2019 Toyota Tundra

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain JTEKT power steering gear assembly service parts for 2007-2021 Tundra and 2008-2022 Sequoia, part numbers 44250-0C160, 44250-0C131, 44250-0C170, and 11250-0C121. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.

Risk. An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.

Remedy. Dealers will inspect and replace the power steering gear assembly, free of charge. Owner notification letters were mailed on February 17, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 21TH01.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.

Risk. An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.

Remedy. Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2021 Tundra vehicles. The headlight electrical circuits may power the high and low beams simultaneously, which could overheat the electrical connector.

Risk. An overheated electrical connector can increase the risk of a fire.

Remedy. Dealers will modify the engine wire harness assembly and replace any damaged bulb, bulb connector, and/or headlight assembly as necessary, free of charge. Owner notification letters were mailed April 25, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB06 and 21TA06.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.

Risk. If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.

Remedy. Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2020 Toyota Tundra vehicles equipped with LED headlight assemblies. Due to a wiring error, the front turn signals may not flash brightly enough. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk. If the turn signals or hazard lamps do not flash brightly enough, other drivers may fail to see that the turn signal or hazard lamp functions have been activated, increasing the risk of a crash.

Remedy. Toyota will notify owners, and dealers will modify the wire harness connected to the front turn signal bulbs free of charge. The recall began August 17, 2020. Owners may contact Toyota customer service at 1-800-270-9371. Toyota's number for this recall is 20TB12/20TA12.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) recalled certain 2018-2019 4Runner, Highlander, Camry, Land Cruiser, Sequoia, Sienna, Tacoma and Tundra, and Lexus RC 300, RC 350, GS 350, GX 460, IS 300, LC 500, LS 500, LX 570, RX 350L, and 2019 Toyota Avalon and Corolla, and certain Lexus NX 300, and ES 350 vehicles on January 13, 2020. On March 4, 2020, Toyota expanded the recall to include certain 2014-2015 Toyota 4Runner and Land Cruiser, 2018 Avalon, Corolla, 2014 FJ Cruiser, 2017 Sienna and Lexus 2018 ES 350, 2018-2019 GS 300, 2013-2014 GS350, 2014-2015 GX 460, IS 350 and LX 570, 2014 IS F, 2018-2019 IS 350, LC 500H and LS 500H, 2013-2015 LS 460, 2015 NX 200T and RC350, 2017 RC 200T and RX 350. Toyota also removed the 2018-2019 Toyota 4Runner and Land Cruiser and 2018-2019 Lexus GX 460 and LX 570 and 2019 NX300 from inclusion in this recall. On March 19, 2020, Toyota expanded the recall to include 2015 Lexus GS350 vehicles. The low-pressure fuel pump inside the fuel tank may fail.

Risk. If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.

Remedy. Toyota will notify owners, and dealers will replace the fuel pump, free of charge. The recall began May 4, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are 20TB02 and 20TA02 for Toyota vehicles and 20LB01 and 20LA01 for Lexus vehicles.

Defect. Gulf States Toyota (GST) is recalling certain 2019 C-HR, 4Runner, Avalon, Avalon Hybrid, Camry, Camry Hybrid, Highlander, Land Cruiser, Prius, RAV4, Sequoia, Tacoma, Sienna, Tundra and Yaris vehicles. The text on the load capacity label may become illegible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

Risk. If the driver cannot read the label, they may unknowingly overload the vehicle, increasing the risk of a crash.

Remedy. GST will notify owners, and dealers will provide corrected load carrying capacity modification labels, free of charge. The recall began May 24, 2019. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 19R1.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 Toyota Tundra standard and long bed trucks equipped with a spray-in bed liner. The load carrying capacity modification label may have been incorrectly calculated. If the label is followed, the vehicle may be overloaded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

Risk. An overloaded vehicle can increase the risk of a crash.

Remedy. Toyota has notified owners, and provided corrected load carrying capacity labels, free of charge. The recall began on January 24, 2019. The recall number is J08. Owners may contact Toyota customer service at 1-888-270-9371.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 Toyota Tundra vehicles. The accessory all-weather floormats may have been counted twice when creating the load carrying capacity modification label, resulting in the capacity modification label incorrectly overstating the additional weight by 10 pounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

Risk. Since the incorrect label is not within 1% of the additional weight, the vehicles are not compliant with the FMVSS.

Remedy. All vehicle owners will be sent a corrected label. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0Z.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 Toyota Tundra and Sequoia vehicles and 2019 Toyota Avalon and Avalon Hybrid vehicles. The air bag electronic control unit (ECU) may erroneously detect a fault during the vehicle start-up self check. If this occurs, the ECU may not deploy the airbags as intended, in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection," and 214, "Side Impact Protection."

Risk. If the air bags do not deploy as intended, it can increase the risk of injury in a crash.

Remedy. Toyota will notify owners, and dealers will update the software for the air bag ECU, free of charge. The recall began October 26, 2018. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0X. Note: 18V-122 was superseded by this recall. The software remedy also includes the updates to the software for 18V-122.

The Forward Recognition Camera on my 2019 Toyota Tundra has suffered an internal failure. The vehicle was inspected by an authorized Toyota dealership, which diagnosed and documented:"FOUND INTERNAL FAULT IN FORWARD RECOGNITION CAMERA." The failed component is available for inspection. This camera is a critical safety component that supports forward collision warning, automatic emergency braking, and other driver-assistance systems. Because of this internal failure, the vehicle's ability to detect potential hazards may be reduced or disabled, leaving the driver without safety features that were designed to help prevent or mitigate crashes. This failure places not only the occupants of my vehicle at risk but also other motorists, pedestrians, and cyclists sharing the roadway. The condition was reproduced and confirmed by an authorized Toyota dealer. The dealer determined that the camera itself had internally failed and requires replacement. The failure was not attributed to an accident, impact, misuse, modification, or outside damage. It was diagnosed as an internal fault of the camera assembly. Prior to diagnosis, warning messages and safety-system malfunction alerts appeared on the vehicle, indicating that the driver-assistance systems were not functioning properly. These warnings prompted me to seek service. The dealership subsequently confirmed the internal camera failure. I am concerned that this component failed under normal operating conditions in a relatively modern ve

The fuel pump and the fuel pump control module system failed. Before the failure, I drove my 2019 Toyota Tundra on XXX from [XXX] to [XXX] with no prior check engine light warning. It was parked for all 3 days at a campground in [XXX]. However, on XXX the vehicle would not start. The truck ignition was moved to the RUN position and then the check engine light came on, which was the first notification of a potential problem. So, I attempted to start the vehicle, there was a crank but not a start incident. The ignition was moved back to the OFF position. I'm also an experienced mechanic, so I lifted the hood to diagnose the issue and search where the malfunction was occurring. I inspected the battery, all the fuses, the relays controlling the fuel pump, and the fuel pump control module. Using a Voltmeter Tester, the battery had a full charge. The relays and the fuses were also replaced with no success in starting the vehicle. The fuel line was disconnected from the fuel rail so I could verify if fuel was getting to the engine. The truck ignition was again moved to the RUN position and then the Start Position with NO success of fuel getting to the fuel rail. The vehicle was then towed to a local auto shop and the problem has been reproduced only by Crawford Auto Repair shop in [XXX]. The auto mechanic mentioned two error codes were presented: 1. The fuel pump 2. The fuel pump control module. Thankfully, there was no immediate risk to my family's safety but it could have occurred

We had just exited the interstate when my Toyota Tundra stopped. We had it towed to the closest Toyota dealer. We had to have fuel pump replaced. They said the previous year Tundra was recalled for this issue, but ours was not. I just found out that some of the 2019 models had been recalled for this issue. They said my VIN was not recalled. That does not make sense. It was the same problem, same year, just at a different plant. Now we are having other fuel issues and the dealer says it all stems from the replacement of the pump, which we had to pay out of pocket. If we had not just exited the interstate it could have caused a major accident.

The contact owns a 2019 Toyota Tundra. The contact stated that while parked for 5-10 minutes, the contact noticed a burning plastic odor, and upon looking up moments later, the contact noticed flames coming from the driver's side headlight, and the flames were 6 inches above the headlight. The contact started extinguishing the fire with water bottles. The contact drove to a water hose, which the contact also used to extinguish the fire. The contact sustained minor smoke inhalation. No police report was filed. The contact was able to drive to the nearby residence. The contact related the failure to NHTSA Campaign Number: 21V688000(Exterior Lighting, Electrical System), which included the VIN. The manufacturer was notified of the failure and sent a field inspector, who inspected the vehicle and informed the contact that the inspection report would be completed on the same day; however, the manufacturer would follow up with the contact within 45-60 days. The contact followed up with the manufacturer three days later and was provided with the same information. The dealer was not contacted. The vehicle was not diagnosed or repaired. The failure mileage was approximately 100,500.

The contact owns a 2019 Toyota Tundra. The contact stated that while starting the vehicle, the engine sounded rough. The check engine warning light was illuminated. The vehicle was turned off and failed to restart. The vehicle was towed to an independent mechanic, where the ECU was reset; however, the failure reoccurred. The mechanic referenced NHTSA ID Number: 20V682000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 104,000.

My toyota tundra is having issues with the fuel pump. It is saying I am using e85 fuel when that is not the case. As a result I am having issues with cold start. There are recalls however I am being told that my truck is listed among them despite having the same issue.

The contact owns 2019 Toyota Tundra. The contact stated that while attempting to start the vehicle, the vehicle failed to respond immediately. The contact stated that while driving 40 MPH and depressing the accelerator pedal, the vehicle stalled, and approximately thirty seconds later the vehicle worked as intended. A dealer was contacted. The vehicle was taken to a dealer and was diagnosed and determined that the fuel pump needed to be replaced, and codes were in the recall. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 20V682000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the recall. The failure mileage was 80,000.

I bought this car in January 2019, and even though it had 210 miles, they sold it to me as new. I think they did something illegal because I have the purchase contract and they didn't put that information there. They put 10 miles and I didn't notice at the time. Also, I have the window sticker and it says the car comes standard with a remote key for entry, and the dealer removed it to make it without one. I'm ashamed I didn't report this sooner. It must be a form of consumer theft, something they only do to protect themselves.

Intermittent message displaying "Trailer Brakes Disconnected" while towing. Trailer lights continued to operate even while message was displayed. On average trailer connected and disconnected every 2-3 minutes

Keep getting the messages "Trailer brake error, if towing come to a stop with manual controls" And "Pre-collision system malfunction" The messages go away usually after restarting the vehicle but eventually comes back on

I had to have the steering rack assembly replaced in my vehicle due to a leak. This is one of the complaints and a recall but I never got a notification.

The built-in navigation system in my 2019 Toyota Tundra is dangerously outdated and cannot be updated over-the-air (OTA). Recently, it misrouted me into a remote, unfamiliar area with no cell service and incorrect road data. If I hadn’t had enough fuel, I could have been stranded in potentially life-threatening conditions. Toyota continues to install these systems with outdated maps and no OTA functionality, while presenting them as part of a reliable, intelligent driving experience. This is not a minor tech issue—it is a safety failure. Drivers are led to trust a system that cannot be trusted. I want to be clear: this experience has completely changed how I view Toyota as a brand. What seemed like a small, fixable flaw turned into a moment of genuine danger. That moment told me everything I needed to know about Toyota’s priorities—and Toyota is no longer in my future because of it. I urge NHTSA to investigate this as a potential recall-level issue. A navigation system that actively misleads the driver and offers no timely updates is not just broken—it’s hazardous.

The contact owns a 2019 Toyota Tundra. The contact stated that while replacing the shocks, the contact noticed that the shocks were oily. The vehicle was taken to the local dealer for warranty repair, and the contact was informed that the brake pads on the rear axle were soaked with oil. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 30,000.

The contact owns a 2019 Toyota Tundra. The contact stated while driving at an undisclosed speed on several occasions, the vehicle stalled. There was no warning light illuminated. The vehicle failed to restart and was towed to the dealer on two occasions. The dealer diagnosed that the fuel pump had failed and needed to be replaced; however, the fuel pump part #770200C170 was on backorder. The dealer reprogrammed the fuel pump system twice as temporary repairs; however, the failure persisted. The contact stated while driving 35 MPH, the vehicle stalled. There was no warning light illuminated. The contact was unable to pull over to the side of the road. The vehicle failed to restart and was towed to the residence, where it was diagnosed by a mobile mechanic. The mechanic diagnosed that that the fuel pump was burned, causing the electrical connector part #9098010844 to burn and melt. The dealer was contacted and informed the contact that the electrical connector part had been discontinued. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under the factory warranty. The failure mileage was approximately 102,000.

Truck shut off while driving fuel pump connector in the tank was melted and could have started a fire. Was told my tundra doesn’t fall under the recall but is having the same problem

The contact owns a 2019 Toyota Tundra. The contact stated while attempting to start the vehicle at the residence, the contact stated that the engine was shaking abnormally. No warning lights were illuminated. The contact stated that a dealer was contacted. The vehicle was taken to a dealer where it was diagnosed and determined that the fuel pump needed to be replaced, and that the electrical fuel module needed to be reset. The vehicle was not repaired. The VIN was not included in NHTSA Campaign Number: 20V682000 (FUEL SYSTEM, GASOLINE). The manufacturer was notified of the failure and opened a case. The failure mileage was 117,000.

Having fuel pump issue. Car stalls very badly and pre collision light and engine lights start flashing. Severe jumping by car driving down the road. When accelerating the car has no acceleration and hesitates very badly.

When refueling this vehicle, gasoline will flow out of the filler tank onto the ground and will shoot out onto the person filling the truck up. Have had the charcoal canister replaced twice and this has not fixed the problem for any length of time. Dealer claims that vent tubes are getting clogged up but cannot explain how or why they are plugged up. Last repair lasted one week before fueling issues showed up again. The gas shooting out of the filler hose onto people standing nearby and onto the ground is an extreme fire and explosion issue and is an environmental issue. This problem seems to be a common issue based on internet search for Toyota Tundra refueling issues. There has been a service bulletin published by Toyota on this issue. I have been having this problem for over 2 years.

Factory installed OEM LED HEADLIGHTS: While driving in WET SNOW and SNOW conditions, headlights get covered in snow and visibility is greatly reduced to almost zero.

The contact owned a 2019 Toyota Tundra. The contact stated that while driving at approximately 45 MPH, an oncoming vehicle did not obey a stop sign and proceeded to crash into the rear driver's side of the contact's vehicle. As a result, the contact lost control of the vehicle and crashed into the platform of an 18-wheeler. No air bags deployed. No warning lights were illuminated. The vehicle was towed to his residence. A police report was filed. The vehicle was deemed destroyed by the insurance company. The contact who was the driver sustained severe back pain and an injured left knee pending further treatment at a clinic. The front passenger sustained bruising to the left arm and back pain but did not seek medical attention. The rear passenger sustained bruising to the right arm and back pain but did not seek medical attention. The other vehicle occupants did not sustain injuries. A dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 75,000.

275/55r20. only have around 10,000 miles. just rotate the tire at Walmart in Texas . on my way to Georgia my rear tire exploded without any warning at 75 mph . I almost lost control over the vechle .

There was three warning light showing malfunction collision warning and i tried to to dealership and they said nothing is wrong

Fuel pump is losing prime and difficult to start when cold. Various websites indicate Toyota issued a recall for 2018 and 2019 Tundra fuel pumps in 2020, but no recall appeared on our recent search when we began having issues. Did Toyota end the recall?

This is the second chrome hood bulge that I've put on it and it keep breaking with the wind and just flys off. Also the collision light will come on by itself.

One morning, I tried to start my truck, and it would not start. After taking it to Lipton Toyota in Fort Lauderdale, they determined the fuel pump was faulty. Unfortunately, they’ve had my truck for over two weeks and have informed me of a national shortage for Toyota fuel pumps. I have spoken to other dealerships in the area, including those in Kentucky, they are also on back order for these fuel pumps.

The vehicle is vibrating while accelerating and bogging down when the accelerator is depress, causing the car to slow down drastically. Doing research it similar to the issues that the fuel pump were having in the 2019 Toyota tundra recalls. Also at the start of the engine it seems that is bogging and causing the rpm to fluctuate, in some cases car will crank and will not start. I have vídeo prove of this issue and audio when the car is starting

I was on a camping trip in Wyoming, and I started my Tundra up on a chilly morning. It was running for about 5 minutes before I came back to it and entered the cab. Immediately upon entering I noticed a strange smell. I also noticed at that time that the driver’s seat was extremely warm. I quickly shut off the heat warmer (original equipment on the truck). Inspecting the seat, I could see where the leather was just starting to melt. Luckily, I caught this in time, for if I would have left it longer, the vehicle could have caught fire. An online search discovered previous problems with Toyota seat warmers. My contact with Toyota was not helpful, for they simply told me that it was out of warranty, despite being a safety issue.

I took my vehicle in for scheduled maintenance. During the safety inspection the Toyota authorized tech advised me about a serious safety issue with rust on the undercarriage of my vehicle. He advised that the control arms as well as sway bars and suspension , shocks, struts had heavy rust on them. He advised that this is a safety issue as if something breaks I could lose control. I have enclosed the video. I then contacted First Team Toyota and they initially wanted me to bring the truck in for inspection. The next day they called and told me that since I was no longer under warranty , That they could not help me. I was also told that the undercoating I paid extra for does not cover the parts that are rusted. I contacted Toyota corporate and they opened a case #[XXX]. After several days they decided that there was nothing they could do for me. I have my vehicle serviced routinely and have never been advised of any rust problems on my truck. Then after the warranty runs out, I’m advised of this problem. I take extreme care of my truck and spray the under carriage with fresh water whenever I drive thru rain or puddles. I am extremely concerned regarding the safety of this vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle died while driving, found that fuel pump quit working. towed to a shop, they informed me that Toyota has a recall on the fuel pumps and was instructed to tow the vehicle to Central Toyota in Jonesboro AR. Was told that my vehicle didn't fall into the recall for fuel pump failing while driving. was forced to purchase a new fuel pump and have it installed after towing back to a repair shop.

IBC errors while towing. Serious safety issue.

The contact owns a 2019 Toyota Tundra. The contact stated that while driving approximately 75 mph, a 2008 Lincoln struck the rear passenger side of her vehicle which caused her vehicle to tail spin and crash into the guardrail. The vehicle continued to tailspin. The air bags did not deploy. All the warning indicator lights were flashing after the crash. The contact sustained a laceration on the neck, a bruised hip, and leg pain and was provided medical attention at the hospital. A police report was filed. There were no reported fires. The vehicle was towed to a towing lot. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was approximately 80,000.

The electrical system malfunctioned, causing all warning lamps on the dashboard to light up. Because this happened while I was driving, I do believe that this electrical issue caused safety concerns for others on the road. The taillights went out first, seconds later, all remaining electrical failed at once, including airbags, windows, headlights at one point, pre collision warning lights, lane departure, and the breaking system failed as well. This caused safety concerns for myself, my passenger, as well as the public because all safety warning sensors failed at once while on the road. The problem has been confirmed by Roseville Toyota, who is a manufacturer, and who currently has the vehicle now, they said that there is definitely an electrical issue and most likely a short of some sort. The warning lamps and messages on the dash lit up one at a time, seconds apart from each other, until the entire dash was lit up completely while I was driving on March 24, 2023.

The seat heater control module has failed causing the plastic to burn and melt, nearly starting a fire. Toyota knows about this but refuses to issue a safety recall.

2019 Tundra: for no reason or indication the vehicle displayed a “Trailer Break Error” and “Pre-collision System malfunction” warning asking me to pull over if towing anything (nothing was being towed) and to contact the dealership. Vehicle still operational however the menus can’t be seen as the warning is consistent.

The contact's husband owns a 2019 Toyota Tundra. The contact stated that on various occasions while starting the vehicle, the vehicle stalled. No warning lights were illuminated. The vehicle was taken to an independent mechanic; however, the failure could not be duplicated. The vehicle was then taken to a local dealer and was diagnosed, and it was determined that the fuel pump needed to be replaced. The contact referenced the failure to NHTSA Campaign Number: 20V682000 (Fuel System, Gasoline); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 100,000.

We were driving down an unpaved road at 8 mph in 4WDh in our 2019 Toyota Tundra when I heard a couple popping sounds from inside the car. Then it stopped. I opened the passenger side door to get out and check on the truck, and flames were pouring out under the engine. There were 3 of us in the car. We immediately got out and tried to pour water and throw sand on the fire. It grew very quickly, so we ran away. The car was immediately engulfed in flames like something out of a movie with black smoke going high into the air. Within 5-10 minutes, the truck was totally gone. There were no warning signs/lights other than the 2 pops and then fire/explosion. We are very lucky we did not die. We bought it brand new. It was the first new car we’ve ever owned. It was impeccably cared for. We always brought it to the Toyota dealership in Eugene, OR for service. It was there about a month prior to the explosion. During that visit, they replaced the battery as well as dealt with the halogen light recall. Other things were more routine maintenance. We are in shock and do not want this to happen to others. We also do not know what our next steps are, but we wanted your agency to be aware of this issue. The local dealership said it must have been a car defect or bad workmanship at our last service. Either way, it was terrifying.

Sunroof shattered while driving on highway. Noise similar to a gun being fired, caused momentary disorientation; however, was able to keep vehicle on the road. No warning, no other vehicles around that could have kicked up a rock, debris, etc. Smooth conditions on the road (no potholes, bumps, etc.). Sunroof was in the tilt up position, side windows down, and rear window down - even temperature outside and inside (74 degrees F). Small glass "shards" in eyes and hair; however, most of it went up/out. Vehicle gets inspected tomorrow (09-21) for insurance purposes.

PCS ABS 4LO 4HI Brake ABS BSM Traction Control RCTA Warning Triangle christmas tree started. Along with the Precollision System Malfunction, Drive Start Control Malfunction, Blind Spot Monitor Malfuntion, Rear Cross Traffic Alert, and Trailer Brake Error massages

A technical safety bulletin was issue for this issue (T-SB-0036-19). On a recent trip in the Great Smokey Mountains National Park, my wife and I were pulling a travel trailer with LED lights and noticed that the trailer disconnected warning come on. We thought it was a loose cable and pulled over to check the plug. We started home after our trip and had this occur several times on step grades. The scary issue is the lights continue to work indicating that it’s still connected, however when I checked the manual brake controller there were no brakes! There were no areas to pull over. Once we were able to pullover safely, we checked the connection again and it was still secure. This occurred again on I-40 as we approached and accident scene with sudden braking. Then it disappeared again. We made it safely home and I started researching the issue and found the bulletin. I took it to Toyota to complete but it’s still an optional bulletin. This is an enormous safety issue considering a 5400 pound truck capable of towing a 9200 pound trailer at highway speeds with no braking or access to the first step to stop trailer sway.

Intermit message "Trailer disconnect " message causing the trailer braking system to fail when attached to truck. Truck brakes are used to stop trailer at unsafe distances. Several trailers were used to verify. I have attached the fix but Toyota says its warranty issue. This is a "safety" issue. I had my 3 year old son in the truck when i had to apply the brakes and couldn't stop in enough time. The truck brakes could not handle the weight of the trailer hence why the trailer brakes were needed. Please prevent a death.

The contact's husband owns a 2019 Toyota Tundra. The contact stated that after her husband had refueled the vehicle, the vehicle failed to start as needed without warning. The contact pushed the vehicle into the gas station's repair garage where the mechanic informed him that the fuel pump was defective. The contact's husband then called the dealer where they informed him of NHTSA Campaign Number: 20V682000 (Fuel System, Gasoline) which the dealer related to the failure; however, the VIN was not included in the recall. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was approximately 36,348.

Integrated break controller won’t detect the trailer and it won’t engage the breaks on the trailer.

2019 TOYOTA TUNDRA. CONSUMER WRITES IN REGARDS TO MISSISING BRAKE SENSOR.

Pre collison warning system has turned itself off in the rain and states visit dealer for service. Never logs data and on when you get to dealer. Same system has also flash "Brake" on the highway at 65 mph when a dry sunny day and no cars around. I am worried it may actually brake by accident causing loss of control. Went to dealer on both occasions and because it doesn't log the data there was nothing they could do. Did my own research and there was a technical service bulletin for certain VINS (not mine) to "repair" this module behind the grill. It was done to my truck but not by my dealership before I took ownership. It should not have been done and Route 44 toyota just did nothing. I asked for a replacement and they wouldn't because there wasn't any codes listed to warrant it because the TSB wasn't for my truck even though someone did it. On their TSB it recommends replacement for my current issues but they wouldn't do it.

My son was driving to Mineral Wells to get something to eat on Wednesday 11/17/21 at 8:00 at night on FM 52 South. All of a sudden the steering wheel falls in his lap. He picked it up and shoved it onto the column and was able to steer the truck onto the side of the road without hitting anything. He looked underneath the steering wheel assembly and 2 of the 4 ubolts where missing. Where did they go - if they were ever there in the first place. The steering wheel has had some vibration and we have had the truck front end aligned and the wheels balanced. I had it in not long ago for an inspection/oil change/tire rotation. After I left the dealership the wheel felt a little loose and there was some vibration but I thought it was the road and it did stop vibrating. I also drive a Prius and I thought maybe I'm just not used to the way the truck feels. I told my son when I got home that it felt loose and he said he would keep an eye on it. Then Wednesday night the steering wheel falls off and the whole column falls out. What is this? I also drive the truck and I do not think I would have had #1 - the strength to pick the wheel up and force it back onto the column or #2 - the sense to even do that. I would have had an accident. The Shottenkirk dealership does not want to deal with the problem even though I have an extended warranty so today Freeman Toyota calls me and they are picking up the truck and will be doing the repair work. Bottom line - my son could have been killed or inju

3 times in the last few mos the BRAKE! warning came on. Nothing was causing this warning to engage. This happened again today. Another issue is when the Valdosta Toyota (GA) dealer attempted to fix the fuel pump recall on 22 JUL 2020 it was assembled incorrectly. I called the dealership and told them to come and get my Tundra because gas was dripping onto my driveway. They sent a tow truck and it was supposedly fixed and they brought it back to me in about 2 hrs. It really does run the way it did before they “re-fixed” it. Very often now when it is driving I feel something like a failing fuel pump. It fades away but it is not comfortable taking it long distances. It feels like there is a clog in the fuel system or something, although there is not. I have 33,400 miles on it today and I can’t help but wonder if Valdosta Toyota didn’t just exchange the original fuel pump with a different used one?

Toyota Safety Sense (TSS) malfunctions sporadically while driving. Warning lights illuminate and Dynamic Radar Cruise Control (DRCC) disengages when activated while driving. The Pre-Collision System (PCS) is turned off and flashes with the following error messages. - Pre-Collision System Malfunction - Visit Your Dealer - Auto Headlight System Malfunction - Visit Your Dealer - LDA Malfunction - Visit Your Dealer This has happened twice, first right after purchasing the vehicle brand new in 2019 and most recently last week on 5/22/2021. I took the vehicle into the dealer on 5/25/2021 and they seemed aware of this issue, but stated they could not reproduce it and there were no error codes logged. I showed them the video of this happening (link below) while driving through Nevada. I was told the errors will not disable the vehicle or put it into limp mode, but my concern is when this happens while using DRCC, which almost made me drive into the back of a tractor trailer on Interstate 80. The speed limit on I-80 in Nevada is 80 MPH. https://drive.google.com/file/d/1WrxgM8SJeB02eO4a6E9tbyCeAr6gRRHs/view?usp=sharing

TRUCK STALLING WHILE DRIVING ON HIGHWAY. THIS IS THE 3RD TIME THIS HAPPENED BUT WHAT SCARED ME THIS TIME IT SHUT OFF WHILE DRIVING. VERY HAZARDOUS AND ALMOST CAUSED A BAD ACCIDENT.

TL* THE CONTACT OWNS A 2019 TOYOTA TUNDRA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V012000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE FAILURE STATED IN THE RECALL SUMMARY WITH SEVERAL UNKNOWN WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO QUALITY TOYOTA LOCATED AT 1125 W. LINCOLN AVE, FERGUS FALLS, MN 56537, (218)998-1900 WHERE THE DEALER CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 8,500. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

VEHICLE REQUIRES MULTIPLE RESTART ATTEMPTS AND THE ENGINE RUNS ROUGH. WARNING LIGHTS AND CHECK ENGINE LIGHT ILLUMINATED ON INSTRUMENT PANEL. LOSS OF POWER AND STALLING HAS OCCURRED WHILE DRIVING. SYMPTOMS OCCURRED MULTIPLE TIMES SINCE VEHICLE PURCHASE.