2026 Ford Explorer

Defect. Ford Motor Company (Ford) is recalling certain 2026 Explorer vehicles. The active vent on the passenger side may not open as intended, preventing the air bag from deploying properly.

Risk. An air bag that does not deploy as intended increases the risk of injury in a crash.

Remedy. Dealers will replace the passenger air bag module, free of charge. Owner notification letters were mailed September 16, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S65. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 14, 2026.

Defect. Ford Motor Company (Ford) is recalling certain 2026 Explorer, Bronco, Bronco Sport, Mustang, and Ranger vehicles. The engine piston domes may have been manufactured incorrectly, which can result in piston dome failure and lead to a loss of drive power.

Risk. An unexpected loss of drive power increases the risk of a crash.

Remedy. Dealers will inspect the engine pistons and replace the engine long block, if necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed September 3, 2026. Additional letters will be sent once the remedy is available, anticipated in December 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S61. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on August 28, 2026.

Defect. Ford Motor Company (Ford) is recalling certain 2026 Explorer vehicles equipped with a 2.3L engine. The engine connecting rod bearings may seize, which can result in engine failure.

Risk. Engine failure can result in a loss of drive power, increasing the risk of a crash. In addition, bearing failure may cause a breach in the engine block, allowing oil to leak, increasing the risk of a fire.

Remedy. Dealers will replace the engine long blocks, free of charge. Owner notification letters were mailed August 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S58. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on August 18, 2026.

Defect. Ford Motor Company (Ford) is recalling certain 2025-2027 Explorer and Lincoln Aviator vehicles. An unoccupied driver's seat may recline unintentionally during certain scenarios, such as remote unlock or remote start.

Risk. Unexpected movement of the driver’s seat back may trap a second-row occupant, increasing the risk of injury.

Remedy. Dealers will disable the driver seat module (DSM) feature until parts are available. Once available, the motor will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S53.

Defect. Ford Motor Company (Ford) is recalling certain 2020-2027 Aviator and 2020-2026 Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, tipping, or sliding unexpectedly.

Risk. A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing the risk of injury.

Remedy. Dealers will inspect and replace the bezel around the switch as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters explaining the safety risk were mailed August 19, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Lincoln Aviator owner notification letters were mailed August 21, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S52. This recall expands Recall 25V393. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.

Defect. Ford Motor Company (Ford) is recalling certain 2025-2026 Explorer, Ranger, and Bronco vehicles. The engine may fail, which can result in a loss of drive power.

Risk. A sudden loss of drive power can increase the risk of a crash.

Remedy. Dealers will replace the engine long block, free of charge. Owner notification letters were mailed October 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S35. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 28, 2026.

Defect. Ford Motor Company (Ford) is recalling certain 2026 Explorer and Mustang vehicles. The engine piston circlips may have been incorrectly installed during manufacturing, which can result in piston failure and engine damage, leading to a loss of drive power.

Risk. An unexpected loss of drive power increases the risk of a crash.

Remedy. Dealers will inspect the engine for missing or mis-installed circlips and replace the engine as necessary, free of charge. Owner notification letters were mailed April 10, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S23. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 2, 2026.

Defect. Ford Motor Company (Ford) is recalling certain 2026 Lincoln Aviator and Explorer vehicles. The heating, ventilation and air-conditioning (HVAC) system may fail, which can cause the defrosting and defogging system to become inoperative.

Risk. An inoperative windshield defrosting and defogging system may decrease the driver's visibility, increasing the risk of a crash.

Remedy. Dealers will inspect and secure the instrument panel joints as necessary, free of charge. Owner notification letters were mailed April 10, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S22. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning April 3, 2026.

Defect. Ford Motor Company (Ford) is recalling certain 2020-2026 Explorer and Lincoln Aviator vehicles. The seat belt anchor bolts at the second-row outer seating positions may be improperly secured.

Risk. A loose seat belt buckle may not properly restrain an occupant during a crash, increasing the risk of injury.

Remedy. Dealers will inspect the second-row outer seat belt lower anchor bolts and replace or repair them as necessary, free of charge. Owner notification letters were mailed March 30, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C18. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.

Defect. Ford Motor Company (Ford) is recalling certain 2025-2026 Explorer vehicles. The Dynamic Bending Light (DBL) system software may cause the passenger-side headlight to turn in the wrong direction when driving through curves in the road. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

Risk. A headlight that turns incorrectly can result in increased glare to other road users, increasing the risk of a crash.

Remedy. The headlight control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C12. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.

Defect. Ford Motor Company (Ford) is recalling certain 2026 Explorer vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."

Risk. In the event of a crash, windshield detachment can increase the risk of injury.

Remedy. Dealers will remove and replace the windshield, free charge. Owner notification letters were mailed January 30, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C02. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 22, 2026.

Defect. Ford Motor Company (Ford) is recalling certain 2026 Explorer, Mustang, Lincoln Corsair, and 2025 Maverick vehicles. The cylinder head may have been improperly manufactured, which can cause the ball plugs to fail, resulting in an oil leak.

Risk. An oil leak in the presence of an ignition source such as hot engine or exhaust components increases the risk of a fire. In addition, the loss of oil can result in engine seizure and loss of motive power, increasing the risk of a crash.

Remedy. Dealers will replace the cylinder head assembly, free of charge. All affected vehicles are still within dealership inventory and therefore no owner notification letters will be mailed. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SD3. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on November 24, 2025.

Defect. Ford Motor Company (Ford) is recalling certain 2025-2026 Lincoln Corsair, Lincoln Aviator, and Explorer vehicles. The windshield glass may have visible air bubbles, which can obscure the driver's visibility. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 205, "Glazing Materials."

Risk. Reduced visibility while driving can increase the risk of a crash.

Remedy. Dealers will inspect and replace the windshield as necessary, free of charge. Owner notification letters were mailed November 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C60. Vehicle Identification Numbers (VINs) involved in this recall become searchable on NHTSA.gov beginning October 27, 2025.

Defect. Ford Motor Company (Ford) is recalling certain 2024-2026 Explorer and 2024-2026 Lincoln Aviator vehicles. The trailer hitch assembly bolts may be loose.

Risk. While towing a trailer, loose trailer hitch bolts can cause a loss of vehicle handling and control, or cause the trailer to detach. Either of these conditions can increase the risk of a crash.

Remedy. Dealers will inspect and tighten the trailer hitch bolts, or replace them as necessary, free of charge. Owner notification letters were mailed October 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA3. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

I purchased a new 2026 Ford Explorer and had owned the vehicle for approximately three days when the driver-side front power window failed at approximately 315 miles. The failure occurred on the evening of October 23, 2026, while the vehicle was parked in my driveway. I operated the driver-side window normally and heard loud crunching/mechanical noises from inside the driver door as the window went down. The glass went fully down and then would not raise. When I attempted to operate the window switch afterward, additional crunching noises could be heard from inside the door, but the glass would not move. Because the Ford service department was already closed, I was unable to have the vehicle inspected that evening. With possible rain, I had to cover the open driver-side window with painter's plastic and tape to protect the interior of a vehicle that was only three days old. I took the vehicle back to the selling Ford dealership the following morning, October 24, 2026, as soon as the service department opened. The vehicle had approximately 328 miles when it was documented by the dealership. The Ford dealership subsequently verified the failure. According to the repair order, the technician found the driver-side window regulator binding. After removing the door panel and inspecting the regulator, the technician found that the window-regulator cable had detached from the regulator. The dealership removed and replaced the window regulator and retested the system. The replacement

I purchased a brand-new 2026 Ford Explorer on XXX. Approximately five weeks later, I experienced a terrifying and potentially life-threatening malfunction while traveling approximately 70 mph in the left lane of [XXX] in [XXX]. An 18-wheel tractor-trailer was traveling beside me when, without warning, my Explorer suddenly stopped responding to the accelerator. Multiple warning lights illuminated on the dashboard. The engine continued running, but the vehicle would no longer accelerate. I was unable to maintain my speed or immediately move into the adjacent lane because of the 18-wheeler. As my vehicle slowed, I struggled to maneuver across traffic toward the right shoulder. Looking in my rearview mirror, I saw a wide-load vehicle approaching from behind. I was desperately trying to get out of traffic and toward the ditch to avoid being struck. I feared for my life. Fortunately, I reached safety without a collision, but my Explorer required towing. The vehicle was taken to Ford on XXX, with only 2,432 miles. It remained at the dealership until XXX. Ford’s repair documentation identified diagnostic trouble code P2138, associated with accelerator pedal/throttle position sensor correlation. The technician performed a wiggle test and discovered an intermittent electrical connection caused by poor pin fit at connector C140. Electrical connector terminals were replaced under warranty after the dealership obtained the necessary parts. I am extremely concerned that a defective electri

Rear liftgate window spontaneously shattered while sitting in my driveway.

Traveling of the freeway at 80 mph, pull left to pass Semi, upon getting halfway past the truck the adaptive cruise Control activates and brings the vehicle to under 65 mph extremely fast. After a few seconds the vehicle rapidly accelerates back to 80 mph. This has happened at least four times since purchasing the vehicle new. The problem is very erratic and only happens when passing a Semi while driving up a hill or passing on a left turning bend on the freeway. The incident that disturbed me the most was when this malfunction happened the last time a vehicle following me had to take to the borrow pit to prevent collision with my vehicle. Fortunately there was no accident or injuries that occurred but I can imagine that at one time this problem will take place and someone will have a serious accident. Contacted Ford Customer service and was given a case number to give to the dealer concerning this problem, upon taking the vehicle to the Dealer I have now been told that Ford stated that if the Dealer could not replicate the problem there was nothing that Ford will do about it. Adaptive cruise control is not a safe option on any vehicle if corrections cannot be made when there is a problem with the programming or the cameras that operate the system.

The contact owns a 2026 Ford Explorer. While the contact's wife was driving 45 MPH, an unknown warning light illuminated, and the hood latch independently released. The contact stated that the hood opened independently and fractured the front windshield. The contact stated that the front windshield was shattered. The dealer was contacted and made aware of the failure. The vehicle was towed to the dealer. The manufacturer was contacted, and a case was filed. The failure mileage was approximately 1,623.

- Driver seat back reclines by itself when vehicle is approached by key fob. As acknowledged by Ford, this situation could result in harm to a passenger sitting behind the driver. The vehicle is available for inspection upon request. - This issue was demonstrated to several dealer service personnel as early as June 12, 2026, at which time there was no service recall or known fix available. A repair order dated August 28, 2026 indicates that seat was operating normally but that "easy exit" was turned on; service tech notes "easy exit" has been turned off. - We received a notice from Ford in late September 2026 that an open recall--26S53--has been issued. Took vehicle to dealer on September 30, 2026 and repair order states that they updated the driver seat module per the recall (Software validation #R47CF90GJUHMR. 26s53b-0.3). Issue continues after this update.

I was sold and delivered a car with an active safety recall for 2nd row seat easy entry. At the time of sale I was told the recall had been done. 2 days later the dealer called and said the recall had not been done and that the car had a do not sell or demonstrate destination. They wanted me to bring the car back to hold on the lot until parts become available. I would have never bought the car if I knew the recall had not been done. It’s now over 3 weeks and still waiting on parts. I feel the dealer just wanted the sale. I don’t see how this “mistake” happened. The dealer is telling me I have to bring the back to their dealership for the recall. I don’t trust them and want the recall done at another dealership.

Vehicle would not accelerate, was shuddering and continued shuddering while stopped and parked.

During a traffic accident the driver side seat airbag deployed. The airbag vent faces towards the driver when it deploys. The air escaping the vent burned through the shirt of the officer driving the vehicle and also caused a mixture of 2nd and 3rd degree burns to the hip and side abdomen region of their body.

The glass roof exploded while traveling down the road. No cause for failure present.

Sunroof spontaneously shattered while driving down the road.

On several occasions when trying to drive from a stopped position I press the gas and the car will move slowly but not shift into gear and then after turning off it struggles to restart. The check engine light is solid but goes away by the next day. This has happened after sitting idling in a parking lot most often but recently it happened 2 times as I was turning left onto a street where I luckily was able to slow roll to the side and not get hit. I brought it in once for service and they struggled to find the issue for hours and eventually said pins in the fuel injector were lose and replaced but it is continuing to randomly happen.

Ford has issued a recall related to the driver seat recline memory feature. It is recall 26V470. The remedy (software-based) disables the driver seat recline memory feature altogether. THIS IS UNACCEPTABLE. Instead of correcting the issue with the recline memory feature, Ford has chosen to disable the feature completely. I did not purchase a new vehicle, just to have the manufacturer disable a standard feature than does not function properly. Ford must repair the standard feature and return the vehicle to it's normal operating function. The solution must not diminish the features and usability of the vehicle that was purchased.

On XXX around 6:30pm: Car would not go into reverse. Upon pressing the gas a 2nd time, a loud pop was heard from the back of the car. The car was then able to drive forward, however, when pressing on the brakes, the rear end of the car would wobble, and the brakes were rubbing and making a loud noise. I contacted Rich Ford, explained that my car is brand new (2 months), with less than 4,000 miles, and this should not happen. I was told that “someone would call me the following morning around 7am”. I drove to work the next morning, XXX, avoiding the use of the brakes as much as possible. I called Rich Ford again, at around 07:45, and spoke to “Toby”. Explained to him what had happened, and asked that they pick up the vehicle to see what’s wrong. I was told that they couldn’t look at it until Monday XXX. I told Toby that I did not feel comfortable or safe driving my car anywhere, and asked that they pick up the car and provide a loaner. Toby then told me I could drop the car off on Friday, XXXat 08:00. Around 3:48pm, Wednesday, I called Rich Ford again and asked them to pick it up because I didn’t feel safe to drive it. They said “No, just drop it off on Friday”. At around 5:35pm, I got to my car, which was parked on the side street of [XXX]. I pressed the brakes, pressed the start engine button, and then went to step out of the car to talk to a co-worker. The car was in “park”. Once I stepped out with my left leg, the car began rolling forward, knocked me face down onto the ro

Seal around the panoramic sunroof is failing and has caused loud wind noises and lack of proper weather seal. Vehicle has 7000 miles and this has randomly started. Loud wind whistle noise occurs now 100% of the time when speed reaches 35mph and stays present at higher speeds.

I had my car in drive in a parking spot. I was ready to go, put the car in drive, DID NOT MOVE but needed to put it in park fast to assist to a child in the back seat. I put it in park pretty fast. Took my seatbelt off and assisted child. It must have not engaged. Car rolled into my office metal mailbox. I 100% put it in park. I took my seatbelt off after so I seen it. It was fast with the gear shift though. Should this have been an issue? I feel like if it was any other car you with a manual gear shifter , not electrical, it’s fine. I feel this was not my fault at all and was a malfunction of the car. The car did not automatically stop either. It hit the mailbox at like 3-4mph. I have never been in an accident of my fault in 10 years of driving. I’ve never made a crazy mistake like that. It should’ve never happened. I drive all types of cars/ and trucks. This is also a lease and I’m SO PISSED. Especially because my kids were in the car. Luckily no one was hurt and no property damage. Just the car.

When using memory seat function and switching between driver profiles, the seat reclines too far back with no regard for the preset position. The height and forward adjustment is correct, but the recline function is not working correctly and it just keep reclining.

When entering the vehicle with a key fob that is programmed for a saved seat setting for the driver, the chair back begins to recline all the way. This could crush a passenger seated behind them.

I am reporting a potential safety defect involving the upper steering column shroud and the driver-facing Driver Status Monitor Camera on my 2026 Ford Explorer equipped with BlueCruise. The upper steering column shroud became extremely loose and will not remain securely attached. The driver-facing camera is mounted in this area. Ford states that BlueCruise uses the driver-facing camera to monitor the driver’s eyes and head position during hands-free operation. I personally observed the shroud and camera assembly loose while BlueCruise remained active. I cannot determine whether monitoring accuracy was affected, but I am concerned that a driver-monitoring camera used during hands-free Level 2 driving can physically move or become unsecured without BlueCruise immediately becoming unavailable. The loose assembly could also detach or distract the driver while the vehicle is moving. Before the repair was completed, the original authorized Ford dealer advised me to temporarily tape the loose shroud assembly back together while waiting for parts. I am reporting that recommendation because the affected area contains the driver-monitoring camera used by BlueCruise. The dealer later documented “SWAP STEERING COLUMN SHROUD WITH STOCK UNIT” and returned the vehicle to me as repaired. The same loose condition remained. The next day, a second authorized Ford dealer inspected the vehicle and documented loose steering-column-shroud fitment, stated the upper and lower halves appeared mismatch

We were driving our new 2026 Ford Explorer on the highway around 7:45 am on 8/15/26 when suddenly we heard what sounded like an explosion. Fortunately, my husband did not wreck, roll the car or stop on the highway like I would have given the pure terror I felt. He pulled over, and we looked around and confirmed the sunroof was completely shattered. Fortunately, the shade was closed, or our daughter and dog would have been covered in glass. No object impact, collision, extreme temperature, or weather event was observed before the sunroof shattered. Fortunately traffic was light, and we feel lucky to be unharmed/alive.

Moonroof had a seal leak. Ford replaced entire moonroof assembly. 3 weeks later the moonroof spontaneously shattered while driving down 40 MPH road, no trees, no rocks, etc. Fortunately, the inner cloth canopy was closed or shattered glass would have fallen down and hit driver and passengers.

The driver's memory seat has a serious malfunction. Whenever I enter the vehicle or switch between memory presets, the driver's seat unexpectedly reclines completely backward. This also crushes anyone sitting in the rear driver's-side seat, making it essentially unusable until we can return the driver's seat to its upright position. Even more concerning, the seat can begin reclining while I am driving, creating an obvious safety hazard. I recently learned that Ford has issued a recall for this exact issue. However, my vehicle was somehow excluded from the recall despite exhibiting the very same defect. My local dealership acknowledged that my car does show the problem listed on the recall and attempted to repair it by replacing the seat back and seat motor. Unfortunately, the replacement parts Ford supplied had the exact same malfunction. The dealership now must order another set of parts and hope they function properly. What concerns me most is the safety aspect. I am continuing to drive a brand-new vehicle with a known defect that may cause the driver's seat to unexpectedly recline while the vehicle is in motion. That is not simply an inconvenience—it is a legitimate safety concern for me, my family, and others on the road.

Put vehicle in drive to pull out of driveway started moving when all of a sudden the explorer started rolling in reverse and the the D on the transmission knob blinked green the E brake did not work I ended up in my garage door and in the back of an ambulance for neck pain and whiplash.

While driving my 2026 Ford Explorer on the highway, the panoramic roof glass made an abnormally loud noise and completely shattered without any impact from an object or other vehicle. No other cars were nearby. The protective shade remained in place and no glass entered the cabin. This appears to be a spontaneous failure of the tempered glass. I have already located a nearly identical NHTSA complaint on another 2026 Ford Explorer (Campaign 11734759). The vehicle is currently undrivable in normal conditions and is being repaired through insurance. I am concerned this is a known defect with the panoramic roof glass on 2026 Explorers.

NHTSA Vehicle Safety Complaint Narrative I am submitting this complaint to report a serious safety incident involving the rear seat belt of a Ford rental vehicle obtained from Budget Rent A Car. My [XXX] grandson was properly restrained in a weight-appropriate booster seat and secured with the vehicle’s rear lap and shoulder seat belt in accordance with child passenger safety recommendations. There had been no collision, sudden stop, or other event that would normally activate the seat belt locking mechanism. While seated in the vehicle, the seat belt became tightly wrapped around my grandson’s waist and locked in a manner that prevented it from being loosened or released. Multiple adults attempted to free him by following the normal procedures for releasing and loosening the seat belt, but all attempts were unsuccessful. An off-duty Emergency Medical Technician (EMT) stopped to assist. After repeated unsuccessful attempts to release the seat belt, the EMT determined that the only safe way to free my grandson was to cut the seat belt. The child could not be removed from the vehicle until the seat belt was cut. This incident caused significant concern because a properly functioning seat belt should not trap an occupant in a manner that prevents emergency release. My grandson had been properly restrained in a weight-appropriate booster seat and was using the seat belt as intended. I respectfully request that NHTSA investigate whether this incident represents a defect in the sea

The contact owns a 2026 Ford Explorer. While the contact's wife was driving 60 MPH, the instrument cluster independently turned off. The vehicle was taken to the dealer where it was diagnosed with a software malfunction. The contact was informed that the unknown software needed to be updated. The vehicle was repaired; however, the failure reoccurred. In addition, the contact stated that only the fuel gauge and the speed odometer operated as needed. The vehicle was taken back to the dealer where the vehicle was diagnosed with an unknown software malfunction. The contact was informed that the software needed to be updated. The vehicle was repaired. The contact was informed that the software update was completed, and the system was rebooted. The contact was not satisfied with the repair. The contact researched and inquired about the APIM board being replaced to prevent the failure from reoccurring. The contact was informed that the manufacturer did not approve of the repair. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 1,000.

The contact owns a 2026 Ford Explorer. The contact stated that while driving approximately 45 MPH in the rain, the front windshield wipers suddenly stopped operating. The front power windows failed to operate properly and failed to go up or down. There were no warning lights illuminated. The vehicle was taken to the local dealer; however, the dealer was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 4,600.

Purchased brand new vehicle two months ago, only has 2000 miles on it. We took it on vacation 14hours from home. Made it to our destination and started getting “vehicle communication errors” on the screen. Jumped the vehicle, notifications went away. We scheduled an appointment with a local ford dealer who told us to bring it in. On the way to the dealership and while driving on the road, the vehicle screen listed the same “vehicle communication error” indicator and every single vehicle service light was on. We lost all electrical power. No blinkers, no miles per hour indicator, no lights etc, but we were able to continue driving to the service dealership. Drove an additional 15 miles with absolutely no electrical power and did not want to stop as we were afraid the car was not going to turn back on, on the side of the road per previous experience.

This 2026 Ford Explorer has stopped, stalled, hesitated and jerks after fuel fill-ups. It stopped twice for myself in busy intersections. The dealer has had it for weeks and when driving the vehicle back to me, stalled and hesitated for Ford Service dept. twice. They told me I could not have my car back for safety reasons.

The contact owns a 2026 Ford Explorer. The contact stated that while attempting to make a left or right turn, the front passenger’s side seat was moving from side to side. A dealer was contacted. The vehicle was taken to the dealer to be diagnosed; however, the diagnostic result was unknown. The contact was informed that that bolts were all connected. The vehicle was not repaired. The contact stated that the failure had occurred on several occasions. The manufacturer was notified of the failure and informed the contact he would receive a call back within 24 hours. The approximate failure mileage was 2,600.

I have a brand new 2026 Ford Explorer ST. There is a permanent haze on or between the glass windshield that does not come off with any cleaning agent and appears to be between the layer. The service manager at the dealership acknowledges seeing the haze and the reduced clarity but clains Ford will not warranty since it is not on a recall. It is dangerous when the sun glare causes it to "glow" impairing clear visibilty of the road. It is also evident and impairs during rain. The difference is very evident when looking through the windshield versus the side windows at the same object,

Description On your vehicle, it may be possible that one or more engine camshaft roller finger followers were not properly installed at the time of engine assembly. Safety Risk An improperly installed engine camshaft roller finger follower may result in engine failure, resulting in a no-start condition or a loss of motive power. A loss of motive power increases the risk of a crash. Your vehicle may also experience engine ticking or tapping noise, and or a low-volume oil leak due to this condition. Remedy A remedy is not yet available. Ford Motor Company is working to provide parts for this repair. When the remedy becomes available, Ford Motor Company will notify you via mail to schedule a service appointment with your dealer for repairs to be completed free of charge. The remedy is anticipated to be available 4TH quarter of 2026. Next Steps Contact your dealer for more information to schedule the free service.

I purchased this new car from Bell Ford on XXX. Since I have owned it, it has been under Ford’s care for almost 2 weeks at 2 different service departments. (I have owned for 90 days.) The car sputters and stops when putting on the gas from a start position. I ended up stalling in a busy intersection on [XXX] All the dash lights come on and then the engine light comes on. Says, take to dealer. They are replacing the fuel pump now and trying that. This car has less than 4900 miles on it. The car they have given me to use is not comparable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Description On your vehicle, some of the bolts used to attach the vehicle trailer tow hitch may have below-specification torque. Safety Risk This condition may affect vehicle handling characteristics or lead to loss of attachment of the trailer hitch while towing, increasing the risk of a crash. Remedy Parts are now available to repair your vehicle. Ford Motor Company Lincoln has authorized your dealer retailer to inspect and secure or replace the trailer tow hitch bolts as required free of charge. Next Steps Contact your dealer for more information to schedule the free service.

Purchased new 26 Ford Explorer on [XXX] from Franklin Ford in TN. During test drive noted the BlueCruise hands free was canceling but was advised by dealer that it might need to download an update or sync my profile. Next day I confirmed the BlueCruise and adaptive cruise was not working. The hands free BlueCruise and adaptive system will cancel randomly with no warning even while in turn. This almost caused me to slam into the vehicle next to me several times but was able to catch the wheel just in time. This is an extreme danger and hazard. The issue seems to revolve around the lane centering feature but Ford has not confirmed this for me. I dropped the vehicle off with Ford of Franklin on 3/24 who kept the vehicle for 4 days. At the end I was advised Ford engendering was working to push out an update to correct this issue. As of today (5/27), I have confirmed with Ford of Franklin that there is currently no fix for this. I have had to disable Ford BlueCruise and have as of today requested a buyback from Ford. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Hello, I am contacting Ford regarding a serious concern with my newly purchased 2026 Ford Explorer ST. Within days of purchase, we discovered water leaking from the moonroof area into the interior of the vehicle, including water coming through the seatbelt pillar area , wetting the roof as well, during rain and vehicle washes. In addition to the leak, there is noticeable wind and air noise coming from the moonroof area even when the roof is fully closed, (we notified them the day we got the vehicle about this) which raises concerns that the seal is not properly seating or sealing against the vehicle. After noticing these issues, we inspected several similar vehicles on the dealership lot and observed that multiple vehicles appeared to have uneven or improperly fitted moonroof seals as well. This has increased our concern that this may be a manufacturing or assembly defect rather than normal wear or an isolated issue. Because this vehicle is brand new and the issue was reported almost immediately after purchase, we are requesting that Ford review this matter seriously and assist in ensuring the vehicle is properly repaired or otherwise resolved. We are concerned about long-term damage to the interior, electronics, airbags, mold or mildew risks, and the overall value and reliability of the vehicle. We have documented the leak and seal concerns with photos/videos and are currently working with the dealership for inspection. Thank you for your time and assistance.

At approximately 1,700 miles, my brand-new 2026 Ford Explorer ST (3.0L EcoBoost) suffered a sudden, catastrophic engine failure while driving, causing an immediate and dangerous loss of motive power. Prior to the failure, the engine experienced severe misfires. Following manufacturer Technical Service Bulletin (TSB) guidance regarding EcoBoost engine misfires, a step-colder spark plug heat range (NGK LTR7IX-11) was utilized to remedy pre-ignition. Ford Motor Company has denied warranty coverage for this catastrophic powertrain failure, falsely claiming the TSB-compliant heat-range plugs caused the destruction. The sudden loss of engine power poses an immediate safety hazard on public roads. I request an investigation into 2025-2026 Ford 3.0L EcoBoost spark plug issues, pre-ignition failures, and unfair warranty denials leaving dangerous vehicles unresolved."

During driving all safety systems shutdown and give warning of fault Has happened multiple times at different speeds.

The contact owns a 2026 Ford Explorer. The contact stated that while driving at an undisclosed speed, the sunroof glass panel made an abnormally loud sound and shattered without impact. The vehicle was taken to a dealer, but the cause of the failure was not yet determined. The vehicle was not repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 10,000.

While driving my new Ford explorer, with 638 miles on it, on the highway I heard a loud pop, and lost power steering. I was barely able to pull the vehicle over to the shoulder to get off the highway. If I would have been on an interstate or a busier highway it could have been very dangerous. I believe that this has put me in danger having to maneuver the vehicle to the side of the highway and sit there while waiting for a tow truck. The Vehicle was towed to the dealership where we bought it. the service manager told us that the engine had blown, it was a catastrophic failure. There were holes in the oil pan as well as through the top part of the engine from it exploding. I believe that we are lucky that the engine wasn't hot enough to start a fire, as we were only a few miles from the start of our drive. there were no warning lamps or messages prior to the engine exploding. The vehicle is currently at our dealership in Monroe Wisconsin, Alphorn Ford is the dealership.

While operating the vehicle with the cruise control enabled and engaged, the vehicle resets the “set” speed 5 to 15 MPH higher than initially set with no driver input or adjustment and begins accelerating. My spouse related this has happened several times to her at various speed settings. Today, I was on the highway with it set at 60 MPH, the vehicle began accelerating and I noticed the set speed had changed to 75 MPH. I disengaged the cruise control and turned it off. We plan to notify Ford and take it to the dealership for evaluation.

While driving, Sirius XM pushes advertisements to my infotainment display. These notifications are distracting to driving and they WILL cause an accident. This practice should be banned outright and a monetary fine placed on Sirius XM for impairing driving. Completely unacceptable placement of advertisements and it is going to get someone seriously injured or worse.

I was driving home from work on the interstate. It was not overly crowded and not many vehicles around me. I was going the speed limit. All the sudden I heard a loud pop and a very loud sound. I wasn’t sure exactly what happened. I thought maybe I blew a tire so I pulled over to the side of the road. I then figured out that my sunroof had shattered/exploded in my brand new 2026 ford explorer. I just purchased it new on 1/30/26 and it has approx 3k mileage. Luckily I had the shade on my sunroof closed otherwise glass would have been everywhere in my car and all of me while I was driving. I was now on the side of the interstate cleaning glass off the top of my car into a bag so I could continuing driving home and it wouldn’t blow off onto the highway into traffic. Needless to say it took a long time. I have no idea what could have caused this to happen other than a manufacture defect in the glass. It is very scary for that to happen while traveling at a higher speed on an interstate. In addition if the sunshade would have been open. I have not spoken to the dealership or insurance company yet, but will call them tomorrow.

Bought the vehicle brand new on March 13, 2026, and the battery light came on in less than 200 miles driven. The vehicle is currently in Ford's possession.