2006 Toyota Tundra

Defect. Tenneco Automotive (DRiV) is recalling certain aftermarket ball joints for 2004-2007 Toyota Sequoia and 2004-2006 Toyota Tundra vehicles, MOOG part number K80521, K80522, NAPA part number NCP2601633, NCP2601634, ACDelco part number 45D2344, and 45D2345. The ball joint housing may have inadequate hardness, causing premature failure.

Risk. A ball joint failure may cause a loss of control, increasing the risk of a crash.

Remedy. DRiV will work with distributors to return unsold parts. Dealers will inspect and replace the ball joint as necessary, free of charge. Owner notification letters were mailed on March 17, 2022. Owners may contact DRiV customer service at 1-877-489-6659 or at [email protected].

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Risk. An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy. Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.

Defect. Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Risk. If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Remedy. SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2003-2006 Toyota Land Cruiser and Lexus LX470, 2005-2006 Toyota Tundra and Sequoia, 2004-2006 Toyota 4Runner and Lexus GX470 vehicles equipped with side curtain-shield-air bags. The affected vehicles have an air bag control module that may be improperly programmed, causing the side curtain-shield-air bags to deploy inadvertently.

Risk. If the side curtain-shield-air bags deploy unexpectedly, it can increase the risk of occupant injury.

Remedy. Toyota will notify owners, and dealers will replace the air bag control module with one that has improved programming, free of charge. The recall began on December 1, 2016. Owners may contact Toyota customer service at 1-888-271-9371. Toyota's number for this recall is G0C and GLB.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015 that they are recalling certain model year 2004 Sequoia vehicles manufactured August 18, 2003, to August 19, 2004, and 2003-2004 Tundra vehicles manufactured March 18, 2003, to August 25, 2004. On June 16, 2015, Toyota expanded the recall to include an additional 1,270,468 vehicles, including model year 2002-2003 and 2005-2007 Sequoia, 2005-2006 Tundra, 2003-2007 Corolla, 2003-2007 Corolla Matrix, 2003-2007 Pontiac Vibe and 2002-2007 Lexus SC vehicles. This is to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. This recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. A replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.

Risk. In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy. 2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-285 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the front passenger air bag. The recall began on July 13, 2015. Toyota owners may contact Toyota customer service at 1-800-331-4331. Pontiac owners may call 1-800-762-2737. NOTE: This recall supersedes recall 14V-312 in its entirety.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015, that they are recalling 2005-2007 Lexus SC, Toyota Corolla, Corolla Matrix, Sequoia, and Pontiac Vibe, and 2005-2006 Toyota Tundra vehicles that were originally sold, or ever registered, in Florida, along the Gulf Coast, Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan and American Samoa. On June 16, 2015 Toyota expanded the recall to cover an additional 769,055 vehicles, including certain model year 2002-2004 Lexus SC, Toyota Sequoia, 2003-2004 Toyota Corolla Matrix, Toyota Corolla, Pontiac Vibe, and Toyota Tundra vehicles, as well the vehicles covered by the May 13, 2015 notification in the portions of Georgia, Alabama, Louisiana, Mississippi and Texas that were not previously included. The inflators in the front passenger air bags are susceptible to rupture in the event of a crash necessitating the deployment of the front passenger air bag.

Risk. In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy. 2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-286 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the passenger side front air bag, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota began the recall on July 13, 2015. Pontiac Vibe owners may contact GM at 1-800-762-2737. GM began the recall on June 29, 2015. NOTE: This recacll supersedes recall 14V-655 in its entirety. For vehicles located in the U.S. states not listed above, please see Toyota recall 15V-285 which covers all other U.S. states.

Defect. Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Risk. Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Remedy. SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

Defect. GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Risk. THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy. DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

Defect. SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Risk. A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy. DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

Defect. TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."

Risk. INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.

Remedy. TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.

Defect. CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.

Risk. LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy. CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.

Defect. ON CERTAIN TRUCKS AND MINI VANS, DUE TO POSSIBLE IMPROPER FINISHING OF THE FRONT SUSPENSION LOWER BALL JOINT, SOME BALL JOINTS MAY EXPERIENCE AN INCIDENTAL DETERIORATION OF THE INTERNAL LUBRICATION. THIS MAY CAUSE THE BALL JOINT TO WEAR AND LOOSEN PREMATURELY, WHICH COULD RESULT IN INCREASED STEERING EFFORT, REDUCED VEHICLE SELF-CENTERING, AND NOISE IN THE FRONT SUSPENSION.

Risk. IN EXTREME CASES, IF THE VEHICLE IS CONTINUOUSLY OPERATED IN THIS CONDITION, THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE AND COULD CAUSE A LOSS OF VEHICLE CONTROL.

Remedy. DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS. THE RECALL BEGAN ON FEBRUARY 28, 2007. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Defect. CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy. CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at …

This investigation was opened based on 20 reports of model year (my) 2000 and 2001 vehicles experiencing severe corrosion of the frame, resulting in either under-body mounted spare tire separation or rear brake failure.the failure report counts shown above are for my 2000 and 2001 vehicles only.by letter of november 16, 2009 toyota has notified the agency that it will conduct a safety recall (09v-444) of approximately 110,000 model year (my) 2000 through 2003 tundra vehicles.the affected recalled vehicles were sold or are currently registered in the district of columbia and the states of ct, …

In a letter dated january 18, 2007, toyota notified NHTSA of a safety defect in model year (my) 2004 through 2006 toyota tundra and my 2004 through 2007 toyota sequoia vehicles produced between september 15, 2003 and november 17, 2006 (NHTSA recall no. 07v-013). According to toyota, ?in the front suspension lower ball joint on the subject vehicles, due to possible improper finishing of the ball joint, such as the aspect of the ball stud surface, some ball joints may experience an incidental deterioration of the internal lubrication. This may cause the ball joint to wear and loosen …

Region Email: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following information for Regional and PD associates.

Region Letter: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following information for Regional and PD associates.

Dealer Email: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following information for Regional and PD associates.

Dealer Package: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following information for Regional and PD associates.

Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical impurities in the atmosphere. If these acidic compounds settle on an exposed vehicle, especially the horizontal areas such as the hood, roof, and decklid, significant damage to the painted surfaces can occur. Acid rain damage can typically be identified …

To prevent brake rotor rust from forming during transportation and storage, wheel film will be used instead of a cardboard type of anti-rust cover. The purpose of the wheel film is to shield the disc brake rotor from weather elements and initial rust before the vehicle is delivered to the customer. Consequently, the film should remain on the wheel for as …

The condition known as acid rain is caused by airborne chemicals or particles in the atmosphere, which mix with rainwater, nighttime dew, or high humidity to form acidic compounds. If these contaminants settle and remain on a painted vehicle surface, especially the horizonal areas of the hood, roof, and decklid, significant damage can occur. This damage is …

Toyota vehicles are currently protected with RapgardTM protective film designed to protect the horizontal painted surfaces. This material protects from acid rain, environmental fallout, and rail contamination. Follow the Removal Procedure in this bulletin to remove the RapgardTM protective film within 90 days from initial application.

Vehicles may occasionally be subjected to contamination by airborne iron particles shed from railroad tracks, train wheels, exposure to heavy machinery facilities, grinding, welding, etc. This type of contamination can be identified by the presence of small, red or brown particles on the paint surface. These particles are often difficult to see on dark …

Some 2005 – 2024 Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Service Bulletin is to provide general guidelines and procedures for odor remediation. This Service Bulletin provides a …

The vehicle was at the independent mechanic. For a repair and discovered that the bottom frame was rusted. The vehicle was not repaired. The dealer was also notified of the failure; however the vehicle was not diagnosed or repaired. The manufacturer was not notified of the issue. The approximate failure mileage was 330,000.

My frame is rotting, with literal holes in it. I spoke with a dealership and they stated the recall had been fixed in 2015, prior to me owning it. I was told to contact the manufacturer and they said it would be an out of pocket expense. When I research the recall, the affected area of the frame is the same, with no apparent fixes.

The frame has rusted so badly that the sway bar mount disengaged from the frame. Brought it to a Toyota dealership and confirmed that frame recalls were performed on earlier models with the same issue . However my year did not qualify.

The contact’s father owns a 2006 Toyota Tundra equipped with Cooper Tires, Tire Line: Discoverer Rugged Trek, Tire Size: 265/70/R16, DOT Number: (N/A). While the contact’s father was driving at an undisclosed speed, the driver lost control of the vehicle. The contact’s father was able to regain control of the vehicle by releasing the accelerator pedal and allowing the vehicle to decelerate. The driver was able to pull over to the side of the road to inspect the vehicle. The driver became aware that the tread on the driver's side tire had separated, causing a portion of the tire near the seam to detach around the entire tire. The tire was a replacement tire. The driver replaced the tire with the spare. The contact sent an email to American Tire Depot where the tire was purchased. The manufacturer was informed of the failure. The vehicle failure mileage was approximately 194,040, and the tire failure mileage was approximately 17,339.

I own a 2006 Toyota Tundra with severe frame corrosion and rot. The rust has eaten through major portions of the frame, especially around the rear crossmember and leaf spring mounts. It has compromised the vehicle’s safety and structural integrity. Toyota previously offered frame replacements and extended corrosion coverage for similar models (Tacoma, Sequoia, and certain Tundras), but my VIN was denied even though the issue is identical. The corrosion is so severe that it poses a risk of the frame snapping or suspension components detaching while driving. This is a serious safety defect, not just cosmetic rust. The frame can fail without warning, which could lead to loss of control or an accident. Toyota should be required to inspect and address this defect for all affected vehicles. Location of problem: Frame rails, rear crossmember, spare tire area, and control arm mounts. Date problem occurred: 07/09/2025 I’m requesting that NHTSA investigate and require Toyota to include my vehicle in their frame corrosion program or issue a new recall covering affected first-generation Tundras.

Frame rust is so extreme that rear suspension mounts are completely disconnected from frame

The contact owns a 2006 Toyota Tundra. The contact stated that while driving 25 MPH, the brake pedal was depressed to prevent a crash with another vehicle that had pulled in front of the vehicle, but the vehicle failed to respond. The contact was able to veer into another lane safely, and the crash was avoided. The brake warning light was illuminated after the failure. The contact continued driving and was able to slow down by shifting the transmission into a lower gear. The vehicle was taken to an independent mechanic, where it was diagnosed with brake line failure which lead to the brake master cylinder and brake fluid reservoir becoming empty. The brake line was replaced, and the vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 277,000.

The contact owns a 2006 Toyota Tundra. The contact stated that upon further inspection, it was noticed that the frame was rusted. In addition, the contact related the failure to an unknown NHTSA Campaign that was performed in the past; however, the failure reoccurred. The local dealer that performed the recall repair was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 200,000.

The lower ball joint broke causing the upper ball joint to break and damage the strut rocked pion and the brake line. I contacted Toyota and they said it was fixed from a former recall

The frame on my 2006 Toyota Tundra SR5 has severe corrosion and multiple areas of rust perforation despite being treated under Toyota’s Limited Service Campaign D0D in 2015. During that campaign, the dealer removed the bed, documented active rust on the frame, cleaned it, and applied Corrosion-Resistant Compound (CRC) to key areas as the preventative remedy. As documented in multiple repairs the corrosion was already advancing at the time the CRC was applied, the steering shaft boot was replaced the same day as the compound was put on at 93,822 miles, several other critical safety failure shortly after; the brake pivots seized at 94900, Rotors rust pitted at 99537, bumper had perforations at 109407, 1 brake line from master cylinder and 1 brake line from ABS actuator leaking near the junction block on L/S of the frame at 113422, 52 days later the shift cable was broken at 114904. The current perforation and delamination indicate that the D0D remedy failed to prevent structural degradation as intended. The vehicle is available for inspection upon request. The vehicle’s structural integrity is severely compromised, creating a risk of frame failure while driving. This puts my safety and the safety of others at risk due to potential loss of control or component separation. The problem has not yet been inspected by the dealer in its current condition but has been escalated to Toyota Corporate. I have attached the communications with them. The truck has been fully serviced through

The contact owns a 2006 Toyota Tundra. The contact stated that while depressing the brake pedal, the steering wheel vibrated abnormally, and the steering wheel was difficult to hold steady. The contact stated that extra effort was needed to secure the steering wheel while depressing the brake pedal to stop the vehicle. The contact stated that the TPMS was providing erroneous operating information and alerts. The contact inspected the vehicle and became aware that the cross member near the steering rack had a fractured in the frame. The vehicle was taken to a Toyota Collision Center, where a mechanic determined that the entire sub frame needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the Toyota Collision Center for assistance. The manufacturer opened a case for the failure. The failure mileage was approximately 148,857.

I have a 2006 Tundra with 120k miles and I was told it wasn't one that was effected by the recall. However I'm have frame rot issues and just had to spend thousands of dollars to make it safe. This is the second time I've had to repair the frame in the 4/5 years I've owned it.

The contact owns a 2006 Toyota Tundra. The contact stated upon taking the vehicle to an independent mechanic for a routine brake line repair, the contact was informed that the sub frame was severely corroded. The mechanic informed the contact that the frame could collapse if the contact continued driving the vehicle. Additionally, the contact stated that while driving at an undisclosed speed and depressing the brake pedal, the vehicle hesitated to respond. There was no warning light illuminated. The vehicle was not repaired. No further information was available. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 35,000.

My 2006 tundra has major rust on the frame to the point it isn't safe to drive anymore. I have reached out to Toyota and my local dealer and have received the same answer from both saying its not something that Toyota will cover, despite the fact that there was a national safety recall that started in 2016 for rust related issues.

The frame/chassis of my truck has sections that are completely rusted out. For instance, the part of the chassis that is responsible for holding the fuel tank in place is rotting away. I know there was a service campaign to have these trucks coated with some preventive coating but that is as effective as the original coating. The truck needs a new frame due to rust.

The truck as a whole is in immaculate condition with absolutely no other issues other than the frame is completely rotting away. Holes on multiple pieces of the frame well above the six of a quarter.

June 14-15, 24 I was driving down the road when all of a sudden it felt like I hit something hard with the passenger front side of my truck. I knew there was nothing anywhere in the road other than potholes, so I was very shocked and worried of what it was. The truck jerked hard and slammed my head into the driver side window post almost knocking me out. It took all I had to keep from wrecking and hitting someone head on. Upon inspection, I saw that the frame had completely rusted through on the passenger side. I had a mechanic, body shop and several very experienced people look at it and have spoken with my insurance company and sent photos, but all are saying this is a serious life threatening Toyota issue where there were recalls and class action suits and they should be held accountable because they know there is a problem. Carfax didn’t show any issues and there were no apparent issues that stood out when I purchased the truck in Oct 2023. I still owe a lot on it and can’t drive it due to this issue. My mom spoke with a lady at Toyota who agreed that this never should’ve happened and that they would work with us to remedy the problem. Then she was transferred to another dept and then another dept and eventually told that Toyota has no open campaigns, the vehicle is out of warranty due to age and miles. No pictures were asked for even though they were offered as this is a serious safety problem that they know about. I was unaware at the time of purchase of this serous pro

On April 6, 2024 I was driving my 2006 Toyota Tundra when the brakes gave out and the vehicle went through the back wall of my garage. The brake fluid spilled onto the street and onto my driveway. There are 3 witnesses to this including a police officer. I am lucky that I was not a highway when this happened. I had the Tundra towed to a repair garage and they put it on a hoist. Two mechanics showed me the underside which is completely rusted , including some holes. They told me I would have continuous problems because of the rust. They also said that Toyota may have had a recall for my vehicle. I did the research and found that to be accurate. The recall includes millions Toyotas, including my Toyota Tundra, built between 2004 and 2008. So mine is eligible. However, Toyota did not contact me about the recall. Toyota did contact me about another recall involving the air bags. Toyota sent me a letter about the air bags. I still have the letter and I can send a copy if you wish. So, they have my name, address, and they know that I own the Tundra. But they did not contact me about the frame rust. Had they done so, I would have acted immediately. I purchased the vehicle in 2012, so it was a used vehicle. So, Toyota, obviously has had plenty of time to notify me, but they did not. I called Toyota and gave the person I talked to the VIN. She looked it up and told me there is " no service history of rust frame repair" for my Tundra" on their system. Toyota needs to rectify this. I ex

Lower ball joint broke Lower control arm collapse causing the to come off

Major Frame rust issues through out,front and rear. Mechanics afraid to do wheel alignment.

06 Toyota Tundra SR5 with has severe frame rusting, to the point the truck has became a safety hazard. I tried to take the truck in for a Fluid Film coating and/or a Ziebart coating, and they both said I shouldn't even bother. Hundreds of thousands of these trucks all had frame issues, and Toyota should step up to the plate and fix them.

My frame on the truck is rusting and cracking. Toyota issued a recall for 2000-2003 tundras and didn’t include the 2004-2006 tundras. These frames are a danger to the driver and others on the road.

Frame has snapped after being denied a replacement by Toyota under their extended service campaign for frame issues. Dealer told customer to make a separate appointment for frame inspection while truck was in for unrelated service and campaign had expired while customer was in hospital ultimately ending with Toyota denying a replacement citing that customer was outside of date for service campaign.

Tried to make an appointment with Ray Brandt Toyota in Kenner Louisiana. Made the appointment online, but could not get someone to call me back telling me if the airbag part was in I tried calling countless times I tried going through their website. Chat nothing. I’m going to have to drive over an hour away to another Toyota dealership, due to this once lack of concern towards their customers. I don’t even feel safe driving my vehicle due to metal being in the airbags.

I purchased vehicle from private dealership Mar/23 with mileage of 77k. While under dealer warranty had it inspected at local Toyota dealership for frame defects. Was told none were found and none were reported in service records. These records were from the Toyota dealership where previous(and original) owner had every factory recommended service performed over a 16 year period. In Dec/23 I discovered, on accident, significant deterioration of frame components as well as a large hole in the main frame rail. This hole was disguised with sheet metal, epoxy, and spray paint. Took it back for re-inspection where the issues were recognized as in serious need of repair. Other trucks of this era were eligible for frame replacement but was told mine was not, nor are the necessary parts available should I want to replace the frame out-of pocket. Truck now has only 82k miles on it but driving it poses a safety concern for those in and around it.

I took the vehicle in for routine oil change. The technician advised on his notes: " Safety hazard: there is very bad rust on the frame of this truck. The sway bar and engine mount looks like it could break free at any time" I then took the vehicle to my Toyota dealer who inspected the frame and advised they couldn't fix it and they did not recommend driving it due to the rusted frame.

I have a 2006 Toyota Tundra SR 5 with only 88330 miles. I had it inspected yesterday and was told that the truck may not pass next year due to the known issue of undercarriage rust. I had checked into this with Toyota in the past and was told that my particular truck was not covered by the recall for this rust issue. I am not sure why or how my truck was excluded from the safety recall but believe it was, and for me, still is an issue that needs to be addressed. The truck is in otherwise beautiful condition with an intact gold paint job and matching Leer camper shell. In fact I get a lot of compliments and believe that it would be also in Toyota's interest to keep this classic on the road. I am hoping that they will work with me in this regard. Thank you in advance.

The contact owns a 2006 Toyota Tundra. The contact stated while an independent mechanic was performing an oil change on the vehicle, he informed the contact that the subframe was severely rusted. The vehicle was taken to several mechanics, who informed the contact that the subframe might collapse if he continued driving the vehicle. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened; however, the manufacturer later informed the contact that they could not assist because an unknown recall related to the failure was previously completed on the vehicle. The failure mileage was approximately 145,000.

Hi, I have a 2005 Toyota tundra with 115,000 miles on it. I took it to my mechanic because of the rust underneath basically my frame and the mechanic looked at it and said it was rusting out so bad it was too dangerous to drive, I called Toyota and they said they had a recall on it and sprayed it that was back in 2014 here it is 2023 and I am afraid to drive it because it could cause a terrible accident for me or somebody else again my mechanic said it’s too dangerous to drive Since Toyota will not do anything I am turning to you. Hopefully you can help me. Thank you very much [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2006 Toyota Tundra. The contact stated that the passenger’s side front door frame was rusted. The vehicle had not been diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that a recall repair had been previously performed on the vehicle. The failure mileage was unknown.

The contact owns a 2006 Toyota Tundra. The contact stated that upon visually inspecting the vehicle, he became aware of corrosion along the frame rails underneath the vehicle. The vehicle was taken to the dealer, who confirmed the frame corrosion. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure but was unable to assist. The failure mileage was 116,000.

Truck won’t pass inspection frame is rusted out like so many other 2006 Tundras. Some web searches showed this year was covered on recalls. In 2015 had a recall for corrosion on frame .. you mean RUST! However those don’t show up as recalls.. WHY? How do all of us affected do another class action law suit? Truck has 147,239 miles way too young to be no good! Can’t afford another car! Hey TOYOTA GIVE US KELLY BLUE BOOK AROUND 7000 or fix the frame! Any lawyers or news contact me! This family is screwed thanks to Toyota passing the buck

Good afternoon, my name is Anthony Eakins, and I live in south west Florida. I have a 2006 Toyota tundra and I absolutely love my truck I believe this is one of the best trucks on the road even though it was built in 2006 (275,000 miles) The issue I'm having is my frame is to the point where I will have to get rid of my truck. The other issue is the frame is so bad I can't even sell my truck. I know there was a recall several years back and I'm curious why my truck is not part of this recall. My truck is rusting right above the rear leaf spring shackles and right at the bend by the motor. I have taken extremely good care of this truck it stays in my garage and the frame has been sprayed with under coating professionally every two years. I even have a detailed list of everything that's been done with this truck since 40,000 miles. Since my truck has been taken care of very well, I have not had any issues until now. I know Toyota is a very reliable vehicle and was curious if there's anything you can do to help me with the situation. Please respond to this email, confirming or denying assistance on my frame repair. Thank you.

My Toyota Tundra has extensive rust damage due to rust and it’s sway at has come completely disconnected from frame. Also there are at least other significant rust issues with the frame that make this truck unsafe.

Nothing

My ruck was recalledseveral years agofor the frame. To correct this issuea toyota dealer spray the frame.this did not stop the frame from rusting.a lot of other people I talked to said their frames replaced with no questions asked. But not mine.when I talked toyota for the new england territory, I was just given a run around. And nothing was done. There have been other recalls such as the air bag recall Iam not sure that was done correctly. Recently I took my toyota to toyota of Keene NH. I was told that they found other issues like the yransfer case was cracked in half. And there was a priblem with the head lights. Yes I can see there was a problem with the lights, someone at toyota service did not plug them backin after they checked them. I had to move the battery to get at the head light think it was a bad bulb, not. And I lost the screw to the battery compartment some where intheengine area. I take great steps to keep my truck safe to drive and clean to look at.

My 2006 Toyota has holes rusted through the frame in more than one location

I have been trying to get my airbag changed from recall. Toyota will not do the repair. They refuse to pick up my truck. My Reference number at Toyota is 220901001583. This is the number Toyota corp. gave to me. Twice corp. set up the repair both times dealers refused to come get it. Now corp. says I have to bring it in to get the repair. For two years they have been sending me recall notices saying they will come and get the vehicle. now they refuse to do that. I will not take it to Toyota. they have wasted enough of my time already. Thanks Russ

The contact owns a 2006 Toyota Tundra. The contact stated while doing a routine tire check underneath the vehicle, the contact noticed that there was corrosion under the rear driver’s side of the subframe. The vehicle was taken to the dealer and the dealer stated there was a hole in the rear driver’s side mount. The contact was informed that the fuel strap mount on the front driver’s side and rear fuel tank was corroded, and that the truck bed was also rusted. The manufacturer was contacted but provided no assistance. The manufacturer filed a case. The failure mileage was 199,884.

Failure of truck frame even though frame protection was applied by dealer.

The contact owns a 2006 Toyota Tundra. The contact stated while driving approximately 5 MPH and making a left turn, there was an abnormal banging sound coming from the vehicle. The contact stated that the front driver’s side of the vehicle lowered unintendedly. Upon inspection, it was discovered that the front driver’s side lower ball joint had separated from the knuckle. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The contact was informed that the vehicle was previously serviced under the NHTSA Campaign Number: 07V013000 (Suspension). The contact stated that the vehicle had experienced the failure listed in the recall. The local dealer was not yet notified of the failure. The failure mileage was 170,000.

Toyota has been aware of rust problems on the first generation Tundra frames, but only put out a recall for the 2000-2003 model years. My 2006 has had some weak spots patched, however the frame broke in one spot due to the rusting out issue that Toyota should be aware of.

The bed of the truck rots out around where it is bolted to the frame. It is a common problem with Toyotas. The bed could collapse down and possibly come off. If this happens on the road it could cause a sever accident. Also the frame on Toyotas rot . If it rots by spring hangers this can be carastrofic.toyota has issued a frame recall on this. I had mine undercoated in 2015 from an authorized Toyota dealer. I was told I had a life time warranty if done by Toyota . The frame is not rotting as well as the bed. I was told it isn't going to be warrantied. Toyota should stand behind they're products.

I Was not notified That there was a recall for the frame rusting. My frame is rusted out and now I’m told that the recall has expired. This is unacceptable and poses a threat to the lives of Me, my family and all Toyota drivers everywhere.

NOT LONG AFTER THE LAST TAKATA RECALL,NHTSA CAMPAIGN ID: 15V286000, THE PASSENGER SIDE AIRBAG COVER BECAME STICKY AND DISCOLORED - MY LOCAL TOYOTA DEALER WHO PERFORMED THE RECALL AND THE TOYOTA CORPORATION SAID IT IS NOT A TOYOTA ISSUE. AN INTERNET SEARCH REVEALS OWNERS OF A VARIETY OF AUTO MANUFACTURERS HAVE THE SAME COMPLAINT. IT IS MY UNDERSTANDING THAT ANY DEFECTS RELATED TO AIRBAG COMPONENTS COULD POSE A POTENTIAL SAFETY HAZARD. PLEASE ADVISE IF THIS CONSTITUTES A " SAFETY PROBLEM " AND ANY KNOWN REMEDY. THANK YOU [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2006 Toyota Tundra. The contact stated that back in 2014 he received a recall notification regarding corrosion on the subframe. The vehicle was taken to the dealer and the contact was informed that a black sealant would be sprayed on the subframe to prevent corrosion. Over time, the sealant began to peel, and corrosion started to form on the subframe. The contact called the manufacturer and dealer about the failure but was offered no assistance. The vehicle was not repaired. The failure mileage was approximately 50,000.

My vehicle was subject to a frame corrosion Limited Service Campaign. I brought the vehicle in for inspection and was advised there we 2 options: Frame replacement or Corrosion-Resistant Compound treatment. The dealership advised the vehicle did not qualify for frame replacement, and opted to apply CRC. The CRC application was performed June 11, 2014. I have documentation. I was recently advised by my mechanic that the gas tank straps are failing, and they cannot replace them due to corroded frame. The cross member requires total replacement due to extensive frame rotting. I believe that if Toyota had done the responsible thing as part of the recall, and replaced the frame instead of applying CRC, this issue would not occur today. I would respectfully like to request the NHTSA look into this matter.

The contact owns a 2006 Toyota Tundra. The contact stated that upon servicing the vehicle at the independent mechanic, she was informed that the entire subframe was severely corroded. The vehicle was taken to the dealer where it was diagnosed that the subframe was severely corroded and had significant holes. The contact was able to drive the vehicle to her brother's residence at a slower speed. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not assist as the vehicle was out warranty. The failure mileage was approximately 136,000. UPDATE 06/07/2023- Consumer mailed letter stated the vehicle was in Ohio with Noxudol 300- 3 liters and 1 liter of another rust prevention product. Consumer had frame inspected. Invoice estimate is attached with letter.

WE bought this truck in 2016. From Mitchell Selig Ford in Windsor CT. Apparently their was a rust recall in 2015. The dealer did not get this fixed and as a result our truck is completely rusted and unrepairable. We were not aware at all this was a recall as it happened prior to us buying the truck. What can I do about this ? Their is really "no incident" to report. I need to know what Toyota will do about this issue.

There is a bracket under the drivers seat, left side of seat, that is cracked all the way through just above the weld where it attachs to the horizontal tube that rotates when the power lever is pushed forward or backward. This bracket is associated with the "seat back" tilting forward or backward. This bracket being broken, allows the drivers seatback to be unstable and can be tilted forward in the event of an accident.