2021 Ford E-450

Defect. Ford Motor Company (Ford) is recalling certain 2021 E-350 and E-450 vehicles that received an incomplete software update under recall 20V795. The engine cover may become excessively hot.

Risk. Direct contact with certain areas of engine cover surface in the passenger compartment may increase the risk of injury or burns to the skin of the driver or front seat passenger.

Remedy. Dealers will update the powertrain calibration for heat management under elevated idle conditions, free of charge. Owner notification letters were mailed January 7, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SC7. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning December 22, 2025.

Defect. Ford Motor Company (Ford) is recalling certain 2021-2022 E-350 and E-450 vehicles equipped with dual rear wheels. An inadequate connection between the power steering pressure line and the brake hydroboost unit may result in a sudden loss of power steering fluid.

Risk. A sudden loss of power steering fluid can result in a loss of power steering and power brake assist, increasing the risk of a crash.

Remedy. Dealers will replace the power steering pressure line and the hydroboost jumper line, free of charge. Vehicles in this recall were previously recalled under 22V-089 and owners will need to have the new remedy completed even if their vehicle was remedied under the prior recall. Owner notification letters were mailed on June 21, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S07.

Defect. Ford Motor Company (Ford) is recalling certain 2021-2022 E-350 and E-450 vehicles equipped with dual rear wheels. An inadequate connection between the power steering pressure line and the brake Hydroboost unit may result in a sudden loss of power steering fluid.

Risk. A sudden loss of power steering fluid can result in a loss of power steering and power brake assist, increasing the risk of a crash.

Remedy. Dealers will inspect the connection between the power steering lines and the Hydroboost unit, and replace the power steering lines, as necessary, free of charge. Owner notification letters were mailed on March 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S08.

Defect. Ford Motor Company (Ford) is recalling certain 2021 E-350 and E-450 vehicles. The underside of the engine cover may have mispositioned insulation, allowing the cover to get excessively hot.

Risk. Direct and continuous contact with certain areas of engine cover surface in the passenger compartment may increase the risk of injury or burns to the skin of the driver or front seat passenger.

Remedy. Ford will notify owners, and dealers will inspect the engine cover for gaps between the rubber seal and the insulation. If gaps are present, the dealer will install engine cover insulation patches in the right hand and left hand inner lower corners of the engine cover. The dealer will also update the powertrain calibration for heat management under elevated idle conditions should a vehicle be equipped with SEIC or BCP, free of charge. The recall began February 15, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S73.

Defect. Ford Motor Company (Ford) is recalling certain 2021 E-350 and E-450 vehicles. A wire harness in the rear of the vehicle may contact the vehicle frame, resulting in damage to the circuits that support the fuel pump and the anti-lock braking system (ABS).

Risk. Damage to the fuel pump circuit in the wiring harness could result in an unexpected engine stall. Damage to the ABS wiring can lead to reduction of ABS functionality and a loss of roll stability control (RSC) functionality. These scenarios increase the risk of a crash.

Remedy. Ford will notify owners, and dealers will inspect the wire harness for damage. If no damage is found, dealers will apply anti-abrasion tape over the area and ensure clearance to surrounding components. If damage is found, dealers will splice in new wire and apply anti-abrasion tape over the area and ensure clearance to surrounding components. All services will be performed free of charge. The recall began May 18, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S13.

Defect. Ford Motor Company (Ford) is recalling certain 2020 F-550 and 2021 E-350 and E-450 vehicles. The rear axle differential fluid may be below the minimum level, possibly resulting in a failure of the rear axle assembly and driveshaft separation.

Risk. If the driveshaft separates, there may be a loss of drive, increasing the risk of crash. Additionally, if the parking brake is not applied, unintended vehicle movement can occur and increase the risk of injury or crash.

Remedy. Ford will notify owners, and dealers will inspect the rear axle differential fluid level and adjust it, or replace the rear axle as necessary, free of charge. The recall began March 19, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S09.

Airbag module casing is cracked.

Engine camshaft and lifters failed. Truck is at a Ford dealer. Engine could fail in the middle of the road, causing an accident. This is our eighth vehicle with the same issue taken to a ford dealer in the past year. A little knocking noise started that quickly turned into a loud knocking/rattling noise. No lights came on the truck.

See attached document for complaint.

This is one of 4 of my 2021 ford econoline fleet vehicles purchased in 2021 that have had engine failure. I am one of many contractors in my area and others around the country who have had this issue with the same F59 engine. Ford has failed to issue a recall.

Engine camshaft and lifters failed and were inspected by Ford dealer, which corrected the issue by replacing the engine. Engine can failed and truck get stuck in the middle of the road. In the past 6 months its our 4th Ford truck with the same issue and a lot of other Fedex contractors that purchased a Ford truck with the 7.3L engine are reporting the same issue. No warning light was on in this vehicle, just started with a knocking sound that got worse until it got to the dealer and engine had to be replaced

Engine Camshaft and lifters failed, unit was inspected by ford dealer and engine had to be replaced. Engine can stop working and truck could break down in the middle of the road. No warning lamps, just a loud knocking sound when brakes were applied and truck was downshifting to stop. A lot of other people that purchased these ford light duty trucks with the 7.3L engine are having the same issue.

The contact owns a 2021 Ford E-450. The contact stated while parking the vehicle, the steering wheel and brake pedal became stiff, and the vehicle failed to slow down as intended. The contact stated that the brake pedal was continuously depressed for the vehicle to come to a stop. The vehicle was towed to an independent mechanic where it was diagnosed that the power steering hose and fluids needed to be flushed and refilled. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 14,104.

Component= Traction control and cruise control. Safety risk=Driving a Ford e-450 Class C RV on interstate at 63 MPH going generally up hill with cruise control on, the "Service AdvanceTrac" warning light came on dashboard. I Immediately lost cruise control capability and steering became a little shakey. Pulled into rest area shut vehicle off. A few minutes and started again. Error went away and cruise control was functioning. Happened again a few hours later and I did the same thing and continued on. What happened=As I was driving, the " Service Advance Traction" light came on and the cruise control stopped, my class c rv immediately slowed at a high rate, a semi was behind me trying to get over to the middle lane. When I slowed down suddenly due to the cruise control going out, the semi had no choice but to change lanes quickly missing the back of my vehicle by a foot or so. If he was not alert as to what was happening, I most assuredly would not be typing this letter. It was that close!! Note= This also happened last year as we only take the RV out a few weeks out of the year. I brought it to Klammer Ford in New Port Richey F1l immediately after we got back from the last trip. They could not reproduce issue or find anything wrong Lamps= The only warning light that came on was a "Service Advance traction" light. No prior indication of any kind.

My RV is make from 2021 Ford E-450. The power steering fluid leaked out and hard to steer the RV, and lost break. Ford has a recall 2021E-450 under similar situation, but my Vin did not received any recall notice.

The contact owns a 2021 Jayco Redhawk Motorhome built on a 2021 Ford E-450 chassis. The contact stated that while her friend was driving at an undisclosed speed, the brake pedal was depressed and went to the floorboard. The RV was towed to the dealer, who informed the contact that the brake line had deteriorated and needed to be replaced. The RV was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 23,000.

2021 FORD E-450- Recall# 21V-441- heat shield not properly installed in between the LP tank and chassis muffler. Consumer enclosed a copy of the recall notice. Consumer went to an RV dealer in reference to a recall repair. The dealership made a call and informed consumer it could be fixed & would received return phone call that same evening or the next day. Several days passed. Consumer called representative 2 more times within a 3 week period with no return call. Consumer called a 3rd time & requested supervisor return the call. After 6 weeks no one called. The RV has only been used 3 times since purchased. July 2022, consumer received a recall notice from Ford about a problem the power steering hose possible failure. Consumer took unit to dealer the same month for repair. The mechanic stated that although it could be fixed, recall repairs wasn't a priority. Consumer left unit for repair. Consumer called several times for status of repair 7 explained about a trip planned in Aug. & was told it would be ready. The unit was not ready by time specified. After returning from trip unit still was not fixed. Consumer picked up unit unrepaired 2 1/2 months later. Consumer now states: "So what now Thor? What do I do with this unit I can't use and just sits in my driveway. It appears that by the way these people operate that once again 1 may not be able to use the unit this summer. By the way your letter states that it is a third notification on this recall matter however the enclosed

The contact owns a 2021 Phoenix Cruiser RV built on a 2021 Ford E-450 chassis, equipped with a 6400 Series window vent. The contact stated that he became aware that the side window was delaminating. The contact became aware of NHTSA Campaign Number: 21E047000 (Structure, Equipment). The RV was taken to a local dealer and was diagnosed, and it was determined that the failure was related to the adhesive; however, no repairs were completed. The manufacturer was made aware of the failure. The failure mileage was unknown.

We received the two recall notice letters from Ford Motor Company, 20V795 & 22V089, for our 2021 Jayco Redhawk class C RV. Upon receiving the first recall notice, 20V795, an appointment was made with our local Ford Dealer, Spradley Ford Lincoln Mercury, in Pueblo, CO, on Oct 1, 2021 to have it inspected and recall taken care of. Upon arrival that morning, was told they did not have the parts, would have to order them & their technician just called in "sick". Appointment was rescheduled once they had the recall parts in for Nov 15, 2021, again at our local Ford Dealer, Spradley Ford Lincoln Mercury, in Pueblo, CO. Upon arrival that morning to drop the unit off for the recall repair, was turned away again & told I'd have to reschedule as they had a break-in overnight & their technicians' had some tools stolen & would not be working today & they would have the service manager call me to reschedule the appointment once again, which never happened. In March of 2022, we received the second recall notice, 22V089, advising to take it to the local Ford dealer for inspection & repair. I called the Ford Dealer, now Alpine Ford, in Pueblo, CO, several times having to leave a message without a return call. On April 6, 2022, I spoke with [XXX] in Service at Alpine Ford & was informed Alpine Ford would not do the recalls as the new owners refused to do them after purchasing the dealership & referred me to Camping World. I had an appointment at Camping World in Colorado Springs this same day

The contact owns a 2021 Ford E-450. The contact stated while driving the RV 60 MPH with the cruise control feature turned off, the stabili-trac warning light illuminated and the RV decelerated. The contact was able to control the RV, and once the contact turned off and restarted the RV, the RV operated normally. The RV was not diagnosed. The dealer was contacted and stated that the failure was not a known failure. The dealer also confirmed that the RV was not under recall. The manufacturer was not contacted. The failure mileage was 18,000.

CP4 fuel pump explodes leaving me and my family stranded on the freeway for over 7 hours, and stuck 1300 miles from home. Dodge has already recalled and repaired there trucks. My truck is 2021 with 50k miles and now I'm expected to pay $15-20k for the damage's

The contact owns a 2021 Ford E-450. The contact received notification of NHTSA Campaign Number: 22V089000 (Steering, Service Brakes, Hydraulic). The contact stated that the vehicle was taken to the dealer where the vehicle was inspected however, while making a turn into a service station, the steering wheel became difficult to maneuver. No warning lights were illuminated. The contact then stated that she was directed to a leak coming from the vehicle. The contact notified the dealer, and the vehicle was towed to an independent mechanic where it was diagnosed that the hydro-boost power failed and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and covered the cost of the tow, but no further assistance was provided. The failure mileage was 4,826.

2021 FORD E-450. CONSUMER WRITES IN REGARD TO SAFETY RECALL NOTICE 22S08. THE CONSUMER REQUESTED ASSISTANCE LOCATING A DEALER WITHIN A REASONABLE DISTANCE TO PERFORM THE RECALL REPAIR.

Driving in about 30mph gusting cross winds which required constant small steering corrections. Sudden loss of braking ABS, loss of Cruise Control, loss of Pre-Collision Assist, loss of Hill Start Assist, and related functions. Warning message: Service AdvanceTrac. Three incidents First and second incidents: After sitting with ignition key off for about 15 minutes, vehicle operated as normal. Third incident: Would not normalize after setting with ignition key off. Faults continued.

The contact owns a 2021 Ford E-450. The contact received notification of NHTSA Campaign Numbers: 20V795000 (Engine) and 22V089000 (Steering, Service Brakes, Hydraulics) however, the parts to do the recall repairs were not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available and Parts distribution disconnect respectively.

ADAS keeps faulting and disabling the cruise control, pre-collision braking, hill hold assist, and skid control functions. The event occurs at highway speeds with strong crosswinds that rock the vehicle in a busy side-to-side motion as gusts hit the vehicle. The system seems to reset after turning the engine off & restarting. But the loss of some of the safety features is worrisome in traffic.