2020 Kia Sportage

Defect. Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Risk. A fire while parked or driving can increase the risk of injury.

Remedy. Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect the vehicle, and, as necessary, replace the fuse and/or tow hitch harness module, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC249.

Defect. Kia Motors America (Kia) is recalling certain 2017-2021 Sportage and Cadenza vehicles. The electrical circuit in the Hydraulic Electronic Control Unit (HECU) may short-circuit, which can cause a fire in the engine compartment.

Risk. An engine compartment fire can increase the risk of injury.

Remedy. Owners are advised to park outside and away from structures as a precaution until the recall repair is complete. Kia will notify owners, and dealers will replace certain fuses in the electrical junction box. Vehicles equipped with an electronic parking brake (EPB) will also receive a HECU software update. Repairs will be performed free of charge. The recall began on April 30, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC206.

High oil consumption burning a quart of oil every 500-600 miles.

While driving on the expressway posted speed 65 was doing 70, left lane driving, suddenly my check engine light started flashing, my oil light came on and my vehicle started slowing down. Acceleration was not an option, causing hazardous conditions to have to put my hazards on and cross two lanes of heavy traffic. Vehicle went into limp mode. Vehicle was caught up on an oil change, and was regularly checked and filled with oil. Oil seemed to have been burning rapidly or just simply disappearing. The motor blew and i purchased this vehicle less than 6 months ago. I only put 4,000 miles on it. 2020 kia sportage s, dealership was lilliston ford. Took vehicle to kia dealership to get two safety campaigns fixed. They informed me i was only a couple hundred miles over my warranty and my repairs are not covered. I now have an inoperable vehicle that i have payments on, which now needs a new engine. No recalls matching my vin, only my make, model and year. All repairs were denied. Worst vehicle decision ive ever made…

Need an engine replaced for the infamous knocking of the motor from the previous class action but my model isn’t covered. Ridiculous to need a new engine on a less than 5 year old car

My 2020 Kia sportage spontaneously caught fire. It started smoking about 1/3 mile from my destination. There were no dash lights on and the temperature gauge was not elevated and was below half so it wasn’t the engine overheating. I pulled into the parking lot and shut off the car and the smoke then increased and turned darker rapidly and the car caught fire and was quickly engulfed and then there were several explosions. The car was a complete loss. Had I taken any more time to figure out the smoke I would have been a casualty.

NHTSA Complaint Description — Kia Sportage Engine Stall While driving my 2020 Kia Sportage in mid‑June 2026 on I‑45 in Houston, TX, the vehicle suddenly stalled while I was driving, with no warning lights, messages, or symptoms beforehand. This created a dangerous situation because I was in active highway traffic and had to pull over immediately. My oil change was due on 06/02/2026, but even between 06/15–06/20, the vehicle should still have had oil. A car does not lose all oil in two weeks under normal conditions. The sudden stall and lack of oil indicate a mechanical defect, not a maintenance issue. I received a Kia notice around December 2025 or early January 2026 stating that my vehicle’s year and model could be eligible for an engine defect inspection. The letter explained that even if my VIN does not show up in their system, the model/year is still included. My vehicle is showing the same symptoms described in the defect notice, including unexpected stalling and oil loss. The problem has not yet been inspected or confirmed by the dealer, but the incident clearly shows a serious safety risk. My vehicle is available for inspection upon request.

COMPONENTS FAILED & EVIDENCE: 4 dry-rotted Kumho Crugen Premium tires, size 225/60R17, DOT 272A YANH 1319. Replaced due to hazard. High-definition photo proof of the severe dry rot defects, deep tread cracking, and the 2019 date stamps discovered upon removal is fully preserved and available.SAFETY RISK & CONCEALMENT: Operating on 7-year-old structurally compromised rubber posed a severe blowout liability on the highway. At delivery, 3 of the 4 tires were mounted inside-out. This reversed mounting placed the worst dry rot cracking and the 4-digit date code (1319, meaning March 2019 manufacture) on the inner undercarriage, actively obscuring a critical safety defect and the expiration date from a standard consumer visual inspection.NEGLIGENT INSPECTION HISTORY: The dealer had physical possession of this vehicle twice: first for pre-sale certification, and second for post-sale service. Prior to the second release, the consumer explicitly texted instructions to ensure the vehicle was completely safe with no issues. The service bay subsequently texted back confirming they performed a "once over" and verified "no issues." The dealer twice failed its duty of care, ignored a critical hazard, and falsely certified road-readiness. Corporate legal has been notified and is stonewalling.DISCOVERY & SEVERE SYMPTOMS: Failure was discovered only after a nail punctured the rear passenger tire, prompting a close inspection of all four wheels. Two weeks prior, all 4 tires simultaneously droppe

I bought vehicle used from a Honda dealership at 51,000 miles. At 55,000 my engine broke, mechanics found metal fragments in my engine. The Honda dealer nor Kia were willing to do nothing. So I had purchase new engine at 12,000.

Engine died. Complete failure with 50,000.

Odometer Fraud. The contact purchased a 2020 Kia Sportage. It was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of the purchase, the mileage was 25,881, and while trying to trade the vehicle with another dealer, it was discovered through the Carfax report that the odometer was rolled back 4,000 miles at the time of the sale. The corrected mileage was 29,881.

The contact owns a 2020 Kia Sportage. The contact stated that while driving at an undisclosed speed, the low oil warning light illuminated. The vehicle was taken to the dealer, where the contact was advised that it was normal for the vehicle to use a quart of oil every 1,000 miles. The contact was advised to bring the vehicle to the dealer every 1,000 miles. The failure became a persistent failure. The failure reoccurred. The contact stated that while driving at an undisclosed speed, there was black smoke coming from the exhaust pipes and the engine seized. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 73,000. The VIN was unavailable.

While driving, the vehicle suddenly lost power and stalled. I was able to safely pull to the side of the road. The engine would not restart. Upon inspection, the engine was found to be completely out of oil despite being maintained according to recommended oil change intervals and not being overdue for service. There were no visible oil leaks under the vehicle and no prior low oil warning light or oil pressure warning light was observed before the failure. The vehicle had previously been serviced by a Kia dealership for turbocharger-related concerns, including turbocharger boost control and wastegate actuator issues. The dealership later diagnosed the vehicle with a burnt valve in cylinder #1 and recommended complete engine replacement. I am concerned because this vehicle experienced excessive oil consumption without sufficient warning to prevent engine failure. The vehicle stalled while being driven, creating a potential safety hazard due to sudden loss of power in traffic. The vehicle is available for inspection. The failure has been confirmed by a Kia dealership service department.

The car shook and lights came on at a stop light and began violently knocking. Since it was at a stop light the safety was a risk had the hazard lights weren't engaged immediately. The dealer confirmed it was a catastrophic engine failure. An inspector for the warranty company was deployed two times. The lights only appeared at the time of engine failure.

In October of 2025 my husband noticed that our car was idling roughly and checked that there was plenty of oil in the system. The dipstick was pretty much empty so my husband added approximately 3 quarts of oil to bring it up to a little over half. After a thousand miles he checked to make sure it was still holding stead just in case. When he did so the dip stick again showed nearly empty. On approximately October 13, 2025 we took our vehicle into the local Kia Service center and they informed us that we would have to do an oil consumption test. The results of this test were that we were losing 2 quarts of oil per 1000 miles. We asked what could be done to remedy the situation and were told we would have to pay $900 for a chemical treatment that "might fix the problem". They said if the $900 cleaning did not work we would have to pay to have the engine repaired/replaced which we simply can't afford. Upon doing some research online we found that this was a problem that a lot of people had not just with our product year but that previous cars of the same make and model had a class action lawsuit due to similar issues. We drive 85 miles per day 5 days a week and feel that this is a major safety hazard. We also have a [XXX] daughter who would potentially be impacted if something happened while driving on the interstate. This is our only vehicle and is essential to our jobs as I work as a rehab director and occupational therapy assistant in a memory care facility and my husband is

1. What component or system failed or malfunctioned, and is it available for inspection upon request? The engine is experiencing excessive oil consumption. The vehicle rapidly burns through engine oil between oil changes without visible external leaks. The condition appears related to the engine lubrication and internal engine components. The vehicle is available for inspection upon request. 2. How was your safety or the safety of others put at risk? The excessive oil consumption creates a risk of sudden engine failure, engine seizure, loss of power while driving, or vehicle stalling in traffic. This creates a serious safety concern because the vehicle could lose acceleration or stop unexpectedly while driving at highway speeds or in traffic conditions, increasing the risk of an accident or injury. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? The excessive oil consumption has been consistently reproduced during normal driving conditions. The vehicle requires frequent oil top-offs between oil changes. The issue has been discussed with a dealership/repair facility, and the symptoms are consistent with widespread Kia engine oil consumption complaints. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle will be inspected by a Kia dealership or repair facility regarding the excessive oil consumption issue. No police or insurance inspection has occurred related to

I respectfully request that NHTSA review this issue for potential safety related defect trends involving excessive oil consumption that progress to catastrophic engine failure in 2020 Kia Sportages equipped with the 2.4L engine. The vehicle consumed oil at an abnormal rate between oil changes despite routine maintenance and regular oil level checks, and the condition ultimately resulted in a non-operational vehicle. Over the months leading up to the failure, I was forced to add oil at least monthly and began checking the oil level more frequently due to the rate of loss. I maintain my vehicle carefully and have consistently kept up with oil changes. In March 2026, the vehicle broke down after I experienced a sudden loss of power and stalling, and the engine ultimately failed and left the vehicle non-operational. When an engine consumes oil rapidly and then stalls or loses power unexpectedly, drivers can face an increased risk of a crash particularly if the failure occurs at highway speeds or in traffic. I have found numerous similar complaints posted online by other Kia owners describing the same pattern of excessive oil consumption followed by sudden loss of power, stalling, and/or engine failure. While I understand online posts are not formal findings, the volume and consistency of these reports suggest a broader trend that warrants NHTSA review for potential defects and safety impacts. After the failure, I had the vehicle towed to Kia of [XXX] . The service department advi

Vehicle: 2020 Kia Sportage Issue: Excessive Oil Consumption — TSB #TSB_ENG222 I am reporting a recurring issue involving excessive engine oil consumption in my 2020 Kia Sportage. The engine is consuming oil at an abnormal rate between scheduled oil changes, requiring me to add approximately 2.5 quarts of oil every month to maintain safe operating levels. This issue first began approximately 6 months ago and has been ongoing since. The affected component is the engine system, specifically related to abnormal oil consumption. The vehicle is available for inspection upon request. This issue poses a serious safety risk to me and my children. If the oil level drops too low, it can lead to sudden engine failure, loss of power while driving, or engine seizure. This creates a dangerous situation, especially when driving at highway speeds or in traffic, increasing the risk of an accident. The problem has been consistent and reproducible. It has been confirmed by an independent service center, which verified that the vehicle is consuming oil excessively beyond normal operating standards. I have brought attention to this issue through service evaluations, but no permanent repair has been provided to resolve the root cause. Prior to the issue, there were no clear warning signs. In some instances, the oil warning light only illuminates after oil levels have already dropped to a critically low level, limiting my ability to prevent potential engine damage or failure. This ongoing defect rai

The contact owns a 2020 Kia Sportage. The contact stated that upon starting the vehicle, the engine made an abnormal knocking sound. The vehicle was taken to the dealer, where it was diagnosed with a cylinder #4 misfire, a knock sensor, and bearing clearance measurement failure. The dealer informed the contact that the vehicle was not covered under warranty because the warranty was on the vehicle with the previous owner. The dealer contacted the manufacturer and was advised that the repair could not be covered under warranty because the failure was considered the consumer’s negligence. The vehicle was not repaired. The failure mileage was approximately 82,000.

Consumes more than 1 liter of oil per 1000 miles

Odometer Fraud. The contact purchased a 2020 Kia Sportage. The contact discovered a mileage discrepancy after the purchase. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 70,000. It was later discovered that the mileage on the Title was 107,000 while having a routine oil change. The service records indicated that the mileage had been altered.

Car was driving, stopped at a stoplight, never moved again. 3 lights came on, Check Engine, Check Oil (Which had been serviced previously by a month and a half), and Check Battery. Bob Sight Kia has stated Engine issues associated with the rods failing and the starter not functioning due the the manifold, I am uncertain to the technical terms. It was late at night, the area only semi lit up and I had to wait for a tow in unsafe conditions as I was stuck in a turn lane. Prior to the failure, no issues. This is my only means of transport as a waitress, I had recently moved into this area and plan to move again at the end of year, so my car is much needed. From the theft issues of this car to the mechanical issues over the last year, I can honestly say I will not be buying a Kia again. What I need to know now is has the threshold been met by the standards you have set through complaints by consumers like myself and the manufacturer information that a recall or a means of financially assisting this situation exist yet? The repairs quoted are literally almost half of what I owe on the car left and I do not know what to do, but am hoping to hear from you.