2021 Toyota Tundra

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain JTEKT power steering gear assembly service parts for 2007-2021 Tundra and 2008-2022 Sequoia, part numbers 44250-0C160, 44250-0C131, 44250-0C170, and 11250-0C121. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.

Risk. An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.

Remedy. Dealers will inspect and replace the power steering gear assembly, free of charge. Owner notification letters were mailed on February 17, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 21TH01.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.

Risk. An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.

Remedy. Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2021 Tundra vehicles. The headlight electrical circuits may power the high and low beams simultaneously, which could overheat the electrical connector.

Risk. An overheated electrical connector can increase the risk of a fire.

Remedy. Dealers will modify the engine wire harness assembly and replace any damaged bulb, bulb connector, and/or headlight assembly as necessary, free of charge. Owner notification letters were mailed April 25, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB06 and 21TA06.

The TPMS display went thermal. It blew smoke out of the unit that is mounted to the drivers side front windshield. We were able to disconnect USB power to the device and roll the windows down to ventilate the cabin and ultimately remove the device from the windshield and isolate it. If we would not have been in the vehicle at the time of the failure this could have been a catastrophic failure between the solar collector and the LiFePO4 battery going thermal. There has been no inspection of the vehicle as we were able to remove the device prior to any serious damage. There were no warnings, the TPMS display simply went dark and quite reporting tire data, then a strong burning smell followed by smoke.

Were were driving, my 2021 Toyota Tundra, just stopped running. No check engine lights had come on until the engine stalled as we coasted to a stop on the side of the road. We had it towed to the Central Maine Motor in Waterville, Maine 04901. Central Maine Motor -Toyota service just got my truck in to a service bay today 1/29/26 and in formed me the failure was due to the fuel pressure module and a fuel pump failure. Toyota has other years of vehicles that they have issues recalls for and my truck has the same fuel system and fuel pump as in those year vehicles, but no recalls for my truck, a 2021 Toyota Tundra built in Sept/Oct of 2020. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Airbag , it was bad accident on freeway , but my car airbag did not work.car did not inspect with dealer , they were not any waring sign

When I turn the key to crank my radio doesn’t come on , A/C won’t blow and I have to jiggle the keys or restart it to end the issue. My husband has witnessed thi happen many times. Scared I might have an electrical issue. Contact me back for assistance to me for this issue please. It doesn’t happen every time either.

The contact owns a 2021 Toyota Tundra. The contact stated that while driving at an undisclosed speed, the vehicle briefly hesitated and jolted, prompting the contact to discontinue driving the vehicle. The transmission warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 48,000.

The power steering failed at around 38,000 miles. The dealership indicated the entire assembly needs to be replaced which cost more than $6,000. This is apparently a known manufacturing issue as they recalled a significant portion of the vehicles made in 2021.

My sunroof exploded due to weather conditions while i was driving with my family on highway during heavy rain storm

The contact owns a 2021 Toyota Tundra. The contact stated that after inserting the fuel nozzle into the vehicle, fuel spilled back out of the vehicle onto the leg of the contact. The vehicle was taken to the local dealer who was unable to duplicate or determine the cause of the failure. The failure reoccurred approximately one year later, and the dealer was unable to duplicate or determine the cause of the failure. The contact stated that during the failures the fuel tank had approximately a quarter tank of fuel and the vehicle had been driven for approximately six hours on an extremely hot day while the air temperature was above 105 degrees. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 18,000.

My moon/sunroof exploded while driving for no apparent reason.

Pre collision warning has erroneously activated numerous (>10) times on the same section of roadway. No other vehicles, pedestrians or animals were present on roadway.

Drivers seat has lateral movement in it associated when vehicle is engaged in a slow speed descending right turn. Dealer claims nothing is wrong.

I've taken my truck in 3 times for a problem with the driver seat having excessive play. Whenever I stop at a light or pull off the seat rocks back and forth. Each time I've taken it in to the dealership they tell me that it is a seat track issue and that if I raise my seat the play will lessen? I've tried that and it still didn't correct the issue. This problem has gotten progressively worse and I'm worried that the seat is going to collapse completely one day when I stop or pull off. I've driven different Tundras of friends and relatives and those trucks don't have this problem. I feel like this is a major safety issue and Toyota should correct this issue or replace the seat track. The first time took it in for this issue was on 7-12-2021 and the last time I took it in for this issue was 23-Jan-2024 .

I purchase a bren new tondrua 2021, and sain moment q have the I realize I didn’t find the ac drain for condensed wather to drop, And then look around the car a found the cone, yes is cone, because the por desing the ac house star to have electric issue because the m wather, Toyo need to make a recol to solve this problem o ac house drain

The software in the combination meter's electronic control Instrument Panel LCD display frequently goes blank I have taken my vehicle at least 5 times since I bought it 18 months ago as a new vehicle and it is yet to be remedied. This is the same issue that the 2022 Thundra has, 2021 should be included in the recall as well to remedy this problem

When I was driving and snow accumulating on the windshield put stress on the windshield wiper arm. The arm stopped working and I later found that the arm stripped out. I contacted three different dealerships and Toyota America and was told the wiper arm is no longer made ( part #85221-0C021 ). I told Toyota if it rains or snows I can not drive the vehicle due to laws and safety issues. I thought under the Magnuson-Moss act, a manufacture had to keep parts for items under warranty.

The contact owns a 2021 Toyota Tundra. The contact received notification of NHTSA Campaign Number: 21V920000 (Steering) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The seats shifts back and forth when brakes applied or hit the accelerator pedal. I’ve taken to two different dealers n made complaints but not results or repairs have been made.

The seat has been loose since I first purchased the truck, first time at the dealer they said it was the cushion which it wasn’t and they ordered part and it didn’t fix the situation. The next oil change I took it in and they said it was the frame, bottom of seat, and they ordered one and it’s been on back order a year now or thereabouts. Now I’ve owned the truck for over a year and a half and still no resolution. If an accident occurs will the seat completely break and fling me out of the vehicle? Anyhow multiple phone calls to dealership and now a phone call to Toyota themselves has yielded no resolution.

Vehicle is now 6 months old from original & new purchase. Within 30-days of ownership, (1) approx 1.5mm in size chip was fully repaired half way up from the front of the windshield. Eight hours ago (1) extremely small pebble, approx 2mm in size, contacted the front windshield 2 inches from lower portion centered in front of the driver and NOT in the area of the previous repair. Now, the same chip is a full length horizontal crack. Windshield material(s) seem to be extremely prone to failure and possibly not up to NHTSA or federal specifications...

LED lights are loose and rattle and flash all over the place. While driving over 40+mph or going over any bumps on the road . This only affects TRD PRO tundra’s with factory Ridgid lights . Toyota does not have a toyota approved repair even after going to dealership multiple times and calling toyota USA . They will not do anything for this safety issue besides offer lemon law options . Toyota states this is the only one with this issue . I have done research and brought this issue on a toyota trd forum and received over 100 complaints of other trd pro tundra owners with the same issue and toyota just gives them the run around . I brought this up to my toyota case manager and declined this is an issue . This can cause Photosensitive Epilepsy seizures and can cause serious injuries or death. Toyota has already replaced bezels once and issue persist they state they have updated bezel but have no ETA on when will be made available to be replaced. Toyota should make a recall on these trd pro tundras . My Toyota USA claim number is 220519001173