2006 GMC Sierra 1500

Defect. CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.

Risk. WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.

Remedy. FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.

Defect. CERTAIN FEDERAL-MOGUL NATIONAL AND CARQUEST AFTERMARKET HUB ASSEMBLIES, P/N 515058, SOLD FOR USE ON 2001-2006 GENERAL MOTORS 1500 AND 2500 4WD TRUCKS. ON THE SUBJECT HUB ASSEMBLIES, THE ABS SENSOR CORD DEPARTS FROM THE HUB ASSEMBLY AT A 90 DEGREE ANGLE. AS A RESULT, THERE IS A FIT ISSUE WITH THE BRAKE ROTOR DUST SHIELD INTERFERING WITH THE ABS SENSOR CORD. IF THE HUB ASSEMBLY IS INSTALLED DESPITE THIS INTERFERENCE, THE GAP BETWEEN THE ABS SENSOR AND THE TONE WHEEL MAY BE ALTERED. THIS MAY WEAKEN THE OUTPUT OF THE ABS SENSOR. DIMINISHED OUTPUT COULD RESULT IN AN UNWANTED ABS ACTIVATION AT LOW SPEEDS AND STOPPING DISTANCE COULD BE AFFECTED.

Risk. IF STOPPING DISTANCE IS LIMITED, A VEHICLE CRASH COULD OCCUR.

Remedy. FEDERAL-MOGUL WILL NOTIFY ITS OWNERS AND WILL EITHER CREDIT THE CUSTOMERS ACCOUNT OR REPLACE THE UNIT. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2006. OWNERS CAN CONTACT FEDERAL-MOGUL CUSTOMER SERVICE AT 1-800-563-8507 EXT 3530.

The front left frame that the wheel and suspension bolt onto is in advanced rust stages. It is being considered unsafe to drive although the right side is still considered safe. Common issue from what I have heard. Took car in to replace the starter and shop doesnwant to work on it. We cannot afford a new vehicle because of a knkwn weakness in the frame work

I WAS SOLD AN UNSAFE VEHICLE FOR WORK/COMUTE FAMILY. THE DEALERSHIP MISLEAD ME AND LIED TO ME ABOUT WARRANTY AND EVEN AFTER I PAID $10,0000 CASH I WAS WRONGFULLY DONE BY THIS BUSSINESS BY NO MEANS WAS THE BUSSINESS TRYING TO CONDUCT GOOD BUSSINESS WITH ME AND I ALSO HAVE A DISSABILITY AND A CHILD WITH A DISABILITY. Incident Date: 5/9/2024 Description: I PURCHASED A 2006 GMC SIERRA $10,000 CASH WAS GIVEN AND PAID OFF BUT I WAS SCAMMED BY THE DEALERSHIP. I BOUGHT THIS VEHICLE UNDER THE IMPRESSION THAT I WAS BEING SOLD A GOOD SAFE VEHICLE FOR WORK AND MY FAMILIES NEEDS ARE ALSO A PRIORITY. I NEVER TEST DROVE THE VEHICLE TILL I DROVE HOME AFTER PURCHASING IT. NOT EVEN 4 MINS ON THE ROAD AND I NOTICED THE ABS LIGHT CAME ON THE DASHBOARD WITH THE BRAKE LIGHT AND THE FRONT BRAKES BEGAN TO SMOKE. I CONTACTED THE DEALSHIP BUT WAS DISREGARDED AND NOT OFFERED AN EXCHANGE OR ANY TYPE OF SOLUTION FOR MY PROBLEM I EVEN EXPLAINED MY JOB REQUIRED ME TO USE MY VEHICLE FOR TRANSPORTING MATERIAL FOR WORK AND SINCE I WAS IN CHARGE OF 4 PEOPLE THAT WOUL BE REQUIREING SKILLS FOR CUSTOMER SERVICE AND MAKING SURE ALL CUSTOMERS WERE SATISFIED. PACIFI NORTHWEST MOTORSPORTS TOOK ADVANTAGE OF MY IMPARIMENT I FEELSCAMMED AND I WANT TO HAVE MY MONEY BACK OR AT LEAST EXCHANGE FOR THE VALUE OF $10,000. I WAS NEVER OFFERED ANY TYPE OF SLOUTION FROM THE BUSSINESS THE OWNER LAUGHED AT ME AND SAID THAT IT SUCKED TO BE ME AND HUNG UP THE PHONE ON ME. THE BUSSINNESS OWNER LIED TO THE ATTORNEY GENERALS OFFICE ABOU

Something shorted on or behind the dash on the drivers side and caught fire

MY PASSENGER SIDE WHEEL BROKE AND WENT SIDEWAYS WHEN I TURN OFF THE HIGHWAY IN MONTZUMA ONLY GOING ABOUT 30MPH

I HAD A CRACK IN THE WINDSHIELD AND WHEN THEY REPLACED IT THE TECHNICIAN SAID IT WAS SO RUSTED FROM THE INSIDE THAT IF ANYTHING HAPPENED AGAIN THEY WOULD NOT REPLACE IT HE HAD TO REALLY DO SOME WORK AROUNDS HE SAID TO EVEN REPLACE THIS ONE. THAT MAKES ME FEEL THAT THIS IS A REAL SAFETY ISSUE IF WE WERE TO GET IN A SERIOUS ACCIDENT. THERE IS NO RUST ON THE OUTSIDE AROUND THE WINDSHIELD AT ALL. SO I WAS VERY SURPRISED WHEN THE TECHNICIAN TOLD ME THAT.

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. THE CONTACT STATED THAT THE HEATER BLOWER RELAY SWITCH WAS REPLACED HOWEVER, THE FAILURE RECURRED. THE CONTACT STATED WHILE VEHICLE WAS IN A STAND STILL, AND ATTEMPTING TO TURN ON THE AIR CONDITIONER, THE AIR CONDITIONER WAS INOPERABLE. THE CONTACT STATED THAT A DEALER WAS NOT CONTACTED. THE CONTACT STATED THAT THE HEATER BLOWER REPLAY SWITCH AND HARNESS NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED AS OF YET. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000. *BF THE CONSUMER STATED IN 2015 THE SWITCH WAS REPLACED, BUT IN 2020 IT WAS REPLACED AGAIN ALONG WITH THE MELTER WIRE HARNESS. *AS

EVEN THOUGH MY TRUCK HAS ALWAYS BEEN GARAGE KEPT AND ONLY HAS 30 THOUSAND MILES ON IT, MY BRAKING SYSTEM WENT OUT WHILE DRIVING BECAUSE MY METAL BRAKE LINES ARE RUSTED . *TR

FUEL GAGE SHOWS HALF A TANK BUT I RAN OUT OF GAS. LIGHTS BLOW ALL THETIME.

ABS LIGHT KEEPS COMING ON WHILE DRIVING

WHILE DRIVING AT LOW SPEEDS, ABOUT 20 MPH OR LOWER, THE BRAKE PEDAL FADES TO THE FLOOR. THERE ARE NO LIGHTS OR CODES AND BRAKE FLUID AT THE PROPER LEVEL. THIS HAPPENS QUITE FREQUENTLY AND ANYWHERE.

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. WHILE DRIVING APPROXIMATELY 8 MPH AND ATTEMPTING TO STOP THE VEHICLE, THE ANTI-LOCK BRAKING SYSTEM SEIZED WITHOUT WARNING. THE FAILURE RECURRED SEVERAL TIMES. THE CONTACT CALLED CHAMPION CHEVROLET OF AVON AT 317-350-1023 (LOCATED AT 183 S COUNTY RD 525, AVON, IN 46123) AND A DIAGNOSTIC TEST WAS RECOMMENDED. THE TEST WAS NOT PERFORMED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 36,000.

TL* THE CONTACT OWNED A 2006 GMC SIERRA 1500. WHILE THE CONTACT'S SON WAS DRIVING 30 MPH, THE POWER STEERING SEIZED AND THE VEHICLE DRIFTED AND CRASHED INTO THE GUARDRAIL OF A BRIDGE. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOTALED. A POLICE REPORT WAS FILED. THE DRIVER WAS INJURED, BUT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO A WRECKING YARD. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 154,000.

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. WHILE DRIVING APPROXIMATELY 35 MPH, THE FORTY TWO VOLT CHARGING WARNING INDICATOR ILLUMINATED. DUE TO THE WARNING, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE CONTACT TURNED OFF THE VEHICLE AND IT FAILED TO RESTART. THE VEHICLE WAS TOWED TO JOHN PAUL'S BUICK GMC (3615 S 108TH ST, GREENFIELD, WI 53228, (414) 208-4113) WHERE IT WAS DIAGNOSED THAT THE GENERATOR STARTER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED DUE TO THE PART NO LONGER BEING MANUFACTURED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 92,350.

I TOOK OUR TRUCK IN FOR SERVICING AT THE O'NEILL GMC DEALERSHIP IN WARMINSTER, PA AND WAS TOLD THAT ALL OF OUR BRAKE LINES NEEDED TO BE REPLACED DUE TO RUSTING. WE PURCHASED OUR VEHICLE NEW FROM O'NEILL AND HAVE CONTINUED TO HAVE IT SERVICED THERE. THE TRUCK IS TREATED WITH GREAT RESPECT AND ONLY HAS 40,000 MILES ON IT. I CONTACTED GMC DUE TO THE DEFECTIVE MATERIALS OF THE VEHICLE THEY SOLD US AND THEY CLAIM THAT THIS IS NORMAL. I NOW AM STRAPPED WITH A BILL FOR $2700.00 TO REPLACE ALL FOUR DEFECTIVE, RUSTING BRAKE LINES THEIR WEBSITE SAYS CUSTOMER SATISFACTION GUARANTEED. I BELIEVE GMC SHOULD CONTRIBUTE $1700 TOWARDS THE BILL. I NOTE THAT THERE ARE OVER TEN PAGES OF COMPLAINTS ON THE INTERNET REGARDING CORROSION PROBLEMS. PLEASE HOLD GMC ACCOUNTABLE. THIS VEHICLE WAS PURCHASED IN GOOD FAITH AND THEY SHOULD ADMIT RESPONSIBILITY FOR THEIR INFERIOR BRAKE LINE MATERIALS. I AM DISAPPOINTED WITH GMC'S EXCUSES AND NONSENSE. I TOLD THEM THEY SHOULD PAY $1700 OUT OF THE MONEY THEY BANKED FROM THE EXPIRED, EXTENDED WARRANTY WE PURCHASED. THIS IS A GMC ISSUE; NOT A [XXX] ISSUE. AGAIN, PLEASE HOLD THEM RESPONSIBLE FOR SELLING A DEFECTIVE TRUCK. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

BRAKE LINE FAILURE, FRONT LEFT. STEEL LINE HAD RUSTED NEXT TO A PLASTIC CLIP THAT SECURED A WIRING HARNESS TO THE BRAKE LINE. BRAKE FLUID WAS SPRAYING ONTO THE SIDE OF THE ENGINE. NOTICED THE LEAK AFTER RETURNING HOME; HAD FAILED IN STOP-AND-GO TRAFFIC.

WHEN BRAKING AT THE END OF OUR DRIVEWAY BEFORE PROCEEDING INTO THE ROAD THE BRAKE PEDAL PULSATES LIKE ABS IS KICKING IN BUT THE VEHICLE HESITATES TO STOP. ALSO WHEN TURNING TO THE LEFT AT LOW SPEED, CAN HEAR THE ABS SYSTEM ACTIVATING AND GET PULSING IN THE BRAKES AS WELL.

WHILE DRIVING ON TWO LANE ROAD,SERVICE BRAKE SYSTEM LIGHT FLASHED, VEHICLE WAS HARD TOO SLOW DOWN AND STOP. STOPPED VEHICLE AND SAW BRAKE FLUID WAS LEAKING FROM LEFT FRONT WHEEL BRAKE LINES.

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE MADE A LOUD CLUNKING NOISE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. IN ADDITION, THE VEHICLE SHIFTED HARD WHEN SWITCHING GEARS. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE VALVE BODY INSIDE THE TRANSMISSION WAS DEFECTIVE. THE VEHICLE WAS NOT REPAIRED. GMC OF PLATTSBURGH, NEW YORK (518)-563-2000 WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL ON THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND PROVIDED THE CONTACT WITH CASE NUMBER: 8-3309303524. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000. UPDATED 12/13/2017 *LN CONSUMER STATED DOES NOT SHIFT DOWN GOING DOWN HILLS HALF TO RIDE BRAKES AT ALL TIMES. LIGHT DID NOT COME ON WHEN WE HAD TROUBLE WITH ABS CABLE TO WHEEL BEARING, YOU LOSE BRAKE POWER. ALSO TRANSMISSON DOES NOT SHIFT DOWN. UPDATED 7/18/18*JB

I OWN A 2006 GMC SIERRA 1500 PICK-UP WITH LESS THAN 75,000 MILES ON JANUARY 23, 2017 I LOST MY BRAKING CAPABILITY DUE TO THE BRAKE LINES BEING COMPLETELY CORRODED/RUSTED THROUGH CAUSING THE LOST OF BRAKE FLUID. LUCKILY I LOST MY BRAKES IN A PARKING LOT AND NOT ON A BUSY MAIN STREET OR HIGHWAY WITH THE POSSIBILITY OF HAVING AN ACCIDENT AND SERIOUSLY HURTING MYSELF OR SOMEONE ELSE. FROM WHAT I HAVE READ GM HAS KNOWN ABOUT THIS PROBLEM FOR SOMETIME AND SAYS IT IS NOT A SAFETY CONCERN. FROM FIRST HAND EXPERIENCE I BELIEVE THIS IS A MAJOR SAFETY CONCERN. *TR

I WAS DRIVING AROUND A CURVE (50MPH)AND STEERING FAILED. THE STEERING WHEEL TURNED COMPLETELY AROUND BUT WHEELS DID NOT RESPOND. I HAD A STRONG ODOR OF BURNING POWER STEERING FLUID JUST PRIOR TO MALFUNCTION. *TR