2022 Tesla Model X

Defect. Tesla, Inc. (Tesla) is recalling certain 2017, 2021-2023 Model 3, 2020-2023 Model Y, 2021-2023 Model S, and Model X vehicles operating software version 2026.8.6. The rearview camera image may be delayed when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk. A delayed rearview image reduces the driver's view behind the vehicle, increasing the risk of a crash.

Remedy. Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed July 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-00-001.

Defect. Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model S and 2021-2025 Model X vehicles. An air bag with the incorrect horn pad may have been installed, preventing the horn from sounding.

Risk. An inoperative horn may prevent the driver from alerting other drivers, increasing the risk of a crash.

Remedy. Tesla service will inspect and install an air bag with the correct horn pad as necessary, free of charge. Owner notification letters were mailed May 20, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-20-001.

Defect. Tesla, Inc. (Tesla) is recalling certain 2021-2025 Model S and Model X vehicles. The driver's air bag could tear during deployment. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 208, "Occupant Crash Protection" and 212, "Windshield Mounting."

Risk. A torn air bag may not adequately protect an occupant in a crash, increasing the risk of injury.

Remedy. Tesla service will replace the air bag assembly, free of charge. Owner notification letters were mailed February 21, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-20-001.

Defect. Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model 3, Model S, Model X, and 2020-2024 Model Y vehicles. The hood latch assembly may fail to detect an unlatched hood condition after the hood has been opened.

Risk. An unlatched hood can fully open, obstructing the driver's view and increasing the risk of a crash.

Remedy. Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed September 24, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-012.

Defect. Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk. A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.

Remedy. Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.

Defect. Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."

Risk. Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.

Remedy. Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.

Defect. Tesla, Inc. (Tesla) is recalling certain 2021-2023 Model S and X vehicles. The cabin doors can be unlocked during a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."

Risk. An unlocked door may unlatch and open during a crash, increasing the risk of injury.

Remedy. Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 17, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-009.

Defect. Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.

Risk. In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.

Remedy. Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.

Defect. Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model S and Model X vehicles. An incorrect air bag may have been installed when the steering yoke or round steering wheel was replaced with a different style of yoke or steering wheel.

Risk. An air bag that is not designed to function with the replacement steering yoke or wheel may deploy incorrectly, increasing the risk of injury during a crash.

Remedy. Tesla Service will inspect and replace the driver air bag as necessary, free of charge. Owner notification letters were mailed January 2, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-20-005.

Defect. Tesla, Inc. (Tesla) is recalling certain 2021-2023 Model X vehicles. The vehicle controller may fail to detect low brake fluid and will not display a warning light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."

Risk. Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.

Remedy. Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed December 12, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-005.

Defect. Tesla, Inc. (Tesla) is recalling certain 2021-2023 Model S and Model X vehicles. The front-row seat belts may not be connected properly to the pretensioner anchors, which can cause the seat belts to detach.

Risk. A detached seat belt may not properly restrain an occupant during a crash, increasing the risk of injury.

Remedy. Tesla Service will inspect the front-row seat belts and connect the seat belts to pretensioner anchors, or replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed September 12, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-20-004.

Defect. Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.

Risk. FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.

Remedy. Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.

Defect. Tesla, Inc. (Tesla) is recalling certain 2021-2023 Model X vehicles. The restraint control module (RCM) calibration may cause the front passenger air bag to deploy incorrectly during certain low speed crashes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk. A passenger air bag that does not deploy as intended increases the risk of injury during a crash.

Remedy. Tesla has released an over-the-air (OTA) software update to recalibrate the RCM, free of charge. Owner notification letters were mailed January 14, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-015.

Defect. Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."

Risk. A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.

Remedy. Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.

Defect. Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S, Model X, and 2022 Model 3 and Model Y vehicles operating certain firmware releases. The infotainment central processing unit (CPU) may overheat during the preparation or process of fast-charging, causing the CPU to lag or restart.

Risk. A lagging or restarting CPU may prevent the center screen from displaying the rearview camera image, gear selection, windshield visibility control settings, and warning lights, increasing the risk of a crash.

Remedy. Tesla will perform an over-the-air (OTA) software update that will improve CPU temperature management, free of charge. Owner notification letters were mailed July 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-009.

Defect. Tesla, Inc. (Tesla) is recalling one 2022 Model X vehicle. A body structure reinforcement bracket was not installed at the second-row seat. As such, this vehicle fails to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 207, "Seating Systems" and 210, "Seat Belt Assembly Anchorages."

Risk. The second-row seat may not properly restrain occupants during a crash, increasing the risk of injury.

Remedy. Tesla will replace the vehicle, free of charge. The recall was completed April 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752.

Defect. Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."

Risk. Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.

Remedy. Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.

Defect. Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model X vehicles. The left or right front-row side curtain air bags may not deploy as intended when the windows are lowered. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 226, "Ejection Mitigation."

Risk. Improper side curtain air bag deployment can increase the risk of injury during a crash.

Remedy. Tesla Service Centers will replace the left and right front-row side curtain air bags, free of charge. Owner notification letters were mailed July 16, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-003.

Defect. Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."

Risk. Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.

Remedy. Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.

Defect. Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model 3, Model S, Model X, and 2020-2022 Model Y vehicles. A software error may cause a valve in the heat pump to open unintentionally and trap the refrigerant inside the evaporator, resulting in decreased defrosting performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."

Risk. Decreased defrosting performance may reduce the driver's visibility, increasing the risk of a crash.

Remedy. Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-18-002.

Defect. Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk. The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.

Remedy. Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.

Defect. Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.

Risk. Failing to stop at a stop sign can increase the risk of a crash.

Remedy. Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.

The driver-side liner from a WeatherTech Custom Fit FloorLiner first-row set, part 4416821, installed in a 2022 Tesla Model X Plaid bowed outward near the accelerator pedal. The set was purchased through Amazon on June 14, 2026, and sold by WeatherTech. On two separate occasions, I pressed the accelerator and it would not move normally because it caught against the bowed liner. When I pressed harder, it released and the vehicle surged forward abruptly. No one was in front of the vehicle, and I stopped without a collision. My wife was frightened by the sudden movement and did not initially understand what happened. We identified the liner interference, removed the liner and notified WeatherTech. My wife had also reported similar interference on earlier occasions. I reported the problem to WeatherTech on October 3, 2026, with a photo and video link. A representative confirmed receiving the photo, stated there was a known Tesla fitment issue and provided seating instructions. By October 17, I had received a replacement, which also bowed outward and contacted the accelerator. On October 17, I reported the recurrence and explained that I had cut away the interfering portion. This modification does not establish that the liner is safe or resolve the repeated problem. The liner interference created a risk of unintended acceleration and collision. Whether a dealer or independent service center reproduced or confirmed it is UNKNOWN. Physical inspection by the manufacturer, police, ins

Dear NHTSA Safety Investigation Team, I am filing an urgent safety complaint regarding dangerous and premature inner-edge rear tire wear on my 2022 Tesla Model X. I have already been forced to replace five tires due to excessive inner-edge wear, which I believe is caused by improper rear suspension camber. Despite repeatedly raising this concern, Tesla has failed to provide a permanent solution. This is a critical safety hazard, not routine tire wear. The damage occurs on the inner edges of the tires, making it difficult to detect and creating a serious risk of sudden tire failure, loss of vehicle control, and potentially catastrophic highway accidents. Similar complaints from other Model X owners suggest a possible widespread suspension-related defect. I strongly urge NHTSA to investigate the 2022 Tesla Model X rear suspension design and determine whether an immediate safety recall or mandatory corrective action is warranted before lives are lost. Sincerely, [XXX] [XXX] [XXX] 2022 Tesla Model X Owner INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The left and right turning signal buttons work intermittently. I would tap on the buttons but they would not turn on the corresponding signal for other drivers to see. I would tap on the buttons multiple times if the initial press fails, but that does not help. I usually resort to turning on the hazard lights and slowly make the needed vehicle turn. This is a hazard to myself, my occupants, and all driving around me.

I own a 2022 Tesla Model X. I began noticing a creaking/clicking noise from the front steering/suspension area, particularly when turning the steering wheel at larger angles and at low speeds. I brought the vehicle to a Tesla Service Center for inspection. Tesla inspected the vehicle and diagnosed a bent steering rack/steering component. Tesla recommended replacement of the complete steering gear assembly, along with repairs to front suspension components. Tesla provided photographs of the condition and stated in writing that bending this component would require approximately 4,000 to 6,000 pounds of force at a specific angle. Tesla attributed the condition to an external impact. However, I am not aware of any accident, collision, curb strike, significant pothole impact, road-debris strike, or other event that would explain this condition. There were no crash-related warning messages or known impact events preceding the steering symptoms. The first symptom I noticed was the creaking/clicking noise during low-speed steering. I am concerned because the steering system is safety-critical and I do not know when, how, or why the steering component became bent. A damaged or bent steering component could potentially affect steering control, alignment, or vehicle handling if the condition progresses. Tesla has physically inspected the vehicle and confirmed the condition. The recommended steering and suspension repairs have not yet been performed, so the vehicle and the affected compo

CRITICAL FLUIDITY/ACCESSIBILITY DEFECT The vehicle lacks a standard mechanical horn assembly, instead it is equipped with a small electronic button. This configuration creates a severe safety hazard due to the following critical failure points: High-Stress Unusability: The button is highly difficult to locate during an unfolding emergency, causing a dangerous delay in driver reaction time. Loss of Function During Maneuvers: When the steering wheel is actively turning, the button's position shifts constantly, making it physically impossible to find or press reliably while evasive steering is underway. Failure to Warn: This design directly compromises the driver's ability to sound an immediate audible warning, drastically increasing the risk of an unavoidable collision.

The power steering fails very often making it hard to turn and happens when I’m on the highway going 60+ mph which is very dangerous and a threat to my safety. The only way to fix it in those moments is to pull over turn the car off which consists of me getting out of my vehicle and waiting two minutes. But usually when it happens once that day it occurs all day even if I reset the car and try all the other troubleshooting options which make it very difficult to rely on the car for safety. It happened only once every few months but now it happens almost every other time I drive my car. This is not a normal wear and tear issue as I’ve had cars before with over 50k miles and not once have I had a power steering failure on those cars which are older and have more mileage.

I was in the car. I had put on my seat belt and reached back to plug in my phone to charge. Before I turned back the phone accelerated forward and crashed into two cars in the parking lot.

I am reporting several safety concerns based on approximately one year of experience using Tesla Full Self-Driving (FSD). Primary Event: Between February 23 and February 28, 2026, while traveling northbound on the NJ Turnpike with FSD engaged, the vehicle accelerated to approximately 95 mph in a 65 mph. The acceleration appeared unexpected and excessive for the traffic conditions. I disengaged FSD and immediately took control of the vehicle to reduce speed and continued driving manually.No collision occurred, but I considered the event a safety risk because the vehicle exceeded the posted speed limit by a substantial margin. Additional Observations: 1. On multiple occasions, FSD appeared not to recognize or comply with “NO TURN ON RED” traffic signs.2. Situations where overhead or elevated traffic signs appeared not to be recognized by the system.3. On one occasion, the vehicle navigated toward railroad tracks where the roadway and tracks intersected at an approximate 45-degree angle. The vehicle behavior caused concern.4. When driving directly into bright sunlight, particularly when the sun is low and shining directly into the windshield, FSD performance appears degraded or confused. Human drivers typically use sun visors and other visual cues in these conditions. The vehicle’s driving behavior appeared less predictable during such events. 5. Lane changes are attempted across areas marked by continuous lane where lane change would not normally be expected. Additional Concern

As I was driving the Tesla Model X, I received a steering assist reduced error on the dash. There was no immediate noticeability, but after about 5 minutes, it felt like there was ZERO power steering, with no additional warnings in the car. With zero power steering, car required extreme forces required to get to the shoulder. If attempting any kind of turn, car would require forces in excess of 80lbs of pressure to execute. Once safely in a parking lot, I put the car into SERVICE mode to check the errors. There was an EPAS error, where it said Torque Sensor 1 not receiving, along with a Torque Sensor 2 not receiving. This has occurred to me 3 times, in the 3 years I've owned the car. Other than "Steering assist reduced", there is no other warning that the car's EPAS steering system reverts to just manual forces required to steer a car. I do not trust my wife to drive this car, as she would not have the strength necessary to get the car to a safe location. If this happened while turning, there's a strong possibility the car would not turn at all, a huge safety factor.

The steering wheel locks periodically and I have to get out and re enter my car. On long drives it works pretty fine and does not do this much on highways only once but in hotter weathers it seems to be much much worse. This happened once before the warranty but I did not think much of it. In one instance the steering wheel was so tight that it hurt my wrist while getting off the road

The primary front trunk (frunk) latch mechanism fails to unlatch on the first attempt, requiring multiple actuations to open. When I brought the vehicle to the manufacturer's official service center to have the defective safety latch inspected and repaired, they confirmed the behavior but refused to fix the underlying hardware. Instead, the service center officially documented on my repair invoice that this latch failure is "frequently present and deemed a characteristic of the vehicle." A malfunctioning, binding, or misaligned front trunk latch poses a severe safety risk. If the primary latch is failing to release properly, it indicates a defect in the retention mechanism that could lead to the hood unexpectedly opening, flying up, and obstructing the driver's vision at highway speeds (a known issue that has caused recalls in the past). The manufacturer's refusal to repair a failing primary safety latch, and instead documenting it as a normal "characteristic," leaves a critical safety component in a compromised and dangerous state. There were no warning lights prior to this failure; it is a physical, mechanical defect that the manufacturer has acknowledged in writing but refuses to remedy.

The failure involves the rear suspension system, specifically suspected rear control arm / suspension linkage play, which caused severe misalignment (rear toe out of specification). The vehicle is available for inspection upon request. This defect created a significant safety risk. The abnormal toe condition caused rapid and uneven tire wear, with both rear tires becoming nearly completely bald within less than 7,000 miles. This condition increases the risk of tire blowout, loss of traction, and potential loss of control at highway speeds. The issue has been confirmed by an independent service center (Les Schwab), which documented suspension play in the rear control arm area and alignment out of specification (rear toe approximately +1.20° total). The alignment could not be maintained, indicating an underlying mechanical issue. Tesla inspected the vehicle but stated that no suspension components required replacement and attributed the issue only to alignment. However, alignment does not go out of specification without a mechanical cause. Despite multiple requests, Tesla refused to provide detailed documentation regarding the inspection or repair of the suspension system. They replaced only one rear tire and did not address the root cause. The other rear tire had already worn completely bald. After approximately 5,386 miles, the replacement tire has again worn down close to the minimum safety limit, demonstrating that the underlying issue was not corrected and continues to aff

Lost power steering while I was driving multiple time and I couldn't turn. Later the alert also come on and off but sometime the steering is fine. Found out on Tesla Model X facebook group people are having the same issues.

The electric power assist steering system on my 2022 Tesla Model X began displaying a "Steering Assist Reduced / Steering May Require Increased Effort" warning intermittently beginning in approximately May 2024, shortly after I purchased the vehicle. This warning appeared more times than I can count over the following months. In most instances the warning appeared but the steering continued to function normally. On approximately March 2, 2026, the warning appeared and for the first time the steering became extremely difficult to turn, requiring significantly increased physical effort to control the vehicle. The first physical failure occurred while parking at low speed in reverse. The steering failure also occurred subsequently while driving at highway speeds. In both instances I stopped the vehicle, exited, waited briefly, and upon re-entering the vehicle the warning cleared and steering returned to normal. This same sequence repeated the following day. The vehicle was brought to a Tesla authorized service center on March 13, 2026. Tesla's technician confirmed the steering assist reduction as reported and determined the steering gear required full replacement. The failed part, steering gear left hand drive part number 1070801-00-F, was replaced. Only full hardware replacement resolved the issue permanently. Prior power cycling provided only temporary relief. My safety was directly at risk. I am a full-time rideshare driver operating at highway speeds. The failed component ha

While driving my 2022 Tesla Model X at highway speed, I experienced a sudden loss of steering assist shortly after Supercharging. The steering wheel became extremely difficult to turn, and I had to use significant force to maintain control. The vehicle displayed a ‘Steering Assist Reduced’ alert, FSD became unavailable, and the suspension behaved unexpectedly. After the incident, the vehicle was taken to Tesla service. At this time, I have not received a clear explanation of the root cause of the steering‑assist loss. Because this event occurred at highway speed and created a safety concern, I am submitting this report so the incident can be documented and reviewed.

On January 31, 2026, at 10:30 PM, I was driving from Fort Lauderdale to my home in Boca Raton, Florida. I was using FSD supervised mode. Close to my home, a big red image suddenly appeared, the car started accelerating fast, and I had no control over the car or its steering wheel. The car hit several electrical posts and only stopped after the airbags engaged. My wife was in the passenger seat. The front of the car was totally damaged, and I will have to total it.

I am writing to formally document a life-threatening mechanical failure involving my 2022 Model X on January 30, 2026. While my wife was operating the vehicle, it suffered a simultaneous and catastrophic collapse of all primary safety systems. During operation, the vehicle experienced a total loss of steering and braking control. This was accompanied by a rapid cascade of critical system alerts on the primary display, including “ABS Malfunction,” “Stability Control Disabled,” and “Steering Assist Reduced/Disabled.” Most critically, the vehicle exhibited Sudden Unintended Acceleration (SUA), increasing speed in direct opposition to the driver’s physical application of the brake pedal. This resulted in a near-miss where the driver narrowly avoided a construction crew.

The turn signal buttons intermittently fail to work. Many presses of the tuen signal buttons do nothing. When it stops working it stops for several minutes and then will start to work again. The problem is happening more and more frequently. The yoke has been replaced 3 times already for the same issue and after about a year just started happening again.

Both front half shafts failed. I did research and this part is known to be substandard, was recalled in China, and remains a problem in the US.

My 2022 Tesla Model X has two recurring safety-critical defects that remain unresolved despite multiple repair attempts. 1. Airbag / Restraint System Failure (RCM2 / OCS Defect): The vehicle frequently misclassifies the front passenger seat. It shows a passenger when the seat is empty and activates passenger seatbelt warnings incorrectly. Recently the vehicle displayed: “Front passenger safety restraint system issue: Service required (RCM2_a064).” Tesla attempted to repair an electrical harness in the seat, but the problem returned. A Tesla technician documented that the seat may still need a new occupancy sensor. Because this affects the Occupant Classification System and airbag deployment logic, it raises potential FMVSS 208 compliance concerns. 2. FSD / GPS Safety Hazard (5 Unsuccessful Repair Attempts): Across five service visits, Tesla attempted to fix GPS drift and unsafe FSD routing. The vehicle still attempts incorrect turns, performs premature lane changes, and misinterprets intersections. One recent incident involved FSD attempting a left turn one intersection early, nearly causing a collision. Tesla replaced the GPS antenna, recalibrated cameras, and replaced the computer, but the unsafe behavior continues. These two defects—incorrect airbag/OCS behavior and hazardous automated-driving/navigation behavior—create a significant safety risk to occupants and other drivers. Both defects persist after repair attempts. I can provide service records, videos, and documentat

The vehicle presents a compounded safety defect creating a risk of passenger entrapment and high-voltage fire. 1. High Voltage Manufacturing Defect: On September 3, 2024, authorized Tesla Service technicians diagnosed a critical safety fault. The service record states technicians 'found A/C compressor HV harness was incorrectly routed, rubbing against the steering column' and 'found sand inside the connector'. Tesla repaired this defects under the 'Basic Vehicle Limited Warranty,' confirming it was a factory assembly error. This defect created an imminent risk of a high-voltage short to the steering column, which could result in driver electrocution or total vehicle power loss at speed. 2. Passenger Entrapment: The vehicle has a documented history of Rear Falcon Wing Door failure (7 repair attempts from April 2023 to May 2025). The doors frequently fail to latch or open. On July 8, 2025, the Left Rear Door failed to open due to a sensor fault. 3. Combined Hazard: If the incorrectly routed High Voltage harness causes a vehicle power failure, the rear doors' electronic latches will fail. Because the doors have a history of mechanical jamming, passengers in the rear seats would be trapped in a vehicle with a compromised High Voltage system.

I had my two Teslas parked in the garage. The model X was charging at about 1:30 AM. We heard explosions coming out of the garage. Went to check only to see my model X in flames. We evacuated and called 911 eventually a fire investigation report was made Showing the fire started within the vehicle outward. The battery pack was on fire. We had lithium contamination all over the house and this fire endangered five lives. This incident has been two years ago and until now Tesla refuses to acknowledge the faulty battery and is refusing to do anything about it

The wing-style door of the car closed while my 1-year-old daughter's leg was sticking out. It dragged her leg sideways as it closed, and he femur broke. None of the sensors worked, the door should have detected motion or pressure, but they did not and it resulted in my daughter's leg breaking.

As I was attempting to merge onto Interstate 75, I noticed that steering became unexpectedly difficult. Consequently, I decided not to enter the highway. I then crossed the highway and pulled into a parking lot, where I turned off the vehicle. Upon restarting the vehicle, the issue seemed to have resolved itself.

Got a warning notice on my dashboard that the passenger safety restraint system failed...ie the airbag.

" PASSANGER SAFETY RESTRAINT SYSTEM FAULT" IS THE WARNING MESSAGE POPPING UP ON THE DISPLAY WE NOTICED THAT THE WARNING LIGHT SOMETIMES GOES AWAY WHEN MOVING THE PASSANGER SEAT, WE FIRST TOUGHT THAT THIS WAS JUST A PROBLEM THAT WE MAY HAVE CAUSED BUT ONCE DOING REASERACH WE NOTICED THAT THERE ARE MANY ONLINE SCENERIOUS THAT HAVE THE SAME ISSUE "PASSANGER SAFETY REISTRAINT FAULT" WE DISSMISSED THE ISSUE WE TOOK IT TO TESLA SERVICE IN JACKSONVILLE FLORIDA THEY MENTIONED THAT SOME WIRE PIN HAD CAME LOOSE WHICH WE THOUGHT WAS ODD SINCE WE HAVE OWNED OVER 20 VEHILES AND WE HAVE NEVER HAD THIS ISSUE WITH ANY OTHER MANUFACTURE. WE WERE CHARGED 300+ DOLLARS FOR THEM TO FIND THEB EXCAT PIN/ WIRE THAT CAME LOOSE. WE ALSO HAVE A 2020 TESLA MODEL 3 STANDER RANGE, WE RECENTLY HAD THE SAME ISSUE AND THE WARNING LIGHT IS CURRENTLY ON AND GOES AWAY IF WE MOVE THE PASSANGER SEAT. I HAVE COME TO CONCLUDE THAT THIS IS A MANUFACTURE DEFECT THAT CAN BE A SERIOUS ISSUE IF AIR BAGS ARE NOT PROPERLY WORKING CAUSING SERIOUS INJURY TO PASSANGERS IN THE VEHICLE I WILL ATTACH THE VIN OF OUR 2020 TESLA MODEL 3 STANDER RANGE [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Suspension Design and Negative Camber: Rear tires have huge inner wear when wires are visible after few thousands miles. Changed tires 3 times already within 14k miles. Current miles is 18,200, but 1st time it happened in Aug 2022 when miles were 4200.

UNKNOWN

This vehicle suffered a flat tire on the left rear at 20,000 miles. It was discovered that the tire had worn out on the inside prematurely due to a faulty negative camber alignment. The other tire on the right rear was examined and found to be worn down to the treads on the inside as well. I informed Tesla and they said this is normal for the make and model. You cannot see the inside of these tires during a normal walk around inspection. Tesla says that the problem cannot be fixed. I could have suffered a tire failure at high speed which could have been catastrophic. Tesla just says its unfortunate and you have to live with this issue. i consider this to be a very unsafe issue that Tesla should address at their expense. This car is under warranty and Tesla refused to repair the car.Tesla did not divulge this issue to me prior to purchasing the vehicle.

My car is been vibrating and shaking for over a year now, and everytime I took it to certified Tesla service, they brought it back to me telling me they can't feel anything, and that there is noting to fix. After the fifth time, they suddenly tells me that I got into a hole in the road and that is why it's shaking, also, the car had a message on the screen saying that the air pressure can't lift the vehicle, and it made a huge noise, I had to call a tow truck to take it to Tesla center. NOW, they are telling me that a mouse ate the hose, and that will cost me $9000. I can't pay that much money, and it's not OK. Can you please contact me as soon as possible and help me solve this problem? Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

To Whom It May Concern, I am writing to inform you of a recurring issue I am experiencing with the power steering in my 2022 Model X Plaid. This problem began on [XXX] and has progressively worsened. Initially, the power steering would function normally for approximately 30 minutes of driving. It would work fine when starting in the morning or when the car was cool. However, after driving about 15 miles, the power steering would completely fail, and a warning message would appear indicating that extra effort was required. Recently, the power steering now fails every time I drive. Based on my research, this appears to be a common problem with Tesla vehicles, and I understand a recall has been issued for some model years, although not for the year of my vehicle. I intend to have this issue addressed and repaired through Tesla service. However, I wanted to make you aware of this problem as it seems to be a known issue that is now affecting my 2022 X Plaid as well. Thank you for your time and attention to this matter. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving my Model X 2022 I noticed the warning "Steering assist reduced, Steering may require increased effort". I was then at a red light and I started to make a left turn and I could BARELY turn the wheel it was like it was almost locked up. Luckily I had enough strength and I was driving into a parking lot where I needed to have my car towed. Tesla service just said there was moisture in the steering wheel connector and they just cleaned it up and connected it. They test drove it and said it's fine. 4 days later I was driving it on the highway and I got the message again and I had my daughter in the car and was terrified. Luckily the steering did not lock up and just drove it home. I have messaged Tesla to see next steps, but when I look at the forums this has been happening A LOT! This is a huge safety concern and I don't feel Tesla is properly handling it based on all the reviews I have read...

The contact owns a 2022 Tesla Model X. The contact stated while his wife was driving 25 MPH, the passenger’s side rear-view mirror exploded. No warning light was illuminated. The contact stated that his wife parked and inspected the vehicle and confirmed that the side-view mirror had exploded. The local dealer was not contacted. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 16,035.

On September, 21 2024 I scheduled an appointment with the Tesla Service Center for the “Front Row Curtain Airbag” recall to be performed. October 30th, I took my 2022 Model X Plaid to the Tesla Service Center for the recall work to be performed. During the repair, their service technician BROKE-OFF an anchor nut that secures the airbag to the A-pillar. The advisor said in order to “fix” it they would need to take the car to a body shop to have a “new” anchor nut welded onto the A-pillar. I was told this repair would require cutting open the A-pillar to access the location where the nut should be welded. Cutting the A-pillar will compromise the structural integrity of the vehicle's roof. And retrofitting a new mounting point for the side curtain airbag will compromise the effectiveness of the airbag in the event of an accident. The manufacturer's airbag recall "fix" does not involve cutting open the A-pillar to weld in a new mounting point for the vehicle's airbag. Performing the airbag recall in this manner creates a greater safety issue for my vehicle. Therefore, this "recall repair" should not be allowed to be performed on my vehicle.

My Tesla stopped in the middle of a 4 way intersection without notice. As I was turning left, the car started to shake for about 2 seconds and then stopped. No warning or anything. The notification stated "electrical system unable to support functions." My safety was put at risk and others. I was traveling with my 11 month old and other cars could have hit my car if they were not paying attention when coming through the intersection. The car was towed to the Tesla dealership. No warnings prior to the failure. Warnings appeared after the car stopped.

I am writing to express a safety concern regarding the Tesla Model X. I have found that the location of the horn is difficult to identify and activate, especially during emergency situations where quick reflexes are critical. In high-stress scenarios, the horn is a vital tool for alerting other drivers and avoiding potential accidents. However, the current design of the Tesla Model X makes it challenging to quickly locate and press the horn button. This could lead to delayed response times, increasing the risk of collisions or other hazardous situations. Given the importance of this issue, I strongly urge Tesla to redesign the horn button to make it more intuitive and easier to access under duress. Additionally, I recommend that any modifications or improvements related to this concern be made available to all Tesla Model X owners free of charge. Ensuring that this safety enhancement is accessible to everyone will help protect Tesla drivers, passengers, and other road users.

I was getting a message on my display saying: Steering assist reduced Steering may require increased effort. But in reality, it requires all my strength, to turn the wheel. Very dangerous. Tesla charge to fix $4,100. I’ll have to pay it.

When applying the brakes the steering wheel vibrates and car has reduced stopping power. when I took it to Tesla service center they said the "rotor runout is out of spec" the car has 25k miles and new "performance pads" were installed by Tesla as an upgrade in December 2023. the shaking developed after this. Tesla says the rotors are a wearable part and not covered under warranty.

We bought the Tesla Model X as a CPO vehicle from Tesla on [XXX]. Within the first 2 months of driving the car we saw an an alert for “Steering assist reduced” and shortly after the steering wheel locked up making the car inoperable. This has happened twice while driving: [XXX] [XXX] This puts the driver and passengers at huge risk because the car was unable to turn while blocking a major intersection on [XXX] . We have taken in the vehicle in to Telsa Santa Barbara service center and they were unable to reproduce the issues so they did not make any fixes and returned the vehicle back in the same condition. There was a “Steering assist reduced” warning message to the driver before the steering wheel locked up. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

As I was making an unprotected left turn, the power steering failed. The steering became incredibly heavy. There was almost an accident. Feels unsafe to drive, will be towing to the dealership. Errors: Steering assist reduced, lane assist unavailable. Codes: EPAS3P_a005_sent2mia, torque sensor 2 signal not received.

I was stopped at an intersection in the left turn lane heading southeast at a busy intersection. Left turn signal was on and within 3 minutes of getting to the intersection the vehicle experiences an uncommanded full power acceleration into a very busy intersection. To avoid oncoming traffic, I veered to the right while breaking which did not stop the vehicle. Avoiding a traffic pole and continuing into a business empty parking lot which usually is not empty due to loitering in the area, and avoiding the building the vehicle continued accelerating at a high rate of speed and was stopped only because it hit a metal pole which was hidden by a large bush on the side of the business. If the pole would have not stopped the vehicle it would have continued into oncoming traffic in the north bound lane. Air bags were deployed. The only visible injury I received was burns from the airbag on my right arm and sever busing on my abdomen which has taken 4 months to resolve. The police were on the scene immediately, my insurance company representatives have seen the videos produce by myself and Tesla sent to me via email. The insurance had put a hold on the vehicle which was towed to Carparts. Tesla has never contacted me or my insurance company that I know of besides my request by email for the additional data. I have driven a Tesla model S for 7 yrs prior to purchasing the Model X. The Model X had an incident once that it stopped on its own while I was driving on an interstate. I veered

The location of horn small icon and not in middle of the steering wheel is very hard to locate when you need it and safety concerns. Several times I needed to use the horn in emergency but were not able to locate it when you are in sudden need. Thanks

Many newer models of Teslas do not include a horn in the middle of the steering wheel. Instead there is a small button on the left side which is impossible to find to warn others of a possible collision! The driver gets distracted trying to find the horn and makes the situation even worse by not reacting quick enough. They released a new version of the wheel with a horn but those who are out of warranty have to pay a large amount for a basic yet hugs safety oversight. They should be replaced on with recall free of charge.

The contact owns a 2022 Tesla Model X. The contact stated that while the vehicle was parked, the driver’s side rear passenger’s seat belt failed to release the child occupying the seat. The contact stated that after five minutes the seat belt was released. The contact then stated that while driving at approximately 20 MPH, with the front passenger and the driver’s side rear seats occupied, the restraint system fault for each passenger was displayed. Additionally, the contact stated that on several occasions while driving at various speeds, the messages appeared intermittently while both seats were unoccupied. The vehicle was taken to a dealer where it was diagnosed that a seat belt module needed to be replaced. The vehicle was repaired but the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 2,000.

The passenger side back door does not open consistently leading to loss of egress. Although the other doors do function regularly, removing a child from a car seat is nearly impossible when accessing from another door. The door also struggles to close consistently, and has closed on my son in the past. The inconsistency of a functioning falcon wing door is a safety risk and it continues to worsen despite many attempts to repair the sensors. The Tesla service center has attempted to repair the door and sensors 4 times without success. The most recent service appointment they stated the door was not opening correctly because it was getting stuck in “indoor mode” sensing something over the top of the car. They replaced the sensor but the problem has not improved. I have notified Tesla of the ongoing issue multiple times without any response, even via certified mail with proof of delivery. There are no warning lamps, beeps or any notifications showing an error in door function.

This vehicle has massive and unbearable static electrical shock when the car stopped and trying to close the door as metal body of the car. and I have several Videos showing the electric shocks The auto pilot stop the vehicle on the highway for no reason that’s put the passenger in serious rear collision

On more than one occasion lost power steering and ability to steer properly suddenly in mid drive. It is associated with a warning that comes on at random times saying steering assist reduced

The yoke steering wheel only had a small horn button on the right side, only accessible by right thumb. If you are in the middle of a turn that requires more than a quarter turn, then your hand cannot possible be in the right place to use the horn. The lack of a horn in the center of the steering (like every other car) is unsafe. On many occasions I have found myself needing the horn but unable to press it fast enough and have had to take other evasive actions to avoid other vehicles.

Center steering wheel horn is not included on these vehicles, which should be considered a significant safety issue as we are trained from a young age to hit the center of the steering wheel/yoke in the event of an imminent accident. I was recently driving when another vehicle ran a stop sign, and I was barely able to avoid them; however, when hitting the "horn" to alert the other driver, it didn't work as the horn button is not in a typical location. This should be considered a significant safety risk. Elon Musk himself indicated a software update would fix this issue; however, it has not. Tesla now indicates it requires a new wheel/yoke and has not yet made it available or covered under warranty.

A couple of days ago, when I was dropping off my child at school, I parked in a spot that required parallel parking to save time as I was in a rush. After reversing into the spot, I just needed to move forward a bit by 1-2 feet. I naturally slide the gear shift up on the screen. Unfortunately, it didn't slide into place, and the car was still in reverse (R), but I didn't realize it. I was already very close to the car behind me. When I pressed the accelerator, the car continued to back up. Luckily, I slammed the brake, avoiding a collision. Just wanted to share that even after a year and a half of driving a Model X, mistakes can still happen. After reading what happened to [XXX] , I posted what happened to me on a social platform and someone else shared they had a similar experience that needed up with a crash. So I decided to report mine and encouraged them to do the same. I like the minimalist design but I need to stay alive to enjoy it. As Tesla is moving away from stalkless design in more models, I hope they can do something to make the current shift more noticeable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)