MGU is integral to the eTorque starting/charging system and the vehicle cannot presently be repaired within a known timeframe. I understand NHTSA has an existing investigation, PE24-018, concerning loss of motive power in 2022 Ram 1500 eTorque vehicles.

The contact owns a 2022 Ram 1500. The contact stated that while driving approximately 40 MPH, the vehicle lost power and coasted to a stop along the curb, stalled, and the transmission independently shifted to park(P). The vehicle failed to restart, and the Police arrived on the scene to assist with traffic control. The vehicle was towed to the local dealer, who replaced the high-pressure fuel pump as part of the repair under NHTSA Campaign Number: 23V263000 (FUEL SYSTEM, DIESEL). However, the repair failed to fix the vehicle. The vehicle was towed to a second dealer, and it was determined that during the failure with the high-pressure fuel pump, the valves in the engine were damaged. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 139,000.

I am submitting this formal complaint regarding my Ram 1500, which I purchased from Tuttle-Click’s Tustin Chrysler Jeep Dodge Ram less than one year ago. Despite the vehicle being relatively new to me, I have experienced multiple serious electrical and safety-related failures, including non-functioning power windows, air conditioning, horn, infotainment/display screen, backup camera, and vehicle sensors. These are not minor inconveniences; several of these failures directly affect the safe operation of the vehicle and my ability to properly operate and maneuver it. I do not believe a vehicle with these systems malfunctioning should be considered safe to drive. I am extremely concerned that I have encountered these problems after purchasing the vehicle from an authorized dealership and after spending my hard-earned money expecting a safe and reliable vehicle. I am requesting that these defects be thoroughly investigated and corrected immediately. I also urge the manufacturer and dealership to review whether similar electrical and safety complaints involving Ram 1500 vehicles indicate a broader recurring problem. I expect a prompt response and a meaningful resolution because I should not be placed in a position where I have to risk my safety or the safety of others simply by operating a vehicle I recently purchased.

When it rains, the ESC, ABS and check engine lights come on. 4WD capability and is disabled and rear backup stopping is disabled. Steering becomes rough like it is locked in 4WD High but once dried out that goes away, and all lights except check engine light goes out. Mechanic reset codes and the next time it rains the scenario repeats itself.

The vehicle has already had the generator replaced due to failure and shutting off while driving down the road and the speed limit. The truck was in the shop for almost 6 moths, then the front drive shaft broke while driving in 2-wheel drive. Now while my wife was driving going 40 mph on HWY 96 the car shut off and put itself in park in the middle of the highway. We were lucky no one hit us and after a few minutes it restarted and we were able to get it off the road and have it towed to the dealer where it is right now.

The contact owns a 2022 Ram 1500. The contact stated that while driving 45 MPH, there was a shimmy coming from the vehicle. The contact pulled into a parking lot, and the front passenger’s side tire, rim, brake assembly, and ball joint suddenly detached from the vehicle. There was no warning light illuminated. The vehicle was towed to the local dealer, and it was confirmed that there was no warranty coverage on the vehicle for the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was approximately 29,000.

The contact owns a 2022 Ram 1500. The contact stated that while her daughter was driving approximately 20 MPH, the vehicle shut off unexpectedly and the electronic parking brake unintendedly engaged. The parking brake warning light was illuminated. The driver was able to pull over to the side of the road. The driver was unable to disengage the parking brake, and the vehicle failed to restart immediately. The vehicle was restarted after several attempts and was driven to the destination. The manufacturer was notified of the failure and referred the contact to a dealer for a service appointment. The dealer was contacted and informed the contact that there would be a charge for a diagnostic test and for the repair. The vehicle was not diagnosed or repaired. The contact associated the failure with NHTSA Action Number: PE24018 (Electrical System, Hybrid Propulsion System, Engine, Engine and Engine Cooling). The failure mileage was approximately 60,000.

Driving 70 mph on a 3 lane hwy. All the sudden it loses power, engine dies. Have barely any brakes or steering. No turn signals I don’t believe or brake lights. Have to swerve through traffic that doesn’t know what I’m doing to get to the side, if there is one. Dash light says “truck not in park”. This is the second time, it could have and almost killed me or someone else both times

I own a 2022 Ram 1500 Limited 4x4 (5.7L HEMI eTorque, ZF 8-speed automatic), VIN [XXX], approximately 40,000 miles. For roughly two years, the transmission has produced a hard, jarring downshift and lurch during normal low-speed deceleration, consistently when slowing from ~20 mph to a stop. This occurs both when the engine is cold and fully warmed up, ruling out a cold-start explanation. It happens under normal city driving, not towing or aggressive driving. The jolt is forceful enough that passengers, including my spouse, are reluctant to ride in the vehicle. I brought the truck to an authorized Ram dealership (Greenway Dodge, Orlando, FL) and left it overnight. The service manager stated this was “normal” behavior and that his own vehicle did the same. When I noted it happens warm as well as cold, I was told nothing could be done. No diagnostic codes were pulled, no fluid inspected, and no TSBs checked during the visit. I later confirmed via NHTSA’s TSB lookup that a bulletin addressing rough downshifting on 5.7L eTorque Ram 1500 trucks (TSB 21-005-19 or superseding revisions) exists for this platform, and has NOT been applied to my VIN despite the dealership having full access to check. I’m filing this because: 1) the behavior involves unexpected, forceful lurching during low-speed deceleration that could startle a driver near intersections; 2) my dealership dismissed it without diagnostics or checking for applicable updates; 3) this appears to be a widely reported issue

While accelerating the vehicle stalled and came to a complete stop. I was unable to leave the road way due to the vehicle stoping, shifting to park, setting the e brake. I then had to push start again and pull to the shoulder. The vehicle then indicated a battery warning light, and the voltage indicated the battery was below 12v. Upon returning home and restarting the vehicle all warning lights turned off and the battery voltage indicated no issues. This vehicle is on its 3rd 12v battery. It has gone to the dealer multiple times over the battery. It hesitates while accelerating but without expensive diagnostics I had no recourse.

After truck has been sitting or several Upon start up and driving in the first 2-5 minutes the truck will stall and display shift to park on the screen. Once truck is shifted to park it will restart fine and work as it should. No engine codes or other symptoms. This has happened 8 times over the past 6 months. Shits off at low speeds making turns usually or coming to a stop. Has been to dealer and they are unable to duplicate or figure anything out.

The Ram uconnect system screen can go black, have glitches or be unresponsive. When this screen goes out the backup camera is no longer displayed.navigation is also no longer usable. When it goes out it is intermittent but can at anytime. Mine was out for an entire week then started working agian.

Twice now my engine has shut off while driving at low speeds under 25mph. When this happens my electric emergency brake engages. Dash tells me to shift to park. The first time this happened my truck was stuck in the middle of an intersection and I almost got hit several times because the truck wasn’t restarting or releasing the electric brake. Took about 7-8 try’s of getting it to start before it finally started then the truck still wouldn’t move because the electric brake wouldn’t disengage even when trying to manually disengage it. I had to turn vehicle off and back on again for the electric brake to manually release. The second time this happened I again was stuck in an intersection but was able to restart on the 2nd try and had to manually release the electric brake. The dealer has told me no codes no problem found the first time this happened. I’m bringing it back to them this weekend. I do not feel safe in this vehicle due to this happening! I feel like I have been lucky that nobody has crashed into me when this happens.

I purchased my 2022 Ram 1500 5.7L new. Since purchasing the vehicle, it has experienced multiple electrical system failures that occurred without warning. The infotainment screen stopped functioning, which also caused the backup camera to become inoperative. In addition, the horn no longer works, the air conditioning has failed, and the power windows will not operate. These failures appear to be related to the vehicle's electrical system and have significantly affected both the safety and usability of the truck. The loss of the backup camera reduces visibility while reversing, increasing the risk of a crash. The horn is an essential safety feature used to warn other drivers and pedestrians of potential hazards, and its failure creates an additional safety risk. The vehicle was purchased new and has experienced multiple critical electrical failures affecting several systems. I am submitting this complaint so the National Highway Traffic Safety Administration (NHTSA) can investigate whether these electrical failures represent a safety-related defect affecting other 2022 Ram 1500 vehicles.

While driving, the front passenger side ball joint failed catastrophically. The wheel completely separated from the control arm and folded under the truck, causing the vehicle to drop hard onto the suspension and nearly lose control. I was extremely fortunate not to be involved in a crash or killed. Photos taken immediately after the failure show the wheel collapsed under the truck and the damaged suspension components (upper/lower control arm and ball joint area). This is a sudden, total failure of a critical steering/suspension part with no prior warning symptoms that I noticed.

"I am filing a formal safety complaint regarding a recurring, dangerous safety violation in my 2022 Ram truck. The entire Uconnect infotainment screen completely blacks out, freezes, and enters an unexpected reboot cycle while the vehicle is in operation. This total system failure causes an intermittent, complete loss of the rearview backup camera, creating an immediate crash hazard and placing the vehicle in direct non-compliance with Federal Motor Vehicle Safety Standard 111 (FMVSS 111). Furthermore, when the system crashes, it completely disables all cabin environment controls—preventing the use of the windshield defroster—and creates a severe, unpredictable distraction while driving in traffic until the system finishes recycling."