2020 Chrysler Pacifica Plug-In Hybrid

Defect. Chrysler (FCA US, LLC) is recalling certain 2019-2021 Pacifica Plug-In Hybrid Electric (PHEV) vehicles. The battery pack may cause a vehicle fire when parked, even with the ignition in the "Off" position.

Risk. A vehicle fire increases the risk of injury.

Remedy. Owners are advised not to charge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed free of charge. Owner notification letters were mailed March 6, 2025. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 72B. This recall is an expansion of NHTSA recall number 22V-077.

Defect. Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.

Risk. A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.

Remedy. FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak.

The contact owns a 2020 Chrysler Pacifica Plug-in-Hybrid. The contact stated that while driving approximately 55 MPH the vehicle lost motive power. The contact stated that the "Turtle Symbol” was displayed with the message "Vehicle Will Shut off Soon - Pull Over" displayed. The contact had taken the vehicle to a local dealer; however, the failure was not duplicated. The vehicle was not repaired. The contact stated that the failure reoccurred, and the vehicle was taken back to the same dealer. The dealer was unable to duplicate the failure again. The vehicle was not repaired. The contact stated that the failure occurred while driving at various speeds and was a recurring failure. The manufacturer was contact and referred the contact to a dealer for a diagnostic test. The failure mileage was 57,016.

We were driving down the freeway at 70 mph and the vehicle displayed "Vehicle will shut off soon, pull over safely" and IMMEDIATELY lost power and the gas pedal would do nothing.

We have a broken 2nd row captain's chair on the passenger side. The seat broke with my child's car seat in it so we didn't notice until we took the carseat out and noticed the seat back was swinging freely forward and back and would not latch. In doing some research we found dozens of other people with similar age Pacificas with identical problems. You can see some details here; [XXX] Some in this forum have mentioned this specific seat part is needed for the repair: Mopar part number 68324912AC - Latch Release Cable It is extremely scary to me this seat latch could just break as the seatback would put the passenger in extreme danger in an accident. I hope you can investigate! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I received a service hybrid electric vehicle system warning. Also vehicle speed may be limited warning. When I shut the vehicle off, it was loud and remained running. My safety and the safety of others were put at risk because the warning happened while I was driving and I couldn’t get speed to park in a safe location. I had my car towed to a local Chrysler Jeep Dodge dealer and they updated software related to my car that was the source of the problem. They also told me the battery completely drained. The recall was due to a faulty PCM that the recall was for. You can see in the invoice the problem I communicated to the manufacturer before they diagnosed my vehicle. You can see clearly the vehicle was still active even after shutting off, likely causing the battery to drain completely. And due to the faulty PCM, it failed to tell the systems to shut down. Chrysler is giving me $100 for the tow. But they say the battery is out if basic warranty so will not reimburse me the $650 or so for the battery. My argument is that it doesn’t matter if the battery is out if basic warranty as the draining of it was a direct result of the recall and failed PCM. There is case law that supports the fact that If a recall-related defect (such as a faulty PCM) directly causes a secondary failure (e.g., battery damage), the manufacturer still bears responsibility, as the defect rendered the vehicle unfit for normal use.

The contact's mother owns a 2020 Chrysler Pacifica Hybrid. The contact stated while driving approximately 65 MPH, the vehicle started losing motive power. The contact stated that his mother observed the message "Stop Safely - Vehicle Will Shut Off Soon" and immediately after the warning light was illuminated the vehicle stalled. The contact stated that the vehicle was towed to the residence and was later restarted, and the vehicle was taken to a dealer. The contact stated that the dealer had diagnosed the vehicle but could not duplicate the failure. The dealer recommended that the vehicle be returned to the dealer if the failure was returned. The failure reoccurred and the vehicle was taken back to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The contact researched online and related the failure to NHTSA Action Number: RQ24004 (Electrical System). The failure mileage was approximately 50,000.

A coolant leak in the engine led to contamination, misfiring spark plugs. Check engine light came on while driving, and very soon thereafter (~3 minutes) car began sputtering while accelerating and shaking while idle. Acceleration seemed particularly unreliable and dangerous, leading driver to immediately exit the highway and continue straight to dealership on back roads. Dealer found that coolant had leaked into the engine, causing the need to replace right side cylinder head, gasket and spark plug.

Pacifica hybrid turned on but would not shift out of park or turn off. The radio was playing, air was blowing (though not cold), power doors were not functioning. The car was towed to a Chrysler service center while still running. They turned the car off and when they looked at it several days later there were no errors codes and the car was turning on/off and able to shift out of park and drive. They returned the car to me without any explanation for why this happened. The car was purchased 13 months ago and this is the second time this has happened. The car did the same thing in January 2024. The car ran for hours without being able to shift out of park or turn off. The car died by the time it was towed to the Chrysler service center. The service center recommended replacing the auxiliary battery at that time, which we did (Jan 2024). They said there were no mechanical error codes showing.

After driving a few minutes gas engine died and received "Stop safely vehicle will shut off soon" on cluster as well as a turtle icon.

I was driving in a remote region of Washington in high heat (101 F) outside of Pasco, when my car alerted me that it was going to turn off and I needed to pull the car over and stop before it shut off. I had to rapidly decelerate and dodge other vehicles to make it to the shoulder of the highway. When I pulled over and shut it off, it reported that the charging system was broken and needed to be repaired. Once off, the car would not start back up. I called for a tow through my State Farm insurance but had trouble getting a vehicle to my location. After an hour of being stranded on the highway in high heat with small children, the car finally turned back on, with the check engine light on. I took it to the Chrysler service station in Walla Walla. They said that the car showed no errors and that it was safe to drive. The check engine light turned back off. I researched this and it’s related to recall 03A, which I am now having performed. The problem is that the fix they are doing for 03A does not fix the underlying problem — it just changed the text of the error message and adds potentially a few more seconds before the car turns off and I lose control of the vehicle. I don’t understand why this “fix” was accepted if the car is still unsafe to drive. I would expect Chrysler to have to replace the faulty components in the transmission. I often have to drive in remote, unpopulated areas in bad weather, icy conditions, etc. Even with the “fix”, the car will not be safe to drive in

Both 2nd row quad seats have failed. The lever for leaning the seat forward pulls a cable that has a large spring in a plastic housing that fails. It failed on both seats within the same day in a hot weather environment. After failure, the seats both slide and tilt without the ability to lock into position. This is a HUGE safety concern as it provides no restraint to the occupant. There are hundreds of accounts of this same issue on forums and reddit posts and highly documented the part that is failed. I have taken to a dealer for repair but fear it will happen again if the part has not been redesigned by Stellantis. There is no warning to this failure so it can happen at any time. Thankfully we were at home when it failed and not stranded somewhere else. With the hundreds of instances I have read accounted online, it is SHOCKING that this is not a recall yet.

We were traveling 70 mph down a steep incline and suddenly the vehicle, a Chrysler Pacifica Hybrid, displayed the warning "Pull Over - Vehicle Will Shut Off Soon" and immediately the vehicle lost all motive power. I was able to pull over to the side of the road safely. This is the second time this has occurred. The first time a Chrysler dealership did not fix the problem. The code pulled was P0A43 related to the 03A recall.

We were driving and the vehicle displayed "Pull Over, Vehicle will Shut off Soon" along with a check engine light. Fortunately we were almost home and the vehicle made it to our house before shutting off. We took it to the dealer and the dealer claimed they were not able to reproduce the issue or see any problems with the vehicle, despite it losing motive power.

While driving, the vehicle spontaneously goes into limp mode and warns the driver to pull over immediately because it is about to shut down. This has happened at least 10 times in my ownership of this vehicle since 10/04/2023 and the first time on 10/09/2024 and most recently occurred 07/06/2024. The first time it occurred on a narrow mountain road at night but I was safely able to drive slowly for about a mile before finding a parking lot to pull over. Several times were significantly more dangerous and occurred while traveling 70mph on a busy interstate and forcing us to navigate across several lanes of traffic into the emergency lane in a vehicle that is no longer able to keep up with traffic due to significant power loss when limp mode. Once pulled over, the vehicle must be turned off for several seconds before restarting and driven again. Occupants are at significant risk of being involved in a collision during the entire process from unexpected power loss, navigating traffic with said power loss, parking and restarting the vehicle on the side of a busy road, and attempting to safely merge back into traffic which is often traveling 70+mph. This entire issue is due to a faulty wiring harness in the transmission of 2017-2023 Chrysler Pacifica Hybrid that can short circuit and requires immediate shutdown of the vehicle when it occurs. Thus far the only remedy from Chrysler is a software update which installs a driver warning to pull over and restart the vehicle before it sh

Got the stop safely Vehicle will shut off soon warning. My wife was upset and not sure what to do. Was able to start again but now we don't trust the van

Invertor coolant pump failure, giving a Check Engine Light P0E7C (coolant bypass valve B control circuit having low voltage). Part from Chrysler seems to be on national back order. replacement part offered by dealership keeps failing.

Dealer said the transmission needs to be replaced. 2020 Chrysler Pacifica Hybrid Limited (Certified) purchased in August with 28,500 miles. Bought the 7 year/100,000 mile extended warranty. Happened on Interstate 495. Chrysler Care was a joke. Wanted info filled out ONLINE. Ask for the zip code and couldn't go past that point. Finally called and waited on hold for 40+ minutes. Hell of a time trying to tell where I was on the interstate. I was almost directly under an overpass, told them the name of the overpass street and they kept wanting to put me on THAT street. Sent coordinates from Google Earth and they put me on the other side of the interstate going in the other direction. 😡 To make a 3-hour story short tow truck finally came and we got it to my dealer. Codes did say something about the transmission but the manager couldn't tell exactly. Now waiting for the service tech to call on Monday. Oh, BTW, no loaner available (even though it's covered in the warranty). The dealer called and paid for a Lyft to take us home.

The spring in the cable that operates the recline and fold function of the passenger captain’s chair failed. The seat is perpetually stuck in “loose” causing the seat back to recline and fold forward freely. Because this function is also part of the fold and move forward function, the seat also becomes unsecured and glides forward and backward on the track freely. This spring failure happened while my child’s car seat was installed and we drove around for an unknown period of time with the unsafe seat. The car seat kept the seat back stable so it remained locked but as soon as the car seat was removed it was able to unlock on its own and move on the track, etc. this has happened to other Pacifica vans according to the internet.

Check engine light came on first in 12/2021 because of a failed coolant heater. Dealer repaired under warranty in 8/2022. Loud/rough idle started 2/23 dealer could not determine what was causing the sound. Started noticing empty coolant bottle once a month. 11/23 check engine light came back on indicating coolant heater failed again. Still noticing vehicle losing coolant. Vehicle begins rough idle again and misfiring code in #3 cylinder. Dealer requires diagnostics to determine reason for coolant heater failure since they replaced in 8/22. soonest appointment avail for diagnostic is [XXX] Misfire continues. On [XXX] goes in “limp mode” take it immediately to the dealer, service advisor clears codes sends me on my way. Take vehicle to scheduled diagnostic on [XXX] and they determine the cause of the rough idle is the valve cover seal leaked oil into spark plug tubes and coils were soaked in oil. Warranty has expired and the dealer cost is $2700. I take to my local mechanic on [XXX] and he replaced all recommendations for $1800. He recommends that coolant is being lost due to head casket issues, cracked block. I have read dozens of the same experiences with these vehicles on Pacifica forums and believe that there is a huge safety issue as they are advertised for families and can carry 6+ passengers and the cost for repairs is in the $6000-$15000 range and are occurring when the vehicle warranty has expired. [XXX] [XXX] [XXX] 2020 Chrysler Pacifica Hybrid Lithia Chrysler Jeep Do

My vehicle developed a squeaking noise and led to a lower control arm malfunction I have searched the web and found that it's a common problem with a specific van My daughter owns one and developed the same problem this could result in loss of steering

Driving at approx 45 MPH the car suddenly lost propulsion and experienced a complete electrical failure. The power steering was lost, braking was stiff, gas pedal was unresponsive. I struggled to get the vehicle out of the lane of traffic. The police arrived and helped route traffic until the tow truck arrived. The vehicle is still covered under factory warranty and is currently at the dealer with no estimated return date. As a matter of fact, the Chrysler dealer that has my car hasn't returned my phone calls or voice mails in a week now to inform me how long I might be without my vehicle. A day before the incident a message appeared: ?service Hybrid electrical system It happened fast but prior to the failure the display flashed red and sounded an alarm Shift to P to start for a few seconds, then the gear shifter was flashing....then I lost all power.