2023 Toyota RAV4

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2026 Toyota, Lexus, and Subaru Solterra vehicles equipped with a Panoramic View Monitor (PVM) system. Please see the recall report for a complete list of models. A software error may cause the rearview camera to freeze or display a blank screen when the vehicle is in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Risk. A rearview camera that fails to display an image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy. Dealers will update the parking assist software, free of charge. Owner letters were mailed January 2, 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB13 and 25LB06. Subaru's number for this recall is WRE25.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2024 Toyota Venza, 2023-2025 RAV4 Prime, RAV4, Highlander, GR Corolla, Crown, 2024-2025 Lexus TX, LS, Toyota Tacoma, Grand Highlander, and 2025 Lexus RX, Toyota Crown Signia, Camry, RAV 4 Plug-in Hybrid (PHEV), and 4 Runner vehicles. Due to an error in the instrument panel software at vehicle startup, the instrument panel may fail to display vehicle speed, brake system, and tire pressure warning lights.

Risk. An instrument panel display that does not show critical information can increase the risk of a crash or injury.

Remedy. Dealers will update the instrument panel software over-the-air (OTA) for non-PHEV vehicles, free of charge. For PHEV vehicles, dealers will inspect the instrument panel assembly, and either replace it, or update the software, free of charge. Owner letters were mailed December 5, 2025. Additional letters will be sent, anticipated in May 2026. This is a phased recall. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB08 and 25TA08. Lexus' numbers for this recall are 25LB05 and 25LA05.

Defect. Gulf States Toyota, Inc. (GST) is recalling certain 2023 Toyota RAV4 vehicles equipped with 17" black alloy accessory wheels. During installation of the alloy wheels, the tire valve stem may have been improperly installed or damaged. In addition, the load carrying capacity label may state the incorrect weight. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Risk. A damaged or improperly installed valve stem may allow air to leak and/or the tires to be underinflated, increasing the risk of tire failure and a crash.

Remedy. Dealers will inspect and, if necessary, replace the wheel valve stems and replace the load carrying capacity modification labels, free of charge. Owner notification letters were mailed on August 18, 2023. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 23R1.

A 2023 Toyota RAV4 Hybrid XSE, purchased October 17, 2023, has experienced serious, recurring safety-related electronic failures for more than two years. The rearview backup camera intermittently displays a completely black image, even while other camera display functions remain operational. The multimedia/navigation screen also malfunctions or goes black while driving, causing navigation directions to disappear unexpectedly. These failures create dangerous conditions. Loss of the backup camera compromises a critical safety feature when reversing, particularly around pedestrians and children. Unexpected display failures while driving can cause dangerous distractions and increase the risk of a collision, serious injury, or death. Toyota's authorized dealership technicians have PERSONALLY WITNESSED these malfunctions. Despite repeated service attempts on April 16, 2025; September 24, 2025; September 1, 2026; and October 2, 2026, the vehicle has NEVER been permanently repaired. The dealership repeatedly returns the vehicle with the same problems unresolved or recurring. Only after escalation did Toyota suddenly claim to have identified a possible repair. However, the earliest available appointment with a loaner vehicle is November 24, 2026. After years of unsuccessful repairs, this is completely unacceptable. NHTSA Safety Recall #25V744000 describes the same type of blank or frozen rearview camera malfunction. This vehicle exhibits substantially similar symptoms. An urgent inves

The rear fixed panoramic roof glass panel spontaneously shattered while driving on the highway at 70 mph with no external impact or road debris present. The shattering sounded like a gunshot. The sliding panel below the glass was closed at the time, but this could have been a major safety issue if it was open and glass shattered into the vehicle and hit the driver. The roof glass was inspected by the collision center and our insurance company covered it as a comprehensive claim with zero evidence of a collision or impact. There was no warnings prior to failure of the glass.

The contact owns a 2023 Toyota Rav4. The vehicle was previously taken to the dealer to be repaired under NHTSA Campaign Number: 25V595000 (Electrical System); however, the dealer repeatedly delayed the repair due to parts availability issues. The dealer kept the vehicle for the duration due to the instrument panel failing. Once the parts had arrived and the repairs started, the dealer declined to complete the recall repair because the vehicle had accumulated too many miles. The failure mileage was 126,293.

My daughter was driving it on the interstate and I was the passenger. When she got up to 60MPH, the hood of the car began a slight vibration. When she got up to 70MPH, the hood began to flutter. As soon as possible, she exited the interstate so that I could be sure the hood was closed properly. It was, but it was still possible to press down on the hood. Though I've had the car two years, most of my driving is local with speed limits far below 60MP. The few times I've been on open highway, I can't see the hood seated in the driver's seat...I am short. I've found information on the Internet that this is a known issue with Rav4's in a certain year range. I have NOT been able to find out if it is only some Rav4's in those years or all models. I feel this is a safety issue....what is to keep the hood from flying open or OFF at highway speeds? Is the buyer expected to drive under 60MPH for the life of the vehicle? This defect WAS NOT disclosed when I purchased the car in 2024.

While in stop and go traffic during heavy rain, vehicle stalled and would not restart. After several attempts, it did restart but ran very rough. A couple days before, a red warning light came on for the steering system, also during a rain event.

Vehicle produces a plastic-sounding grinding noise from the brake area whenever the vehicle rolls over a rough or uneven road surface while braking. This has occurred since purchase of the vehicle and continues to occur as of current mileage (approximately 45,000 miles). The noise is distinct from normal brake pad wear squeal -- it sounds like a hard plastic component grinding or rattling, correlated specifically with braking over bumps/uneven pavement rather than constant or speed-dependent. The dealer has not yet inspected this specific complaint. Other owners of the same model year have filed similar NHTSA complaints describing brake grinding/squealing noise beginning well under 10,000 miles, with one referencing a technical service bulletin for brake noise on 2019-2023 model year vehicles of this make/model, suggesting this may be a widespread condition rather than an isolated defect.

Fuel gauge needle drops to empty when approximately one-quarter tank or more of fuel remains. First noticedXXX; the exact day is approximate (first noticed sometime in XXX). Dealer (Toyota of Gastonia, [XXX], phone [XXX]; repair order XXX dated XXX) diagnosed a suspected deformed fuel tank and faulty fuel level sender causing improper fuel level readings, and quoted $1,788.85 for tank removal, inspection, and tank assembly replacement. This is the same defect family Toyota acknowledged in Technical Service Bulletin T-SB-0109-20 and Customer Support Program 20TE04 (fuel tank shape variation causing the fuel sender gauge to read incorrectly) for 2019-2021 RAV4 Hybrids. The vehicle is a 2023 RAV4 Hybrid exhibiting the same failure. Inaccurate fuel level readings prevent the driver from knowing the actual fuel remaining, creating a risk of unexpected fuel exhaustion and stalling. Dealer has submitted a coverage request to Toyota; no resolution yet. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

1. System Failure & Availability: Vehicle's automated driver-assist (Lane Tracing/Keeping Assist) and steering modules failed. The vehicle is intact and available for inspection under a strict spoliation hold at an independent facility. 2. Safety Risk & Injuries: On a curve at ~50 mph, the automated steering suffered a violent uncommanded intervention, overrode human control, and jerked the wheel out of the driver's hands, causing a head-on collision with a tree. Injuries required immediate ambulance transport. Diagnoses include a concussion, a severe large left leg hematoma with extreme swelling, open wounds, and deep tissue trauma causing foot numbness. This required a secondary ER return and an active orthopedic referral from a specialized Wound Care Center. 3. Problem Reproduction: The vehicle was rendered a total loss and is non-operational, preventing physical test-driving. The defect is expected to be confirmed forensically via electronic diagnostics. Onboard modules contain recorded Pre-Crash Steering Torque Discrepancies and Vehicle Control History (VCH) metrics showing the automation overrode manual input. 4. Inspections Conducted: The manufacturer's corporate liability division opened an accident investigation. A signed Imaging Authorization form is executed; corporate technicians have contacted the driver to finalize the date to download Event Data Recorder (EDR) logs at the yard. The auto insurer explicitly refused to inspect the vehicle or download data, citing

The exterior plastic parts on this 2023 Toyota RAV4 XLE Premium are warping, bubbling, and melting. It began with both side mirror covers (left and right). Later, the black plastic trim panels alongside the rear windows (rear pillar trim) began failing the same way. The damage is on different parts, on different sides of the vehicle, and appeared at different times. All affected parts are still on the vehicle and available for inspection. The manufacturer claims the cause is "solar convergence" or "outside influence" — sunlight reflecting off a window. This does not hold up. Sunlight is not selective. It cannot single out only certain black plastic pieces and melt them while leaving the paint, glass, and every surrounding surface undamaged. If concentrated sunlight were really hitting these areas, the nearby surfaces would be damaged too — and they are not. The only thing the failed parts share is the type of plastic they are made from. That points to poor-quality material that cannot handle normal sun and heat, not to an outside cause. I first reported this to a Toyota dealership while the vehicle was still under warranty. The dealership took photographs and sent them to the manufacturer's regional representatives. The claim was denied based on those photos alone. No one physically inspected the vehicle, and no one ever identified the specific window or surface supposedly responsible. A denial based on an unverified theory, with no inspection, is not a credible finding of th

The "failed or malfunctioning" system is the JBL infotainment system software, and it is available for inspection upon request. The safety of others and my own safety was compromised by the system's natural but inconsistent tendency to often default to the Toyota "Experience Drive Connect" advertisement screen rather than immediately resuming apple CarPlay or android auto. The reason this is a safety concern is because attention is taken away from the road to click the CarPlay/android auto button on screen to resume navigation, causing a risk of diverted attention and potentially collisions. The problem is easily reproduced by the vehicle owner, it has not been brought to the attention of a dealer or service center. The vehicle/component for this specific issue has not been inspected by the manufacturer, police, insurance or others. No other symptoms.

The rotating mechanism does not allow the seat to lock properly.

The backup camera display only works intermittently. About 75% of the time the screen is blank when I put it into reverse

The contact owns a 2023 Toyota Rav4 equipped with Firestone Tires, Tire Line: Destination LE2, Tire Size: 225/65/R17, DOT Number: [XXX]. The contact stated that while driving on [XXX], the red light illuminated and there was an abnormal rumbling sound. The contact pulled over at the exit and became aware that the outside circumference of the tire was shredded on the driver’s side rear tire. The tread was in good working order. The vehicle was taken to the local dealer, where all four tires were replaced. The manufacturer was contacted and informed the contact about rebates on the tires. The tire and failure mileage was approximately 58,000. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle experienced a sudden, severe loss of vehicle control while driving twice. Without any warning lights, dash indicators, or stored error codes, it began violently surging and decelerating uncontrollably around 20 mph with severe bucking. My [XXX] daughter was driving. Fortunately, this occurred on a quiet local residential road at 5 am; had this sudden failure occurred at highway speeds, it would have resulted in a catastrophic rear-end collision. The vehicle was purchased in May 2023, has 42k miles, and was used normally for school commuting. Incident 1 (XXX): Towed to Toyota. Techs could not diagnose it and opened a Tech Case. Per instructions, dealer replaced shifter assembly due to internal short (Part 33560-0R070). However, within 24 hours of return, the exact same dangerous failure reoccurred suddenly without warning in mild traffic. Experiencing an uncontrollable vehicle was terrifying. Fortunately no crash occurred, but it was towed back immediately. When I raised urgent safety concerns and sought a permanent resolution, Toyota stated it takes 60 days for review. During this period, if the dealer requests loaner return, I must return it immediately. They further stated that as soon as the dealer declares the vehicle "ready for pickup," I must retrieve it immediately or be charged daily storage fees. When I asked how the dealer could diagnose and repair the car entirely on their own—without Toyota Corporate engineering instructions while Toyota is supposedly

Front forward camera unavailable, World wide shortage of part. No known date of supply.

Description of the Defect:I am reporting a premature and dangerous failure of the electronic door lock actuators on my 2023 Toyota RAV4 Hybrid SE. The issue began with the driver’s door lock intermittently failing to respond to the key fob and the internal master switch. Shortly after, the rear passenger door developed the exact same failure. Both doors can now only be operated strictly by manual intervention. The vehicle currently has over 36,000 miles, meaning this safety-critical component failed immediately after the expiration of the manufacturer's bumper-to-bumper warranty.Safety Risk:This component defect poses a severe safety hazard. In the event of a severe crash, electrical failure, or fire, passengers (especially children or occupants in the rear seats) face a high risk of entrapment, as the doors cannot be unlocked electronically for a quick evacuation. Furthermore, because the doors fail to lock automatically while driving, the occupants are left vulnerable to carjacking or external intrusion at intersections, and the doors could potentially be forced open by a child pulling the lever while the vehicle is in motion. This is a well-documented systemic issue across Toyota's 5th generation RAV4 platform, and a safety recall is urgently needed

The contact owns a 2023 Toyota Rav4. The contact stated that while her husband was driving approximately 25 MPH, there was an abnormal bang coming from the vehicle, and the rear glass shattered without impact. The vehicle was taken to a local dealer, and the contact was informed that the damage was not covered under warranty. The contact was provided an estimate for the repair. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was approximately 57,079.

On August 6 2026, my RAV4 just cut off at the traffic light. The car was completely dead. I was unable to unlock the trunk but the doors did open. The vehicle was towed to the local dealership. The tow truck man hooked up his portable car charger and the car started. On August 8, 2026 the car cut off after parking in a parking space and would not start so I had to get a jump off. After driving for approximately 50 miles to home, I got a low voltage warning and a statement the battery is charging. The local Toyota dealership did a diagnostic test on August 11, 2026 and stated the battery, starter, and alternator were okay. The same thing happened again on August 12, 2026. The car just cut off after stopping in the parking lot. After getting a jump off, I received a message that the battery is charging. Also, the car shifts speed while driving.

Driving South on [XXX] and almost to [XXX] about 60 MPH. The rubber roof drip moldings released and starting flying against my car very hard, this was beyond scary. I had to pull over and try to tuck them in, they are so worn and keep scratching my car from hitting it and could possibly break window or fly off damaging another vehicle. These rubber moldings have flown all over the place ever since I got vehicle in 2023, I have continually tried to glue them in they won't stay. There is one on each side and their both loose, I keep pushing back in but won't stay. They have scratched my paint and trim so badly. I called and reported to Toyota they didn't care. They told me you shouldn't run vehicle through car wash, that was a very dumb response, everyone uses car washes. I don't have time to hand wash my vehicle weekly, this should be made to go through a car wash. This is my company vehicle and its the most dangerous vehicle I've ever driven, I'm working in it all day long. I would never buy this vehicle because of this issue, I don't feel safe. Everyone at my company that has this vehicle has the same problem. We purchase all our fleet cars from Toyota and are a huge company Nationwide, Old Dominion Freight Line. This is a major hazard and I'm asking you publish a recall immediately, Toyota needs to fix this dangerous issue and should not sell a vehicle like this. Please I'm asking for your help, thanks so much. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT

While making a left turn in my 2026 Toyota RAV4, the vehicle's Automatic Emergency Braking / Pre-Collision System suddenly activated without cause. The system sounded an audible warning beep and forced the vehicle to brake and come to a hard stop mid-turn. There was nothing in front of me that should have triggered the system. This put my safety and the safety of other drivers at risk. The forced stop occurred suddenly and unexpectedly while turning, which nearly caused an accident, as vehicles behind me had no warning that I would suddenly brake mid-turn. There were no warning lamps or dashboard messages prior to the incident — the false activation occurred suddenly with no prior symptoms. I have dashcam footage of the incident attached below.

Hello Respected Sir/Madam, I am the owner of a 2023 Toyota RAV4. I discovered a visible hairline crack in the windshield that originated from the lower left corner on the passenger side. The crack measured approximately 6 inches when I first noticed it in the morning and grew to approximately 12 inches by the afternoon. The windshield was not impacted by a rock, road debris, or any other object, and the vehicle was not involved in an accident. There were no visible chips or signs of external damage at the point where the crack originated. The crack appeared to develop spontaneously and continued to spread on its own. I am submitting this complaint because I am concerned that the windshield may have a manufacturing or installation defect that could affect visibility and vehicle safety. Thank you [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am reporting a serious safety concern involving the rear passenger-side seat belt in my 2023 Toyota RAV4. After normal use, a child who had been properly secured in a child booster seat in the rear passenger-side seating position was unable to be released from the seat belt. The vehicle had not been involved in an accident, collision, or any emergency situation. The child had simply been riding in the vehicle under normal driving conditions. When it was time for the child to exit the vehicle, the rear passenger-side seat belt had become tangled and tightened around the child. The seat belt would not unlock or release despite repeated attempts to unbuckle it and allow the belt to retract or loosen. The restraint effectively trapped the child in the booster seat. Because the child could not be freed using the seat belt release mechanism, the only way to remove the child safely was to cut the seat belt. This occurred solely because the seat belt could not be released after ordinary use, not because of a crash or any other unusual event. A seat belt is intended to protect occupants while also allowing them to exit the vehicle safely after normal operation. In this case, the rear passenger-side seat belt failed to function as intended and created a serious safety hazard by trapping a child and requiring the seat belt to be cut in order to free them. I am requesting that this incident be investigated to determine whether the rear passenger-side seat belt or its locking mechanism

Door locks not working front doors had actuators replaced after about a year and a half . They have since went out again.

I am writing to formally express my concern regarding the premature oxidation developing inside the tail lights on my 2023 Toyota RAV4 XLE. The oxidation is present on both the driver and passenger side tail light assemblies. As the oxidation continues to worsen, it reduces the clarity and effectiveness of the tail lights. This is not only a cosmetic concern but also a potential safety issue. Diminished light output can make it more difficult for other drivers to clearly see my brake lights, tail lights, and turn signals, particularly during nighttime driving or in adverse weather conditions. This increases the risk of rear-end collisions and compromises the safety of both myself and other motorists. I have taken good care of my vehicle, and I do not believe this level of deterioration is reasonable for a 2023 model. Exterior lighting components should remain clear and functional for many years under normal use. The fact that both tail lights are experiencing the same issue suggests this may be a manufacturing or material defect rather than normal wear and tear. I respectfully request that Toyota investigate this matter and inspect my vehicle under the applicable warranty or goodwill policy. If this is a known issue affecting other 2023 RAV4 vehicles, I ask that Toyota consider replacing the affected tail light assemblies at no cost. Vehicle lighting is a critical safety feature, and I believe it is important to address this issue before visibility is further compromised. I h

The contact owns a 2023 Toyota RAV4. The contact stated that while driving at 46 MPH in heavy rain, a warning message indicating that the pre-collision sensor was blocked and needed to be cleared, was displayed temporarily, and the contact continued driving. The contact stated that the vehicle suddenly lost motive power shortly after, and the message "Steering power is low; please contact dealer" was displayed. The vehicle stalled and failed to restart.The following day, the contact's husband successfully restarted the vehicle, but the vehicle immediately stalled again, displaying a "Pre-collision malfunction; please call dealer" message. A local dealer was contacted, and the contact spoke with a receptionist regarding the battery, but the vehicle was neither diagnosed nor repaired. The manufacturer had not been made aware of the failure. The failure mileage was approximately 58,829.

Back up camera stopped working screen is black when put into reverse. Approximately 2 weeks after camera stopped working warnings appeared on dash headlight system malfunction pre collision system malfunction rear cross traffic alert malfunction blind spot monitor malfunction LTA malfunction. There is no current recalls on this particular car but others of same make and model have recalls with same issues

Odometer shows incorrect speed than actual.

Vehicle was traveling straight approximately 70–80 mph in very light drizzle. No warning lights or messages before the event. Vehicle suddenly entered an uncontrolled spin multiple times. During the spin, I heard a grinding noise. After stopping, brake/parking brake system warnings appeared on the dash, video after the event recorded.

The front camera is known to overheat in weather that exceeds 70°F. Which disables the AEB, Cruise Control, Lane Keep, Automatic Headlights, and Automatic Wipers.

I have owned this vehicle close to three years and these were the all season tires that came with the car.I live in New England where I run snow tires on the car from October to April every year that I have owned the car. The car has 30K miles on it ,but the tires that came with the car only have about 10K or 7/8 tire tread left. The tires have become very noisy and are starting to cup. I did take the car to the dealer and had the front end checked out and nothing is worn or out of alignment. Tires were rotated at 5K intervals .I contacted Dunlop and was told there was not much they would do since the tires were made when Dunlop was owned by Goodyear. Dunlop is now owned by Falken. I was offers 30% off a new set of tires (Dunlop) as a good will gesture. A new set of tires will run about 1K with tax and mounting/balance. I should have to spend that kind of money on tires that are not worn, just poorly made. Falken admitted that they have a lot of complaints about this tire. Tire size is 225/60R18/ 2023 Toyota RAV4 XSE

I was driving across a mountain pass in Washington State at an elevation of approximately 4,000 ft. With no warning I hear a very loud noise, sounding like a gunshot. I was in pretty heavy traffic and pulled over as soon as it was safe. A walk around the car revealed no problems, but looking at the top of the car showed that the glass over the sunroof had imploded. I'm not a fan of sunroofs and I may have never opened it. My favorite AI search engine Gemini had plenty of information. I experienced what is known as a spontaneous sunroof implosion/explosion. Fortunately, neither my passengers nor I was injured. Toyota is not accepting responsibility for these incidents.

The display goes black and then will restart. It foes this over and over. The navigation and other features can’t be used and it will not stay on long enough to try and update.

My car has shut off for a second time without warning. This time was in a busy chic [XXX] drive through line in [XXX] . The car read “low power steering” and the battery and engine light came on. These have both been checked before in addition to the alternator and they cannot find an issue. I am having it taken back to the dealership tomorrow for further investigation. Given I purchased this vehicle with a little over 19k miles and the car now only has 22k miles on it. It should not have any significant issues such as cutting off while driving on the interstate or while sitting in a busy drive through lane waiting for food. Now I am wondering if the previous owner traded it in for this issue. I will say, both incidences it has been raining and the first time I could have been hit by oncoming traffic due to low visibility and I am wondering if heavy rain has something to do with this. The car has not been through any significant puddles or left out in the rain. It sits in the garage when not in use and has only been used as a work commute vehicle. Something is wrong. They need a recall! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The video display screen shuts off while driving. You end of trying to get it going again while driving and getting distracted. Ongoing issue over a dozen times in last 2 years.

The contact owns a 2023 Toyota RAV4. The contact stated while the vehicle was parked, the hatch door glass independently fractured. The vehicle was taken to an independent mechanic and repaired. The contact was informed that the failure was a known failure with the vehicle. The dealer was made aware of the failure but provided no assistance. The manufacturer was not made aware of the failure. The failure mileage was approximately 119,000.

Nav Screen randomly goes black for variable amounts of time.

Was moving forward when all of the sudden the tailpipe flew off (metal thing in the muffler). No real cause, moves the vehicle normally oyt of the driveway and it just flew off.

During the day after driving in rain in a 2023 Rav 4 LE AWD with 19000 miles car turned off. I was parked with it idling and with no warning stalled. I turned on multiple times and it kept stalling out. Finally a message appeared on dash "power steering low". After inspecting under hood and seeing all fluids ok I tried car again (maybe 10 min) and it started. Drove around parking lot it was fine. Drove to my mechanic. No error codes, battery was in good shape. This is very concerning. Suspect water in a hard rain somehow got in car. I was on major roads prior to parking, no huge puddles. Others online have mentioned this issue with no real answer and fears this will occur again while driving. NEEDS A RECAL.

I have a limited service campaign from Toyota 25TD01 that my local authorized Toyota dealer refuses to repair. The dealer is Classic Toyota of Henderson

When I put the vehicle in reverse the backup camera is displaying a black screen. I looked up recalls and see there is a recall on RAV4’s for this very issue, but my VIN shows no recalls. I called service at Hubler Toyota in Greenwood IN and they confirmed my VIN is not included in the recall. I want to know why it is not included. I am taking it to Hubler tomorrow for diagnostic and repair. I called Toyota manufacturing to report the incident and was advised to contact NHTSA.

System states Pre System Collision Malfunction- Parking Brake Malfunction- secondary collision Malfunction warnings. AWD system malfunctions

The vehicle exhibits a consistent and reproducible malfunction in the powertrain system, specifically related to acceleration response and drivetrain engagement. While driving at a steady speed, when the accelerator is pressed gradually (approximately 50–60%), the engine RPM increases but the vehicle does not accelerate accordingly. There is a delay in power delivery. When the accelerator is released, the engine may continue revving briefly, followed by a sudden and jerky engagement of the drivetrain. This issue occurs consistently under the same driving conditions and can be reproduced every time. The vehicle is available for inspection upon request. This malfunction creates a safety risk when merging into traffic, entering intersections, or making turns. The vehicle does not respond when acceleration is required, which can lead to dangerous situations where other vehicles may approach at higher speeds. After the delay, the vehicle may surge forward unexpectedly, increasing the risk of collision. The issue has been reported to multiple authorized Toyota dealerships on several occasions within the first 15 months of ownership. The vehicle has been inspected by dealership technicians, but the concern has not been diagnosed or repaired. Dealerships have stated that the behavior is normal, despite the repeatable nature of the issue. No warning lights, error messages, or diagnostic indicators have appeared at any time. No diagnostic trouble codes have been reported. The vehicle i

The 2023 Toyota RAV4 8-speed transmission is catastrophically defective and poses an immediate safety hazard. It exhibits severe hesitation, slipping, and lurching when accelerating from a stop or low speed, and when attempting to merge into high-speed traffic (I-15/Las Vegas), creating a high risk of rear-end collisions. During these events, the RPMs spike and fall rapidly but the vehicle fails to accelerate. Furthermore, the vehicle lunges forward while the brakes are applied. The engine actively fights the braking system, requiring extreme physical force to stop the car and prevent front-end collisions. This lunging has repeatedly triggered the Pre-Collision System, causing the seatbelts to lock and tension against the driver’s body. Additionally, the vehicle exhibits steering resistance and feedback during turns, making it difficult to maneuver safely. The local dealership (AutoNation Toyota Las Vegas) inspected the vehicle and claimed these life-threatening behaviors are "normal" for this model.

Sat in driver seat, closed driver seat door, and the rear window shattered. There was no impact or other incident to the glass.

Had safety inspection done when having oil changed on 3/5/26. was informed by dealer that it needed both outer tie rod ends replaced has play in it. this came to a cost of $735.00 with alignment. Of course not covered by vehicle warranty which is useless at this point. I have never had this problem on any vehicles I have owned since starting to drive in 1975. This is a safety and quality issue and I should be reimbursed. I will seriously think about about an American owned company in the future. Having Friend at another dealership TCO 3/18/26 I was away last week and SUV parked in garage.

Rear hatch fails repeatedly to open. it locks up. it failed to shut too and damaged a rear taillight, forcing me to bring it to toyota. i had toyota dealer look at it twice now. from jan up to mar of this year. they had my car 2 weeks. even after replacing hatch struts and hinges,it still happens. it has to be an electrical, mechanical, or computer issue causing it. new vehicle, now under 20k mi. the hatch is widespread in rav4 models and I've found soo many reports online of same problem. this needs to be investigated more and fixed and recalled.

On a rainy day after driving on the interstate, I pulled into a drive thru. Once there and idling for a few minutes, I tried moving forward and the car rough idled, shows message on dash "Engine Stopped, Power Stering Low" and had reduced engine power and no power steering and then stalls out. I tried turning it back on and it stays on for less than 3 seconds and shuts off. I had it towed to the dealer and they say there are no codes. After reading online, multiple other users experienced the exact same thing when its raining, wipers were on and they were idling after a trip on the interstate. If this would have occurred on the interstate and I lost engine power and reduced steering, it would cause major safety concerns. There were no warning lights prior to the issue and the only thing that flashed for a second when the engine stalled was the power steering, check engine and battery light. Toyota checked the battery and said its at 100%. Dealer cannot identify and issue, but I couldnt drive, had no power steering and had to have the car towed.

Few days back got a message "voltage abnormality steering power low" a few times. Today, got a message saying the sensors indicated on the form are malfunctioning. Car is 2.5 yrs old with 23.5k miles on it.

The contact owns a 2023 Toyota RAV4. The contact stated that while driving at an undisclosed speed, the vehicle was swaying back and forth. There was no warning light illuminated. The contact stated that the vehicle became inoperable and failed to properly switch lanes. The vehicle was taken to the dealer, where it was diagnosed and determined that the front and rear wheel alignment had failed and needed to be repaired. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer, but was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 74,000.

The contact owns a 2023 Toyota Rav4. The contact stated the front passenger’s side Occupant Classification System (OCS) sensor failed to detect an occupant seated in the passenger’s seat and was deactivated on the instrument panel. The dealer was contacted and informed of the failure; however, the vehicle had not been taken to be diagnosed or repaired. The contact researched and found information on NHTSA Campaign Number: 22V519000 (Air Bags) and associated the failure with the recall. The manufacturer was informed of the failure, and the contact was informed that the VIN was not included in the recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 57,500