1995 Ford F-250

Defect. ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Risk. OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Remedy. DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)

Defect. CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy. CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

Defect. ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

Risk. A FIRE AT THE SWITCH COULD OCCUR.

Remedy. BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)

Defect. THE WIRE HARNESS FOR THE POWER LUMBAR FEATURE ON THE SEAT IS UNDERNEATH THE FRONT SEAT CUSHION SUPPORT WIRES. THE SUPPORT WIRES ON THE DRIVER SEAT CAN CONTACT AND DAMAGE THE INSULATION HARNESS RESULTING IN A HIGH RESISTANCE ELECTRICAL SHORT THROUGH THE SUPPORT WIRES.

Risk. CONSEQUENCE OF DEFECT: OVER HEATING OF THE SUPPORT WIRES COULD RESULT, AND MELTING, SMOKE, OR POSSIBLE IGNTION OF THE SURROUNDING MATERIALS COULD OCCUR.

Remedy. DEALERS WILL INSPECT THE SEATS ON THE AFFECTED VEHICLES. IF NO DAMAGE IS FOUND, THE DRIVER SEAT WIRE HARNESS WILL BE COVERED WITH A PROTECTIVE CONVOLUTE TUBING, WRAPPED WITH ELECTRICAL TAPE AND THE HARNESS WILL BE REROUTED. IF DAMAGE IS FOUND, THE WIRE HARNESS WILL BE REPLACED.

SEAT BACK BOLTS BROKE WHILE DRIVING VEHICLE. LOST CONTROL ALMOST GOING OFF ROAD. IN MOTION, TWO LANE HIGHWAY DRIVING WINDING ROAD. BROKE ROUNDING A CURVE.

TL* THE CONTACT OWNED A 1995 FORD F-250. WHEN THE VEHICLE CAME TO A COMPLETE STOP, THE CONTACT NOTICED FLAMES UNDERNEATH THE HOOD. THE CONTACT SUSTAINED HAND INJURIES WHILE ATTEMPTING TO EXTINGUISH THE FIRE. MEDICAL ATTENTION WAS NOT REQUIRED. THE CONTACT DISCOVERED THAT THE FIRE STARTED AT THE WIRING HARNESS. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 103,000.

I REPLACED THE REAR BRAKES ON MY 1995 FORD F250. I PUT ON NEW DURALAST BRAKE SHOES (PART #358) FROM AUTOZONE. AFTERWARDS, THE EMERGENCY/PARKING BRAKE FAILED. I TOOK EVERYTHING APART AND TOOK A WHILE BEFORE I FOUND THE PROBLEM. AT THE TOP OF THE BRAKE SHOES THERE IS A HALF CIRCLE WHERE THE FRONT AND BACK SHOE MEETS AND THAT IS WHERE THE EMERGENCY/PARKING BRAKE CAM PUSHES THE SHOES APART. THE OEM SHOES HAVE A TALL SHOULDER AT THE VERY TIP TOP WHERE THE CAM PUSHES AGAINST THE REAR SHOE, THE DURALAST SHOE HAS A SHORTER SHOULDER AND ALLOWED THE CAM TO SLIP OVER THE TOP OF THE REAR SHOE CAUSING THE UNEXPECTED EMERGENCY/PARKING BRAKE FAILURE. *DT

TL* THE CONTACT OWNS A 1994 FORD F-250. THE CONTACT STATED THAT THERE WAS A VISIBLE FUEL LEAK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

DRIVER SIDE SEAT BELTS WILL NOT RETRACT AUTOMATICALLY CAUSING CONCERN BELT WOULD FAIL TO WORK. *TR

1995 FORD F250. CONSUMER WRITES IN REGARDS TO PROBLEMS WITH LEAKING GAS LINE, BRAKES, TRANSMISSION AND SEVERAL OTHER ISSUES WITH VEHICLE. CONSUMER STATES UNSATISFACTORY CUSTOMER SERVICE FROM SEVERAL DEALERSHIPS. *SMD THE MASTER CYLINDER, AIR PUMP, BRAKE PADS, SERPENTINE BELT, BRAKE LINES, ALTERNATOR, CRUISE CONTROL SENSOR, BATTERY, HEADLIGHT CONTROL AND UPPER SWITCH WERE ALL REPLACED. ALSO, THE STARTER SOLENOID SWITCH WAS REPLACED, AS WELL AS THE OIL PAN, THAT WAS RUSTED. THE TIRES WERE REPLACED, DUE TO CRACKING.

TL* THE CONTACT OWNS A 1995 FORD F-250. THE CONTACT STATED THAT THE PARKING BRAKE FAILED. THE CONTACT STATED THAT THEY WERE ABLE TO DRIVE THE VEHICLE WITH THE PARKING BRAKE ENGAGED. THE VEHICLE WAS TAKEN THROUGH STATE INSPECTION AND DID NOT PASS BECAUSE THE PARKING BRAKE WAS INOPERABLE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 02V068000 (PARKING BRAKE) AND WAS TOLD BY THE MANUFACTURER THAT THE RECALL WAS ONLY FOR VEHICLES WITH MANUAL TRANSMISSIONS. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 202,000. *TR

TL* THE CONTACT OWNS A 1995 FORD F-250. THE CONTACT STATED THAT THERE WAS A RECURRING FAILURE WITH THE FLY WHEEL IN WHICH THE FLY-WHEEL HAD TO BE REPLACED CONTINUOUSLY. THE FAILURE MILEAGE WAS 78,955 AND THE CURRENT MILEAGE WAS 86,760. *TR

1995 FORD F250. CONSUMER STATES ENGINE STALL WHILE DRIVING. *TGW WHEN THE ENGINE STALLED, THE CONSUMER HAD TO PUT THE SHIFTER INTO PARK OR NEUTRAL AND THE ENGINE WOULD RESTART. HE ALSO, STATED THE FUEL/WATER SEPARATOR WAS REPLACED. ALSO, OTHER REPAIRS INCLUDED, NEW HOSES, FAN CLUTCH, IDLER WHEEL, BRAKE PADS, RELAY ON GLOW PLUG, V-BELT, SEVERAL BATTERIES, THE LIFT PUMP AND THE SOLENOID ON THE STARTER. JB ALSO, THE O-RINGS WERE REPLACED. UPDATED 12/31/12 THE DEALER FOUND PROBLEMS WITH THE ICP INJECTOR PRESS, EBA EXH BACK PRESS, MAP, MANIFOLD AND ABS. UPDATED 03/14/13. *JB

TL* THE CONTACT OWNS A 1995 FORD F-250. THE CONTACT STATED THE VEHICLE HAD A DUAL FUEL TANK, ONE IN THE FRONT AND ONE IN THE REAR. WHILE DRIVING, THE FRONT FUEL TANK BEGAN TO LEAK. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO DIAGNOSED THE FAILURE AND STATED THE CHECK VALVE INSIDE THE FUEL TANK CAUSED THE FAILURE. THE DEALER STATED THAT IN ORDER TO PERFORM A DIAGNOSTIC TEST THE CONTACT HAD TO PAY A FEE AND OFFERED NO OTHER ASSISTANCE. THE MANUFACTURER WAS NOTIFIED WHO STATED THE VEHICLE WAS NOT COVERED BY A WARRANTY AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 168,000. THE CURRENT MILEAGE WAS 170,000.

TL* THE CONTACT OWNS A 1995 FORD F-250. THE CONTACT STATED WHILE DRIVING 2 MPH AND ATTEMPTING TO PLOW SNOW, THE FRAME OF THE VEHICLE BENT WHEN CONTACT WAS MADE WITH THE SNOW. THE CONTACT EXITED THE VEHICLE AND NOTICED THAT THE FRAME WAS RUSTED NEAR THE FRONT END. THE CONTACT ATTEMPTED TO TOW THE VEHICLE, BUT IT FLATTENED WHEN IT WAS RAISED ONTO THE TOW TRUCK. THE DEALER AND MANUFACTURER WERE NOTIFIED AND PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 98,000.

1995 FORD F250. CONSUMER WRITES IN REGARDS TO PROBLEM WITH SPEEDOMETER CLUSTER. *TGW THE CONSUMER STATED WHEN HE SHIFTED FROM PARK TO DRIVE, OR FROM NEUTRAL TO REVERSE THE ENGINE WOULD SHUT OFF

TL* THE CONTACT OWNS A 1995 FORD F250. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE. THE FIRE ORIGINATED FROM THE MASTER CYLINDER. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE AND THE HOOD, FENDER WALLS AND WIRES WERE DESTROYED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THE CONTACT TO WAIT UNTIL THE LEGAL DEPARTMENT CONTACTED HIM BEFORE ANY REPAIRS WERE PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 140,000. UPDATED 04/15/11*LJ UPDATED 12/19/2011 *LN

ENGINE COMPARTMENT FIRE ON A PARKED 1995 FORD F-250. THE FIRE SPREAD RAPIDLY THROUGHOUT THE ENGINE COMPARTMENT, AND CAUSED A CAR PARKED NEXT TO THE TRUCK TO CATCH FIRE. THE VEHICLE IS TOTALED. THE FIRE INVESTIGATOR FOR MOUNT PROSPECT, IL, INDICATED THAT IT WAS LIKELY AN INTERNAL ELECTRICAL FAULT. *TR

TL* THE CONTACT OWNS A 1995 FORD F250. THE CONTACT STATED HE WAS AWAKENED BY THE HORN OF HIS VEHICLE INDEPENDENTLY SOUNDING. THE CONTACT THEN OBSERVED FLAMES SHOOTING FROM THE DRIVER'S SIDE OF THE ENGINE COMPARTMENT. THE ENGINE WAS DESTROYED AND THE LEFT SIDE OF THE ENGINE, INCLUDING THE METAL, HAD MELTED. THE INSURANCE COMPANY WAS CONTACTED. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 133,000.

1995 FORD F-250 TRUCK CAUGHT FIRE. *TR

1998 FORD F150 TRUCK (BRAKES LOCKING WHENEVER FAST BRAKING APPLIED, FORD F250 SAME THING TRUCK WAS WRECKED LAST NIGHT DUE TO THIS PROBLEM THANKS GOD NO ONE WAS KILLED ! 1997 FORD MUSTANG SAME PROBLEM ,BRAKES LOCK WHEN FAST PRESSURE IS APPLIED . HELP THESE VEHICLES ARE GOING TO KILL SOMEBODY . OH YES AND ON THE F250 WE NOW HAVE A TRAFFIC TICKET FOR FAILURE TO CONTROL SPEED AND THE TRUCK IS TOTALED. *TR

1995 FORD F-250 7.3 POWERSTROKE. CAM POSITION SENSOR (CPS) FAILURE , REPLACED AND TRUCK STARTED , GOES BAD OFTEN , WHEN IT DOES TRUCK DIES WONT START. OLD PART IS AVAILABLE. *TR

MY 1995 F250 FORD PICKUP BURNED UP WHILE PARKED. ABSOLUTELY NO-CONTACT FROM FORD MANUFACTURING SINCE THE INCIDENT - EVEN AFTER I TRIED TO CONTACT FORD ON SEVERAL OCAASIONS - COULD GET THROUGH TO PHONE OPERATOR BUT NO RESPONSE FROM FORD MOTOR CO.

1995 FORD F250 7.3L TURBO DIESEL : CAM POSITION SENSOR FAILED AFTER NUMEROUS, WORSENING EXPERIENCES WITH ERRATIC ENGINE PERFORMANCE. SENSOR REPLACED BY DEALER ON 12/07/2006 WITH TRUCK BARELY ABLE TO CONTINUE RUNNING. THIS CORRECTED THE PROBLEM AT THE TIME, BUT I AM NOW OCCASIONALLY EXPERIENCING THE SAME SYMPTOMS AGAIN. I HAVE SUBSEQUENTLY DISCOVERED THAT THIS IS A CHRONIC PROBLEM WITH THIS NAVISTAR ENGINE. MANY FORD VEHICLES HAVE BEEN RECALLED AS A RESULT, BUT MINE HAS NOT, DESPITE NUMEROUS VEHICLES OF MY MODEL YEAR (1995) EXPERIENCING THIS PROBLEM. *TR