2021 Kia Sportage

Defect. Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Risk. A fire while parked or driving can increase the risk of injury.

Remedy. Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect the vehicle, and, as necessary, replace the fuse and/or tow hitch harness module, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC249.

Defect. Kia Motors America (Kia) is recalling certain 2017-2021 Sportage and Cadenza vehicles. The electrical circuit in the Hydraulic Electronic Control Unit (HECU) may short-circuit, which can cause a fire in the engine compartment.

Risk. An engine compartment fire can increase the risk of injury.

Remedy. Owners are advised to park outside and away from structures as a precaution until the recall repair is complete. Kia will notify owners, and dealers will replace certain fuses in the electrical junction box. Vehicles equipped with an electronic parking brake (EPB) will also receive a HECU software update. Repairs will be performed free of charge. The recall began on April 30, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC206.

Severe structural manufacturing defect in my 2021 Kia Sportage. A physical hole has formed in the floorboard on the driver side directly next to the pedals, creating an immediate risk of a catastrophic accident. The vehicle also has chronic failure of the air conditioning system, documented by Sunset Kia of Sarasota as a leaking evaporator. This prevents the windshield from defrosting during heavy Florida rains, severely impairing visibility. Dealer confirmed these hazards under a signed repair order on June 3 2026, but Kia Corporate closed case 25175676 without any physical technical inspection, leaving an unsafe vehicle on the road.

See attached document for complaint.

The hose connected on the antifreeze leak into the engine compartment

On June 14, 2026, the driver experienced sudden rough engine running followed immediately by a flashing check engine light. The vehicle was towed to the selling dealer, which has performed all prior maintenance. The vehicle is currently at the dealership and available for inspection. Technician notes show DTC P1326 was stored — the Knock Sensor Detection System code associated with connecting rod bearing wear on Kia's Theta II engine family. The technician performed an audible knock check only (none heard) and cleared the code. The vehicle was found approximately 2.5 quarts low on oil due to an internal turbo oil leak. The dealer's notes state the code "may be related" to low oil — hedged language, not confirmed causation. The dealer confirmed the turbo failure but has not performed a bearing clearance test to confirm or rule out bearing damage from the low oil condition. The dealer performed a turbocharger replacement. Despite a verbal commitment from the service manager that a bearing clearance test would follow, no such test was performed 40 days later. When the vehicle was declared ready, the service manager did not recall the commitment and suggested driving 40-50 miles as an alternative. Kia America opened a formal case last month and authorized a partial goodwill adjustment but no one has addressed the safety concern of the unperformed engine test indicated by the thrown code. Driving a vehicle with potential connecting rod bearing wear risks catastrophic engine failur

The infotainment center screen in my 2021 Kia Sportage is DELAMINATING. The uv gel adhesive that holds the screen is failing. This is a known widespread safety issue as many controls are handled through the infotainment touch screen as well as the screen displaying the back up camera visability. You should force Kia to fix this problem past 3 years /36000 miles! Please advise me.

The contact owns a 2021 Kia Sportage. The contact stated that while parked on several occasions, a "Battery Discharge Warning" message was displayed, which disappeared once the vehicle was driven. The contact then stated that on several occasions after the vehicle sat unoperated for a day, the engine failed to start. The contact's husband jump-started the vehicle on multiple occasions and noticed that the battery was completely drained. The contact's husband replaced the battery approximately three times; however, the failure persisted. The vehicle was taken to an independent mechanic, where it was diagnosed with an electrical issue, requiring repair or replacement. The contact was advised to take the vehicle to a dealer for a full diagnosis. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 55,000.

The contact owns a 2021 Kia Sportage. The contact stated that while driving at undisclosed speeds, the drain plug detached, and oil started leaking from the oil pan. The accelerator was depressed, but the vehicle failed to move and stalled while driving on the highway. The vehicle failed to restart. The oil light illuminated after the failure. The vehicle was towed to an independent mechanic who determined the oil cap had detached. The mechanic informed the contact that the vehicle was difficult to start. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 60,000.

While driving southbound on Route 93 on 6/11/2026 during the morning commute, my 2021 Kia Sportage suddenly sputtered and lost the ability to accelerate. I was traveling about 65 mph in heavy traffic when the vehicle abruptly lost power without any warning lights or prior symptoms. As my speed dropped, I had to cross multiple lanes to reach the breakdown lane, creating a dangerous situation for me and surrounding drivers. The vehicle had to be towed to a repair shop, where I was informed that the high‑pressure fuel pump had failed and needed to be replaced. The car has only 22,000 miles on it and is just one month out of warranty. This sudden loss of drive power at highway speed poses a significant safety risk.

While I was driving in the interstate my car when in limp mode while I was trying to pass a semi. I had my children in the car and was stranded on the side of the road. No warning lights ever came on before hand. My mechanic said it was a problem with my engine and it’s common in Kia’s in but doe not include my year. It’s a costly repair for a car that’s not even 5 years old.

Loosing oil constantly. Always on the low end. I am having to keep oil in my car to put in it when needed which is often.

The engine in my 2021 Kia Sportage failed while being driven at highway speeds on US 131 in Michigan. The car was taken to the closest gas station where the oil was checked and it was determined that 5 quarts were needed to reach the dipstick's full line. The fact that the car had consumed 5 quarts of oil seems to be a major safety concern. I've attached a note with additional information that has also been submitted to Kia; a case number has been provided. However, after several weeks, there hasn't been any progress. I haven't even been able to get Kia to provide information as to the fundamental root cause of the engine failure.

On March 4, 2026, the engine in my 2021 Kia Sportage malfunctioned while I was driving on a local road on Long Island, NY. The check engine light illuminated, the vehicle lost the ability to accelerate normally, and the steering wheel became heavy and difficult to turn at the same time. This created a serious safety risk, as I was unable to maneuver or accelerate normally and could have been stranded in an active roadway or unable to avoid a collision. The vehicle was able to restart but was towed as a precaution and transported to service. An independent repair shop examined the vehicle and identified the issue as an engine problem, advising that the repair should be covered by Kia. I delivered the vehicle to Kia Smithtown, an authorized Kia dealership, on March 9, 2026. As of today, the dealership has had the vehicle for approximately six weeks and has not yet completed a formal diagnosis or begun the repair, and no loaner vehicle has been provided. No police or insurance inspection has occurred. The check engine light first appeared at the moment of the failure on March 4, 2026; there were no clear warning symptoms prior to that. The vehicle remains in the possession of Kia Smithtown and is available for inspection.

I was driving only going around 35 miles and the car went from no check engine light to flashing check engine light I had it taken to a show and was told the rod bears where grinding away and putting metal in the oil which is what the 2017-2019 model of the engines had the same problem

Catastrophic fire started in fast food restaurant drive through, but able to drive to the parking lot before it became engulfed in flames.

I am filing a complaint regarding a 2021 Kia Sportage that experienced catastrophic engine failure, leaving the vehicle non-drivable despite regular maintenance and documented oil changes. I brought the vehicle to an authorized Kia dealership, located at 402 NJ-35, Keyport, NJ 07735, for evaluation. On or about March 17, 2026, I was informed by the dealership that coverage for engine replacement had been denied. At that time, I was not provided with a clear or sufficient explanation for the denial. Due to the lack of explanation and assistance, I escalated the matter to Kia corporate and was assigned a case manager. On March 30, 2026, I was contacted by my assigned case worker from Kia corporate, Marcia, who confirmed that my request for engine replacement remained denied. Again, no specific or sufficient explanation for the denial was provided, despite my attempts to obtain clarification. I made multiple efforts to understand the reason for the denial and to resolve the issue directly with both the dealership and Kia corporate. Despite these efforts, I was not offered a reasonable solution, nor was meaningful assistance provided. The vehicle ultimately stalled out in the middle of a highway. As a result, I am now left with a non-drivable vehicle and a significant financial burden, including an outstanding loan balance on a vehicle that cannot be used. I am also aware that there have been reported concerns, recalls, and investigations involving engine issues in certain Kia ve

The oil is mixing with the gas and their was smoke coming from the engine after that the engine has seized and the car stopped working. Also at the body shop i was told some wires were cut.

Smoke coming from the engine.

I have experienced chronic and excessive engine oil consumption in my 2021 Kia Sportage S with the 2.4 L Theta II engine. Since around 80,000 miles, I have had to add oil every 2 weeks between oil changes to prevent the engine from running low. My vehicle now requires a complete engine replacement, estimated at $10,000. Despite regular maintenance and oil changes (documented by Express Oil Change in Pinson, AL, with service records at 81,520 mi, 88,215 mi, 94,153 mi, 96,970 mi, 98,902 mi, 101,522 mi, and 105,273 mi), the vehicle continues to lose oil rapidly. Kia and my dealer have confirmed there are no recalls or warranty campaigns for my VIN, even though this issue is identical to the well-documented engine defect affecting earlier Kia models covered under the Theta II engine settlement. This defect creates a serious safety risk, as the engine can run dangerously low on oil between services, leading to engine failure or stalling while driving. I am currently out of work recovering from surgery and cannot afford the $10,000 repair. I am requesting that NHTSA investigate and expand the existing Kia engine defect recalls to include 2021 Sportage models using this engine.

My vehicle is burning oil. In a little over 1500 miles after I get a oil change from the King Kia Dealership Service, my oil stick shows that the level of oil in my engine is none at all. When I check my oil, the stick, is absolutely dry. This has happened in the last 3 oil changes with my vehicle. There is no oil indicator light that comes on in the dash, but the oil stick is dry. Additionally, there is no indication of oil leaking from my car in my drive way. I will be returning to the King Kia dealer service for the third time on 10/13/25 for remedy of this situation. I contacted Kia Customer care and reported this situation and received a case number: [XXX]. I currently have 75,943 miles on my vehicle. To prevent engine damage, I've added quarts of oil to my vehicle to compensate but I'm most concerned that this oil is prematurely burning. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Kia Sportage. The contact stated that her mother was driving at an undisclosed speed on the freeway and had stopped on the shoulder of the road to access the navigation system. The contact stated that after the driver shifted to park(P), the driver noticed smoke. The contact's grand-mother who was also occupying the vehicle advised the driver that the smoke was coming from underneath the hood. The driver then noticed that smoke and flames were coming from underneath the hood of the vehicle. The contact stated that the vehicle burned to the ground. The fire department was called to the scene and extinguished the fire. It was unknown whether a fire department report and a police report were filed. The vehicle was towed to an unknown location and was in the process of being inspected by the insurance company adjuster. Both the contact's mother and grand-mother later received medical assistance for smoke inhalation. The cause of the fire was not determined. The manufacturer and local dealer were not yet contacted. The failure mileage was approximately 70,000.