1994 Ford Mustang

Defect. DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Defect. SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Defect. K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Risk. WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy. K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.

Defect. CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy. TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.

Defect. CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Risk. LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH

Remedy. AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.

Defect. CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy. CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

Defect. CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy. PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Defect. CERTAIN POLI-AUTO COMBINATION HEADLAMP ASSEMBLIES, P/NOS. 11-728, 11-728D, 11-710, 11-419, 11-713, 11-703, 11-704, 11-708P, 11-735, 11-725, 11-726, 11-716 (P&C), 11-721-1, 11-733, 11-729, 11-730, AND 11-732, SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy. POLI-AUTO WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE HEADLAMPS AT ITS ORIGINAL PURCHASE PRICE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2006. OWNERS MAY CONTACT POLI-AUTO AT 305-477-1356.

Defect. CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy. ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.

Defect. EQUIPMENT DESCRIPTION: PASSENGER VEHICLES THAT HAVE HAD THE DRIVER'S AIR BAG MODULE REPLACED AFTER APRIL 5, 2000. THE REPLACEMENT DRIVER'S AIR BAG MODULE INFLATOR MAY HAVE INSUFFICIENT WELDS THAT COULD PREVENT PROPER INFLATION OF THE AIR BAG.

Risk. IN THE EVENT OF A CRASH, THE DRIVER'S AIR BAG MAY NOT PROPERLY DEPLOY WHICH COULD POTENTIALLY RESULT IN LESS THAN THE INTENDED LEVEL OF OCCUPANT PROTECTION.

Remedy. DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER'S AIR BAG MODULE. OWNER NOTIFICATION BEGAN OCTOBER 5, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

TL* THE CONTACT OWNS A 1994 FORD MUSTANG. THE CONTACT STATED THAT WHILE DRIVING AT NIGHT, THE HEADLAMPS WERE VERY DIM. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE HOOD LATCH FRACTURED CAUSING THE HOOD TO RAISE UP AND CRACK THE WINDSHIELD AND DAMAGE TO THE DASHBOARD. THE CONTACT STATED THAT THE SEAT HEATER OVER HEATED AND THE WIRING HARNESS WAS DISCONNECTED. THE VEHICLE WAS NOT DIAGNOSED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED BY LETTER HOWEVER, THERE WAS NO RESPONSE. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 09E025000 (EXTERIOR LIGHTING), 97V180000 (STRUCTURE), AND 95V062000 (SEATS) AS A POSSIBLE SOLUTION TO THE FAILURES HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 88,000. *CK*BF CONSUMER STATED THERE WAS WATER DAMAGE AND PROBLEMS PERSISTED.*JB

TL* THE CONTACT OWNS A 1994 FORD MUSTANG. WHILE DRIVING AT AN UNKNOWN SPEED, THE REAR DRIVER SIDE TIRE DETACHED FROM THE RIM. AS A RESULT, THE CONTACT LOST CONTROL OF THE VEHICLE AND IT SLID INTO AN EMBANKMENT AND WENT AIRBORNE INTO A TREE. THE AIR BAG FAILED TO DEPLOY. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A TOW LOT. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE CONTACT STATED THAT SHE PURCHASED FOUR TIRES FROM SAM'S CLUB AND THAT THE WRONG TIRE SIZE WAS PLACED ON THE VEHICLE, WHICH CAUSED THE CRASH. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 42,480.

TL* THE CONTACT OWNS A 1994 FORD MUSTANG. WHILE DRIVING 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND IT WAS DIAGNOSED THAT THE CAMSHAFT NEEDED TO BE REPLACED. THE CONTACT STATED THAT THE VEHICLE WOULD BE REPAIRED BY THE INDEPENDENT MECHANIC. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND WAS UNABLE TO ASSIST. THE FAILURE MILEAGE WAS 13,000.

TL* THE CONTACT OWNS A 1994 FORD MUSTANG. THE CONTACT STATED THAT THE FUEL TANK SEPARATED FROM THE STRAP. THE CONTACT INSPECTED THE VEHICLE HIMSELF AND FOUND THAT THE FUEL TANK AND STRAPS FAILED DUE TO CORROSION. THE CONTACT WAS UNABLE TO INSTALL THE NEW FUEL TANK DUE TO SEVERE CORROSION TO THE FUEL TANK MOUNTING AREA. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 124,000.

WHILE TRYING TO BUCKLE UP THE LOWER SEAT BELT RETRACTOR LOCKED AND WILL NOT UNLOCK. I TRIED CONTACTING EVERY THIRD PART, OEM AND DEALER IN THE EASTERN HALF OF THE UNITED STATES FOR A REPLACEMENT SEAT BELT. THIS PART IS NOT AVAILABLE AS NEW OR RECERTIFIED. SINCE THIS IS CRITICAL TO THE SAFETY OF PASSENGERS FORD SHOULD PROVIDE AN ALTERNATIVE SOLUTION OR PART. *TR

STARTED CAR, DROVE LESS THAN A MILE DOWN THE ROAD AND GOT A BIG CLOUD OF SMOKE INSIDE THE CAR. PULLED OVER AND MADE IT TO THE PASSENGER SIDE WHERE THE BACK PANEL WAS ALREADY BUBBLING WITH FIRE. CALLED 911 BUT THE CAR WAS COMPLETELY ENGULFED IN FLAMES WITHIN MINUTES. STILL DON'T KNOW WHAT CAUSED THE FIRE JUST GLAD I GOT OUT ALIVE.

TL* THE CONTACT OWNS A 1994 FORD MUSTANG. THE CONTACT STATED THAT WHILE APPLYING THE BRAKES, THE VEHICLE MADE A STRANGE SOUND THEN ACCELERATED. THE CONTACT STATED THAT THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FUEL PUMP AND HEAD GASKET NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 97,000. UPDATED 6/27/14*CN THE CONSUMER STATED THERE WAS A CONSTANT HUMMING NOISE COMING FROM THE RADIO AND ENGINE AREA WHEN TURNED ON. THERE WAS AN INCREASE SREECHING NOISE FROM THE RADIO BEFORE THE VEHICLE SHUT OFF OR ACCELERATED ON ITS OWN. ALSO, THE WINDSHIELD WIPERS DID NOT WORK

TL* THE CONTACT OWNS A 1994 FORD MUSTANG. THE CONTACT WAS DRIVING 65 MPH WHEN THE AIR BAGS DEPLOYED. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. A DIAGNOSIS FROM THE DEALER WAS FORTHCOMING. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 1994 FORD MUSTANG. THE CONTACT WAS PERFORMING ROUTINE MAINTENANCE ON THE VEHICLE WHEN HE NOTICED THAT THE WELDING ON THE SIDE PANELS UNDER THE HOOD WAS FRACTURING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 200,000. THE VIN WAS UNAVAILABLE.

BLOWN HEAD GASKETS AND CRACKED ALUMINUM HEADS. FOUND THAT REPLACING THERMOSTAT 15 DEGREES COOLER IE(195 FACTORY CHANGE TO 108 DEGREE) WORKS MUCH BETTER. ALSO NEVER USE 50/50 OR WATER WITH ALUMINUM HEADS. *TR

TL*THE CONTACT OWNS A 1994 FORD MUSTANG. WHILE DRIVING 20 MPH, THE CONTACT HEARD POPPING NOISES COMING FROM THE STEERING COLUMN WHEN SHE TURNED THE STEERING WHEEL. THE DEALER STATED THAT THE TIE ROD WAS DEFECTIVE AND THE RACK AND PINION WAS WORN. IN ADDITION, THE BEARINGS WERE SEEPING LIQUID. AS OF DECEMBER 12, 2007, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE CONTACT STATED THAT THE SAME FAILURE OCCURRED IN 2003. THE CURRENT AND FAILURE MILEAGES WERE 232,000.

TL* - THE CONTACT WAS DRIVING A 1994 FORD MUSTANG AT A SPEED OF 30 MPH. WHILE DRIVING THE HOOD SEPARATED FROM THE VEHICLE CRACKING THE WINDSHIELD. *AK

I WAS DRIVING MY 1994 FORD MUSTANG GT, WITH 5.0 V8 ENGINE, ON INTERSTATE 64 IN RICHMOND VA. I WAS IN 5TH GEAR DRIVING AT APPROXIMATELY 65 MPH WHEN THE ENGINE SUDDENLY STOPPED OPERATING. I DOWNSHIFTED THE CAR INTO 4TH GEAR HOPING TO RESTART THE ENGINE. THE ENGINE DID NOT RESTART AFTER I RELEASED THE CLUTCH. I IMMEDIATELY STARTED TO PULL OFF TO THE SIDE OF THE ROAD WHEN I SAW ORANGE FLAMES SHOOTING OUT FROM UNDERNEATH THE HOOD. I STOPPED THE CAR AND RETRIEVED MY FIRE EXTINGUISHER FROM THE TRUNK. I WAS ABLE TO PUT OUT 95% OF THE FLAMES AND THE HENRICO COUNTY FIRE DEPT ARRIVED AND PUT OUT THE REMAINING FIRE. VA STATE POLICE SHOWED UP SHORTLY THEREAFTER. THE RUBBER FUEL LINE THAT CONNECTS FROM THE FIREWALL TO THE INTAKE MANIFOLD SPLIT IN THE MIDDLE CAUSING GASOLINE TO SPILL ONTO THE ENGINE. THE GASOLINE CAUGHT FIRE AND IT CAUSED OVER $7,000 IN DAMAGE TO MY VEHICLE. THE VEHICLE IS CURRENTLY BEING REBUILT AND THE DEFECTIVE FUEL LINES WILL BE REPLACED WITH CUSTOM MADE RUBBER FUEL LINES AS FORD NO LONGER MAKES THESE FUEL LINES. *NM

DT: CONTACT STATED THE DRIVER'S SIDE AND PASSENGER'S SIDE AIR BAG DEPLOYED WHILE DRIVING DOWN THE HIGHWAY. THERE WAS NO PRIOR WARNING. THE VEHICLE HAS BEEN TOWED TO THE DEALER. THE DEALER STATED ALL THE SENSORS WERE IN PLACE. THE DEALER WAS OFFERING NO FREE REMEDY. *AK THE CONSUMER STATED THE ENGINE HAD BEEN REPLACED. UPDATED 12/07/05. *JB

DT: ON FEBURARY 20 2005 THE OWNER WAS MOVING THE SEAT FORWARD AND THERE WAS A SMELL OF SMOKE COMING FROM UNDER THE SEAT. THE OWNER LOOKED UNDER HOOD AND SAW THAT A FUSE BLEW OUT. SINCE THE FIRST TIME THE FUSE BLEW OUT FOUR OR FIVE TIMES. THE CAR WAS TAKEN TO DEALERSHIP, WHO ADVISED THE OWNERTHAT THERE WAS A $90 FEE TO INSPECT THE VEHICLE AND THEN WILL CHARGE FOR REPAIRS. RECALL 95V062000 WAS ISSUED . BUT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. THE OWNER CALLED FORD ,AND THEY ADVISED ONLY THE GT EDITION IWASINCLUDED, THEY WON'T TELL WHY. THE OWNER IS CONCERNED THIS WILL CAUSE A FIRE. *AK

ELECTRICAL WIRING BELOW THE DRIVER'S SEAT HAD A SHORT, CAUSING THE SEAT TO CATCH ON FIRE. DEALER WAS NOTIFIED BY CONSUMER.*AK *BF *NM

SUDDEN FAILURE OF ONE- OF THE TWO MOUNTING STUDS WHICH SECURE THE SERVICE BRAKE MASTER CYLINDER TO THE BRAKE POWER BOOSTER UNIT. LOSS OF STUD ALLOWED MASTER CYLINDER TO MOVE WHEN SERVICE BRAKE PEDAL APPLIED - DIMINISHING BRAKING PERFORMANCE.*AK

THE MOUNT UNDER THE LEFT SIDE OF THE DRIVER'S SEAT HAS BROKEN AND IS UNABLE TO BE FIXED WITH A BOLT. THIS OCCURED WHILE DRIVING DOWN THE ROADWAY. WHEN THE DRIVER OF THE VEHICLE MAKES A LEFT TURN, THE SEAT LEANS TO THE RIGHT. THIS CAUSES A SAFETY HAZARD. THE REAR END OF THE CAR ALSO MAKES A SCRUBBING SOUND WHEN THERE ARE MORE THAN TWO PEOPLE IN THE CAR. THE SOUND IS MADE WHEN GOING OVER BUMPS AND WHEN ACCELERATING SLOWLY FROM A COMPLETE STOP. I ALSO HAD TO PAY FOR A CRACKED HEAD GASKET IN LATE 2001. I WAS NOT AWARE OF THE RECALL ON THE HEAD GASKETS UNTIL THE DAY MY CAR WAS PUT IN THE SHOP. I CONTACTED THE DEALER AND WAS TOLD MY MILEAGE WAS TOO HIGH FOR THE HEAD GASKET TO BE COVERED UNDER THE RECALL.

ENGINE FAILURE.*AK

FUEL-TANK FILLER-PIPE GASKET HAS APPARENTLY FAILED. PROBLEM HAS GRADUALLY WORSENED OVER TIME. CAN NOT PUMP MORE THAN A FEW GALLONS INTO TANK OR FUEL LEAKS OUT RAPIDLY; FUMES EVEN ENTER CAR. INVESTIGATED PROBLEM AND DISCOVERED FAILED GASKET, WHICH SEEMS AN ODD DESIGN CHOICE IN PLACE OF SIMPLE WELDED PIPE STEM, GIVEN INEVITABLE VIBRATION OF COMPONENTS. *JB