1998 Ford F-250

Defect. FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.

Risk. AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.

Remedy. FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21

Defect. CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

Risk. IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.

Remedy. ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.

Defect. CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.

Defect. ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Risk. OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Remedy. DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)

Defect. CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.

Defect. ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

Risk. A FIRE AT THE SWITCH COULD OCCUR.

Remedy. BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)

Defect. VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."

Risk. THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.

Remedy. OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Defect. VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES AND LIGHT DUTY PICKUP TRUCKS. THE LUG NUTS ON THESE VEHICLES MAY NOT CREATE SUFFICIENT CLAMP LOAD ALLOWING WHEEL MOVEMENT IN RELATION TO THE HUB/ROTOR MOUNTING SURFACE.

Risk. THIS CAN RESULT IN THE LOOSENING OF LUG NUTS, STUD FATIGUE FAILURE, AND THE POTENTIAL FOR A WHEEL SEPARATION FROM THE VEHICLE, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy. OWNERS OF THESE VEHICLES WILL BE RECEIVING TWO NOTIFICATIONS. THE FIRST NOTIFICATION, WHICH BEGAN IN MAY 1998, WILL PROVIDE AN INTERIM REPAIR PROCEDURE UNTIL PARTS BECOME AVAILABLE. THIS INTERIM PROCEDURE CAN BE COMPLETED BY OWNERS OR THEIR DEALERS. IT SPECIFIES THAT THE LUG NUT TORQUE MUST BE VERIFIED TO BE 100 LBS. THEN THE LUG NUTS NEED TO BE TIGHTENED AN ADDITIONAL 1/8 TO 1/4 TURN MORE. THERE WILL BE A SECOND OWNER NOTIFICATION, WHICH IS EXPECTED TO BEGIN JULY 20, 1998, UNDER WHICH DEALERS WILL INSPECT THE WHEEL STUDS AND REPLACE THE WHEEL LUG NUTS.

Defect. VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. IF THE AUTOMATIC TRANSMISSION SHIFT CABLE ASSEMBLY WAS NOT FULLY ATTACHED TO THE STEERING COLUMN BRACKET, THE SHIFT CABLE ASSEMBLY CAN COME OUT OF THE BRACKET. THE VEHICLE OPERATOR WOULD THEN NOT BE ABLE TO SHIFT THE TRANSMISSION FROM ONE OF THE DRIVE GEAR POSITIONS INTO THE PARK POSITION EVEN THOUGH THE GEAR SHIFT SELECTOR WOULD INDICATE "PARK."

Risk. THE CONDITION WOULD NOT ALLOW A DISENGAGEMENT OF THE TRANSMISSION FROM THE PARK POSITION OR AFFECT PROPER NEUTRAL START SWITCH OPERATION. UNINTENDED VEHICLE MOVEMENT COULD OCCUR IF THE PARKING BRAKE WAS NOT SET.

Remedy. DEALERS WILL MAKE THE PROPER ATTACHMENT OF THE TRANSMISSION SHIFT CONTROL CABLE TO THE STEERING COLUMN BRACKET AND ADD A TIE STRAP TO THAT CONNECTION.

TL* THE CONTACT OWNS A 1998 FORD F-250. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT TIRE STORE AND THE MECHANIC REFUSED TO MOUNT THE REAR DRIVER SIDE TIRE BECAUSE THE RIM WAS SEVERELY RUSTED. ALL OF THE OTHER RIMS WERE IN THE SAME CONDITION, INCLUDING THE SPARE THAT WAS NOT EVEN MOUNTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 220,000. *TT*JB

SAILUN IS NOT A CURRENTLY A VALID CHOICE AS A TIRE BRAND NAME:, NOR IS TARRAMAX H/T A VALID CHOICE AS A TIRE LINE:, WHY I HAVE SUBMITTED THIS REPORT UNDER THE UNKNOWNCATEGORY FOR BOTH OF THESE CELL INPUTS. PURCHASED (4) NEW SAILUN, TARRAMAX H/T, LT265/75R-16 TIRES (IN JANUARY 2016). AFTER APPROXIMATELY 13,000 MILES OF USE, STARTED EXPERIENCING AN UNUSUAL VIBRATION AT HIGHWAY SPEEDS. AFTER MANY HOURS OF TROUBLESHOOTING THE VIBRATION PROBLEM, IT WAS FINALLY REVEALED AT ANOTHER TIRE CENTER (USING A HUNTER ROAD FORCE TEST/BALANCING MACHINE...AT AN EXTRA COST) THAT 3 OF THE 4 TIRES WERE ACTUALLY DEFECTIVE (RED (75 LBS, 73 LBS AND 43 LBS) CONDITION, REPLACE TIRE) AND THE 4TH TIRE USABLE (YELLOW (15 LBS) CONDITION, SLIGHTLY OUT OF ROUND, BUT ARE STILL USABLE...FOR HOW LONG, IS ANYONE GUESS). ROAD FORCE TESTING REVEALED THAT THE INTERNAL BELTS HAD SEPARATED AND ARE THE CAUSE FOR THE OUT OF ROUND TIRE CONDITION. THIS IS WHY THE VIBRATION HAS GOTTEN SIGNIFICANTLY WORST OVER THE PAST MONTH...MORE BELT SEPARATION WITH EACH USE. ACCORDING TO THE TIRE EXPERT TECHNICIAN AT DISCOUNT TIRES, "THE TIRES ARE EGG SHAPED RATHER THAN ROUND LIKE A DOUGHNUT AND THIS CONDITION IS WHAT IS CAUSING THE VIBRATIONS EVEN THOUGH THE TIRES ARE SHOWING BALANCED ON OTHER BALANCING MACHINES AT OTHER SHOPS. OTHER BUYERS HAVE COMPLAINED ON-LINE ABOUT THIS SAME PROBLEM, BUT I SUSPECT THEY HAVE NOT OFFICIALLY REPORTED THESE PROBLEMS TO THE NHTSA. TBCBRANDS CUSTOMER SERVICE IS CLAIMING THAT THERE HAS NEVER BEEN ANY R

SAILUN IS NOT A CURRENTLY A VALID CHOICE AS A TIRE BRAND NAME:, NOR IS TARRAMAX H/T A VALID CHOICE AS A TIRE LINE:, WHY I HAVE SUBMITTED THIS REPORT UNDER THE UNKNOWNCATEGORY FOR BOTH OF THESE CELL INPUTS. PURCHASED (4) NEW SAILUN, TARRAMAX H/T, LT265/75R-16 TIRES (IN JANUARY 2016). AFTER APPROXIMATELY 13,000 MILES OF USE, STARTED EXPERIENCING AN UNUSUAL VIBRATION AT HIGHWAY SPEEDS. AFTER MANY HOURS OF TROUBLESHOOTING THE VIBRATION PROBLEM, IT WAS FINALLY REVEALED AT ANOTHER TIRE CENTER (USING A HUNTER ROAD FORCE TEST/BALANCING MACHINE...AT AN EXTRA COST) THAT 3 OF THE 4 TIRES WERE ACTUALLY DEFECTIVE (RED (75 LBS, 73 LBS AND 43 LBS) CONDITION, REPLACE TIRE) AND THE 4TH TIRE USABLE (YELLOW (15 LBS) CONDITION, SLIGHTLY OUT OF ROUND, BUT ARE STILL USABLE...FOR HOW LONG, IS ANYONE GUESS). ROAD FORCE TESTING REVEALED THAT THE INTERNAL BELTS HAD SEPARATED AND ARE THE CAUSE FOR THE OUT OF ROUND TIRE CONDITION. THIS IS WHY THE VIBRATION HAS GOTTEN SIGNIFICANTLY WORST OVER THE PAST MONTH...MORE BELT SEPARATION WITH EACH USE. ACCORDING TO THE TIRE EXPERT TECHNICIAN AT DISCOUNT TIRES, "THE TIRES ARE EGG SHAPED RATHER THAN ROUND LIKE A DOUGHNUT AND THIS CONDITION IS WHAT IS CAUSING THE VIBRATIONS EVEN THOUGH THE TIRES ARE SHOWING BALANCED ON OTHER BALANCING MACHINES AT OTHER SHOPS. OTHER BUYERS HAVE COMPLAINED ON-LINE ABOUT THIS SAME PROBLEM, BUT I SUSPECT THEY HAVE NOT OFFICIALLY REPORTED THESE PROBLEMS TO THE NHTSA. TBCBRANDS CUSTOMER SERVICE IS CLAIMING THAT THERE HAS NEVER BEEN ANY R

SAILUN IS NOT A CURRENTLY A VALID CHOICE AS A TIRE BRAND NAME:, NOR IS TARRAMAX H/T A VALID CHOICE AS A TIRE LINE:, WHY I HAVE SUBMITTED THIS REPORT UNDER THE UNKNOWNCATEGORY FOR BOTH OF THESE CELL INPUTS. PURCHASED (4) NEW SAILUN, TARRAMAX H/T, LT265/75R-16 TIRES (IN JANUARY 2016). AFTER APPROXIMATELY 13,000 MILES OF USE, STARTED EXPERIENCING AN UNUSUAL VIBRATION AT HIGHWAY SPEEDS. AFTER MANY HOURS OF TROUBLESHOOTING THE VIBRATION PROBLEM, IT WAS FINALLY REVEALED AT ANOTHER TIRE CENTER (USING A HUNTER ROAD FORCE TEST/BALANCING MACHINE...AT AN EXTRA COST) THAT 3 OF THE 4 TIRES WERE ACTUALLY DEFECTIVE (RED (75 LBS, 73 LBS AND 43 LBS) CONDITION, REPLACE TIRE) AND THE 4TH TIRE USABLE (YELLOW (15 LBS) CONDITION, SLIGHTLY OUT OF ROUND, BUT ARE STILL USABLE...FOR HOW LONG, IS ANYONE GUESS). ROAD FORCE TESTING REVEALED THAT THE INTERNAL BELTS HAD SEPARATED AND ARE THE CAUSE FOR THE OUT OF ROUND TIRE CONDITION. THIS IS WHY THE VIBRATION HAS GOTTEN SIGNIFICANTLY WORST OVER THE PAST MONTH...MORE BELT SEPARATION WITH EACH USE. ACCORDING TO THE TIRE EXPERT TECHNICIAN AT DISCOUNT TIRES, "THE TIRES ARE EGG SHAPED RATHER THAN ROUND LIKE A DOUGHNUT AND THIS CONDITION IS WHAT IS CAUSING THE VIBRATIONS EVEN THOUGH THE TIRES ARE SHOWING BALANCED ON OTHER BALANCING MACHINES AT OTHER SHOPS. OTHER BUYERS HAVE COMPLAINED ON-LINE ABOUT THIS SAME PROBLEM, BUT I SUSPECT THEY HAVE NOT OFFICIALLY REPORTED THESE PROBLEMS TO THE NHTSA. TBCBRANDS CUSTOMER SERVICE IS CLAIMING THAT THERE HAS NEVER BEEN ANY R

SAILUN IS NOT A CURRENTLY A VALID CHOICE AS A TIRE BRAND NAME:, NOR IS TARRAMAX H/T A VALID CHOICE AS A TIRE LINE:, WHY I HAVE SUBMITTED THIS REPORT UNDER THE UNKNOWNCATEGORY FOR BOTH OF THESE CELL INPUTS. PURCHASED (4) NEW SAILUN, TARRAMAX H/T, LT265/75R-16 TIRES (IN JANUARY 2016). AFTER APPROXIMATELY 13,000 MILES OF USE, STARTED EXPERIENCING AN UNUSUAL VIBRATION AT HIGHWAY SPEEDS. AFTER MANY HOURS OF TROUBLESHOOTING THE VIBRATION PROBLEM, IT WAS FINALLY REVEALED AT ANOTHER TIRE CENTER (USING A HUNTER ROAD FORCE TEST/BALANCING MACHINE...AT AN EXTRA COST) THAT 3 OF THE 4 TIRES WERE ACTUALLY DEFECTIVE (RED (75 LBS, 73 LBS AND 43 LBS) CONDITION, REPLACE TIRE) AND THE 4TH TIRE USABLE (YELLOW (15 LBS) CONDITION, SLIGHTLY OUT OF ROUND, BUT ARE STILL USABLE...FOR HOW LONG, IS ANYONE GUESS). ROAD FORCE TESTING REVEALED THAT THE INTERNAL BELTS HAD SEPARATED AND ARE THE CAUSE FOR THE OUT OF ROUND TIRE CONDITION. THIS IS WHY THE VIBRATION HAS GOTTEN SIGNIFICANTLY WORST OVER THE PAST MONTH...MORE BELT SEPARATION WITH EACH USE. ACCORDING TO THE TIRE EXPERT TECHNICIAN AT DISCOUNT TIRES, "THE TIRES ARE EGG SHAPED RATHER THAN ROUND LIKE A DOUGHNUT AND THIS CONDITION IS WHAT IS CAUSING THE VIBRATIONS EVEN THOUGH THE TIRES ARE SHOWING BALANCED ON OTHER BALANCING MACHINES AT OTHER SHOPS. OTHER BUYERS HAVE COMPLAINED ON-LINE ABOUT THIS SAME PROBLEM, BUT I SUSPECT THEY HAVE NOT OFFICIALLY REPORTED THESE PROBLEMS TO THE NHTSA. TBCBRANDS CUSTOMER SERVICE IS CLAIMING THAT THERE HAS NEVER BEEN ANY R

FORD F-250 4X4 FORD RECALL 11S21(NHTSA 11V385) FUEL TANK STRAP CORROSION INSPECTION AND REPLACEMENT WAS CONDUCTED. THE FUEL TANK WAS ALSO FOUND TO BE RUSTED UNDER THE STRAP AREA ONLY. AFTER THE OLD STRAPS WERE REMOVED THE TANK STARTED TO LEAK FUEL AND FORD NOR THE DEALER WOULD REPLACE THE TANK. IF THE STRAPS ARE COVERED FOR CORROSION THEN THE TANK SHOULD BE ALSO DUE TO THE CORROSION TRANSFERRING TO THE TANK SURFACE. THE DEALER PLACED NEW STRAPS OVER A RUSTED TANK. THE TRUCK WILL NEED OVER $1200.00 IN REPAIRS FOR SAFE OPERATION AND TO REMEDY THE NOW LEAKING FUEL. *TR

THE EVENING OF JULY 26TH, 2011 APPROXIMATELY 10:00PM EST, AN ENGINE FIRE OCCURRED IN OUR 1998 FORD F-250 TRUCK (EXT CAB, TRITON V-8 ENGINE, LARIAT ED). THE F-250 HAD BEEN PARKED IN A REMOTE PARKING AREA ON THE INTERIOR AREA OF THE MASON COUNTY FAIR GROUNDS. DUE TO COUNTY FAIR ACTIVITIES DURING THAT DAY, THE TRUCK HAD NOT BEEN STARTED FOR OVER 10 HOURS WHEN THIS FIRE OCCURRED. THE LOCAL FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRE. IT TOTALED THE ENGINE, BUCKLED THE HOOD, BLISTERED THE PAINT, ETC. LUCKILY THERE WAS NO PROPERTY DAMAGE, NOR WAS THERE ANY BODILY INJURY. WE HAD PURCHASED THE TRUCK IN APRIL OF 2010. THIS TRUCK WAS IN PRISTINE (EAT OFF THE ENGINE) CONDITION. SINCE WE HAVE OWNED IT, IT HAD REGULAR OIL CHANGES (MOBIL-1 SYNTHETIC ONLY). ASIDE FROM THAT, AND OTHER NORMAL MAITENANCE, THERE HAD BEEN NO MODIFICATIONS TO THE VEHICLE, WHICH HAD STOCK EQPT WHEN WE PURCHASED IT. NO-OFF ROADING, MY SON BABIED THIS TRUCK. HE DID NOT EVEN LIKE GOING TO HIS GIRLFRIEND'S HOME WITH IT, BECAUSE SHE LIVED ON A DIRT ROAD. HE IS MORE THAN JUST LEFT WITHOUT A VEHICLE, HE IS HEARTBROKEN, TO SAY THE LEAST. I HAVE CHECKED THAT THERE WAS A POLICE REPORT. 911 WAS CALLED, BUT ULTIMATELY IT IS THE FIRE DEPARTMENT THAT MADE THE REPORT. I NOTIFIED FORD ON JULY 27TH, 2011. ON JULY 30TH, 2011 I RECEIVED A LETTER FROM MARIA AGUILERA, PRODUCT CLAIMS LEGAL ANALYST, FORD'S OFFICE OF GENERAL COUNCIL IN DEARBORN, MI. WE ARE WORKING TO GATHER INFORMATION REQUIRED BY HER AT THIS TIME. *KB

THE METAL STRAPS HOLDING THE GAS TANK ON MY 1998 F250 (REGULAR DUTY) RUSTED TO PIECES ONE AT A TIME UNTIL THE LAST STRAP BROKE AND THE GAS TANK DROPPED ON TO THE ROAD. IT IS A MIRACLE THE TANK DIDN'T GET WEDGED UNDER THE VEHICLE OR EXPLODE FROM BEING DRAGGED ON THE ROAD. *TR

ON APRIL 9TH 2011 MY FUEL TANK STRAPS BROKE WHILE DRIVING AT 45 MPH. THE TRUCK WAS PULLED TO THE SIDE OF THE ROAD AND THE TANK WAS HANGING BY THE FUEL LINES AND TANK NECK. THE TRUCK IS A FORD F-250 LIGHT WITH A 24 1/2 GALLON FUEL TANK, THAT HAS 102000 MILES. I REPLACED BOTH STRAPS AT A COST OF $34.00. I PAINTED THE NEW STRAPS TO PREVENT FUTURE PROBLEMS. *TR

1998 FORD F-250 (EARLY BUILD) WITH 201,992 MILES, HAD THE GAS TANK STRAP RUST AND BREAK RESULTING IN THE GAS TANK DROPPING TO THE PAVEMENT. THE FORWARD (FRONT) GAS TANK STRAP FAILED AND THE GAS TANK FELL TO THE PAVEMENT CAUSING THE RELEASE OF APPROXIMATELY 22 GALLONS OF FUEL. THE RESULTING SPILL REQUIRED A CLEANUP BY THE LOCAL FIRE DEPARTMENT. THE SPILL CLEANUP RESULTED IN A $453 CHARGE BY THE FIRE DEPARTMENT. THE VEHICLE WAS TOWED TO A REPAIR SHOP AT A COST OF $112. THE FUEL TANK AND STRAPS REQUIRED REPLACEMENT AT A COST OF $978.00. TOTAL COST OF EVENT $1,500. *TR

I RECENTLY READ THAT NHTSA WAS INVESTIGATING FORD F 150 FROM 1997 TO 2001 FOR RUSTING GAS TANK STRAPS THAT EFFECTED 1.4 MILLION TRUCKS. I HAVE A FORD 1998 F-250 THAT HAD RUSTED GAS TANK STRAPS. ONE STRAP LET GO AND THE TANK MOVED OUT OF POSITION. I REPLACED IT MYSELF, BUT I DON'T KNOW IF IT WAS DONE CORRECTLY OR WITH THE PROPER SAFETY PROTECTION. DID FORD ISSUE A RECALL ON THIS? WILL THEY INSPECT THE VEHICLE TO SEE IF IT WAS DONE CORRECTLY? IS THERE A COST TO THE OWNER FOR ANY OF THIS? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR THE CONSUMER STATED HE HAS AN APPOINTMENT WITH THE DEALER TO HAVE THE STRAPS REPLACED. UPDATED 10/25/11

SPARK PLUG GETS BLOWN COMPLETELY OUT OF THE ENGINE BLOCK AND DESTROYS THE ENGINE COIL. THE ENGINE THEN NEEDS TO BE REBORED TO BE REPAIRED TO BE DRIVABLE. THIS OCCURS WHILE DRIVING THE VEHICLE AND HAS NOW HAPPENED TO US TWICE WHILE THE VEHICLE WAS UNDER NO LOAD. *TR

STEERING GEAR BOX. IT HAS BECOME DISENGAGED AT THE PITMAN ARM. AND LEAKING FLUID. I HAVE FOUND THAT THE 97 AND 99 VERSIONS OF THIS TRUCK HAVE HAD PROBLEMS AND RECALLS FOR THIS. I WAS TOLD A WHILE BACK ( ABOUT 1 YEAR AGO) BY A CAR DEALERSHIP OWNER THAT THIS TRUCK IS ACTUALLY A 99 I WOULD LIKE TO ADD MY VEHICLE YEAR TO THIS LIST. I HAVE ALSO HAD PROBLEMS WITH THE SPARK PLUGS "POPPING OUT" WHICH IS ALSO A PROBLEM WITH THE TRITON ENGINES. *TR

1998 FORD F-250 STEEL TIE-ROD WERE SUFFICIENTLY WORN, LOWER BALL JOINTS WERE ALSO WORN AND NEEDED TO BE REPLACED. *KB ***NAR*** THE CONSUMER RECEIVED A CAUTIONARY LETTER FROM THE FORD MOTOR COMPANY WHICH STATED IT WAS NECESSARY TO HAVE THE STEERING LINKAGE INSPECTED EVERY 15,000, WHICH PROMPTED THE CONSUMER TO HAVE THE VEHICLE INSPECTED. AFTER THE INSTALLATION OF THE NEW AND IMPROVED STEERING COMPONETS, THE LEFT OUTER STEERING TIE ROD SOCKET DISENGAGED FROM THE BALL ON THE LEFT WHEEL ASSEMBLY WHILE MAKING A SLOW GRADUAL LEFT TURN. THIS FAILURE BOUGHT THE VEHICLE TO AN ABRUPT STOP IN THE MIDDLE OF THE INTERSECTION. AFTER THE VEHICLE WAS TOWED AND INSPECTED, IT WAS DISCOVERED THAT ALL THE TIE RODS NEEDED TO BE REPLACED AGAIN.*JB

BROKEN FRONT TORSION BAR. STARTED MOTOR, SHIFTED FROM PARK TO REVERSE, AND WITHOUT MOVING FROM THE SPOT, HEARD A LOUD CRACK AND THE TORSION BAR HAD SNAPPED. MY GARAGE WAS TOLD BY THEIR PARTS SUPPLIER THAT, UNTIL THIS PAST MONTH, THEY NEVER HAD A REQUEST FOR THIS PART BEFORE. THIS IS NOW THE SECOND REQUEST IN THE PAST MONTH. KEPT THE BROKEN BAR AFTER REPLACEMENT.

THE TRUCK WAS STARTED AND THE SPARK PLUG BLEW OUT FROM THE ENGINE. THE TRUCK WAS TAKEN TO A LOCAL DEALERSHIP. THEY STATED IT WASN'T A PROBLEM. THE NEXT TIME, THE SPARK PLUG BLEW OUT WHILE TRAVELING ON THE HIGHWAY AT 55 MPH. THE CONSUMER HAD TO COAST TO THE SIDE OF THE ROAD. PLEASE PROVIDE DETAILS. *JB

WHILE STARTING MY FORD TRUCK WITH THE 5.4 L ENGINE I HEARD A VERY LOUD POP AND THE ENGINE RAN AS IF THE HEAD GASKET BLEW. A NON-FORD MECHANIC VERIFIED THE NO. 3 SPARK PLUG ON THE PASSENGER SIDE BLEW OUT AND STRIPPED THE THREADS FROM THE CYLINDER HEAD INSERT THAT THIS FORD DEALER INSERTED TO REPAIR AN EARLIER BLOWN SPARK PLUG. THE OLD INSERT FOR THE PREVIOUS FAILURE WAS REMOVED AND REPLACED WITH A NEW TYPE ACCORDING TO THE FORD MECHANIC. THIS IS THE SECOND TIME FOR THIS TO HAPPEN. ON JULY 10, 2003, APPROXIMATELY 1 YR AND 2 DAYS BEFORE THIS FAILURE THE NO. 3 SPARK PLUG BLEW OUT STRIPPING THE TREADS IN THE CYLINDER HEAD. NUMEROUS NON-FORD MECHANICS I'VE TALKED TO HAVE VERIFIED THIS BEEN A FAIRLY COMMON OCCURRENCE IN THE 5.4 L FORD ENGINE IN TRUCKS AND SUV'S. AN INDIVIDUAL THAT I WORK WITH HAD THE SAME SPARK PLUG (NO. 3 PASSENGER SIDE) BLOW OUT FROM HER FORD EXPLORER WITH THE 5.4 L ENGINE APPROXIMATELY 6 WEEKS AGO. *LA

WHILE DRIVING, THE REAR SUSPENSION SNAPPED. THE CONSUMER MANAGED TO PULL OVER AND HAD THE VEHICLE TOWED. THE DEALERSHIP TRIED TO REPAIR THE PROBLEM ONCE BEFORE, BUT THE PROBLEM WAS NOT RESOLVED. *AK THREE AIR SUSPENSION BAGS HAD BLOWN OUT SINCE THE CONSUMER PURCHASED THE VEHICLE. (RIGHT AIRBAG ON THE REAR SUSPENSION) *SCC *JB

RIGHT TURN SIGNALS WOULD FAIL TO STAY ON IF ROAD BEARS OPPOSITE OF SIGNAL. INDEPENDENT TECHNICIAN REPLACED TURN SIGNAL. BUT, PROBLEM WAS NOT SOLVED, UNABLE TO BE FIXED. DEALER STATED NEED TO REPLACE THE SWITCH. IT WILL COST CONSUMER $310.00. *AK

REAR WINDOW CRACKS AND LEAKS WATER INTO THE CAB. THIS IS EVIDENTLY A MAJOR PROBLEM AFTER TALKING TO TWO AUTO GLASS PLACES. TALKING TO FORD IS NO HELP.

THERE WAS A PULSATION IN THE BRAKE PEDAL WHEN DEPRESSED. THE ABS SYSTEM LOCKED UP INTERMITTENTLY WHICH CAUSED THE TIRES TO WEAR PREMATURELY. *NLM

I HAVE A 1998 F-250 LIGHT DUTY PICKUP WITH REAR AIR BAG SUSPENSION. THE AIR BAGS HAVE FAILED 3 TIMES IN THE LAST 18 MONTHS. I WAS HOPING THERE WAS A RECALL OR SOMETHING FROM FORD TO FIX THIS PROBLEM, I AM GETTING TIRED OF REPLACING THESE THINGS AT $500 A PIECE. *JB

WHILE DRIVING AT 35MPH INVOLVED IN A FRONTAL COLLISON. UPON IMPACT, AIR BAGS DID NOT DEPLOY.*AK

WHILE DRIVING THE VEHICLE THE OIL LIGHT CAME ON, DISCOVERED VEHICLE WAS LOW ON OIL AND REPLACED OIL, NEXT DAY VEHICLE MADE A TERRIBLE NOISE AND WAS TAKEN TO DEALER ONLY TO FIND THE OIL HAD BEEN BURNED UP THROUGH THE CONVERTER.ENGINE IS BAD DUE TO THE CASINGS. *JG

HAVE FOUND A CRACK LOCATED ON THE DRIVER'S SIDE DOOR AT WINDOW CUTOUT.*AK

BOTH DOORS OF VEHICLE EXHIBIT A FATIGUE CRACK ON THE OUTSIDE OF THE VEHICLE NEAR THE WINDOW AREA, REAR EDGE, ABOUT 3 INCHES UP FROM THE BOTTOM OF WINDOW FRAME, CRACK BEGINS AT THE RUBBER WEATHER SEAL, THEN PROGRESSES REARWARD HORIZONTALLY FOR ABOUT ,5 INCHES. WE THEN CHECKED MY BUDDIES 1997 F150 AND HIS HAD IT TOO. HE THEN CHECK 3 OF HIS FRIENDS, AND THEY ALSO HAD THE CRACKS. SEEMS THAT AUTO BODY SHOPS KNOW OF THIS PROBLEM, CHECK IT OUT SEEMS TO BE A HIGH PERCENTAGE FROM A VERY SMALL SAMPLE. *AK

WHILE TRAVELING DOWN INTERSTATE WITH CRUISE ON AT 70MPH, THE CRUISEW OULD NOT TURN OFF WITH THE BRAKE BEING APPLIED OR WITH THE OFF BUTTON, THE CRUISE ACCELERATED AND WOULD NOT TURN OFF UNTIL THE KEY WAS USED TO TURN THE MOTOR OFF WITH OUT LOCKING THE STEERING WHEEL. THE FIRST TWO TIMES THIS HAPPEN IT WAS JUST THAT THE CRUISE WOULD NOT TURN OFF WITH THE BRAKE OR OFF BUTTON.*AK

SPARK PLUG NUMBER FOUR HAD BLOWN OUT OF HEAD, CONSUMER MANAGED TO GET VEHICLE TO A MECHANICE AND WAS INFORMED THAT HEAD WAS MADE OF ALUMINUM AND ENGINE WAS MADE OF IRON, THIS IS WHAT CAUSED THE SPARK PLUGS TO BLOW, RIGHT HEAD WAS REPLACED FOR A TOTAL COST OF $1900, PARTIAL REIMBURSEMENT WS GIVEN TO CONSUMER. *SLC

WATER LEAKING TO INTERIOR OF VEHICLE CAUSED MAL-FUNCTIONS CAUSING TRUCK TO SHORT AND STOP IN INTERSECTION.*AK

NO SUMMARY LISTED FOR ABOV EVEHICLE. *AK

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

NO SUMMARY LISTED FOR ABOV EVEHICLE. *AK

DRIVER'S SIDE DOOR IS CRACKING ABOVE DOOR HANDLE. DEALERSHIP IS REPLACING DOOR. *AK

WHEN WEATHER IS COLD THROTTLE GETS STUCK IN OPEN POSITION, CAUSING VEHICLE TO RESPOND AS IF CRUISE CONTOL WAS ACTIVATED. FORD HAS BEEN CONTACTED.*AK

THE 6 MONTH OLD FRAME IS WARPED, THERE WAS A BREAK ON THE FRAME THAT WAS VISIBLE WHEN THE REPAIRS WERE MADE, THE DEALER STATED THAT THE SUSPENSION BROKE, CONSUMER STATES THAT THE PROBLEM IS STILL PERSISTING. *SLC

ABS SYSTEM DOES NOT WORK PROPERLY WHEN VEHICLE COMES TO A SUDDEN STOP. THIS USUALLY HAPPENS AT 30-40 MPH. CONTACTED DEALER, AND DEALER ROTATED ROTORS.*AK

VEHICLE EXPERIENCES A PROBLEM WITH THE FRAME CONTINUALLY BECOMING WARPED EVEN AFTER BEING REPLACED, THE CONSUMER IS CONCERNED THAT IT COULD BREAK WHILE DRIVING. *SLC

WHILE DRIVING TORSION BAR BROKE WHICH ALMOST CAUSE A CRASH. CURRENTLY AT DEALER. *AK THE MANUFACTURER FIXED THE TORSION BAR. *YH

TRUCK THAT WAS PURCHASED BRAND NEW HAS A LPG TANK ASSEMBLY, CONSUMER SMELLS PROPANE THROUGH THE FRESH AIR OF THE A/C SYSTEM WHILE SET ON VENT, FLOOR, AND DEFROST, DEALERSHIP HAS NOT BEEN ABLE TO REMEDY THE PROBLEM AFTER MANY ATTEMPTS. *SLC

TORSION BAR KEEPS BRAKING FIRST ON DRIVER'S SIDE AT 35000 WHICH COULD CAUSE FRONT END TO DROP, THEN ON PASSENGER'S SIDE.*AK TORSION BAR BROKE TWICE IN THE SAME YEAR. FRONT END DROPPING AT HIGH SPEED COULD CAUSE THE VEHICLE TO ROLLOVER. *YH

DURING A FRONT IMPACT COLLISION WITH ANOTHER VEHICLE ABOVE 15 MPH THE AIR BAGS FAILED TO DEPLOY . I AM IN DOUBT AS TO THE RELIABILITY OF THE SYSTEM. THE DEALER SAID IT DID NOT DEPLOY DUE TO THE ANGLE AT WHICH THE BUMPER WAS HIT.

ONE SIDE OF TRUCK SAT LOW, SHORTLY AFTER THE OTHER SIDE SAT LOW. REAR END AIRBAG SUSPENSION GAVE WAY AS WELL AS THE SPRINGS. AIR BAGS WERE REPLACED TWICE WITH IN 3 MONTH PERIOD. AFTER RECIEVING TRUCK FROM REPAIR SHOP IT WAS NOTICED BY BODY SHOP THAT FRAME ON LEFT SIDE WAS CRACKED. THIS CRACK WAS IN FRONT VIEW OF SERVICE PEOPLE AND NOT DETECTED. I DO NOT RECALL THE CRACK FROM THE PREVIOUS TIME THE AIR BAGS WERE REPLACED. I DO NOT RECALL THE CRACK WHEN I DROPPED THE TRUCK FOR SECOND REPLACEMENT OF AIRBAGS AND SPRINGS. THE TRUCK FRAME ON LEFT SIDE IS HELD TOGETHER BY TWO INCHES OF CONNECTING STEEL AND I HAVE BEEN ADVISED NOT TO DRIVE THE VEHICLE. THIS TRUCK IS MY LIVELYHOOD AND ONLY MEANS OF TRANSPORTATION. FORD BODY SHOP WILL NOT WELD OR REPAIR FRAME DO TO LIABILITY. THEY RECOMMEND NEW FRAME. AFTER DISCUSSION WITH SERVICE PEOPLE AND BODY SHOP MANAGER IT WAS REVEALED THAT FORD MADE CHANGES TO THE FRAME IN THE 1999 YEAR. THIS IS WHY IN THE 1998 F-250 A DISIEL ENGINE WAS NOT AVAILABLE. OTHER WORDS THE 1998 F-250 WAS FOUND TO BE A WEAKER FRAME THAN ANY OTHER YEAR. ALSO, THE DESIGN OF THE AIRBAG SUSPENSION SYSTEM OF THIS TRUCK IS WEAKER THAN EVEN THE F-150 MODELS. THE SPRINGS ARE OF LESSOR MATERIALS AND LESSOR STRENGTH. THIS WAS EXPLAINED TO ME THAT THIS WAS DONE DO TO THE AIRBAGS CAPABILITY TO MAKE UP THE DIFFERENCE IS SUPPORT. MY VIEW IS THAT ALL THESE COMPONENTS WORK IN UNISONAND WHEN ONE SYSTEM FAILED THE OTHERS FOLLOWED. THE REPAIRS I HAVE DONE ARE NOT REMEDYING THE PROBLEM AND

WHEN BRAKES ARE APPLIED, BRAKES LOCK AND RELEASE RESULTING IN FAILURE OF VEHICLE TO STOP. WHEN BRAKES ARE APPLIED QUICKLY, PEDAL GOES TO FLOOR AND BRAKES FAIL. WHEN TRAVELING OVER A BUMPY SURFACE, IF BRAKES ARE APPLIED, THEY FAIL. IF DRIVING ON EXTREMELY WET ROADS AND BRAKES ARE APPLIED, THEY FAIL TO WORK PROPERLY. BRAKES PADS AND/OR ROTORS HAVE BEEN REPLACED NUMEROUS TIMES DUE TO IMPROPER WEAR. NUMEROUS ATTEMPTS HAVE BEEN MADE WITH THE DEALER AND FORD MOTOR COMPANY TO RESOLVE. HOWEVER, SINCE WARRANTY HAS EXPIRED, FORD MOTOR COMPANY REFUSES TO DISCUSS VEHICLE REPLACEMENT. THEY ACKNOWLEDGE A BRAKING DEFECT HOWEVER THEY CLAIM TO HAVE NO SOLUTION AT THIS TIME. COPIES OF ALL REPAIR ORDERS AND SERVICE NOTICES FROM FORD ARE AVAILABLE, AS WELL AS CORRESPONDENCE TO THE DISPUTE REOLUTION BOARD AND FORD MOTOR COMPANY. *AK

DEALER SERVICE DEPART STATES: "3 OUT OF 10" TRUCKS HAVE THIS PROBLEM! WHY NO RECALL?

WHEN APPLYING THE BRAKES RIGHT REAR WHEEL LOCKS UP, CAUSING THE VEHICLE TO SPIN. DEALER CAN'T FIND A SOLUTION. *AK

BRAKES SHUDDER OR WOBBLE. MULTIPLE REPAIRS DONE BUT PROBLEM PERSISTS. WE WERE GIVEN A LOANER TRUCK (SAME MODEL AND MAKE) WHICH TURNED OUT TO HAVE SAME PROBLEM! DEALER HAS REPLACED ALL BRAKE PARTS MULTIPLE TIMES , TURNED DRUMS MULTIPLE TIMES, AND REPLAC

TURN SIGNAL DOES NOT REMAIN ENGAGED OR IS DIFFICULT TO ENGAGE DURING TURNS.

FRONT END TIRES AND STEERING SHAKE CONSTANTLY AND AT HIGHWAY SPEED IT VIBRATES AND SHAKES SO HARD OVER 50 MPH IT IS HAD TO HOLD ON ROAD. TIRES ARE WEARING DUE TO SHAKING. VEHICLE HAS HAD NEW TIRES, BALANCING, FRONT END ALIGNMENT, MORE THAN ONCE. *AK

WHEN APPLYING BRAKES OR SLOWING DOWN VEHICLE WILL SHUTTER, CAUSING A SAFETY HAZARD. DEALER CANNOT DETERMINE WHAT IS CAUSING THE DEFECT. *AK *ML

BREAKAGE OCCURRED EITHER WHILE STATIONARY OR DOING SLOW SPEED - NOT SURE WHEN. VEHICLE WAS LEANING TO RIGHT WHEN I RETURNED TO IT 20 MINUTES AFTER DRIVING IT. FEEL FREE TO CALL FOR MORE INFORMATION. I SEE ON THE WEB THAT THESE TORSION BARS HAVE BEEN BREAKING QUITE FREQUENTLY ON F150S TOO! *AK