2022 Tesla Model Y

Defect. Tesla, Inc. (Tesla) is recalling certain 2017-2023 Model 3 and 2020-2023 Model Y vehicles. The headlight low beams may be too bright and exceed the maximum light output. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk. Headlight low beams that are too bright can reduce visibility for oncoming drivers, increasing the risk of a crash.

Remedy. Tesla Service will replace the headlights, free of charge. Interim owner notification letters explaining the safety risk were be mailed October 3, 2026. Another notice will be sent once the repair becomes available. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-003.

Defect. Tesla, Inc. (Tesla) is recalling certain 2017, 2021-2023 Model 3, 2020-2023 Model Y, 2021-2023 Model S, and Model X vehicles operating software version 2026.8.6. The rearview camera image may be delayed when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk. A delayed rearview image reduces the driver's view behind the vehicle, increasing the risk of a crash.

Remedy. Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed July 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-00-001.

Defect. Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."

Risk. Driving with improperly inflated tires increases the risk of a crash.

Remedy. Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.

Defect. Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model 3, Model S, Model X, and 2020-2024 Model Y vehicles. The hood latch assembly may fail to detect an unlatched hood condition after the hood has been opened.

Risk. An unlatched hood can fully open, obstructing the driver's view and increasing the risk of a crash.

Remedy. Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed September 24, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-012.

Defect. Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk. A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.

Remedy. Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.

Defect. Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."

Risk. Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.

Remedy. Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.

Defect. Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."

Risk. Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.

Remedy. Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.

Defect. Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.

Risk. In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.

Remedy. Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.

Defect. Tesla, Inc. (Tesla) is recalling certain 2022-2023 Model Y vehicles. The steering wheel fastener may be loose.

Risk. A loose fastener may allow the steering wheel to disconnect from the steering column, which can cause a loss of steering control and increase the risk of a crash.

Remedy. Tesla Service will inspect and replace the fastener as necessary, free of charge. Owner notification letters were be mailed July 28, 2023. Tesla's number for this recall is SB-23-32-001.

Defect. Tesla, Inc. (Tesla) is recalling certain 2022-2023 Model Y vehicles. The bolts securing the second-row seat back frames may not have been securely tightened.

Risk. A loose seat frame bolt may reduce the seat belt system's performance, increasing the risk of injury during a crash.

Remedy. Tesla Service Centers will inspect and tighten the bolts as necessary, free of charge. Owner notification letters are expected to be mailed April 25, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-13-001.

Defect. Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.

Risk. FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.

Remedy. Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.

Defect. Tesla, Inc. (Tesla) is recalling certain 2023 Model 3 and 2020-2023 Model Y vehicles. One or both taillights may intermittently fail to illuminate.

Risk. A taillight that fails to illuminate may reduce the visibility of the vehicle, increasing the risk of a crash.

Remedy. Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed January 14, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-016.

Defect. Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."

Risk. A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.

Remedy. Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.

Defect. Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S, Model X, and 2022 Model 3 and Model Y vehicles operating certain firmware releases. The infotainment central processing unit (CPU) may overheat during the preparation or process of fast-charging, causing the CPU to lag or restart.

Risk. A lagging or restarting CPU may prevent the center screen from displaying the rearview camera image, gear selection, windshield visibility control settings, and warning lights, increasing the risk of a crash.

Remedy. Tesla will perform an over-the-air (OTA) software update that will improve CPU temperature management, free of charge. Owner notification letters were mailed July 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-009.

Defect. Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."

Risk. Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.

Remedy. Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.

Defect. Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."

Risk. Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.

Remedy. Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.

Defect. Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model 3, Model S, Model X, and 2020-2022 Model Y vehicles. A software error may cause a valve in the heat pump to open unintentionally and trap the refrigerant inside the evaporator, resulting in decreased defrosting performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."

Risk. Decreased defrosting performance may reduce the driver's visibility, increasing the risk of a crash.

Remedy. Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-18-002.

Defect. Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk. The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.

Remedy. Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.

Defect. Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.

Risk. Failing to stop at a stop sign can increase the risk of a crash.

Remedy. Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.

Defect. Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y vehicles. The front and rear suspension knuckles may fracture, causing the suspension links to separate.

Risk. Suspension links that separate can reduce vehicle stability and control, increasing the risk of a crash.

Remedy. Tesla Service will inspect and replace the knuckles as necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-004.

The Office of Defects Investigation (ODI) has received 156 complaints alleging a suspension failure in model year (MY) 2018-2020 Model 3 and MY 2021-2023 Model Y vehicles. The suspension failure involves the detachment of the front lower lateral link, which potentially causes a loss of vehicle directional control. In most cases, there was no advance warning or indication that the suspension failure would occur. Some cases cite noises occurring prior to failure, but note that the vehicle provides no visual warnings. Once the failure occurs, the vehicle may not be drivable, thus requiring a …

The Office of Defects Investigation (ODI) is opening this Engineering Analysis to evaluate Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) degradation detection system. The focus of this investigation will be to assess the system’s ability, when encountering reduced roadway visibility conditions, to detect degradation and alert the driver with sufficient time to respond. ODI will evaluate the performance of FSD in degraded roadway conditions and the updates or modifications by Tesla to the degradation detection system, including the timing, purpose, and …

The Office of Defects Investigation (“ODI”) is opening this Preliminary Evaluation (PE) to assess the scope, frequency, and potential safety consequences of FSD executing driving maneuvers that constitute traffic safety violations. This investigation concerns versions of FSD that Tesla has labeled as "FSD (Supervised)" and "FSD (Beta)." Tesla characterizes FSD as an SAE Level 2 partial automation system requiring a fully attentive driver who is engaged in the driving task at all times. Level 2 partial automation systems are designed to support and assist the driver in performing certain aspects …

The Office of Defects Investigation (“ODI”) has identified numerous incident reports submitted by Tesla, Inc. (“Tesla”) in response to Standing General Order 2021-01 (the “SGO”), in which the reported crashes occurred several months or more before the dates of the reports. The majority of these reports involved crashes in which the Standing General Order in place at the time required a report to be submitted within one or five days of Tesla receiving notice of the crash. When the reports were submitted, Tesla submitted them in one of two ways. Many of the reports were submitted as part of a …

On January 6, 2025, the Office of Defects Investigations (ODI) opened Preliminary Evaluation 24003 (PE24033) to investigate Actually Smart Summon (Summon) sessions resulting in crashes during active sessions. According to Tesla, Summon is a short-distance SAE Level 2 system, controlled by the user from a cell phone within a certain distance and intended for use in parking lots and on private property. ODI analyzed complaint data provided by Tesla as well as complaints submitted to ODI from consumers to identify Summon incidents resulting in crashes. ODI's analysis indicates that almost all …

On October 17, 2024, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24031) of Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) to assess: the ability of the FSD system to detect and respond appropriately to reduced roadway visibility conditions; whether any other FSD crashes had occurred under degraded roadway visibility conditions that are similar in nature to the four SGO-reported crashes identified in the opening document, and if so, the contributing circumstances for each of those crashes; and any updates or …

The Office of Defects Investigation (ODI) is opening a Recall Query to assess the remedy adequacy of Recall 23V838. On December 12, 2023, Tesla filed a Defect Information Report (Recall 23V838) applicable to all Tesla models produced and equipped with any version of its Autopilot system, which Tesla described as an SAE Level 2 (L2) Advanced Driver Assistance System (ADAS). Autopilot is the simultaneous engagement of Tesla’s Traffic-Aware Cruise Control (TACC) and Autosteer. In describing the safety defect, Tesla’s Defect Information Report (DIR) explained that “the prominence and scope of the …

The Office of Defects Investigation (ODI) received a petition requesting that ODI reevaluate its decision to deny DP20-001 on the basis that intermittent high electrical current demands on the vehicles' 12VDC systems may have caused some or all of the incidents examined by ODI in DP20-001. The petitioner bases this information on a review of open-source research and the DP20-001 denial. The petition and related materials can be reviewed at NHTSA.gov under the following ODI number: 11528471.

On March 21, 2023, the Office of Defects Investigation (ODI) received a petition requesting a “recall of all Tesla cars” produced from 2013 to the date on which the petition was filed due to what Petitioner considers to be the increased likelihood of pedal misapplication. Attached to the Petition is a paper authored by Petitioner. According to Petitioner, the differences in the operator controls between the subject Tesla vehicles and internal combustion engine powered vehicles promote driver pedal misapplication, leading to sudden unintended acceleration (SUA) incidents. To fix this alleged …

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after …

The Office of Defects Investigation (ODI) upgraded PE21020 to EA22002 on June 8, 2022, to extend work and deepen the PE21020 crash analysis, to supplement that analysis with additional data, and to perform vehicle evaluations to understand how Tesla’s Autopilot system may exacerbate human factors or behavioral safety risks by undermining the effectiveness of the driver’s supervision. To support this work, ODI collected additional crash information and assessed vehicle control authority, driver engagement technologies, and related human factors considerations associated with partial automation …

On February 16, 2022, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE22002) to investigate reports of unexpected deceleration while driving with the adaptive cruise control system engaged in Model Year (MY) 2021 – 2022 Model 3 and Model Y vehicles manufactured by Tesla. The subject systems include Autopilot (all versions), Full Self-Driving (FSD) and Traffic Aware Cruise Control (TACC). These complaints have been colloquially referred to as “phantom braking”. ODI opened PE22002 to determine the scope and severity of the potential problem and to assess any …

The Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE21-023) on December 21, 2021, to evaluate the driver distraction potential and use frequency / circumstances of in-vehicle game-play functionality referred to as ?Passenger Play? in certain model year (MY) 2017-2022 Tesla Model 3, S, X, and Y vehicles. Distracted driving can result in an increased risk of a crash. PE21-023 was prompted by the receipt of Vehicle Owners Questionnaire (VOQ) 11439598 from the owner of a 2021 Model 3 on November 6, 2021. ODI sent an Information Request (IR) letter to Tesla on January 20, …

On August 13, 2021, NHTSA?s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE21-020) to assess the performance of Tesla?s Autopilot system (a system characterized by Tesla as an SAE Level 2 driving automation system designed to support and assist the driver in performing the driving task) available in Tesla vehicles. The investigation opening was motivated by an accumulation of crashes in which Tesla vehicles, operating with Autopilot engaged, struck stationary in-road or roadside first responder vehicles tending to pre-existing collision scenes. Upon opening the …

I am reporting a safety defect on my 2022 Tesla Model Y (VIN [XXX], 70,856 miles). On XXX, I brought the vehicle to Tesla Service in [XXX] for a tire pressure alert. While performing its own service-bulletin inspection of the front and rear chassis, Tesla found that BOTH front lower lateral link assemblies require replacement and presented me with a $1,173.56 estimate, classifying the required wheel alignment as "Customer Pay." The front lower lateral link is the exact component under ODI's open Preliminary Evaluation PE26006 for 2021-2023 Model Y, involving detachment and potential loss of vehicle directional control. Both links failing simultaneously, discovered through Tesla's own bulletin inspection with no accident or impact damage, indicates premature component failure of a safety-critical steering/suspension part, not ordinary wear. Tesla has not agreed to cover this repair. The vehicle was promised back on XXX and is still not repaired. I am filing this report so the condition is documented within PE26006, and I request that NHTSA consider this case when evaluating whether the lateral link defect on 2021-2023 Model Y requires a recall. I have asked Tesla to preserve the removed parts for inspection. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On October 18, 2026, at approximately 3:15, I was opening the driver’s door of my 2022 Tesla Model Y, using the exterior door handle in the normal way. My left thumbnail became trapped inside the handle mechanism as it operated. The handle tore the entire thumbnail off at the nail bed, and the nail remained lodged in the handle. I had to pull the detached nail out of the handle myself. I lost consciousness briefly from the pain and blood loss. I went to the emergency room at Kaiser Permanente, where the nail bed was cleaned and the detached nail was reinserted and splinted. No stitches were required. The nail will take approximately 6-8 months to regrow. The vehicle was parked and undamaged. The handle did not malfunction in an obvious way; the injury occurred during ordinary operation. I believe the design of the recessed handle allows a fingernail to be caught between the moving handle and the door, and I am reporting this as a safety concern.

I was using the Full Self Driving Feature on the Tesla when it began to merge into the lanes on the right and it almost hit another vehicle. Today is the second day using the FSD feature, this is the first time it does this. Prior to it merging lanes on its own, it did swerve to the right on one lane as well.

Tesla manual States that to shift from drive to reverse all you have to do is press the stop all the way up. However while driving if you had used autopilot which is the adas system and disengaged it without hitting the brakes then the car will refuse to go into reverse contradiction to the user manual. I have almost been in numerous low-speed crashes because I pressed the stock up to go into reverse and thinking that the car will go into reverse I'm pressing the throttle again only for the car to work forward followed by a delayed sound indicating that the car didn't go into reverse. The sound he's almost always delayed.

After making a left turn I got 2 alerts on my screen "steering assist reduced" and "lane departure disabled", I tried to reset the vehicle few times, but it didn't work, I drove it to Tesla repair center and they issued steering rack damage diagnosis, Tesla is removing and replacing the steering rack along with wheel alignment at this moment. Driving with the alert was extremely dangerous since the steering could have been completely disabled while driving and this could happen on the freeway or a busy street which would have put me and others at the risk. Since it has been a very common problem with 2022 and 2023 models and recall has been issued for 2023 models, I feel like the 2022 models having the exact same problem are being ignored and it's drivers put at a risk of hurting themselves or others.

The contact owns a 2022 Tesla Model Y. The contact stated that the steering wheel covering delaminated and detached from the steering wheel structure. The contact indicated that while turning the steering wheel, additional effort was required to grip the wheel. Both the dealer and manufacturer were notified of the failure. The failure mileage was 72,000.

On XXX, I was involved in a collision in [XXX], while manually driving my 2022 Tesla Model Y (VIN: [XXX]). Neither Full Self-Driving (FSD) nor Autopilot was engaged. I was making a right turn at a red traffic signal while another vehicle was making a U-turn. My Tesla collided with the passenger-side door of the other vehicle. Before the collision, I did not receive any audible or visual Forward Collision Warning (FCW). I also did not observe the Automatic Emergency Braking (AEB) system activating or attempting to slow the vehicle before impact. My approximate speed at the time of the collision is unknown. No injuries occurred. I am concerned that the vehicle's Forward Collision Warning and Automatic Emergency Braking systems did not respond to the collision risk. I understand these systems have operating limitations, particularly during turning maneuvers, but I would like this incident documented as a potential vehicle safety concern. I request that NHTSA review this incident to determine whether further investigation is warranted, including whether the vehicle detected the collision risk and whether the safety systems were functioning as designed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am reporting a potentially serious tire safety failure involving a Continental ProContact RX, size 255/45R19 104W XL, installed on a 2022 Tesla Model Y. The tire was purchased new and installed by Tesla on January 15, 2026. In September 2026, while driving, the tire experienced a sudden catastrophic failure. The sidewall was extensively torn and separated circumferentially around the wheel, while substantial portions of the tread remained intact. The tire carcass was left hanging around the wheel. This was not simply a small puncture or localized cut. The incident created a significant safety concern due to the sudden loss of tire integrity while the vehicle was moving. The vehicle was subsequently towed to a Tesla service center for inspection. No resulting vehicle damage was identified, but the tire required replacement. Tesla documented tread-depth measurements of 6/32, 7/32 and 8/32. Continental subsequently declined warranty coverage, citing treadwear and reported tire-pressure concerns. However, the precise initiating cause of the catastrophic failure has not been established. Continental has now arranged for the failed tire to be returned for further technical examination, with findings expected approximately 6–8 weeks after receipt. The failed tire has been retained and is available for inspection, and extensive photographs document its condition. I am concerned that a relatively new tire could fail in this manner and request that NHTSA review this incident for any

On [xxx], I brought my 2022 Tesla Model Y (VIN [XXX]), with approximately 31,000 miles, to Tesla Service in Owings Mills, Maryland. During the inspection, Tesla identified significant deterioration of the front suspension bushings. Tesla’s written estimate states: “recommend to replace lateral links and compliance links due to bushing being torn and dry rotting.” Tesla recommended replacement of the front lower lateral link assemblies and front lower compliance links. The estimated repair cost is $1,548.80. I was not aware of this condition before Tesla’s inspection. I am reporting it because deterioration of front suspension/lateral-link components could potentially affect vehicle handling or steering if the components deteriorate further or fail. Components failed/deteriorated: Tesla diagnosed the bushings as torn and dry rotting and recommended replacement of the affected front suspension links. I have not experienced an actual component detachment or complete suspension failure. Warning lights: I did not have a warning light indicating this suspension condition before Tesla’s inspection. I am aware that NHTSA has opened an investigation involving reported front lower lateral-link failures on certain 2021–2023 Model Y vehicles. I am not claiming that my vehicle has the same defect, but I want this condition documented and evaluated for possible relevance to that investigation. Tesla also verbally told me that goodwill assistance was denied because the vehicle had been driv

The contact owned a 2022 Tesla Model Y. The contact stated that while driving at an undisclosed speed, the central computer suddenly overheated. The failure caused the vehicle to stop immediately and disabled other essential safety features. During the failure, the center screen flashed red with a message instructing the driver to take control, followed by a series of unknown error codes and an "APP_W141 ECU thermal alert" warning. After researching, the contact discovered that the failure might have been caused by a recent software update from the manufacturer. The manufacturer was notified of the failure, and a Tesla Service Center confirmed the failure as a Hardware 3 computer failure. The contact was informed that the system needed to be replaced. The failure mileage was 95,000.

Kept getting warnings "Steering assist reduced" and "steering may require increased effort" that would come and go even after resetting vehicle. This resulted in unpredictable steering and unsafe driving conditions and matches ongoing NHTSA investigation EA24001. This required replacement of the entire steering rack. Tesla's own diagnosis confirmed no wiring/connector fault and recommended full steering rack replacement at the cost of: $3,589.92, entirely out of pocket, outside both warranty and any current recall despite ongoing investigation

The suspected malfunction involved Tesla’s Full Self-Driving (Supervised) and related automated steering, lane guidance, lane-departure avoidance and disengagement/warning systems. FSD was active before the event but changed to “Unavailable” approximately 1.35 seconds before impact as the vehicle began moving left toward a barrier. The exact cause has not been independently determined. The vehicle remains in my possession and is available for inspection, along with the EDR report and Tesla data files. My safety and the safety of others were placed at risk because the vehicle departed its travel path at approximately 65–67 mph. The warning and disengagement sequence provided only about one to one-and-a-half seconds before impact. The vehicle struck the barrier at highway speed, deploying the left side and curtain airbags. This created a risk of serious injury, rollover or collision with nearby motorists. The problem has not been reproduced or confirmed by a dealer because the vehicle was rendered inoperable. However, Tesla’s data confirms that FSD was active, became unavailable approximately 1.35 seconds before the crash, and that the steering angle moved sharply left immediately before impact. The data confirms the sequence but does not conclusively establish who or what initiated the steering movement. The vehicle has not received a technical inspection by Tesla or an independent defect specialist. Towing have handled it, but no one has technically evaluated the FSD or steer

After only 34,306 miles, the front lower forward suspension control arms (left and right) and front lower rearward csuspension control arms and ball joints need to be replaced. I discovered this when having the tires replaced. This seems to be a common issue with this model, but failure of these parts is very premature. There was no accident or incident, but the replacement of these parts is critical to the safety of the vehicle.

When engaging fsd, you can’t see the safety distance between you and the car in front of you for defensive driving. Even if you are supervising fsd at high speed on the freeway, the high speed and sudden possibility of fsd disengaging is dangerous. The fsd mode should allow for safe distance between you and vehicle in front to be set manually and if it can’t be set manually, it shouldn’t be allowed to following too closely to the front vehicle. It’s unfair and absolutely dangerous to all should the fsd disengage and the driver doesn’t have time to react even though we are responsibly supervising. This feature needs mitigation

The contact owns a 2022 Tesla Model Y. The contact stated that while stopped at a red light and attempting to accelerate, the vehicle failed to accelerate as intended and jerked. The contact stated that after shifting into reverse(R), the vehicle failed to reverse as intended. The vehicle was shifted to park(P) and then into drive(D) several times, and the vehicle accelerated. The contact stated that approximately 20 minutes later, while exiting the highway and approaching a red light, the brake pedal was depressed and the vehicle was stopped and the hold feature was engaged and the icon showed up on the dashboard, but the vehicle rolled backward and struck another vehicle. The vehicle was then shifted to park(P), and after speaking with the other driver, the vehicle was moved to the closest parking lot. The Police were called, but a report was not filed. The vehicle was then taken to the residence. The vehicle was taken to a dealer; however, the failure could not be duplicated. The vehicle was then taken to the same dealer, but the failure could not be duplicated. The manufacturer was notified of the failure. The failure mileage was approximately 63,500.

While driving on the highway with Full Self-Driving (Supervised) engaged, the vehicle approached an exit that had been closed with traffic cones and road-closure signage. The vehicle failed to properly respond to the closure, continued through and struck multiple traffic cones, and ultimately collided with the road-closure equipment, causing significant front-end damage. My primary safety concern is that multiple safety systems appeared to provide no effective intervention. I observed no Forward Collision Warning, no Automatic Emergency Braking, and no effective automatic braking or avoidance maneuver, even after the vehicle had already begun striking traffic cones. There were no warning messages or indications of a system malfunction before the collision. This was a serious safety incident involving FSD, Forward Collision Warning, Automatic Emergency Braking, and the vehicle's obstacle-detection/collision-avoidance systems. I am requesting that Tesla immediately preserve and review all available vehicle data, including FSD status, camera/perception data, detected objects, vehicle speed, steering, braking commands, Forward Collision Warning events, Automatic Emergency Braking activity, and driver inputs before and during the collision. The vehicle is available for inspection. I also have evidence of the damage and incident available upon request. I am requesting a formal investigation to determine why the vehicle continued through multiple physical traffic-control obstacles w

At only 27k miles in with no accident history and perfect maintenance my camera system began to fail. It started with a delay of the backup camera and then turned into the cameras no longer working and no longer talking to the satellites. This then became a gps issue. Tesla despite me being 1 month outside warranty and well below the mileage charged me for a $4k new computer without diagnosing the failure as to whether it was heat related or what. It said the FSD computer was failing to make connection with the other computer. I had never even used FSD. This Premature failure of the computer system should’ve never been charged to me.

Tesla identified that the Front Lower Lateral Link was worn with 33,971 miles and was not covered under warranty. Two were replaced.

My 2022 Tesla Model Y does not reliably activate the rear air-conditioning vents when a baby is properly restrained in a rear car seat. When the climate system is set to Auto, the rear vents remain off because the vehicle does not detect the baby/car seat as an occupant. When an adult occupies the same rear seat, the vehicle detects the passenger and the rear vents activate automatically. This creates a significant safety concern because the driver can have the climate system running normally and the front of the cabin can be cool, while very little conditioned air is being directed to the rear where the baby is seated. On multiple occasions, my baby has been visibly hot and sweating in the rear car seat even though the front of the cabin felt cool and the front climate system was actively running. The problem is particularly concerning because a baby cannot communicate that they are overheating, and there is no obvious warning to the driver that the rear vents have remained off. A driver could reasonably assume that setting the vehicle’s climate control to Auto is appropriately cooling the occupied cabin. I have been able to reproduce and isolate the issue. Applying approximately 20 pounds of pressure to a particular area of the rear seat cushion causes the vehicle to recognize the seat as occupied and the rear climate vents to activate. Removing that pressure causes the normal behavior to return. This indicates that the automatic rear climate behavior is dependent on an occ

My chat constantly phantom brakes. This is a constant issue, I ve had the car since it was new and almost everytime im in adaptive cruise control it randomly brakes. Today with nothing in front of my on 3 separate occasions it applies the brakes and forces me to accelerate to maintain speed.

Every little bump or weight shift my car makes, the rear suspension makes a creeping slide. I've already had to replace control arms in tube front suspension for a loud clunking noise

Child entered our vehicle and was UNABLE to exit/open his door (driver's side passenger door) from inside. The child locks were not enabled. The door would also NOT open from the outside. When entering service mode, a VCLEFT_a187latchReleaseFailedR error was present. I looked up on Tesla service how to manual release the door. It states to use a fingernail or flat tool to open the plastic flap in the pocket of the door handle. I was unable to open with a my fingernail and using a small screwdriver took me multiple attempts. It then took me multiple attempts (~5) of pulling the release cable for the latch to unlock. I believe I finally got it to unlock while holding the electronic latch while pulling --this is not mentioned in the service manual (unsure if this step is missing or it just was extremely stuck/luck that it finally unlatched when I did this). Once the latch was released, this error and all history of it was not even logged in the service alerts section. Made a service appointment, however, first available is not for >20 days. I also have a video of us trying to open the door multiple times but I can not upload it here.

While operating a 2022 Tesla Model Y with Full Self-Driving (FSD Supervised) engaged, the vehicle failed to execute a right merge onto the CA-280 North freeway ramp in Redwood City, CA. Instead, FSD initiated an unexpected wrong-way maneuver down a downward off-ramp. As the vehicle headed toward a sharp left curve, it failed to decelerate sufficiently for the turn. The vehicle maintained speed on the downward incline and then accelerated slightly, traveling at around 30 mph immediately prior to impact. Facing an active hazard initiated by the software, I performed an emergency manual override. System steering resistance and abrupt load transfer mid-turn caused an immediate loss of control, driving the vehicle over a mound and into an off-road ditch. Airbags deployed upon impact, and occupants (including a 5-month-old infant) were transported to the emergency room for evaluation. A formal safety complaint is being filed regarding FSD wrong-way navigation failures, failure to decelerate, and severe handling/disengagement instability during emergency takeover scenarios.

FSD (Supervised) was engaged while the vehicle was traveling toward a freeway entrance. The vehicle was expected to turn right, but instead began veering left. The driver applied the brake in an attempt to slow the vehicle and disengage FSD. According to the driver’s recollection, the vehicle did not respond as expected and continued accelerating until it left the roadway and crashed into a ditch. The incident created a serious safety risk to the driver and an infant passenger. Emergency services responded, and the driver and infant passenger were transported to an emergency department for evaluation. The vehicle was subsequently towed from the scene. The suspected malfunction involves FSD/vehicle control behavior, including whether the system properly responded to brake input and whether commanded acceleration continued after the driver attempted to intervene. The vehicle and its electronic systems should currently be available for inspection, and a request has been made to preserve relevant vehicle telemetry, driver-input data, FSD engagement status, accelerator and brake inputs, commanded motor torque, speed, steering inputs, camera footage, Event Data Recorder information, diagnostic logs, and software/FSD version information. A police report has been filed and both Tesla and Tesla insurance have been contacted.

Car makes loud noise from front axel

Tailgate doesn’t close. Electric hydraulic arm on driver side is too strong forcing misalignment of tailgate. Tesla will not repair under warranty.

The contact owns a 2022 Tesla Model Y. The contact stated that while driving at an undisclosed speed, the steering wheel started sticking, and the contact discovered that the center of the steering wheel was cracked and peeling. No warning lights were illuminated. The vehicle was taken to a dealer to be diagnosed; however, the cause of the failure was not yet determined. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 58,997.

On 8/22/2026, my 2022 Tesla Model Y Long Range with approximately 81,000 miles developed an Electronic Power Assisted Steering (EPAS) fault immediately after I felt a brief jerk while reversing. The vehicle displayed “Steering assist reduced / Steering may require increased effort.” Manual steering currently feels normal, but Full Self-Driving/Autosteer and Lane Departure/Lane Keeping functions became unavailable. Tesla Service Mode shows repeated faults EPAS3P_a072_motFeedFwdError, EPAS3P_a049_piCtrlError, and UI_a020_SteeringReduced. For EPAS3P_a072, Tesla’s diagnostic screen describes a “Motor control feed-forward correlation error,” lists the potential impact as “Reduced steering assist and EAC inhibited,” and specifically lists “Replace EPAS” as the clear condition. The faults return after vehicle power-off and reboot. The vehicle was updated to software 2026.21.6 / FSD v14 Lite approximately two weeks before this occurred. There were no previous steering warnings. I am not claiming the update caused the failure, but I believe the timing warrants investigation. NHTSA Complaint 11749826 describes a 2021 Model Y with the same EPAS3P_a072 and UI_a020 faults, including Tesla Service Mode stating “Replace EPAS.” Complaint 11758026 describes another 2021 Model Y steering gear failure and requests expansion of Recall 25V-092 to earlier Model Ys. My vehicle has not yet been physically inspected by Tesla. The vehicle and diagnostic information are available for inspection. I requ

The contact owns a 2022 Tesla Model Y equipped with Michelin Tires, Tire Line: Michelin Pilot Sport, Tire Size: 255/35/ZR21, DOT Number: (N/A). The contact stated that while driving 65 MPH, the rear driver’s side tire experienced a blowout. The contact was able to safely pull off the roadway and wait for towing assistance. The local dealer was contacted. The vehicle was towed to American Depot Tires. The contact stated that all four tires were replaced, and the vehicle was repaired. The contact stated that the inner tread of the front tires were prematurely worn, and the vehicle required an alignment every three months instead of every six months. The manufacturer was notified of the failure and informed the contact to take the vehicle to the dealer and have the vehicle repaired out of pocket. The failure mileage was approximately 99,482.

2022 Tesla Model Y - Premature inner rear tire wear due to excessive negative camber from factory. Both rear tires worn to cords on inside edge at 17k miles, outside tread 6/32 still. Alignment specs show rear camber out of spec caused by short factory rear camber arms. This is a known defect, creates blowout risk at highway speed. Vehicle never modified, never in accident. Mileage 113,136. I have photos. Bronx NY.

The rear lift gate will not close. Defective hinges and electrical strut causing miss alignment and inability to close.

On Aug. 9, 2026, my 2022 Tesla Model Y experienced a sudden low-voltage electrical failure that completely immobilized the vehicle. Earlier that morning, the Tesla app sent a push notification indicating low-voltage battery service was needed. I tapped it, but it provided no actionable warning. I immediately checked Maintenance. At 9:06 AM, the app displayed “0 Recommended” and “No maintenance is recommended for your vehicle at this time.” Less than an hour later, the vehicle completely failed. Nothing functioned. We could not open the doors or trunk, access the vehicle normally, or operate vehicle functions. The vehicle could not be put into a condition for normal towing; it would have had to be dragged/pulled onto the tow truck. Tesla later documented “Electrical system is unable to support all features” and is replacing the 12V battery. This may be relevant to NHTSA PE25010.

--torn bushings on both the lateral and compliance links --my understand is that torn bushings, if they completely failed, could cause a wheel to lose its rigid control causing the control arm to shift wildly, causing severe steering wander, loud clunking noises over bumps, unstable braking, and rapid, uneven tire wear. In worst-case scenarios, it can lead to a sudden loss of vehicle control and at worst cause an accident --also, this can also cause alignment issues and excessive tire wear--in my case, the torn bushings caused the front tires to chunk --three dealerships, including Tesla, confirmed the issue, including that it likely impacted the alignment and tires --the earliest symptoms were uneven tire wear: 1) all four tires from my first set were chunking and had to be replaced; 2) the front two exhibited the same chunking and have yet to be replaced

The Autopilot/FSD computer (driver-assistance ECU) on my 2021 Model Y (HW3) began failing intermittently on August 2, 2026, days after installing a software update -FSD v14 "Lite" branch. The component is in the vehicle and available for inspection. While driving at highway speed in high ambient temperatures (112–125°F), the system repeatedly disengaged with "Cruise control unavailable" (alert DI_a175) and "System error — take over immediately" warnings, and later alert APP_w46u on FSD engagement. Failures included: FSD and Autosteer aborting within seconds of engagement or disappearing from the menu entirely; complete loss of driving visualizations (no lane lines or vehicle overlays); rear camera blacking out; loss of speed-limit recognition and automatic turn-signal cancel. Both FSD and Autosteer Beta failed identically, indicating the fault is in the shared Autopilot computer/camera pipeline, not one feature. Because the same camera/compute stack supports automatic emergency braking, forward-collision warning, and blind-spot warning, the status of those safety systems during the failures is UNKNOWN — I had to complete long desert highway stretches fully manually, with repeated unrequested hand-backs of control creating a sudden-takeover risk. The fault is thermal-load related and intermittent: it recurred at high ambient temperatures, sometimes recovered after a rest or power-off reset, but on August 4 one full power-off reset at 88°F ambient failed to restore the system (

I am reporting a serious safety issue involving severe, difficult-to-detect inner-edge tire wear on my Tesla that resulted in a tire failure on Highway 101. The tire failed while I was driving on the highway, creating a dangerous situation and significant traffic disruption. After the failure, I discovered severe wear concentrated on the INSIDE edge of the tire. The concerning part is that the normally visible tread appeared serviceable. An owner can therefore believe the tire is safe while the difficult-to-see inner portion may be dangerously worn. I am concerned that Tesla’s suspension/alignment geometry, including camber/toe settings, vehicle weight, or related components may contribute to excessive inner-edge tire wear. NHTSA should investigate whether this is occurring on other Tesla vehicles and whether owners are being adequately warned to inspect the entire tire, particularly the hidden inner shoulder. I also experienced a very concerning mileage discrepancy. My vehicle showed approximately 36,000 miles before traveling to Tesla for service. During the trip to the dealership, the mileage associated with my vehicle appeared to increase to approximately 56,000 miles. Tesla subsequently referenced the higher mileage in connection with service/maintenance coverage. I request that NHTSA investigate whether Tesla vehicles have a pattern of excessive hidden inner-tire wear capable of causing sudden tire failures; whether suspension, alignment, camber, toe, vehicle weight, or

Tesla released a new version of FSD: 2026.20.6.11 V14 Lite for my 2022 Model Y Long Range. I installed it overnight and the next morning, several systems become intermittent. The backup camera stopped working immediately, and FSD would drop out, with the message "Take control immediately". I would then lose traffic visualization and other advanced features. Eventually the system would recover and start the cycle all over again. Several times per drive. I took the car to the dealer and they diagnosed it as a failed HW3 computer. The cost to repair it was $2,939 out of pocket since my car was 2 months out of warranty. The car was 100% functional before the V14 Lite update. The dealership denied the problem was related to the update, but the internet now has numerous instances of this problem, and attribute it to the computer running much hotter under this new update, causing components to fail. Our update was installed while the car was in our garage at a temperature in the 70’sF and immediately caused the computer failure before the car even left the garage. I requested and was given the failed computer in case any independent investigation is needed

During normal driving on roadway the vehicle pulled to the left and driver was not able to steer right to avoid travelling into oncoming traffic and struck another vehicle from opposing traffic. The vehicle gave no notice prior and was not in automatic mode.

While operating my 2022 tesla model y, the vehicle suffered a catastrophic hardware failure of the onboard vehicle control computer. This total computer failure resulted in an immediate, sudden loss of electronic power steering assist while the vehicle was in motion. The steering wheel became incredibly stiff and heavy, creating a severe and hazarders driving situation. the vehicle was towed to a tesla service center, where technicians confirmed the onboard computer hardware requires a complete replacement. A vital computer failing prematurely on a 2022 vehicle presents an extreme safety risk of crash or injury due to sudden loss of vehicle control.

I took my Vehicle to Tesla service for battery not charging. Service did a vehicle inspection and noted the following Concern: Upon Vehicle inspection, Found front suspension control arms worn and at a charge to me repaired with the below notes.. Repair Notes: Correction Links - Lateral - Lower - Front - Pair (Remove & Replace) - Remove and Replace ALSO repaired Correction Links - Compliance - Lower - Front - Pair (Remove and Replace) - Remove and Replace

The bushings on my vehicles front suspension completely failed at 47k miles and required replacement. The vehicle was under warranty and the manufacturer replaced them free of charge, but I'd heard that this component is being investigated. To be clear, the front lower lateral links and compliance arms all had to be replaced.

The car started having a lound clicking sound while making a right turn while I exit from my workplace garage. I started driving home and I was on the freeway and suddenly got an alert from the car saying I need a wheel alignment check. I drove slowly and arrived home. When I was making a turn on my drive way to the garage, I again heard a loud clunk and the car front side appears to be elevated and stopped moving. I went out and saw the left front driver's side looks weired and saw a large bolt on the driveway. I immeditely called my neighboor who is a car repair guy and he found out the suspesion is detached. I have attached the bolt that fell out of the suspension. My neighbor fixed but it was ultimately sent to Tesla for a full repair on March 23rd, 2026.

I was driving at approximately 30-35 mph on a 30 mph residential road with my son in the front passenger seat. My vehicle unexpectedly collided with a parked, unoccupied car on the right side of the road, impact occurring between my front passenger side and the rear driver side of the parked vehicle. Following the initial collision, the vehicle continued past a small tree, mounted the sidewalk, and struck a second parked car before I was able to manually bring it to a stop 2–3 houses further down near an intersection. Throughout this sequence—with the vehicle traveling at ~35 mph—neither the Automatic Emergency Braking (AEB) activated nor did any airbags deploy. Fortunately, neither my son nor I sustained catastrophic injuries, though my chest struck the steering wheel during the impact, causing ongoing pain my and mental trauma for my son. I am currently receiving medical advise. Given the speed and sequence of impacts, it is terrifying that the vehicle’s primary safety systems failed to engage before, during, or after the collision. I am seeking a thorough technical investigation into why Automatic Emergency Braking and airbag deployment failed in this scenario with Tesla Model Y

FSD failed when on FSD to go to local Walmart, in Walmart parking lot while on FSD, vehicle was parking it self by backing up and it hit shopping cart rack. It failed to see physical shopping cart rack and stop and park. It could have hurt someone if someone was there, software and 3 cameras didn’t avoid the accident.

The contact owns a 2022 Tesla Model Y. The contact stated that while the vehicle was operating in the self-driving feature, the vehicle bumped into a shopping cart holder while attempting to park into a parking space, prompting the contact to take control of the vehicle. The rear bumper on the driver's side was impacted. No property damage was reported. The vehicle came to a complete stop upon impact. No air bag was deployed. There was no warning light illuminated. A Police report was not filed. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 32,074.

I was backing out of my residential driveway when I suddenly noticed the steering wheel required much greater effort than normal, indicating a loss of power steering. There were no prior warning messages or symptoms before this event. As I began driving, multiple warnings appeared on the display, including “Steering Assist Reduced,” “Stability Control Disabled,” “Traction Control Disabled,” and “Vehicle Hold Unavailable.” The steering immediately became extremely heavy, making the vehicle difficult to maneuver safely. Because the failure occurred without warning, I did not feel it was safe to continue driving except to move the vehicle as necessary. The vehicle was subsequently inspected by a Tesla Service Center, which confirmed that the steering rack and Front Vehicle Controller required replacement. The repair was performed by Tesla after diagnosis. I am submitting this report because a sudden loss of steering assist without any prior warning presents a significant safety risk. Although this occurred while pulling out of my driveway, the same failure could occur while a driver is traveling at higher speeds or in traffic, where maintaining control of the vehicle could be much more difficult.

**Incident Report — Tesla Model Y Safety System Failure** The subject vehicle, a Tesla Model Y equipped with Full Self-Driving (FSD) technology and advanced safety features, was involved in a collision at an estimated impact speed of 40–45 MPH. The vehicle's onboard recording system captured the incident and clearly documents the impact dynamics, vehicle speed at impact, and the contributing actions of the other party involved. **Incident Details:** - **Impact Location:** Left front side of vehicle - **Impact Speed:** 40–45 MPH - **Damage Assessment:** Vehicle declared total loss by insurance - **Recorded Evidence:** Onboard system footage available **Safety System Failures:** Despite the severity of the impact and speed involved, the following safety systems failed to activate: - Emergency braking system did not engage - Forward Collision Warning Failed - Seatbelt pre-tensioning/locking mechanism did not activate - Airbag deployment systems failed (front, side, curtain, and knee airbags) **Concern:** The vehicle's advanced safety features—which are primary design components marketed for collision mitigation—did not function as designed or expected. Given the impact speed and severity, these safety systems should have either mitigated the collision or deployed to protect occupants. The failure of multiple redundant safety systems raises questions regarding the reliability and function of these critical systems at the time of impact. **Available Evidence:** - Onboard system fo

As a 100% T&P Disabled Veteran relying on advanced driver-assistance for mobility, I purchased a 2022 Tesla Model Y Performance with Hardware 3 (HW3), which was actively advertised and sold as possessing all necessary hardware for safe, autonomous operation. In practice, the vehicle suffers from safety-critical driver-assist defects—including unexpected disengagements and erratic system choices—due to fundamental HW3 processing and memory bandwidth limitations. Operating a vehicle marketed as autonomy-ready, but constrained by hardware incapable of handling complex traffic scenarios safely, forces constant manual intervention and creates an unacceptable collision hazard for a disabled driver.

The passenger-side (right) headlight assembly suffered an internal mechanical failure and is stuck aimed too high. It cannot be calibrated or lowered to factory specification. This poses a severe safety risk by blinding oncoming traffic at night. The vehicle was inspected by a manufacturer service center on July 13, 2026. The factory technician confirmed in the official service notes that the right-side headlight is 'internally faulty and will not lower the headlight height to specification,' requiring a full assembly replacement. This is the second time this exact OEM component has failed under normal use; the entire assembly was previously replaced for a failure just over two years prior. No external damage, collision, or impact caused this internal mechanism to fail.

The contact owns a 2022 Tesla Model Y. The contact stated that while pulling in and out of a driveway, and while coming to a stop or driving from a stop, the vehicle made an abnormal sound that became louder over time. No warning lights illuminated. The vehicle was taken to the service center, where it was diagnosed and determined that the front driver’s and passenger’s side upper control arms had failed. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure. The failure mileage was approximately 50,000.

Tesla Y on the freeway, FSD on(Full Self Driving), driving at 70 mph. I saw the cars ahead are slowing but my car was not slowing, so I braked and held the steering wheel firmly. However, my car still hit the car in front at 36 mph. The airbag deployed and luckily I only sprained my thumb in both hands in holding the steering wheel very hard. If I didn't take over my car would have hit the car in front at 70 mph. I downloaded Tesla "Vehicle Data Report" and it shows that the "FSD was active, Cruise Control State was active, Driver Monitoring Detection was detected and I applied the brake. I used FSD for over 3 years and no problem at all, until the accident. The Tesla Data shows that the FSD malfunctioned that caused the accident but my insurance told me that it was my fault and they increased my insurance for $227 a month.