2018 Chrysler Pacifica Plug-In Hybrid

Defect. Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric (PHEV) vehicles that received a software update remedy under NHTSA recall number 22V-077. The battery pack may cause a vehicle fire when parked, even with the ignition in the "Off" position.

Risk. A vehicle fire increases the risk of injury.

Remedy. Owners are advised not to charge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed free of charge. Interim notification letters, notifying owners of the safety risk, were mailed August 1, 2024. Owner notification letters were mailed December 12, 2024. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 73B. Vehicles previously repaired under recall 22V-077 will need to have the new remedy completed.

Defect. Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV). A vehicle fire can occur when parked, even with the ignition in the "Off" position.

Risk. A vehicle fire increases the risk of injury.

Remedy. Owners are advised not to recharge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed free of charge. Interim letters, informing owners of the safety risk were mailed on February 25, 2022. Final owner notification letters were mailed October 6, 2022. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is Z11. This recall is superseded by NHTSA recall 24V-538.

Defect. Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.

Risk. A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.

Remedy. FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak.

Defect. Chrysler (FCA US LLC) is recalling certain 2018 Chrysler Pacifica and Pacifica hybrid vehicles. The right front lower control arm may separate from the steering knuckle.

Risk. A control arm separation could increase the risk of a crash.

Remedy. Chrysler will notify owners, and dealers will inspect the right front knuckle and lower control arm for damage, replacing the components as necessary. The right front lower control arm knuckle pinch bolt will be replaced with a larger-diameter pinch bolt. These repairs will be performed free of charge. The recall began April 26, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V15.

Defect. Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica Plug-in Hybrid Electric vehicles (PHEV). After the vehicle has been operating in PHEV propulsion mode, the gas-fueled engine may not restart properly resulting in unburned fuel entering the exhaust catalyst.

Risk. The improperly started engine could result in a loss of motive power increasing the risk of a crash or the unburned fuel in the catalyst may ignite increasing the risk of a fire.

Remedy. FCA will notify owners, and dealers will update the powertrain controller module software, and inspect and replace the catalytic converter as necessary, free of charge. The recall began November 15, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U94.

Defect. Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.

Risk. A vehicle stall can increase the risk of a crash.

Remedy. Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.

The contact owns a 2018 Chrysler Pacifica Plug-In Hybrid. The contact stated that while driving at 65 MPH, the vehicle experienced a total loss of motive power. The Check Engine warning light illuminated, and a warning message reading "Stop Safely Vehicle will shut off Soon" was displayed. The vehicle was towed to a dealer where diagnosis confirmed a transmission failure requiring replacement. The vehicle was scheduled for repair. The failure mileage was 181,901.

The contact owns a 2018 Chrysler Pacifica. The contact stated when attempting to charge the battery, the charger failed to work as intended . A dealer was contacted. The vehicle was towed to the dealer where it was diagnosed that the battery needed to be replaced and and they sent a request to the manfactuer in regards to replacing another battery. The vehicle was repaired as the battery was replaced three times. The manufacturer was notified of the failure and they could not give her an update and they informed her this is up to the dealer. The approximate mileage was 101,000.

I was traveling at south bound on TOLL 130 going 80MPH (which is the speed limit on that road) when my Pacifica immediately slowed down and my accelerator gave out. In addition to my dash flashing that the cruise control was no longer available, but the van also said "Service Charging System" and "Shift to P to Start", the engine light and batter light both came on. I am sure that I almost died as I was in the middle lane and cars were whipping around me since I had slowed down so much, there was an 18 wheeler behind me and one of my righthand side, which is the shoulder I was trying to get to. I was finally able to coast to the shoulder and came to a stop, put the car in park and turned it off. I immediately started researching what the problem could be and I was alarmed to find out that this is an issue that others have had and that Chrysler has failed to issue a recall...I was able to start the car once more and get on to a little back road, after pushing through a barricade off the toll just for safety's sake, and my van broke down again, this time on a little 2 lane road, which thankfully had a little bit of a gravel shoulder. This time, my van took quite a bit longer to get started, but I was not safe where I was. I started it once more and was able to get to a Wal-Mart parking lot where my brother-in-law picked me up so that I could have a chance of making it to see my grandmother who was on her deathbed, I missed my window of opportunity to make it to see her, she die

I have a 2018 Chrysler Pacifica Hybrid. I purchased it brand new in 2018. This van has had sooo many problems, it has been in and out of the shop, countless recalls. Last year it was in the shop for almost the entire year, I think I had possession of the van for less than 3 months of the year. I just brought my van in for a recall related to the hybrid battery and it was returned to me in December, within 2 weeks there were check engine lights on and when I googled the code that was showing I found a ton of blogs about how people had the same recall done and within a short period of time this code came up and it meant the hybrid battery needs to be replaced. I reached out to the dealer and brought it in to get looked at. After a couple weeks I was told that the replacement of the battery would not be covered under the recall since part of the recall solution is testing the battery, and it tested good. I literally had only had the van back for 2 weeks. And I have countless records of engine codes showing up for years. I currently have 8 active engine codes showing. I know there is an open investigation concerning the recall I just had the remedy done for and I am 100% sure that this defect is related to that recall.

Vehicle states "Stop Safely Vehicle Will Shut Off Soon" with a red turtle logo. I have restarted the vehicle, and the warning persists. I am bringing in the car to the dealer next.

Had check engine code p1c5e and vehicle would not charge. Dealership has confirmed that the lithium battery has failed and needs to be replaced. They communicated with Chrysler, opened a STAR case, and are in process of replacing the battery

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 24V536000 (HYBRID PROPULSION SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

On [XXX], my vehicle produced a large red wrench and a turtle warning on a busy highway and I was forced to pull to the side with my [XXX] son in the car, as the vehicle lost motive power. It was towed to the dealer and after several days, they told me the issue was due to normal wear and tear in the transmission. I had to escalate to a service manager to even get a diagnosis after 5 days in the shop. I believe my transmission issue is due to a failure of the fix implemented in the 03A/NHTSA 23V-010 recall. It has been documented that the software update did not fix the issue. My vehicle experienced the exact series of failures described in the recall. Chrysler is refusing to fix my vehicle, even though they had extended the warranty on my Pacifica to unlimited miles/unlimited years because of all of the transmission issues the model has experienced. I would appreciate it if someone could look into this and Chrysler's unwillingness to stand behind their products and provide fixes for their recalls that work. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact stated while driving at an undisclosed speed, the middle passenger’s side captain seat became inoperable. The contact stated the back rest failed to remain locked in place. The contact stated that seat fell forward, raised up and unlocked before sliding forward and collapsing. The vehicle was taken to the dealer but was not diagnosed or repaired. The contact was informed by the dealer that a fix was not available for the failure. The manufacturer was made aware of the failure and a case was opened. The approximate failure mileage was 81,000.

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 24V536000 (Hybrid Propulsion System); however, the part to do the repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 24V536000 (Hybrid Propulsion System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

I have a Chrysler Pacifica Hybrid which has had multiple recalls for the battery causing fires with no resolution. The NHTSA website said to submit a complaint "If the manufacturer has failed or is unable to remedy this safety recall for your vehicle in a timely manner". The most recent recall was in July without resolution but the battery has been recalled multiple times over the last few years without actual fix being done.

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 24V536000 (HYBRID PROPULSION SYSTEM); however, the part to do the recall repair was unavailable. The manufacturer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The local dealer was not contacted. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Chrysler Pacifica. The contact received a notification of NHTSA Campaign Number: 24V536000 (Hybrid Propulsion System); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds, the vehicle failed to accelerate while depressing the accelerator pedal. No warning light illuminated. The vehicle was taken to an unknown dealer, where unknown repairs were completed at the contact's expense. No further information was provided. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.

The unresolved recall with no remedy stems from an earlier recall is entering its fourth month with no further communications from the manufacturer about the status of the remedy. There has been no compensation provided to car owners with increased carrying costs due to the manufacturing failures, decreased car valuation due to repeated failed attempts to remedy the same recall, nor indirect costs of extended stress and fear. I am unable to park my car by my house due to the fire risk, which has required me to buy monthly parking passes. I am unable to charge my car, which has caused increased gas costs. I previously paid to install a level 2 charger in my home, which I am unable to use. Additionally a concerning electrical noise has started to occur when starting the car or long after turning the car off. I am continually anxious about driving this car with my children, but I have no other choice to continually put all of us at risk. Jul 18,2024 Manufacturer Recall Number73B NHTSA Recall Number24V-536 Recall Status Recall Incomplete, remedy not yet available

Chrysler has still not offered a remedy for this recall .the vehicle was purchased used and selling dealer did not provide recall info until the sale had been completed. I love the vehicle except the possible fire hazard in the recall makes me nervous to drive it . Chrysler told me earlier recalls were for this hazard but now says remedy is incomplete!!

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 24V536000 (Hybrid Propulsion System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

My vehicle was performing great - no Issues what so ever until FCA performed Recall 03A. After I had FCA US LLC Recall 03A for Loss of Motive Power installed; my vehicle had several issues the same day I picked it up from the Dealer. They stated it was ready for pickup even with all my issues and they new I had ½ of them and still turned it over to me. . 50 % of the issues are still waiting to be repaired. The Major issue remaining is the High Voltage Battery. After 1 year of them trying to get the vehicle back to the condition I turned it in before for the Recall - Chrysler refuses to replace the HV battery under the 10 year 100,000 mile warranty. They will not let anyone order the part even the dealer can not. To order the bad part Chrysler STAR (FCAs part replacement approval authority) has to Approve it. They say they won't replace it due to normal degradation. I was getting 30 miles per full charge and after the Recall I was only getting18-20 Miles per full charge. That is Not normal degradation. Now I only get 17-18 miles per charge. They Degraded my battery with their Recall. The battery degraded by 33% in 2 weeks – that is Not normal their Recall caused it. I feel someone needs to enforce them to put my vehicle back the the same as I turned it over to them September 26, 2023 at their Expense no matter what it takes. The following is the list of issues in the past year because of Recall 03A. Basically my vehicle was in the shop for repairs Almost the Entire year! 1. En

The back of the second row bucket bucket will no longer latch in place, and free floats forwards and backwards, the bottom latch of the seat is also not longer catching and holding the seat in one place and moves all the way forwards in backwards. This is the second time this has happen, with a car seat installed. This caused the car seat to be the at the incorrect angle for the age, height and weight of my child. The latch mechanism that holds the seat back in a fixed position, and the seat in a fixed location both failed. In the event of a crash the seat back would swing forward causing the passenger in that seat to be hunched forward, along with the passenger to be pushed into the front passenger seat. The dealership repaired this same issue several years ago and it has since happened again. We took the car to the dealership today but they were not able to take in for a repair. There were no warning for this defect, just looking back and seeing that the car seat was no longer at the correct angle, and when removing my child from the car feeling the seat back, and seat base free moving in my hand.

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 24V536000 (Hybrid Propulsion System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Middle passenger side captain seat becomes unlocked. The back rest does not stay locked and when falling forward the seat lifts up and unlocks and slides forward. You just bounce around in the seat.

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 24V536000 (Hybrid Propulsion System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The contact stated that the failure occurred immediately after the vehicle was repaired under NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System). The vehicle was taken back to the dealer. The dealer requested that the vehicle be diagnosed and provided the cost for the diagnostic test. The contact declined to pay for a diagnostic test. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was 100,800.

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 24V536000 (Hybrid Propulsion System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact took the vehicle to a dealer for NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, the contact stated the advanced collision warning light had illuminated after the recall repair. The local dealer was contacted; however, denied further assistance because the recall repair was completed. The contact was referred to the manufacturer. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 5,000. The VIN was not available.

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 24V536000 (Hybrid Propulsion System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 24V536000 (Hybrid Propulsion System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

After refueling on a recent road trip the check engine light came on. After driving for a little bit to get to a hotel for the night white smoke started coming out the back of the car. To me the incident seems similar to the recall for other 2018 Chrysler Pacifica's, noted below, but did not apply to my VIN so wasn't completed for my car. The mpg's kept going down because I believe too much fuel was being fed to the engine resulting in the white smoke. When taken to the dealer there was a pending error code to the catalyst. It is currently at the Riser Chrysler Dealership in Hot Springs, AR awaiting further diagnostic and repair. NHTSA Campaign ID: 18V740000

The contact owns a 2018 Chrysler Pacifica. The contact stated while driving 40 MPH, several unknown warning lights illuminated. Additionally, the gear shift indicator light turned off, and the vehicle lost motive power. The contact was able to pull into a parking lot. The contact turned off and restarted the vehicle however, the failure persisted, and the gear shifter became inoperable. The contact turned off the vehicle. The contact stated that upon restarting the vehicle after an hour, several unknown warning lights were illuminated, but the gear shifter was operable. The contact was able to drive to residence and parked the vehicle. The contact stated that the dealer had previously repaired the vehicle under NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System) on several occasions; however, the failure persisted. The dealer was not contacted. The manufacturer was notified of the failure. The failure mileage was approximately 69,750.

I was driving with my family on the interstate and was exiting when the car shuddered and I lost propulsion. Interior electrical power was still functional. This occurred as the car was switching to gas mode as I had been been driving about 30-35 miles on electric at that point. The gas motor never came on. I was able to roll into a gas station since we were on a bit of a downhill. Shut off car and waited a beat then started car again, battery showed 1% and was able to pull 2 more feet into gas station and off to side before it completely died again (battery at 0%). I feel extremely fortunate that this didn't happen a moment earlier when I was on the expressway and that were able to get off of a busy road. I had the vehicle towed to nearest Chrysler dealer and had a friend drive me and my family to a nearby car rental place. After two weeks at the dealer, we were informed that the issue was likely the Power Inverter Module. We are still without car and waiting for updates from service department.

I was driving on the freeway and my engine suddenly stopped out of nowhere. A console message informed me to shift from Drive to Park. The accelerator did not work. This happened 4 times before I could get off the freeway. The first time I pulled into the shoulder, but I still had to get off the freeway. I had to wait about 10 minutes each time for the engine to start again until I could pull off the freeway and wait for AAA. I did not feel safe waiting on the freeway. I'm aware that there is a recall and that Chrysler has extended my engine warranty to 10 years. This is unacceptable because: 1. Replacing a part or wire does not ensure my transmission will not give out again. I was fortunate this last time, but I may not be so the next time this happens. I could die or cause harm to others, especially if I am travelling fast in the carpool or fast lane. 2. My car is paid off and has only 40,100 miles on it. But I have lost money and value in my car. 3. Chrysler knows there is a grave problem and should recall all affected vehicles to replace the entire transmission. The company is putting tens of thousands of people's lives at risk by not doing so.

Warning message stating "stop safely, vehicle will shut off soon", which is followed by loss of power and vehicle will only go about 30 MPH. There is an open investigation according to the NHTS website, NHTSA Action Number: RQ24004. Loss of motive power due to an internal wiring connector short. Dealer says that the fix is to replace the Power Inverter module (PIM), for which we are waiting for the part.

When traveling at interstate speeds, the van suddenly went into limp mode going from 75 mph to less than 30 mph in seconds. It then told me I needed to get off the road and power down the vehicle or it would be done for me. I had to put in the flashers and take the van across 6 lanes of traffic. I had a letter from Chrysler from last summer stating was a possibility, but they just said to come in if it happened. There was no preventative measure offered. My van had to be towed to the dealer.

Tried to start car. When start button was pressed the dash lit up like a Christmas tree. Multiple error messages. FCW unavailable, power steering unavailable, fuel door open, park brake unavailable, park sense unavailable, Service hybrid electric system, power steering unavailable. The gear indication, both on dash and by shifter was flashing. The car would not turn off. I had to open hood and disconnect 12v battery for the car to power off. Waited 10 seconds and connected 12v and it power on, but the check engine light is still active

In the past 6 months, we have noticed 2 seat belts with tears in them. One of the seat belts was not even being used as a car seat using the latch system had been in that seat. The first was noticed August 2023 and we just noticed another tear affecting a different seat belt January 2024. We replaced the first and are scheduling the 2nd for replacement.

While traveling for holidays, the CEL came on. We stopped at an auto shop to confirm the error code, before driving the car back home, to ensure safety. Error code P0E15-00 "Hybrid/EV Battery Pack Coolant Heater "A" Control Performance" was the issue. This will be the 3rd-4th time that we have had an issue with the Hybrid system on this vehicle. Thankfully, we purchased an extended warranty. However, we're sure that we are not the only ones experiencing so many problems with this and the Hybrid system should be recognized as being faulty.

On Sunday, November 5, 2023, our 2018 Chrysler Pacifica Hybrid caught fire in our garage. Please refer to the attached PDF which details the incident. I have pictures and videos of the incident as well as a report from the fire department is being prepared. We have placed home and auto claims with our insurance provider, and we are also working with a disaster recovery company who is compiling a report on the damages and losses. - What component or system failed or malfunctioned, and is it available for inspection upon request? My educated guess from what I witnessed and discussions with the firefighters is it was the car’s electric battery. - How was your safety or the safety of others put at risk? Refer to PDF; further would this have happened at night and as discussed with the fire department, the toxic smoke, heat, and fire/explosion would very likely have caused the situation to have a much more catastrophic outcome. - Has the problem been reproduced or confirmed by a dealer or independent service center? I do not know specifically; however, please note PDF related to NHTSA Recall # 20V-334 we had completed in September 2023. - Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Refer to PDF; after the fire was extinguished and at the directive of the fire department, the car was taken to a local salvage yard for safety/risk of reigniting. - Were there any warning lamps, messages or other symptoms of the problem p

Pull into garage with <1% hybrid battery. Pressed the power button and the Pacifica threw an error about servicing the transmission and it would not disconnect the power to shut off the vehicle. Opened the hood and disconnected the 12v battery to complete remove electric from the system. The van completed a shutdown. Reconnected the 12v battery and closed the hood. Car returned to working conditions.

In March my van stalled as I was turning through a busy intersection with my child in the front seat. We narrowly avoided being t-boned. For a second the dash lit up with lights and then it said to shift to park to start vehicle but I couldn't shift. After finally getting it in neutral some good samaritans helped me push it out of the intersection and while I sat off to the side, after about 15 minutes of getting out and checking under the hood, the car started. We used our own code reader and it threw the PoA79 code. We brought it to Lewisville with an appointment, told them about the stall and they did the Z11 recall work for the fire risk with the battery but say there are no issues with the battery and no codes, but they have us ready for the recall work on Loss of Motive Power as soon as the recall work is available because loss of power is a known issue. They think my stall is related to the recall and needs a software update so hold off. Pick the van up after Easter. 3 months later it stalls again, this time with my child and husband on the freeway! After about 10 minutes of everything flashing, it starts again just as it did before, and the CEL clears. We call and are told that the Loss of Motive Power recall O3A process is now out for the 2018. We have never noticed an unexpected loss of charge. We were charging outside and far from our house, per the recall. No lobster popping up. Make an appointment for the O3A recall work and the van stalls on the way. This time i

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact stated that the dealer had completed the recall repair of NHTSA Campaign Number 23V010000 (Electrical System, Hybrid Propulsion System) on the vehicle; however, after the repair, the message "Service Hybrid Battery," was displayed. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 50,000.

What component or system failed or malfunctioned, and is it available for inspection upon request? - The dealer / manufacturer is unable to determine the root cause. The car shut down while I was driving on the highway. It does not start, meaning no engine turnover to operate / drive the vehicle. The only known issue was the recall for the electrical component failure. How was your safety or the safety of others put at risk? - Yes, both myself and others on the highway were at great risk. As my car shut down, I lost control of the vehicle - no power steering or ability to use the accelerator. My vehicle slowed to 40mph in the right lane, while other vehicles including trucks were still traveling at high speeds and quickly approached my vehicle. They did not see the hazard lights until they were only 20 feet away. This was very close to a fatal accident. Has the problem been reproduced or confirmed by a dealer or independent service center? - No. There is no solve to the issue. They claim, however, that they are replacing the *entire* transmission and think that this will fix the car. Yet, this seems to be an entirely separate, unrelated issue. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? - No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? - Yes, I received an error message 1 day prior. See attachment photo of dashboard. I was instruct

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact stated that the vehicle was repaired on July 28, 2023, under NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System). The contact stated that after the service visit at the dealer, the vehicle was driven to the residence and parked in a closed garage. The contact stated that on July 29, 2023, he entered the garage and discovered that the vehicle had independently started, and the garage was filled with fumes, and the gear shifter was locked in gear and was inoperable. The contact stated that he contacted the dealer and made them aware of the failure; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 57,290.

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact stated while driving 35 MPH, the check engine warning illuminated. The vehicle was taken to the dealer, where the battery was replaced; however, the failure reoccurred. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The approximate failure mileage was 55,000.

My Pacifica Hybrid van has been at a Chrysler dealership (Castle Rock in Colorado) for over six weeks now to have the Z11 recall addressed. It is clear that neither Chrysler nor their dealers know how to properly fix this (potentially lethal) issue with their vehicle batteries. Chrysler have failed to provide a loaner vehicle, even though it is stated in their recall letter that they would, and their "Customer Care" hotline have been unable to assist in any way. No one will call me back or otherwise inform me of next steps.

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue, and a case was opened. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Chrysler Limited. The contact received notification of NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available. The contact stated that the vehicle is being kept at the dealership without a repair. No help with a loaner vehicle was given.

Our car’s battery ran out and left our car blocking both lanes of our traffic. We tried to shift into neutral but weren’t able to. We found an online tutorial about a panel that contains a string to pull which would enable us to shift to neutral. When we opened the panel, we found the string was missing. Upon further research, I found this was a problem with other cars as well. When we brought it in to be serviced, they couldn’t fix it. The owner’s manual has no instructions for how to get the car into neutral.

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect. The consumer stated the recall was repaired and wants to withdraw the complaint.