1997 Ford Ranger

Defect. FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Risk. A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Remedy. FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Defect. DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Defect. SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Defect. K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Risk. WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy. K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.

Defect. CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy. PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Defect. THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.

Risk. SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.

Remedy. THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.

Defect. TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.

Risk. IF THE TREAD SEPARATES FROM THE TIRE, THE DRIVER CAN LOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH CAUSING INJURY OR DEATH.

Remedy. THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON AUGUST 29, 2001. HOWEVER, CUSTOMERS SHOULD CONTACT FIRESTONE CUSTOMER SERVICE AT 1-800-465-1904 FOR POSSIBLE ASSISTANCE.

There is no summary currently available

There is no summary currently available

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT

SUBJECT REGARDING FUEL SYSTEM DIAGNOSTIC. *TT

MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW

TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT WHILE HAVING A ROUTINE INSPECTION AT HALDEMAN FORD OF KUTZTOWN, INC. (15465 KUTZTOWN RD, KUTZTOWN, PA 19530, (610) 683-3553) THE MECHANIC DETERMINED THAT THE FRONT AND REAR SUBFRAME WAS SEVERELY CORRODED. AFTER HAVING AN EMISSIONS INSPECTION, THE VEHICLE WAS DEEMED UNSAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 154,000.

FORD RANGER 4X4 XLT 4.0L HAS HAD PROBLEMS FROM THE BEGINNING FRONT TIRES TWO OUT , FOG LIGHTS, AIR CONDITIONING, TRANSMISSION SHIFT POINTS , CHECK ENGINE LIGHT WHEN NEW AND TO THIS DAY GAS MILEAGE NOT AS STATED ON WINDOW STICKER ,ALSO WINDOWS MOTOR AND CONTROLS

BELT SEPARATION ON 2 TIRES IN ONE MONTH TIME SPAN. FUSION TOURING 195 70R14 91T. THESE TIRES HAVE 8/32 TREAD REMAINING. FAILURES WERE FRONT RIGHT, THEN LEFT READ ONE MONTH LATER. CAUSED DIFFICULTY STEERING AS THE CAR WAS ALL OVER THE ROAD PLUS BUMPY RIDE. THE TIRES ARE VISIBLY BULGING BALOON. I FELT TIRE TEMP WITH MY HAND. UNIFORMLY WARM EXCEPT AT THE BULGE WHERE IT WAS SO HOT AS TO BURN MY HAND. WOULD NTSB LIKE ME TO SAVE A TIRE FOR EVALUATION? THIS SECOND TIRE FAILURE OCCURRED AT 70 MPH ON I-94 IN MICHIGAN WHEN A SUDDEN VIBRATION OCCURRED AND I OBSERVED THE LEFT REAR FENDER BOUNCING UP AND DOWN. I STOPPED TO INVESTIGATE AND FOUND THE BULGE AND HOT SPOT.

TL* THE CONTACT OWNS A 1997 FORD RANGER. UPON INSPECTION, IT WAS DISCOVERED THAT THE FUEL TANK WAS NOT SECURED AND WAS HANGING FROM THE SUBFRAME OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FAILURE WAS CAUSED BY SEVERE RUSTING AND CORROSION OF THE SUBFRAME. THE FAILURE WAS NOT REPAIRED. THE LOCAL DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 233,479. *TT

EXCESSIVE RUST NOT CAUSED BY NORMAL WEAR AND TEAR, HAD SPARE TIRE CARRIER RUST OFF WHILE ON THE ROAD

TAKATA RECALL -- I BELIEVE ALL AIRBAGS ARE DEFECTIVE AND MORE DANGEROUS THAN RIDING WITH SEAT BELTS ALONE. I RECOMMEND 100% DISABLING OF AIRBAGS AND THE REMOVAL OF ALL AIRBAGS AND ASSOCIATED HARDWARE FROM FUTURE VEHICLES.

I HAD FIVE (5) BF GOODRICH RADIAL ALL TERRAIN TA TIRES FAIL WHILE DRIVING THE SAME VEHICLE OVER ABOUT A TEN YEAR PERIOD. EACH FAILURE IS THE SAME. THE STEEL BELT OF THE TIRE PARTIALLY SEPARATES WHILE ROLLING. THE FIRST OCCURRED ABOUT TEN YEARS AGO ON THE INTERSTATE WHILE PULLING A SMALL FLATBED TRAILER. STEEL BELT THEN WHIPS AROUND INSIDE WHEEL WELL DAMAGING WHATEVER IT COMES IN CONTACT WITH. BF GOODRICH RADIAL ALL TERRAIN TA TIRES WERE ON THIS TRUCK WHEN PURCHASED USED. SECOND TIRE FAILED APPROXIMATELY THREE YEARS AGO THE SAME WAY AT LESS THAN 30 MPH. REPLACED ALL WITH USED SET OF FOUR TIRES WITH 50 % TREAD LEFT. LESS THAN A MONTH AFTER, THIRD TIRE FAILED ON INTERSTATE ONCE AGAIN IN THE SAME WAY. STEEL BELT CUT THE FIBERGLASS REAR OUTER FENDER IN HALF, RIPPED OUT THE REAR WIRING HARNESS, DESTROYED THE LEFT TAIL LIGHT, AND EVEN DAMAGED THE GASOLINE FILL TUBE AND DESTROYED ITS LOCKING GAS CAP FROM THE FORCE OF THE BELT WHIPPING ROUND AND ROUND THE WHEEL, PARTIALLY ATTACHED AND PARTIALLY OFF. NEARLY LOST CONTROL OF VEHICLE, BUT WAS NOT INVOLVED IN ACCIDENT. ALL TIRES FAILED WHILE IN DRIVER'S REAR WHEEL POSITION. THEN LAST MONTH AGAIN, THE LEFT REAR BF GOODRICH RADIAL ALL TERRAIN TA TIRE STEEL BELT CAME PARTIALLY OFF AT ABOUT 30 MPH. EACH TIME A USED TIRE REPLACED THE FAILED TIRE. THEN TWO DAYS LATER, A FIFTH BF GOODRICH RADIAL ALL TERRAIN TA BEGAN TO FAIL WITH STEEL BELT COMING APART. THIS TIME RIGHT REAR WHEEL LOCATION. NOTICED THE FAILURE BEFORE STEEL BELT CAME COMPLETELY OFF

THE DOME LIGHT STARTED TURNING ITSELF ON WHILE PARKED IN FRONT OF MY HOUSE. SOMETIMES IT WOULD TURN ITSELF BACK OFF. IT WOULD ALSO TURN ON WHILE I WAS DRIVING AT NIGHT. I COULDN'T GET THE LIGHT COVER OFF SO I PULLED THE FUSE WHICH LEAVES ME WITH NO WINDSHIELD WASHER SQUIRTER. THE CHECK ENGINE LIGHT IS ALWAYS ON. NO MATER WHAT IS DONE OR FIXED, THE LIGHT STAYS ON WHICH IS A PROBLEM BECAUSE CARS WILL USUALLY AUTOMATICALLY FAIL INSPECTION WHEN THE CHECK ENGINE LIGHT IS ON. HOW AM I SUPPOSED TO GET IT TO PASS INSPECTION IF ITS ON 90% OF THE TIME? I NEVER HAD A PROBLEM WITH MY 93 RANGER BUT OTHER PEOPLE WITH RANGERS HAVE HAD THE SAME ISSUES & THIS SITE SHOWS OTHERS WITH THE SAME ISSUES. WHY WON'T FORD RECALL & FIX IT WHEN ITS A KNOWN PROBLEM? THESE THINGS ARE SAFETY ISSUES!! I CAN'T ADD WHEN THESE THINGS HAPPEN BECAUSE THEY ARE ONGOING ISSUES FOR THE LAST TENISH YEARS!

FARMR RUSTED THROUGH TRUCK WAS SITTING AT HOME PARKED WHEN IT BROKE THROUGH

IDLE SPEED RISES TO 3,000 RPM IN BETWEEN SHIFTS AND WHILE COASTING WITH CLUTCH PEDAL DEPRESSED. DOES NOT DROP TO NORMAL IDLE SPEED UNTIL VEHICLE COMES TO A COMPLETE STOP. THIS CAUSES BRAKING TO BE LESS EFFECTIVE.

TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT THE SPEED CONTROL SWITCH MELTED. THE CONTACT STATED THAT HE HAD NOT EXPERIENCED A FAILURE PRIOR TO THE VEHICLE BEING REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 09V399000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.

REAR LEAF SPRING HANGERS/SHACKLES RUSTED OFF AS WELL AS THE FRONT ONES ON THE REAR LEAF SPRINGS. SPARE TIRE CARRIER FELL DOWN DRAGGING THE SPARE TIRE ACROSS THE ROAD. ONE CROSSMEMBER HOLDING UP THE FRONT OF THE GAS TANK IS READY TO GO. BOTH GAS TANK STRAPS ROTTED OFF. TOYOTA WAS MADE TO FIX THESE ISSUES. WHY NOT FORD? I WORK AT A TOYOTA DEALERSHIP REPLACING ROTTEN FRAMES ON TUNDRAS, SEQUOIAS, AND TACOMA VEHICLES. THERE IS NO DIFFERENCE AS BOTH THE FRAMES FOR TOYOTA AND FORD ARE BUILT AT THE SAME FACTORY IF I AM CORRECT? THE VEHICLE WAS BEING DRIVEN DOWN THE ROAD ALL TIMES THE ABOVE LISTED FAILED. SOME TIMES ON THE HIGHWAY, OTHERS IN TOWN. I DO NOT FEEL SAFE SELLING THIS VEHICLE TO ANOTHER INDIVIDUAL WHEN IT'S READY TO GO.

GUY NEXT DOOR KNOCKED ON MY DOOR LATE ONE NIGHT TO TELL ME THAT MY DOME LIGHT WAS ON. I LOOKED & IT WASN'T. HE SAID THAT WAS ODD BECAUSE HE EVEN WALKED BY IT & COULD SEE INSIDE. A FEW DAYS LATER IT HAPPENED AGAIN. THEN WHILE DRIVING AT NIGHT THE LIGHT CAME ON BY ITSELF. FROM THAT POINT ON IT WOULD RANDOMLY TURN ITSELF ON. NATURALLY FORD TOLD ME THAT WAS IMPOSSIBLE. THE ONLY WAY I COULD STOP IT WITHOUT PAYING A TON OF MONEY TO A GARAGE WAS TO PULL THE FUSE & I'VE HAD TO USE A FLASHLIGHT IF I NEED A LIGHT AT NIGHT EVER SINCE. MY TRUCK ALSO HAS A THEFT LIGHT BECAUSE A FACTORY ALARM WAS AN OPTION FOR MY TRUCK. I DO NOT HAVE AN ALARM BUT THE WORD ALARM IS STILL ON THE PANEL. THAT LIGHT WILL RANDOMLY TURN ON & SAY THEFT. I DO NOT HAVE AN ALARM! I TOLD FORD & THAT TOLD ME THAT WAS IMPOSSIBLE SINCE I DON'T HAVE AN ALARM. I SAID THAT MAYBE A WIRE WAS CROSSED SOMEWHERE BUT FORD TOLD ME," NO! ". TALKING TO OTHER RANGER OWNERS HERE & THERE I'VE FOUND OUT THAT NOT ONLY ARE THERE OTHERS DOING THE EXACT SAME THINGS BUT IT IS ALSO OTHER YEARS BESIDES 1997. I LIKE THE TRUCK JUST TIRED OF FORD & TIRED OF THE BS!!

AIR BAGS.. DEFLATING, UNSERVICEABLE, DEMAND USELESS, ONLY ON PASSENGER SIDE, DRIVERS SIDE DISLODGED HORN FUEL/PROPULSION.. WITH FUEL TANK FILLED, FIRST HALF(1/2) TANK HAVING EXCESSIVE FUEL CONSUMED. SECOND (1/2) OF FUEL CONSUMED AT OWNERS MANUAL SPECIFICATIONS OF CITY AND HIGHWAY MILES PER GALLON. THROTTLE PEDAL STIFF, STICKS, AFTER NORMAL DAILY WARM UP, EXTRA FOOT PRESSURE NEEDED TO DISLODGE PEDAL AND CABLE, REAL SLUGGISH AS IF NOT RECEIVING ENOUGH FUEL TO INJECTORS, EVEN AFTER REGULAR MAINTENANCE COMPLETED.. SEAT BELTS.. DRIVERS SIDE HOOKUP RETAINING LATCH MALFUNCTIONS AND " WILL NOT REMAIN LATCHED", SEVERAL ATTEMPTS NEED TO BE MADE BEFORE GETTING A STRONG SEATBELT CLIP TO LATCH LOCKED ON

LOOKED UNDER MY FORD RANGER AND SAW THAT BOTH OF THE METAL STRAPS THAT HOLD THE FUEL TANK TO THE VEHICLE HAD RUSTED THROUGH AND BROKEN IN HALF. I SAW THAT THERE WAS A RECALL FOR THE SAME ISSUES ON MY YEAR, BUT ONLY FOR THE FORD F150, NOT THE FORD RANGER, EVEN THOUGH THE ISSUE IS THE SAME.

WHEEL BEARINGS KEEP GOING OUT ON FRONT TIRES BECOMING A REAL ISSUE AND HAZARD AND SAFETY THEY LOCK UP ON ROAD AND HAVE GOTTEN SLIDES OFF ROAD. AFRAID IT WILL BE WORSE NEXT TIME. THEY HAVE GONE OUT THREE TIMES AND BEEN REPLACED. THEY ARE GOING OUT AGAIN AND FEAR FOR OUR SAFETY BUT THIS IS OUR ONLY VEHICLE FOR WORK AN APPOINTMENT NEED THIS TRUCK. PLEASE HELP. I DON'T HAVE THE MONEY TO KEEP REPLACING BUT LOVE THIS TRUCK. *TR

I WALKED OUT OF MY HOUSE ONE MORNING AND MY REAR BUMPER WAS LAYING ON THE GROUND BEHIND MY TRUCK. *TR

I BOUGHT THIS TRUCK IN OHIO IN OCTOBER 2014, AFTER PURCHASING I NOTICED QUITE A BIT OF RUST ERODING THE FRAME BEHIND 20" LOW PROFILE TIRES, I PUT FACTORY SUGGESTED TIRES ON IT THE LEAF SPRING HANGERS BROKE IN EARLY DEC. 2014 AFTER THAT WAS FIXED, THE EROSION WAS NOTICEABLE. NOW THE SHOCK HAS FALLEN OFF AND THE FRAME HAS A CRACK THROUGH IT AT THE LEAF SPRING HANGER. THE TRUCK IS NOT DRIVABLE AT THIS POINT. I NEED ANOTHER FRAME OR WILL HAVE TO JUNK THE TRUCK. *TR

TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH, THE ENGINE STALLED. THE VEHICLE RESTARTED AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING THE MECHANIC WAS UNABLE TO LOCATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

REPORTING NUMEROUS SERIOUS SAFETY PROBLEMS WITH VEHICLE SINCE PURCHASED USED ---ORIGINAL OCCURRENCE DATE NOT CERTAIN BUT OVER A NUMBER OF YEARS MECHANICAL FAILURES OCCURRED THAT COULD HAVE RESULTED IN SERIOUS INJURY OR FATALITIES. THE FAILURES INCLUDE BUT NOT EXCLUSIVE TO ENTIRE BRAKE SYSTEM FAILURE DUE TO BRAKE LINES CORRODED AND LEAKED ALL HYDRAULIC FLUID --REAR BODY SUPPORT SYSTEM GAVE OUT DURING DRIVING AND REAR WHEELS AND AXLES NOT ATTACHED TO BODY ---VEHICLE LOST CONTROL AND WENT OFF INTO SHOULDER--RADIAL AXIAL ARM RUSTED AWAY AND STEERING SYSTEM FAILED WHILE DRIVING. GAS LEAKS FROM TOP OF TANK IF FILLED TO FULL --LEAKS ON TO GROUND AND COULD RESULT IN GAS FIRE AND EXPLOSION --DO NOT FILL TANK MORE THAN 3/4 ! ALL BRAKE LINES SHOULD BE REPLACED AND FREQUENT CHECKS OF STEERING AND SUSPENSION. I AM REPORTING THIS TO MAKE OWNERS AWARE AND TAKE PRECAUTION TO PREVENT INJURY OR DEATH.. *TR

I PURCHASED USED FORD RANGER 1997...TURNS OUT CHASSIS HAS A SAFETY DEFECT....IT IS RUSTED AND NEEDS TO BE WELDED.....MEINEKE SAID SAFETY IS A BIG ISSUE...AND WE SHOULD TALK TO FORD... RUST SHOULD NEVER HAVE HAPPENED.....WHAT SHOULD I DO? THE PART IN QUESTION IS FRAME CHASSY! DROP DOWN WOULD NOT ALLOW ME TO LIST CHASSY. *TR

WE WERE DOING 30MPH AND WE HIT A SHEET OF BLACK ICE. THEN WE HIT THE GUARDRAIL. WHEN WE HIT THE DRIVER SIDE AIR BAG DID NOT GO OFF UNTIL THE VEHICLE STOPPED AND THE PASSENGER SIDE AIR BAG DID NOT GO OFF. *TR

I HAVE SEVERE RUSTING OF THE FRAME AND PARTS CONNECTED TO FRAME OF MY 1997 FORD RANGER, AND I AM WORRIED ABOUT ITS SAFETY ON THE ROAD/HIGHWAY. AND I ONLY HAVE 64,000 MILES ON IT! I HAVE HEARD OF SPARE TIRES COMING LOOSE AND FALLING OFF, REAR BUMPERS FALLING OFF, GAS TANKS FALLING OFF, REAR SHACKLES COMING LOOSE ETC...ON THE FORD RANGER BECAUSE OF THE SEVERE RUST. IF I WAS TOWING A TRAILER AND THE REAR BUMPER FELL OFF THERE GOES THE TRAILER TOO, A TRAILER AND/OR BUMPER THAT COULD CAUSE AN ACCIDENT AND KILL SOMEBODY! SAME WITH THE OTHER PARTS COMING LOOSE. AND IF THE REAR AXLE BROKE LOOSE FROM THE FRAME IT WOULD CAUSE A LOSS OF CONTROL AND AN ACCIDENT AND FATALITY. AND IF I WAS CARRYING A HEAVY LOAD THE FRAME COULD BUCKLE OR BREAK IN HALF AND CAUSE AN ACCIDENT AND FATALITY, BECAUSE THE FRAME IS HALF GONE BECAUSE OF THE RUST. ITS JUST LIKE THE FRAME RUST PROBLEMS ON THE TOYOTA TACOMA AND TUNDRA TRUCKS. I ALSO HEARD THAT THE SUPPLIER OF THE FRAMES FOR THE TOYOTA TACOMA AND TUNDRA, WAS ALSO THE SUPPLIER FOR THE FORD RANGER FRAMES. I THINK THIS IS A MANUFACTURING DEFECT BY FORD, AND THAT THE GOVERNMENT SHOULD FORCE FORD TO RECALL MY 97 FORD RANGER, AND ALL OTHER FORD RANGERS AFFECTED BY THE RUSTY FRAMES ASAP. FORCE FORD TO BUYBACK THE TRUCKS AT KBB VALUE, OR REPLACE THE RUSTY FRAMES WITH NEW ONES FREE OF CHARGE. THE FRAME IS THE BACKBONE OF A TRUCK, ITS A CRITICAL PART AND IF IT FAILS BECAUSE OF SEVERE RUSTING, YOU HAVE A SERIOUS SAFETY PROBLEM HERE. ITS A DISASTER JUST WAITING TO

PLASTIC FUEL LINE SPLIT AT THE INPUT OF THE FUEL FILTER THAT IS LOCATED BEHIND THE ENGINE ATTACHED TO THE VEHICLE FRAME. WHEN THE IGNITION IS TURNED ON GASOLINE SPRAYS FROM THIS CRACK PIECE OF PLASTIC LINE. THIS IS DUE TO THE FACT THAT THE FUEL PUMP IS ELECTRIC AND ENERGIZES ANYTIME THE IGNITION IS ON THE PUMP IS LOCATED IN THE GAS TANK AT THE REAR OF THE TRUCK . THIS IS POTENTIALLY VERY DANGEROUS AS THE SPRAYING GASOLINE COULD EASILY HIT THE CATALYTIC CONVERTER OR EXHAUST SYSTEM WHEN THE VEHICLE IS IN MOTION. FORTUNATELY I NOTICED THE LEAK UNDER THE VEHICLE WHEN I WAS WARMING UP THE CAR ON AS COOL MORNING. AS A RESULT NO REAL DAMAGE WAS DONE. WILL COST ABOUT $350 TO REPAIR. *TR

UNDER HARD BRAKING TO AVOID AN ACCIDENT THE SEAT BELT DISENGAGED FROM THE BUCKLE. I HAVE BEEN DEALING WITH THE SEAT BELT BUCKLE NOT "BUCKLING" WITH THE SEAT BELT FOR YEARS. LOOKING ONLINE I SEE NUMEROUS PEOPLE COMPLAINING OF THE SAME PROBLEM. COMPLAINTS OF A SPRING IS MISSING OR BROKEN, COINS ARE STUCK DOWN INSIDE THE MECHANISM, ETC. THIS IS A DEFECTIVE DESIGN! I CAN ONLY WONDER HOW MANY INJURIES OR DEATHS HAVE OCCURRED FROM SEAT BELT BUCKLE FAILURE. EVERY DAY I GET IN MY TRUCK I HAVE TO WIGGLE THE BELT BACK AND FORTH TO GET IT TO ENGAGE. SOMETIMES I JUST CHECK AFTER IT HAS ALREADY ENGAGED AND IT COMES LOOSE. THE DEALER SOLUTION IS TO PAY THEM FOR A "REPLACEMENT" ITEM, THE COST OF WHICH IS AROUND $250-300... I'LL BE PURCHASING A REPLACEMENT. THE ONLY PROBLEM IS THAT THE REPLACEMENT IS OF THE SAME DESIGN. I'M ASKING FOR HELP TO REMEDY A LIFE THREATENING SITUATION. *TR

TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT FUEL SPILLED FROM THE VEHICLE AND ONTO THE GROUND AS THE CONTACT ATTEMPTED TO REFUEL THE VEHICLE. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHOM LOCATED THE FAILURE AT THE FUEL FILTER NECK HOSE, WHICH WAS CRACKED DUE TO CORROSION. THE VEHICLE WAS REPAIRED AND THE FUEL FILTER NECK HOSE WAS REPLACED. THE MANUFACTURER DENIED ANY ASSISTANCE WITH THE REPAIR DUE TO THE VEHICLE'S AGE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000 AND THE APPROXIMATE CURRENT MILEAGE WAS 210,000.

NO INCIDENT OCCURRED BECAUSE I FOUND IT IN TIME (THANK GOD)! I CAME OUT MY FRONT DOOR AND NOTICED SOMETHING HANGING UNDER MY TRUCK. I TOOK IT TO CAR-X AND THEY TOLD ME IT WAS ONE OF MY SUPPORTS HOLDING UP MY GAS TANK. RIGHT THERE I ALMOST HAD A HEART ATTACK! I ASKED THEM TO CHECK IT OUT. THE NEXT DAY THEY CALLED ME AND TOLD ME THEY COULDN'T FIX IT BECAUSE IT WAS TOO RUSTY UNDERNEATH. THEY EVEN CALLED THE DEALER, I GOT IT FROM, AND THEY TOLD THEM THEY DIDN'T WANT ANYTHING TO DO WITH IT. RIGHT NOW I HAVE A RATCHET BELT HOLDING IT UP BUT I'M AFRAID IT WON'T LAST THROUGH A LOT OF RAIN AND SNOW. *TR

EACH TIME I FILL UP, THE GAS TANK OVERFLOWS, CREATING A HUGE SAFETY RISK OF EITHER A FIRE OR EXPLOSION. *TR

LAST YEAR I STARTED NOTICING A GAS SMELL WHEN FILLING. BEGINNING OF THIS YEAR I NOTICED GAS LEAK ON GROUND WHEN FILLING. I AM NOW IN THE PROCESS OF REPLACING THE GAS FILL PIPE, IT HAS DETERIORATED TO AN UNUSABLE CONDITION. WHETHER THIS IS BECAUSE OF THE GASOHAUL USED IN MN. OR POOR QUALITY IN THE MANUFACTURING I COULDN'T TELL YOU,BUT WHEN I ORDERED THE PART THEY TOLD ME THE SAME THING HAPPENED TO THEIR DELIVERY TRUCK. I BELIEVE THIS IS AN UNSAFE CONDITION AND SHOULD BE LOOKED INTO BEFORE THERE IS AN EXPLOSION OR FIRE IN A GAS STATION WHILE SOMEONE IS FILLING THEIR TRUCK. PLEASE CONTACT ME IF MORE INFORMATION IS NEEDED OR WHAT IS BEING DONE WITH THIS MATTER. *TR

FRAME IS NEARLY GONE / RUSTED , REAREND / AXLE FELL OUT IN MIDDLE OF ROAD. *TR

TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT THE REAR FUEL STRAP WAS COMPLETELY RUSTED AND DETACHED FROM THE VEHICLE. THE FRONT FUEL STRAP WAS ALSO RUSTED. THE CONTACT SPOKE WITH THE DEALER AND WAS TOLD THERE WERE NO RECALLS FOR THE FUEL STRAPS ON THE VEHICLE AND PROVIDED NO FURTHER ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE AND THE CURRENT MILEAGE WAS 225,000.

TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT THE VEHICLE WOULD LOSE POWER SPORADICALLY BEFORE ABNORMALLY ACCELERATING. THE CONTACT STATED THAT WHEN THE FAILURE OCCURRED, THE FAILURE COULD NOT BE STOPPED BY APPLYING THE BRAKES. IN ADDITION, THERE WAS AN ABNORMAL SPIKE IN ENGINE RPMS WHEN THE FAILURE OCCURRED. THE VEHICLE WOULD CORRECT ITSELF SHORTLY THEREAFTER. THE FAILURE MILEAGE WAS 126,000 AND THE CURRENT MILEAGE WAS 136,252.

TODAY MY ACCELERATOR FAILED. I WAS SITTING AT A RED LIGHT. I WENT TO ACCELERATE BY PUSHING ON THE ACCELERATOR PEDAL WITH MY RIGHT FOOT. THERE WAS NO ACCELERATION. THE ACCELERATOR PEDAL HAD FAILED. FURTHER INVESTIGATION REVEALED THREE SPOT WELDS THAT HELD A PLATE TO THE FIREWALL HAD FAILED. THE ACCELERATOR PEDAL PIVOTS ON THIS PLATE AND ATTACHED BOLT. I WAS ABLE TO DO A TEMPORARY REPAIR TODAY. BUT, THE FAILURE IN TRAFFIC WAS VERY DANGEROUS. *TR

DRIVING DOWN ROAD REAR SPRING BROKE ANOTHER TIME SPAR TIRE CAME OF ALMOST CAUSING CRASH ,HAVE REPAIRED BOTH REAR SPRING BRACKETS ,TWO FRONT SUSPENSION , LOST SPARE AND FRAME ABOUT TO BRAKE AWAY . WHAT SHOULD I DO . HAVE LOT OF MONEY INVESTED . *TR

MY 1997 4X4 RANGER, 61500 MILES, HAS MAJOR FRAME RUST AND HAS IN FACT RUSTED THROUGH IN ONE AREA. THE FRAME RAILS ALSO AT THE REAR LEAF SPRING SHACKLES HEAVILY RUSTED. I HAVE OWNED THIS SINCE OCT.OF 2000. THE BODY IS CLEAN AND STRAIGHT OF ANY DAMAGE OR RUST. I EXPECT A FORD FRAME TO LAST AND NOT BE THE REASON OF THE VEHICLES TOTAL FAILURE IN BOTH SAFTEY AND OF THE VEHICLE LIFE AFTER 12-13 YEARS WITH ONLY 61,500 MILES. THE CAR IN MY OPINION IS UNSAFE TO DRIVE. FORD SHOULD STAND BEHIND THEIR PRODUCT AND DO WHAT TOYOTA HAS DONE WITH SIMILAR FRAME ISSUES. I LOOK FOWARD TO YOUR REPLY. *TR

WHILE WORKING ON AND DOING AN UNDERBODY INSPECTION I NOTICED THAT THE DRIVERS SIDE REAR SPRING HANGER IS ALMOST ROTTED COMPLETELY THROUGH. IT IS A CAUSE FOR ALARM FOR ME AND ANYBODY DRIVING NEAR ME ON THE HIGHWAY. IF NOT FIXED IT COULD POSSIBLY CAUSE A DEADLY ACCIDENT. THE PASSENGER SIDE IS ROTTED AS WELL. FRONT SUSPENSION IS ROTTING AS AT A FAST RATE. THE TRUCK SEEMS TO JUMP INTO OTHER LANES AFTER HITTING POT HOLES OR OTHER ROAD HAZARDS. *TR

WHILE GOING DOWN HILL AND AROUND A CURVE HEARD A LOUD NOISE FROM REAR AND FELT BACK OF TRUCK MOVE SIDE WAYS. A SHORT TIME AFTER, ANOTHER LOUD NOISE FROM REAR AND REAR OF TRUCK DROPPED LOW . I LOST CONTROL AND WENT ONTO SHOULDER AND SLOWED DOWN WAS ABLE TO RECOVER AND AT SLOW SPEED WENT HOME. ON INSPECTION FOUND BOTH REAR LEAF SPRING FORWARD SHACKLE SUPPORTS FAILED DUE TO CORROSION. WAS LUCKY NOT GOING FASTER AS COULD HAVE RESULTED IN VERY SERIOUS CRASH. PLEASE INVESTIGATE AND WARN OWNERS OF POSSIBLE FAILURE OF LEAF SPRING. AND LOSS OF CONTROL TRUCK IS PARKED AND NOT ABLE TO BE DRIVEN. *TR

TL* THE CONTACT OWNS A 1997 FORD RANGER EQUIPPED WITH BRIDGESTONE DUELER AT TIRES, LINE SIZE 225/70/R14 . THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, HE BEGAN TO HEAR A THUMPING NOISE. THE VEHICLE WAS DRIVEN HOME WHERE THE CONTACT NOTICED THAT THE TREAD ON THE REAR DRIVER SIDE TIRE WAS PEELING. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 131,000.

TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT ONE MINUTE AFTER STARTING, THE VEHICLE FAILED TO SHIFT INTO GEAR AND THE VEHICLE STALLED. THE VEHICLE WAS NOT TAKEN TO THE DEALER, HOWEVER THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 181,000 AND THE CURRENT MILEAGE WAS 181,760.

1997 FORD RANGER DRIVER SIDE REAR SPRING HANGER RUSTED AWAY & BROKE CAUSING WEIGHT OF VEHICLE TO BE CARRIED BY TRUCK BED FLOOR. *TR

UNDERSIDE OF 1997 FORD RANGER IS COMPLETELY RUSTED OUT. BUMPER WON'T STAY IN PLACE AND THE SPARE TIRE BOLT WOULD NOT ALLOW SPARE TIRE TO COME OFF. WE HAVE JUST PARKED VEHICLE AFTER WERE WARNED ABOUT IT. WE JUST USE IT FOR SHORT TRIPS. *KB

THE GAS TANK STRAPS ON MY 1997 RANGER HAVE RUSTED THROUGH DROPPING THE FUEL TANK WHILE I WAS PULLING INTO MY DRIVEWAY. BOTH THE FRONT AND REAR STRAP HAVE RUSTED THROUGH. THE TANK IS BEING HELD UP WITH COMMERCIAL GRADES STRAPS. IS THIS MODEL BEING INCLUDED IN THE RECENT FORD RECALL ANNOUNCEMENT? I DID NOT SEE THE EXTENDED CAB RANGER MODEL MENTIONED.

FUEL TANK STRAPS FAILED DUE TO CORROSION/RUST CAUSING FUEL TANK TO PARTIALLY FALL. DEFECTIVE STRAPS WERE REPLACED WITH NEW ONES. *KB

FORD RANGER 1997 REAR LEAF SPRING MOUNTS COMPLETELY RUSTED AWAY. HEARD LOUD BANGING NOISE WHEN DRIVING. INSPECTED TRUCK AND FOUND BOTH DRIVER AND PASSENGER REAR SPRING MOUNTS COMPLETELY RUSTED AWAY. FRONT SPRING MOUNTS ALMOST RUSTED AWAY -NEAR LOSS OF REAR AXEL AND SUSPENSION !!! VERY DANGEROUS FAILURE WITHOUT ANY WARNING. IF HAD OCCURRED AT HIGHWAY SPEED COULD HAVE BEEN TOTAL LOSS OF REAR SUSPENSION. ALSO DROPPING AXEL WITH LEAF SPRINGS NOT GOOD FOR ANY TRAFFIC FOLLOWING VEHICLE. MAJOR SAFETY PROBLEM AS NO OTHER RUST APPARENT ON TRUCK OUTSIDE OR ELSEWHERE UNDER TRUCK. INFERIOR METAL USED FOR SPRING MOUNTS WHICH IS APPARENTLY VERY PRONE TO RUST COMPARED TO REST OF TRUCK. HIGHLY RECOMMEND ALL FORD RANGER OWNERS BE NOTIFIED AND ADVISED TO HAVE SPRING MOUNTS INSPECTED BEFORE FATAL ACCIDENT OCCURS. CAN NOT STRESS ENOUGH THAT THERE WERE NO SYMPTOMS NOTED BEFORE FAILURE, AND NO APPARENT RUST ON TRUCK TO INDICATE ANY PROBLEMS. *TR

WITHIN THE PAST TWO MONTHS I HAD A SPLIT IN THE FLEXIBLE FUEL FILLER PIPE ON MY 1997 FORD RANGER XLT. IN THE COURSE OF HAVING IT REPLACED, THE REPAIR SHOP REMOVED THE GAS TANK AND FOUND THE SAME CONDITION WITH THE METAL STRAPS THAT HOLD THE GAS TANK IN PLACE, EXTENSIVE CORROSION AS REPORTED ON THE FORD F150. IT APPEARS THE POSSIBILITY OF GAS TANKS DROPPING OUT OF THE VEHICLE MAY BE MORE EXTENSIVE THAN THE INITIAL REPORTS AND MAY APPLY TO OTHER FORD PICK-UP TRUCKS. *TR

FUEL LINE CRACKED ABOVE GAS TANK . STRONG GAS ODOR AFTER DRIVING OR DURING REFILL -GAS WILL SPILL OUT WHEN FILLING TANK UP TO FULL AND GAS SMELL CAN ALSO BE SMELLED DURING COMMUTE. WILL BE TAKING IT IN TO GREENWAY FORD DEALERSHIP HERE IN ORLANDO THIS WEEK. *TR

I WAS LEAVING THE PARKING LOT OF THE GROCERY STORE I HAD BEEN SHOPPING AT, AND THE DRIVERS SIDE RECLINING SEAT LATCH ASSEMBLY THAT CONTROLS THE ANGLE OF, AND LOCKS THE BACK OF THE SEAT INTO POSITION, GAVE WAY AND THE BACK OF THE SEAT COLLAPSED BACKWARDS CAUSING ME TO GO BACKWARDS AS WELL. FORTUNATELY I WAS ABLE TO STOP MY VEHICLE WITHOUT CAUSING A COLLISION OR INJURY. THE VEHICLE IS NOW AT HOME, AND WITH INTERNET RESEARCH IT SEEMS THAT THE RECLINING SEAT LATCH ASSEMBLY HAS BEEN A WEAK POINT WITH FORD RANGER TRUCKS AND FORD EXPLORER SUV VEHICLES FOR YEARS. THE FORD DEALER/SERVICE CENTER THAT I DO BUSINESS WITH, NOW TELLS ME THAT THE REPLACEMENT PART IS OBSOLETE AND THEY WILL HAVE TO CONTACT VARIOUS DEALERS STILL LISTING IT IN THEIR INVENTORY TO SEE IF THEY CAN GET THE PART, AS THE PARTS SUPPLIER FOR FORD THAT MADE THE REPLACEMENT LATCHES WENT OUT OF BUSINESS DURING THE BAD ECONOMY. I'M AMAZED THAT A RECALL HAS NOT BEEN ISSUED, GIVEN THE POTENTIAL FOR GREAT HARM AND POSSIBLE INJURY OR DEATH FROM THE FAILURE OF THIS COMPONENT.

TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT WHEN THE VEHICLE IS FILLED WITH GASOLINE, THE GAS WILL SPILL BACK OUT. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE BOTTLE NECK ON THE FILLER CAP IS CORRODED. THIS CAUSES A STRONG SMELL OF GAS WHEN DRIVING THE VEHICLE. THE DEALER WAS VERY FAMILIAR WITH THE FAILURE, BUT THE VEHICLE IS NO LONGER UNDER WARRANTY ALL AND THERE IS NO RECALL. THE FAILURE MILEAGE WAS 72000 AND CURRENT MILEAGE WAS 75000.

REAR LEAF SPRING BRACKETS RUSTING AND BREAKING. *TR

CRACK IN GASOLINE FILLER TOP CAUSING FUMES AND GASOLINE ODOR IN CAR, ESPECIALLY WHEN TURNING RIGHT. * WHEN FILLING TANK WITH GASOLINE, THE FUEL WOULD LEAK OUT OF THE FILLER NECK ONTO THE GROUND WHILE FILLING AT THE GAS STATION, AS IF YOU WERE SLOWLY POURING A GLASS OF WATER, MUCH MORE THAN A DRIP. COULD NOT FILL TANK FULL UNTIL REPAIR WAS DONE. MECHANIC REPLACED FILLER AND FILLER NECK. HAD TO REMOVE GAS TANK AND TRUCK BED TO INVESTIGATE AND REPAIR. BIG JOB, BIG HAZARD!! *TR