2002 Volkswagen Passat

Defect. The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.

Risk. A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.

Remedy. Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.

Defect. VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.

Risk. A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.

Remedy. DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Defect. CERTAIN SEDANS AND STATION WAGONS EQUIPPED WITH 4.0L W8 ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE AFFECTED VEHICLES ARE EQUIPPED WITH TIRES OF THE MAXIMUM LOAD RATING INDEX 93H; HOWEVER, THEY SHOULD HAVE BEEN EQUIPPED WITH TIRES WITH THE LOAD RATING INDEX 97H.

Risk. THESE VEHICLES SHOULD HAVE BEEN EQUIPPED WITH TIRES HAVING THE LOAD RATING INDEX 97H.

Remedy. DEALERS WILL REPLACE ALL FOUR TIRES WITH THE PROPER SIZE TIRES. OWNER NOTIFICATION BEGAN SEPTEMBER 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VW AT 1-800-822-8987.

Defect. ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.

Risk. FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.

Remedy. DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.

To Whom It May Concern, I am submitting this letter as a formal complaint regarding an authorized automobile dealer’s refusal to perform an open safety recall on my vehicle. Vehicle information: * Year/Make/Model: 2002 Volkswagen Passat 1.8T GLS * VIN: [XXX] I contacted Platinum Volkswagen, of Hicksville, New York, an authorized Volkswagen dealer, on January 7, 2026, to schedule a repair for an open safety recall applicable to my vehicle. I was advised by the service manager that the owner of the dealership refused to perform the recall repair solely based on the age of the vehicle. He advised me to request service at another authorized dealership. The service manager confirmed that the parts for the recall were available or could have been ordered and that the decision was based solely on the individual VW franchise owner's discretion not to service older vehicles. My understanding of federal motor vehicle safety law is that open safety recalls do not expire due to vehicle age, and that manufacturers and their authorized dealers are required to remedy such recalls at no cost to the owner. The dealer did not cite recall closure, lack of available parts, or any condition that would make the repair unsafe or infeasible. I am requesting that the National Highway Traffic Safety Administration review this matter and determine whether the dealer’s refusal is consistent with federal safety recall requirements. Please let me know if additional documentation or information is required

I was letting my car run for a couple of minutes for the AC to cool down the car and I went into my house. When I came out about 2 minutes later, there was a large puddle of gas under the car in front of the right rear wheel and gas was running down the driveway all the way to the street. I immediately turned off the car and the gas stopped pouring out from under the car. I was lucky the car, my house or I did not go up in flames.

WHILE DRIVING INTO THE MALL PARKING LOT AT SPEED OF 20 MPH ALL AIRBAGS EXPLODED EXCEPT THE STEERING WHEEL AIRBAG AND MY DAUGHTER SUFFERED FROM ARM AND AIR INJURIES

WHEN IT RAINS THE CAR GETS FLOODED CAUSING THE WHOLE WIRING SYSTEM THROUGH THE CAR TO GET DAMAGE. THE CAR WILL SUDDENLY LOSE POWER AND DIE AS YOUR DRIVING. SEEMS TO HAPPEN. WHEN ON HIGHWAY MOST. THE CAR WILL NOT START OR CRANK. I'VE HAD TO VACUUM THE FLOOR BOARDS AND TRUNK, SEARCH FOR DAMAGED WIRES, CHANGE RELAYS AS WELL AS CAMSHAFT POSITION SENSOR, AND FUEL PUMP.AS WELL AS SENSORS. TRYING TO GET IT RUNNING AGAIN. ALSO THE TRANSMISSION JERKS VERY HARD WHEN TRYING TO GO INTO REVERSE AND MOST OF THE TIME IN SLIPS OUT OF GEAR WITHIN1OR 2 SECONDS.

HEADLIGHT PIGTAILS HAVE MELTED ,FUEL PUMP HAS GONE ,AND THE PLASTIC RESERVOIR PEICE FROM MY COOLANT PUMP HAS MELTED OFF DRIVER SIDE WIPER ARM BAR HAS MALFUNCTIONED

THE ABS LIGHT CAME ON AND BRAKE LIGHT IS FLASHING RED. THE ABS MODULE SEEMS TO BE BAD. THE VEHICLE HAS THESE LIGHTS WHEN ITS MOVING AND STATIONARY

I PURCHASED A 2002 PASSAT W8 4-MOTION, HAVING ONLY 126,000 MILES ON THE ODOMETER, IN OCTOBER 2017 OFTEN AFTER REFUELING THE VEHICLE, I WOULD NOTICE THE FAINT SCENT OF GASOLINE. UPON INVESTIGATING WHERE THE GASOLINE SMELL WAS ORIGINATING, I FOUND IT HAD DEVELOPED A VERY LARGE FUEL LEAK FROM WHICH FUEL COULD BE SEEN DRIPPING ON THE FORWARD, LEFT SIDE OF THE FUEL TANK. AFTER PERFORMING SOME BRIEF RESEARCH, I FOUND THAT THERE WAS A RECALL ON THE PASSAT 4-MOTIONS, DATED APRIL 2008, IN REGARDS TO A VENTILATION VALVE ON THE FUEL TANK. I PROMPTLY MADE A APPOINTMENT WITH MY LOCAL VW DEALER FOR DEC 4TH. ON DECEMBER 6, 2017, I CONTACTED THE DEALERSHIP ASKING JAY, THE SERVICE MANAGER AT THE VW DEALERSHIP, IF THEY FOUND THE VENT VALVE TO BE LEAKING. I WAS TOLD THAT THE VALVE WAS IN FACT LEAKING AT THE BONDED VALVE POINT. AFTER HEARING NOTHING THE NEXT TWO DAYS, I RECEIVED A PHONE CALL FROM VW STATING THAT THEY FOUND THE UNDER-BODY DAMAGE TO BE THE CAUSE OF THE LEAK. I REQUESTED TO SEE THE PICTURES OF THE DAMAGE SO THAT I COULD EXAMINE THEM MYSELF. ON DECEMBER 11, 2017, I RECEIVED THE PICTURES FROM THE SERVICE MANAGER SHOWING THE HEAT SHIELDS SURROUNDING THE TANK TO HAVE SOME BRUSH MARKS AND TO BE DISFIGURED A BIT. PLEASE KEEP IN MIND, THIS WAS A KNOWN ISSUE IN THE EARLY 2000'S, AND THE VEHICLE IS NOW 15 YEARS OLD WITH 127,000 MILES ON IT AND THE RECALL HAD BEEN COMPLETED. THIS "DAMAGE" WOULD NOT LEAD TO A FUEL TANK LEAK AS THE FUEL TANK ITSELF WAS NOT DAMAGED. VERY UPSET, I WROTE TO THE R

THE ABS BRAKES ARE FAULTY....THEY WORK RANDOMLY. FROM WHAT I HAVE RESEARCH THIS PARTICULAR MODULAR SHOULD HAVE BEEN A FACTORY RECALL.....

I GET AN AUDIO AND VISUAL ALERT ON MY DASH STATING TO 'STOP, BRAKE FAILURE' IT HAS OCCURRED MANY TIMES WHILE DRIVING, TURNING, AND PARKED WITH THE CAR ON. THE CAR'S BRAKES HAVE NEVER FAILED TO BRAKE APPROPRIATELY. I BROUGHT THE CAR INTO MY MECHANIC. THE OBD 2 SCAN SHOWS NO FAULTS AND MY MECHANIC SAYS THE BRAKES ARE FINE AND THESE CARS ARE KNOWN TO HAVE A FAULTY ELECTRONIC BOARD WHICH FALSELY ALERTS OF A BRAKE FAILURE.

ABS LIGHT IS ON

AIR BAG FAULT MESSAGE WHEN STARTING MY CAR EVERYTIME.

WHEN FUEL TANK HAS APPROXIMATELY 8 GALLONS OR MORE, FUEL POURS OUT FROM UNDER THE REAR DRIVER'S SIDE ABOUT TWO FEET FROM THE OUTER KICK PANEL. NOTICED THERE WAS A RECALL AND VWOA SAID THAT MY VIN DOES NOT QUALIFY FOR THE RECALL DESPITE MY EXPLAINING THAT THE PROBLEM IS IDENTICAL TO OTHER COMPLAINTS ON VEHICLES THAT WERE RECALLED. THIS WAS AT 118K MILES AND IT HAPPENED TO THE PREVIOUS OWNER ARROUND 80K.

THE GAS TANK IS LEAKING ON THE UPPER SIDE BEHIND THE REAR SEATS WHEN IS FULL. I THINK VOLKSWAGEN RECALLED SOME VEHICLES FOR THE SAME PROBLEM IN THE PAST.

FUEL LEAK AFTER FILLING GAS TANK. LEAK ON DRIVER SIDE UNDER REAR DOOR. STOPS AFTER GAGE IS BELOW 3/4 FULL.

PERIODICALLY, WHEN DRIVING, THE "ABS", "BRAKE", AND THE "ANTI SLIP REGULATION" LIGHTS WILL FLASH WITH AN ALARM SOUND THAT LASTS AROUND THREE SECONDS AND THE LIGHTS GO OFF. THIS HAPPENS WHEN THE CAR IS RUNNING AND HAS HAPPENED ON THE HIGHWAY AND WHILE STOPPED. THERE IS NO DIFFERENCE IN THE WAY THE CAR HANDLES, DRIVES, OR BRAKES DURING AND AFTER THIS OCCURS. ON ONE INSTANCE THE "ANTI SLIP REGULATION" LIGHT STAYED ON AND I HAD TO STOP AND SHUT THE CAR OFF. WHEN I STARTED IT AGAIN, THE LIGHT WAS EXTINGUISHED. THIS HAS BEEN GOING ON FOR 3-4 MONTHS AND ONLY HAPPENS ABOUT ONCE A WEEK.

ABS LIGHT COMES ON WHILE DRIVING BRAKES LIGHT FLASHES ON AND OFF WITH NOISE

TL* THE CONTACT OWNS A 2002 VOLKSWAGEN PASSAT THE CONTACT STATED THAT THE VEHICLE LEAKED FUEL WITHOUT WARNING. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 08V156000 (FUEL SYSTEM), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE CONTACT STATED THAT THE VENTILATION VALVE WAS FRACTURED AND CAUSED FUEL TO LEAK. ALSO, THE TANK ONLY LEAKED WHEN IT WAS MORE THAN HALF FULL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000. UPDATED 01/25/17*LJ *TR

TL* THE CONTACT OWNS A 2002 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A FUEL LEAK. UPON FURTHER INSPECTION, THE CONTACT NOTICED THAT THE FUEL LEAK ORIGINATED NEAR THE REAR OF THE EXHAUST. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS CONFIRMED THAT THERE WAS A FUEL LEAK IN THE VEHICLE COMING FROM THE TOP OF THE FUEL TANK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 08V156000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.

REPORT RECEIPT DATE: APR 07, 2008 NHTSA CAMPAIGN NUMBER: 08V156000 COMPONENT(S): FUEL SYSTEM, GASOLINE WHEN FUEL TANK IS MORE THAN 3/4 FUEL A FUEL SMELL APPEARS INSIDE THE VEHICLE. A PRIOR RECALL WAS DONE FOR A HEAT SHIELD, FUEL LINE AND 4MOTION FUEL TANK VENT VALVE FOR INSPECTION AND REPLACE AS NEEDED. THESE SEEM TO FAIL AGAIN. MOST DEALERS MARK RECALL AS PERFORMED WITHOUT A LEAK AND WHEN THE LEAK ACTUALLY OCCURS THEY TRY TO DENY THE ISSUE AS PERFORMED ALREADY. THIS NEEDS TO BE ADDRESSED SO THAT OWNERS OF LOWER MILEAGE VEHICLES ( UNDER 150000) CAN GET THE REPAIR FIXED UNDER A RECALL THAT HAS BEEN ON THE VEHICLE PRIOR.

LOW OIL PRESSURE LIGHT CAME ON FOR THE FIRST TIME AND NOW ENGINE MAKES A TICKING NOISE. THERE WAS A RECALL FOR THIS ISSUE. NOW I'M STUCK WITH A CAR I CAN'T GET FIXED. FOR AN ISSUE THAT HAD A LAW SUIT.