2016 Kia Soul EV

Defect. Kia America, Inc. (KIA) is recalling certain 2015-2019 Soul EV vehicles. The parking mechanism may be damaged, which can result in unintended vehicle movement when the gear shift lever is in the Park 'P' position and the parking brake is not applied while the vehicle is powered on.

Risk. Unintended vehicle movement can increase the risk of a crash.

Remedy. Dealers will update the electronic control unit software, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC287. This recall expands and replaces recall number 20V-389. Vehicles previously repaired under 20V-389 will need to have the new remedy completed.

Defect. Kia America, Inc. (Kia) is recalling certain 2015-2019 Soul EV vehicles equipped with an E400 battery. The high-voltage battery pack may experience an electrical short-circuit while driving.

Risk. A battery electrical short-circuit increases the risk of a fire.

Remedy. Dealers will update and/or replace the battery management system and software, as necessary, free of charge. The new software will illuminate the EV warning light, limit charging capacity, and reduce vehicle power if abnormal voltage is detected. If this occurs, the battery will be replaced, free of charge. Owner notification letters were mailed August 18, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC267.

Defect. Kia Motors America (Kia) is recalling certain 2015-2016 Kia Soul Electric Vehicle (EV) vehicles. The parking mechanism may become damaged if the driver moves the gear shift lever into Park 'P' before the vehicle comes to a complete stop. If the parking mechanism is damaged, unintended vehicle movement may occur when the gear shift lever is in the Park 'P' position and the parking brake is not applied.

Risk. Unintended vehicle movement can increase the risk of a crash.

Remedy. Kia will notify owners, and dealers will update the electronic control unit software, free of charge. The recall began August 7, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC191.

Defect. Kia Motors America (Kia) is recalling certain 2014-2016 Soul and Soul EV vehicles. The pinion plug may allow the pinion gear to separate from the steering gear assembly.

Risk. If the pinion gear separates, steering will be lost, increasing the risk of a crash.

Remedy. Kia will notify owners, and dealers will inspect and secure the pinion plug or replace the steering gear assembly, as necessary, free of charge. The recall began November 16, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC155. Note: This recall supersedes campaigns 14V-332 and 15V-736. Vehicles previously remedied under those numbers are being recalled again under this campaign.

The contact owns a 2016 Kia Soul EV. The contact stated that on several occasions while the vehicle was on the charging port, the vehicle failed to hold the charge and only displayed an 83 percent charge. Additionally, the contact stated that when the vehicle was fully charged, the energy percentage display rejected and while driving after a full charge, the percentage displayed at 70 percent after driving approximately 25 MPH. An unknown warning light was intermittently illuminated. The contact then stated that while driving at undisclosed speed, there was a burning odor throughout the vehicle. The contact was concerned for his safety while operating the vehicle. The vehicle was taken to the dealer however, the appointment was rescheduled for diagnostic test on October 18, 2023. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 129,000.

AUTOMATIC TRANSMISSION WAS PLACED INTO PARK AFTER DRIVING. THE CAR INDICATED IT WAS IN PARK, HOWEVER THE CAR ROLLED - IT WAS NOT IN PARK. APPLYING THE FOOT BRAKE WORKED. APPLYING THE PARKING BRAKE WORKED, HOWEVER THE GEARSHIFT DID NOT ENGAGE PARK PROPERLY.

THE HORN AND ALARM DONT WORK EVEN WHEN I SET THE ALARM THERES NO BEEP JUST FLASHES AND IVE PRESS THE HORN MULTIPLE TIMES AND IT DOESN'T MAKE A SOUND THIS OCCUR DURING DRIVING AND AFTER WHILE I WAS STATIONARY JUST TO CHECK

BACKED UP DRIVEWAY TO PARK CAR IN GARAGE. PUT CAR IN "PARK". GOT OUT TO CLEAR PARKING SPACE IN GARAGE. TURNED AROUND TO SEE CAR ROLLING DOWN DRIVEWAY INTO WALL- WHILE IN "PARK".

SUNROOF COLLAPSED WHILE DRIVING TO SCHOOL IN THE MORNING WITHOUT ANY SIGNIFICANT CHANGE OF TEMPERATURE.

AFTER PUTTING THE CAR IN PARK AND TURNING IT OFF, THE CAR STARTED ROLLING. I STOPPED THE CAR, TURN IT ON, PUT IT IN DRIVE, THEN TURNED IT BACK OFF. IT ROLLED AGAIN (IN A RELATIVELY FLAT PARKING STRUCTURE.) I NORMALLY SET THE PARKING BREAK SO I'M NOT SURE WHEN THIS MAY HAVE STARTED.

CHARGING PORT CAN AUTOMATICALLY LOCK THE CHARGING CONNECTOR, MAKING IT IMPOSSIBLE TO REMOVE WITHOUT DAMAGE OCCURRING, IF NOT DONE CORRECTLY. OF COURSE, THIS ONLY OCCURS WITH THE VEHICLE STATIONARY AT A CHARGING STATION. (I UNDERSTAND THIS IS NOT UNUSUAL ON ELECTRIC CARS BECAUSE IT IS SUPPOSED TO KEEP PEOPLE FROM REMOVING IT WHILE THE CAR IS CHARGING SO THEY CAN CHARGE THEIR CAR.) I HAVE OWNED THE CAR FOR ONE MONTH AND IT HAS HAPPENED TWO TIMES. BOTH TIMES, "ONE" OF THE MANY THINGS I TRIED UNLOCKED IT BUT I'M NOT EXACTLY SURE WHAT RESOLVED IT. I HAVE BEEN UNABLE TO LOCATE ANYTHING IN THE OWNER'S MANUAL TELLING ABOUT THE POSSIBILITY OF LOCKING THE CHARGING PORT AND ONLINE SEARCH HAS ONLY RESULTED IN OTHERS SAYING THEY HAVE EXPERIENCED THE SAME PROBLEM BUT NOTHING FROM KIA MOTOR COMPANY ABOUT WHAT RESOLVES THE ISSUE...NISSAN LEAF OWNER'S MANUAL CLEARLY TELLS HOW TO LOCK AND UNLOCK THE CHARGING PORT BUT I FIND NOTHING MENTIONED ABOUT IT IN MY KIA MANUAL...ROADSIDE ASSISTANCE ONLY SENDS A TOW TRUCK DRIVER APPROXIMATELY AN HOUR AFTER THE CALL IS MADE AND THE DRIVER KNOWS LESS ABOUT THE CAR THAN THE OWNER. I BELIEVE THERE IS THE POSSIBILITY THIS COULD BE A SERIOUS PROBLEM, IN AN EMERGENCY OR NOT, WHETHER IT RESULTS IN INJURY TO THE PERSON OR DAMAGE TO THE VEHICLE.